Prevention of hydrolytic rancidity in rice bran during storage.

The effect of microwave heating, packaging, and storage temperature on the production of free fatty acids (FFA) in rice bran was examined. Freshly milled raw rice bran was adjusted to 21% moisture content and heated in a microwave oven at 850 W for 3 min. Raw and microwave-heated rice bran were packed in zipper-top bags or vacuum-sealed bags and stored at 4-5 or 25 degrees C for 16 weeks. FFA content of bran was measured at 4-week intervals. Total FFA increased rapidly over the 16-week period from the initial value of 2.5% in raw bran stored at 25 degrees C to 54.9% in vacuum bags and 48.1% in zipper-top bags. However, total FFA of raw bran stored at 4-5 degrees C increased at a slower rate from an initial value of 2. 5 to 25.4% in vacuum bags and 19.5% in zipper-top bags. After 16 weeks of storage, total FFA of microwave-heated bran stored at 25 degrees C increased from 2.8 to 6.9 and 5.2%, respectively, for samples stored in vacuum bags and zipper-top bags. Total FFA of microwave-heated samples stored at 4-5 degrees C did not change significantly with storage time. Results showed that hydrolytic rancidity of rice bran can be prevented by microwave heating and that the recommended storage condition for microwaved rice bran is 4-5 degrees C in zipper-top bags.     

Degradation of malathion, in aqueous extracts of asparagus (Asparagus officinalis)

Malathion was incubated in water extracts of vegetables at various temperatures and pH, and the amount of malathion present over time was analyzed by a gas chromatograph with a flame photometric detector. Malathion was degraded to a nondetectable level in a 1% asparagus extract incubated at pH 7.4 and 37 degrees C for 4 h. Carrot extract showed the second highest rate of malathion degradation (76%), followed by kale extract (23.7%), spinach extract (9.7%), and broccoli extract (1.5%) under the same conditions. The highest degradation rates of malathion were observed at 37 degrees C, when three different temperatures were tested (5, 25, and 37 degrees C) at pH 7.4. Rate constants were 0.134 min(-)(1) from a 1% asparagus solution and 0.095 min(-)(1) from a 0.5% asparagus solution. The highest degradation rate of malathion was achieved at pH 9 among the pHs tested (pH 4, 7.4, and 9) in a 0.5% asparagus solution. The 0.5% asparagus solution degraded dicarboxylic acid esters by almost 100% for dimethyl succinate and diethyl adipate, by 64% for diethyl acetyl succinate, and 30% for diethyl benzyl malonate when incubated at pH 9 for 20 min. The results support the hypothesis that the enzyme that degrades malathion in the asparagus solutions is a carboxylesterase.     

Effects of microwave heat, packaging, and storage temperature on fatty acid and proximate compositions in rice bran

The effect of microwave heat, packaging methods, and storage temperatures on proximate and fatty acid compositions of rice bran during 16 weeks of storage was examined. Freshly milled raw rice bran was adjusted to 21% moisture content and microwave heated for 3 min. Raw and microwave-heated brans were packed in zipper-top bags and/or vacuum-sealed bags and stored at 4-5 and/or 25 degrees C for 16 weeks. The moisture content decreased significantly from an initial 8.4 to 6.4% in microwave-heated samples regardless of packaging methods and storage temperatures. Protein, fat, linoleic, and linolenic contents did not change significantly in all raw and microwave-heated samples during 16 weeks of storage. The microwave-heated rice bran packed in zipper-top bags can be stored at 4-5 degrees C for up to 16 weeks without adverse effect on proximate and fatty acid composition quality under the conditions employed in this study.     

Effect of different treatments on the evolution of polyamines during refrigerated storage of eggplants

The applicability of a thermal treatment was compared with modified-atmosphere (MA) storage in relation to chilling injury (CI) and polyamines evolution in eggplants. Fruits underwent physiological disorders at 3 degrees C, evidenced by the appearance of surface injuries at the third day of storage, and, after moving the fruits to 20 degrees C, by increased respiratory activity and more intense ethylene production. Storage of fruits in sealed low-density polyethylene bags and a previous treatment with heated air (1 h at 35 degrees C) were both effective in retarding chilling injury, though the former was better. Two free polyamines were found in cv. Black Nite: putrescine, in greater proportion, and spermidine. Putrescine increased in control (untreated) fruits stored at 3 degrees C in parallel with the external appearance of chilling injury, whereas this increase was either not exhibited or retarded in treated or MA stored fruits. Spermidine did not change in control fruits at 3 degrees C, remaining almost constant over the whole storage period, whereas in heat- and MAP-treated fruits spermidine levels exhibited a decrease.     

