马铃薯交联淀粉醋酸酯的制备工艺及特性

马铃薯原淀粉在水相体系、碱性条件下与醋酸酐作用，生成马铃薯淀粉醋酸酯，然后与交联剂进行交联反应，得到马铃薯交联淀粉醋酸酯。通过改变反应温度、反应时间、pH值和交联剂用量等条件，得出制取马铃薯交联淀粉醋酸酯的最佳工艺条件：反应温度35℃，pH值11，反应时间2 h，交联剂用量2%。所制取的马铃薯交联淀粉醋酸酯较原淀粉在糊液黏度的稳定性、抗老化性、抗分离性等方面均有较大的改善。     

甲醛交联工业碱木质素-聚乙烯醇薄膜的力学性能(英文)

以工业碱木质素和聚乙烯醇为原料,以甲醛为交联剂,利用流延法制备了碱木质素-聚乙烯醇交联反应膜。通过单因素实验探索了碱木质素含量、甲醛含量、反应温度、交联时间、溶液p H值对碱木质素-PVA反应膜力学性能的影响。经甲醛交联反应,交联反应薄膜液的黏度大于共混薄膜液的黏度。结果表明,制备最佳力学性能薄膜的条件为碱木质素和聚乙烯醇的质量比为2∶8、甲醛占干物质量为8.8%、交联时间为40 min、反应温度为90℃、p H值为9。在保持薄膜仍然具有较好力学性能的前提下,碱木质素的加入量可达到20%。在最佳力学性能条件下,纯聚乙烯醇薄膜和碱木质素-聚乙烯醇交联薄膜的断裂伸长率分别是205%和236%,拉伸强度分别是52和46 MPa。与纯聚乙烯醇薄膜相比,反应薄膜的断裂伸长率得到了提高,而拉伸强度降低。适当量的交联剂和较高的溶液温度有利于薄膜力学性能的提高。由于木质素在碱性条件下溶解,溶液p H值对薄膜的力学性影响较大。红外衰减全反射分析证明碱木质素和聚乙烯醇之间发生了交联反应。与纯聚乙烯醇薄膜相比,由于碱木质素的加入使聚乙烯醇分子间的距离增大,使薄膜内分子流动性增大,碱木质素-聚乙烯醇反应薄膜的能量损耗和玻璃化转变温度降低。该研究为制备具有良好力学性能的薄膜提供了详细的数据。     

脱水热处理改善鱼皮明胶可食膜的性能

为了改良鱼皮明胶可食膜的性能,拓宽可食膜的资源,以罗非鱼皮为原料提取明胶制备可食膜,考察了脱水热处理对其理化性质的影响。结果发现罗非鱼皮明胶中亚氨基酸含量为19.3%,主要由β链和α链组成,制备的可食膜其抗拉伸强度（tensile strength,TS）达37.5 MPa。80℃热处理对明胶膜的理化性质无明显的影响。当热处理温度提高到100℃或120℃时,伴随热处理明胶膜的TS逐渐增大而溶解性逐渐降低。在热处理过程中,膜的颜色略微变黄,但断裂延伸率和透明度却无明显的变化。SDS-PAGE 图谱和明胶膜在蛋白变性剂中的溶解性结果显示,高于100℃的热处理使明胶α链和β链发生交联,增强疏水相互作用和共价键在明胶膜中的贡献,使膜的玻璃化转变温度得到提高。以上结果表明,脱水热处理可改善鱼皮明胶膜的机械性能、耐水性能和热稳定性,有利于拓宽可食膜的资源和鱼皮明胶膜的应用。     

