Effects of distillers grains with high sulfur concentration on ruminal fermentation and digestibility of finishing diets

Twelve ruminally cannulated crossbred Angus steers were used to evaluate ruminal fermentation characteristics and diet digestibility when 30% (DM) corn dried distillers grains with solubles (DDGS) containing 0.42 or 0.65% (DM) of dietary S was incorporated into finishing diets based on steam-flaked corn (SFC) or dry-rolled corn (DRC). The study was a replicated, balanced randomized incomplete block design with a 2 × 2 factorial arrangement of treatments. Factors consisted of dietary S concentration (0.42 and 0.65% of DM; 0.42S and 0.65S, respectively) and grain processing method (SFC or DRC). The 0.65S concentration was achieved by adding H(2)SO(4) to DDGS before mixing rations. Steers were assigned randomly to diets and individual, slatted-floor pens, and fed once daily for ad libitum intake. Two 15-d experimental periods were used, each consisting of a 12-d diet adaptation phase and a 3-d sample collection phase. Samples were collected at 2-h intervals postfeeding during the collection phase. Ruminal pH was measured immediately after sampling, and concentrations of ruminal ammonia and VFA were determined. Fecal samples were composited by steer within period and used to determine apparent total tract digestibilities of DM, OM, NDF, CP, starch, and ether extract. Feeding 0.65S tended (P = 0.08) to decrease DMI but resulted in greater apparent total tract digestibilities of DM (P = 0.04) and ether extract (P = 0.03). Ruminal pH increased (P < 0.05) in steers fed 0.65S diets, which may be attributable, in part, to decreased (P = 0.05) VFA concentrations and greater (P < 0.01) ruminal ammonia concentrations when 0.65S was fed, compared with feeding 0.42S. These effects were more exaggerated in steers fed DRC (interaction, P < 0.01), compared with steers fed SFC. Steers fed DRC-0.65S had greater (P < 0.01) acetate concentration than steers fed DRC-0.42S, but acetate concentration was not affected by S concentration when SFC was fed. Propionate concentration was decreased (P < 0.01) in steers fed SFC-0.65S compared with steers fed SFC-0.42S, but dietary S concentration had no effect on propionate concentration when DRC was fed. Butyrate concentration was less (P < 0.01) in steers fed 0.65S diets than in steers fed 0.42S. Lactate concentrations tended (P = 0.06) to decrease in steers fed 0.65S diets. Feeding DDGS with increased S concentration may decrease feed intake and ruminal VFA concentration but increase ruminal ammonia concentration.     

Effects of wet corn gluten feed and roughage levels on performance, carcass characteristics, and feeding behavior of feedlot cattle

Two experiments were conducted to evaluate the effects of feeding different levels of wet corn gluten feed (WCGF) and dietary roughage on performance, carcass characteristics, and feeding behavior of feedlot cattle fed diets based on steam-flaked corn (SFC). In Exp. 1, crossbred steers (n = 200; BW = 314 kg) were fed 4 dietary treatments (DM basis): a standard SFC-based diet containing 9% roughage (CON) and 3 SFC-based diets containing 40% WCGF, with either 9, 4.5, or 0% roughage. A linear (P = 0.04) increase in final BW and DMI (P < 0.01) was observed in diets containing WCGF as dietary roughage increased. Steers fed WCGF and higher levels of roughage had greater (P = 0.01) ADG than steers fed lower levels of roughage. Steers fed the CON diet had lower (P = 0.04) daily DMI and greater (P = 0.03) G:F than those fed WCGF. Most carcass characteristics of steers fed CON did not differ (P > 0.10) from those of steers fed WCGF. Based on feed disappearance and visual scan data, consumption rate did not differ (P > 0.10) among treatments; however, feeding intensity (animals present at the bunk after feeding) was greater for steers fed CON (P < 0.01) than for steers fed WCGF. In Exp. 2, yearling crossbred steers (n = 1,983; BW = 339 kg) were fed 4 dietary treatments (DM basis): a standard SFC-based control diet that contained 9% roughage (CON) and 3 SFC-based diets containing either 20% WCGF and 9% roughage or 40% WCGF with 9 or 4.5% roughage. Steers fed the CON diet tended to have lower final BW (P = 0.14), ADG (P = 0.01), and DMI (P < 0.01) than steers fed diets containing WCGF. Steers fed the 20% WCGF diet had greater (P = 0.08) G:F than steers fed the 40% WCGF diets. With 40% WCGF, increasing roughage from 4.5 to 9% decreased (P < 0.01) G:F and increased (P = 0.06) DMI. Gain efficiency was improved (P < 0.01) for steers fed CON vs. those fed diets containing WCGF, whereas HCW (P = 0.02) and dressing percentage (P < 0.01) were greater for steers fed WCGF. Percentage of cattle grading USDA Choice was greater (P = 0.02) for cattle fed WCGF. Results suggest that replacing SFC with up to 40% WCGF increased ADG and decreased G:F when 4.5 to 9.0% roughage was supplied. More CON steers were present at the feed bunk during the first hour after feeding than WCGF steers, suggesting that including WCGF at 40% of the diet affected feeding behavior.     

