Possibilities for preservation of coarse particles in pelleting process to improve feed quality characteristics

Poultry diets are mainly used in pelleted form because pellets have many advantages compared to mash feed. On the other hand, pelleting causes reduction of feed particle size. The aim of this research was to investigate the possibility of increasing the content of coarse particles in pellets, and, at the same time, to produce pellets with satisfactory quality. In this research, the three grinding treatments of corn were applied using hammer mill with three sieve openings diameter: 3 mm (HM‐3), 6 mm (HM‐6) and 9 mm (HM‐9). These grinding treatments were combined in pelleting process with three gaps between rollers and the die of pellet press (roller‐die gap, RDG) (0.30, 1.15 and 2.00 mm) and three moisture contents of the pelleted material (14.5, 16.0 and 17.5%). The increased coarseness of grinding by the hammer mill resulted in the increased amount of coarse particles in pellets, especially when the smallest RDG was applied (0.30 mm), but pellet quality was greatly reduced. Increasing of RDG improved the quality of pellets produced from coarsely ground corn, but reduced the content of coarse particles in pellets and increased specific energy consumption of the pellet press. Increasing the moisture content of material to be pelleted (MC) significantly reduced energy consumption of the pellet press, but there was no significant influence of MC on particle size after pelleting and on the pellet quality. The optimal values of the pelleting process parameters were determined using desirability function method. The results of optimization process showed that to achieve the highest possible quantity of coarse particles in the pellets, and to produce pellets of satisfactory quality, with the lowest possible energy consumption of the pellet press, the coarsest grinding on hammer mill (HM‐9), the largest RDG (2 mm) and the highest MC (17.5%) should be applied.     

Effect of feed particle size and feed processing on morphological characteristics in the small and large intestine of pigs and on adhesion of Salmonella enterica serovar Typhimurium DT12 in the ileum in vitro

A 2 x 2 factorial experiment with pigs was undertaken to investigate the effect of particle size (fine and coarse) and feed processing (pelleted and nonpelleted) on morphological characteristics in the small intestine, cecum, and colon of pigs and on the adhesion of Salmonella enterica serovar Typhimurium DT12 to the ileum in vitro. Ninety-six pigs (average BW = 33 +/- 7 kg) were fed the experimental diets. After 4 wk, 24 pigs were selected (six pigs per diet) and euthanized, and tissue samples were taken from the mid and distal small intestine, cecum, and distal colon. The effects of particle size and feed processing on villus height and crypt depth in the small intestine were minor. Feeding coarse diets increased (P = 0.05) the crypt depth in the colon. The crypt depth was 420 +/- 12 and 449 +/- 12 microm in pigs fed finely and coarsely ground feed, respectively. Pigs fed pelleted diets had a larger (P = 0.01) staining area for neutral mucins, as well as for acidic and sulfomucins on the villi of the distal small intestine than pigs fed nonpelleted diets. The area was 41, 46, and 33% larger for neutral, acidic, and sulfomucins, respectively. The mucin-staining areas of the crypts in the cecum and the colon were not affected by the experimental diets. Examination of lectin binding characteristics of the distal small intestine and the cecum did not reveal any differences between the experimental diets. Using a pig intestine organ culture model, Salmonella adhered less (P < 0.05) to the ileal tissue of pigs fed the nonpelleted diets than to those fed pelleted diets; the adherence was 60% less in these pigs. Results of this study suggest that pigs fed pelleted diets secrete mucins that are capable of binding Salmonella enterica serovar Typhimurium DT12 and thereby allowing for colonization. Therefore, pigs fed a nonpelleted diet are better protected against Salmonella infections than pigs fed a pelleted diet.     

Lower grinding intensity of cereals for dietetic effects in piglets?

