Animal welfare and disease control regulations for killing cattle, swine and sheep with the help of a transportable electric stunning facility (SCHERMER, type EC)

Stamping-out of animals in case of infections diseases has to meet the requirements resulting from animal welfare, disease prevention, and practicability under conditions in practice. This is well qualified by application of electrical shock stunning with subsequent generation of ventricular fibrillation in cattle, swine and sheep. The scientific elements of the method, the procedure, and experiences in application of the method during the stamping-out of 340 cattle, 980 swine, 152 sheep and 18 goats are discussed in the paper.     

CO2 stunning of broilers and turkey hens

Stunning of poultry is still not solved satisfactorily. This concerns the requirements of animal welfare, meat quality and working conditions in the lairage, stunning and debleeding area. In an investigation of combined CO2-/O2-stunning in a new gas stunning system stress reactions of the animals during the induction phase and stunning effectivity were recorded in 7,000 chicken and 3.825 turkeys. During the induction phase (here: chicken 41 sek./turkeys 25-65 sec.) the animals first staid calm and then showed beak-opening as a consequence of the breathing stimulating effect of CO2. As a further sign of the aversiveness against CO2 the animals showed head shaking and wing flapping. The used settings of gas concentrations and stunning time in the system investigated lead to a very deep stunning resp. Killing of the animals. Therefore the debleeding cut could be performed late (chicken 44-55 sec., turkeys 54-90 sec.) after leaving the system without animals regaining consciousness. The stunning of turkeys with a mixture of CO2 and oxygen is an improvement according to animal welfare requirements because unnecessary pain and suffering, happening very often with electrical stunning, can be avoided. As far as animal welfare in chicken stunning is concerned it must be evaluated if gas stunning means an improvement because stress during the till now relatively long induction phase must be put into relation with comparably lower stress caused by hanging upside down and a fast and safe working electrical stunning unit.     

Field report from large-scale killing of ducks

An outbreak of avian influenza in August 2007 resulted in the culling of hundreds of thousands of Peking ducks. An earlier tutorial had shown that whole house gassing with carbon dioxide to kill waterfowl has to be refused because of interference with animal welfare. Culling by electrocution is a reliable method that fulfils animal welfare requirements. Stationary electrocution lines for slaughtering should be preferred if suitable for the killing of the birds. Mobile electrocution lines (MET) are a good alternative or supplementation with a capacity of circa 2,500 animals per hour. MET are suitable for killing Peking ducks with a weight of approximately 500 g. At least two veterinarians are required per MET for the supervision of animal welfare during culling. When following German animal welfare laws, killing in mobile gas containers filled with carbon dioxide is an alternative with a capacity comparable to that of MET. The problem of looking into the containers for controlled stunning and killing can be solved by installing observation windows. Manpower requirements are comparable to those of MET, while requirements for material and transportation are unlikely higher. This method is suitable for birds which are too small to be killed by electrocution.     

Animal welfare and workers' protection during electric stunning of poultry for slaughter

Every slaughter process involves problems as to animal welfare as well as safety aspects and the protection of workers. With poultry these are basically concentrated on electrical stunning. Electrical currents and voltages suitable for stunning slaughter animals are principally also hazardous for man in what respect body resistance is of crucial importance. Potential hazards have to be looked upon as present in spite of existing safety regulations. Comparatively high stunning voltages for poultry recently proposed because of animal welfare considerations have met objections not only from the viewpoint of meat hygienic but workers' safety regulations as well. While the former meanwhile could be overcome the latter still has to be investigated, especially as a regulation on the electrical stunning of poultry is currently being prepared. In this respect the question whether adequate stunning efficiency can be obtained by reducing the voltage and prolonging the time of exposure is of special interest. First preliminary results of such investigations are presented. To ensure workers' safety other related aspects should also be taken into account and examined for improvements.     

