Effect of restricted postweaning growth resulting from reduced floor and feeder-trough space on pig growth performance to slaughter weight in a wean-to-finish production system

The effect of reduced pig growth rate postweaning as a result of restricted floor space and feeder trough space on subsequent growth to slaughter was investigated in a wean-to-finish system. Crossbred pigs (n = 1,728) were used in a randomized block design with a 2 x 2 x 2 factorial arrangement of treatments: 1) floor space (high [0.630 m2/pig] vs. low floor space [0.315 m2/pig]), 2) feeder trough space (unrestricted [4 cm/pig] vs. restricted feeder trough space [2 cm/pig]), and 3) period of imposing floor- and feeder-trough-space treatments (12 vs. 14 wk postweaning). Growth performance was measured from weaning (5.5 +/- 0.01 kg of BW; 17 d of age) to slaughter (the end of wk 25 postweaning). From the end of the treatment period to the end of wk 25, pigs on all treatments had the same floor and feeder trough space. Pigs with low floor space had lower (P < 0.01) ADG, ADFI, and gain:feed ratio than those with high floor space, and were therefore lighter (P < 0.05) at the end of the postweaning treatment period. Pigs given the restricted feeder trough space had lower (P < 0.05) ADFI, similar (P > 0.05) ADG, and higher (P < 0.01) gain:feed ratio than those with unrestricted feeder trough space during the treatment period. Pigs in the 14-wk treatment period had higher (P < 0.01) ADG and ADFI, but lower gain:feed than those in the 12-wk treatment during that period. In the subsequent period, from the end of treatment to wk 25, there was an interaction (P < 0.05) between floor space and treatment period; the difference in ADG and gain:feed for pigs on low vs. high floor space was greater for the 14-wk than the 12-wk treatment period. However, low-floor-space pigs tended (P = 0.06) to be lighter than high-floor-space pigs at the end of wk 25 postweaning. Neither feeder trough space nor treatment period affected pig growth performance during the period from the end of treatment to wk 25. Carcass backfat and longissimus depths at the end of wk 25 were not influenced (P > 0.05) by treatment. In summary, pigs with restricted growth due to low floor space until either 12 or 14 wk postweaning had increased growth and feed efficiency in the subsequent period to wk 25 postweaning, with only a slight effect on BW and no effect on carcass measures.     

Two reduced nocturnal temperature regimens for early-weaned pigs

Two experiments, each consisting of three trials and using 3- to 4-wk-old newly weaned pigs, were conducted to evaluate the effects of two reduced nocturnal temperature regimens on weaned pig and subsequent growing-finishing performance and nursery energy (propane and electricity) use. In Exp. 1, nursery treatments were 1) a control temperature (CT) regimen of 30 degrees C constant air temperature lowered 2C degrees/wk and 2) a regimen for pigs in pens with hovers (MRNT-H) in which the temperature from 1900 to 0700 beginning 1 wk after weaning was lowered 6 C degrees from the 0700 to 1900 temperature setting, which was 3C degrees lower than CT. The nursery temperature treatments in Exp. 2 were 1) CT and 2) a 10C degrees reduction in air temperature (MRNT10) from 1900 to 0700 from CT beginning 1 wk after weaning. In addition, within each temperature, diet sequences of 1.2% lysine for 3 wk followed by 1.0% lysine vs 1.15% lysine offered continuously were evaluated. In Exp. 1, there was no effect (P greater than .1) of temperature on feed intake but ADG decreased (P less than .001) in two of the three trials for MRNT-H vs CT and feed/gain worsened (P less than .05) in all trials. In Exp. 2, there was no difference between MRNT10 and CT for ADG and feed/gain. No interaction was observed between nursery diet and temperature regimen for weaned pig performance. There was no effect (P greater than .1) in either experiment of nursery temperature on subsequent growing-finishing performance. Overall energy savings comparing the MRNT-H and CT treatments were 68 MJ per weaned pig. Energy savings for Exp. 2 were 79 MJ per weaned pig. Application of cyclical temperatures in a controlled manner can result in energy savings of approximately $50 per pig weaned under the conditions of these experiments.     

Impact of early postweaning growth rate as affected by diet complexity and space allocation on subsequent growth performance of pigs in a wean-to-finish production system

