Planting materials for warm tropic potato production: growth and yield of transplanted seedlings or rooted cuttings and tuber materials in the field

Expansion of potato production in lowland tropical regions has been constrained by the lack of planting materials, given that adapted genotypes and suitable field management practices now exist.

The respective performance of transplanted materials (i.e., true potato seed (TPS) seedlings or rooted stem cuttings) produced in situ in the warm tropics were compared with that of genetically identical seedling tubers (tubers produced from seedlings) or seed tubers. Seed and seedling tubers had been previously produced under optimal cool conditions. Transplanted materials achieved lower maximum leaf area index than did tuber materials (1.3–2.2 vs. 2.7) but relative growth rates of cuttings and seedlings were greater. This was in part due to the greater net assimilation rate of cuttings and to greater leaf:stem ratio for both compared with plants originating from tubers. Stolon and tuber formation were greater in seed tubers than in cuttings and in seedlings versus seedling tubers. On average, seedlings produced 14 tubers per plant, apical cuttings 12, seedling tubers 8, and stem cuttings 6.

Tuber yields within a genotype were statistically similar for crops from seed tubers or cuttings and for crops from seedling tubers or seedlings. However, the proportion of marketable (i.e., > 3.5 cm diameter) tubers was approximately 12% less in the crops from seed tuber and seedlings compared with those from cuttings and seedling tubers, respectively. Within a genotype, the crop duration in the field was similar whatever the type of planting material. Maximum yields, at 23 t/ha in warm sites, were still below those of temperate potato crops, but could be achieved equally well with transplanted in situ-produced materials or imported cool-climate seed tubers.     

Potato (Solanum spp.) production using apical cuttings and tuberlets under three contrasting environments of Vietnam

Potato production from rooted apical cuttings or from small tubers (l–20g) produced in high density beds has great potential in Asia. This is particularly important in non-traditional warmer environments. This research was conducted to assess the feasibility of producing many small tubers in high density beds. A second objective compared tubers from beds with transplanted rooted cuttings and traditional seed tubers for growth and yield in the field. Tuberlet production in beds exceeded 2000/m² with a density of 1000 plants/m² under optimal growing conditions while under high temperatures only about 1.25 tuberlets/plant were produced. In field experiments, transplanted cuttings yielded 20 t/ha in the mid and high elevation areas, only slightly less than tuberlets of 5–10g while at the hot site, yields were generally only 8 to 10 t/ha for both materials. Larger healthy seed tubers produced significantly higher yields at the low and high elevation sites. Tuberlets of 1–5g were also able to give yields of 20 t/ha in the mid-elevation site. These results indicate that cuttings and small tuberlets are two ways of growing potatoes which need to be further evaluated for socioeconomic assessment by farmers.     

Comparative performance of three small seed tuber sizes and standard size seed tubers planted at similar stem densities

Summary Small seed tubers of 1–5 g, 5–10 g and 10–20 g were planted at the same sprout densities as standard size seed tubers of 40–60 g in order to give similar stem densities. Early ground cover by foliage, total yield, and yield of tubers >45 mm were consistently greater in plots planted with larger seed tubers. The effect of seed tuber size on yield and tuber number per stem varied between years but 1–5 g seed tubers always gave lower yields per stem than larger seed tubers. Reducing the spacing between rows from 90 cm to 60 cm and maintaining the same sprout density was more effective in increasing yields from small seed tubers than increasing sprout density from 20 to 40 sprouts per m² by reducing plant spacing within the row.     

Greenhouse production of potato (Solanum tuberosum L. cv. Désirée) seed tubers using in vitro plantlets and rooted cuttings in large propagation beds

Summary Seed tuber production fromin vitro potato plantlets and cuttings was conducted in large propagation beds in a greenhouse. Propagules of wholein vitro plantlets (WIP), plantlets with apical (ACR) and lateral (LCR) cuttings removed, the rooted apical cuttings (RAC) and rooted lateral cuttings (RLC) were planted at three densities of 25, 49 and 100 plants per m². The plantlets from which cuttings were removed (ACR and LCR) produced more tubers than the rooted cuttings (RAC and RLC); however, the most tubers were produced by WIP. RAC produced highest tuber yields followed by WIP and RLC. Intact WIP and plantlets with cuttings removed (ACR and LCR) produced twice as many tubers <40 g as those from rooted cuttings (RAC and RLC). The yield (kg/m²) as well as the number of tubers per m² increased with the increasing planting density within the densities tested.     