Changes of folates, dietary fiber, and proteins in wheat as affected by germination

Wheat kernels of the cultivar 'Tommi' were germinated for up to 168 h at 15, 20, 25, or 30 degrees C. Samples were taken at different stages of germination and were analyzed for the quantitative protein composition using an extraction/HPLC method, for folate vitamers using a stable isotope dilution assay, and for soluble, insoluble, and total dietary fiber using a gravimetric method. Gluten proteins were substantially degraded during germination. During the first stages of germination the degradation of glutenins was predominant, whereas longer germination times were required to degrade gliadins. The optimal temperature for gliadin degradation was 20 degrees C, and that for glutenin degradation was 25 degrees C. Omega5- and omega1,2-gliadins were less sensitive to proteolytic degradation than alpha- and gamma-gliadins, and LMW subunits of glutenin were less sensitive than HMW subunits. During germination a time- and temperature-dependent increase of total folate occurred. A maximum 3.6-fold concentration was obtained after 102 h of germination at 20 and 25 degrees C including 5-methyltetrafolate as the major vitamer. The concentration of dietary fiber remained constant or decreased during the first 96 h of germination. Prolonged germination times of up to 168 h led to a substantial increase of total dietary fiber and to a strong increase of the soluble dietary fiber by a factor of 3, whereas the insoluble fiber decreased by 50%.     

Effect of storage on wall-bound phenolics in green asparagus

The cell walls of green asparagus spears have been analyzed for their phenolic and carbohydrate composition as modified by postharvest storage. Esterified phenolic components were released by sequential alkaline hydrolysis and identified and quantified by diode array HPLC. Significant quantities of ferulic acid (FA) and its derivatives were found to increase at least 3-fold during storage, particularly in walls from the lower parts of the stem, where accompanying changes in sugar composition were also observed. In fresh asparagus, >60% of the total FA was in the form of diferulic acid, and this increased to approximately 70% after 3 days of storage. The main FA dehydrodimers were 8-8-, 8-O-4-, and 8-5-diferulates. These have been detected in other monocotyledonous and dicotyledonous plants, but as a smaller proportion of the total FA. The possible roles phenolic esters might have in relation to the mechanical, textural, and wound-response properties of asparagus spears are discussed.     

Prevention of oxidative rancidity in rice bran during storage.

The effect of microwave heat on lipoxygenase (LOX) activity in rice bran under various storage conditions was examined. Raw rice bran from the long-grain variety Lemont was adjusted to 21% moisture content and heated in a microwave oven at 850 W for 3 min. Raw and microwave-heated rice bran samples were packed in zipper-top bags or vacuum packs and stored at room temperature (25 degrees C) or in the refrigerator (4-5 degrees C) for 16 weeks. Samples were analyzed for LOX activity at 4-week intervals. LOX activity did not significantly change from its initial value at week 0 for zipper-top and vacuum-packed samples while stored at 4-5 degrees C for 12 weeks, but decreased at week 16. Vacuum packing did not show a significant impact on LOX activity during 16 weeks of storage. Microwave-heated samples stored in the refrigerator did not show significant change in LOX activity for up to 12 weeks but showed a significant (p < 0. 05) decrease at 16 weeks. Results showed that oxidative rancidity of rice bran could be prevented by microwave heating the samples, packing in zipper-top bags, and storing at 4-5 degrees C for up to 16 weeks.     

The effect of post-harvest and packaging treatments on glucoraphanin concentration in broccoli (Brassica oleracea var. italica)

The effects of post-harvest and packaging treatments on glucoraphanin (4-methylsulfinylbutyl glucosinolate), the glucosinolate precursor of anticancer isothiocyanate sulforaphane [4-methylsulfinylbutyl isothiocyanate], were examined in broccoli (Brassica oleracea var. italica) during storage times. The results showed that at 20 degrees C, 55% loss of glucoraphanin concentration occurred in broccoli stored in open boxes during the first 3 days of the treatment and 56% loss was found in broccoli stored in plastic bags by day 7. Under both air and controlled atmosphere (CA) storage, glucoraphanin concentration appeared to fluctuate slightly during 25 days of storage and the concentrations under CA was significantly higher than those stored under air treatment. In modified atmosphere packaging (MAP) treatments, glucoraphanin concentration in air control packaging decreased significantly whereas there were no significant changes in glucoraphanin concentration in MAP with no holes at 4 degrees C and two microholes at 20 degrees C for up to 10 days. Decreases in glucoraphanin concentration occurred when the broccoli heads deteriorated. In the present study, the best method for preserving glucoraphanin concentration in broccoli heads after harvest was storage of broccoli in MAP and refrigeration at 4 degrees C. This condition maintained the glucoraphanin concentration for at least 10 days and also maintained the visual quality of the broccoli heads.     