Assessment of cattle welfare at a commercial slaughter plant in the northwest of Mexico

Slaughter plants have been undergoing radical transformations in recent years due to the need to increase efficiency and incorporate new technologies for the improvement of the infrastructure, animal welfare, and product quality. The aim of this study was to assess the cattle welfare status during the unloading, lairage, stunning, bleeding and quantify bruising incidence at a commercial slaughter plant in the northwest of Mexico. We monitored 8,118 cattle during the unloading, lairage, stunning, bleeding, and carcass bruise incidence. Our results showed that in the unloading stage, 2% of the cattle vocalized, 5% were prodded with an electric goad, and 4% either slipped or fell. In the lairage stage, 12% of the animals vocalized, 80% prodded with an electric goad, and 8% of the animals slipped or fell. In the stunning stage, 10% of the animals vocalized, 67% prodded with an electric goad, and 15% of the animals slipped or fell. Ninety-five percent of the animals were stunned with a single shot, and 51% of the animals were effectively desensitized. Ninety-two percent of the carcasses had some type of bruise. Although the slaughter plant had adequate infrastructure and stringent operational standards, in all of the stages except unloading handling had an impact on the welfare of the animals being slaughtered.     

The use of electrical stunning followed by electro-immobilization for the humane slaughter of cattle

Sir;- In New Zealand, calves are often electrically stunned before slaughter. However, electrical stunning is not usually used for adult cattle, primarily because the large size of the adult animal makes restraint more difficult, resulting in less reproducible stunning, with potential danger to personnel from animal movement. In addition, the slaughter of cattle may be inhumane if the stunning process does not ensure immediate and permanent insensibility (Newhook and Blackmore 1982b). The use and humaneness of electrical stunning of sheep and cattle have been the subject of our recent research, in which we have addressed and resolved many of these problems. We wish to relate our observations in the context of head-only electrical stunning of cattle followed by electro-immobilization to maintain insensibility and ensure carcass stillness.     

Animal welfare aspects of the killing of fish

According to the Animal Protection Law (1986) fish are to be killed by methods which do not cause pain. However, the regulations do not cover the killing of non-food fish. A questionnaire, conducted among 85 fish scientists, revealed that single fish should be killed by a blow on the head, and larger numbers by electrical methods or by use of chemicals. Decapitation was proposed for eels. A regulation from 1936 stipulates the methods for the slaughtering of food fish. Mechanical or electrical stunning is compulsory except for eel and flatfish. The questionnaire showed that in general the present legal regulations are sufficient for the slaughtering of fish with the exception of eels. The commercially available apparatus for stunning and killing do not always fulfill the requirements of animal protection, slaughtering technology and safety for the user. Official testing of these apparatus as well as the evaluation of new methods--like CO2-stunning--are necessary in order to prevent the use of methods which are feasible, but do not fulfill animal welfare, especially for eel.     

Cattle stunning with a penetrative captive bolt device: A review

The captive bolt device has been used for stunning cattle at abattoirs for more than 100 years and is now one of the stunning devices used most widely. The aim of this review article was to assess the effects that are decisive during cattle slaughter on the quality of stunning with the use of a captive bolt stunning device. The basis of effective stunning is the use of a suitable type of device, with the speed of the bolt and the kinetic energy corresponding to the anatomical parameters of the slaughtered animal. The importance of the regular cleaning and maintenance of stunning devices and monitoring of the effectiveness of stunning goes without saying. The immediate loss of sensibility in the animal must occur after the first shot. The effectiveness of the stunning process can be quantified by regular monitoring of the behavior of animals after stunning with an emphasis on the loss of reflexes (corneal reflex, regular breathing, attempts to regain physiological posture) and checks on the shot location on the skulls of slaughtered animals.     

Reflexes and loss of sensibility following head-to-back electrical stunning in sheep

The effects of head-to-back electrical stunning on the incidence of post-stunning reflex activity and cortical evoked responses were investigated in sheep. The stuns were effective in terms of inducing epileptiform activity and they resulted in cardiac fibrillation which ensured that there was no recovery of consciousness. Even though the corneal reflex and respiratory gasps were present, in 10 out of 12 sheep there were no concomitant visual and somatosensory evoked responses following a stun. In the remaining two, the responses were rudimentary and it would be unwise to conclude that the animals were conscious. It is suggested that brain stem reflexes following this stunning method should not be relied on as indices of recovery. The results support the view that an electrical stunning method which induces cardiac fibrillation results in improved animal welfare.     

Religious slaughter in Italy

This research aims to understand the prevalence of religious slaughter practices in Italy. Two different ways of slaughtering animals are identified. Conventional slaughter is performed with prior stunning; kosher slaughter is practiced without stunning. Halal slaughter is performed for most animals without stunning. Halal slaughter with prior stunning is acceptable for 5.90% of small ruminants. For Halal slaughter in Italy, the terms “religious slaughter with stunning” and “religious slaughter without stunning” should be used to differentiate religious slaughter practices, keeping animal welfare in perspective.

