Diet mixing time affects nursery pig performance

The objective of this study was to determine the effects of mixing time (mixer efficiency) of diets containing several low-inclusion ingredients (crystalline AA, ZnO, a medication, and vitamin and trace mineral premixes) on growth performance of nursery pigs. In a pilot study, mixing efficiency of a 1,360-kg capacity, horizontal ribbon mixer was evaluated with salt of different particle sizes (440, 730, 2,000, and 3,000 microm). Sample preparation was evaluated by analyzing diet samples as collected (unground) or by grinding the entire sample to approximately 400 microm in particle size (ground). Diets (907 kg) were mixed, and samples were collected after 0, 30, 60, 120, 210, 330, 480, and 630 s of mixing. The coefficient of variation among 10 samples for each mixing time was used to measure mixer efficiency as determined by Cl concentration. A salt particle size x sample preparation x mixing time interaction was observed (P = 0.04). Samples with 2,000- or 3,000-microm salt particle size (unground or ground) never reached the desired mixing efficiency of a 10% CV. Using 440-microm salt (unground or ground) or 730-microm salt particle sizes (ground) was necessary to accurately achieve a mixing efficiency of a <10% CV within 330 and 630 s, respectively. Next, 180 weanling pigs (PIC, 6.31 +/- 0.84 kg of BW, 21 +/- 3 d of age) were fed diets in 2 phases (d 0 to 14 and d 14 to 28). Treatments consisted of mixing diets for 0, 30, 60, 120, or 330 s (440-microm salt particle size). Samples were collected in the mixer, and then each bag of feed (22.5 kg) was labeled (first to last as-manufactured) and sampled to determine the mixing efficiency. An individual bag of feed was fed to a single pen of pigs, and when finished, the next sequential bag was used. As mixing time increased, mixer CV were 178, 38, 26, 21, and 5% for phase 1 and 172, 79, 60, 48, and 26% for phase 2. As mixing time increased, bag CV values were 26, 20, 16, 11, and 7% for phase 1 and 56, 45, 40, 33, and 12% for phase 2. From d 0 to 14, increasing mixing time increased ADG (linear, P < 0.01) and G:F (quadratic, P = 0.03). From d 0 to 28, increasing mixing time increased ADG (quadratic, P < 0.01) and G:F (linear, P = 0.04). These data demonstrate that inadequate diet mixing (CV > 12%) reduces nursery pig performance.     

Effects of blood meal pH and irradiation on nursery pig performance

A total of 720 nursery pigs in three experiments were used to evaluate the effects of blood meal with different pH (a result of predrying storage time) and irradiation of spray-dried blood meal in nursery pig diets. In Exp. 1, 240 barrows and gilts (17 +/- 2 d of age at weaning) were used to determine the effects of blood meal pH (7.4 to 5.9) in diets fed from d 10 to 31 postweaning (7.0 to 16.3 kg of BW). Different lots of dried blood meal were sampled to provide a range in pH. Overall (d 0 to 21), pigs fed diets containing blood meal had greater ADG (P < 0.05) and ADFI (P < 0.05) than pigs fed diets without blood meal. Ammonia concentrations in blood meal rose as pH decreased. However, blood meal pH did not influence (P > 0.16) ADG, ADFI, or gain:feed (G:F). In Exp. 2, 180 barrows (17 +/- 2 d of age at weaning) were used to determine the effects of post drying pH (7.6 to 5.9) and irradiation (gamma ray, 9.5 kGy) of blood meal on growth performance of nursery pigs from d 5 to 19 postweaning (6.8 to 10.1 kg of BW). One lot of whole blood was isolated with 25% of the total lot dried on d 0, 3, 8, and 12 after collection to create a range in pH. Overall, pigs fed blood meal had improved G:F (P < 0.01) compared to pigs fed the control diet. Similar to Exp. 1, the ammonia concentration of blood meal increased with decreasing pH. Blood meal pH did not influence ADG, ADFI, or G:F (P > 0.21), but pigs fed irradiated blood meal (pH 5.9) had greater ADG and G:F (P < 0.05) than pigs fed nonirradiated blood meal (pH 5.9). In Exp. 3, 300 barrows (17 +/- 6 d of age at weaning) were used to determine the effects of blood meal irradiation source (gamma ray vs. electron beam) and dosage (2.5 to 20.0 kGy) on growth performance of nursery pigs from d 4 to 18 postweaning (8.7 to 13.2 kg of BW). Overall, the mean of all pigs fed blood meal did not differ in ADG, ADFI, or G:F (P > 0.26) compared to pigs fed the control diet without blood meal. Pigs fed irradiated blood meal had a tendency (P < 0.10) for increased G:F compared with pigs fed nonirradiated blood meal. No differences in growth performance were detected between pigs fed blood meal irradiated by either gamma ray or electron beam sources (P > 0.26) or dosage levels (P > 0.11). These studies suggest that pH alone as an indicator of blood meal quality is not effective and irradiation of blood meal improved growth performance in nursery pigs.     

