Thin-layer chromatographic determination of erythromycin and other macrolide antibiotics in livestock products

A method is described for determination of 4 macrolide antibiotics in livestock products. Erythromycin, tylosin, oleandomycin, and spiramycin were extracted from animal tissues, milk, and egg with acetonitrile at pH 8.5. Cleanup was done by adding sodium chloride and dichloromethane, evaporating the organic layer, and subsequent acid/base partitioning. After the antibiotics were separated by thin-layer chromatography (TLC), they were reacted with xanthydrol and could be detected as purple spots down to 0.02 mg/kg without interference by other commonly used therapeutic drugs (23 were tested). Anisaldehyde-sulfuric acid, cerium sulfate-molybdic acid, phosphomolybdic acid, and Dragendorff's reagent proved to be less sensitive as visualizing agents. For quantitation, TLC plates were scanned at 525 nm. Recoveries were between 71 and 96% for erythromycin and tylosin in liver, muscle, and egg at the 0.1-0.5 mg/kg level and 51% for erythromycin in milk at the 0.02 mg/kg level (coefficient of variation = 10-18%). Bioautography with Bacillus subtilis was used to confirm results, in addition to TLC analysis of derivatized antibiotics and liquid chromatography with electrochemical detection. Various derivatization procedures for erythromycin were investigated for improved ultra-violet or fluorescence detection in liquid chromatography.     

Improved spectrophotometric determination of cyclopiazonic acid in poultry feed and corn

An improved visible spectrophotometric method has been developed for cyclopiazonic acid in poultry feed and corn. The method is based on the reaction of cyclopiazonic acid with Ehrlich reagent and detection at 580 nm. Reaction conditions were optimized with respect to reaction and measurement times and acid and Ehrlich reagent concentrations. Calibration curves were linear from 1 to 20 micrograms cyclopiazonic acid in 3 mL Ehrlich reagent, with a lower detection limit of 0.08 mg/kg for 50 g samples of poultry feed and corn. Recoveries from 50 g samples of poultry feed spiked with cyclopiazonic ranging from 0.16 to 1.20 mg/kg averaged 93.8%. Moldy corn and poultry feed samples analyzed by this method contained between 1 and 4 mg/kg cyclopiazonic acid.     

Screening and quantitation of ochratoxin A in corn, peanuts, beans, rice, and cassava

To answer the need for simple, economical, rapid methods for mycotoxins, a procedure for screening and quantitation of ochratoxin A was developed. A methanol-aqueous KCl extraction is used, followed by cleanup with clarifying agents and partition into chloroform. Part of the chloroform extract is used for screening and the other part for quantitation by thin layer chromatography (TLC). The screening procedure takes 40 min, using a silica gel/aluminum oxide minicolumn developed for this purpose. The limits of detection are 80 and 10 micrograms/kg, respectively, for minicolumn screening and TLC quantitation. Ammonium sulfate is efficient in cleaning samples of corn and cassava; cupric sulfate is better with peanuts, beans, and rice. Tests were conducted on triplicate spiked samples of yellow corn meal, raw peanuts, dried black beans, polished rice, and cassava flour at different levels (400, 200, 80, 40, and 10 micrograms/kg). Recoveries ranged from 86 to 160% and the coefficients of variation ranged from 0 to 26%.     

Determination of penicillin G residues in edible animal tissues by liquid chromatography

An improved method has been developed for the determination of benzyl penicillin in animal tissues. Tissues are fortified with a known amount of penicillin V (internal standard) and extracted with water. The extract is deproteinized with sulfuric acid and sodium tungstate, filtered, and concentrated on a conditioned C18 solid phase extraction column. Penicillin V and benzyl penicillin are then eluted from the column with 1 mL 60% acetonitrile-35% water-5% 0.2M phosphate buffer solution and derivatized with 1 mL 1,2,4-triazole-mercuric chloride solution at 65 degrees C for 30 min. An aliquot of this sample is analyzed by reverse phase liquid chromatography with UV detection at 325 nm. The limit of detection is 5 micrograms/kg (ppb) penicillin G (8.4 IU/kg) in liver, kidney, and muscle tissues).     