Effect of gibberellic acid and multiple harvests on production and reproductive value of seed potatoes produced above ground on stem cuttings

Summary Potato plants of cvs Eersteling and Bintje were grown from stem cuttings and induced to form aerial tubers for use as seed. Spraying the plants with gibberellic acid in concentrations of 10, 25 and 50 mg/l to induce stolon formation in the leaf axils led to a decrease in the number of tubers formed per plant. Multiple harvesting of the largest tubers from plants treated with gibberellic acid or not, approximately doubled the number of tubers formed but halved their individual weight compared with only one harvest at plant senescence. After a storage period of about 1 year, with their vigour declining, the aerial tubers were planted in the field. Aerial seed tubers taken from multiple harvests during the previous year produced the same number of tubers as plants grown from above-ground tubers harvested at plant senescence only, but the tuber yields declined with earlier harvesting when small (5–13 mm) aerial tubers were used, compared to larger (14–19 mm) tubers.     

The effects of (S)-(+)-carvone treatments on seed potato tuber dormancy and sprouting

Summary Potato seed tubers may suffer from premature sprouting during storage, thus limiting their suitability for cultivation. Commonly used sprout suppressant treatments negatively affect but viability and therefore a reliable method to inhibit bud development must still be found for seed tubers. The monoterpene carvone ((S)-(+)-carvone) was tested in small scale experiments. The vapour of this compound fully inhibited bud growth of tubers cv. Monalisa stored at 23°C without affecting bud viability throughout 6 months of treatment. The most effective range of carvone vapour concentrations was between 0.34 and 1.06 μmol mol⁻¹. With these qualities we can expect carvone to become a suitable sprout suppressant for seed tubers.     

Effect of second growth on the quality of tubers as seed in the cultivar Record

Summary Seed quality in a crop harvested in 1984 was compared in tubers which either, (a) were unsprouted prior to harvest (normal), (b) had formed secondary chain tubers prior to harvest (primary), (c) secondary chain tubers. Normal and primary tubers formed substantial sprout growth during storage, while there was little sprout growth from secondary tubers. Plants derived from these seed tuber types differed, in terms of emergence, number of emerged stems, and tuber number. It is concluded that the tuber types can be considered to vary in terms of physiological age; normal and primary tubers appear to be physiologically older than the secondary tubers. This variability in seed condition can lead to variability in the performance of the subsequent crop.     

Seed Potato Performance after Storage in Light at Elevated Temperatures

In regions with short growth seasons, it is of great importance to use potato (Solanum tuberosum L.) seed tubers with a high growth vigour and a short growth cycle. Such qualities may be obtained by treatments advancing the physiological age of the seed tubers. In this study, we have exposed tubers from four cultivars to various combinations of temperature and light conditions (green-sprouting) for 3–7 months in controlled climate. Subsequent sprout quality, seed tuber health and performance were studied in laboratory, greenhouse and field trials. Satisfactory short, sturdy and leafy sprouts were produced even after 7 months storage at 15 °C under light exposure. An assay of black scurf (Rhizoctonia solani) on the tuber skin showed that light exposure significantly reduced the occurrence compared with dark-stored tubers, while the average effect of storage temperatures was insignificant. In general, green-sprouting advanced emergence and plant growth by 1–2 weeks, and showed early tuber initiation and growth, compared to untreated material. Yields, 107 days after planting in the field trial, did not deviate significantly from untreated tubers. However, plant development at harvest was in accordance with general responses to physiological ageing of potato seed tubers, i.e. still tall and immature plants from untreated tubers, and short and mature plants from aged tubers. Results demonstrated the possibility of successful long-term storage of potato seed tubers in light at elevated temperatures and a potential for earlier harvests and higher early yields from such treatments.     