Effect of pig weaning weight and associated nursery feeding programs on subsequent performance to 105 kilograms body weight

An experiment using a total of 210 crossbred pigs from two farrowing groups evaluated the effects of three weaning weights and their associative starter feeding program on subsequent postweaning performance to 105 kg BW. One group of pigs nursed their dams in outside heated hutches (Trial 1), and a second group was raised in a centrally heated farrowing house (Trial II). The three pig weaning weight groups ranged in weight from 1) 4.1 to 5.0 kg, 2) 5.5 to 6.8 kg, and 3) 7.3 to 8.6 kg. Pigs in Group 1 were fed a high nutrient dense diet (HNDD) for a 2-wk period followed by a corn-soybean meal-dried whey (C-SBM-DW) and then a corn-soybean meal (C-SBM) diet, each for a 2-wk period. Group 2 was fed the same diet sequence except that HNDD was provided for 1 wk, whereas Group 3 was provided only the C-SBM-DW and the C-SBM diets each for 2 wk, consecutively. At the end of the nursery period, pigs were fed C-SBM diet formulations to 105 kg BW. Pigs of Trial I averaged 5.2 d older at weaning than those raised in the central farrowing house, but only a 1.5-d difference existed between light- and heavy-weight groups in both trials. Gains and feed intakes for the three weaning groups were higher as weaning weight increased during both the nursery and the growing-finishing period. There did not seem to be a compensatory growth response for lighter-weight weanling pigs even though they had been fed starter diets containing milk products. Consequently, fewer days (approximately 15) were required for the heavier-weight weanling pig group to reach a final weight of 105 kg than for the light-weight group. The medium-weight group required an intermediate number of days to reach 105 kg.     

保育猪的精细管理（一）

在由两部分组成的“保育猪的精细管理”系列中,我们将在第一部分中讨论实现较大断奶体重的重要性以及怎样实现更大的上市体重。在第二部分中我们将讨论会影响仔猪采食量及生产性能的管理因素。     

The effects of poultry meal source and ash level on nursery pig performance

Weanling pigs (total of 560) were used in two experiments to determine the effects of poultry meal in nursery diets on pig performance. In Exp. 1,210 barrows and gilts (initially 7.4 kg and 21 +/- 2 d of age) were fed one of five diets, which included a control diet with no specialty protein products or (as-fed basis) the control with 2.5 or 5.0% fish meal, or 2.9 or 5.9% poultry meal (11.8% ash). Poultry meal replaced fish meal on an equal lysine basis. Overall (d 0 to 28), pigs fed diets containing fish meal had greater (P < 0.01) ADG than pigs fed poultry meal. Increasing fish meal tended to have increased (quadratic, P < 0.07) ADG, with the greatest improvement observed in pigs fed the diet containing 2.5% fish meal. Pigs fed diets containing fish meal had improved (P < 0.01) G:F compared with pigs fed diets containing poultry meal. In Exp. 2, a total of 350 barrows and gilts (initially 8.9 kg and 22 +/- 2 d of age) were fed one of seven experimental diets, which included a control diet with no specialty protein products, or the control with 2.5 or 5.0% fish meal, 2.9 or 5.8% low-ash (10.9%) poultry meal, and 3.1 or 6.2% high-ash (13.5%) poultry meal. Poultry meal replaced fish meal on an equal lysine basis. Overall (d 0 to 15), there were no differences in ADG and ADFI (P = 0.14); however, pigs fed diets containing fish meal or poultry meal had improved (linear, P < 0.01) G:F compared with pigs fed the control diet. Pigs fed diets containing low-ash poultry meal had greater (P < 0.01) G:F compared with pigs fed diets containing high-ash poultry meal. Based on these data, quality control specifications, such as ash content, need to be considered when using poultry meal as an animal protein replacement in diets for nursery pigs.     