The grinding intensity of cereals as ingredients of pelleted diets has various effects on pigs' health and performance. Feeding a coarsely ground diet (62.2% of particles > 1 mm; 10% < 0.4 mm) to piglets resulted in significantly higher starch contents in the hindgut chyme and increased counts of gram positive bacteria, but had no significant effect on dry matter (DM) digestibility. The combination of coarse grinding and addition of 1.2% potassium diformate (pdf) to the diet led to interesting effects in piglets infected experimentally with Salmonella Derby (single oral dose of 4.4 × 10¹⁰ cfu per piglet). In spite of the same infectious dosage in all piglets a marked reduction of Salmonella counts was found in chyme of piglets (sacrificed 4–6 h after experimental infection) when the coarsely ground diet including pdf was fed. It seems that coarse grinding of ingredients could have numerous dietetic advantages: reducing risks of Salmonella infection (faster elimination) as well as praebiotic effects in the hindgut by favouring gram positive bacteria like lactobacilli or gram positive cocci. Therefore, grinding intensity is worth to be reconsidered.     

Effects of dietary additives (potassium diformate/organic acids) as well as influences of grinding intensity (coarse/fine) of diets for weaned piglets experimentally infected with Salmonella Derby or Escherichia coli

The aim of this study was to examine whether and to what extent the addition of potassium diformate (pdf) or free organic acids (fpa) to the diet and the grinding intensity might affect the course of infection and the passage of orally applied Salmonella and Escherichia coli in pigs. Experiments were carried out using 80 reared piglets allotted to four groups. Pigs were fed pelleted diets ad libitum (except during a 15 h feed‐withholding‐period before infection). The control diet contained finely ground cereals (2 mm screen). To two test diets (also finely ground) 1.2% pdf, 0.9% organic acids (75% formic and 25% propionic acid, fpa) respectively were added. The fourth diet (without acids) was based on coarsely ground cereals (6‐mm screen). After experimental infection alternately with S. Derby or E. coli, the course of infection was examined (rectal swab technique). Pigs were sacrificed 4–5 h after a further oral application of ～10⁹–10¹⁰ CFU S. Derby or E. coli to determine the counts of Salmonella or E. coli in chyme (classical culture methods). Adding pdf or fpa to the diet led to reduced Salmonella shedding and resulted in significantly lower counts of Salmonella and E. coli in the stomach content indicating an improved efficacy of the stomach barrier. In the distal parts of the digestive tract, the effect was less obvious concerning counts of E. coli, whereas counts of Salmonella were reduced markedly as well. The diet based on coarsely ground cereals failed to demonstrate positive effects concerning infection and passage of orally applied bacteria as well, but this diet was also pelleted and showed unintentionally, comparable amounts of fine particles. Results obtained in this study allow the recommendation of using pdf or organic acids as additives when dietary measures against Salmonella or E. coli in pigs are required.     

Effects of food deprivation and particle size of ground wheat on digestibility of food components in broilers fed on a pelleted diet

The first aim of the experiment was to study the effect of wheat (Triticum aestivum) particle size on the digestibility of starch in a pelleted diet given to broilers. The second aim was to study the consequences of food deprivation before the excreta collection period (from 21 to 24 d). Wheat from a strong hardness cultivar was incorporated at 546.1 g/kg in diets. The other main ingredients were soybean meal (353.5 g/kg) and rapeseed oil (55.0 g/kg). Diets were given as pellets. The experimental design was a 2 x 2 factorial design testing two particle sizes of wheat flour and two procedures of a balance experiment (with or without food deprivation). Birds given diet C (wheat coarse grinding before pelleting) had significantly greater gizzard weight than birds fed on diet F (wheat fine grinding before pelleting). Starch digestibility value was significantly increased when birds were fed on diet F. This effect was halved by food deprivation. No significant effect of grain particle size was observed for protein and lipid digestibility values. However, food deprivation decreased apparent protein digestibility, with an effect which was more pronounced for fine than for coarse grinding. AMEN of the diet was significantly improved by fine grinding of wheat and decreased by food deprivation. However, no significant differences in growth performance were induced by differences in wheat grinding. No significant effect of grinding was observed on the water excretion:feed intake ratio. No significant difference was observed for vent score between treatments. There was over-excretion of starch in the first hours of refeeding following food deprivation.     