Effects of dry, wet, and rehydrated corn bran and corn processing method in beef finishing diets

Two finishing trials were conducted to determine the effects of adding different types of corn bran, a component of corn gluten feed, on cattle performance. In Trial 1, 60 English crossbred yearling steers (283 +/- 6.7 kg) were used in a completely randomized design with four dietary treatments. Treatments were diets with no corn bran, dry corn bran (86% DM), wet corn bran (37% DM), and rehydrated dry bran (37% DM). Bran was fed at 40% of dietary DM. All finishing diets had (DM basis) 9% corn steep liquor with distillers solubles, 7.5% alfalfa hay, 3% tallow, and 5% supplement. Gain efficiency and ADG were greater (P < 0.01) for cattle fed no corn bran compared with all treatments containing corn bran; however, no differences were detected across corn bran types. In Trial 2, 340 English crossbred yearling steers (354 +/- 0.6 kg) were used in a randomized block design with treatments assigned based on a 2 x 4 + 2 factorial arrangement (four pens per treatment). One factor was the corn processing method used (dry-rolled corn, DRC; or steam-flaked corn, SFC). The other factor was corn bran type: dry (90% DM), wet (40% DM), or dry bran rehydrated to 40 or 60% DM. Bran was fed at 30% of dietary DM, replacing either DRC or SFC. Two control diets (DRC and SFC) were fed with no added bran. All finishing diets contained (DM basis) 10% corn steep liquor with distiller's solubles, 3.5% alfalfa hay, 3.5% sorghum silage, and 5% supplement. Corn bran type did not affect DMI (P = 0.61), ADG (P = 0.53), or G:F (P = 0.10). Dry matter intake was greater (P < 0.01) by steers fed bran compared with those fed no bran, and was greater by steers fed DRC than by steers fed SFC (P < 0.01). Interactions occurred (P < 0.01) between grain source and bran inclusion for ADG and G:F. The ADG by steers fed the SFC diet without bran was greater (P < 0.01) than by steers fed SFC diets with bran, whereas the ADG by steers fed DRC diets with or without bran was similar. Daily gain was 15.2% greater (P < 0.01) by steers fed SFC without bran than by steers fed DRC without bran. Gain efficiency was 16.9% greater (P < 0.01) for steers fed SFC without bran compared with steers fed DRC without bran. In DRC and SFC diets, feeding bran decreased (P < 0.01) G:F by 5.2 and 13.8%, respectively. The moisture content of corn bran had no effect on finishing steer performance, and drying corn bran did not affect its energy value in finishing cattle diets.     

Corn processing method in finishing diets containing wet corn gluten feed

Two trials were conducted to determine the effect of corn processing method on performance and carcass traits in steers fed finishing diets containing wet corn gluten feed (WCGF). In Trial 1, 480 steer calves (303 kg initial BW) were fed eight finishing diets: 1) dry-rolled corn (DRC) without; and 2) with 32% (DM basis) WCGF; 3) steam-flaked corn (SFC) without; and 4) with WCGF; 5) a combination of DRC and SFC without WCGF; 6) finely-ground corn (FGC) with WCGF; 7) high-moisture corn (HMC) with WCGF; and 8) whole corn (WC) with WCGF. Feeding WC + WCGF increased (P < 0.10) DMI and decreased gain:feed compared with all other treatments. Feeding DRC + WCGF increased (P < 0.10) DMI and decreased (P < 0.10) gain:feed compared with treatments other than WC + WCGF. Steers on treatments that included WCGF gained similarly, regardless of corn processing method, and at a rate 6% faster (P < 0.10) than steers fed diets that did not include WCGF. Gain:feed did not differ among steers fed SFC, SFC + WCGF, SFC + DRC, and HMC + WCGF. Steers fed SFC or SFC + WCGF were more efficient (P < 0.10) than steers fed DRC or FGC + WCGF. In Trial 2, 288 steer calves (382 kg initial BW) were fed six finishing diets: 1) DRC without; and 2) with 22% (DM basis) WCGF; 3) SFC without; and 4) with WCGF; 5) finely rolled corn (FRC) with WCGF; and 6) HMC corn with WCGF. Steers fed DRC + WCGF or FRC + WCGF consumed more DM (P < 0.10) than steers fed DRC, SFC, or SFC + WCGF. Feed intake did not differ between steers fed SFC + WCGF and HMC + WCGF. All treatment groups receiving WCGF consumed more DM (P < 0.10) feed than steers fed DRC or SFC without WCGF. Steers fed SFC + WCGF gained 8% faster (P < 0.10), and steers fed DRC 9.5% slower (P < 0.10) than steers receiving all other treatments. Daily gains did not differ among other treatment groups. Steers fed SFC or SFC + WCGF gained 10% more (P < 0.10) efficiently than all other treatment groups. Feed efficiency did not differ among steers fed DRC, DRC + WCGF, FRC + WCGF, and HMC + WCGF. Estimates for the NEg of WCGF calculated from animal performance indicated that WCGF contained approximately 25.3% more energy when fed with SFC than when fed with DRC. In general, more intensively processing corn improved gain:feed in finishing diets containing WCGF.     

Effects of copper supplementation on feedlot performance, carcass characteristics, and rumen sulfur metabolism of growing cattle fed diets containing 60% dried distillers grains

The effects of 3 supplemental Cu concentrations on feedlot performance, mineral absorption, carcass characteristics, and ruminal S metabolism of cattle fed diets containing 60% dried distillers grains with solubles (DDGS) were evaluated in 2 experiments. Experiment 1 was conducted with 84 Angus-cross yearling steers and heifers (initial BW = 238 ± 36 kg), which were blocked by gender and allocated to 12 pens. Supplemental dietary Cu (tribasic copper chloride) treatments were: 1) 0 mg Cu/kg diet DM, 2) 100 mg Cu/kg diet DM, 3) 200 mg Cu/kg diet DM. The remainder of the diet was DDGS (60%), grass hay (10%), pelleted soy hulls (15%), and a vitamin-mineral supplement (15%). Diets were offered ad libitum throughout the finishing phase (168 d). Three cattle from each pen (n = 36) were harvested on d 168 and carcass data and liver samples were collected. Copper supplementation did not affect ADG (P = 0.22). However, the nonsignificant trend for increased ADG and decreased DMI led to a linear increase (P = 0.02) feed efficiency (G:F = 0.167, 0.177, and 0.177 for 0, 100, and 200 mg Cu/kg diet DM, respectively). The apparent absorption of Cu decreased quadratically (P = 0.07) and the apparent absorption of Mn and Zn were decreased linearly (P = 0.03 and P = 0.05, respectively) with increased Cu supplementation. Cattle supplemented with 100 or 200 mg Cu/kg diet DM had greater liver Cu concentrations (P < 0.01) than cattle that were not supplemented with Cu. There were no treatment effects (P > 0.10) on HCW, LM area, USDA yield grade, backfat, or marbling score. Experiment 2 was conducted with 6 ruminally fistulated steers that were fed the same diets as in Exp 1 in a replicated 3 × 3 Latin Square design. Copper supplementation did not affect (P > 0.10) ruminal pH or liquid S(2-) concentrations in steers consuming 60% DDGS diets (total dietary S = 0.55%). From 3 to 9 h after feeding, H(2)S gas concentration was decreased in those cattle supplemented with 100 mg Cu/kg diet. Concentration of H(2)S gas did not differ among cattle supplemented with 0 or 200 mg Cu/kg diet DM on 60% DDGS diets. Supplemental Cu improved feed efficiency in cattle consuming diets containing 60% DDGS; however, effects of Cu on rumen S metabolism were minimal even when supplemented at twice the maximum tolerable limit for beef cattle (NRC, 2000).     