Effect of crude glycerol on pellet mill production and nursery pig growth performance

The objective of this study was to determine the effects of diets containing crude glycerol on pellet mill production efficiency and nursery pig growth performance. In a pilot study, increasing crude glycerol (0, 3, 6, 9, 12, and 15%) in a corn-soybean meal diet was evaluated for pellet mill production efficiency. All diets were steam conditioned to 65.5 degrees C and pelleted through a pellet mill equipped with a die that had an effective thickness of 31.8 mm and holes 3.96 mm in diameter. Each diet was replicated by manufacturing a new batch of feed 3 times. Increasing crude glycerol increased both the standard (linear and quadratic, P < 0.01) and modified (linear, P < 0.01; quadratic, P 相似文献   

Photoperiod and heat stress influence on lactating sow performance and photoperiod effects on nursery pig performance

Three experiments were conducted to evaluate sow and piglet productivity under extended photoperiod. In Exp. 1, 98 crossbred, lactating sows were housed in one of four treatments: thermoneutral air temperature (23.6 degrees C) in either (h of light:dark) 1:23 or 16:8 photoperiods, or heat stress (30.4 degrees C) in either 1:23 or 16:8 photoperiods. Heat stress reduced (P less than .05) sow feed intake, piglet mortality and piglet weaning weight and increased (P less than .01) sow lactation weight loss. Number of pigs weaned per litter was increased (P less than .01) when sows were heat-stressed. Extended photoperiod reduced (P greater than .05) time for sows to rebreed postweaning by .4 d. The interaction between air temperature and photoperiod was significant only for sow lactation weight loss. Heat stress increased sow lactation weight loss, but this effect was more severe in the 1:23 than in the 16:8 photoperiod. Experiments 2 and 3 examined the effects of 1:23 or 16:8 photoperiods on nursery pig performance when pigs were weaned from sows experiencing 1:23 (Exp. 3) or 16:8 (Exp. 2) photoperiods. In both nursery studies, photoperiod did not influence (P greater than .10) postweaning pig mortality, feed intake, weight gain or gain:feed ratio. In conclusion, extended photoperiod reduced days to return to estrus and reduced sow lactation weight loss, especially during heat stress. No benefits in preweaning or postweaning piglet weight or survival were observed by use of extended photoperiod.     

Effect of concentration and source of sulfate on nursery pig performance and health.

The effect of sulfate in drinking water at concentrations of 600, 1,200, and 1,800 mg/L on nursery pig performance and health was evaluated over 28 days on 415 weaned pigs. Sodium sulfate and magnesium sulfate were evaluated in combination at concentrations of 600, 1,200, and 1,800 mg/L, and independently at concentrations of 600 and 1,800 mg/L in the drinking water. Seven treatment groups and 1 control group were evaluated for mean gain, feed consumption, water consumption, feed conversion, prevalence of diarrhea, and evidence of common post-weaning enteric pathogens. Statistical analysis was performed, using analysis of variance with repeated measures including initial pig weight as a covariate. Prevalence of diarrhea was analyzed nonparametrically with a repeated measures design. Results indicated that pigs drinking 600, 1,200, or 1,800 mg of sulfate/L water had increased prevalence of nonpathogenic diarrhea during the trial period. There was a trend for increased water consumption corresponding to increased sulfate in the water. Differences in mean daily gain, feed consumption, or feed-to-gain ratios were not observed. Forty-five pigs were treated at least once during the trial and 4 pigs died, resulting in a nursery morbidity of 11% and mortality of 0.96%. Fourteen isolates of enterotoxigenic Escherichia coli were found and rotavirus was isolated from 1 pig. Pigs in this study were not exposed to transmissible gastroenteritis virus. Except for an increase in fecal moisture content (not associated with pathogenic diarrhea), concentrations of up to 1,800 mg of sodium, magnesium, or a combination of sodium and magnesium sulfate/L had no adverse effect on nursery pig performance.     