The objective was to evaluate the effect of restricted early postweaning growth rate due to diet complexity, pen space, or both on subsequent growth to market in a wean-to-finish system. Pigs (n = 1,728) were used in a randomized block design with a 2 x 2 factorial arrangement of treatments: 1) diet complexity (Complex vs Simple) and 2) space allocation (Unrestricted vs Restricted). Treatments were imposed for the first 8 wk after weaning (period 1) and growth was measured from weaning (5.0 +/- 0.01 kg body weight; 15 d of age) to the end of wk 23 postweaning. The Simple diet was based on corn-soybean meal with minimal inclusion of milk products, processed cereals, and animal protein-based ingredients compared to the Complex diet. Floor and feeder-trough spaces were 0.63 m2 and 4 cm and 0.21 m2 and 2 cm per pig for Unrestricted and Restricted space treatments, respectively. From the end of wk 8 to end of wk 23 (period 2), pigs on all treatments had the same floor and feeder spaces and were fed common diets. There was no interaction (P > 0.05) between diet and space treatments. In period 1, Simple diets resulted in similar average daily feed intake (ADFI; 639 vs 650 +/- 5.4 g; P > 0.05), but lower average daily gain (ADG; 408 vs 424 +/- 3.8 g; P < 0.01) and gain:feed ratio (0.64 vs 0.65 +/- 0.002; P < 0.001), and lighter body weight (2.8%; P < 0.01) compared to the Complex diets. In period 2, growth was not affected (P > 0.05) by previous diet complexity, and pig body weight was similar (114.4 vs 114.4 +/- 0.37 kg, P > 0.05) at the end of wk 23. In period 1, pigs with Restricted space had lower ADG (398 vs 434 +/- 3.8 g; P < 0.001), ADFI (621 vs 668 +/- 5.4 g; P < 0.001), and gain:feed ratio (0.64 vs 0.65 +/- 0.002; P < 0.01), and were lighter at the end of wk 8 (6.5%; P < 0.001) than those with Unrestricted space. However, in period 2, pigs with Restricted space had higher (P < 0.01) ADG (3%), ADFI (2%), and gain:feed ratio (3%) than those with Unrestricted space, and body weight was similar (114.5 vs 114.3 +/- 0.37 kg; P > 0.05) at end of wk 23. Carcass backfat and loin-eye depth at market body weight were influenced by neither diet nor space treatment. Using a simple diet program and restricted space allowance immediately postweaning resulted in a lower early growth rate, but had no impact on pig body weight or carcass measures at market.     

Effect of pig weaning weight and associated nursery feeding programs on subsequent performance to 105 kilograms body weight

An experiment using a total of 210 crossbred pigs from two farrowing groups evaluated the effects of three weaning weights and their associative starter feeding program on subsequent postweaning performance to 105 kg BW. One group of pigs nursed their dams in outside heated hutches (Trial 1), and a second group was raised in a centrally heated farrowing house (Trial II). The three pig weaning weight groups ranged in weight from 1) 4.1 to 5.0 kg, 2) 5.5 to 6.8 kg, and 3) 7.3 to 8.6 kg. Pigs in Group 1 were fed a high nutrient dense diet (HNDD) for a 2-wk period followed by a corn-soybean meal-dried whey (C-SBM-DW) and then a corn-soybean meal (C-SBM) diet, each for a 2-wk period. Group 2 was fed the same diet sequence except that HNDD was provided for 1 wk, whereas Group 3 was provided only the C-SBM-DW and the C-SBM diets each for 2 wk, consecutively. At the end of the nursery period, pigs were fed C-SBM diet formulations to 105 kg BW. Pigs of Trial I averaged 5.2 d older at weaning than those raised in the central farrowing house, but only a 1.5-d difference existed between light- and heavy-weight groups in both trials. Gains and feed intakes for the three weaning groups were higher as weaning weight increased during both the nursery and the growing-finishing period. There did not seem to be a compensatory growth response for lighter-weight weanling pigs even though they had been fed starter diets containing milk products. Consequently, fewer days (approximately 15) were required for the heavier-weight weanling pig group to reach a final weight of 105 kg than for the light-weight group. The medium-weight group required an intermediate number of days to reach 105 kg.     

Weaning weight response of pigs to simple and complex diets

Five experiments were conducted to determine (1) the value of simple vs complex diets on gains and feed conversion of pigs weaned at a constant age but varying in weight, (2) the optimum postweaning time to change from a complex to a simple diet and (3) the effect of previous treatment on subsequent performance. In the first experiment, pigs were weaned at 3 wk +/- 3 d and assigned within four weight groups (4.1, 5.0, 5.6 and 6.7 kg) to a simple or complex diet that was fed for 28 d. The complex diet improved (P less than .01) pig performance in all weight groups. As anticipated, the heavier pigs (5.6 and 6.7 kg) ate more (P less than .02) and grew faster (P less than .03) than did their lighter weight littermates (4.1 and 5.0 kg). The second experiment involved pigs weaned at 3 wk +/- 3 d that were assigned within two weight groups (4.4 and 6.6 kg) and fed a complex diet for 10 d, after which one-half of each weight group was switched to a simple diet. Pigs fed the complex diet for the entire 24-d period gained faster (P less than .05) and were more efficient (P less than .05) than those changed to the simple diet after 10 d. The heavier weight (6.6 kg) pigs ate more (P less than .02) and gained faster (P less than .02) than did the lighter weight (4.4 kg) pigs.(ABSTRACT TRUNCATED AT 250 WORDS)     

Effects of grouping unfamiliar cohorts, high ambient temperature and stocking density on live performance of growing pigs