Effects of haylage and monensin supplementation on performance, carcass characteristics, and ruminal metabolism of feedlot cattle fed diets containing 60% dried distillers grains

The objectives of this research were to determine the interaction of monensin and haylage supplementation for steers fed 60% dried distillers grains (DDGS) on 1) mineral status, performance, and carcass characteristics, and on 2) ruminal pH, H(2)S, and short-chain fatty acid concentrations. In Exp. 1, Angus-cross steers (n=168; BW=277 ± 67 kg) were blocked by BW and allotted in a 2 × 2 factorial arrangement of treatments to 24 pens. Dietary treatments were 1) 0 mg of monensin/kg of diet + 0% haylage, 2) 33 mg of monensin/kg of diet + 0% haylage, 3) 0 mg of monensin/kg of diet + 10% haylage, and 4) 33 mg of monensin/kg of diet + 10% haylage. The remainder of the diet was 60% DDGS, 10% corn silage, 15% supplement, and corn (either 5 or 15%) on a DM basis. When supplemented with 0 mg of monensin/kg of diet, added haylage increased ADG by 5.7%, whereas when supplemented with 33 mg of monensin/kg of diet, added haylage increased ADG by 13% (P < 0.01). No interactions of monensin and haylage were observed for DMI or G:F (P ≥ 0.36). Haylage inclusion increased (P < 0.01) DMI and decreased (P < 0.01) G:F. No interactions (P > 0.05) on plasma mineral concentrations were observed; however, over time, plasma Cu concentrations decreased (P < 0.01), whereas plasma ceruloplasmin and S concentrations increased (P < 0.01). There were no treatment effects (P ≥ 0.08) on carcass characteristics. Cattle fed the 60% DDGS diets benefitted from increased dietary forage, and the effects of monensin and forage were additive for ADG and final BW. In Exp. 2, ruminally fistulated steers (n=8; BW = 346 ± 34 kg) were used in a replicated 4 × 4 Latin square design and were randomly assigned to the diets used in Exp. 1. Haylage inclusion increased ruminal pH from 1.5 through 12 h postfeeding, and the effects of monensin supplementation were additive (P < 0.05). From 1.5 through 9 h postfeeding, steers fed 33 mg of monensin/kg of diet tended to have reduced (P ≤ 0.10) concentrations of H(2)S when compared with steers fed 0 mg of monensin/kg of diet. Acetate:propionate ratios at 6 h postfeeding were 0.94, 0.93, 1.29, and 1.35 for diets 1 to 4, respectively (P < 0.01); total lactate was decreased regardless of treatment (range: 0.94 to 1.42 μmol/mL). Sulfuric acid in DDGS, not ruminal short-chain fatty acids, may be responsible for the low rumen pH observed and may influence the maximum inclusion of DDGS in cattle diets. Monensin supplementation decreased H(2)S concentration and may decrease the risk of polioencephalomalacia for cattle fed high-DDGS diets.     

Tolerance of cattle to increased dietary sulfur and effect of dietary cation-anion balance

The objective of this study was to determine if dietary cation-anion balance (DCAB) affects the concentration of S that can be tolerated by growing and finishing cattle without adversely affecting performance. Angus cross and Bradford steers (n=114; average initial BW=252.8 kg) were blocked by BW and breed, and randomly assigned within a block to treatment. The design was a 3 × 2 factorial arrangement of treatments with S (from NH(4)SO(4)) supplemented at 0, 0.15, or 0.30% of DM, and NaHCO(3) added at 0 or 1.0% of DM. Each treatment consisted of 3 pens containing 5 steers and 1 pen containing 4 steers. Steers were used in an 84-d growing study followed by a finishing study. A corn silage-based diet was fed during the growing study and a corn-based diet was fed during the finishing study. Steers were not randomized between experiments. The analyzed concentrations of S in the growing diets were 0.12, 0.30, and 0.46%, whereas the analyzed concentrations of S in the finishing diets were 0.13, 0.31, and 0.46% for treatments supplemented with 0, 0.15, and 0.30% S, respectively. Increasing DCAB by approximately 15 mEq/100 g of DM, by the addition of NaHCO(3,) did not affect (P > 0.36) performance during the growing or finishing studies. During the growing study DMI was not affected (P=0.29) by dietary S. Steers fed diets containing 0.30% S had greater ADG (P=0.02) and G:F (P=0.01) than those receiving 0.46% S, but similar (P > 0.36) performance to steers fed 0.12% S. During the finishing study, steers fed diets containing 0.46% S had less ADG than steers fed 0.13 (P=0.004) or 0.31% S (P=0.07), whereas ADG did not differ (P=0.18) among steers fed 0.13 and 0.31% S. Steers fed diets containing 0.31 (P=0.01) or 0.46% S (P=0.001) had less DMI than controls, but G:F was not affected (P=0.52) by S during the finishing study. Carcass characteristics did not differ (P > 0.18) among steers fed diets containing 0.13 and 0.31% S. Steers receiving diets containing 0.46% S had decreased HCW (P=0.001), quality (P=0.02), and yield grades (P=0.04) than steers receiving 0.13% S. Plasma Cu concentrations on d 101 of the finishing phase and liver Cu concentrations at slaughter were greater (P ≤ 0.05) in control steers compared with those fed diets containing 0.31 or 0.46% S. This study indicates that steers fed growing diets can tolerate up to 0.46% S with minimum effects on performance. Finishing steers tolerated diets containing 0.31% S without adverse affects on ADG or G:F. However, 0.46% S greatly decreased ADG and DMI, and increasing DCAB did not prevent these depressions.     

