Digestibility of nitrogen and amino acids in soybean meal with added soyhulls

This study was designed to quantify the effect of soyhulls on N and AA digestibilities of soybean meal for growing pigs. Soyhulls were incorporated into 17% CP diets containing 33.25% soybean meal (SBM) at 0, 3, 6, or 9% (as-fed basis) and fed to 35-kg barrows to determine their effect on apparent and true digestibility of DM, GE, N, and AA measured at the terminal ileum. Positive and negative control diets containing 1.05% lysine were formulated with 35% SBM and 27% soy protein concentrate (SPC), respectively. A low-protein, casein-based diet was used to estimate endogenous AA losses. Soyhulls were incorporated into experimental diets at the expense of cornstarch, and SBM levels were adjusted to accommodate the contribution of CP from soyhulls. Fourteen pigs were surgically fitted with simple T-cannula at the distal ileum and fed the seven semipurified cornstarch diets based on a replicated 7 x 7 Latin square design. Each period lasted 7 d, with diet acclimation from d 1 to 5 and ileal sample collection for 12 h on d 6 and 7. Feed was offered at a level of 90 g/kg BW(0.75) in two equal portions at 0800 and 2000. Apparent ileal digestibilities of DM and GE decreased approximately six percentage units with the addition of soyhulls (linear, P < 0.05), whereas N was not affected. Both apparent and true ileal digestibilities of arginine, histidine, lysine, phenylalanine, aspartic acid, serine, and tyrosine also exhibited a decrease (linear, P < 0.05) of up to five percentage units with the addition of soyhulls. True ileal lysine digestibility of SBM decreased from 90.3 to 87.7% with the addition of 9% soyhulls. The endogenous nutrient fraction measured at the distal ileum was rich in proline, glutamic acid, and glycine, with losses greater than 1,000 mg/kg of DMI for each AA, and contained minimal amounts of tryptophan, methionine, and cystine. The current data suggest that a 0.2% decrease in some true ileal indispensable AA digestibilities may result with each 1% increase in soyhull inclusion in semipurified diets containing SBM as the sole source of AA as fed to growing pigs.     

Effect of feed intake on endogenous losses and amino acid and energy digestibility by growing pigs

An experiment was conducted to determine the effect of feed intake (FI) on endogenous losses and the digestibility of CP and AA by growing pigs. Six growing barrows (initial BW = 70.3 kg) had a T-cannula installed in the distal ileum and were used in a 6 x 6 Latin square design. A soybean meal cornstarch-based diet and a N-free diet were formulated. Chromic oxide (0.25%; as-fed basis) was included in both diets as an inert marker. Each diet was provided at three different levels of FI. Feed intake level 1 was equal to the estimated energy requirement for maintenance of the pigs, whereas levels 2 and 3 were two or three times this amount, respectively. Each experimental period lasted 7 d. The initial 4 d of each period comprised an adaptation period to the experimental diets. On d 5, fecal samples were collected, while ileal digesta were collected during two 10-h periods on d 6 and 7. Between each experimental period, a corn-soybean meal-based diet (16% CP) was fed to all pigs for 7 d. The basal ileal endogenous losses (IAA(end)) of CP and AA were measured for each level of FI from pigs fed the N-free diet. Likewise, the apparent (AID) and standardized (SID) ileal digestibility coefficients for CP and AA in soybean meal were calculated for each level of FI. The total-tract digestibility coefficient of energy in the soybean meal-based diet also was calculated. The AID for CP and all indispensable AA except Lys, Met, and Thr increased (P < or =0.055) as FI increased. The IAA(end) of CP and all AA except Pro decreased linearly (P < 0.05) as FI increased when expressed as g/kg of DMI; however, the total daily IAA(end) increased as FI increased (linear, P < or =0.056) for all AA, except for Phe, Thr, Trp, Val, Cys, Gly, and Ser. The AA composition (% of CP) of endogenous protein was not affected by the level of FI, except for Arg, Thr, Pro, and Ser. As FI increased, the SID decreased linearly (P < 0.04) for CP and all AA, except Arg, Trp, Asp, Pro, and Tyr. The total-tract digestibility of energy was not influenced by the FI level. These results demonstrate that the FI level significantly influenced AID, SID, and IAA(end) for CP and AA. Therefore, pigs used to measure AA digestibility coefficients and IAA(end) should be fed at a level that is close to what is used under commercial conditions.     