Ninety-six crossbred intact male pigs (34.5 +/- 3.5 kg BW) were allocated by weight and vocalization score to a 2 x 2 x 2 dynamic experimental design including two stocking densities (1 or 2 m(2)/pig), two temperatures (22 degrees C and 30 degrees C), and two short groupings of unfamiliar cohorts (six pigs as one pig per group, and six pigs per group). The study was conducted over 8 wk, and live weight gain (WTG) and feed intake (FI; as-fed basis) were measured weekly. During the first week, pigs were housed in individual pens from four independent rooms. To group pigs, pen partitions were removed. Pigs were grouped in Rooms 2 and 3 from wk 2 to 4, and in Rooms 1 and 4 during wk 7. Temperature was increased from 22 degrees C to 30 degrees C in Rooms 1 and 2 during wk 4 and 7. Pen partitions were replaced in Rooms 2 and 3 at the end of wk 4 and in Rooms 1 and 4 at the end of wk 7 to return pigs to their individual pens. Grouping pigs decreased FI during wk 3 (15.08 +/- 0.43 vs. 14.03 +/- 0.41 kg P < 0.10), and during wk 7 (17.42 +/- 0.46 vs. 14.24 +/- 0.41 kg; P < 0.01). In addition, grouping had a negative effect (P < 0.001) on WTG at wk 3 (7.38 +/- 0.28 vs. 5.71 +/- 0.28 kg) and at wk 7 (6.70 +/- 0.26 vs. 2.99 +/- 0.26 kg). For grouped pigs, raising the temperature decreased (P < 0.01) WTG (7.49 +/- 0.29 vs. 6.41 +/- 0.29 kg during wk 4, and 3.37 +/- 0.38 vs. 2.62 +/- 0.38 kg during wk 7). Mean FI was decreased (P < 0.01) with the 30 degrees C treatment during wk 7 only (15.49 +/- 0.33 kg at 22 degrees C compared with 12.99 +/- 0.33 kg at 30 degrees C). Compensatory feed intake was evident after the treatments had ceased at wk 6, whereby previously heat-treated grouped pigs had a higher FI (17.97 +/- 0.45 kg) than the animals individually housed at 22 degrees C (12.99 +/- 0.33 kg). Stocking density effects were noted after the grouping and high temperature treatments had ceased. For instance, during wk 5, low-density-housed pigs grew faster (P < 0.001) than their high-density counterparts (9.04 +/- 0.38 vs. 7.49 +/- 0.29 kg). In conclusion, under the conditions of this study, the grouping of unfamiliar cohorts and high ambient temperature treatments had a detrimental effect on pig performance, and these effects were reversible.     

Effect of pharmacological concentrations of zinc oxide with or without the inclusion of an antibacterial agent on nursery pig performance

A study involving nine research stations from the NCR-42 Swine Nutrition Committee used a total of 1,978 crossbred pigs to evaluate the effects of dietary ZnO concentrations with or without an antibacterial agent on postweaning pig performance. In Exp. 1, seven stations (IA, MI, MN, MO, NE, ND, and OH) evaluated the efficacy of ZnO when fed to nursery pigs at 0, 500, 1,000, 2,000, or 3,000 mg Zn/kg for a 28-d postweaning period. A randomized complete block experiment was conducted in 24 replicates using a total of 1,060 pigs. Pigs were bled at the 28-d period and plasma was analyzed for Zn and Cu. Because two stations weaned pigs at < 15 d (six replicates) and five stations at > 20 d (18 replicates) of age, the two sets of data were analyzed separately. The early-weaned pig group had greater (P < 0.05) gains, feed intakes, and gain:feed ratios for the 28-d postweaning period as dietary ZnO concentration increased. Later-weaned pigs also had increased (P < 0.01) gains and feed intakes as the dietary ZnO concentration increased. Responses for both weanling pig groups seemed to reach a plateau at 2,000 mg Zn/kg. Plasma Zn concentrations quadratically increased (P < 0.01) and plasma Cu concentrations quadratically decreased (P < 0.01) when ZnO concentrations were > 1,000 mg Zn/kg. Experiment 2 was conducted at seven stations (KY, MI, MO, NE, ND, OH, and OK) and evaluated the efficacy of an antibacterial agent (carbadox) in combination with added ZnO. The experiment was a 2 x 3 factorial arrangement in a randomized complete block design conducted in a total of 20 replicates. Carbadox was added at 0 or 55 mg/kg diet, and ZnO was added at 0, 1,500, or 3,000 mg Zn/ kg. A total of 918 pigs were weaned at an average 19.7 d of age. For the 28-d postweaning period, gains (P < 0.01), feed intakes (P < 0.05), and gain:feed ratios (P < 0.05) increased when dietary ZnO concentrations increased and when carbadox was added. These responses occurred in an additive manner. The results of these studies suggest that supplemental ZnO at 1,500 to 2,000 mg Zn/kg Zn improved postweaning pig performance, and its combination with an antibacterial agent resulted in additional performance improvements.     