Determination of florfenicol amine residues in animal edible tissues by an indirect competitive ELISA

Florfenicol (FF) is a broad-spectrum antibiotic used increasingly in aquaculture, livestock, and poultry to treat diseases. To avoid using labor-intensive instrumental methods to detect residues of FF in food and food products, a simple and convenient indirect competitive enzyme-linked immunosorbent assay (ic-ELISA) method for florfenicol's major metabolite, florfenicol amine (FFA), was developed using a polyclonal antibody prepared in this study. FFA was covalently attached to carrier protein as immunogen by using the glutaraldehyde method. The antibodies obtained were characterized by an ELISA method and showed excellent specificity and sensitivity with the 50% inhibition values (IC 50) of 3.34 microg/L for FFA in PBS buffer. In the ELISA, sample extractions were performed by ethyl acetate/ammonium hydroxide (90 + 10, v/v) following combined acid hydrolysis of FF and its known metabolites. The limits of detection (LOD) calculated from the analysis of 20 known negative swine muscle, chicken muscle, and fish samples were 3.08, 3.3, and 3.86 microg/kg (mean + 3 SD), respectively. Recoveries of FFA fortified at the levels of 5, 50, 100, and 300 microg/kg ranged from 64.6 to 124.7%, with coefficients of variation of 11.3-25.8% over the range of FFA concentrations studied. Validation of the ELISA method with FFA-fortified swine muscle at the levels of 10, 50, 100, and 200 microg/kg was carried out using GC, resulting in a similar correlation in swine muscle ( r = 0.97). The results suggest that this ELISA is a specific, accurate, and sensitive method, which is suitable for use as a screening method to detect residues of FFA in animal edible tissues.     

Liquid chromatographic determination of chloramphenicol residues in meat: interlaboratory study

A liquid chromatographic (LC) method for the determination of chloramphenicol (CAP) residues in meat at the 10 microgram/kg level was tested in an interlaboratory study. The method used, based on aqueous extraction and sample cleanup with a cartridge containing Extrelut, was published earlier. A prestudy to familiarize collaborators with the method was performed before the actual interlaboratory precision study. The meat samples used in the precision study were prepared by diluting dosed chicken and pig muscle tissues with blank tissues from other species. Fourteen laboratories received 20 meat samples; 13 laboratories actually participated in the study. Two blank samples and 2 positive samples each of pig, calf, chicken, lamb, and cow meat were tested. The chloramphenicol concentrations in the positive samples ranged from 6.5 to 21 micrograms/kg. The overall mean reproducibility coefficient of variation was 17.9% after the results per laboratory were corrected for the mean recovery obtained within each sample series. The overall mean recovery was 55.1% with a coefficient of variation of 18.0% at the 10 micrograms/kg level. The limit of detection, based on chromatograms of blank samples, was estimated to be 1.5 micrograms/kg of chloramphenicol. No false positives or false negatives were observed in the concentration range tested; only 2 false positive results above the detection limit (1.7 and 6 micrograms/kg) on a total number of 60 blank analyses (3.3%) were observed.     

Rapid time-resolved fluoroimmunoassay for the screening of narasin and salinomycin residues in poultry and eggs

Anticoccidial drugs are extensively used in the poultry industry to control the infection of the single-cell protozoa of the genus Eimeria. The most commonly used coccidiostats in poultry are the polyether ionophores such as narasin and salinomycin. This paper presents a rapid and simple method for the screening of residues of these two coccidiostatic compounds in poultry and eggs. The method is based on time-resolved fluoroimmunoassay. Sample preparation of eggs consists only of one extraction and evaporation step, and a solid phase extraction step is needed only for the muscle sample preparation. Mean recoveries were 91.0% from muscle tissue and 81.1% from eggs for both narasin and salinomycin. The performance of the assay was evaluated only for narasin because salinomycin had a cross-reactivity of 100% in the assay, and the recoveries of the compounds were not significantly different (P >0.05). The limits of detection [mean + 3 x standard deviation (SD)] of narasin were 0.56 and 0.28 microg/kg, and the limits of quantification (mean + 9 x SD) were 1.80 and 0.57 microg/kg for muscle and eggs, respectively. The coefficients of variation (CV) of the interassay precision of the method, evaluated by five replicate analyses of muscle samples spiked with 2 microg/kg of narasin and egg samples spiked with 1 microg/kg of narasin, were 4.1 and 6.4%, respectively. The CVs of intra-assay precision tests, determined by 10 replicate analyses at the above-mentioned concentration levels, were 3.8 and 4.5%, respectively.     