Effect of common antinutritive factors and fibrous feedstuffs in pig diets on amino acid digestibilities with special emphasis on threonine

Most feedstuffs contain antinutritive factors (ANF) such as insoluble fibers, lignins, tannins, and lectins. Intake of these ANF has the ability to reduce nutrient digestibility and to increase endogenous protein losses, such as through increased intestinal mucus secretion. The objective of this experiment was to determine the apparent ileal digestibilities (AID) of AA of 6 ANF-enriched diets to estimate endogenous protein loss associated with these ingredients in diets for young pigs. Forty-two 10-kg BW pigs fitted with a simple T-cannula at the distal ileum were randomly assigned to 1 of 7 casein-based diets with: no supplement (control), 100 g/kg of canola meal (CM), 100 g/kg of wheat bran (WB), 150 g/kg of barley (BR), 22.5 g/kg of lignin (LG), 15 g/kg of kidney beans [as a lectin (LE) source], and 15 g/kg of tannins (TN). All diets were formulated to be similar in N, indispensable AA, and caloric contents. After a 7-d adaptation to the test diets, N balance was conducted for 5 d, followed by 24 h of collection of digesta for analyses of AA. Pigs fed BR had 17% lower ADG and 15% lower feed conversion ratio (P < 0.05) compared with control and CM pigs. Pigs fed diets containing WB and BR had lower N retention as a percentage of absorbed N compared with all other groups (P = 0.03). The AID for CP was lower in BR, WB, and LE pigs compared with control. Of the AA, AID of Thr was notably lowest in BR, WB, and TN pigs (P < 0.05). The standardized ileal digestibility was lower in WB and BR pigs for most indispensable AA. Altogether, these data suggest that hemicellulose fiber, at concentrations typical in commercial swine diets, reduces AID of AA by increasing endogenous losses. Understanding the differential effects of ANF on endogenous losses of individual dietary AA will improve the accuracy of diet formulation.     

Determination of true ileal amino acid digestibility and the endogenous amino acid outputs associated with barley samples for growing-finishing pigs by the regression analysis technique

This study was conducted to determine true ileal AA digestibility coefficients and the endogenous AA outputs associated with barley samples for growing-finishing pigs using the regression analysis technique with dual digestibility markers. Six barrows, with 30.5 and 58.6 kg average initial and final BW, were fitted with a simple T-cannula at the distal ileum and fed six barley-based diets at close to ad libitum feed intake according to a 6 x 6 Latin square design. The six diets contained 97% of six barley samples varying from low to high in CP and AA contents (8.5, 9.2, 9.8, 11.5, 12.6, and 15.6% CP, respectively, on DM basis). The dietary NDF content ranged from 16.8 to 23.8% on DM basis. Chromic oxide (Cr2O3) and acid-insoluble ash (AIA) were used as digestibility markers. Each experimental period lasted 7 d. Ileal digesta were collected, at 2-h intervals, for a total of 24 h during d 6 and 7. There were linear relationships (P < 0.01) between dietary contents of apparent ileally digestible and total CP and AA as determined by using either Cr2O3 or AIA as a digestibility marker. The use of Cr2O3 vs AIA affected (P < 0.01) the determination of true ileal AA digestibility coefficients and the endogenous CP and AA outputs. However, there were no differences (P > 0.01) in the true ileal AA digestibility coefficients in barley samples between this study and the average values reported in the literature. The endogenous CP and AA outputs determined in this study were higher (P < 0.01) than reported values (35.1+/-3.0 vs 14.7+/-1.1 g CP/kg DMI). It is concluded that dual digestibility markers should be used to measure true ileal AA digestibility coefficients and endogenous AA outputs when dietary fiber content is high and the ileal digesta is collected through a simple T-cannula in the pig. True rather than apparent ileal AA digestibility coefficients determined in barley samples should be used in diet formulation for swine. The gastrointestinal endogenous AA secretion, recycling, and output losses are important in whole-body AA utilization and homeostasis, especially when fiber-enriched diets are fed to growing-finishing pigs.     

The effect of protein status of the pig on the recovery and amino acid composition of endogenous protein in digesta collected from the distal ileum

Barrows with an average initial weight of 55 kg were fitted with simple T-cannulas at the distal ileum. The animals were fed a protein-free diet that consisted of 79.7% cornstarch, 10% sucrose, 3% Alphafloc (a source of cellulose), 3% canola oil and a vitamin-mineral premix. The pigs were fed 700 g of diet twice each day, at 0800 and 2000. A balanced amino acid mixture or a saline solution was administered intravenously while the protein-free diet was fed. Ileal digesta were collected for 24 h following a 7-d adaptation period. The administration of amino acids reduced (P less than .05) the recovery of endogenous protein from 18.5 to 12.7 g per kg dry matter intake. For the amino acids, the reduction was only significant (P less than .05) for proline, from 3.6 to .6 g per kg dry matter intake. If the total endogenous protein losses are assumed to be constant and the differences in the amino acid composition of non-reabsorbed endogenous protein, as observed in this study, are used to calculate true ileal digestibilities, differences in the digestibilities of the indispensable amino acids are large (up to 7.4 percentage units for threonine). The amino acid composition of endogenous protein determined in pigs fed a protein-free diet and parenterally administered with amino acids should provide a better estimate for the calculation of true amino acid digestibilities when based on the determination of true protein digestibility by the 15N-isotope dilution technique.     

