Application of a real time polymerase chain reaction method to detect castor toxin contamination in fluid milk and eggs

The castor seed contains ricin, which is one of the most potent biological toxins and is widely considered to be a threat agent for bioterrorism. In this study, a rapid and sensitive PCR method was applied to the detection of castor contamination in milk and liquid egg samples. The targeting gene sequence of the primer set, Ricin-F4/R4, was not found in either the bovine or chicken genome. Primers against a highly conserved sequence from the 18S ribosomal RNA gene were used as a positive control for DNA extraction and PCR reaction efficiency. The quantity and quality of DNA prepared from castor spiked or nonspiked milk and egg samples obtained from three different DNA extraction methods were compared. The cetyl trimethylammonium bromide (CTAB) method yielded the highest quality of DNA and is most suitable for the sensitive detection of castor DNA by real-time PCR in both milk and liquid egg matrixes. However, taking time and cost into consideration, a commercial kit designed for extraction of DNA from stool samples could be used as an alternative method for the routine extraction of DNA from milk for real-time PCR assays. The egg matrix was found to inhibit PCR amplification and interfere with two of the three methods tested for DNA extraction. Egg yolk had a greater negative effect on PCR amplification than the egg white matrix. Our results affirm the necessity of performing individual validations for each food matrix. Both real-time PCR systems used in this study, TaqMan and SYBR Green I dye, were capable of detecting 100 ng of castor acetone powder, corresponding to 5 ng of ricin, in 1 mL of milk or liquid egg, well below the toxic dose for humans. On the basis of these results, the real-time PCR method for detection of intentional castor contamination is applicable to milk and egg matrixes.     

Thermal inactivation of ricin using infant formula as a food matrix

Ricin is a potent protein toxin found in the seeds of the castor bean plant, Ricinus communis. Ricin specifically and irreversibly inactivates ribosomes, promoting cell death by inhibiting protein synthesis. It is composed of a ribosome-inactivating enzyme (A-chain) linked to a lectin (B-chain) by a single disulfide bond. Several reports indicate that ricin can be detoxified by thermal treatment; however, the conditions required for inactivation are not well characterized. In addition, little information exists on the thermal stability of ricin added to foods. The objective of this work was to determine the effects of heat treatments on the detection and toxicity of ricin added to milk- and soy-based infant formulas. Reconstituted infant formula powders containing 100 mug of ricin/mL were heated at 60-90 degrees C for up to 5 h. The heat-treated formulas were analyzed by ELISA to determine levels of ricin. The residual cytotoxicity of ricin-containing infant formula after heat treatments was determined using RAW264.7 mouse macrophage cells. The ELISA and the cytotoxicity assay indicated that ricin detection and toxicity decreased with increasing heating times and temperatures. Minimal losses in detection and toxicity were found for ricin heated at 60 degrees C for 2 h. The half-lives of ricin cytoxic activity in a milk-based infant formula at 60, 70, 75, 80, 85, and 90 degrees C were >100, 9.8 +/- 0.5, 5.8 +/- 0.9, 5.1 +/- 0.7, 3.1 +/- 0.4, and 1.8 +/- 0.2 min, respectively; the comparable values for a soy-based infant formula were >100, 16 +/- 1.6, 8.7 +/- 1.2, 6.9 +/- 1.1, 3.0 +/- 0.4, and 2.0 +/- 0.3 min. ELISA detection was a good indicator of the cytotoxicity of heat-treated ricin. The results indicate that ricin is a relatively heat stable protein and may remain toxic under some food processing conditions.     

Use of fourier transform near-infrared reflectance spectroscopy for rapid quantification of castor bean meal in a selection of flour-based products

Methodology was developed and evaluated for the rapid detection of castor bean meal (CBM) containing the toxic protein ricin by using Fourier transform near-infrared (FT-NIR) spectroscopy and multivariate techniques. The method is intended to be a prototype to develop a more general approach to detect food tampering. Measurements were made on an FT-NIR system using a diffuse reflection-integrating sphere. Flours spiked with caffeine, crystalline sugar, and corn meal, 1-20% w/w, were used as test articles to evaluate the methodologies. Food matrices (bleached flour, wheat flour, and blueberry pancake mix) spiked with CBM (0.5-8% w/w) were analyzed. Multiplicative scatter correction transformed partial least-squares regression models, using a specific NIR spectral region, predicted CBM contamination in foods with a standard error of cross-validation of <0.6% and a coefficient of determination (R(2)) of >94%. Models discriminated between flour samples contaminated with CBM and other protein sources (egg white, soybean meal, tofu, and infant formula). CBM had loading spectra with bands characteristic of amide groups (4880 and 4555 cm(-1)) and lipids (5800, 5685, 4340, and 4261 cm(-1)).     

Quantitative PCR detection of pork in raw and heated ground beef and pâté

Quantitative estimates are important to establish whether pork adulteration in ground beef and paté is accidental or intentional. A PCR procedure has been developed and evaluated to quantify pork in heated and nonheated meat and patés by densitometry using a specific and sensitive repetitive DNA element. Thirty, twenty-five, and twenty PCR cycles were carried out to find the best standard curve and correlation between pork content and band intensity. Twenty cycles showed the best results, quantifying degree contamination up to 1% pork in beef (heated and nonheated) and pork in duck paté with a minimum error. Finally, fraud was found in commercial patés.     

