Economic effects of increased vitamin E supplementation of broiler diets on commercial broiler production

1. The economic effects of increased vitamin E supplementation in 168 commercial broiler flocks incorporating over 3 million birds was assessed using a computerised data retrieval system.

2. Approximately half of the flocks were fed on either a high (163 mg/kg) vitamin E or on a normal (44 mg/kg) vitamin E‐containing diet throughout production.

3. Approximately half of the flocks were the progeny of breeder flocks which had been fed on a high vitamin E‐containing diet throughout production.

4. The improvement in target income in the vitamin E‐supplemented broiler flocks was 8–44% (P < 0.01).

5. The residual improvement in target income in these flocks, after the cost of the additional vitamin E was taken into account, was 2.74% and failed to reach statistical significance.

6. The increased net income was achieved by a significantly improved food conversion ratio and average weight per bird (P < 0.05).

7. There was no overall effect of vitamin E supplementation of broiler breeders on subsequent broiler performance.     

A selection experiment on a white leghorn strain under Ahemeral light‐dark Cycles

1. Selection was carried out for increased ovulation frequency in two flocks; under ahemeral (9 generations of selection) or normal (8 generations) light‐dark cycles.

2. By the use of an ahemeral regime, the barrier to progress imposed by the limit of one ovulation in each light‐dark cycle was evaded.

3. Both flocks achieved a considerable increase in oviposition frequency but so far there has been little evidence of any advantage in this respect due to the ahemeral regime.

4. There was a marked correlated decrease in egg weight in both flocks.     

Traits influencing the hatching performance of Japanese quail eggs

1. Japanese quail eggs from moderately heavier sires showed superior fertility; while fertile eggs from moderately heavier dams hatched slightly better than the eggs from lighter dams.

2. Higher rates of fertility and hatchability of Japanese quail eggs were observed from parents of 10 to 19 weeks of age, with peak fertility and hatchability at 14 and 12 weeks of age, respectively.

3. Sex ratios of 1:2 to 1:5 gave comparable fertility and hatchability results.

4. The hatching performance of quail eggs from cage and deep litter reared breeders was comparable.

5. Fertility and hatchability were directly proportional to the egg weight.

6. Quail egg shell colour, tints and blotches were found to influence hatching performance.

7. Storing quail eggs at 16 ± 2°C and 75 ± 5% relative humidity for more than 4 d reduced hatchability.

8. Hatchability of eggs stored at room temperature was improved if they were sealed in polyethylene bags.

9. Provision of light during the first 14 d of incubation resulted in a photo‐acceleration of about 3.2 h.     

Forecasting egg production in commercial flocks

1. Production traits in 4 commercial flocks were regressed on age or on a function of age.

2. Regression accounted for a significant proportion of the observed variation.

3. The regression equations, together with several constraints upon their application, were used to predict future performance which, in most cases, agreed well with the performance actually observed in the flocks.     

Metabolic and anatomical adaptations of light‐bodied chicks to intermittent feeding

1. Chicks of a light‐bodied strain were deprived of food on alternate days from 15 to 46 d of age.

2. Hyperphagia, amounting to twice the intake of control birds early in the experiment, occurred on the repletion day.

3. Final body weight attained 80% of that of the controls.

4. Body fat concentration decreased at first but returned to that of controls after 3 weeks.

5. A consistent hyperlipaemia was observed after food deprivation or restoration.

6. There was a marked increase in the digestive enzymes found in the small intestine, but not in the pancreas during the repletion day.

7. These responses may be considered as mechanisms to reduce the physiological manifestations of starvation.     

Factors influencing bacterial eggshell contamination in conventional cages,furnished cages and free-range systems for laying hens under commercial conditions

1.?The aim was to assess eggshell contamination in various laying hen-housing systems and to identify factors influencing this contamination.

2.?Fifty-eight laying hen farms in France were studied, including 21 flocks housed in conventional cages, 7 in furnished cages and 30 kept on-floor.

3.?Sixty eggs per flock were analysed to obtain counts of the total mesophilic flora. Data on equipment and hen management were collected.

4.?Mean bacterial count on eggshells tended to be higher in on-floor systems (4·82 ± 0·51 log CFU/eggshell) than in cage systems (4·57 ± 0·58 log CFU/eggshell, P = 0·09).

5.?Contamination increased with age of the hens, airborne dust concentration, manual packing of the eggs, and packing in plastic rather than in recycled-pulp egg-flats.