Amino acid digestibility in dry extruded-expelled soybean meal fed to pigs and poultry

The digestibility of AA in dry extruded-expelled soybean meal (DESBM) and regular, solvent-extracted soybean meal (SBM) were determined in pigs and poultry. In the pig assay, 4 Cotswold barrows (average initial BW of 80.4 kg) fitted with a T-cannula at the distal ileum were allotted to 4 semipurified diets in a 4 x 4 Latin square design. Diet 1, a low protein diet (5% casein), was used to quantify endogenous CP and AA losses. Diets 2, 3, and 4 were formulated to contain 35% regular, solvent-extracted SBM; batch 1 of DESBM (DESBM-1); and batch 2 of DESBM (DESBM-2), respectively, as the sole source of protein. The DESBM samples were obtained from 2 different batches but were subjected to the same processing conditions. Chromic oxide (0.3%) was included as a digestibility marker in all diets. Compared with DESBM-1 and DESBM-2, apparent ileal digestibility of DM in SBM was greater (P < 0.05). Apparent and true ileal digestibilities of AA in SBM were greater (P < 0.05) compared with DESBM-2. In the poultry assay, 4 dietary treatments were each assigned to adult cecectomized roosters in a completely randomized design. Treatment 1 was a nonnitrogenous diet (NND; 90% sucrose and 10% vegetable oil) used to estimate endogenous N and AA losses. Treatments 2, 3, and 4 contained SBM, DESBM-1, and DESBM-2 as the only source of protein. Each of these diets was fed in 25-g quantities formulated to provide 5 g of CP from the respective soybean meal source. The SBM had greater (P < or = 0.05) true digestibility for isoleucine, leucine, cysteine, proline, serine, and tyrosine compared with DESBM-1. The results indicate that, relative to regular, solvent-extracted soybean meal, AA digestibilities of different batches of dry extruded-expelled soybean meal varied in pigs and poultry.     

The influence of soy oligosaccharides on apparent and true ileal amino acid digestibilities and fecal consistency in growing pigs

Fourteen ileally cannulated pigs (BW = 35 +/- 2 kg) were randomly allotted to a replicated 7 x 7 Latin square design experiment to evaluate the influence of the soybean oligosaccharides (OS), raffinose and stachyose, on ileal nutrient digestibility and fecal consistency. Semipurified diets containing soy protein concentrate (SPC) or soybean meal (SBM) as the sole protein sources were fed. Soy solubles (SS), a by-product of SBM processing containing 3.5% raffinose and 11.5% stachyose, were used to increase dietary raffinose and stachyose concentrations. The seven dietary treatments were SPC, SPC + 9% SS, SBM, SBM + 9% SS, SBM + 18% SS, SBM + 24,000 U alpha-galactosidase enzyme preparation/kg diet, and a low-protein casein (LPC) diet used to calculate true digestibility. Diets, with the exception of the LPC diet, were formulated to contain 17% CP. All diets contained 0.5% chromic oxide as a marker for ileal digestibility determination. The experimental periods were divided into a 5-d diet adaptation followed by 2-d of ileal digesta collection. Diets and digesta were analyzed for DM, N, Cr, amino acids (AA), raffinose, and stachyose. Fecal consistency was determined on d 6 and 7 of each experimental period. The apparent and true ileal AA digestibilities were not different (P < 0.05) for the SPC and SBM control diets. When SS was added to the SPC diet, apparent and true N and AA digestibilities were depressed (P < 0.05) with the exception of Trp and Pro. The apparent and true ileal N and AA digestibilities were not different (P > 0.05) between the SBM control and SBM + 9% SS diets with the exception of Glu. There was a linear decrease (P < 0.05) in apparent and true DM, Val, Gly, and Tyr digestibilities when increasing levels of SS were added to the SBM diet. The addition of alpha-galactosidase did not improve apparent or true ileal N or AA digestibilities except for apparent and true Val and Tyr. Ileal raffinose digestibility was improved (P < 0.05) by addition of a-galactosidase, but was not affected by any other dietary treatment. Ileal stachyose digestibility was not affected (P > 0.58) by treatment. Fecal consistency likewise was not affected (P > 0.36) by dietary treatment. In conclusion, soy OS reduced nutrient digestibilities, but the reductions were small, ranging from approximately 1.1 to 7.4 percentage units. This suggests that other factors may be negatively impacting SBM digestibility.     

Determination of the ileal amino acid and energy digestibilities of corn distillers dried grains with solubles using grower-finisher pigs

