Comparison of radioimmunoassay and enzyme-linked immunosorbent assay for determining aflatoxin M1 in milk

Using a highly specific antibody against aflatoxin M1, a radioimmunoassay (RIA) and an enzyme-linked immunosorbent assay (ELISA) were developed for the quantitation of M1 in milk. RIA was sensitive in the range of 5-50 ng per assay but was subject to interference by whole milk. Extraction and cleanup were therefore necessary for the detection of M1 in milk at 0.5 ng/mL. An ELISA procedure was developed by using an aflatoxin M1-carboxymethyl-horseradish peroxidase conjugate as the ligand. Competitive assays revealed that this system was relatively more sensitive for M1 than for B1, and had a much lower degree of cross-reactivity for aflatoxins B2, G1, G2, B2a, and aflatoxicol. As low as 0.25 ng M1/mL in artificially contaminated milk (raw, whole, skim) could be detected by ELISA in 3 h without extraction or cleanup. Because of its simplicity, sensitivity, and specificity, ELISA is the preferred method for monitoring aflatoxin M1 in milk.     

Liquid chromatographic determination of aflatoxin M1 in milk

The official AOAC method for aflatoxin M1 in milk was modified by replacing cellulose column chromatography with cartridge chromatographic cleanup and replacing thin layer chromatographic (TLC) determination with liquid chromatographic (LC) quantitation to yield a new method for bovine and porcine milk. An acetone extract of milk is treated with lead acetate and defatted with hexane, and M1 is partitioned into chloroform as in the AOAC method. Chloroform is removed by evaporation under a stream of nitrogen at 50 degrees C. The residue is dissolved in chloroform, the vessel is rinsed with hexane, and the 2 solutions are applied in sequence to a hexane-activated silica Sep-Pak cartridge. Less polar impurities are removed with hexane-ethyl ether, and M1 is eluted with chloroform-methanol, and determined by C18 reverse phase LC using fluorescence detection. Recoveries of M1 added to bovine milk at 0.25, 0.50, and 1.0 ng/mL were 90.8, 93.4, and 94.1%, respectively. The limit of detection was less than 0.1 ng M1/mL for both bovine and porcine milk.     

Optimum conditions for formation of aflatoxin M1-trifluoroacetic acid derivative

Because thin-layer chromatographic (TLC) confirmation of identity and reverse-phase liquid chromatographic (LC) determination with fluorescence detection of aflatoxin M1 both require the derivative formed in the reaction of M1 and trifluoroacetic acid (TFA), various reaction conditions were studied to obtain complete derivative formation. Of the various organic solvents tested, the reaction between M1 and TFA proceeded best in the nonpolar solvents hexane and isooctane. Other parameters investigated were reaction temperature and time, aflatoxin M1 concentration, and solvent volume. The following procedure is considered optimum: 200 microL each of hexane and trifluoroacetic acid are mixed with M1 standard in a silylated glass vial or with milk residue in a regular glass vial with a Teflon-lined screw cap and heated 10 min at 40 degrees C. The mixture is evaporated to dryness under N2, and the derivative is saved for TLC or LC. No unreacted aflatoxin M1 was detected by reverse-phase LC after this procedure was incorporated for analysis of milk samples.     

Simple, rapid cleanup method for analysis of aflatoxins and comparison with various methods

A method is described for simple and rapid determination of aflatoxins in corn, buckwheat, peanuts, and cheese. Aflatoxins were extracted with chloroform-water and were purified by a Florisil column chromatographic procedure. Column eluates were concentrated and spotted on a high performance thin layer chromatographic (HPTLC) plate, which was then developed in chloroform-acetone (9 + 1) and/or ether-methanol-water (94 + 4.5 + 1.5) or chloroform-isopropanol-acetone (85 + 5 + 10). Each aflatoxin was quantitated by densitometry. The minimum detectable aflatoxin concentrations (micrograms/kg) in various test materials were 0.2, B1; 0.1, B2; 0.2, G1; 0.1, G2; and 0.1, M1. Recoveries of the aflatoxins added to corn, peanut, and cheese samples at 10-30 micrograms/kg were greater than 69% (aflatoxin G2) and averaged 91%, B1; 89%, B2; 91%, G1; 78%, G2; and 92%, M1. The simple method described was compared with the AOAC CB method, AOAC BF method, and AOAC milk and cheese method. These methods were applied to corn, peanut, and cheese composites spiked with known amounts of aflatoxins, and to naturally contaminated buckwheat and cheese. Recoveries were much lower for the BF method compared with our simple method and the CB method.     