明胶酶解物捕获甲醛工艺的优化及其应用

为控制鱿鱼丝制品中的甲醛含量,以食用明胶酶解物为甲醛捕获剂,采用响应面法对捕获条件进行优化,并将明胶酶解物运用到秘鲁鱿鱼丝加工中,改良生产工艺,降低鱿鱼丝制品甲醛含量。结果表明,p H、温度、时间对明胶酶解物的甲醛捕获率均有显著影响,明胶酶解物捕获甲醛的最佳条件为:温度94.04℃,时间87.04 min,p H值8.99,明胶酶解物浓度1%,该条件下甲醛捕获率达94.12%。在鱿鱼丝加工中,蒸煮前将鱿鱼片浸泡在含1%明胶酶解物的溶液(料液比1∶3)中6 h,制得的鱿鱼丝成品甲醛含量为7.49 mg·kg~(-1),极显著低于原工艺组鱿鱼丝甲醛含量(13.21 mg·kg~(-1)),且对鱿鱼丝的口味和色泽无影响。综上,明胶酶解物具有较好的甲醛捕获能力,能抑制鱿鱼丝加工中甲醛的产生。本试验结果为生产食用安全的鱿鱼丝提供了指导。     

高密度二氧化碳对牛初乳的杀菌效果及对理化性质影响

高密度二氧化碳（DPCD）杀菌技术是目前越来越受关注的非热杀菌技术之一。本文研究了20 MPa、37℃条件下DPCD对牛初乳的杀菌效果。并探讨了经过处理后牛初乳粒度、黏度、色泽、pH值等的变化。结果表明在20 MPa、37℃的DPCD处理30 min以上条件能较好地杀灭牛初乳中的细菌,同时牛初乳发生了色泽变亮、粒度增大、黏度和pH值均降低等变化。     

高凝胶性蛋白粉制取工艺条件优化

为了进一步改善高凝胶蛋白粉的品质,探讨了利用酶交联反应制取高凝胶蛋白粉的新方法,在进行了琥珀酰化酪蛋白添加量、反应pH值、转谷氨酰胺酶添加量对蛋白粉凝胶强度影响的单因素试验基础上,该文通过响应面分析法对制取高凝胶性蛋白粉的酶交联反应条件进行了优化,并通过SDS-PAGE电泳、扫描电镜等手段探讨了酶交联蛋白粉凝胶性能增加的机理。结果表明,最佳工艺条件为:琥珀酰化酪蛋白添加量2.29%、反应pH值5.87、转谷氨酰胺酶添加量1.06%、反应温度40℃、反应时间40min。理论最大凝胶值为1072.8g/cm2,验证值为1054.5g/cm2,说明预测模型可靠性高,可用于反应条件的优化。     

凋落物中次生代谢物对森林土壤可溶性氮的影响

通过外加性质不同的凋落物以及不同浓度的单宁酸,于武夷山不同海拔高度的森林土壤中进行培养,研究森林凋落物中次生代谢物对土壤可溶性氮(N)的影响。结果显示,土壤经加入凋落物处理,其可溶性N含量降低。加入杉木凋落物使红壤可溶性N含量降低12.0%～27.5%,杉木较竹叶凋落物处理降低作用显著(p0.05);对黄红壤添加不同浓度单宁酸处理显示,与对照比较,高浓度单宁酸可显著(p0.001)降低土壤可溶性N含量,降低幅度在40.6%～48.1%,而低浓度单宁酸对土壤可溶性N的影响不显著。表明植物凋落物,尤其是杉木对土壤可溶性N的影响很可能与其本身单宁酸含量差异有关,从而影响了土壤可溶性有机N和无机N的转化。     

不同灭酶处理对燕麦气味和品质的影响

为选择合适的灭酶处理方法,通过电子鼻、感官评价和快速黏度分析等方法,对5种灭酶处理（焙炒、常压蒸煮、高压蒸煮、远红外处理和微波加热）对燕麦粉的气味、色泽和糊化特性的影响进行了研究。研究表明：燕麦粉的电子鼻主成分分析（PCA）二维和三维指纹图谱均可将不同灭酶处理的样品明显区分开来;样品的感官评价气味值由高到低依次为：焙炒组,红外组,高压蒸煮组,常压蒸煮组,微波组;样品白度检测结果由高到低依次为：红外组,微波组,焙炒组,蒸煮组,与色泽的感官评价结果基本一致,微波组和红外组的色泽明显优于其他3组的色泽。样品的糊化特性指标中,除糊化温度外,其他6项快速黏度分析（RVA）特征值均差异显著。由此说明,不同灭酶处理对燕麦粉的气味、色泽和糊化特性均有不同影响,应结合燕麦粉的不同用途选用不同的灭酶处理。     