An experiment evaluated the ileal apparent and standardized AA and apparent energy digestibilities in grower-finisher pigs of 5 sources of distillers dried grains with solubles (DDGS) from corn. The 5 DDGS sources were analyzed for AA, GE, NDF, ADF, and color score. Diets were formulated to contain 15% CP from the test DDGS sources (approximately 60% of the diet). A low-protein (5% casein) diet was used to estimate basal endogenous AA losses. The experiment was conducted in 2 replicates of a 6 x 6 Latin Square design, with 6 treatments and six 1-wk periods. The experiment used 12 crossbred barrows [(Yorkshire x Landrace) x Duroc], averaging 28 kg of BW and 60 d of age, and surgically fitted with a T-cannula in the distal ileum. After a 10-d recovery period, treatment diets were fed in meal form, initially at 0.09 kg . BW(0.75). Feed intake was equalized between pigs within each period and increased for each subsequent period. Periods included 5 d of diet acclimation followed by two 12-h ileal digesta collections, one on d 6 and one on d 7. Apparent and standardized digestibility of AA was calculated using chromic oxide (0.4%) as an indigestible marker. The results demonstrated that apparent and standardized lysine digestibilities ranged from 24.6 to 52.3% and 38.2 to 61.5%, respectively. Average apparent essential AA digestibility was lower (P < 0.05) in sources 1 and 5, the 2 sources that were darkest in color. Apparent and standardized digestibility of the averaged nonessential AA were lower (P < 0.05) in source 5 than in all other sources. Source 5, the darkest colored DDGS, had a 10% lower (P < 0.05) average apparent and standardized essential AA digestibility and was more than 15% lower (P < 0.05) in lysine digestibility than the 3 lightest colored sources. Apparent ileal energy digestibility did not differ among the 5 sources. Lysine content and digestibility seemed to be reduced to a greater extent by the darker colored DDGS than the other essential AA, suggesting that the Maillard reaction reduced total lysine content and lowered its digestibility. These results, therefore, imply that darker colored DDGS sources may have lower (P < 0.05) analyzed lysine contents, as well as lower (P < 0.05) lysine and essential AA digestibilities, than lighter colored DDGS sources.     

Energy, phosphorus, and amino acid digestibility of high-protein distillers dried grains and corn germ fed to growing pigs

Three experiments were conducted to measure energy, P, and AA digestibility in 2 novel co-products from the ethanol industry [i.e., high-protein distillers dried grains (HP DDG) and corn germ]. These products are produced by dehulling and degerming corn before it enters the fermentation process. Experiment 1 was an energy balance experiment conducted to measure DE and ME in HP DDG, corn germ, and corn. Six growing pigs (initial BW, 48.9 +/- 1.99 kg) were placed in metabolism cages and fed diets based on corn, corn and HP DDG, or corn and corn germ. Pigs were allotted to a replicated, 3 x 3 Latin square design. The DE and ME in corn (4,056 and 3,972 kcal/kg of DM, respectively) did not differ from the DE and ME in corn germ (3,979 and 3,866 kcal/kg of DM, respectively). However, HP DDG contained more (P < 0.05) energy (4,763 kcal of DE/kg of DM and 4,476 kcal of ME/kg of DM) than corn or corn germ. Experiment 2 was conducted to measure apparent total tract digestibility (ATTD) and true total tract digestibility of P in HP DDG and corn germ. Thirty growing pigs (initial BW, 33.2 +/- 7.18 kg) were placed in metabolism cages and fed a diet based on HP DDG or corn germ. A P-free diet was used to measure endogenous P losses. Pigs were assigned to treatments in a randomized complete block design, with 10 replications per treatment. The ATTD and the retention of P were calculated for the diets containing HP DDG and corn germ, and the endogenous loss of P was estimated from pigs fed the P-free diet. The ATTD was lower (P < 0.05) in corn germ (28.6%) than in the HP DDG (59.6%). The retention of P was also lower (P < 0.05) in pigs fed corn germ (26.7%) than in pigs fed HP DDG (58.9%). The endogenous loss of P was estimated to be 211 +/- 39 mg per kg of DMI. The true total tract digestibility of P for HP DDG and corn germ was calculated to be 69.3 and 33.7%, respectively. In Exp. 3, apparent ileal digestibility and standardized ileal digestibility values of CP and AA in HP DDG and corn germ were measured using 6 growing pigs (initial BW, 78.2 +/- 11.4 kg) allotted to a replicated, 3 x 3 Latin square design. The apparent ileal digestibility for CP and all AA except Arg and Pro, and the standardized ileal digestibility for CP and all AA except Arg, Lys, Gly, and Pro were greater (P < 0.05) in HP DDG than in corn germ. It was concluded that HP DDG has a greater digestibility of energy, P, and most AA than corn germ.     

Ileal amino acid digestibilities by pigs fed soybean meals from five major soybean-producing countries

Growing conditions and processing technologies to which soybeans (SB) are exposed have an effect on digestibilities of AA found in the resultant soybean meals (SBM). This study evaluated SBM from five major SB-producing countries (Argentina, Brazil, China, India, and the United States). An industry representative in each country collected samples of unprocessed SB and SBM subjectively determined to be of high, intermediate, or low quality. The SB from each country were processed into SBM under uniform conditions in the United States. Five experiments (each examining the three SBM and the SB processed in the United States from a single country) were conducted to determine true ileal AAd digestibilities. In addition, a standard SBM purchased on the open market in the United States was used in all experiments as a control. Data from pigs fed a low-protein casein diet in each study were used to calculate true AA digestibilities. Pigs were fitted with simple T-cannulas at the terminal ileum and allotted to treatments in Latin square design experiments. Duplicate experiments were conducted at the University of Illinois and at The Ohio State University. Within each country comparison, pigs fed the SBM processed in the U.S. from SB grown in the five countries had lower (P < 0.05) true total amino acid (TAA) digestibilities than did pigs fed any of the SBM prepared within the country of origin, except the United States. This indicates that processing conditions used at the U.S. pilot plant were not ideal when using SB from other countries. True TAA digestibilities of the diets containing the high-, intermediate-, and low-quality SBM did not differ, except for China, where the low-quality SBM (83.5%) had a lower (P < 0.05) digestibility than the intermediate- (89.6%) or high- (89.0%) quality meals. Soybean meal produced in Argentina (average, 87%) and Brazil (average, 82%) had lower (P < 0.05) true TAA digestibilities than did the standard SBM (91%), indicating that the processing plants in those countries may produce a less digestible SBM than that available on the open market in the United States.     