Influence of temperature, modified atmosphere packaging, and heat treatment on aroma compounds in broccoli

The aroma compounds in broccoli stored in different modified atmospheres were studied. The packaging materials used were oriented polypropylene (OPP), poly(vinyl chloride) (PVC), and low-density polyethylene (LDPE) containing an ethylene-absorbing sachet. All samples were stored for either 1 week at a constant temperature of 10 degrees C or for 3 days at 4 degrees C, followed by 4 days at 10 degrees C. The atmospheres that developed inside the packaging materials differed significantly. The broccoli samples were analyzed raw and after cooking, with regard to volatile compounds, using gas-phase (headspace) extraction followed by gas chromatography-mass spectrometry (GC-MS) and GC-olfactometry. Dimethyl sulfide (DMS), dimethyl disulfide (DMDS), dimethyl trisulfide (DMTS), hexanal, 3-cis-hexen-1-ol, nonanal, ethanol, and a group of thiocyanates were selected for a detailed study because these compounds cause off-odor and can be used as indicators of stress. Significant differences were found in the aroma profiles of the broccoli samples relative to the packaging materials used for storage. Storage in OPP (14% O(2), 10.5% CO(2)) resulted in most of the off-odors, while storage in LDPE (6% O(2), 7% CO(2)) and PVC (17.9% O(2), 4% CO(2)) was found to maintain the concentration of DMS, DMDS, and DMTS during storage. Heat treatment of the broccoli increased the content of aroma compounds as well as the number of compounds containing sulfur.     

Flavonoids in baby spinach (Spinacia oleracea L.): changes during plant growth and storage

The variation in flavonoid concentration and composition was investigated in baby spinach (Spinacia oleracea L.) cv. Emilia sown on three occasions, each harvested at three growth stages at 6-day intervals. After harvest, leaves were stored in polypropylene bags at 2 or 10 degrees C. Flavonoids were analyzed by reversed phase HPLC. Twelve flavonoid peaks were detected. The main flavonoid, making up on average 43% of the total flavonoid concentration, was identified as 5,3',4'-trihydroxy-3-methoxy-6:7-methylenedioxyflavone-4'-glucuronide. Four other flavonoids each contributed 7-12% of the total flavonoid content. Total flavonoid content was relatively stable during normal retail storage conditions, although some of the individual flavonoid compounds showed considerable variation. The youngest plants had the highest flavonoid concentration, indicating that by harvesting the baby spinach a few days earlier than the current commercial stage of harvest, the flavonoid concentration in the product may be increased and the content of potentially health-promoting compounds enhanced.     

Warm water treatment in combination with modified atmosphere packaging reduces undesirable effects of irradiation on the quality of fresh-cut iceberg lettuce

Fresh-cut iceberg lettuce dipped in either 5 or 47 degrees C water for 2 min was packaged in modified atmosphere film bags and then exposed to 0, 0.5, 1, or 2 kGy gamma-radiation. Dipping cut lettuce in 47 degrees C water for 2 min prior to irradiation reduced antioxidant and phenolic accumulations induced by irradiation. Irradiation at 2 kGy increased cellular leakage and sogginess of cut lettuce dipped in both temperatures. Samples irradiated at 0.5 and 1 kGy had similar firmness and vitamin C and antioxidant contents as the controls after 14 and 21 days of storage except 1 kGy samples dipped at 47 degrees C had lower antioxidant contents than controls at 14 days of storage. Lettuce dipped at 47 degrees C and irradiated at 0.5 and 1 kGy had better overall visual quality and less tissue browning than corresponding irradiated samples dipped at 5 degrees C. These results suggest lettuce treated with warm water and irradiated at 0.5 or 1 kGy had the best sensory quality without significant loss in texture, vitamin C, or total antioxidants.     