     

A study of preslaughter pig handling and stunning in selected South African Highveld Region abattoirs

The study hypothesis was that pre-slaughter handling is not conducted in such a way that pigs can be considered humanely slaughtered, nor is it conducive to promoting those properties of fresh meat that could enhance pork quality. The 1st phase of the investigation was aimed at confirming the present compliance level within the prescribed norms. To this end the importance of stunning induction requirements for effective electrical stunning, the welfare implications relating to the pre-slaughter handling of pigs and the stunning and sticking techniques were investigated. Pre-slaughter welfare of the pigs at the abattoir was found to be influenced at the outset by the origin and type of pig slaughtered, the daily throughput range of pigs and the type of abattoir involved. A disappointing pre-arrival aspect was that deficiencies in road motor vehicles were observed while off-loading pigs. Through poor design or lack of maintenance, another factor that hampered free movement of pigs was the off-loading facilities. The nature of animal behaviour in the pens, in the passages and when going into the stunning area was directly related to the pig handling efficiency and to the nature and extent of design and maintenance problems with equipment. None of the abattoirs had a well designed in-feed to a well planned stunning area/facility, and a very high level of pig pre-slaughter stress prevailed. The optimum position of the electrodes is virtually impossible to attain under practical conditions and the practice of repeat application of electrical stunning is common. Of the total sample size (n = 1175), 34% were difficult to shackle, 90% of these being from the abattoirs tending to slaughter more routinely a wide range of different sized pigs. In this survey 149 pigs (13%) required more than a single sticking attempt to bleed out properly, considerably higher than in other published reports.     

Electrocardiograms as an aid in assessing the stunning of cattle and pigs

Electrocardiograms (ECG's) were made from cattle and pigs after slaughter using only the left arm and right arm recording electrodes of a portable electrocardiogram with 12 recording electrodes. Functional heart activity was demonstrated in cattle after stunning with a captive bolt, nonpenetrative percussive methods and a head-only electrical technique. Recordings compatible with ventricular fibrillation were made in the majority of cattle and pigs subjected to a head-to-chest form of electrical stunning. In cases where the placement of stunning electrodes was defective, functional cardiac activity could be detected. Movement artefact on the ECG trace associated with epileptiform seizures following head-only electrical stunning was a technical problem. This was reduced by restunning the animal with a captive bolt before taking an ECG. The examination of ECG's made subsequent to slaughter could form an important component of the quality control of Halal slaughter or a slaughter process using the head-to-body electrical stunning techniques. Adoption of this would be facilitated by the development of a more simple and less sensitive electrocardiograph than that used in the present investigation.     

Carcase and meat quality in ducks killed with either gas mixtures or an electric current under commercial processing conditions

1. The feasibility of killing 7-week old Peking ducks with gas mixtures and their effects on carcase and meat quality were evaluated and compared with killing in electrical waterbath under commercial conditions. 2. The prevalence of carcase appearance defects and broken bones in the carcases and haemorrhaging, pH, colour, cooking loss and texture of breast muscles were determined. 3. Ducks can be killed within 3 min by exposure to either 90% argon in air or a mixture of 30% carbon dioxide and 60% argon in air. 4. Gas or controlled-atmosphere killing of ducks, whilst they are still in their transport containers, would eliminate some of the welfare concerns associated with the conventional electrical waterbath stunning systems, without adversely affecting carcase and meat quality.     

肉牛运输应激危害及动物福利化预防措施

肉牛的运输福利是关乎内蒙古地区畜牧业发展的重要因素之一,作为畜牧业大省,内蒙古地区每年都进行大量的调运肉牛操作,不规范的运输会引起动物发生应激反应,进而使肉品质的下降。因此在实际生产中应注重运输环节的动物福利问题。文章通过总结实践和经验,分析了内蒙古地区肉牛运输中存在的问题及其危害,并提出了运输过程中的福利化预防措施,以其为改善肉牛运输福利提供参考。     