Nitrogen balance and ileal amino acid digestibility in growing pigs fed diets reduced in protein concentration

Two studies were conducted to assess the effect of dietary protein reduction on N utilization, N excretion, and AA digestibility in growing pigs. The objective was to determine whether pigs fed diets with a reduced CP concentration could maintain the same N retention as pigs fed an adequate diet. The second objective was to test whether reducing dietary CP concentration decreases AA digestibility. In each study, six barrows were allotted to one of six dietary treatments in a Latin square design. Treatments consisted of four corn-soybean meal-based diets containing 15, 12, 9, and 6% CP, a casein-based diet containing 15% CP, and a protein-free diet. Crystalline AA were included in the 12, 9, and 6% CP diets. The indispensable:dispensable AA ratio was maintained at 45:55 with the addition of L-glutamic acid to the 9 and 6% CP diets. The casein-based and protein-free diets were used to determine endogenous total tract N and ileal AA losses. In the first study, total N losses and N absorbed decreased linearly (P < 0.001) as dietary CP concentration decreased from 15 to 6%. Both a linear (P < 0.001) and a quadratic (P < 0.05) decrease in N retention were found with decreasing dietary CP concentration. Nitrogen retained as a percentage of intake and absorbed increased (P < 0.001) as dietary CP concentration was reduced from 15 to 6%. In the second study, six barrows were surgically fitted with a T-cannula at the terminal ileum to determine ileal AA digestibility. For all dispensable and most indispensable AA, apparent and standardized ileal digestibility increased linearly (P 0.01, and for arginine, P < 0.05) as dietary CP concentration decreased. These results indicate that dietary CP concentration can be decreased from 15 to 12% with crystalline AA supplementation to meet an ideal AA profile without adversely affecting N retention, and that decreasing dietary CP concentration from 15 to 6% increases both dispensable and indispensable AA ileal digestibility.     

True ileal amino acid digestibility and endogenous ileal amino acid losses in growing pigs fed wheat shorts- or casein-based diets

Use of dietary AA in growing pigs reflects digestion and use of digested AA for various body functions. Before evaluating dietary effects on use of digestible AA intake for body protein deposition, a digestibility study was conducted to investigate true ileal AA digestibility and endogenous ileal AA losses in growing pigs fed graded levels of wheat shorts (WS) or casein (CS; control). A casein-based basal diet (basal) was formulated to contain 0.27 g of standardized ileal digestible (SID) Lys per MJ of DE, to which extra Lys was added from WS (WS2, +0.10 g of SID Lys per MJ of DE; WS3, +0.20 g of SID Lys per MJ of DE) or casein (CS3, +0.20 g of SID Lys per MJ of DE). A fifth diet was formulated to be similar in CP level and source as CS3 but in which 6% pectin, a source of soluble non-starch polysaccharides (NSP), was included at the expense of cornstarch (CS3 + pectin). Five Yorkshire barrows (17.5 +/- 1.5 kg of BW) were fitted with a T-cannula at the distal ileum and randomly assigned to 1 of the 5 experimental diets in a 5 x 5 Latin Square design. Apparent ileal digestibility (AID), true ileal digestibility (TID), and endogenous ileal protein losses (EPL) were determined using the homoarginine method. Diet CS level did not influence (P > or = 0.10) TID of most essential AA or EPL (10.4 g/kg of DM intake). Including pectin in the diet did not influence TID of AA (P > or = 0.10) but increased EPL (15.6 g/kg of DM intake; P > or = 0.01). Inclusion of WS in the diet reduced TID of most essential AA (P < 0.01). The TID values for most essential AA, however, were the same (P > or = 0.10) for both dietary WS levels, except for Lys and Met, which were further reduced at the greatest dietary WS level. Increased EPL (P < 0.01) was only observed for WS3 (16 g/kg of DMI). We concluded that (1) the effects of dietary protein source on AID of AA can be attributed both to reduced TID of AA and increased EPL, (2) the impact of dietary WS level on TID of AA and EPL does not seem to be linear, (3) soluble NSP from pectin or WS exerts a greater effect on EPL than insoluble NSP, and (4) because of the metabolic cost associated with EPL and the impacts of feed composition on microbial fermentation in the gut lumen, the effects of feed ingredients on the use of ileal digestible AA for protein deposition should be investigated further.     