Farm factors associated with the use of antibiotics in pig production

The aim of this study was to investigate farm-level economic and technical factors that are associated with the use of antibiotics on pig farms. Identification of such factors, like farm size and net farm result, may help to increase epidemiological knowledge and to specify farm advice and policy making to reduce inappropriate use of antibiotics. The study used over 300 farm-year records collected during 2004 to 2007 from pig farms in the Netherlands. Data included economic and technical factors as well as antibiotic administration. Data were statistically analyzed for factors associated with antibiotic use, both for fattening pig and sow farms (piglets only), separately. The response variable was the average number of daily dosages per average pig year. Statistical analysis was performed on 16 and 19 potential explanatory factors for the fattening pig and sow farms, respectively. The results showed that, both on the fattening pig and sow farms, the average use of antibiotics increased from 2004 to 2006, but decreased during 2007, but the effect of year was not significant (P > 0.05). Use of antibiotics varied between individual farms. Large farm repeatability for the use of antibiotics in the different years was found. Factors associated (P < 0.05) with the use of antibiotics included: farm system, number of pigs, and population density in the region of the farm (for sow farms only). As these factors are easy to collect and to register, they can be used to specify farm advice and investigation, as well as for policy making. The majority of the technical and economic factors were not significantly (P > 0.05) related to the on-farm use of antibiotics. Therefore, it is recommended to focus future research on the potential role of socioeconomic factors associated with antibiotic use on pig farms.     

虎杖对保育猪生长性能和血液生化指标的影响

虎杖含有蒽醌类化合物和黄酮类多种活性成分,具有抗菌、抗氧化、降血脂等作用。本试验研究饲料中添加0、80 g/t虎杖对保育猪生长性能、腹泻率及免疫力的影响,以评估其对保育猪的作用。选择品种、胎次和日龄相近的40头(10.53±0.69)kg的杜长大三元保育猪,按完全随机设计法分为2组,分别为对照组和试验组,每组4个重复,每重复5头猪,饲养30 d。对照组饲喂基础日粮,试验组饲喂基础日粮+80 g/t虎杖。结果表明:与对照组相比,试验组(80 g/t)的平均日增重提高了8.35%,平均日采食量提高了9.43%,料肉比降低了0.60%(P0.05);腹泻率有所降低(P0.05);血液中白细胞(P0.05)、红细胞的数量较低(P0.05);这说明饲料中添加80 g/t的虎杖可提高保育猪的生长性能,降低保育猪的腹泻率,提高保育猪的免疫力。     

Effect of irradiation of individual feed ingredients and the complete diet on nursery pig performance

A total of 1,210 nursery pigs was used in two experiments to evaluate the effects of irradiation of typical nursery diet ingredients, specialty protein products, and the whole diet on nursery pig performance. In Exp. 1, 880 barrows and gilts (15 +/- 2 d of age at weaning) were used in two growth trials (14 d and 12 d for Trials 1 and 2, respectively) to determine the effects of individual ingredient and whole-diet irradiation on nursery pig performance. Overall (d 0 to 14 of Trial 1 and d 0 to 12 of Trial 2), ADG was greater (P < 0.05) for pigs fed irradiated animal plasma compared with pigs fed the control, the diet containing irradiated microingredients, and the diet that was manufactured and irradiated. Also, pigs fed irradiated soybean meal had greater (P < 0.05) ADFI compared with pigs fed the manufactured diet that was irradiated. Pigs fed the diet containing irradiated animal plasma had improved feed efficiency (G:F; P < 0.05) compared with those fed the diet with irradiated microingredients and when all ingredients were irradiated before manufacturing of complete feed. Finally, pigs fed irradiated corn, whey, fishmeal, soybean oil, microingredients, or if all ingredients or the whole diet were irradiated, had similar ADG, ADFI, and G:F (P > 0.12) to control pigs. In Exp. 2, 330 nursery pigs (20 +/- 2 d of age at weaning) were used to determine the effects of irradiation of commercially available specialty protein products in diets for nursery pigs. Overall, ADG was greater (P < 0.05) when pigs were fed diets containing nonirradiated spray-dried animal plasma and egg combination (SDAPE) and dried porcine digest (DPD) compared with pigs fed the control diet containing no specialty protein products. In addition, G:F was improved (P < 0.05) when pigs were fed diets containing nonirradiated SDAPE, DPD, spray-dried beef muscle (SDBM), and spray-dried whole egg (SDWE) compared with pigs fed the control diet. Pigs fed irradiated SDAPE and SDBM had greater (P < 0.05) ADG than pigs fed the nonirradiated forms. Pigs fed irradiated SDBM had improved (P < 0.05) G:F compared with pigs fed the nonirradiated form. In Exp. 1 and 2, an irradiation treatment level of 8.5 kGy was effective in reducing the total bacterial concentration of all ingredients evaluated, as well as the whole diet in Exp.1. Irradiation of certain ingredients, but not the complete diet, increased growth performance of nursery pigs.     