Determination of water-insoluble cell walls in feeds: interlaboratory study

A collaborative study was conducted to test a new rapid procedure for determination of water-insoluble cell wall (WICW) content in feeds. In the method, starch is solubilized near boiling temperature with Termamyl, a heat-stable alpha-amylase, and proteins are solubilized at 40 degrees C with sodium dodecylsulfate and Pronase. Then, the organic matter of the residue is determined by incineration. Three hours were required to treat 12 different samples, including solubilization treatments, filtrations, and rinses. Eleven unknown products including 9 common feedstuffs of various origin and 2 mixed diets for poultry were analyzed by 7 analysts in France. Coefficients of variation ranged from 2.3 to 6.1%. The results were compared to those for water-insoluble dietary fiber (WIDF), total dietary fiber, and neutral detergent fiber. Agreement was best with the water-insoluble dietary fiber procedure. For most samples, the ratios of WIDF/WICW ranged from 0.981 to 0.842. The differences between WICW and WIDF values correspond to cell wall protein which is accounted for in WICW, but not in WIDF.     

气调处理对绿芦笋抗氧化及抗病酶活性的影响

为探讨气调处理对绿芦笋抗氧化和抗病性相关酶活性的影响,以空气为对照(CK),在15±1℃和相对湿度为90%~95%的贮藏条件下,研究5种不同比例气体成分[CA1(5%CO_2+1.5%O_2)、CA2(7%CO_2+0%O_2)、CA3(7%CO_2+1.5%O_2)、CA4(7%CO_2+3.5%O_2)、CA5(9%CO_2+1.5%O_2)]对达宝利绿芦笋采后感官品质、菌落总数、相对电导率、丙二醛(MDA)含量、总酚含量、二苯基苦基苯肼(DPPH)清除率、羟自由基(·OH)清除率以及超氧化物歧化酶(SOD)、过氧化氢酶(CAT)、过氧化物酶(POD)、多酚氧化酶(PPO)、苯丙氨酸解氨酶(PAL)活性的影响。结果表明,气调处理不同程度抑制了芦笋根部的腐烂,延缓了其菌落总数、相对电导率和MDA含量的上升,维持其较高的总酚含量、DPPH清除率、·OH清除率以及SOD、CAT、PPO活性,减缓了其POD活性上升,并保持了组织较低的PAL活性,所有气调处理中以CA3效果较好。此外,以绿芦笋根部开始出现腐烂为标准,CK、CA1、CA2、CA4、CA5和CA3的贮藏期分别为1、2、2、2、4和5 d。因此,CA3(7%CO_2+1.5%O_2)的气调处理可维持达宝利绿芦笋采后较好品质。本研究结果为绿芦笋的贮藏保鲜提供了理论依据及技术支持。     

Phytoextraction of Cd and Pb and physiological effects in potato plants (Solanum tuberosum var. Spunta): importance of root temperature.

Three consecutive years of field experiments were carried out to investigate the effect of different root-zone temperatures, induced by the application of mulches, on the concentration and accumulation of Cd and Pb and on bioindicators (chlorophylls, catalase, peroxidase and cell wall fractions) in different organs of potato plants (roots, tubers, stems, and leaflets). Four different plastic covers were employed (T1, transparent polyethylene; T2, white polyethylene; T3, white and black coextruded polyethylene, and T4, black polyethylene), using uncovered plants as the control (T0). The different treatments had a significant effect on the mean root-zone temperatures (T0 = 16 degrees C, T1 = 20 degrees C, T2 = 23 degrees C, T3 = 27 degrees C, and T4 = 30 degrees C) and induced significantly different responses in the Cd and Pb concentrations and phytoaccumulation, with T2 (23 degrees C) and T3 (27 degrees C) giving high concentrations of Cd in the roots and low concentrations in other organs. In relation to Pb, T2 and T3 reached higher levels in the tubers and lower levels in the roots, stems, and leaves. In terms of phytoaccumulation, the roots and tubers were the most effective organs for Cd and Pb. On the other hand, the highest values of peroxidase and catalase activities were obtained for T3. In addition, most of the carbohydrate fractions in both the roots and the tubers were highest for T3. Meanwhile, the lowest pigment values were registered for T1 (20 degrees C). For phytoremediation, it is necessary to ascertain the relevance and control of the thermal regime of the soil to optimize the phytoextraction of pollutant elements (Cd and Pb).     