The effect of grinding and pelleting of wheat and maize on amino acids true ileal digestibility and endogenous losses in growing pigs

Two experiments were performed in order to test the effects of grinding and pelleting wheat (experiment 1) or maize (experiment 2) on amino acids (AA) standardized (SID) and true (TID) ileal digestibility. Basal ileal endogenous losses (IEL), used to calculate SID from apparent digestibility, were determined by feeding a protein-free diet. Total IEL required to calculate TID were estimated as the difference between total and dietary losses determined according to the isotope dilution technique using ¹⁵N-labeled crops. Wheat and maize were ground to compare two different mean particle sizes (d₅₀ 500 μm and 1000 μm). Then, a fraction of the 500-μm mash was further pelleted through two dies of different thicknesses (16 vs. 20 mm for wheat and 16 vs. 24 mm for maize), holes diameter 4 mm in both cases. Cereals were incorporated in 4 isoproteic diets either in mash form (fine vs. coarse mash) or in pelleted form (thin vs. thick die). In experiment 1, wheat was associated with rapeseed meal diets, while in experiment 2, maize was associated with soybean meal. The reduction of wheat particle size affected neither AA SID nor TID. In contrast, the pelleting treatment significantly improved protein and most AA SID and TID. In addition, total IEL of protein and several AA were significantly reduced when the thicker die was used. Numeric improvements of protein and AA SID were observed with reduction of maize particle size and this was associated with a significant decrease in total IEL so that TID was not modified. Further improvements of AA SID and TID occurred with pelleting of maize, without significant effect on IEL regardless of die thickness.     

Effects of pelleting and pellet conditioning temperatures on weanling pig performance

We conducted two experiments to study the effects of pelleting and pellet conditioning temperature on weanling pig performance. In Exp. 1, 252 weanling pigs (PIC, L326 x C22) averaging 6.0 +/- 1.3 kg and 21 +/- 3 d of age were used to evaluate six corn-soybean meal-based diets containing 15% dried whey and formulated to contain 1.4% lysine. Treatments consisted of a control diet without spray-dried animal protein (SDAP) fed in meal form, a diet with 5% SDAP fed in meal form, and four diets with 5% SDAP that were conditioned at 60, 66, 71, or 77 degrees C for 10 s prior to pelleting. Pellets had a 3.97-mm diameter. The experimental diets were fed from d 0 to 14 after weaning, and all pigs were fed a common diet in meal form from d 14 to 28 after weaning. From d 0 to 7 after weaning, pigs fed diets containing SDAP had greater ADG, gain/feed (P < 0.001), and ADFI (P < 0.05) than pigs fed the control diet. No differences (P > 0.10) were observed between pigs fed the pelleted diets and those fed the SDAP diet in meal form. Conditioning temperature had no effect (P > 0.10) on weanling pig performance from d 0 to 14, and the diet fed from d 0 to 14 had no effect on overall performance (d 0 to 28). In Exp. 2, 252 weanling pigs (6.3 +/- 1.5 kg and 22 +/- 4 d of age) were used to evaluate diets with same composition as in Exp. 1, but treatments consisted of diets with or without SDAP conditioned at 60 degrees C before pelleting, and four diets containing 5% SDAP that were conditioned at 68, 77, 85, and 93 degrees C before pelleting. As in Exp. 1, conditioning lasted 10 s, pellets were 3.97 in mm diameter, and experimental diets were fed for the first 14 d of the 28-d experiment. From d 0 to 7, pigs fed the SDAP diet conditioned at 60 degrees C had greater ADFI (P < 0.05) and tended (P = 0.12) to have greater ADG than pigs fed the diet without SDAP and conditioned at 60 degrees C. From d 0 to 7, ADG (quadratic effect, P < 0.03) and ADFI (linear effect, P < 0.002) decreased as conditioning temperature increased, with the largest decrease observed above 77 degrees C. From d 0 to 14 and 0 to 28, ADG was not affected (P > 0.10) by pellet conditioning temperature or SDAP fed from d 0 to 14. The results of these studies suggest that conditioning diets containing 5% SDAP at temperatures above 77 degrees C decreases weanling pig growth performance.     