A screening method for sulfonamides extracted from animal tissues.

A screening method for the estimation of possible residues of sulfonamides in poultry tissues is described. The method utilizes thin layer chromatography (TLC) to separate Bratton-Marshall positive reactants. In the absence of interference and the identification of 1 sulfonamide by TLC, the colorimetric method is recommended for quantitation. When interferences are present, TLC should be used for both qualitative and quantitative analysis. The screening method has a sensitivity of less than 0.05 ppm and a recovery of greater than 80%.     

Thin layer chromatographic determination of aflatoxins, ochratoxins, sterigmatocystin, zearalenone, citrinin, T-2 toxin, diacetoxyscirpenol, penicillic acid, patulin, and penitrem A.

A general method is described for determining 16 mycotoxins in mixed feeds and other food products used in the manufacture of these feedstuffs. The mycotoxins are extracted and cleaned up by extracting with solvents of different pH. Thin layer chromatography is used to separate the toxins; toxins are then quantitated by the limit detection method. The minimum detectable concentration of mycotoxins in various products is: aflatoxin B1 or G1, 4--5 micrograms/kg; ochratoxin A or ethyl ester A 140--145 micrograms/kg; citrinin 600--750 micrograms/kg; zearalenone, 410--500 micrograms/kg; sterigmatocystin, 140--145 micrograms/kg; diacetoxyscirpenol, 2400--2600 micrograms/kg; T-2 toxin, 800--950 micrograms/kg; patulin, 750--800 micrograms/kg; penitrem A 14,000--14,500 micrograms/kg; penicillic acid 3400--3650 micrograms/kg.     

Survey of aflatoxins, ochratoxin A, zearalenone, and sterigmatocystin in some Brazilian foods by using multi-toxin thin-layer chromatographic method

A previously published method for ochratoxin A was evaluated and proved appropriate for simultaneous determination of aflatoxins, ochratoxin A, sterigmatocystin, and zearalenone, with considerable savings in time and reagent costs. The detection limits were 2, 5, 15, and 55 micrograms/kg, respectively. The recoveries and coefficients of variation obtained with artificially contaminated samples were 91-101% and 0-16% for aflatoxin B1, 98-117% and 0-17% for sterigmatocystin, and 96-107% and 0-17% for zearalenone, respectively. The coefficients of variation for naturally contaminated samples (aflatoxins in rice and ochratoxin A in beans) ranged from 0 to 8%. The method was used to survey 296 samples that included 10 cultivars of dried beans, 8 types of corn products, 3 types of cassava flour, and both polished and parboiled rice between May 1985 and June 1986 in Campinas, Brazil. Only aflatoxin B1 (9 samples, 20-52 micrograms/kg), aflatoxin G1 (4 samples, 18-31 micrograms/kg), and ochratoxin A (5 samples, 32-160 micrograms/kg) were found. The average contamination percentage was 4.7%; beans showed the highest (6.6%) and rice showed the lowest (3.3%) incidence rates. Zearalenone and sterigmatocystin were not detected. Positive samples were confirmed by chemical derivatization, corroborated by development in 3 solvent systems.     