Effects of dietary dried whey and corn oil on weanling pig performance, fat digestibility and nitrogen utilization

Two experiments were conducted to evaluate the effects and interactions of dietary levels of corn oil (0 vs 6%) and dried whey (0 vs 25%) on performance of young pigs during a 4-wk postweaning period. The first experiment, conducted in five replicates as a 2 x 2 factorial in a randomized block design, evaluated gain and feed intakes of 172 pigs weaned at 21 d of age. Pigs were bled at weekly intervals, and samples were assayed for serum triglyceride and urea concentrations. In a second experiment, 36 barrows in three replicates were used to evaluate the same treatments on apparent digestibility and absorption of fat and N retention during each week of a 4-wk postweaning period. The dietary inclusion of dried whey resulted in greater gains and feed intakes and reduced feed-to-gain ratios during each week of the postweaning period, with the largest relative improvement occurring during wk 1. Supplemental corn oil did not enhance pig gains the first 3 wk postweaning, but response improved by wk 4. Feed intakes were slightly (P less than .10) lower when corn oil was provided. The inclusion of corn oil resulted in an improved feed-to-gain ratio (P less than .01), particularly evident during wk 3 and 4 postweaning. Neither gain nor feed utilization were improved by added corn oil during the initial 2-wk postweaning period regardless of dried whey addition. Apparent digestibilities of fat were unaffected at each weekly interval by dietary dried whey inclusion.(ABSTRACT TRUNCATED AT 250 WORDS)     

Added dietary pyridoxine, but not thiamin, improves weanling pig growth performance

We conducted two trials to determine the effects of added dietary pyridoxine (vitamin B6) or thiamin (vitamin B1) on growth performance of weanling pigs. In Exp. 1, weanling pigs (n = 180, initially 5.55 +/- .84 kg, and 21 +/- 2 d of age) were fed either a control diet (no added pyridoxine or thiamin) or the control diet with added thiamin (2.8 or 5.5 mg/kg) from thiamin mononitrate or pyridoxine (3.9 or 7.7 mg/kg) from pyridoxine HC1. These five diets were fed in meal form in two phases (d0 to 14 and 14 to 35 after weaning), with identical vitamin concentrations in both phases. From d 0 to 14 after weaning, pigs fed added pyridoxine had increased (quadratic, P < .05) ADG and ADFI; pigs fed 3.9 mg/kg of added pyridoxine had the greatest improvement. From d 14 to 35 and 0 to 35, ADG and ADFI increased (linear P = .06) for pigs fed increasing pyridoxine. Growth performance was not improved by added thiamin. In Exp. 2, weanling pigs (n = 216, initially 6.08 +/- 1.13 kg, and 21 +/- 2 d of age) were fed a control diet or the control diet with 1.1, 2.2, 3.3, 4.4, or 5.5 mg/kg of added pyridoxine from pyridoxine HCl. From d 0 to 14 after weaning, increasing pyridoxine increased (quadratic, P < .05) ADG and ADFI; pigs fed 3.3 mg/kg of added pyridoxine had the greatest ADG and ADFI. Break-point analysis suggested a requirement estimate of 3.3 and 3.0 mg/kg of added pyridoxine to maximize ADG and ADFI, respectively. From d 14 to 35 or 0 to 35, increasing pyridoxine had no effect (P > .10) on pig growth performance. These results suggest that adding 3.3 mg/kg of pyridoxine (7.1 to 7.9 mg/kg of total pyridoxine) to diets fed from d 0 to 14 after weaning can improve pig growth performance.     

Effect of birth and fraternal litter size and cross-fostering on growth and reproduction in swine

Twelve hundred fifty-one pigs from six farrowings (FGRP) were classified within a FGRP by their birth litter size (BL- = below average and BL+ = above average), randomly allotted to nursing litter sizes of 6 or 12+ pigs/sow (NL- vs NL+) and reared by their own or foster dams (XF- vs XF+). Pigs were weighed at birth, 21 d and when near 105 kg. A random sample of 40 gilts per FGRP was retained for observation of pubertal age and primipara conception. Twenty-four gilts per FGRP were farrowed and rebred for a second parity. Pigs born in large litters were younger at 105 kg than those born in small litters (189 vs 196 d +/- 1.4); no other differences (P greater than .05) were observed for BL. Pigs reared in larger litters had lower survival rate from birth to weaning (79 vs 86% +/- 1), had slower weight gains to 21 d of age (5.3 vs 6.6 kg +/- .17) and were older at 105 kg (195 vs 190 d +/- 1.4) than those reared in small litters (P less than .04). Cross-fostered pigs were slower gaining to 21 d (5.9 vs 6.1 kg +/- .14) and were older at 105 kg (195 vs 191 d +/- 1.4) than pigs not cross-fostered pigs (P less than .02). Growth beyond 105 kg and pubertal age were unaffected by any factor studied (P greater than .05). Although size of birth litter did not affect (P greater than .05) any reproductive trait, an interaction between litter size and farrowing group was detected.(ABSTRACT TRUNCATED AT 250 WORDS)     