The quality of seed tubers multiplied in the Golan Heights for the spring season in Israel

Summary Seed tubers grown in the northern mountain region — the Golan Heights — were as productive as imported seed tubers. In cvs. Blanka and Désirée, both the locally grown and the imported seed tubers were similar when yield components and tuber fresh weight are considered. In Up-to-Date, the locally grown seeds produced higher yields of marketable tubers (over 60 g/tuber) than those imported. Désirée seed tubers grown for two generations in the Golan Heights did not differ significantly in their productivity as compared with common Golan seeds and with imported ones. Seed tubers harvested from plots which were protected by means of white coarse nets and weekly sprays with insecticides, were virtually virus-free and were used for growing commercial seeds in the Golan. The use of this method for seed multiplication is suggested. Contribution from the Agricultural Research Organization. The Volcani Center, Bet Dagan, Israel. No 137-E, 1981 Series.     

Production of above-ground seed tubers on stem cuttings from eight potato cultivars

Summary The formation of above-ground tubers on stem cuttings of eight potato cultivars was studied over three seasons. To promote tuber formation in the leaf axils, stems grown from single node cuttings were exposed to short day conditions. Tuber formation underground was reduced by covering the soil with a plastic sheet and by using single node cuttings planted with the leaf axils several centimetres above the soil surface. With all cultivars except Alpha, which produced mis-shapen tubers in all experiments, an average of 11 (maximum 40) tubers per cutting were harvested. Significant cultivar × year interactions were observed.     

Tillage and seed-sprouting strategies to improve potato yield and quality in short season climates

Management practices that accelerate crop development and allow earlier harvest would be beneficial in short-season potato (Solanum tuberosum L.) production areas. Yield and quality of the potato cultivar ‘Russet Burbank’ were evaluated in a 2-yr study in northern Maine to determine effects of soil tillage and seedsprouting treatments designed to dry soil early in the spring and hasten seed emergence. The tillage treatments, consisting of fall raised bed (RB), fall ridge till (RT), and spring chisel plow (CH), were tested in combination with green-sprouted and non-sprouted seed tubers on a Caribou gravelly loam (coarse-loamy, mixed, frigid,Typic Haplorthod). Plants from green-sprouted seed emerged earlier than from non-sprouted seed tubers (87%-96% vs 21%-37%, respectively, at 18 days after planting [DAP] in 2000; and 73%-88% vs 18%-23%, respectively, at 20 DAP in 2001). Green-sprouted seed tubers in RB yielded 4.6 to 5.9 T ha^-1 more than nonsprouted seed tubers in RB. However, non-sprouted seed tubers yielded higher than green-sprouted seed tubers in RT by 2.9 to 4.2 T ha^-1 and in CH by 1.1 to 4.1 T ha^-1. Similarly, green-sprouted seed tubers in RB and nonsprouted seed tubers in RT and CH produced higher marketable yield, greater tuber length, and greater tuber diameter than the corresponding seed-sprouting treatment. In the comparatively wetter year (2000), the use of green-sprouted seed tubers in RB significantly increased total and marketable yields, and produced longer and larger tubers than all other treatments. However, in 2001 (relatively dry year), yield and quality from green-sprouted seed tubers in RB did not differ from non-sprouted seed in RT or CH. Green-sprouted seed produced fewer sunburned and rotten tubers, but more misshapen tubers than non-sprouted seed in RB tillage. The technique of producing Russet Burbank potatoes in raised beds is a promising system in regions with short growing seasons for enhancing early soil drainage during spring and improving soil water retention during critical periods of crop growth and development.     

Effect of production temperature of seed potatoes on subsequent yielding potential

A two year experiment was conducted to test if the temperature environment under which seed potatoes are produced significantly affects the tuber development and yield of the resultant potato plants. Six temperature regimes were established in the controlled facility of the Biotron. Two generations ofSolanum tuberosum ‘Kennebec’ tubers were grown in these environments and the yielding ability of plants produced from these tubers was tested in greenhouse facilities. Plant growth and tuber yields were similar to those which might be expected under field conditions, and marked differences in the development and productivity as a result of the production environment of the seed tubers were apparent. However, no evidence was found to support the contention that seed potatoes originating from cooler environments had any increased potential to produce higher yielding plants than comparable seed from warm environments. Even within a generation, the highest yields were found in the warmest environments, somewhat modifying the concept that the potato is strictly a cool-season crop. Other possible non-pathogenic explanations for previously observed differences in seed quality as a result of the production environment are discussed.     