Effects of diet and housing density on growth and stomach morphology in pigs.

Two experiments were conducted to evaluate the impact of housing density on the stomach morphology of growing pigs and determine whether there was an interaction between housing density and diet. All diets were corn-soybean meal based. In Exp. 1, 42 barrows (41.0+/-.95 kg BW) were allotted either individually or three pigs per pen to evaluate the effects of crowding on stomach lesions. Pen space per pig was 1.54 and .51 m2, respectively. All pigs were fed a finely ground and pelleted diet (610 microm) for 6 wk. The ADG decreased (P<.05) for the pigs housed three per pen during wk 4 to 6 only. There was no effect of housing density on feed intake or gain/feed ratio. Neither visual nor histological ulcer score differed between the two treatment groups. No stomachs were graded as normal. In Exp. 2, 80 barrows (39.8+/-.9 kg BW) were allotted either two or four pigs per pen. Pen space per pig was .77 and .39 m2, respectively. Half of the pigs in each housing situation were fed a coarse meal diet (1,050 microm), and half of the pigs were fed a finely ground and pelleted diet (577 microm) throughout the 49-d experimental period. Throughout the trial, pigs housed two per pen gained at a greater rate (P<.05) than pigs housed four per pen. From d 14 to the end of the trial, pigs consuming the finely ground and pelleted diet gained at a greater rate (P<.05) than pigs fed the coarse meal diet. The differences in ADG were reflected in final body weight. Stomach weight as a percentage of body weight was higher for animals on the coarse meal diet. Visual and histological ulcer scores were similar, and both were higher (P<.001) on the finely ground and pelleted diet, indicating greater damage. There was no effect of space restriction on stomach morphology. These data show the major effect of diet type on stomach lesions with no interaction with space restriction.     

The response of broilers to the feeding of mash or pelleted diets containing maize of varying particle sizes

1. The effects of maize particle size and steam pelleting on growth and nutrient utilisation were studied with broiler chicks. 2. The presence or absence of 10 microg/kg of 1,25 dihydroxycholecalciferol in diets adequate or deficient in phosphorus was also investigated. Food efficiency was superior with the fine maize diets but calcium retention and phytate phosphorus retention were greatest with the coarse maize diets. Pelleting improved food efficiency and growth in both experiments while phytate phosphorus utilisation was decreased. 3. Addition of 1,25-dihydroxycholecalciferol to the diet increased 16-d body weight, bone ash, plasma dialysable phosphorus and retentions of total phosphorus and phytate phosphorus while decreasing phosphorus deficiency rickets and tibial dyschondroplasia. 4. There were significant interactions between maize particle size and food form. The improvement in calcium retention observed with the coarse maize diets was reduced when the diets were pelleted. When fed as a mash, coarse maize diets resulted in increased plasma dialysable phosphorus levels but when the diet was pelleted this response was eliminated. 5. There was also a significant interaction between particle size and phosphorus concentration in that chicks given diets deficient in phosphorus had improved bone ash when fed coarse maize as compared to fine maize. However, this response was eliminated when the diets were adequate in phosphorus. 6. In one experiment, fine maize diets had higher metabolisable energy values and there was a significant interaction between maize particle size and food form as pelleting improved the metabolisable energy value of coarse maize diets but not fine maize diets. In another experiment only pelleting of the factors studied improved the metabolisable energy value of the diets.     