Effects of blood meal pH and irradiation on nursery pig performance

A total of 720 nursery pigs in three experiments were used to evaluate the effects of blood meal with different pH (a result of predrying storage time) and irradiation of spray-dried blood meal in nursery pig diets. In Exp. 1, 240 barrows and gilts (17 +/- 2 d of age at weaning) were used to determine the effects of blood meal pH (7.4 to 5.9) in diets fed from d 10 to 31 postweaning (7.0 to 16.3 kg of BW). Different lots of dried blood meal were sampled to provide a range in pH. Overall (d 0 to 21), pigs fed diets containing blood meal had greater ADG (P < 0.05) and ADFI (P < 0.05) than pigs fed diets without blood meal. Ammonia concentrations in blood meal rose as pH decreased. However, blood meal pH did not influence (P > 0.16) ADG, ADFI, or gain:feed (G:F). In Exp. 2, 180 barrows (17 +/- 2 d of age at weaning) were used to determine the effects of post drying pH (7.6 to 5.9) and irradiation (gamma ray, 9.5 kGy) of blood meal on growth performance of nursery pigs from d 5 to 19 postweaning (6.8 to 10.1 kg of BW). One lot of whole blood was isolated with 25% of the total lot dried on d 0, 3, 8, and 12 after collection to create a range in pH. Overall, pigs fed blood meal had improved G:F (P < 0.01) compared to pigs fed the control diet. Similar to Exp. 1, the ammonia concentration of blood meal increased with decreasing pH. Blood meal pH did not influence ADG, ADFI, or G:F (P > 0.21), but pigs fed irradiated blood meal (pH 5.9) had greater ADG and G:F (P < 0.05) than pigs fed nonirradiated blood meal (pH 5.9). In Exp. 3, 300 barrows (17 +/- 6 d of age at weaning) were used to determine the effects of blood meal irradiation source (gamma ray vs. electron beam) and dosage (2.5 to 20.0 kGy) on growth performance of nursery pigs from d 4 to 18 postweaning (8.7 to 13.2 kg of BW). Overall, the mean of all pigs fed blood meal did not differ in ADG, ADFI, or G:F (P > 0.26) compared to pigs fed the control diet without blood meal. Pigs fed irradiated blood meal had a tendency (P < 0.10) for increased G:F compared with pigs fed nonirradiated blood meal. No differences in growth performance were detected between pigs fed blood meal irradiated by either gamma ray or electron beam sources (P > 0.26) or dosage levels (P > 0.11). These studies suggest that pH alone as an indicator of blood meal quality is not effective and irradiation of blood meal improved growth performance in nursery pigs.     

Group size and floor-space allowance can affect weanling-pig performance

Crossbred weanling piglets (n = 1,920; mean initial BW, 5.3 +/- .7 kg) were used in two 9-wk trials employing a randomized block design in a 2 x 2 factorial arrangement of treatments to determine effects of group size (20 [Small = S] or 100 [Large = L] pigs/pen) and floor-space allowance (calculated requirement [CR] or calculated requirement less 50% of estimated "free space" [CR-50]) on growth performance. Free space was estimated for each group size. From wk 1 through 4 after weaning, S and L groups at CR were allowed a floor space of .17 m2/pig, and at CR-50, S and L groups were allowed .15 m2/pig and .13 m2/pig, respectively. From wk 5 through 9 after weaning, all CR treatment pigs were provided a floor space of .38 m2/pig, and for the CR-50 treatment, S and L pigs were allowed .32 m2/pig and .28 m2/pig, respectively. Piglets had free access to feed and water. Feeder-trough space per pig was the same for both group sizes. Feed-intake data were collected for only wk 1 through 4. Group size by floor-space allowance interactions (P < .05) were found for gain/feed ratio (G/F) for wk 1 and wk 2 through 4, but not for wk 1 through 4. Piglets in L groups were lighter (P < .001) at the end of wk 1, 4, and 9 by 2, 4, and 5%, respectively, and had lower ADG (6%; P < .001) throughout the trial than S piglets. During wk 1 through 4, feed intake was lower (7%, P < .001) in L piglets than in S piglets, but G/F was similar (P > .05). Piglets in CR groups had greater ADG (5%; P < .01) throughout the trial, with a greater G/F (P < .05) for wk 1 through 4, and were heavier (P < .01) than those in CR-50 groups at the end of wk 4 (3%) and 9 (4%). Pigs in L groups had a greater within-pen coefficient of variation in BW at the end of wk 9 than pigs in S groups. Large groups and reduced floor-space allowance reduced piglet growth performance in the nursery.     

Effects of feeder-trough space and variation in body weight within a pen of pigs on performance in a wean-to-finish production system