1,4-Dimethylnaphthalene treatment of seed potatoes affects tuber size distribution

1,4-DMN is a relatively new sprout inhibitor for use on maincrop and seed potatoes. Despite its registration as a “dormancy enhancer” for seed, relatively little is known about its effects on plant establishment and productivity. The main objective of this study was to evaluate the effects of 1,4-DMN on the productivity of seed potatoes. ‘Umatilla Russet’ (UR), ‘Ranger Russet’ (RR), and ‘Russet Burbank’ (RB) seed tubers were stored at 4, 7, and 9 C over three seasons to create 80-, 554- and 642-degree-day seed, and 1,4-DMN was applied to maintain dormancy several times during each season. 1,4-DMN residue levels at the end of storage were lower in seed aged at higher temperatures. Multiple applications of 1,4-DMN at higher-than-label rates were necessary to effectively inhibit sprouting of seed of all cultivars stored above 4 C. In field trials, depending on cultivar and year, 1,4-DMN either delayed plant emergence slightly or had no effect. 1,4-DMN increased stem numbers from RB and UR seed, but not from RR seed. 1,4-DMN reduced total tuber yields by 3.2 to 5.6 t ha^?1 (5% to 9%), and U.S. No. 1 tuber yields by 4.8 to 7.8 t ha^?1 (8% to 15%) in all cultivars, regardless of seed tuber age. 1,4-DMN also reduced the average tuber weight for all three cultivars and shifted the size distribution from larger (> 284 g) to smaller tubers. 1,4-DMN reduced the respective yields of > 397-g, 340-to 397-g, and 284-to 340-g tubers by 43%, 19%, and 18% for RR seed, 31%, 14%, and 11% for RB seed, and 40%, 47%, and 27% for UR seed. Conversely, depending on cultivar, yields of smaller tubers (≤170 g) were 11% to 38% higher from 1,4-DMN-treated seed. The shift in tuber size distribution for RR was accompanied by a 1,4-DMN-induced increase in tuber number per plant and per hectare. However, no such effects on tuber set occurred in RB and UR. Moreover, in most cases, the 1,4-DMN effects on yield and tuber size distribution were independent of seed age. Since the 1,4-DMN-induced shifts in tuber size distribution were greater than the reductions in total and U.S. No. 1 yields, 1,4-DMN may be a suitable treatment to reduce average tuber size and increase yield and uniformity of specific size classes of tubers to more closely match market requirements.     

Inter-stem and inter-tuber competition in potatoes

Summary Seed pieces of varying size and bearing different numbers of uniform growing sprouts were planted in specific combinations. Sequential harvests were made and the growth of the plants followed. There appeared to be competition between emerging sprouts for nutrients and water from the soil. This competition influenced the number of stems produced per sprout and the size attained by these stems. There was no effect of size of the seed piece on the apparent time to tuber initiation. A constant number of tubers were formed per stem despite large variations in stem size, but the final weight of tubers per stem was lower the greater the number of stems per hill. The number of tubers larger than 2| inches (5.7 cm) remained constant over the whole range of stem numbers per hill and the mean weights of tubers in the two size categories larger than 1| inches (3.2 cm) remained constant after the second harvest. These results suggest that only a few of the tubers in each hill were growing rapidly at any one time. There was no effect of cutting the seed tubers on any aspect of the growth of potatoes that was measured which could not be attributed to an effect on either the size of the seed piece or on the number of sprouts per seed piece.     

A promising method for screening drought tolerance in potato using apical cuttings

Ten diverse potato genotypes from apical cuttings were screened for drought tolerance in raised beds of 3:1 v/v volcanic soil:burnt rice hull medium. The object was to test whether this method could replace field evaluation. Growth analyses were done periodically on potatoes from apical cuttings grown in beds. Correlations were made with those from seed tubers concurrently grown in the field. Total and tuber dry matter yield of plants grown from apical cuttings in beds and from seed tubers in the field were significantly correlated (r=.80*). Drought stress sensitivity based on % reduction in tuber and total dry matter at maturity in beds was similar to the results found in the field at maturity. Consistency of the method necessitates the standardization of the age, quality and source of apical cuttings and the growing conditions particularly drought stress imposition.     