Comparison of two immunochemical methods with thin-layer chromatographic methods for determination of aflatoxins

Three different methods were compared for the determination of total flatoxins in corn and peanuts naturally contaminated with aflatoxins and in corn, peanuts, cottonseed, peanut butter, and poultry feed spiked with aflatoxins B1, B2, and G1. The 3 methods were an enzyme-linked immunosorbent assay (ELISA) screening test; a monoclonal antibody-affinity column-solid-phase separation method; and the AOAC official thin-layer chromatography (TLC) methods for all except poultry feed, for which Shannon's TLC method for mixed feed was used. The ELISA test is designed to provide only positive results for total aflatoxins at greater than or equal to 20 ng/g or negative results at less than 20 ng/g. The affinity column separation is coupled with either bromination solution fluorometry to estimate total aflatoxins or liquid chromatography (LC) to quantitate individual aflatoxins. Fluorodensitometry was used to determine aflatoxins in commodities analyzed by the TLC methods. The LC and TLC results were in good agreement for all the analyses. The results for the affinity column using bromination solution fluorometry were similar except those for cottonseed, which were about 60% higher. The ELISA screening method correctly identified naturally contaminated corn and peanut positive samples. No false positives were found for controls. The correct response for spiked corn, raw peanuts, peanut butter, and cottonseed at greater than or equal to 20 ng aflatoxins/g was about 90%. The correct response for spiked poultry feed at greater than or equal to 20 ng aflatoxins/g was about 50%.     

Detection, accumulation, distribution, and depletion of furaltadone and nifursol residues in poultry muscle, liver, and gizzard

Nitrofurans were broadly used as an extremely effective veterinary antibiotic especially in pig and poultry production farms. Because of fears of the carcinogenic effects on humans, the nitrofurans were banned from use in livestock production in many countries, including the European Union. The present study examines the accumulation, distribution, and depletion of furaltadone and nifursol and of their tissue-bound metabolites [3-amino-5-morpholinomethyl-2-oxazolidinone (AMOZ) and 3,5-dinitro-salicylic acid hydrazine (DNSAH), respectively, in poultry edible tissues (muscle, liver, and gizzards) following administration to chickens of therapeutic and subtherapeutic concentrations of both compounds. Nitrofurans determination was performed by high-performance liquid chromatography-diode array detection and liquid chromatography-tandem mass spectrometry, respectively, for feeds and for poultry tissues. Furaltadone and nifursol, in very low concentrations, were found in samples of muscle, liver, and chicken's gizzard collected from slaughtered animals after 5 weeks of treatment and no withdrawal time period. When a withdrawal time period of 3 weeks was respected, no detectable nitrofuran parent compounds was observed in all of the studied matrices. For AMOZ, concentrations of 270 μg/kg in meat, 80 μg/kg in liver, and 331 μg/kg in gizzard were determined after administration of a medicated feed with furaltadone (132 mg/kg), 3 weeks after withdrawal of treatment. For DNSAH, the concentration values obtained are much lower than those observed for AMOZ. For meat, liver, and gizzard, DNSAH concentrations of 2.5, 6.4, and 10.3 μg/kg, respectively, were determined, after administration of a medicated feed with nifursol (98 mg/kg), 3 weeks after withdrawal of treatment. The gizzard could be considered a selected matrix for nitrofuran residues evaluation in poultry, due to its capacity of retaining either nitrofuran parent compounds or metabolites in higher concentrations, regardless of the administered dose or of the respected withdrawal time period.     

Rapid thin layer chromatographic determination of zearalenone in corn, sorghum, and wheat

A rapid method is described for determining zearalenone in corn, sorghum, and wheat. The mycotoxin is extracted with a mixture of acetonitrile and 4% KCl in HCl. The extract is cleaned up with isooctane, evaporated, and redissolved in chloroform. Zearalenone is separated by thin layer chromatography; identity is confirmed with various developing solvents and spray reagents. Zearalenone is then quantitated by the limit detection method. The minimum detectable concentration is 140-160 micrograms/kg when aluminum chloride solution is used as spray reagent, and 85-110 micrograms/kg when Fast Violet B salt is used as spray reagent.     