Two studies were carried out with the same group of pigs within a wean-to-finish system. In Study 1 (weaning to wk 8 postweaning), the effect of feeder-trough space in pens that were double-stocked on pig growth was evaluated. In Study 2 (end of wk 8 to 112 +/- 1.5 kg BW), the effect of variation in pig BW within a pen on growth was investigated. In Study 1, a randomized block design was used to compare two feeder-trough space treatments (Double [4 cm/pig] vs Control [2 cm/pig]). Pigs (n = 1,728) were randomly allocated at weaning (5.4 +/- 0.01 kg BW; 16 d of age) to mixed-sex pens (8 pens/treatment) of 108 pigs/pen on the basis of BW. Floor-space (0.30 m2/pig) and drinker allocation (13 pigs/drinker) were the same for both treatments. Two six-place (35 cm/place) feeders were positioned together in the center of each pen and were accessible from both sides. For the Double treatment, both feeders contained feed, whereas for the Control only one feeder contained feed. In Study 2, a randomized block design was used to compare three BW/variation in BW treatments: 1) Heavy BW/Low variation, 2) Light BW/Low variation, and 3) Mixed BW/Normal variation. The double-stocked pens of pigs from within previous feeder-trough space treatment were split into two groups of 54 pigs (equal sex ratio) having either high or low BW variation within pen. Pigs had free access to feed and water throughout the studies. In Study 1, doubling feeder-trough space did not affect (P > 0.05) pig growth from weaning to the end of wk 6. From wk 6 to 8, pigs on the Double treatment compared to the Control treatment had higher (P < 0.05) ADG and were heavier (P < 0.05), but had similar (P > 0.05) ADFI and gain:feed ratio. In Study 2, pen-BW treatment did not impact (P > 0.05) ADG or gain:feed ratio; however, Heavy/Low had greater (P < 0.01) ADFI than Light/Low with Mixed/Normal being intermediate for ADFI. At 112 kg BW, CV of BW within a pen was similar (P > 0.05) across treatments; however, days to market BW was greater (P < 0.001) for Light/Low than Heavy/ Low with Mixed/Normal being intermediate. In summary, increasing feeder-trough space from 2 to 4 cm per pig increased daily gain after wk 6 postweaning in double-stocked pens of pigs; however, sorting pigs on the basis of BW when splitting pens did not impact growth rate or variation in BW within a pen at market BW.     

Photoperiod and heat stress influence on lactating sow performance and photoperiod effects on nursery pig performance

Three experiments were conducted to evaluate sow and piglet productivity under extended photoperiod. In Exp. 1, 98 crossbred, lactating sows were housed in one of four treatments: thermoneutral air temperature (23.6 degrees C) in either (h of light:dark) 1:23 or 16:8 photoperiods, or heat stress (30.4 degrees C) in either 1:23 or 16:8 photoperiods. Heat stress reduced (P less than .05) sow feed intake, piglet mortality and piglet weaning weight and increased (P less than .01) sow lactation weight loss. Number of pigs weaned per litter was increased (P less than .01) when sows were heat-stressed. Extended photoperiod reduced (P greater than .05) time for sows to rebreed postweaning by .4 d. The interaction between air temperature and photoperiod was significant only for sow lactation weight loss. Heat stress increased sow lactation weight loss, but this effect was more severe in the 1:23 than in the 16:8 photoperiod. Experiments 2 and 3 examined the effects of 1:23 or 16:8 photoperiods on nursery pig performance when pigs were weaned from sows experiencing 1:23 (Exp. 3) or 16:8 (Exp. 2) photoperiods. In both nursery studies, photoperiod did not influence (P greater than .10) postweaning pig mortality, feed intake, weight gain or gain:feed ratio. In conclusion, extended photoperiod reduced days to return to estrus and reduced sow lactation weight loss, especially during heat stress. No benefits in preweaning or postweaning piglet weight or survival were observed by use of extended photoperiod.     

A modified reduced nocturnal temperature regimen for early-weaned pigs

A four-trial experiment utilizing 3- to 4-wk-old newly weaned pigs was conducted to evaluate the effect of a modified reduced nocturnal (MRNT) nursery temperature regimen on weaned pig and subsequent grower-finisher performance. Nursery treatments were 1) a control temperature (CT) regimen of 30 degrees C constant air temperature lowered 2 degrees C/wk and 2) a regimen beginning 1 wk after weaning in which the temperature from 1900 to 0700 was lowered 6 degrees C from CT. Weaned pigs gained faster (P less than .01) in the MRNT treatment than in the CT treatment, with gains in Trials 1, 2, 3 and 4 being .39 vs .37, .28 vs .27, .38 vs .37 and .39 vs .36 kg/d, respectively. This improvement in gain was due to an increase (P less than .005) in feed intake for the same periods (.60 vs .58; .48 vs .42; .59 vs .58; .63 vs .58 kg/d). There was no difference in feed conversion (P greater than .1). There was no effect (P greater than .1) of MRNT vs CT on subsequent performance to slaughter weight for average daily gain (.69 vs .69 kg/d), average daily feed (2.22 vs 2.23 kg/d) or gain/feed (.31 vs .31). These results support the conclusions that weaned pigs eat more feed and gain faster with a reduced nocturnal temperature scheme and that there are no carry-over effects during the growing-finishing phase.     

Effect of nutritional status, age at weaning and room temperature on growth and systemic immune response of weanling pigs

Two experiments were conducted to determine the effect of nutritional status, age at weaning and room temperature on growth and immune response of pigs. In the first experiment, 72 pigs were weaned at either 2 or 3 wk and fed either a complex, simple-adequate or simple-inadequate diet for a 24-d period. Total antibody (TAb) titers in response to injections of human red blood cells (RBC) on either 0, 4, or 16 d postweaning were not affected by age at weaning or dietary treatments even though the nutritional status was compromised to such an extent that pigs fed the simple-adequate diet gained at one-half the rate (.172 vs .349 kg/d) of pigs fed the complex or simple-adequate diets (P less than .01). In Exp. 2, the immunological response of 144 pigs weaned at 3 wk were evaluated at 4 and 8 d postweaning. Pigs were weaned into rooms that averaged either 25 or 18 C, and were fed either a complex or simplex-adequate diet at either ad libitum (AL) or restricted (Res) levels for a 24-d period. Restriction of either the complex or simple diet for the first 16 d of the trial drastically reduced (P less than .01) the growth rates of Res pigs compared with AL pigs (.042 vs .236 kg/d). There were no differences in skinfold thickness (Sf) or TAb, 2-mercaptoethanol sensitive (MEs) and resistant (MEr) antibody titers when pigs were inoculated with phytohemagglutinin-P (PHA-P) or RBC at 4 d postweaning regardless of room temperature, diet source or feeding level.(ABSTRACT TRUNCATED AT 250 WORDS)     