The effect of microbial phytase on true and apparent ileal amino acid digestibilities in growing-finishing pigs

Ten 56-d-old, 15-kg barrows were surgically fitted with a postvalvular T-cecum cannula at the ileo-cecal junction to evaluate the effect of microbial phytase on apparent and true ileal AA digestibility and N utilization. A semipurified cornstarch- and soybean meal-based diet was formulated to contain 3.4 Mcal of DE/kg, 17.0% CP, 0.8% Ca, and 0.6% P but had a low phytate-P concentration (0.13%; all on an as-fed basis). Chromic oxide and dysprosium chloride were used as indigestible markers. The basal diet was supplemented with 0 or 1,000 phytase units/kg of microbial phytase. Postprandial plasma urea N and alpha-amino N concentrations, excretion of Ca, P, and N in feces and urine, and ileal AA digestibilities were determined 3 times at 4-wk intervals beginning at 70 d of age. The homoarginine (HA) method was used to determine endogenous AA flow by replacing 50% of the basal protein with guanidinated protein. Microbial phytase had no effect on apparent ileal digestibility (AID) or on true ileal digestibilities of N and most AA but did increase AID for arginine (P = 0.006) and methionine (P = 0.037). However, in HA diets, phytase increased the AID of CP (P = 0.01) and several AA. Addition of microbial phytase had no effect on the postprandial alpha-amino N concentrations in plasma but increased overall plasma urea N concentrations (P = 0.035). Barrows fed phytase-supplemented diets had decreased P in feces (P = 0.003) and greater P in urine (P = 0.001) but comparable total P excretion compared with barrows fed no phytase-supplemented diets. In conclusion, the addition of phytase to a semi-purified soybean meal-based diet did not affect the AID of several AA. In addition, differences between the basal and HA diets in N digestibilities indicated that that guanidination may limit the use of the HA method in determining endogenous protein losses.     

True ileal digestibility of amino acids in sow's milk for 17-day-old pigs

The digestibility of amino acids in sow's milk consumed by young pigs is currently unknown because of difficulties associated with collecting an adequate quantity of milk, and also problems in cannulating suckling pigs. A total of 14 kg of sow's milk was collected, two soluble indigestible markers (Co-EDTA and YbC13) were added, and the milk was fed to four pigs at 17 d of age that were fitted with a simple T-cannula at the terminal ileum. Another four cannulated pigs were offered a similar amount of a 20% DM liquid diet based on enzymatically hydrolyzed casein and lactose to assess endogenous amino acid losses. All pigs were fed about 875 g of each diet per day in 10 hourly meals from 0700 to 1700. Following 2 d of adaptation, ileal digesta were collected from 0800 to 1800 for 2 d. Diets and digesta were analyzed for amino acids using appropriate hydrolysis and preoxidation procedures. Average nitrogen true digestibility was 88%, whereas amino acid true digestibilities ranged from 84% (cystine and threonine) to 100% (methionine, histidine, and glutamic acid); the average for all amino acids was 92 +/- 4%. Based on average values, true digestibility of essential amino acids was not different from that of nonessential amino acids (P > 0.10). In whole milk, amino acids found in abundance in whey proteins (i.e., cystine, glycine, and threonine) were less (P < 0.05) digestible than amino acids predominating in casein proteins (i.e., glutamic acid, proline, and methionine). When true ileal digestible amino acid concentrations in sow's milk were expressed as ratios to digestible lysine, it appeared that threonine, tryptophan, and arginine were lower than what might be considered optimal. In conclusion, amino acids in sow's milk were highly digestible, but most of the amino acids had true ileal digestibility values significantly less than 100%.     

Measurement of endogenous amino acid losses in poultry

1. Ileal endogenous amino acid losses were determined in broiler chickens and in cannulated cross‐bred layer strain cockerels using either a nitrogen‐free diet, regression analysis or a 48 h fast.

2. Endogenous amino acid flows to the ileum in fasted cockerels were significantly lower than those obtained both by feeding the nitrogen‐free diet, and from regression analysis in either broilers or cockerels. Regression analysis gave the highest flows.

3. The apparent digestibility coefficients of amino acids in a diet containing 200 g/kg crude protein were lower in broilers (0.84) than in cockerels (0.88). When corrected, by regression analysis, for the contribution of endogenous amino acids, the true digestibility coefficients became 0.90 and 0.92 respectively.     

Regional and processor variation in the ileal digestible amino acid content of soybean meals measured in growing swine