Development of milk powder reference materials certified for aflatoxin M1 content (Part II): Certification of milk powder RM 283

The development of a full cream milk powder reference material, certified for its aflatoxin M1 content (target concentration: 0.1 microgram/kg), is described. The material (RM 283) was prepared and certified within the Reference Material Programme of the Community Bureau of Reference, along with other members of a series of milk powder reference materials. Homogeneity, evaluated by determining the aflatoxin M1 content of 30 units, was found to be acceptable (coefficient of variation of analysis results: 9.1%); stability has been demonstrated in a long-term study. The certification exercise involved 7 laboratories. Calibration, control of recoveries, blank values, and independence of the replicate measurements were emphasized. All sets of results of the certification exercise were accepted for statistical evaluation. A certified value for the aflatoxin M1 content: 0.09(+0.04)(-0.02) micrograms/kg was derived. The certification of RM 283 completes the series of 4 milk powder reference materials having certified aflatoxin M1 contents.     

Rapid high pressure liquid chromatographic determination of aflatoxin M1 in milk and nonfat dry milk

A modification of the current revised AOAC method, 26.A10-26.A15, is described for the rapid analysis of aflatoxin M1 in milk and nonfat dry milk. The method incorporates chloroform extraction and eliminates the need for column chromatography by using liquid-liquid partition for sample extract cleanup. Quantitation is carried out by using fluorescence detection combined with high pressure liquid chromatography (HPLC) of aflatoxin M1 which has been converted to aflatoxin M2a with trifluoroacetic acid. The method has a detection limit of 0.014 micrograms/L (2 X signal/noise) for whole milk. For 6 samples of naturally contaminated nonfat dry and freeze-dried milk, the modified method gave an average result of 0.698 micrograms/L; the AOAC method gave an average result of 0.386 micrograms/L.     

Solubility, tensile, and color properties of modified soy protein isolate films

Protein solubility (PS) values of different soy protein isolate (SPI) films were determined in water, 0.01 N HCl, 0.01 N NaOH, 4 M urea, and 0.2 M 2-mercaptoethanol. Tensile and color (L, a, and b values) properties of films also were determined. Control films were cast from heated (70 degrees C for 20 min), alkaline (pH 10) aqueous solutions of SPI (5 g/100 mL of water) and glycerin (50% w/w of SPI). Additional films were cast after incorporation of dialdehyde starch (DAS) at 10% w/w of SPI or small amounts of formaldehyde in the film-forming solutions. Also, control film samples were subjected to heat curing (90 degrees C for 24 h), UV radiation (51.8 J/m(2)), or adsorption of formaldehyde vapors. PS of control films was highest (P < 0.05) in 2-mercaptoethanol, confirming the importance of disulfide bonds in SPI film formation. All treatments were effective in reducing (P < 0.05) film PS in all solvents. Both DAS and adsorbed formaldehyde rendered the protein in films practically insoluble in all solvents. Adsorption of formaldehyde vapors and heat curing also substantially increased (P < 0.05) film tensile strength from 8.2 to 15.8 or 14.7 MPa, respectively. However, heat curing decreased (P < 0.05) film elongation at break from 30 to 6%. Most treatments had small but significant (P < 0.05) effects on b color values, with DAS-containing films having the greatest (P < 0. 05) mean b value (most yellowish). Also, DAS-containing, heat-cured, and UV-irradiated films were darker, as evidenced by their lower (P < 0.05) L values, than control films. It was demonstrated that PS of SPI films can be notably modified through chemical or physical treatments prior to or after casting.     

Determination of aflatoxicol and aflatoxins B1 and M1 in eggs

Procedures from 2 methods, one for aflatoxins B1 and M1 in eggs and one for aflatoxicol in milk, blood, and liver, have been combined to determine the 3 toxins in eggs. The sample is blended with sodium chloride-saturated water and this mixture is then blended with acetone. After separation from the solid residue, the aqueous acetone extract is defatted with petroleum ether. The toxins are next partitioned into chloroform and separated from interferences on a silica gel column. Aflatoxicol is determined by fluorescence measurement after separation on a C18 reverse phase liquid chromatographic column, and aflatoxins B1 and M1 are determined by fluorescence densitometry after separation on a silica gel thin layer chromatographic plate. In a recovery study with eggs, mean recoveries of aflatoxicol added at levels of 0.1, 0.05, and 0.025 ng/g were 87, 77, and 78%, respectively. Mean recoveries of aflatoxins B1 and M1 added at a level of 0.1 ng/g were 75 and 87%, respectively, and at an added level of 0.05 ng/g were 86 and 75%. The within-laboratory precision (repeatability) ranged from 2 to 13%.     