6.?The effect of the housing system on eggshell contamination, previously described in experimental assays, was confirmed under production conditions.     

Effects of short intermittent lighting on food consumption and performance of dwarf broiler breeders and progeny

1. Two hundred and sixty four dwarf broiler breeder hens were subjected to ad libitum or restricted feeding and to four lighting patterns: 15L (bright light):9D (dark), 15L:9d (dim light), 2L:10d: 1L:11d, (0.5L:3.5d) × 6.

2. Breeder hens fed ad libitum and subjected to either conventional or intermittent lighting ingested respectively, 25 g and 14 to 17 g more than hens restricted to 115 g/d.

3. Body weight was greater in hens fed ad libitum irrespective of the lighting pattern and of the amount of food intake.

4. Persistency of egg production was impaired by intermittent lighting.

5. Ad libitum feeding reduced egg fertility. The decrease was larger in breeder hens on intermittent lighting.

6. Hatchability was increased in hens submitted to the symmetrical lighting pattern (0.5L:3.5d).

7. Egg and chick weights were higher in hens fed ad libitum.

8. Shell index and shell breaking strength increased in restricted hens on the intermittent lighting pattern (0.5L:3.5d) × 6.

9. The best performance was obtained in restricted hens on the conventional lighting pattern.     

Inheritance of body weight and rate of gain in Japanese quail

1. The effects of hatch date, location and sex on the body weight and rate of gain in Coturnix coturnix japonica were examined.

2. The data conformed to a mixed model and adjustments were made for the fixed effects sex, hatch date and location. Adjustment improved the precision of the estimates by reducing the error variances significantly.

3. Rearing equal numbers of birds from each family at different locations made the interactions negligible.

4. Weight gain was greater if illumination intensity up to 35 d was less.

5. Females were not heavier on the 1st day but were heavier on the 14th and 35th days than males.

6. Variance components and genetic parameters were estimated.     

Digestibility studies in broiler chickens: Influence of genotype,age, sex and method of determination

1. The influences of genotype, age and sex on droppings digestibility coefficients of a compound food were studied using male and female broiler chickens of three different genotypes at 2, 4 and 6 weeks of age.

2. Because the traditional method of determination of droppings digestibility coefficients of nitrogen may lead to systematic errors in estimating the feeding value of foodstuffs, a method is proposed to determine the ileal digestibility coefficients. The ileal method is compared with the droppings method for a mixed food and for two foodstuffs: wheat and solvent‐extracted soyabean meal.

3. Birds selected for efficient food conversion showed distinctly higher digestibility coefficients for all nutrients than birds selected for high growth potential or birds from a commercial strain.

4. The influence of age on digestibility coefficients was not consistent.

5. Female birds showed digestibility coefficients which were, in general, 3% higher than those of male chickens.

6. Interactions between genotype and sex and between genotype and age for energy metabolisability were the only interactions observed for digestibility measurements.

7. The method of determination influenced the amino acid digestibility coefficients of the mixed food and the relative feeding values of wheat and soyabean meal.

8. It is important to use well defined animals (genotype, sex, age) in evaluating foodstuffs.

9. The preferred method for determination of digestibility coefficients of nitrogen and amino acids is based on ileal sampling, although the differences in amino acid digestibility coefficients were small between methods.     

Whitening of brown shelled eggs: Individual variation and relationships with age,fearfulness, oviposition interval and stress

1. Fearfulness, shell colour, incidence and degree of shell whitening and the interval between ovipositions were studied in two populations of 30 brown egg laying hens with family histories of a low or a high incidence of egg shell whitening.

2. Hens of the population with the high incidence of whitening appeared to be more fearful than hens of the population with the low incidence of whitening.

3. Brown colouration of the egg shell and the incidence and degree of shell whitening declined as the hens aged.

4. Brown colouration and egg shell whitening were most pronounced on the blunt ends of the eggs.

5. A large part of the variation in egg shell whitening was attributable to the individual (hen) component of variance.

6. Differences in egg shell whitening, between the two populations, were detectable throughout the 26 weeks of the experiment.

7. Oviposition intervals were similar for normal and coated eggs when birds were not exposed to disturbance.

8. Disturbance of hens increased oviposition intervals and the incidence and degree of shell whitening, to a similar extent, in both populations.

