日粮添加干玉米酒糟对泌乳奶牛干物质采食量、泌乳性能和瘤胃发酵的影响

文章旨在研究日粮中添加不同比例的干玉米酒糟对泌乳奶牛干物质采食量、泌乳性能和瘤胃发酵的影响。试验选择45头健康的中国荷斯坦奶牛,按照胎次、泌乳天数和产奶量进行区组设计,随机分配到3个处理组中,每组15头牛。对照组奶牛饲喂以玉米和豆粕为基础的日粮,不含有干玉米酒糟,试验1组和试验2组奶牛饲喂的日粮均以干玉米酒糟替代部分玉米和豆粕,替代比例分别为10%和20%(干物质基础)。预试期为2周,正试期为10周。试验结果表明,日粮添加干玉米酒糟显著提高了泌乳奶牛干物质采食量(P<0.05),而不同干玉米酒糟添加比例对奶牛的干物质采食量无显著影响(P>0.05)。日粮添加干玉米酒糟显著提高了泌乳奶牛的产奶量,且呈剂量依赖效应(P<0.05)。日粮添加干玉米酒糟对乳成分无显著影响(P>0.05),但由于产奶量的增加显著增加了乳中营养成分含量(P<0.05)。日粮添加干玉米酒糟改变了瘤胃发酵模式,降低了瘤胃液乙酸摩尔比值(P<0.05),增加了丙酸和丁酸摩尔比值(P<0.05),降低了瘤胃液NH3-N浓度。因此,可以使用干玉米酒糟替代部分玉米和豆粕来配合奶牛日粮,本试验中以20%的添加量较为合适。     

乙醇生产工艺对DDGS蛋白营养价值影响的研究进展

干酒糟及其可溶物(DDGS)是乙醇生产工业中的一种副产物,常常被用作动物蛋白原料使用。由于原料来源不同,DDGS的粗蛋白质含量以及粗蛋白质和氨基酸的消化率存在差异,另外,加工工艺也会影响DDGS蛋白质质量。本文综述了乙醇生产过程影响DDGS蛋白价值的因素。加热对DDGS干燥过程中的影响报道最多。在加热过程中,氨基酸会发生一系列的化学反应,导致氨基酸消化率降低或结构破坏。DDGS蛋白质质量、颜色、酸性洗涤不溶氮及氨基酸含量都是评判加热影响DDGS质量的指标。除了干燥,另外可能影响DDGS蛋白质价值的因素是在干燥和混合步骤前的高温条件。     

Rumen fermentation,milk production and conjugated linoleic acid in the milk of cows fed high fiber diets added with dried distillers grains with solubles

The effects of corn dried distillers grains with solubles (DDGS) feeding on rumen fermentation and milk production in cows were evaluated using diets high in neutral detergent fiber (NDF, 45.9–46.6%). The control diet (Control) consisted mainly of hay, corn silage and concentrates. In the experimental diets, the concentrates were replaced with DDGS as 10% dry matter (DM) (10%DDGS) and 20% DM (20%DDGS). Eight cows were used for each 14‐day treatment period. Effect of DDGS feeding on DM intake was not significant. Ruminal volatile fatty acids and ammonia‐N at 5 h after feeding of 20%DDGS were decreased compared to Control, whereas protozoal count at 2 h after feeding of 20%DDGS was higher than that of 10%DDGS. Milk yield of cows fed DDGS diets was greater than that of Control, although percentages of milk protein and solids‐not‐fat were decreased by DDGS diets. The proportions of C10:0, C12:0, C14:0 and C16:0 in the milk fat decreased, and those of C18:0, C18:1, C18:2 and cis‐9, trans‐11 conjugated linoleic acid (CLA) increased markedly with elevated DDGS. Increase in trans‐11 C18:1 was observed in the rumen fluid at 5 h after feeding. These findings suggest that DDGS feeding enhanced milk yield, as well as CLA synthesis under a high dietary NDF condition.     