Naturally occurring estrogens in processed milk and in raw milk (from gestated cows)

The occurrence of the steroid hormones estrone (E1), 17alpha-estradiol (alphaE2), 17beta-estradiol (betaE2), and estriol (E3) in processed bovine milk with different fat contents and in raw milk from (non)gestated cows was investigated. Following liquid extraction, optional enzymatical deconjugation, C18 solid-phase extraction, and derivatization, estrogens were analyzed using liquid chromatography-tandem mass spectrometry (LC-MS/MS). Free and deconjugated E1 (6.2-1266 ng/L) was the major estrogen followed by alphaE2 (7.2-322 ng/L) and betaE2 (5.6-51 ng/L), whereas E3 was detected regularly at the detection limit of 10 ng/L. The lowest and highest concentrations were determined in raw milk from nonpregnant and from cows in the third trimester of gestation, respectively. The estrogen concentration in processed milk coincides with that of raw milk between first and second trimesters, reflecting the contribution of lactating pregnant cows to the final consumable product. The daily intake of total investigated estrogens through milk is 372 ng, which is dramatically more than currently recognized.     

Simultaneous determination of chloramphenicol and aflatoxin M1 residues in milk by triple quadrupole liquid chromatography-tandem mass spectrometry

A reliable, rapid, and sensitive liquid chromatography-tandem mass spectrometry (LC-MS/MS) method for simultaneous determination of chloramphenicol and aflatoxin M(1) in milk has been developed. This method includes simple extraction of sample with acetonitrile, separation on a MGIII-C(18) column using 5 mM ammonium acetate aqueous solution/methanol (60:40, v/v) as mobile phase, and MS/MS detection using multiple reaction monitoring mode. The method was validated according to Commission Decision 2002/657/EC. The limits of detection (LODs) were 0.05 μg/kg for chloramphenicol and 0.005 μg/kg for aflatoxin M(1.) The limits of quantification (LOQs) were 0.2 μg/kg for chloramphenicol and 0.02 μg/kg for aflatoxin M(1). The recovery values ranged from 88.8% to 100.6%, with relative standard deviation lower than 15% in all cases, when samples were fortified at three different concentrations. The decision limits (CCα) and detection capability (CCβ) of the method were also reported. This method has been successfully applied for simultaneous analysis of chloramphenicol and aflatoxin M(1) residues in milk from local supermarkets in China.     

Reverse phase liquid chromatographic determination and confirmation of aflatoxin M1 in cheese

A systematic method is proposed for determination and confirmation of aflatoxin M1 in cheese by liquid chromatography (LC). A sample of cheese is extracted with chloroform, cleaned up on 2 silica gel columns followed by a Sep-Pak C18 cartridge, and chromatographed on a 5 microns octadecyl silica column with fluorometric detection. The sample extract or standard is treated with n-hexane-trifluoroacetic acid (TFA) (4 + 1) for 30 min at 40 degrees C. Analysis by LC with TFA-treatment of the extract provides quantitative data. Multiple assays of 5 samples of Gouda cheese spiked with aflatoxin M1 at levels of 0.5, 0.1, and 0.05 ng/g showed average recoveries of 93.2, 91.6, and 92.4%, with coefficients of variation of 2.63, 3.97, and 4.52%, respectively. Assay of 5 naturally contaminated cheeses resulted in 0.051-0.448 ng/g of aflatoxin M1. Limit of quantitation is about 0.01 ng/g. The identity of aflatoxin M1 is confirmed by treating aflatoxin M1 or the M2a derivative with TFA-methanol (or ethanol) (3 + 1). The TFA-methanol reaction products of M2a could be detected quantitatively.     