Effects of grain processing and dietary lipid source on performance, carcass characteristics, plasma fatty acids, and sensory properties of steaks from finishing cattle

An experiment was conducted to evaluate the effects of grain processing and lipid addition to finishing diets on cattle performance, carcass characteristics, and meat quality. Eighty Hereford x Angus steers (384 kg +/- 17 kg of BW) were fed diets containing steam-flaked corn (SFC) or dry-rolled corn (DRC) with and without the addition of tallow (SFC/Fat and DRC/Fat) or steam-flaked corn with ground flaxseed (SFC/Flax). Ribeye steaks from steers fed SFC, SFC/Fat, or SFC/ Flax were used to evaluate the effects of fat source on meat quality. Cattle fed SFC and SFC/Fat tended to have greater ADG, G:F, HCW, and USDA yield grade, compared with those fed DRC and DRC/Fat (P < 0.10). Steaks from steers fed SFC/Flax developed a detectable off-flavor (P < 0.05) compared with steaks from steers fed SFC and SFC/Fat, and steaks from steers fed SFC retained desirable color longer than those from steers fed SFC/Flax (P < 0.05). Feeding SFC/Flax increased deposition of alpha-linolenic acid in muscle tissue compared with feeding SFC or SFC/Fat (P < 0.01). Dietary treatment did not cause differences in tenderness, juiciness, or flavor intensity. Ground flaxseed can replace tallow in finishing diets without loss in performance, but flax may affect flavor and color stability of beef. Feeding flaxseed can effectively alter composition of carcass tissues to yield beef that is high in n-3 fatty acids.     

Effects of limit feeding corn or dried distillers grains with solubles at 2 intakes during the growing phase on the performance of feedlot cattle

Energy density in growing diets may affect carcass quality of cattle; however, few reports have described the impact of energy source. The objectives of this research were to determine effects of source [dried distillers grains with solubles (DDGS) vs. corn] and amount (limit-fed to gain 0.9 vs. 1.4 kg of BW/d) of energy during the growing phase on feedlot performance and marbling. Angus-cross steers (144 head) were blocked by BW (average initial BW = 252 ± 36 kg), allotted within each block to 8 pens (6 steers/pen, 24 pens total), and randomly assigned to 1 of 4 feeding systems in a 2 × 2 factorial arrangement of treatments: 1) 65% DDGS fed to gain 0.9 kg of BW/d, 2) 65% DDGS fed to gain 1.4 kg of BW/d, 3) 65% corn fed to gain 0.9 kg of BW/d, and 4) 65% corn fed to gain 1.4 kg of BW/d. Fecal grab samples were collected on d 52 of the growing phase to determine digestibility of DM, ADF, NDF, ether extract (EE), and CP. After the 98-d growing phase, all steers were fed the same finishing diet. Steers were slaughtered by pen when average BW within the pen was 544, 522, and 499 kg for the large, medium, and small BW blocks, respectively. Average daily gain and DMI differed (P<0.01) by design during the growing phase. Compared with the corn-based diets, digestibilities of DM, NDF, and EE were decreased (P<0.02) when DDGS-based diets were fed during the growing phase, whereas the digestibility of N was increased (P<0.01). The ADG was greatest (P=0.02) during the finishing phase for steers fed to gain 0.9 kg of BW/d initially, but source of energy during the growing phase did not affect (P=0.24) finishing phase ADG. Steers fed to gain 0.9 kg of BW/d during the growing phase also had less backfat (P=0.08), decreased USDA yield grades (P=0.03), and greater LM area (P<0.01) than steers fed to gain 1.4 kg of BW/d. There was an interaction between energy source and amount for marbling scores (P=0.02). Steers fed corn-based diets to gain 0.9 kg of BW/d during the growing phase had the most marbling, whereas those fed to gain 0.9 kg of BW/d on DDGS had the least marbling; the remaining feeding systems were intermediate. Overall ADG and DMI were affected (P < 0.06) by both source and amount of energy fed during the growing phase. Feeding the DDGS-based diet to achieve greater ADG during the growing phase increased marbling, whereas feeding the corn-based diet to increase ADG during the growing phase decreased marbling.     