Development of an indirect competitive ELISA for the detection of furazolidone marker residue in animal edible tissues

Due to its carcinogenicity and mutagenicity, furazolidone has been prohibited completely from being used in food animal production in the world since 1995. To monitor the illegal abuse of furazolidone, a polyclonal antibody-based indirect competitive enzyme-linked immunosorbent assay (ic-ELISA) was developed for the determination of tissue-bound furazolidone metabolite 3-amino-2-oxazolidone (AOZ). The highly specific antibody was targeted for PAOZ, the benzaldehyde derivative of AOZ. The 50% inhibition values (IC 50) of 0.91 microg/L for AOZ was achieved with the most sensitive antibody Ab-B1 by altering ELISA conditions. In the ELISA, sample extraction and cleanup were performed by an is MAX cartridge following combined hydrolysis of the tissue-bound AOZ and derivatization of the homogenized tissues with benzaldehyde. The limits of detection (LOD) calculated from the analysis of 20 known negative tissue samples (swine liver, swine muscle, chicken liver, chicken muscle,and fish muscle) were 0.3-0.4 microg/kg (mean+3 SD). Recoveries of AOZ fortified at the levels of 0.4, 1, and 5 microg/kg ranged from 55.8 to 96.6% in the tissues. The coefficients of variation were less than 20% over the range of AOZ concentrations studied. The linear detection range was between 0.1 and 25.6 microg/L. Validation of the ELISA method with swine muscle and liver from furazolidone-treated pigs was carried out using HPLC, resulting in a similar correlation in swine muscle (r=0.99) and in swine liver (r=0.98). The results suggest that this ELISA is a specific, accurate, and sensitive method of detecting AOZ residues in animal edible tissues.     

Development of a lateral flow colloidal gold immunoassay strip for the rapid detection of olaquindox residues

A rapid immunochromatographic lateral flow test strip of competitive format has been developed for the specific determination of olaquindox (OLA) residues in pig urine and muscle tissues. The sensitivity of the test strip was found to be 1.58 ± 0.27 μg/kg and 1.70 ± 0.26 μg/kg of OLA in pig urine and muscle tissues, and the lower detection limit was 0.27 ± 0.08 μg/kg and 0.31 ± 0.07 μg/kg respectively. For negative pig urine and muscle samples spiked with 4, 12, and 36 μg/kg, the recovery range was 83.0-94.0% and 78.8-87.4% and the coefficient of variation scope [CV (%)] was 3.17-7.41% and 4.66-7.64% respectively. Parallel analysis of OLA samples from pig urine and muscle tissue showed comparable results from the test strip and HPLC. Each test requires 5-8 min, and the test strip can provide a useful screening method for quantitative, semiquantitative, or qualitative detection of OLA residues.     

Comparison of four thin-layer chromatographic methods for the determination of aflatoxins in raisins

A study was conducted to determine the accuracy and precision of 3 AOAC methods, secs 26.026-26.031 (CB), secs 26.032-26.036 (BF), and secs 26.052-26.060 (cottonseed), and the Romer quantitative method for the thin-layer chromatographic (TLC) determination of aflatoxins B1, B2, G1, and G2 in raisins. The samples were spiked at a level of 10 micrograms total aflatoxins/kg. The TLC development systems were: ether-methanol-water (94 + 4.5 + 1.5) and chloroform-acetone (9 + 1). The interaction between the 4 methods and the 2 development systems was also studied. The average recoveries were 88, 80, 75, and 93% with coefficients of variation of 14.0, 10.4, 14.0, and 9.6% for aflatoxin B1 using the CB, BF, cottonseed, and Romer methods, respectively. Statistical analysis showed no difference in the results obtained using the 2 TLC development systems.     

Assay of oxolinic acid residues in salmon muscle by liquid chromatography with fluorescence detection: interlaboratory study.