Development and validation of an ultrasensitive chemiluminescent enzyme immunoassay for aflatoxin M1 in milk

A fast and ultrasensitive chemiluminescent enzyme immunoassay for aflatoxin M(1) in milk samples has been developed and validated. The method is an indirect competitive type format involving the immobilization of an aflatoxin M(1)-bovine serum albumin conjugate on 384 well black polystyrene microtiter plates and the use of a secondary antibody labeled with horseradish peroxidase detected with a luminol-based substrate. Aflatoxin M(1) standard solutions were prepared in milk-based buffer, and milk samples were analyzed without any cleanup procedure. The limit of quantification was 1 ppt, the coefficient of variation was below 9% for both intra- and interassay precision, and the recovery ranged from 96 to 122%. The method is specific, and other aflatoxins do not significantly cross-react with the antibody. Twenty-four milk samples were analyzed, and a good correlation was observed (y = 0.98x + 1.71, r(2) = 0.98, n = 24) when the data were compared with a reference high-performance liquid chromatography method with a fluorescent detector. The developed method is suitable for an accurate, sensitive, and high-throughput screening of aflatoxin M(1) in milk samples with a reduction of costs and increased detectability, as compared with previously developed immunoassays.     

Determination of aflatoxin M1 in milk by liquid chromatography with fluorescence detection

A liquid chromatographic (LC) method is proposed for the determination of aflatoxin M1 in milk. The method was successfully applied to both liquid whole and skim milk and also whole and skim milk powder. The samples are initially extracted with acetonitrile-water followed by purification using a silica gel cartridge and a C18 cartridge. Final analysis by LC was achieved using a radial compression module equipped with a 5 micron C18 column and a fluorescence detector. The method was successfully applied to samples at levels of 10 to 0.08 ppb added aflatoxin M1 with recoveries in the range of 70-98%.     

Rapid reverse phase liquid chromatographic determination of aflatoxin M1 in milk

A rapid, economical, and reliable liquid chromatographic (LC) method is described for determination of aflatoxin M1 in milk. The method includes an improved AOAC extraction procedure, cleanup of the extract on a silica cartridge, and LC quantitation. Alternatively, a rapid column cleanup procedure can be used. Milk artificially spiked with aflatoxin M1 at 0.05, 0.1, and 0.5 ppb was analyzed using both new approaches as well as an AOAC method coupled with LC for quantitation of the toxin. Recovery of aflatoxin M1 by the first approach of the new method ranged between 93.4 and 99.1%, and for the alternative procedure between 92.4 and 96.8%. The AOAC method gave lower recovery (85.6-90.7%) of toxin, but the results from this method had a somewhat smaller standard deviation for replicate analyses than did results of the new method.     

Inhibition of key aroma compound generated during ultrahigh-temperature processing of bovine milk via epicatechin addition

The ability of epicatechin (EC) to inhibit the thermal development of aroma compounds (i.e., Maillard reaction products) formed during ultrahigh-temperature (UHT) processing of bovine milk was evaluated. Volatile extracts were prepared for two UHT-processed milk samples made from (1) raw milk and (2) raw milk containing 0.1% EC by solvent-assisted flavor evaporation (SAFE) and subsequently analyzed by aroma extract dilution analysis (AEDA). Sensory evaluation was also conducted by a trained panel on the intensity of cooked flavor and bitterness in four UHT-processed milk samples (0.00, 0.01, 0.10, and 0.20% EC added prior to processing), as well as a commercial pasteurized milk sample for comparison. AEDA indicated that addition of EC to raw fluid milk prior to UHT processing reduced the overall thermal formation of key aroma-active compounds in comparison to the traditional UHT milk sample. The largest changes in FD values were reported for methional, furfural, 2-isopropyl-3-methoxypyrazine, 2-acetyl-1-pyrroline, and 2-acetyl-2-thiazoline (Maillard-type aroma compounds) with 32-, 8-, 8-, 4-, and 4-fold reductions in formation, respectively. Sensory evaluation also revealed that all EC-containing UHT milk samples had statistically (P < 0.05) lower cooked flavor intensity in comparison to the control, whereas the 0.2% EC sample was statistically similar to a pasteurized milk sample. Furthermore, addition of EC at or below 0.1% in UHT fluid milk did not significantly increase the bitterness intensity.     

Improved cleanup for liquid chromatographic analysis and fluorescence detection of aflatoxins M1 and M2 in fluid milk products

A rapid method is described for extraction and cleanup of raw and processed milk for determination of aflatoxins M1 and M2 by using a C18 Sep-Pak/silica gel cleanup column combination. Aflatoxins are separated by normal phase liquid chromatography and their concentrations are determined by fluorescence detection in a silica gel-packed flow cell. Recoveries ranged from 99 to 103% with coefficients of variation less than 2% for M1 levels of 0.117-1.17 ng/mL added to raw milk. Similar recoveries were obtained for M2. The coefficient of variation for analysis of 5 subsamples of naturally contaminated milk was less than 1%. Agreement with the official method is satisfactory. Each sample requires less than 25 mL solvent and 10 min actual handling time. Sample chromatograms show no interferences in the M1-M2 elution region and no late-eluting peaks, which permits spacing injections at 13-20 min intervals. Aflatoxin levels as low as 0.03 ppb may be determined by this procedure. Extracts have also been analyzed by thin layer chromatography.     