Effects of different heat treatments during processing of soybean meal on nursery and growing pig performance

Four soybean meals (SBM) were manufactured in a commercial solvent-extraction plant to give a much wider range in heat treatment than is usually found among commercially available SBM. The SBM were designated in ascending order of heat treatment as Under, Normal, Over and Rumen Escape. The nutritive value of the four meals was evaluated in a series of five feeding trials using 458 pigs: two performance and two diet preference trials with pigs weaned at 4 wk of age and one performance trial with growing pigs (17.4 kg initial weight were conducted). In both nursery and grower trials, there were no differences (P greater than .10) in performance of pigs fed the four meals. However, in the nursery trials, the severely heated meal (Rumen Escape) supported slightly lower gains (6.4%) and less desirable feed efficiency (3.5%) than the average of the other three meals. Growing pig performance was essentially the same for all meals. This suggests that older pigs either used the Rumen Escape meal more effectively than nursery pigs, or the Rumen Escape diet contained adequate digestible lysine for 17.4-kg pigs to grow optimally. In the preference studies, pigs selected between Normal- and Rumen Escape-supplemented diets. Pigs consumed 63 and 62% of the Normal diet in preference trials 1 and 2, but these differences were not significant (P greater than .10) due to the large variation among pens. These data suggest that the range of heat treatment normally found among commercially available SBM (Under, Normal and Over meals) has no effect on the nutritive value of the meal for swine.(ABSTRACT TRUNCATED AT 250 WORDS)     

Effect of pharmacological concentrations of zinc oxide with or without the inclusion of an antibacterial agent on nursery pig performance

A study involving nine research stations from the NCR-42 Swine Nutrition Committee used a total of 1,978 crossbred pigs to evaluate the effects of dietary ZnO concentrations with or without an antibacterial agent on postweaning pig performance. In Exp. 1, seven stations (IA, MI, MN, MO, NE, ND, and OH) evaluated the efficacy of ZnO when fed to nursery pigs at 0, 500, 1,000, 2,000, or 3,000 mg Zn/kg for a 28-d postweaning period. A randomized complete block experiment was conducted in 24 replicates using a total of 1,060 pigs. Pigs were bled at the 28-d period and plasma was analyzed for Zn and Cu. Because two stations weaned pigs at < 15 d (six replicates) and five stations at > 20 d (18 replicates) of age, the two sets of data were analyzed separately. The early-weaned pig group had greater (P < 0.05) gains, feed intakes, and gain:feed ratios for the 28-d postweaning period as dietary ZnO concentration increased. Later-weaned pigs also had increased (P < 0.01) gains and feed intakes as the dietary ZnO concentration increased. Responses for both weanling pig groups seemed to reach a plateau at 2,000 mg Zn/kg. Plasma Zn concentrations quadratically increased (P < 0.01) and plasma Cu concentrations quadratically decreased (P < 0.01) when ZnO concentrations were > 1,000 mg Zn/kg. Experiment 2 was conducted at seven stations (KY, MI, MO, NE, ND, OH, and OK) and evaluated the efficacy of an antibacterial agent (carbadox) in combination with added ZnO. The experiment was a 2 x 3 factorial arrangement in a randomized complete block design conducted in a total of 20 replicates. Carbadox was added at 0 or 55 mg/kg diet, and ZnO was added at 0, 1,500, or 3,000 mg Zn/ kg. A total of 918 pigs were weaned at an average 19.7 d of age. For the 28-d postweaning period, gains (P < 0.01), feed intakes (P < 0.05), and gain:feed ratios (P < 0.05) increased when dietary ZnO concentrations increased and when carbadox was added. These responses occurred in an additive manner. The results of these studies suggest that supplemental ZnO at 1,500 to 2,000 mg Zn/kg Zn improved postweaning pig performance, and its combination with an antibacterial agent resulted in additional performance improvements.     