Characterization of nonstarch polysaccharides content from different edible organs of some vegetables, determined by GC and HPLC: comparative study

Content and composition of dietary fiber as nonstarch polysaccharides (NSP) was determined in vegetables belonging to different types of edible organs, using GC and HPLC. Samples analyzed were subterranean organs (radish and leek), leaves (celery, swiss chard, and lettuce), stalks (celery, swiss chard, and asparagus), inflorescence (broccoli), and fruits (tomato, green pepper, and marrow). The results indicate that though the monomeric profile is similar in all these samples quantitative differences were found for neutral sugars and uronic acids among samples of the same type of vegetal organ. The NSP values determined using CG method were in good agreement with HPLC method (R(2) = 0.9005). However, arabinose, mannose, and galactose plus rhamnose are more influenced by the analytical method used than the rest of the monomers in nearly all the samples analyzed. Final values of NSP depend on the method used in celery stalks, broccoli, and green pepper.     

Microbial inactivation of paprika by a high-temperature short-X time treatment. Influence on color properties

High-temperature short-time (HTST) treatments have been used to destroy the bioburden of paprika. With this in mind, we have designed a device to treat samples of paprika with a gas whose temperature, pressure, and composition can be selected. Temperatures and treatment times ranged from 130 to 170 degrees C and 4 to 6 s, respectively. The survival of the most commonly found microorganisms in paprika and any alteration in extractable and superficial color were examined. Data showed that the optimum HTST conditions were 145 degrees C, 1.5 kg/cm2 of overpressure, 6 s operation time, and a thermal fluid of saturated steam. No microbial growth was detected during storage after thermal treatment. To minimize the color losses, treated (HTST) paprika samples should be kept under refrigeration.     

Effect of storage temperature on the degradation of dimethoate in fortified orange and peach juices

The effect of storage temperature on dimethoate degradation in fortified orange and peach juices was studied. The insecticide was aseptically injected into packed orange and peach juices and stored at 40, 15, and 0 degrees C. Samples were taken at regular time intervals and were examined for dimethoate residues. The residues were determined with a simple gas chromatographic method; the recoveries of dimethoate from orange and peach juices were found to be from 88 to 114% for both products. The limits of determination were 0.004 and 0.003 mg/kg, respectively. From the experimental data, rate constants, half-lives, and activation energies for the decomposition of dimethoate in orange and peach juices were evaluated. During the storage of fruit juices in refrigerated rooms (0 degrees C) half-lives of dimethoate were found to be largely extended, being 1733 days for orange juice and 2310 days for peach juice. Corresponding times for storage at 15 degrees C were 533 days for both juices and for storage at 40 degrees C 24 days for orange juice and 24.6 days for peach juice. The activation energy for dimethoate in orange juice was 22.3 kcal/mol and for peach juice, 21. 2 kcal/mol.     

Characterization of Dietary Fiber Polysaccharides from Dehulled Common Buckwheat (Fagopyrum esculentum) Seeds

Buckwheat is a pseudocereal that has gained increasing interest of industry and consumers over the past decade. Little, however, is known about its dietary fiber composition and nonstarch polysaccharide structures. Analysis of the monosaccharide composition indicated large amounts of pectic polysaccharides in both insoluble and soluble fiber from buckwheat. Methylation analysis gave further insights into the structures of the polysaccharides. The corresponding partially methylated alditol acetates suggested only low amounts of galactans. Xyloglucans were the main hemicellulosic polysaccharides in the insoluble fiber fraction. Highly branched arabinans, exclusively substituted at position O3, were of higher abundance. These results were confirmed by screening endo‐arabinanase and endo‐galactanase liberated oligosaccharides with high‐performance anion‐exchange chromatography with pulsed amperometric detection and LC‐MS². Application of this method also demonstrated highly branched arabinan areas within the pectic polysaccharides. Only low amounts of fiber associated hydroxycinnamic acids and diferulic acids were liberated by alkaline treatment, and no evidence was found for their attachment to polysaccharides, suggesting only a minor impact of these structural elements on fiber structures in dehulled buckwheat seeds.     

Flavor, color, and vitamin C retention of pulsed electric field processed orange juice in different packaging materials

Effects of packaging materials, storage temperature, and time on the stability of pulsed electric field (PEF) processed orange juice were investigated. Single-strength orange juice was treated with PEF at an electric field strength of 35 kV/cm for 59 micros using an integrated pilot plant scale PEF processing and glovebox packaging system. The retention of eight orange juice aroma compounds, color, and vitamin C in glass, polyethylene terephthalate (PET), high-density polyethylene, and low-density polyethylene were evaluated at 4 and 22 degrees C for 112 days. Packaging material had a significant effect (p < or = 0.05) on the retention of orange juice aroma compounds, color, and vitamin C. PEF-treated orange juice had a shelf life of >16 weeks in glass and PET at 4 degrees C.