Rapid liquid chromatographic determination of aflatoxins M1 and M2 in artificially contaminated fluid milks: collaborative study

An international collaborative study involving 14 collaborators from 5 different countries was conducted to test a rapid liquid chromatographic (LC) method for detecting aflatoxins M1 and M2 in fluid milk. Each collaborator prepared artificially contaminated milk samples (0.078-1.31 ng M1/mL and 0.030-0.13 ng M2/mL) by adding solutions containing various concentrations of aflatoxins M1 and M2 to fresh milk. Recoveries ranged from 85.2 to 102.5% (av. 93.7%) for aflatoxin M1 and from 99.5 to 126.7% (av. 109.8%) for aflatoxin M2. Coefficients of variation averaged 21.4% (M1) and 35.9% (M2). An analysis of variance was calculated from combined data to determine variance components. The within-laboratory variations (So) (repeatability) were 27.9% (M1) and 23.9% (M2), and the among-laboratory variations (Sx) (reproducibility) were 44.5% (M1) and 64.7% (M2). No visual differences were determined between normal or reverse phase LC for contaminated samples; however, there were an insufficient number of collaborators using normal phase to give meaningful separate statistical data. For 26 observations of uncontaminated milk, 3 false M1 positives were reported for normal phase LC determinations and 2 false M1 positives were reported for reverse phase LC determinations. Three normal phase and 11 reverse phase false M2 positives were reported for 104 observations in uncontaminated milk. The reverse phase LC method for determination of aflatoxins M1 and M2 in fluid milk has been adopted official first action.     

Determination of aflatoxin M1 in milk and milk products contaminated at low levels

A new method is described for the determination of aflatoxin M1 in milk and dairy products by thin layer chromatography. The main characteristic is the extraction system using an alkaline solution. Lipids are removed by centrifuging at low temperatures, and the aflatoxins are then extracted with CHCl3. The method has 2 options: Technique II (detection limit 0.02 ppb) requires cleanup on a chromatographic column; this is not necessary in Technique I (detection limit 0.1 ppb). The recovery rate in both techniques is over 92.8% in milk and yoghurt. This method may also be used for other aflatoxins. Because of the advantages of the method, Technique II is recommended for aflatoxin M1 control in milk, where a low detection limit is necessary. Technique I is proposed for experimental aflatoxin production studies in dairy products, which require analysis of a large number of samples but which do not require a very low detection limit.     

Development of milk powder reference materials certified for aflatoxin M1 content (Part I)

The development of 3 full-cream milk powder reference materials, certified for their aflatoxin M1 content, is described. The materials were prepared and certified within the Reference Material Programme of the Community Bureau of Reference (BCR). The 3 reference materials, RMs 282, 284, and 285, contain aflatoxin M1 at concentrations of less than 0.05, 0.31 +/- 0.06, and 0.76 +/- 0.05 micrograms/kg, respectively. The preparation, testing for homogeneity, stability of the reference materials, and the certification exercise, which was preceded by 2 intercomparisons of methods, are discussed. Particular emphasis was placed on the independence of the measurements in the certification exercise and the control of errors associated with extraction efficiency and the aflatoxin M1 calibrant. Finally, some guidance is given on avoiding the principal sources of errors in the determination of aflatoxin M1. Details concerning the supply of the reference materials will be provided by BCR on request.     

Rapid thin layer chromatographic determination of aflatoxin M1 in powdered milk

A method has been developed for the detection of aflatoxin M1 in milk. The toxin is extracted with chloroform, the extract is evaporated, and the residue is partitioned between carbon tetrachloride and an aqueous saline-methanol solution. The toxin is once again extracted with chloroform from the methanol solution and analyzed by thin layer chromatography. The limit of detection of M1 in powdered milk is 0.5 microgram/kg; recoveries of added M1 are about 83%. The limit of detection can be improved to 0.3 microgram/kg if the plate is sprayed with an aqueous solution of H2SO4 after development.