Risk factors associated with Brachyspira hyodysenteriae PCR-positivity in East-European pig production units

The objective of the present study was to determine the risk factors for swine dysentery in East-European middle-to-large sized, farrow-to-finish units, with separate breeding and grower-finisher facilities. Samples of faeces from 10 breeding animals (3-10% of the female inventory) and 10 grower finisher pigs (80-140 days of age) were collected for polymerase chain reaction testing (PCR) for Brachyspira hyodysenteriae (B. hyo). Of 139 farrow-to-finish units, 51 (36.7%) were positive, 49 (35.3%) were negative, and 39 (28.1%) were inconclusive for B. hyo by PCR. In breeding subunits, twelve variables passed the screening criterion for risk factors (P < .2) for B. hyo PCR positivity. The odds of the breeding subunits being B. hyo PCR positive were 3.5 times greater when the grower-finisher subunit was positive and the fibre content of the diet was > 6%. Use of 'all-in-all-out' farrowing policy and having >60% multiparous sows each reduced the odds of being B. hyo PCR-positive by 4-fold. In grower-finisher subunits, fourteen variables passed the screening criterion for risk factors (P < .2) for B. hyo PCR positivity. B. hyo PCR-positive status of the breeding subunits and higher fibre content of the diet were the most influential variables, with the odds of the grower-finisher subunits being B. hyo PCR positive being almost 8 times greater when the breeding subunit was also B. hyo PCR positive. Grower-finisher B. hyo PCR positivity was also associated with the percentage of pigs housed on concrete slats, with the odds of being positive being 7.5-times higher for subunits where more that 70% of the animals were kept on concrete slats compared with all other floor types. There was a strong association between grower-finisher status and whether the animals were on outdoor lots, with the odds of being B. hyo PCR positive being substantially lower for pigs on outdoor lots compared with all other surfaces. IN CONCLUSION: All-in-all-out management in the breeding units, B. hyo negativity of adjacent grower-finisher units, high fibre content of the diet, and older parity structure in a sow herd may reduce the risk of swine dysentery. In grower-finisher units, slatted flooring is associated with a higher risk, while B. hyo negativity of the breeding units, the fibre content of the diet, and outdoor production are associated with lower risk of swine dysentery.     

Evaluating processing temperature and feeding value of extruded-expelled soybean meal on nursery and finishing pig growth performance

We conducted two experiments comparing the use of extruded-expelled soybean meal (EESoy) to solvent-extracted soybean meal (SBM) in swine diets. In Exp. 1, the objective was to determine the optimal processing temperature of EESoy for nursery pig growth performance. Pigs (n = 330, 13.2 +/- 2.3 kg of BW) were fed a control diet containing SBM with added fat or one of five diets containing EESoy extruded at 143.3, 148.9, 154.4, 160.0, or 165.6 degrees C. All diets were formulated on an equal apparent digestible lysine:ME ratio. From d 0 to 20, no differences were observed (P > 0.32) in ADG or ADFI (average of 544 and 924 g/d, respectively). However, gain:feed ratio (G/F) improved (quadratic, P < 0.01, range of 0.56 to 0.60) with increasing processing temperature, with the greatest improvement at 148.9 degrees C. In Exp. 2, the objective was to determine the feeding value of EESoy relative to SBM with or without added fat for growing-finishing pigs in a commercial production facility. A total of 1,200 gilts (initially 24.5 +/- 5.1 kg of BW) was used, with 25 pigs per pen and eight replications per treatment. Dietary treatments were arranged in a 2 x 3 factorial, with two sources of soybean meal (SBM or EESoy) and three levels of added fat. Pigs were phase-fed four diets over the experimental period and added fat (choice white grease) levels were 0, 3.4, and 7% initially, with the added fat levels decreasing in the next three dietary phases. Energy levels were based such that the higher energy in EESoy (with or without added fat) was calculated to be equal to that provided by SBM with added fat. From 24.5 to 61.2 kg, pigs fed EESoy had greater (P < 0.07) G/F than those fed SBM. Increasing added fat in either EESoy- or SBM-based diets increased G/F (linear, P < 0.0003). From 61.2 to 122.5 kg, ADG and G/F were unaffected in pigs fed EESoy and/or increasing added fat (P > 0.10). For the overall growing-finishing period, ADG was unaffected (P > 0.61) by increasing energy density of the diet; however, ADFI decreased (P < 0.05) and G/F increased (P < 0.02, range of 0.37 to 0.40) as energy density increased with either EESoy or added fat. Carcass leanness was not affected by dietary treatment. These results indicate that EESoy should be extruded at 148.9 to 154.4 degrees C, and that increasing dietary energy density by using EESoy and/or added fat improves feed efficiency in finishing pigs reared in a commercial environment.     