Liquid diets accelerate the growth of early-weaned pigs and the effects are maintained to market weight

Piglets (n = 240, 11.0+/-0.1 d old, 3.93+/-0.05 kg) were allotted to one of four treatments in a 2 x 2 factorial arrangement to examine the effects of diet physical form and nursery environment during the first 14 d after weaning on growth to market weight. During the treatment period, pigs were housed (10 pigs/ pen) in either a conventional hot nursery (30 degrees C) or a segregated-temperature nursery (cool ambient temp. of 24 degrees C, with enclosed hot-box hovers at 32 degrees C). Pigs in each environment were fed nutritionally identical diets in either liquid or dry-pellet form for 14 d. Subsequently, all pigs were fed identical dry diets and were housed in common grower-finisher facilities (penned by sex, five pigs/pen). At the end of the treatment period (d 14), pigs fed the liquid diet were 21% heavier than pigs fed the dry pellet diet (9.22 vs 7.60 kg; P < 0.001). Similarly, gain, feed intake, and gain/feed of liquid-fed pigs were 44%, 18%, and 22% greater, respectively, than observed for pigs fed the dry pellet diet. No main effect of environment was observed (P > 0.10); however, an interaction with diet physical form occurred during the early-nursery period (P < 0.01). Pigs fed the liquid diet showed better performance in the conventional nursery, whereas pigs fed the dry pellet diet were favored in the segregated-temperature nursery. No major differences in growth performance or in ultrasound carcass measurements were detected during the growing-finishing period; however, the advantage in body weight of liquid-fed pigs gained during the first 2 wk postweaning was maintained to the end of the trial (113.9 vs 110.6 kg; P < 0.05). Pigs that were fed the early-nursery diet in liquid form reached market weight (110 kg) 3.7 d sooner than the dry-fed controls (P < 0.01). Estimates of lean gain (calculated from live ultrasound data) were unaffected, suggesting that composition of growth was not altered. Collectively, these results show that liquid feeding during early life can markedly accelerate piglet growth performance and that the growth advantage is maintained to market weight, with no evidence of compensatory gain in the dry-fed control pigs.     

Growth performance and intestinal morphology responses in early weaned pigs to supplementation of antibiotic-free diets with an organic copper complex and spray-dried plasma protein in sanitary and nonsanitary environments

The objective of this study was to determine the effects of addition of spray-dried plasma protein (SDPP) and Cu to nonmedicated diets on growth performance and intestinal morphology in weaned pigs reared in sanitary or nonsanitary environments. Weanling pigs (n = 192, 18 +/- 2 d of age, 6.0 +/- 0.2 kg of BW) were assigned to 8 treatments arranged factorially, including 2 dietary levels of SDPP (0 or 6% for the initial 10 d), 2 levels of added dietary Cu (0 or 200 ppm for the entire 35-d experiment), and 2 pen sanitation conditions (sanitized or nonsanitized before pig placement). The nonsanitary pen condition was created by 3 applications of swine manure slurry to all pen surfaces in 1 room and not washing or disinfecting. In an identical adjacent room, sanitary pens were washed and disinfected before weaning. There were 4 pigs per pen, and feed and water were available ad libitum. Growth performance was determined at the end of each diet formulation phase (d 10, 20, and 35 after weaning). On d 10, 1 pig per pen was euthanized, and cross sections of duodenum, jejunum, and ileum were collected for microscopic assessment of mucosal morphology. During the initial postweaning period, SDPP, and Cu supplementation improved ADG and ADFI (P < 0.001). A trend for an interaction of sanitation x dietary SDPP (P = 0.07) was observed for G:F, with a positive response to the supplement in nonsanitary pens but no response in sanitary pens. There were no interactions of SDPP and Cu for any performance variables (P > 0.30). By d 35, there were no main or interaction effects of treatment on ADG or G:F (P > 0.17). Pen sanitation condition produced morphological effects, with shorter villous length and less crypt depth observed in each intestinal segment for pigs reared in the nonsanitary pens (P < 0.05), but these effects must be considered conditional based on the potential confounding influence of separate nursery rooms. In the duodenum, reduced crypt depth with Cu supplementation (P = 0.01) and a tendency for greater villous length with SDPP supplementation (P = 0.09) were observed. In this study, SDPP and Cu supplementation improved pig growth performance during the initial 10-d postweaning. These modifications to nonmedicated diets acted independently with regard to their impacts on postweaning performance and, therefore, could have additive effects.     