Effects of distillers dried grains with solubles and mineral sources on gaseous emissions

Distillers dried grains with solubles (DDGS), an important ethanol industry co-product, has been used as a high-protein feed in poultry production. Limited studies exist on their effect on air emissions, however. In the current study, 4 diets (2 × 2 factorial design: 0 or 20% DDGS + inorganic or organic mineral sources) were fed to Hy-line W36 hens from 50 to 53 wk of age and the effects of DDGS level and mineral sources on air emissions were monitored continuously for a 23-d period in environmentally controlled chambers. The NH₃, H₂ S, CH₄, nonmethane hydrocarbons, N₂ O, CO₂, and CO₂-equivalent emissions ranged from 0.51 to 0.64 g/day-hen, 0.71 to 0.84 mg/day-hen, 33.9 to 46.0 mg/day-hen, 54.1 to 60.0 mg/day-hen, 66.0 g to 72.2 g/day-hen, and 83.1 to 92.1 g/day-hen, respectively. Feeding DDGS to laying hens resulted in 14% decreased NH₃ emissions but a 19% increase in CH₄ emissions without affecting other gaseous emissions. More than 30% of N, 80% of P, 80% of K, and 50% of Ca was retained in the manure. In conclusion, feeding laying hens a diet containing 20% DDGS may be beneficial for the environment. Substitution for organic trace minerals did not affect hen performance or air emissions.     

Efficacy of feed enzymes in pig and poultry diets containing distillers dried grains with solubles: a review

Distiller's dried grains with solubles (DDGS), a coproduct of the ethanol industry, are often used as feed material in livestock and poultry nutrition. Results of many experiments have indicated, however, that a high dietary level of DDGS can negatively affect the digestibility of nutrients and the performance of monogastric animals due to their high content of non‐starch polysaccharides (NSP). Nevertheless, using high levels of DDGS as a protein source in livestock diets can be still economically justifiable in view of the rising prices of soya bean meal and other protein sources. The aim of some recent experiments with poultry and pigs was to improve the nutritional efficacy of high‐NSP diets through the addition of feed enzymes. As presented and discussed in this review article, the efficacy of feed enzymes added to poultry and pig diets containing DDGS is not consistent and depends on many factors. However, NSP‐hydrolysing enzymes generally seemed to be more efficient than phytases in terms of the digestibility of nutrients and the growth performance of poultry and pigs fed high‐DDGS diets. For this reason, supplementation with NSP‐hydrolysing enzymes could be an efficient way to enable the use of increased levels of DDGS in poultry and pig diets.     

Amino acid digestibility in low-fat distillers dried grains with solubles fed to growing pigs

The objective of this experiment was to determine the standardized ileal digestibility (SID) of amino acids (AA) in 3 sources of distillers dried grains with solubles (DDGS) with different concentrations of fat. Twelve growing barrows (initial body weight: 76.1 ± 6.2 kg) were randomly allotted to a replicated 6 × 4 Youden square design with 6 diets and 4 periods. The fat content of the 3 sources of DDGS were 11.5, 7.5, and 6.9% respectively. Diets contained 60% DDGS and fat concentration of the diets were 7.5, 5.2, and 5.2%, respectively. Two additional diets containing the 2 sources of DDGS with 7.5 and 6.9% fat were also formulated, and corn oil was added to these diets to increase the concentration of fat in the diets to levels that were calculated to be similar to the diet containing conventional DDGS with 11.5% fat. A N-free diet was also formulated to calculate endogenous losses of crude protein (CP) and AA from the pigs. Pigs were fed experimental diets during four 7-d periods. The first 5 d of each period were an adaptation period and ileal digesta were collected on d 6 and 7 of each period. The apparent ileal digestibililty (AID) and SID of CP and all indispensable AA, except AID Pro and SID of Trp, were greater (P < 0.01) in conventional DDGS than in the 2 sources of DDGS with reduced fat. Adding oil to the diets containing the 2 sources of DDGS with reduced fat did not consistently increase SID of AA. In conclusion, conventional DDGS has greater SID values for most AA compared with DDGS that contains less fat and inclusion of additional oil to diets containing low-fat DDGS does not increase AID or SID of AA. The lower AA digestibility in low-fat DDGS could not be overcome by the inclusion of additional fat to the diets.     