Evaluation of soy protein concentrates in nursery pig diets

Four experiments were conducted with 730 weanling pigs to determine the effects of soy protein concentrate (SPC) in diets for weanling pigs. Experimental diets were fed from d 0 to 14 postweaning and a common diet was fed from d 15 to 28 for Exp. 1, 2, and 3; experimental diets were fed from d 0 to 7 postweaning in Exp. 4. In Exp. 1, the 4 experimental diets included 1) a 0% soybean meal (SBM) diet containing animal protein sources; 2) a 40% SBM diet; or a 28.55% SPC (replacing the 40% SBM on a total Lys basis) diet from 3) source 1, or 4) source 2. Pigs fed diets containing either animal protein or 40% SBM had greater ADG and ADFI (P <0.05) than pigs fed either SPC source. In Exp. 2, the 5 experimental treatments included diets 2, 3, and 4 from Exp. 1, along with 14.28% SPC from each SPC source used in Exp. 1 (replacing half of the total Lys from the 40% SBM diet). From d 0 to 14 and d 0 to 28, the SPC source x level interaction was significant for ADG (P <0.01) and was a tendency for ADFI (P <0.07). Replacing SBM with SPC from source 1 did not affect pig performance. However, replacing SBM with SPC from source 2 resulted in an improvement (quadratic, P <0.05) in ADG for pigs fed the diet containing 14.3% SPC, but resulted in no benefit from replacing all the SBM with SPC. Replacing SBM with SPC from either source improved G:F (quadratic, P <0.01), with the greatest G:F observed for pigs fed the diets with 14.3% SPC. Experiment 3 evaluated increasing levels of source 2 SPC, with treatments consisting of 1) 0% (40% SBM); 2) 7.14%; 3) 14.28%; 4) 21.42%; and 5) 28.55% SPC. There was a tendency for increased ADG (quadratic, P <0.06) and increased ADFI (quadratic, P <0.04) as inclusion of SPC in the diet increased. The gain-to-feed ratio improved (linear, P <0.01) as the SPC level in the diet increased. Inclusion of approximately 14 to 21% SPC from source 2 maximized pig performance. In Exp. 4, pigs were offered a choice of consuming the diets containing 40% SBM or 28.6% SPC from source 2. Daily feed intake was greater (P <0.0001) for the SBM diet (186 g/d) than for the SPC diet (5 g/d). Our results suggest that replacing a portion, but not all, of the high-SBM diet with SPC from source 2, but not from source 1, improves pig performance. The poor intake of pigs fed high levels of SPC may indicate a palatability problem, thus limiting its inclusion in nursery pig diets.     

Farm-level factors associated with above-average production on pig farms in Evia, Greece

The aim of this study was to identify farm-level factors associated with above-average production of pig farms in Evia, Greece. Cross-sectional data on pig farm characteristics and management, farmer characteristics, worming practices, anthelmintics used, and the parasite loads of 10 randomly selected boars, sows, weaners, and fatteners were collected from 28 pig enterprises in the Evian region of Greece (74% of the total number of pig enterprises in this region). Above-average productivity was defined as weaning 18 or more piglets per sow per year. A multivariate logistic regression model found that employing immigrant workers reduced the odds of a farm being an above-average producer (OR 0.016, 95% CI 0.001–0.27), while having a veterinarian select the anthelmintic strategy significantly increased the odds of a farm being an above-average producer (OR 10.24, 95% CI 0.78–135.13). None of the gastrointestinal parasites under investigation were significantly associated with above-average productivity. It is concluded that despite the fact that endoparasite load was not significantly associated with above-average production, a quantification of the impact of intestinal worms on pig productivity is needed to know how much control can be envisaged for gastrointestinal worms before reaching the threshold at which it is no longer physically or financially reasonable to continue pursuing control.     