食用明胶的酶解及其酶解物的甲醛捕获特性研究

以氨基含量为响应值,通过Box-Behnken中心组合试验对碱性蛋白酶酶解食用明胶的工艺条件进行优化,并进一步研究明胶酶解物的甲醛捕获特性.结果表明:(1)碱性蛋白酶酶解食用明胶的最佳工艺条件为:加酶量2667U·g-1,温度61℃,pH值8.0,时间180min,在此条件下,所得酶解液的氨基含量为0.277mol·L-1.(2)酶解物能捕获甲醛,其甲醛捕获率受酶解物浓度、反应温度、反应时间及pH值的显著影响,与酶解物浓度、反应温度和反应时间呈正相关,碱性环境有利于酶解物对甲醛的捕获.100℃反应1h,1％浓度酶解物的甲醛捕获率在pH值为7时达51.09％,pH值为9时高达82.77％.     

明胶涂膜保持猪背最长肌冷藏期间新鲜度

与传统的包装材料相比,冷鲜肉的明胶涂膜处理具有众多优势,这也决定其具有广阔的发展前景。为研究明胶涂膜处理对生鲜肉冷藏期间氧化稳定性和新鲜度的影响。该文以猪背最长肌为材料,研究其经过不同浓度(0%、10%、20%)明胶涂膜处理后冷藏期间的加压失水率、脂肪氧化、蛋白质氧化、血红素铁、挥发性盐基氮以及肉色的变化情况。结果表明:猪背最长肌在4℃条件下冷藏第3、5和7 d时,明胶涂膜处理组的硫代巴比妥酸反应值、蛋白质羰基、血红素铁质量分数、挥发性盐基氮值、红度值以及高铁肌红蛋白质量分数分别与对照组比较,结果均存在显著性差异(P0.05)。此外,在冷藏时间相同的条件下,10%与20%明胶涂膜处理组之间均差异不显著(P0.05)。试验证实,明胶涂膜处理有益于提高冷藏期间肉品的氧化稳定性,维系理想的肉品色泽及延长其货架期。     

Alteration of kafirin and kafirin film structure by heating with microwave energy and tannin complexation

Heating with microwave energy and tannin complexation of kafirin both increase the tensile strength of cast kafirin bioplastic films. The effects of these treatments on the molecular structure of kafirin and of kafirin in the film were investigated. SDS-PAGE of heated wet kafirin showed an increase in kafirin oligomers. Disulfide groups increased in heated kafirin and in films made from the heated kafirin. Fourier transform infrared (FTIR) spectroscopy of heated kafirin and films made from the heated kafirin indicated an increase in beta-sheet conformation. In contrast, kafirin complexation with tannic acid (TA) and sorghum condensed tannin (SCT) resulted in a slight decrease in beta-sheet conformation in the kafirin and a larger decrease in the kafirin in the films. Raman spectroscopy showed that, with TA, there was a shift in peak from 1710 to 1728 cm(-1) for kafirin-tannic acid complexes, indicating kafirin and tannic acid interaction. The protein conformational changes presumably facilitated cross-linking between kafirin molecules and/or between kafirin and the tannins. Thus, although both heating with microwave energy and tannin complexation cause cross-linking of kafirin to increase film tensile strength, their effects on kafirin structure appear to be different.     

Inhibition of iron uptake by phytic acid, tannic acid, and ZnCl2: studies using an in vitro digestion/Caco-2 cell model.

The objective of this study was to document the effects of phytic acid, tannic acid, and zinc on iron uptake in an in vitro digestion/Caco-2 cell culture model. The effects of phytic acid and tannic acid on iron uptake were measured at increasing molar ratios of FeCl3 to phytic acid or tannic acid. Maximal inhibition of iron uptake by phytic acid occurred at a 1:10 ratio of Fe to phytic acid. Dialyzable Fe decreased with a low Fe to phytic acid ratio but increased with Fe:phytic acid ratios greater than 1:3 indicating that more iron was soluble at higher phytic acid levels but less available. As in human studies, heme iron was less inhibited by phytic acid than nonheme iron. Tannic acid was a more potent inhibitor of nonheme iron uptake, as maximal inhibition (97.5%) of iron uptake occurred at a ratio of 1:1 or less. The addition of ZnCl2 to the digest at ratios of 1:0.5 and 1:1 decreased iron uptake by 57 and 80%, respectively. Overall, the results agree qualitatively with studies in humans and demonstrate the relative effects of these compounds on iron uptake in this model system. This study provides key information for determining iron availability under more complex meal conditions.     