Amino acid digestibility of heat damaged distillers dried grains with solubles fed to pigs

The primary objective of this experiment was to determine the effects of heat treatment on the standardized ileal digestibility (SID) of amino acids (AA) in corn distillers dried grains with solubles (DDGS) fed to growing pigs. The second objective was to develop regression equations that may be used to predict the concentration of SID AA in corn DDGS. A source of corn DDGS was divided into 4 batches that were either not autoclaved or autoclaved at 130°C for 10, 20, or 30 min. Four diets containing DDGS from each of the 4 batches were formulated with DDGS being the only source of AA and CP in the diets. A N-free diet also was formulated and used to determine the basal endogenous losses of CP and AA. Ten growing pigs (initial BW: 53.5 ± 3.9 kg) were surgically equipped with a T-cannula in the distal ileum and allotted to a replicated 5 × 4 Youden square design with 5 diets and 4 periods in each square. The SID of CP decreased linearly (P < 0.05) from 77.9% in non-autoclaved DDGS to 72.1, 66.1, and 68.5% in the DDGS samples that were autoclaved for 10, 20, or 30 min, respectively. The SID of lysine was quadratically reduced (P < 0.05) from 66.8% in the non-autoclaved DDGS to 54.9, 55.3, and 51.9% in the DDGS autoclaved for 10, 20, or 30 min, respectively. The concentrations of SID Arginine, Histidine, Leucine, Lysine, Methionine, Phenylalanine, or Threonine may be best predicted by equations that include the concentration of acid detergent insoluble N in the model (r² = 0.76, 0.68, 0.67, 0.84, 0.76, 0.73, or 0.54, respectively). The concentrations of SID Isoleucine and Valine were predicted (r² = 0.58 and 0.54, respectively) by the Lysine:CP ratio, whereas the concentration of SID Tryptophan was predicted (r² = 0.70) by the analyzed concentration of Tryptophan in DDGS. In conclusion, the SID of AA is decreased as a result of heat damage and the concentration of SID AA in heat-damaged DDGS may be predicted by regression equations developed in this experiment.     

Amino acid digestibility of heat damaged distillers dried grains with solubles fed to pigs

The primary objective of this experiment was to determine the effects of heat treatment on the standardized ileal digestibility(SID) of amino acids(AA) in corn distillers dried grains with solubles(DDGS) fed to growing pigs. The second objective was to develop regression equations that may be used to predict the concentration of SID AA in corn DDGS. A source of corn DDGS was divided into 4 batches that were either not autoclaved or autoclaved at130°C for 10, 20, or 30 min. Four diets containing DDGS from each of the 4 batches were formulated with DDGS being the only source of AA and CP in the diets. A N-free diet also was formulated and used to determine the basal endogenous losses of CP and AA. Ten growing pigs(initial BW: 53.5 ± 3.9 kg) were surgically equipped with a T-cannula in the distal ileum and allotted to a replicated 5 × 4 Youden square design with 5 diets and 4 periods in each square. The SID of CP decreased linearly(P 0.05) from 77.9% in non-autoclaved DDGS to 72.1, 66.1, and 68.5% in the DDGS samples that were autoclaved for 10, 20, or 30 min, respectively. The SID of lysine was quadratically reduced(P 0.05) from 66.8% in the non-autoclaved DDGS to 54.9, 55.3, and 51.9% in the DDGS autoclaved for 10, 20, or30 min, respectively. The concentrations of SID Arginine, Histidine, Leucine, Lysine, Methionine, Phenylalanine, or Threonine may be best predicted by equations that include the concentration of acid detergent insoluble N in the model(r2= 0.76, 0.68, 0.67, 0.84, 0.76, 0.73, or 0.54, respectively). The concentrations of SID Isoleucine and Valine were predicted(r2= 0.58 and 0.54, respectively) by the Lysine:CP ratio, whereas the concentration of SID Tryptophan was predicted(r2= 0.70) by the analyzed concentration of Tryptophan in DDGS. In conclusion, the SID of AA is decreased as a result of heat damage and the concentration of SID AA in heat-damaged DDGS may be predicted by regression equations developed in this experiment.     