Evaluation of methods to reduce bacteria concentrations in spray-dried animal plasma and its effects on nursery pig performance

Four experiments with 1,040 weanling pigs (17 +/- 2 d of age at weaning) were conducted to evaluate the effects of spray-dried animal plasma source, drying technique, and methods of bacterial reduction on nursery pig performance. In Exp. 1, 180 barrows and gilts (initial BW 5.9 +/- 1.8 kg) were used to compare effects of animal plasma, animal plasma source, drying technique (spray-dried or freeze-dried), and plasma irradiation in nursery pig diets. From d 0 to 10, pigs fed diets containing irradiated spray-dried animal plasma had increased ADG and ADFI (P < 0.05) compared with pigs fed diets containing nonirradiated spray-dried animal plasma. Pigs fed irradiated animal plasma Sources 1 and 2 were similar in ADG and ADFI, but pigs fed animal plasma Source 1 had greater ADG (P < 0.05) than pigs fed animal plasma Source 2 and pigs not fed plasma. Pigs fed freeze-dried animal plasma had growth performance similar (P > 0.36) to pigs fed spray-dried animal plasma. Overall (d 0 to 24), pigs fed irradiated spray-dried animal plasma were heavier (P < 0.05) than pigs fed no animal plasma, whereas pigs fed nonirradiated spray-dried plasma were intermediate. In Exp. 2, 325 barrows and gilts (initial BW 5.8 +/- 1.7 kg) were used to compare the effects of irradiation or formaldehyde treatment of animal plasma and formaldehyde treatment of the whole diet. Pigs fed diets containing irradiated animal plasma had greater ADG (P < 0.05) than pigs fed nonirradiated plasma. Pigs fed formaldehyde-treated plasma had greater ADG and ADFI (P < 0.05) than pigs fed diets with either nonirradiated plasma or whole diet treated with formaldehyde. In Exp. 3 (360 barrows and gilts; initial BW 6.3 +/- 2.7 kg) and Exp. 4 (175 barrows and gilts; initial BW 6.1 +/- 1.7 kg), the irradiation of feed (high bacteria) and food-grade (low bacteria) animal plasma in nursery pig diets was examined. Pigs fed irradiated feed-grade plasma Product 2 had increased ADG (P < 0.05) compared with pigs fed nonirradiated plasma Product 2 and pigs fed the control diet without plasma. In Exp. 3 and 4, pigs fed irradiated food-grade plasma had growth performance similar to pigs fed nonirradiated food-grade plasma (P > 0.12). These studies indicate that bacterial reduction of feed-grade, but not food-grade animal plasma, improves nursery pig performance.     

Description of risk factors associated with the detection of BVDV antibodies in Brazilian pig herds

Bovine viral diarrhea virus (BVDV) infects ruminants as primary hosts. However, other animals like pigs are susceptible. This study was conducted to investigate seroprevalence and risk factors associated with the detection of BVDV antibodies in pig herds. A total of 1.705 serum samples of 33 finisher herds, from seven Brazilian states, were collected in slaughterhouses. The samples were tested by virus neutralization (VN) test. In total, 5.35% (91/1.705) were positive and 64% (21/33) of the herds had positive animals. A significant association with “trucks are not cleaned and disinfected” and “visitors do not respect 72-h interval between visits to farms” (P?<?0.05) was found in association with detection of BVDV-2 antibodies. This study suggests that important biosecurity gaps are present in Brazilian pig farms, as the presence of BVDV antibodies in pigs suggests (direct or indirect) contact with population(s) of ruminant species. Closing biosecurity gaps prevents spread of BVDV and other pathogens such as foot-and-mouth disease virus (FMDV) between pig and ruminant farms. This data should be taken in account by CSF surveillance programs, once cross-reaction in serologic tests between classical swine fever virus (CSFV) and BVDV antibodies has been shown to occur.