Feed physical form and formic acid addition to the feed affect the gastrointestinal ecology and growth performance of growing pigs

The effect of feeding a coarsely ground meal (COARSE) and a finely ground pelleted diet with 1.8% (as-fed basis) added formic acid (ACID) was compared with feeding a standard finely ground pelleted diet (STD) on the gastrointestinal ecology of growing pigs at different intervals after feeding. One hundred five castrated male growing-finishing pigs (initial BW 27 kg) were used. At a BW of 63 kg, 60 pigs were killed 0.5, 2.5, 4.5, 6.5, and 8.5 h after feeding, and samples from the gastrointestinal tract (GIT) were obtained. The remaining 45 pigs were kept on the experimental diets to a BW of 99 kg. Feeding the three diets resulted in a similar pattern of gastric pH with time, (i.e., highest pH values 0.5 h after feeding and decreasing values at the following sampling times, to reach a value of 2.12 at 8.5 h after feeding). The pH of the gastric digesta of pigs fed the ACID diet was below 4 at all sampling times, whereas the digesta from the other two dietary groups had values above pH 4 at the first sampling times. Feeding the ACID diet decreased the counts of total anaerobes in the proximal GIT (P < or = 0.007), and of lactic acid bacteria (P < or = 0.001), enterobacteria (P < or = 0.02), and yeasts (P < or = 0.01) along the GIT compared with feeding the other two diets. Feeding the COARSE diet stimulated the growth of total anaerobes and lactic acid bacteria in the stomach and distal small intestine increased the microbial diversity mainly in the stomach (P = 0.001), compared with feeding the other two diets (P < or = 0.09), and decreased the number of enterobacteria in the cecum compared with the STD diet (P = 0.03), with the same tendency in the mid-colon (P = 0.07). The concentration of lactic acid in the stomach was highest in the pigs fed the COARSE diet compared with the other two groups (P < 0.05). The concentration of formic acid was highest in the stomach and all segments of the small intestine of the pigs fed the ACID diet compared with those fed the STD and COARSE diets (P < 0.05). The results from this study suggest that feeding a coarsely ground diet and a finely ground diet with added formic acid affect the gastrointestinal ecology of pigs mainly by changing the environment in the proximal GIT. The presence of organic acids in the proximal GIT is a crucial factor contributing to the decrease in the number of enterobacteria along the GIT. The time after feeding at which samples are taken to measure characteristics describing the gastrointestinal ecology affects the results from the stomach and small intestine.     

Effect of particle size distribution and dietary crude fibre content on growth performance and gastric mucosa integrity of growing-finishing pigs

This study was designed to examine the effect of crude fibre (CF) content and particle size of the diet on growth performance, carcass yield and gastric mucosa integrity. The experimental design was a 2×2 factorial trial with 192 pigs fed from 24 to 110 kg bodyweight. Four diets were compared: (1) low fibre finely ground; (2) low fibre coarsely ground; (3) high fibre finely ground; and (4) high fibre coarsely ground. All ingredients were ground before mixing. The high fibre coarsely ground diet resulted in the fewest lesions in the gastric pars oesophagea (P<0.001). Coarse grinding also resulted in the lowest urease activity in the stomach (P=0.006). The feed conversion ratio was worse on the coarsely ground diet than on the finely ground diet (P=0.038), whereas carcass yield was lower for pigs on the high fibre diet vs. the low fibre diet (P<0.001). Coarse grinding feed ingredients in a growing pig diet that is high in CF may reduce macroscopic lesions of the pars oesophagea but such a diet was accompanied in this study by inferior carcass yield.     