Evaluation of finishing performance,carcass characteristics,acid-resistant E. coli and total coliforms from steers fed combinations of wet corn gluten feed and steam-flaked corn

Crossbred beef steers (n = 615) were used in a 152-d experiment to compare steam-flaked corn (SFC) diets containing 0, 30, or 60% wet corn gluten feed (WCGF). On d 114 to 118, ruminal and fecal samples were collected from 180 steers and analyzed for pH, VFA, and total and acid-resistant Escherichia coli and coliforms. Acid resistance of E. coli and coliform populations was determined by exposure of the samples for 1 h in pH 2, 4, and 7 citric acid/sodium phosphate buffers. Increasing levels of WCGF linearly decreased total ruminal VFA (P = 0.01) and total fecal VFA (P = 0.06), but linearly increased ruminal and fecal acetate:propionate (P < 0.01) ratio and ruminal and fecal pH (P < 0.05). Feeding increasing WCGF levels resulted in a quadratic response (P < 0.05) with respect to numbers of ruminal E. coli and total coliform populations resistant to pH 4 exposure. Steers fed 30% WCGF had higher (0.7 log units) ruminal E. coli and total coliforms after exposure at pH 4 compared to steers fed 0 or 60% WCGF. Populations of E. coli and total coliforms at pH 2 and 7 were similar for all dietary treatments. Dietary WCGF linearly increased DMI (P = 0.07) and liver abscesses (P = 0.03) and linearly decreased dietary NEg (P = 0.02). Average daily gain and feed efficiencies were greatest when steers were offered 30% WCGF (quadratic, P < 0.05). Dietary manipulations that reduce acid concentrations may not correspond to changes in acid resistance of E. coli and total coliform populations detected in the gastrointestinal tracts of cattle. Moderate levels of WCGF complement SFC finishing diets.     

Growth and muscle development of feedlot cattle of different genetic backgrounds

The effects of crossbreeding, cattle type and dietary energy level on semitendinosus muscle (ST) development, feedlot performance, daily carcass protein and fat gain and serum anabolic hormone concentrations were studied. Over 3 consecutive years, 176 feedlot steers representing four cattle types - unselected Hereford (UH), selected Hereford (SH), Angus x Hereford x Charolais (AHC) and Angus x Hereford x Holstein (AHH) - were fed either an all-corn silage (HS) or a high grain (HG) diet. Steers were slaughtered on day 1 and at the end of the feedlot trial, and ST muscles were removed rapidly. During years 2 and 3, single blood samples were obtained from steers on days 1, 29, 57, 113 and 169, and analyzed for insulin and growth hormone (GH). Steers fed HG had a higher (P less than .005) average daily gain (ADG) than steers fed HS, and cattle type had an effect (P less than .005) on ADG. Cattle type and HG affected (P less than .005) daily carcass protein and fat gain. Weight of ST muscle and total muscle RNA, DNA and protein content increased with frame size, and HS steers had heavier (P less than .05) ST muscles than the HG steers. Steers fed HG had higher (P less than .01) serum insulin concentrations than steers fed HS, but there were no consistent cattle type effects. Serum GH concentrations were not affected by cattle type or diet. Serum insulin concentrations, combined across diet and cattle types, were correlated (P less than .01) with ADG; however, serum GH, assessed on the same basis, was not related to ADG. Average daily protein and fat gain were positively related to serum insulin and were negatively related to serum GH.     

Effects of feeding whole cottonseed and cottonseed products on performance and carcass characteristics of finishing beef cattle

Three experiments were conducted to determine the effects of whole cottonseed or cottonseed products on performance and carcass characteristics of beef cattle. In Exp. 1, 120 beef steers (initial BW = 381 +/- 31.7 kg) were fed steam-flaked corn-based finishing diets with 10% (DM basis) basal roughage, and whole cottonseed or individual cottonseed components (cottonseed hulls, meal, and oil). Over the entire feeding period, ADG did not differ (P = 0.95), but DMI increased (P = 0.07) and G:F decreased (P = 0.06) for steers fed the cottonseed diets compared with the control diet. Dressing percent (P = 0.02) and marbling scores (P = 0.02) of carcasses from steers fed the cottonseed diets were less than for steers fed the control diet. In Exp. 2, 150 beef steers (initial BW = 364 +/- 9.9 kg) were used to determine the effects of whole cottonseed or pelleted cottonseed (PCS) on performance and carcass characteristics. Cattle were fed steam-flaked corn-based finishing diets in which whole cottonseed or PCS replaced all of the dietary roughage, supplemental fat, and supplemental natural protein of the control diet. Over the entire feeding period, steers fed the cottonseed diets had lower (P = 0.04) DMI and greater (P < 0.01) G:F than steers fed the control diet. Carcass characteristics did not differ (P = 0.16 to 0.96) among dietary treatments. In Exp. 3, 150 beef heifers (initial BW = 331 +/- 17.1 kg) were used to determine the effects of PCS or delinted, whole cottonseed (DLCS) on performance and carcass characteristics. Heifers were fed rolled corn-based finishing diets in which cottonseed replaced the dietary roughage, supplemental fat, and all or part of the supplemental natural protein of the control diet. Over the entire feeding period, ADG, DMI, and G:F of heifers fed the control diet did not differ (P = 0.19 to 0.80) from those of the cottonseed diets; however, heifers fed the diets containing PCS had greater ADG (P = 0.03) and G:F (P = 0.09) than heifers fed diets containing DLCS. Carcass characteristics of heifers fed the control diet did not differ (P > or = 0.28) from those fed the cottonseed diets. Heifers fed the diets containing PCS had greater (P < or = 0.03) HCW, dressing percent, and LM area than those fed DLCS. Based on our results, whole cottonseed, or products derived from processing whole cottonseed, can replace feedstuffs commonly used in beef cattle finishing diets with no adverse effects on animal performance or carcass characteristics.     

Comparative feeding value of steam-flaked corn and sorghum in finishing diets supplemented with or without sodium bicarbonate.