Use of Tannic Acid as Dough Oxidizing and Vitamin C Protective Agent

Trials with tannic acid in three concentrations (0.1, 0.2, and 0.3%) in a wheat flour dough were run to test its property to preserve the ascorbic acid degradation during baking and its performance in the dough viscoelasticity measured by its extensigraphic properties. The addition of tannic acid to the dough in the cited concentrations increased its resistance to extension (RE) and consequently reduced its extensibility (E) in the same way that ascorbic acid performed but using concentrations 10× smaller. In a dough containing ascorbic acid 0.02% and tannic acid 0.3%, the ascorbic acid retention after 10 days of storage was 34.8%, which represents 154% of the recommended daily intake of vitamin C by FAO/WHO (2002) for an adult (19–65 years old). The addition of tannic acid to the dough also increased the bread specific volume.     

单宁酸对不同pH茶园土壤中活性铝形态分布的影响

采集云南省普洱市和江西省南昌县两地典型的茶园土壤,通过添加HCl和Ca(OH)2调节土壤pH,研究不同pH(3.0、3.5、4.0、4.5)茶园土壤添加0.4 mmol·kg 1、2.0 mmol·kg 1、4.0 mmol·kg 1、8.0 mmol·kg 1、12.0 mmol·kg 1单宁酸后,活性铝形态交换态铝(Al3+)、单聚体羟基铝[Al(OH)2+、Al(OH)+2]、酸溶无机铝[Al(OH)03]和腐殖酸铝[Al-HA]的分布特征。结果表明:单宁酸添加量为0~0.4 mmol·kg 1和0~2.0 mmol·kg 1时,江西南昌和云南普洱茶园土壤中交换态铝随土壤pH的增加呈明显下降趋势,而羟基态铝、酸溶无机铝和腐殖酸铝呈逐渐上升趋势;当单宁酸浓度增至2.0 mmol·kg 1以上时,随土壤pH的增加,单宁酸对活性铝释放的抑制作用增强,各形态活性铝含量都较低,且不同pH处理土壤间的差异不显著。0~20 cm土层土壤与20~40 cm土层土壤变化规律大致相似,总体上看,下层土壤活性铝总量高于上层。云南普洱茶园土壤活性铝总量明显高于江西南昌的茶园土壤。相关分析表明,0~20 cm土层土壤中,pH与羟基态铝、腐殖酸铝、土壤酸碱缓冲容量(pHBC)呈正相关(r=0.796,P0.01;r=0.960,P0.01;r=0.852,P0.01);pHBC与交换态铝、羟基态铝呈负相关(r=0.904,P0.01;r=0.645,P0.05),而与腐殖酸铝呈正相关(r=0.795,P0.01)。同时,单宁酸加入浓度为0~0.4 mmol·kg 1时,土壤pH明显上升,之后随着单宁酸加入浓度的增加土壤pH持续下降,土壤pH(YpH)与单宁浓度(CDN)在此阶段基本符合方程:YpH=0.04CDN+3.82(R2=0.95,P0.01)的线性变化趋势,在单宁酸浓度达到8.0~12.0 mmol·kg 1时,土壤pH基本不再变化。     

Models for tetracycline in aquatic environments

The interactions of tetracycline with model clay adsorbents has been studied as a function of suspension pH, ionic strength, and adsorbate concentration. The model clay adsorbents were the Na, Ca, and dodecyltrimethylammonium forms of bentonite and a tannic acid covered bentonite. The adsorption isotherms were of the Langmuir type and the adsorption capacity decreases in the order tannic acid-clay > Ca-clay > Na-clay > dodecyltrimethylammonium-clay. The adsorption onto the clay substrates decreases as the ionic strength and pH increases.     