To assess differences in soybean meal quality related to region of production, researchers in Illinois, Kansas, North Carolina, The Netherlands, and Ohio collected four soybean meal samples processed locally at least 15 d apart. These samples were assayed for ileal amino acid digestibility by pigs using a common soybean meal and a soy protein concentrate as references, and a low-protein casein diet for determination of endogenous amino acid losses. Digestibility was determined at each university using seven barrows surgically fitted with ileal cannulas in a 7 x 7 Latin square design. The experimental diets contained 17% CP from the test material except for the low-protein casein diet. Animals were fed twice daily, 12 h apart, at a level of 45 g x kg(-0.75) BW for each meal. Following a 5-d adaptation period, ileal digesta were collected for two 12-h periods for 2 d to be used for determination of ileal digestibility. Variation in amino acid digestibility was very small among and within sites and was much smaller than variation in the concentration of amino acids. Among sites, samples from The Netherlands had less total and thus digestible lysine and methionine than the U.S. samples (P < 0.05). The soybean meals tested in this experiment were approximately 4% higher in amino acids than that reported in the NRC (1998). True (standardized) digestibilities, however, were very similar to NRC values except for cysteine and threonine, which were 5 and 3 percentage points lower in this experiment, respectively. In conclusion, soybeans grown in the United States and locally processed into soybean meal were very similar in nutritional composition. Soybean meals produced in The Netherlands were lower in lysine and methionine (P < 0.05) but had a digestibility similar to that produced in the United States.     

Effects of level of supplemental phytase on ileal digestibility of amino acids, calcium, and phosphorus in dehulled soybean meal for growing pigs.

Ileally cannulated pigs were used to assess the effects of four dietary levels of microbial phytase (Natuphos) on the apparent and true digestibility of Ca, P, CP, and AA in dehulled soybean meal. Fourteen pigs (25 kg initial BW) were surgically fitted with T-cannulas at the terminal ileum and assigned to diets in a replicated 7 x 7 Latin square design. Following a 14-d recovery, four diets consisting of 30.5% soybean meal with 0, 500, 1,000, or 1,500 units of phytase/kg of diet were fed. Diets 5 (1.05% lysine, 0.90% Ca, and 0.75% P) and 6 (1.05% lysine, 0.90% Ca, and 0.75% P) contained 35.25% soybean meal and 27.0% soy protein concentrate, respectively. Diet 7 (0.37% lysine, 0.03% Ca, and 0.05% P) was a low-CP, casein-based diet used to estimate the nonspecific endogenous losses of Ca, P, CP, and AA in order to estimate the true digestibility of these nutrients. All diets contained cornstarch and dextrose and were fortified with vitamins and minerals. Chromic oxide was used as an indigestible indicator. The diets were fed daily at 9% of metabolic BW (BW0.75). Apparent and true ileal digestibility of P increased quadratically (P < 0.01) and true digestibility of Ca increased linearly (P < 0.07) with increasing levels of phytase. Apparent digestibility of Ca was unaffected (P = 0.15) by phytase level. Apparent and true ileal digestibility of CP and most AA increased slightly with the addition of 500 units of phytase/kg of diet, but not at higher levels of phytase supplementation (in most cases, cubic effect, P < 0.05). Apparent and true ileal nutrient digestibility coefficients were unaffected by soybean meal source (Diet 1 vs Diet 5), except for arginine and Ca. The apparent and true digestibility coefficients for most of the AA tended (P < 0.10) to be lower in diets containing soy protein concentrate vs the common source of soybean meal used in Diet 5, but ileal digestibilities of Ca and P were unaffected (P = 0.15). In this study, supplemental microbial phytase did not improve the utilization of AA provided by soybean meal but was an effective means of improving Ca and P utilization by growing swine fed soybean meal-based diets.     

Digestible and metabolizable energy concentrations and amino acid digestibility of dried yeast and soybean meal for growing pigs

Energy values and amino acid (AA) digestibility of dried yeast (DY) and soybean meal (SBM) were determined in 2 experiments with growing pigs. Experiment 1 was conducted to determine the digestible energy (DE) and metabolizable energy (ME) in DY and SBM. Thirty barrows with a mean initial body weight (BW) of 20.6 kg (SD = 1.04) were assigned to 5 dietary treatments in a randomized complete block design with period and BW as blocking factors. A reference diet was prepared with corn, canola meal, and soybean oil as energy-contributing ingredients. Four additional diets were prepared by adding 5% and 10% DY or SBM at the expense of energy-contributing ingredients in the reference diet. The ratio of corn, canola meal, and soybean oil was kept consistent across the experimental diets. Each experimental period consisted of 5-d adaptation and 5-d quantitative collection of feces and urine. Test ingredient-associated DE or ME intake (kcal/d) was regressed against test ingredient intake [kg dry matter (DM)/d] to estimate the DE or ME in test ingredients as the slope of linear regression model. The DE in DY was estimated at 3,933 kcal/kg DM, which was not different from the estimated DE in SBM at 4,020 kcal/kg DM. Similarly, there was no difference between DY and SBM in the estimated ME (3,431 and 3,756 kcal/kg DM, respectively). Experiment 2 was conducted to determine the standardized ileal digestibility (SID) of AA in DY and SBM. Twenty-one barrows with a mean initial BW of 20.0 kg (SD = 1.31) were surgically fitted with T-cannulas at the distal ileum and assigned to 3 dietary treatments in a randomized complete block design with BW as a blocking factor. Two semi-purified diets containing DY or SBM as the sole nitrogen source and one nitrogen-free diet (NFD) were prepared. The NFD was used to estimate the basal ileal endogenous losses of CP and AA. Pigs were fed the 3 diets for 5 d as adaptation, followed by 2 d of feeding with ileal digesta collection. The SID of AA, except Gly and Pro, in DY was less (P < 0.05) than in SBM. The SID of indispensable AA in DY ranged from 64.1% for Thr to 85.2% for Arg, and those in SBM ranged from 83.9% for Thr to 91.8% for Arg. In conclusion, energy values of DY are not different from those of SBM, whereas AA in DY is less digestible than in SBM. The estimated DE and ME as well as the SID of AA in DY and SBM can be used in diet formulation for growing pigs using these ingredients.     