A previously developed method that uses a simplified sample preparation and fluorometric detection of liquid chromatographic eluates for the determination of oxolinic acid in salmon muscle has been collaboratively studied. Five laboratories participated in the study to analyze, in quintuplicate, blank salmon muscle fortified at 10, 20, 50, and 100 micrograms/kg (ppb), and 2 incurred samples from salmon given feed with medicated oxolinic acid. The tissue, 2 g mixed with 2 g Na2SO4, is extracted with ethyl acetate and centrifuged, and the solvent is evaporated. The residue is partitioned in a mixture of hexane and 0.01 M oxalic acid, and the aqueous phase is chromatographed using fluorescence detection at 327 nm excitation and 369 nm emission. Mean recoveries ranged from 77.2 to 84.5% in spiked samples with reproducibility relative standard deviation (RSDR) ranging from 11.5 to 18.3%. Treated salmon were found to contain 8.71 and 53.8 micrograms/kg with RSDR of 18.6 and 16.7%, respectively. The corresponding repeatability relative standard deviations (RSDR) were 5.8-12.2%, and 7.7 and 6.2%. The method is recommended for regulatory purposes in Canada.     

Determination of zearalenone in cornflakes and other corn-based foods by thin layer chromatography, high pressure liquid chromatography, and gas-liquid chromatography/high resolution mass spectrometry

A simple cleanup procedure based on pH adjustments was used to obtain extracts of corn foods. The method gave good recoveries of zearalenone determined by thin layer chromatography (TLC) and high pressure liquid chromatography (HPLC). As little as 5 ng zearalenone was detected by TLC, using Fast Violet B Salt as the spray reagent; the lower limit of detection in cornflakes was about 20 microgram/kg. With HPLC on Spherisorb silica (5 micrometer) and detection by fluorescence at an excitation maximum of 310 nm as little as 5 microgram zearalenone/kg cornflakes could be determined. While the TLC method was also applicable to corn chips, cornmeal, popcorn, and frozen corn, an interference was observed in HPLC of the latter 3 products. This interference was separated from zearalenone by adding a second HPLC analytical column (Spherisorb ODS). Gas-liquid chromatography coupled with mass spectrometric single ion monitoring at high resolution, although of limited availability, was shown to be the most sensitive and selective method for determining zearalenone in corn foods. The natural occurrence of zearalenone in a sample of cornflakes (13-20 microgram/kg) was demonstrated by all 3 detection procedures.     

Capillary column gas chromatographic determination of ethyl carbamate in alcoholic beverages with confirmation by gas chromatography/mass spectrometry

A method is described for determining ethyl carbamate at low microgram/kg levels in several types of alcoholic beverages by capillary column gas chromatography with Hall electrolytic conductivity detection and confirmation by mass spectrometry. Samples are diluted to obtain a uniform concentration of ethanol (ca 10%) then saturated with NaCl and extracted with methylene chloride. Extracts are evaporated to a small volume and injected in ethyl acetate solution for chromatographic analysis. The method was evaluated by 5 laboratories, 4 employing the Hall detector and one using mass spectrometric detection. Overall between-laboratory mean percent recoveries were: wine, 85.3 +/- 21.0% coefficient of variation (CV) (spiking level 20-45 micrograms/kg); sherry, 83.8 +/- 16.1% CV (spiking level, 81-142 micrograms/kg); whiskey, 79.5 +/- 13.9% CV (spiking level 127-190 micrograms/kg); and brandy, 85.0 +/- 12.5% CV (spiking level 297-446 micrograms/kg). Mass spectrometric results agreed well with the Hall results for all commodities. Detection limits were about 5 micrograms/kg for the Hall detector and about 0.5 microgram/kg for mass spectrometric detection.     

Thin layer chromatographic determination of citrinin.

A thin layer chromatographic (TLC) method is described for the determination of citrinin in feeds. Citrinin is extracted from feed with methanol and water, the mixture is made alkaline with 10% sodium carbonate, and the aqueous solution is filtered and extracted with chloroform to remove most of the interfering materials. The aqueous layer is acidified with 2N HCl and extracted with chloroform. The chloroform extract is concentrated and spotted on a thin layer chromatographic (TLC) plate which is developed in chloroform-acetone-ethanol-water (60 + 40 + 10 + 1). The citrinin is viewed under ultraviolet light after TLC. Either visual or fluorodensitometric quantitation is used. Recoveries of citrinin from various feed samples spiked at levels of 2.0--5 micrograms/g were 75--92%. The proposed method can detect 0.5 micrograms/g feed, including corn, silage, ready mixed feeds, and feed pellets.