动物福利在肉牛生产中的应用现状与展望

规模化、集约化肉牛养殖方式在一定程度上可以降低生产成本,是提高生产效益的有效途径。然而,集中式、拴系式、高密度的生产方式下,常常导致肉牛的动物福利得不到有效保障,会对肉牛的生长和健康产生不利影响。改善肉牛动物福利可提高生产性能和养殖效益,实现绿色健康可持续发展。文章介绍了动物福利的概念、肉牛在饲养管理中的福利标准要求,以及在肉牛养殖过程中动物福利的重要意义,同时对我国肉牛生产福利的研究发展进行了展望,以期为生产实际提供指导和参考。     

The least requirements for the rotation of swine for slaughter from loading to transport to resting time until stunning from the viewpoint of animal protection and meat quality

1. According to the loading density there is a significant increase of the physical burden (strain) during a transport of pigs to the slaughterhouse. Keeping up minimal requirements (kgs pigs/sqm) the stress reaction decreases and the meat quality becomes better. 2. Each transport produces excitement which can be shown in higher respiratory and heart frequencies. The slaughtering of excited animals shows a higher percentage of carcasses with bad meat quality. Waiting times from at least 2 hours up to a maximum of 4 hours shows that the percentage of carcasses with a better meat quality increases. 3. Handling of animals at the slaughterhouse prior to stunning by dividing the number of pigs into small groups of at least 9 animals is very important especially because it reduces the excitement of the pigs prior to stunning. The stunning results are getting better. Mistakes in handling pigs prior to stunning especially in guiding them to the stunning place usually destroy all positive efforts for optimal transparent conditions and keeping up waiting times after transport. 4. The last step ahead to the stunning equipment. No good solution does exist which makes the pigs willingly do this last step and enter the place where the stunning is performed. This results in the CO2 stunning system itself as well as in the automatic electrical stunning equipment using a restrainer. 5. Stunning with CO2.     

A brief summary of European legislation regarding animal welfare

An overview of the current European legislation concerning animal welfare is given. The legal requirements concern the housing and care of production animals (poultry, calves and swine), the transport of animals and the killing of animals (not only in slaughterhouses, but also in case of contagious animal disease outbreaks). General information concerning the principles and contents of European pieces of legislation as well as detailed information concerning requirements for individual animal species is given. Furthermore, other elements concerning animal welfare such as castration of piglets, ritual slaughter and animals used for experimental purposes are also reviewed. Finally, some recent initiatives in the field of animal welfare are mentioned and useful links are provided for finding the various legislative acts and additional supportive information.     

Electrical stunning of cattle--experiences in New Zealand

Ever since the middle of the nineteen-eighties electrical stunning of cattle is used in industrial slaughter plants in New Zealand. Today electrical stun boxes operate in export slaughter plants throughout New Zealand. The reversible stun is utilised on the vast majority of slaughtered cattle. The electrical stunning (head only) immediately followed by bleeding is an alternative to ritual slaughter without prior stunning. Throughout the world's islamic community this alternative is widely accepted as Halal.     

Electrical stunning of red deer (Cervus elaphus)

Eighteen of 23 red deer (Cervus elaphus) at a deer slaughtering premises were successfully stunned with an apparatus modified from that normally used to stun sheep. The five unsuccessful electrical stuns were associated with poor head restraint and poor head contact by the electrodes. The median stunning current was 0.9 A, and in the majority of cases the duration of stunning was less than 1 second. The signs of the electrically induced epileptiform seizures in the deer were dissimilar to those seen in sheep, cattle and pigs, in that the initial tonic phase was less marked, and of shorter duration. A similar shorter and less obvious tonic phase was noted in four deer shot with a captive bolt pistol. Two animals which were electrically stunned, and bled within 10 seconds, showed no signs of recovery while bleeding. The electroencephalograms of four deer stunned with currents of 1.3 A for a duration of either 0.5 or 1.0 seconds were recorded under more controlled conditions. All four animals developed electroencephalograms typical of an epileptiform seizure. The animals exhibited behavioural reactions similar to the other 18 animals in the trial at the deer slaughtering premises and were rendered unconscious for between 54 and 122 seconds. The electroencephalogram activity amplitude was greater than that recorded immediately before stunning and took between 6 and 9 seconds to build up to maximum value. It is concluded that, providing the heads of deer are adequately restrained, head-only electrical stunning can be incorporated into a humane method of slaughter for deer.