9. It is concluded that stress‐related egg retention is not the sole factor responsible for abnormal egg shell whitening. Shell whitening may occur as a consequence of the premature termination of shell pigmentation as well as a consequence of the retardation of oviposition which occurs when hens are disturbed.     

Explanted embryo culture: In vitro and in ovo techniques for domestic fowl

1. Embryos of the domestic fowl (72 h old) have been explanted into shell‐less cultures or ‘surrogate’ eggshells, in order to investigate the possibility of rearing these embryos to hatching.

2. Rocking embryo cultures during the first half of incubation enhanced embryo growth.

3. Embryos explanted into ‘surrogate’ eggshells of either other individuals or other species have been successfully ‘hatched’.

4. A normal chorioallantois is formed in these surrogate eggshells. This enables a functional albumen sac to form and eggshell resorption to be achieved.

5. Embryos grown in ‘surrogate’ eggshells are slightly smaller than controls but otherwise normal.

6. The technique provides opportunities for genetic engineering experiments.     

Photoperiod and seasonal influences on the growth of turkey hens

1. The influence of photoperiod and time of year on the growth of hen turkeys was investigated.

2. Photoperiod treatments consisted of computer simulations of day lengths which occur naturally in the spring and autumn of the year. Both photoperiod treatments were given to hens in the autumn and spring.

3. Data were collected for growth evaluations at 2‐ to 4‐week intervals to 16 weeks of age. No significant season × photoperiod interactions occurred.

4. The spring trial resulted in greater body weights and better food conversions (food/gain) than the autumn trial.

5. Simulated autumn daylengths resulted in greater body weights and improved food efficiency at 16 weeks of age compared with simulated spring daylengths.

6. The pattern of growth (period changes) was influenced by season, but not photoperiod.

7. Season and photoperiod both have important and independent influences on the growth of the turkey hen.     

The effect of delaying the onset of laying in pullets with a low‐calcium diet on subsequent egg production

1. A low‐calcium diet (0.5 g calcium/kg) was used to prevent the onset of laying in young pullets.

2. It was fed at 16 weeks of age to five separate groups (groups 2 to 6) each of 50 to 60 birds.

3. Group 2 was fed on a normal layers’ diet at 23 weeks of age, group 3 at 27 weeks, group 4 at 31 weeks, group 5 at 35 weeks and group 6 at 55 weeks while the control group (group 1) of similar size to groups 2 to 6 was subjected to a normal commercial treatment for laying stock.

4. In all the experimental groups the onset of sexual maturity occurred normally, but only one or two eggs were laid before laying ceased under the influence of the treatment.

5. Laying re‐started when the hens were fed on a normal diet and production rapidly rose to a high level.

6. Groups 1, 2 and 3 differed little in the total number of eggs produced up to 72 weeks of age.

7. In all experimental groups there were fewer very small, small and medium eggs than in the control group.

8. It is suggested that the use of a low‐calcium diet before the onset of lay may have advantages which could be exploited on a commercial scale.     

Battery cage shape: Its effect on diurnal feeding pattern,egg shell cracking and feather pecking

1. Battery cages 460 mm in depth (deep) were compared with 305 mm cages (shallow); the two shapes provided equal areas per bird.

2. More eggs were produced per hen housed from 30 to 70 weeks in the shallow cages; the difference approached significance.

3. The pattern of feeding activity over the day was significantly more U‐shaped in the shallow cages; this pattern accords more closely with physiological requirements.

4. Feather damage caused by pecking was slightly but significantly more severe in the deep cages at 70 weeks.

5. The proportion of cracked eggs (collected from 60 to 70 weeks) was significantly lower in the shallow cages.

6. The arrangement of the hens was such that within the shallow cages a higher proportion of birds was present in the front half.

7. It is suggested that some of the advantages conferred by the shallow cage may be related to the greater accessibility of the food trough.     

Genotypic differences in speed and magnitude of response to ahemeral lighting

1. The paper compares between three genetically different lines in their egg weight and shell thickness response to a 28‐h cycle.

2. The response in shell thickness to ahemeral lighting was more rapid (2.2 d) than for egg weight (4.2 d).

3. Differences between genotypes were evident in both the speed and magnitude of response.

4. Overall, egg weight and shell thickness on the 28‐h cycle were 7% and 8% greater than on 24 h.

5. The allometric increase indicates that the increase in shell weight was on average 14% more than the increase in egg weight.     