精料干酒糟及其可溶物水平对奶牛产奶性能及氮排泄的影响

本试验旨在研究精料中不同干酒糟及其可溶物(DDGS)水平对奶牛产奶性能及氮排泄的影响。选择30头体重、胎次、产奶量、乳成分和泌乳天数[(115±14)d]相近的健康中国荷斯坦牛,随机分为5个组,对照组精料不添加DDGS,试验Ⅰ组、Ⅱ组、Ⅲ组和Ⅳ组分别以10.0%、17.5%、25.0%和32.5%的DDGS等比例替代精料中花生粕、棉籽粕、豆粕和玉米。预试期15 d,正试期60 d。结果表明:1)干物质采食量,试验Ⅰ组、Ⅱ组、Ⅲ组及对照组显著高于试验Ⅳ组(P<0.05),而这4个组间无显著差异(P>0.05);粗蛋白质采食量,4个试验组间无显著差异(P>0.05),试验Ⅰ组、Ⅱ组与对照组之间无显著差异(P>0.05),而试验Ⅲ组和Ⅳ组显著低于对照组(P<0.05)。2)日均产奶量,对照组和试验Ⅰ组、Ⅱ组、Ⅲ组整个正试期的平均值均显著高于试验Ⅳ组(P<0.05),分别比试验Ⅳ组高6.17%、8.27%、9.06%和9.59%,对照组和试验Ⅰ组、Ⅱ组、Ⅲ组间则无显著差异(P>0.05)。3)对照组和4个试验组间各乳成分含量均无显著差异(P>0.05)。4)4个试验组总氮排泄量整个正试期的平均值分别比对照组下降4.19%、9.36%、12.08%和18.02%,各组间均存在显著或极显著的差异(P<0.05或P<0.01)。综合考虑奶牛产奶性能和氮排泄,在本试验条件下,奶牛精料中适宜的DDGS水平为25.0%。     

Corn protein has greater concentrations of digestible amino acids and energy than low-oil corn distillers dried grains with solubles when fed to pigs but does not affect the growth performance of weanling pigs

Three experiments were conducted to test the hypothesis that standardized ileal digestibility (SID) of amino acids (AA) and digestible energy (DE) and metabolizable energy (ME) in a new source of corn protein are greater than in corn distillers dried grains with solubles (DDGS) and that corn protein may be included in diets for weanling pigs. In experiment 1, the SID of AA was determined in two sources of DDGS (DDGS-1 and DDGS-2) and in corn protein. Results indicated that SID of most AA was greater (P < 0.05) in DDGS-2 and corn protein than in DDGS-1, but corn protein contained more digestible AA than both sources of DDGS. In experiment 2, the DE and ME in corn, the two sources of DDGS, and corn protein were determined. Results demonstrated that DE (dry matter basis) in corn protein was greater (P < 0.05) than in corn, but ME (dry matter basis) was not different between corn and corn protein. However, DE and ME in corn (dry matter basis) were greater (P < 0.05) than in DDGS-1 and DDGS-2. In experiment 3, 160 weanling pigs were allotted to four treatments in phases 1 and 2 and a common diet in phase 3. Corn protein was included at 5% to 10% in phases 1 and 2 at the expense of plasma protein and enzyme-treated soybean meal. Results indicated that although differences in average daily gain and gain to feed ratio were observed in phase 1, no differences among treatments were observed for the overall experimental period. In conclusion, the concentration of digestible AA is greater in corn protein than in DDGS; DE and ME in corn protein are also greater than in DDGS; and up to 10% corn protein may be included in phase 1 and phase 2 diets for weanling pigs.