The presence and distribution of cannabinoid type 1 and 2 receptors in the mandibular gland: The influence of different physical forms of diets on their expression in piglets

We explored the expression and cell type distribution of cannabinoid receptors type 1 (CB1) and cannabinoid receptors type 2 (CB2) in the mandibular glands of pigs in relation to different physical forms of the diet. Thirty‐two crossbred growing pigs (ages 5–6 weeks) were randomly allotted to four experimental groups (eight pigs/group) and fed four different physical types of the same diet for 4 weeks: finely ground pellet (FP), coarsely ground meal (CM), coarsely ground pellet (CP) and coarsely ground extruded (CE) with dMEAN of 0.46, 0.88, 0.84 and 0.66 mm respectively. At the end of the feeding trial, the pigs were euthanized and the mandibular gland was collected after dissection. By immunohistochemistry, positive signals for CB1 were found in the cytoplasm of duct epithelial cells of pigs fed CP, FP and CE diets and in the serous cells of mixed acini in pigs fed the coarser CM diet. Positive signals for CB2 were detected in duct epithelial cells and in neurons of ganglia close to major secretory ducts of all pigs. The differential expression and localization of these receptors in response to variable chewing activity due to the type of diet suggest that endocannabinoids may influence the functional activity of the mandibular gland by modifying qualitative and/or quantitative aspects of salivary secretion.     

Coarse structured feed stimulates members of the genera Lactobacillus and Mitsuokella as well as propionate and butyrate producers in the pig stomach

Pigs in four groups were fed fine non-pelleted (F-NP), fine pelleted (F-P), coarse non-pelleted (C-NP) or coarse pelleted (C-P) diets. DNA fingerprints, T-RFLP, revealed a strong dietary effect on bacterial community structure in the stomachs. Pigs fed the C-NP diet had the highest microbial diversity in stomach and the T-RFLP fingerprints suggested that bacteria tentatively identified as Lactobacillus delbrueckii, L. mucosae, L. reuteri, L. amylovorus/L. sobrius, Mitsuokella multiacida and Megasphera elsdenii were specifically stimulated. Lactobacilli may be responsible for the previously reported increase in stomach lactate levels of pigs fed the C-NP diet [Mikkelsen, L.L., Naughton, P.J., Hedemann, M.S., Jensen, B.B., 2004. Effects of physical properties of feed on microbial ecology and survival of Salmonella enterica serovar Typhimurium in the pig gastrointestinal tract. Appl. Environ. Microbiol. 70, 3485–3492.]. Moreover, earlier observations of butyrate and propionate accumulation in the stomach of pigs fed C-NP diets could be due to stimulation of M. elsdenii and S. ruminantium according to the T-RFLP fingerprints.     

Growth performance and carcass quality are not different between pigs fed diets containing cold-fermented low-oil DDGS and pigs fed conventional DDGS,but pelleting improves gain to feed ratio regardless of source of DDGS

The objective of this study was to test the hypothesis that growth performance and carcass characteristics of pigs fed diets containing cold-fermented, low oil distillers dried grains with solubles (DDGS) is not different from that of pigs fed diets containing conventional DDGS regardless of the physical form of the diets. A total of 160 barrows and gilts were used. There were 4 diets, 10 pens per diet, and 4 pigs per pen. Pigs were weaned at 21 d of age and fed a common phase 1 diet that did not contain DDGS during the initial 7 d post-weaning. Pigs were then allotted to the four diets that were arranged in a 2 × 2 factorial design with two sources of DDGS (cold-fermented and conventional DDGS) and two diet forms (meal and pellets). Pigs were fed phase 2 diets from day 7 to 21 and phase 3 diets from day 21 to 43 post-weaning. All diets were based on corn and soybean meal, but phase 2 diets also contained 15% DDGS and phase 3 diets contained 30% DDGS. From day 43, pigs were fed grower diets for 38 d, early finisher diets for 38 d, and late finisher diets for 18 d and these diets also contained 30% DDGS. Feed was provided on an ad libitum basis and daily feed allotments were recorded. Pigs were weighed at the beginning of each phase and at the conclusion of the experiment. On the last day of the experiment, the pig in each pen with a body weight that was closest to the pen average was slaughtered and carcass measurements were determined. Combined results for the two nursery phases indicated that feeding meal diets instead of pelleted diets increased (P < 0.001) average daily feed intake and decreased (P < 0.05) gain to feed ratio (G:F). However, no differences between the two sources of DDGS were observed for the overall growth performance of weanling pigs. For the entire growing-finishing period, the source of DDGS did not affect growth performance, but pigs fed meal diets had reduced (P < 0.001) G:F compared with pigs fed the pelleted diets. There were no differences between the two sources of DDGS for carcass characteristics. Back fat was greater (P < 0.05) for pigs fed pelleted diets than for pigs fed meal diets. In conclusion, no differences in growth performance or carcass characteristics between pigs fed cold-fermented DDGS and pigs fed conventional DDGS were observed. However, pigs fed pelleted diets had greater G:F and greater back fat than pigs fed meal diets.     