Tubers from leaf-bud cuttings: A tool for potato seed certification and breeding programs

The use of leaf-bud cuttings as a tool for rapid clonal increase was studied in 6 cultivars. Small tubers were obtained directly from leaf-bud cuttings maintained for 7 weeks in sand-filled pots or benches. The tubers ranged in size up to 1 1/4 inches (3cm) in diameter. The number of leaf-bud cuttings ranged from 37 to 288, depending on size of mother plant. They averaged 114 cuttings. Almost all of the leaf-bud cuttings produced tubers. The procedure is fast, simple, and provides for rapid increase of selected stocks.     

Manipulation of microtubers for direct field utilization in seed production

A two-year field study was conducted to determine the effects of jasmonic acid (JA), light (duringin vitro explant production andin vitro tuberization phases), and dormancy-breaking treatment on performance of microtubers in the production of seed tubers (pre-elite) in five potato cultivars. Microtubers were produced under short day (8-h) conditions and in darkness, from stock plantlets pre-treated with JA and untreated, and on tuberization media with or without JA. Microtuber performance was compared to invitro plantlets transplanted directly to the field. Yields of tubers from microtubers were 30% to 40% of those from plantlets. Microtubers of cultivars Amisk and Russet Burbank produced the highest yields of pre-elite tubers. Atlantic microtubers performed poorly in the field. JA pre-treatment of stock plantlets, prior toin vitro tuberization, enhanced seeds tuber production from microtubers in Russet Burbank and lowered in Shepody. JA presence in media duringin vitro tuberization significantly lowered production of tubers while exposure to 8-h light resulted in microtubers performing significantly better in the field than microtubers produced in the dark. Dormancy release was the key factor influencing microtuber performance. Unlike greenhouse studies, gibberellic acid (GA₃) was more effective than Rindite. A further refinement of the production and handling methods is required before microtubers can be recommended for field production of seed tubers.     

Seed potato quality as influenced by high temperatures during the growth period. 2. Sprouting pattern in several cultivars in response to storage temperature

Summary Locally grown seed tubers of nine varieties developing in spring or in autumn in a semi-arid region were examined for length of dormancy and for sprouting response. In spring, high temperatures during the last part of tuber development markedly shortened the dormant periods of tubers in comparison with tubers of the same varieties developing in autumn. The sprouting behaviour of tubers indicated that it is a varietal characteristic influenced by the change in environmental conditions during tuber development and storage. On tubers developing in spring and stored at high temperatures, three sprouting patterns were defined: a) apical dominance, characterized by the evident development of the apical sprout and less than 10% sprouting of the non-apical buds; b) apical influence, the apical sprout well developed and 10–20% sprouting of the non-apical buds; and c) simultaneous sprouting of 3 or 4 sprouts of similar size per tuber. It is suggested that apical dominance is a relative rather than an absolute phenomenon. The extent of dominance depends upon the variety's response to the high temperatures during tuber growth and storage. Contribution from the Agricultural Research Organization, Beit Dagan, Israel, 1979 Series, No 301.     

Field performance of potato shoot-tips proliferated in culture

Summary Plants of cvs Kennebec and Pontiac were propagated in petri dishes or flasks and rooted and transplanted into the field as cuttings. Plants from eight week old cuttings gave higher final yields than those from six-week-old cuttings. The field performance of Pontiac plants propagated in petri dishes was superior to that of plants propagated in flasks. Yields from cuttings were between 30% and 97% of those of plants from tubers.     

Field performance of potato minitubers with different fresh weights and conventional seed tubers: Crop establishment and yield formation

Summary Field performance of five fresh weight classes of minitubers ranging from 0.13–0.25 g to 2.00–3.99 g and conventional seed tubers was studied in a short growing season (79 or 82 days) in two years. The heavier minitubers gave a more regular emergence, faster ground cover soon after emergence, higher dry-matter yields, and higher fresh tuber yields. Radiation conversion coefficient (RCC) did not differ. Higher tuber yields resulted from more radiation intercepted due to a faster ground cover, and a higher harvest index. All minitubers produced plants with one primary stem. In one experiment when heavier minitubers had long sprouts, time to 50% emergence decreased with tuber weight, whereas dry-matter concentration of progeny tubers increased. Conventional tubers appeared superior to minitubers in all characteristics mentioned except RCC, which was similar. Differences in performance between minitubers and conventional tubers were attributed to weight and age of seed tubers, presprouting method and crop husbandry.