Free radical scavenging capacity in the aging of selected red Spanish wines

Free radical scavenging capacity by the DPPH(*) method and main physicochemical properties, polyphenols content by HPLC, color by a tristimulus colorimeter, and UV-vis spectra in the aging of selected red Spanish wines, were studied. As the wines age, they become darker (lower lightness, L) and increase their hue angle (lower red color) as well as the ratio of absorbance at 420 nm to that at 520 nm. Main polyphenolics identified in the samples were tannic acid, oenin, and gallic acid. The antiradical efficiency of the samples increased during aging, which could be related to an increase in the tannic acid concentration shown by the following correlationship: EC(50) = 1/(0.18 + 0.0011[tannic acid](mg/L)) with a correlation coefficient of 0.744.     

Transglutaminase catalyzed cross-linking of sodium caseinate improves oxidative stability of flaxseed oil emulsion

Sodium caseinate was modified by transglutaminase catalyzed cross-linking reaction prior to the emulsification process in order to study the effect of cross-linking on the oxidative stability of protein stabilized emulsions. The extent of the cross-linking catalyzed by different dosages of transglutaminase was investigated by following the ammonia production during the reaction and using SDS-PAGE gel. O/W emulsions prepared with the cross-linked and non-cross-linked sodium caseinates were stored for 30 days under the same conditions. Peroxide value measurement, oxygen consumption measurement, and headspace gas chromatography analysis were used to study the oxidative stability of the emulsions. The emulsion made of the cross-linked sodium caseinate showed an improved oxidative stability with reduced formation of fatty acid hydroperoxides and volatiles and a longer period of low rate oxygen consumption. The improving effect of transglutaminase catalyzed cross-linking could be most likely attributed to the enhanced physical stability of the interfacial protein layer against competitive adsorption by oil oxidation products.     

线性和非线性方法估计单宁酸共存下形成的无定形铝氧化物上菲的吸附等温线参数比较

采用批实验研究了菲在单宁酸干扰下形成的不同晶形铝氧化物上的吸附现象,并用不同的吸附等温线方程对吸附平衡数据进行了拟合,重点比较了线性和非线性回归方法估计吸附等温线参数的差异。结果表明:菲在各种晶形的铝氧化物上都有明显的吸附,但并不是完全随着单宁酸含量和结晶度的变化而规律性变化。吸附平衡数据以Langmuir、Redlich-Peterson和Dubinin-Radushkevich吸附等温方程,用不同的回归方法估计的等温线参数值均有显著性差异。线性回归得到的参数有不确定性,表明用线性回归来判断吸附等温线能否对吸附平衡数据进行最优拟合是不可靠的。相反,非线性回归能较好地确定菲在不同晶形铝氧化物上的最佳吸附等温线及相应参数。采用R2和χ2共同检验发现,菲在4种不同结晶度(单宁酸与铝的摩尔比(MR)=0,10-3,10-2,10-1)铝氧化物上的最佳吸附等温线方程并不尽相同,分别为Freundlich,Freundlich,Dubinin-Radushkevich和Freundlich,反映了各种晶形的铝氧化物的表面异质性。修正的Freundlich方程比较不同晶形铝氧化物对菲的相对吸附容量顺序为:MR=10-3MR=10-2MR=0MR=10-1。由此,认为菲在无定形铝氧化物上的吸附是熵驱动的结果。     

New method for evaluating astringency in red wine

Astringency is an important sensory attribute of red wine. It is usually estimated by tasting and is subject to a certain subjectivity. It can also be estimated by using the gelatin index. This procedure is not very reproducible because there are many gelatins on the market with a heterogeneous composition. Furthermore, the gelatin index determines procyanidin concentration by acid hydrolysis that gives only an approximate result. This paper proposes a new and reproducible method that determines astringency by using ovalbumin as the precipitation agent and tannic acid solutions as standards. Statistical analysis of the results indicates that this method is more reproducible (RSD = 5%) than the gelatin index (RSD = 12%) and correlates better with sensorial analysis.