Comparison of nutritive values of groundnut oil cake and Niger oil cake for laying pullets

1. The nutritive value of Niger oil cake (Guizotia abyssinica, Cass.) as a protein supplement for layers’ diets has been assessed.

2. Replacing groundnut oil cake (GNC) by Niger oil cake (NC) on an isonitrogenous basis, did not affect egg production, egg weight or the amount of food required per dozen eggs.

3. The percentage retention of nitrogen from diets containing 30% GNC or 30% NC was similar.

4. The ME value of NC used was 3025 kcal/kg.

5. It is concluded that NC can replace GNC in layers’ diets.     

Performance of a deep litter system for egg production

1. Medium hybrid hens were housed from 20 to 64 weeks in a deep litter house as flocks of 300, 370 and 370 and at stocking densities of 2–4 to 10–7 birds/m² in three successive laying cycles. Sister birds were housed in cages in an adjacent building as groups of 3 and 4, at 750 or 560 cm²/bird.

2. Hen housed egg production was lower on litter (208 to 235) than in cages (230 to 253). However, the estimated 52‐week values for litter were comparable to or better than standards published by the National Farmers’ Union.

3. Ambient temperatures were well controlled in both houses, but atmospheric dust and ammonia were a problem in the litter system and ammonia was a problem in the deep pit cage house. Litter condition was good at all stocking densities.

4. There was a trend for production to increase with stocking density on litter, but to decrease in cages.

5. Most egg quality variables were similar in the two systems, although there were more dirty eggs from litter and shell thickness was slightly greater in eggs from cages.

6. Body weight increase was initially faster in birds on litter; caged hens were equally heavy by the end of lay, but a greater proportion of their body mass was lipid.

7. The severity of feather damage and loss was correlated with stocking density for hens both on litter and in cages, being worse at the higher densities. Median cage scores were greater than values from litter at low densities but less than those from high densities. Beak trimming reduced feather damage on litter but had no effect in cages.

8. Mortality was low (1 to 3%) for all flocks, except those in year 3 which had not been beak trimmed and which suffered from cannibalism both in cages and on litter.     

Effect of oiling on internal quality of eggs stored at 28 and 12°G

1. The effects of spraying linseed oil on naturally clean eggs, subsequently stored for 24 d at 28 °C were studied.

2. Oiling slowed the decline in albumen height (Haugh units) to that which occurred in unoiled eggs stored at 12 °C.

3. Oiling slowed the increase in albumen pH equally at 28 and 12 °C.

4. Oiling markedly decreased the weight loss of eggs stored at either temperature.

5. Oiling and temperature of storage were without effect on the whipping volumes of either albumen or unseparated albumen and yolk.     

Performance of commercial laying hen genotypes on free range and organic farms in Switzerland,France and The Netherlands

1. A total of 257 farmers with free ranging laying hens (organic and conventional) in Switzerland, France and The Netherlands with 273 flocks were interviewed to determine the relationships between the genotype of the hens, management conditions and performance.

2. Almost 20 different genotypes (brands) were present on the farms. In France, all birds were brown feathered hens laying brown eggs. In Switzerland and The Netherlands, there were brown, white (white feathered hens laying white eggs) and silver (white feathered hens laying brown eggs) hens. In Switzerland, mixed flocks were also present.

3. The overall effect of system (organic vs. conventional free range) on egg production and mortality was significant, with higher mortality and lower egg production among organic hens. In pair wise comparisons within country, the difference was highly significant in The Netherlands, and showed a non-significant tendency in the same direction in Switzerland and France.

4. White hens tended to perform better than brown hens. Silver hens appeared to have a higher mortality and lower production per hen housed at 60 weeks of age.

5. There were no significant relationships between production, mortality, feather condition and use of outside run or with flock size.

6. There was more variation in mortality and egg production among farms with a small flock size than among farms with a large flock size.     

The incidence of bruising in broiler flocks

1. The amount of down‐grading due to bruising in 55 flocks of broilers was investigated.

4. Bruising was classified as light or bad bruising and it is suggested that this division represents two distinct types of bruises with different causes.

3. The incidence of bruising was greater in female flocks than in male although the bruising in the former tended to be less severe.

4. The relationships between incidence of bruising and several variables associated with the flock and the environment were examined using regression analysis. The factors shown to have a significant influence on the incidence of bruising were: the age and mean weight of the flock, and the temperature and humidity on the day of processing.