Amino acid and energy digestibility in ten samples of distillers dried grain with solubles fed to growing pigs

The objective of this experiment was to measure the digestibilities of energy, CP, and AA in 10 samples of corn distillers dried grain with solubles (DDGS) and in corn fed to growing pigs. Twelve growing barrows (initial BW: 34.0 +/- 1.41 kg) were allotted to an 8 x 12 Youden square design with 8 periods and 12 animals. Ten of 12 diets were based on the 10 DDGS samples (66.7%), 1 diet was based on corn (97%), and the last diet was a N-free diet based on cornstarch and sucrose. Chromic oxide (0.3%) was included in all diets as an inert marker. Pigs were provided their respective diets at a level of 3 times their estimated energy requirement for maintenance. The apparent (AID) and standardized (SID) ileal digestibilities for CP and AA were measured in the 10 samples of DDGS and in corn using the direct procedure, but the apparent total tract digestibilities for DM and GE were estimated using the difference procedure. The concentration of DE in each sample of DDGS and in corn was also calculated. The results of the experiment indicated variation among the different sources of DDGS in AID and SID for Lys, which ranged from 35.0 to 55.9% and 43.9 to 63.0%, respectively. For Met, the SID varied between 73.9 and 84.7%. However, the variability among samples in the SID for CP, and for the indispensable AA other than Lys and Met, was relatively low and ranged between 6 and 8 percentage units (i.e., from 64.0 to 70.6%, 74.1 to 80.1%, and 67.4 to 75.3% for Thr, Trp, and Ile, respectively). The SID for Trp in corn (72.8%) was lower (P < 0.05) than in DDGS, but for the remaining indispensable AA, except Arg, the SID for corn were greater (P < 0.01) than for DDGS. The DE concentration in the 10 samples of DDGS varied (P < 0.001) from 3,382 to 3,811 kcal of DE per kg of DM. For corn, the DE was 3,845 kcal per kg of DM. It is concluded that the AID and SID for Lys vary among samples of DDGS, but for most other AA the AID and SID are relatively similar and vary only 6 to 8 percentage units among different samples. Future work should focus on identifying the reasons for the variation in the digestibility of Lys to avoid processing procedures that are detrimental to Lys digestibility.     

Evaluation of the homoarginine technique for measuring true ileal amino acid digestibilities in pigs fed a barley-canola meal-based diet

The homoarginine technique has been suggested as a means to determine true ileal amino acid digestibilities in nonruminant animals fed protein-containing diets. Conditions for guanidinating lysine to homoarginine in barley and canola meal and the effect of this process on nutrient composition and ileal digestibilities in the resulting material were investigated. Conditions tested were methylisourea concentration (0.4, 0.5, or 0.6 M) and reaction time (4 or 6 d) at pH 10.5. Using 0.4 methylisourea M solution for 4 or 6 d gave guanidination rates of 72.5 and 78.5% for barley and 72.3 and 75.2% for canola meal, respectively. Using 0.5 M gave 88.0 and 84.6% guanidination rates in barley and canola meal, respectively, after a 6-d reaction time. Under these conditions, guanidination did not change the nutrient composition of barley (P > 0.10), whereas it increased CP (38.4 vs 49.0%), crude fiber (10.2 vs 16.0%), acid detergent fiber (30.0 vs 43.4%) and neutral detergent fiber (29.8 vs 49.4%) levels in canola meal (P < 0.05). Four 33.6-kg barrows fitted with a simple T-cannula at the terminal ileum were fed a 16% CP unguanidinated barley and canola meal-based diet for four consecutive 14-d periods. Ileal digesta were collected continuously for 24 h on d 12 and 14 to determine apparent nutrient digestibilities. On the morning of d 14, pigs were fed a diet in which half of the barley and canola meal was replaced with guanidinated material for determining true ileal amino acid digestibilities. Digesta samples were pooled by pig and by 24-h period to give 16 observations per diet. Apparent ileal digestibilities of DM, CP, and AA in the unguanidinated and guanidinated barley-canola meal diet were similar (P > 0.10) despite the changes observed in canola meal. Apparent ileal lysine digestibility was 73.9 and 74.5% in the unguanidinated and guanidinated diet, respectively. The true ileal lysine digestibility was 88.1%. The present results show that guanidination does not interfere with digestion and further support the use of the homoarginine method for determining true ileal amino acid digestibilities in pigs fed practical diets. A methylisourea solution of 0.5 M and a 6-d reaction time are recommended for converting lysine to homoarginine in barley and canola meal.