A feedlot growth-performance trial involving 64 yearling steers and a metabolism trial involving four steers with cannulas in the rumen, proximal duodenum, and distal ileum were conducted to evaluate the comparative feeding value of steam-flaked corn (SFC, density = .30 kg/liter) and sorghum (SFS, density = .36 kg/liter) in finishing diets supplemented with or without .75% sodium bicarbonate (BICARB). No interactions between BICARB and grain type proved to be significant. Supplemental BICARB increased ADG 5.9% (P less than .10) and DMI 4.6% (P less than .05) but did not influence (P greater than .10) the NE value of the diet. Supplemental BICARB increased ruminal pH (P less than .01) and total tract fiber digestion (P less than .05). Differences in ruminal and total tract OM, starch, and N digestion were small (P greater than .10). Replacing SFC with SFS decreased (P less than .05) ADG 6.1% and increased (P less than .01) DMI/gain 9.7%. Corresponding diet NEm and NEg were decreased (P less than .01) 7.0 and 9.3%, respectively. Ruminal digestion of OM and starch tended to be lower (11.8 and 7.2%, respectively, P less than .10) for SFS. Ruminal degradation of feed N was 31% lower (P less than .05) for the SFS diets. Total tract digestibility of OM, N, DE, and ME were 3.3, 10.8, 4.4, and 5.5% lower (P less than .05), respectively, for the SFS vs SFC diets. In conclusion, 1) SFS had 92% the NEm of SFC; 2) differences in total tract starch digestibility were small and cannot explain the higher feeding value of SFC; 3) the low ruminal degradation of sorghum N (roughly 20%) should be considered in diet formulation to avoid a deficit in ruminally available N; and 4) .75% BICARB supplementation increased DMI and ADG of cattle fed highly processed grain-based diets.     

Use of dried distillers grains throughout a beef production system: effects on stocker and finishing performance, carcass characteristics, and fatty acid composition of beef

A 2-yr study was conducted using a 3 × 2 factorial arrangement of treatments to evaluate the effects of feeding dried distillers grains throughout a beef production system on performance, carcass characteristics, and fatty acid profile of beef. Factors were wheat pasture supplement [no supplement (CON), dry-rolled corn (DRC), and dried distillers grains (DDG)] fed at 0.5% BW daily and finishing diet [steam-flaked corn based diet containing 0 (SFC) or 35% (35DDG) DDG]. Each year, 60 preconditioned Hereford steers (initial BW = 198 kg ± 3) grazed winter wheat pasture with or without supplement. Body weight gain was 8% greater for steers consuming DDG supplement compared with CON and DRC steers (P < 0.01). After the grazing period, pastures within supplement treatment were randomly assigned to SFC or 35DDG. There was no supplement by finishing diet interaction for any performance or carcass variable of interest (P ≥ 0.41). Previous supplementation on winter wheat affected BW at feedlot entry and adjusted G:F (P ≤ 0.05) but had no effect on finishing ADG or carcass traits (P ≥ 0.12). On a carcass-adjusted basis, steers consuming 35DDG had reduced final BW, ADG, G:F, and total BW gain throughout the system (P ≤ 0.04) compared with SFC. Additionally, steers consuming 35DDG had reduced HCW, dressing percent, and fat thickness (P ≤ 0.03) compared with SFC. There was a supplement by finishing diet interaction (P = 0.02) for 18:0, in which cattle supplemented with DRC and fed the SFC finishing diet had the lowest concentration of 18:0 but DRC supplemented steers fed the 35DDG diet had the greatest concentration. The interaction was not significant (P ≥ 0.18) for other fatty acids. Main effects of supplement and finishing diet affected (P ≤ 0.05) several other fatty acids of interest, particularly 18:2, which is associated with reduced flavor-stability of beef. The use of DDG as a supplement to wheat pasture resulted in greater ADG during wheat grazing and heavier BW at feedlot entry, but final BW was not different from CON or DRC groups. Feeding DDG at 35% DM in steam-flaked corn-based finishing diets reduced ADG, G:F, and HCW, and affected the fatty acid composition of beef.     

Interaction of corn processing and distillers dried grains with solubles on health and performance of steers

Feeding increased concentrations of distillers dried grains with solubles (DDGS) to ruminants has been avoided due to risks of S toxicity and concerns about animal performance. The objective of this study was to evaluate the influence of feeding an increasing concentration of DDGS and corn processing method on animal performance, incidence of polioencephalomalacia (PEM), and concentration of H(2)S gas in feedlot steers. Sixty steer calves (336 ± 13.2 kg) were individually fed for an average of 136 d in a completely random design with a 3 × 2 factorial arrangement of treatments. Main effects included concentration of DDGS (20, 40, or 60% DM basis) and corn processing method [high-moisture (HMC; 71.7% DM) vs. dry-rolled corn (DRC; 86.2% DM)] resulting in treatments of 1) 20% DDGS with DRC, 2) 40% DDGS with DRC, 3) 60% DDGS with DRC, 4) 20% DDGS with HMC, 5) 40% DDGS with HMC, and 6) 60% DDGS with HMC. Ruminal H(2)S gas concentrations were measured on d 0, 7, 14, 21, 28, 35, 49, 63, and 91 via rumen puncture. Animal performance and carcass characteristic data were collected. The day × corn processing × DDGS interaction for H(2)S gas concentrations was not significant (P = 0.91). Ruminal H(2)S concentration increased with increasing DDGS concentration (P < 0.001) and day (P < 0.001), but was not influenced by corn processing method (P = 0.94). Carcass-adjusted final BW decreased linearly (P = 0.009), whereas carcass-adjusted ADG decreased quadratically (P = 0.05) with increasing concentration of DDGS in the diet. Carcass-adjusted G:F was not affected (P ≥ 0.28) by increasing concentration of DDGS in the diet. Carcass characteristics reflected the decrease in final BW with decreased HCW (P = 0.009), as well as decreased fat depth (P = 0.005) with increasing concentrations of DDGS. The combination of decreased HCW and backfat thickness resulted in decreased (P = 0.02) yield grade with increasing DDGS inclusion. There were no confirmed cases of PEM. In conclusion, corn processing did not influence animal performance, incidence of PEM, or H(2)S concentrations under the conditions of this study. Feeding 60% DDGS in beef cattle finishing diets is not recommended due to poor animal performance.     