Early weaning to reduce tissue mobilization in lactating sows and milk supplementation to enhance pig weaning weight during extreme heat stress

This study was conducted to determine the effect of reduced lactation length and supplemental milk replacer (MR) during high ambient temperatures. Thirty nine primiparous and 100 multiparous sows (PIC, Franklin, KY, C-22) were used in a 2 x 2 x 2 factorial arrangement of treatments. Treatments consisted of two lactation room temperatures (21 degrees C [TN] and 32 degrees C [HOT]), two lactation lengths (14 or 19 d), and two parity groups (primiparous, multiparous). Pigs were either: 1) sow-reared to 19 d or 2) sow-reared to 14 d, and then reared to 19 d with MR after sow removal. All sows were fed the same diet (1.07% lysine, 3,366 kcal of ME/kg). Sows were weighed and ultrasound for backfat thickness (BF) and longissimus muscle area (LMA) within 6 h after farrowing and at the time of sow removal (d 14 or 19). Pigs were individually weighed at weaning (d 19) and after a 47-d nursery period (d 66). Heat stress increased sow weight loss (-13.35 kg, P < 0.01) and decreased sow feed intake (4.63 kg/d, P < 0.01) during lactation compared with sows in TN (+4.5 kg and 7.5 kg/d, respectively). Early weaning (d 14) during heat stress decreased maternal weight loss (-10.1 vs. -16.6 kg, P < 0.01). Primiparous sows lost more BF in both environments (-2.60 vs. -1.56 mm, P < 0.05), and both parity groups lost more BF (-3.35 vs. -2.3 mm, P < 0.10) and LMA (-1.82 vs. -0.77 cm2, P < 0.05) when lactating for 19 d in the HOT environment than those lactating for 14 d. Pigs nursing primiparous and multiparous sows in the HOT environment and provided MR had heavier individual 19-d weights (7.37 and 8.12 kg/ pig, respectively) than those nursing to 19 d (5.57 and 6.04 kg/pig, P < 0.01). Milk replacer decreased the difference normally observed in 19-d weights between primiparous and multiparous sow-reared pigs in TN. Pigs fed MR in both environments and nursing multiparous sows had improved weight gains in the nursery compared with pigs nursing sows to 19 d (428 vs. 406 g/d, respectively; P < 0.01), or reared by primiparous sows (444 vs. 390 g/d , respectively; P < 0.01). Sow weaning on d 14 in the HOT environment decreased the wean-to-estrus interval in primiparous sows (22.8 vs. 9.2 d, P < 0.10). This study shows the benefit of early weaning in combination with milk replacer to preserve the sow and to restore pig weaning weights and nursery end weights under heat stress.     

Effects of double stocking and weighing frequency on pig performance in wean-to-finish production systems

Two studies were carried out in different wean-to-finish barns to determine the effects of double stocking on pig growth performance. In Study 1, pigs (n = 1,560) were used in a randomized complete block design with a 2 x 2 factorial arrangement of treatments: initial stocking treatment (Single [52 pigs/pen] vs Double [104 pigs/pen] stocked for 10 wk after weaning) and weighing frequency (High [12 times during the study] vs Low [3 times]) on pig performance from weaning (5.9+/-0.01 kg BW; 17 d of age) to harvest (114+/-0.67 kg BW). Floor and feeder space per pig were 0.650 m2 and 4 cm and 0.325 m2 and 2 cm for the single- and double-stocked treatments, respectively. In Study 2, pigs (n = 1,458) were used in a randomized complete block design to evaluate two initial stocking treatments (Single [27 pigs] vs Double [54 pigs] stocked for 10 wk after weaning) on pig performance from weaning (4.8+/-0.01 kg BW; 15 d of age) to harvest (24 wk after weaning). Floor and feeder space per pig were 0.640 m2 and 3.4 cm and 0.320 m2 and 1.7 cm for single- and double-stocked pens, respectively. In both studies, double-stocked pigs were split at the end of wk 10 into two equal-sized groups of similar mean BW and CV of BW, and one group was moved to a different pen in the same building. In Study 1, performance was not affected (P > 0.10) by frequency of weighing. For the first 10 wk after weaning, the Double compared to the Single treatment had lower ADG (7.7 and 7.9%, for Studies 1 and 2, respectively; P < 0.001) and lighter pigs at wk 10 (6.8 and 7.3%, respectively; P < 0.001). During the first 10 wk in Study 1, Double compared to the Single pigs had lower ADFI (7%; P < 0.001) but similar gain:feed (P > 0.10). From wk 11 to harvest, pigs on Double and Single treatments had similar (P > 0.10) ADG in both studies and, in Study 1, ADFI was unaffected by initial stocking treatment, but double-stocked pigs had greater gain:feed (4%, P < 0.01). Double-stocked pigs required an additional 2 d to reach a fixed harvest BW (P < 0.05) in Study 1 and were lighter (4%; P < 0.05) at 24 wk after weaning in Study 2. Carcass measures were similar (P > 0.10) for double- and single-stocked pigs. Double-stocked pigs that were moved at the end of 10 wk had growth performance similar (P > 0.10) to those that remained in the original pen. In summary, double stocking reduced growth rate to 10 wk after weaning but subsequently had no effect on growth rate and improved feed efficiency.