Feeding organic acids enhances the barrier function against pathogenic bacteria of the piglet stomach

The effect of coarsely ground meal feed versus finely ground heat-treated pelleted feed and the addition of lactic acid and formic acid in combination on the physico-chemical properties, microbial composition and concentration of organic acids in the stomach content of piglets was investigated. A total of 60 weaned piglets were included in a 2 × 2 factorial arrangement in 15 randomised complete blocks. After three weeks, the pigs were put down and samples of digesta from the gastrointestinal tract were analysed for dry matter (DM), pH, organic acids and microbiological enumeration. Feeding coarsely ground meal feed increased the DM percentage, the concentration of organic acids and pH in the proximal stomach and lowered the distal stomach pH compared with finely ground heat-treated pelleted feed. However, the addition of organic acids to the diets lowered the pH in the stomach and was able to reduce the population of enterobacteria in the stomach.     

Effect of pelleting and associations with maize or wheat on the nutritive value of smooth pea (Pisum sativum) seeds in adult cockerels

Four types of diet were tested: 960 g maize/kg (M), 960 g wheat/kg (W), 463 g maize added to 497 g of smooth peas/kg (PM) and 463 g wheat added to 497 g smooth peas/kg (PW). Three treatments were applied to each of these 4 diets: grinding (OP), one steam pelleting (1 P) and two successive steam pelleting (2 P). The pelleted diets were ground before feeding. Adult cockerels received all the diets whereas rats received only W and PW diets. Apparent metabolisable energy values corrected for N-equilibrium (AMEn), protein and starch digestibilities were measured in adult cockerels. Digestible energy (DE) values were measured in rats. The AMEn values of cereals remained practically unchanged by pelleting, whereas that of smooth peas was increased by between 1.8-4.6% after pelleting. Pelleting also induced 3.5 and 5.4% increases respectively in the digestibilities of pea protein and starch. Pelleting did not change the DE values measured in rats. The AMEn values of smooth peas mixed with maize were 4.6% higher than those of smooth peas mixed with wheat. The true digestibility of pea protein was 8.4% higher in the former mixture, whereas the pea starch digestibility remained unchanged. Calculation showed that most of the pea AMEn variations could be explained in terms of variations in protein and starch digestibilities.     

Effects of the Addition of Roller Mill Ground Corn to Pelleted Feed on Pelleting Parameters,Broiler Performance,and Intestinal Strength

Maintaining an optimal pelleting production rate can be difficult when manufacturing feeds for meat birds. Increased production time may be required to fill feed demand and feed outages occur if demand is not met. Identifying management strategies to enhance overall feed production rate without compromising broiler performance is warranted. This study examined the effects of adding varying amounts of corn, ground through a roller mill, to pelleted supplements on feed production parameters, growth performance, and intestinal strength of broiler chickens. Four treatments were used from 18 to 41 d, which included a control (total diet pelleted), and addition of rolled corn to pelleted supplements at 15, 25, and 35% of the corn required in diet formulation. The final diets fed were identical in nutrient composition. Decreasing the amount of ground corn in the pelleted supplement did not affect pellet durability index in the grower diet, but pellet quality declined in the finisher diet. The dietary treatments did not adversely affect final BW gain or feed conversion. Progressive additions of ground corn to pelleted supplement did not affect gizzard weight or peak force intestinal strength. These data indicate that 35% of the formula corn can be added postpellet to reduce electrical cost for grinding and pelleting and improve overall production rate without adversely affecting cumulative growth performance of broilers.     