Growing and finishing performance of steers when fed recycled poultry bedding during the growing period

Sixty Angus-cross steers were used to compare the effects of recycled poultry bedding (RPB) stacking method and the inclusion of monensin in growing diets on performance. Steers were individually fed balanced, growing diets for a period of 84 d. The diets were control (CON), CON + monensin (CON+M), deep-stacked RPB (DS), DS+M, shallow-stacked RPB (SS), and SS+M. The CON diets contained corn, soybean meal, corn silage, and cottonseed hulls. In the RPB diets, 35% of the silage, cottonseed hulls, and soybean meal was replaced with RPB (as-fed basis). At the end of the growing period, 30 steers, representing all treatment groups, had liver biopsies for trace mineral analysis and ruminal fluid samples to assess pH, VFA, and ammonia concentrations. All steers had blood samples drawn at the end of the growing period for analysis of Se and urea N. Steers were transported 466.6 km to simulate shipping stress and started on a finishing diet for a 120-d period. Intake, ADG, and G:F were monitored throughout the trial. Steers fed CON diets had higher ADG, DMI, and G:F than SS, and higher ADG and G:F than DS (P < 0.05) during the growing period. Steers fed DS diets had higher DMI than SS (P < 0.05) during the growing period. Inclusion of monensin in the growing diets increased G:F and decreased DMI (P < 0.05). Steers from the RPB treatments started the finishing period at lighter BW than steers fed CON diets (P < 0.05). During the finishing period, steers fed SS diets had higher DMI than steers fed CON diets (P < 0.06), whereas steers fed DS diets were intermediate. At slaughter, steers fed CON diets had higher hot carcass weights and quality grades than steers fed SS diets (P < 0.07), whereas steers fed DS diets were intermediate. Results indicate that steers fed RPB consumed it better when processed by deep stacking before consumption, that carryover effects of RPB into the finishing phase were minimal, and inclusion of monensin did not affect consumption of RPB diets.     

Wet corn gluten feed and alfalfa hay levels in dry-rolled corn finishing diets: effects on finishing performance and feedlot nitrogen mass balance

One-hundred ninety-two crossbred steers (initial BW = 351 +/- 11 kg) were used to determine the effects of removing alfalfa hay (AH) from dry-rolled corn-based diets containing wet corn gluten feed (WCGF) on animal performance and nutrient (N and OM) mass balance in open feedlot pens. Steers were stratified by weight and assigned randomly to 24 pens (2 x 3 factorial) and fed for 132 d from June to October 2002. Experimental diets contained either 0 or 35% WCGF and 0, 3.75, or 7.5% AH, and were formulated to be isonitrogenous. For efficiency of gain, an interaction occurred (P = 0.09) between AH and WCGF. Feed efficiencies of cattle fed 35% WCGF were improved 4.4% (P = 0.10) compared with efficiencies of cattle fed no WCGF at 0% AH; there was a marked improvement in ADG for cattle fed WCGF compared with no WCGF in diets with 0% AH. Within 35% WCGF diets, efficiency decreased as AH inclusion increased (P = 0.06). Efficiency was equal across AH levels when 0% WCGF was fed; however, ADG was decreased when AH was removed. Interactions between AH and WCGF were not detected for other performance or carcass criteria; therefore, main effects of AH and WCGF are discussed. Daily intake, ADG, and HCW increased linearly (P < 0.05) as dietary AH level increased. Feeding 35% WCGF also resulted in greater DMI (P < 0.01) and a tendency for greater ADG and HCW (P < or = 0.10) compared with steers fed no WCGF. Interactions between AH and WCGF were not observed for feedlot N mass balance. As level of AH increased across diets, N intake, N retention, and N excretion increased (P < 0.05). Steers fed 35% WCGF consumed and excreted more N (P < 0.01) than those fed no WCGF. More manure DM (P = 0.11), OM, and N (P < 0.01) were removed from pens housing steers fed 35% WCGF as well as greater OM and N recovery in finished compost. More N (kilogram/steer) was also lost to volatilization as a result of greater N excretion when WCGF was fed. Expressed as a percentage of N excretion, loss of N from pens housing steers fed 0 and 35% WCGF was not different, averaging nearly 80%. These data suggest that AH has less value when dry-rolled corn-based diets contain 35% WCGF and can be decreased from conventional levels. Furthermore, loss of N from open feedlot pens is high during the summer months, and feeding WCGF may not reduce N losses during these times of year.     

Effects of dried full-fat corn germ and vitamin E on growth performance and carcass characteristics of finishing cattle

Two experiments were conducted to evaluate dried full-fat corn germ (GERM) as a supplemental fat source in cattle finishing diets. In Exp. 1, 24 pens totaling 358 crossbred beef steers with an initial BW of 319 kg were allowed ad libitum access to diets containing dry-rolled corn, 35% wet corn gluten feed, and 0, 5, 10, or 15% GERM on a DM basis. Increasing GERM decreased (linear; P < 0.02) DMI and increased (quadratic; P < 0.02) ADG. Steers fed 10% GERM had the greatest ADG (quadratic; P < 0.02) and G:F (quadratic; P < 0.05). The addition of GERM increased (linear; P < 0.05) fat thickness, KPH, and the percentage of USDA Yield Grade 4 carcasses (quadratic; P < 0.03), with steers fed 15% GERM having the greatest percentage of USDA Yield Grade 4 carcasses. In Exp. 2, 48 pens totaling 888 crossbred beef heifers with an initial BW of 380 kg were allowed ad libitum access to diets containing steam-flaked corn, 35% wet corn gluten feed, and either no added fat (control), 4% tallow (TALLOW), or 10 or 15% GERM on a DM basis, with or without 224 IU of added vitamin E/kg of diet DM. No fat x vitamin E (P > or = 0.08) interactions were detected. Fat addition, regardless of source, decreased (P < 0.01) DMI, marbling score, and the number of carcasses grading USDA Choice. Among heifers fed finishing diets containing TALLOW or 10% GERM, supplemental fat source did not affect DMI (P = 0.76), ADG (P = 0.54), G:F (P = 0.62), or carcass characteristics (P > or = 0.06). Increasing GERM decreased DMI (linear; P < 0.01) and ADG (quadratic; P < 0.02), with ADG by heifers fed 10% GERM slightly greater than those fed control but least for heifers fed 15% GERM. Increasing GERM improved (quadratic; P < 0.03) G:F of heifers, with heifers fed 10% GERM having the greatest G:F. Increasing GERM decreased HCW (linear; P < 0.02), marbling score (linear; P < 0.01), and the percentage of carcasses grading USDA Choice (linear; P < 0.01). The addition of vitamin E increased (P < 0.04) the percentage of carcasses grading USDA Select and decreased (P < 0.01) the percentage of carcasses grading USDA Standard. These data suggest that GERM can serve as a supplemental fat source in cattle finishing diets, and that the effect of vitamin E did not depend on source or concentration of supplemental fat.     

Effects of polyunsaturated fatty acid supplementation on ruminal in situ forage degradability, performance, and physiological responses of feeder cattle

Two experiments were conducted to compare ruminal, physiological, and performance responses of forage-fed cattle consuming grain-based supplements without (NF) or with the inclusion (10%; DM basis) of a rumen-protected PUFA (PF) or SFA source (SF). Supplements were offered and consumed at 0.6% of BW/animal daily (DM basis). In Exp. 1, DMI and ruminal in situ forage degradability were evaluated in 3 Angus × Hereford cows fitted with ruminal cannulas and allocated to a 3 × 3 Latin square design. Within each experimental period, hay was offered in amounts to ensure ad libitum access from d 1 to 13, DMI was recorded from d 8 to 13, and cows were limited to receive 90% of their average hay DMI (d 1 to 13) from d 14 to 21. On d 16, polyester bags containing 4 g of ground hay (DM basis) were incubated within the rumen of each cow for 0, 4, 8, 12, 24, 36, 48, 72, and 96 h. Hay and total DMI were reduced (P < 0.05) in cows receiving PF compared with cows receiving SF and NF. No treatment effects were detected (P > 0.48) for ruminal disappearance rate and effective ruminal degradability of hay DM and NDF. In Exp. 2, preconditioning DMI, ADG, carcass traits, and plasma concentrations of cortisol, fatty acids, acute-phase proteins, and proinflammatory cytokines were assessed in 72 Angus × Hereford steers receiving supplement treatments during a 28-d preconditioning period. All steers were transported to a commercial growing lot after preconditioning (d 1) and were later moved to an adjacent commercial finishing yard (d 144), where they remained until slaughter. No treatment effects were detected (P ≥ 0.52) for preconditioning ADG and G:F, but DMI tended (P = 0.09) to be reduced in steers receiving PF compared with those receiving NF and SF. Plasma PUFA concentrations were greater in steers receiving PF compared with those receiving NF and SF (P = 0.01). After transportation, concentration of tumor necrosis factor-α increased for steers receiving NF, did not change for steers receiving SF, but decreased for steers receiving PF (treatment × day interaction, P < 0.01). Steers fed PF had greater (P = 0.02) ADG compared with those fed NF during the growing phase. Carcass yield grade and marbling were greater (P < 0.05) for steers fed PF compared with those fed NF. In conclusion, PUFA supplementation did not affect ruminal forage degradability but did impair DMI in beef cows. Further, PUFA supplementation to steers during preconditioning reduced plasma concentrations of tumor necrosis factor-α after transportation, and benefited growing lot ADG and carcass marbling.     

Effect of cattle age, forage level, and corn processing on diet digestibility and feedlot performance

Three experiments were conducted to determine the effects of cattle age and dietary forage level on the utilization of corn fed whole or ground to feedlot cattle. In Exp. 1, 16 steers were used to investigate the effects of cattle age and corn processing on diet digestibility. Two cattle age categories were evaluated (weanling [254 +/- 20 kg BW] and yearling [477 +/- 29 kg BW]; eight steers per group), and corn was fed either ground or whole to each cattle age category. Cattle age and corn processing did not affect (P > 0.10) diet digestibility of DM, OM, starch, CP, NDF or ADF, and no interactions (P > 0.10) between these two factors were detected. In Exp. 2, the effects of forage level and corn processing on feedlot performance and carcass characteristics were evaluated. One hundred eighty steers (310 +/- 40 kg BW) were allotted to 24 pens, and were fed one of the following diets: high-forage (18.2% corn silage) cracked corn (HFCC); high-forage shifting corn (whole corn for the first half of the trial, then cracked corn until harvest; HFSC); high-forage whole corn (HFWC); low-forage (5.2% corn silage) cracked corn (LFCC); low-forage shifting corn (LFSC); and low-forage whole corn (LFWC). For the high-forage diets, steers fed cracked corn had 7% greater DMI than those fed whole corn, whereas for the low-forage diets, grain processing did not affect DMI (interaction; P = 0.02). No interactions (P > 0.10) between forage level and corn processing were found for ADG and G:F. Total trial ADG and G:F, and percentage of carcasses grading USDA Choice, and carcass yield grade were not affected (P > 0.10) by corn processing. Cattle with fewer days on feed grew faster and more efficiently when cracked corn was fed, whereas cattle with longer days on feed had greater ADG and G:F when corn was fed whole (interaction; P < 0.10). In Exp. 3, the effects of forage level and corn processing on diet digestibility were evaluated. The high-forage cracked corn, high-forage whole corn, low-forage cracked corn, and low-forage whole corn diets used in Exp. 2 were fed to 16 steers (350 +/- 27 kg BW) in a digestion trial. No interactions (P > 0.10) between forage level and corn processing were detected for starch digestibility. Forage level and corn processing (grinding) did not affect (P > 0.10) diet DM, OM, starch, CP, and NDF digestibility. Processing corn did not provide additional benefits to feedlot cattle performance under these experimental conditions.