Effects of diets differing in propensity to promote gastric lesions on defense systems in gastric mucosae.

The objectives were to characterize biochemical changes, focusing on the antioxidant defense system, in stratified squamous and oxyntic mucosae in pigs fed diets with differing propensity to promote gastric lesions. Barrows (n = 24; 48.7+/-1.0 kg BW) housed in individual pens were used in the experiment. Barrows were fed a corn-soybean meal diet. Half of the animals were fed the diet as a coarsely ground meal (CGM; average particle size = 886 microm), and half were fed the diet as a finely ground pelleted (FGP; average particle size = 528 microm) feed. Initiation and termination of the experiment were staggered over a 3-wk period. Diets were fed for 6 wk. Visual evaluation of the stratified squamous mucosa of the proximal stomach showed increased (P<.001) damage in animals fed the FGP diet. These results were supported by histological evaluation. Thiobarbituric acid-reacting substances (TBARS), indicative of peroxide generation, relative to amount of protein were higher (P<.001) in stratified squamous than in oxyntic mucosa, and, per unit of tissue, TBARS were highest in stratified squamous mucosa of animals fed the FGP diet. Glutathione peroxidase activity followed a pattern similar to that of peroxides. Prostaglandin E2 was higher (P<.004) in stratified squamous than in oxyntic mucosa. In contrast, the activity of catalase was higher (P<.001) in oxyntic mucosa and was not affected by diet. The data show differences in the production of peroxides, the antioxidant defense system, and PGE2 between stratified squamous and oxyntic mucosae. Generation of prooxidants and the antioxidant defense system may play a role in the predilection of ulcers for the stratified squamous mucosal region of the pig stomach.     

The influence of diet on Lawsonia intracellularis colonization in pigs upon experimental challenge

The objective of this investigation was to study if different feeding strategies influence experimental infections of pigs with Lawsonia intracellularis, the causative agent of proliferative enteropathy. In three sequential trials, a total of 144 weaned pigs were fed five different diets all made from a standard diet based on wheat and barley as carbohydrate source and soybean as protein source. The five diets were: a standard diet (fine ground and pelleted), the standard diet fed as fermented liquid feed, the standard diet added 1.8% formic acid, the standard diet added 2.4% lactic acid and a diet similar to the standard diet (made from the same ingredients), but fed coarse ground. Twenty-four pigs on each diet were orally inoculated with L. intracellularis and growth performance and faecal excretion of bacteria were monitored. Twenty-four pigs fed the standard diet were included as not experimentally infected controls. Pigs in the first two trials were sacrificed 4 weeks post-inoculation, whereas animals in the third trial were sacrificed after 5 weeks. Pigs in all experimentally infected groups excreted L. intracellularis. The fermented liquid diet delayed the excretion of L. intracellularis and furthermore, pigs fed the standard diet supplemented with lactic acid had limited pathological lesions when the intestines were examined 4 weeks after inoculation. The growth performance was reduced in pigs experimentally challenged with L. intracellularis, however the prevalence and severity of diarrhea was limited.     

Effect of crude glycerol on pellet mill production and nursery pig growth performance

The objective of this study was to determine the effects of diets containing crude glycerol on pellet mill production efficiency and nursery pig growth performance. In a pilot study, increasing crude glycerol (0, 3, 6, 9, 12, and 15%) in a corn-soybean meal diet was evaluated for pellet mill production efficiency. All diets were steam conditioned to 65.5 degrees C and pelleted through a pellet mill equipped with a die that had an effective thickness of 31.8 mm and holes 3.96 mm in diameter. Each diet was replicated by manufacturing a new batch of feed 3 times. Increasing crude glycerol increased both the standard (linear and quadratic, P < 0.01) and modified (linear, P < 0.01; quadratic, P 相似文献