Detection of Salmonella spp in estuarine waters by using both the conventional culture and a probe technique

The presence of Salmonella spp in estuarine waters was investigated along the Patras harbor where pipes containing urban sewage terminate. Salmonellae detection was performed by a conventional culture and a DNA probe technique (Gene-Trak Salmonella assay — Gene Trak Systems, Framingham). The Gene Trak colorimetric Salmonella assay uses the ribosomal hybridization format followed by a colorimetric detection system. Salmonellae were detected in 3 out of 102 water samples (2.9%) when the culture technique was used and in 7 out of 102 samples (6.8%) when the DNA probe technique was used . All DNA probe positive samples were confirmed by culture of the pre-enrichment Gram-negative broth and biochemical tests according to the manufacturers instructions. Culture positive samples were confirmed by serological tests in the National Salmonella-Shigella Center (National Institute of Public Health). The data demonstrate that the colorimetric hybridization method and the conventional culture method are equivalent in their ability to detect Salmonellae in estuarine waters (χ² = 0.33 < 2.43). Both methods have the disadvantage of giving false negative results. However, the Gene Trak assay saves time by lessening the response time in the case of a contamination problem.     

Colorimetric deoxyribonucleic acid hybridization assay for rapid screening of Salmonella in foods: collaborative study

A collaborative study was performed in 11 laboratories to validate a colorimetric DNA hybridization (DNAH) method for rapid detection of Salmonella in foods. The method was compared to the standard culture method for detection of Salmonella in nonfat dry milk, milk chocolate, soy isolate, dried whole egg, ground black pepper, and raw ground turkey. Samples inoculated with high (0.4-2 cells/g) and low (0.04-0.2 cells/g) levels of Salmonella and uninoculated control samples were included in each food group analyzed. There was no significant difference in the proportion of samples positive by DNAH and culture procedure for any of the 6 foods. The colorimetric DNA hybridization assay screening method has been adopted official first action as a rapid screening method for detection of Salmonella in all foods.     

Comparative study of three different methods for the determination of aflatoxins in tahini

Aflatoxins spiked at three different levels (6.5, 13.0, and 19.5 microg/kg) in tahini, a sesame butter, were analyzed by using three different methods: high-performance liquid chromatography (HPLC), fluorometry, and enzyme-linked immunosorbent assay (ELISA). An immunoaffinity column was used for cleanup and purification of extracts prior to detection by HPLC and fluorometry. All methods were statistically evaluated for accuracy, precision, and simple correlations. Additionally, 14 tahini samples randomly obtained from Turkish retail markets were analyzed using an immunoaffinity column cleanup procedure coupled with the HPLC detection method. The fluorometric determination method involving an immunoaffinity column cleanup step was found to be highly correlated with the HPLC method (r = 0.978). Both methods were found to be effective due to their high recoveries and low variance for the prediction of total aflatoxin contamination in tahini samples. The ELISA method, due to its high variation in replicates, was found to be applicable only as a screening method. The survey study demonstrated the need for control of aflatoxin contamination of foodstuffs involving sesame seeds as an ingredient.     

Monoclonal antibody-based ELISA and colloidal gold immunoassay for detecting 19-nortestosterone residue in animal tissues

This article presents the generation of monoclonal antibodies (mAbs) with high specificity against 19-nortestosterone (NT) through cell fusion techniques and the development of a mAb-based indirect competitive ELISA (icELISA) method and colloidal gold-based immuno-chromatographic assay to detect NT residues in beef and pork samples. A modified carbodiimide method was employed to synthesize the artificial antigen, and BALB/c mice were used to produce anti-NT mAbs. On the basis of the checkerboard titration, an indirect competitive ELISA standard curve was established. This assay was sensitive and had a linear range from 0.03 to 38 ng/mL in phosphate buffered saline (PBS), with IC(50) and LOD values of 0.52 ng/mL and 0.01 ng/mL, respectively. Of all the competitive analogues, the produced mAb exhibited a high cross-reactivity to 17α-nortestosterone (83.6%), the main metabolite of NT in animal tissues. Except for moderate cross-reactivities with trenbolone (22.6%) and β-boldenone (13.8%), the other interference to the assay was negligible (<0.05%). In contrast, the strip test had a visual detection limit of 1 ng/mL in PBS, 2 μg/kg in beef, and 2 μg/kg in pork, respectively, and the results can be judged within 10 min. The ELISA and GC-MS results showed close correlation in beef (R2=0.9945) and in pork (R2=0.9977). Therefore, the combination of two immunoassays provides a useful screening method for quantitative or qualitative detection of NT residues in animal-origin products.     

Beef- and bovine-derived material identification in processed and unprocessed food and feed by PCR amplification

This research developed and evaluated a PCR procedure to detect beef in heated and unheated meat, sausages, and canned food, using a specific and sensitive method. To confirm the effectiveness and specificity of this fragment, we tested 45 cattle blood DNA samples (from different breeds) and obtained positive results. With 125 samples tested from other species, the specific beef amplification was not detected. Feed components intended for cattle nutrition were also checked, and bovine-derived material was detected. Using this method we can detect the degree of contamination up to 0.01% raw beef in pork. In the same way, 1% beef was detected in cooked meat mixtures and bovine-derived material in concentrate mixtures. Beef has been identified in both heated and unheated meat products, sausages, canned food, and hamburgers. In conclusion, specific PCR amplification of a repetitive DNA element seems to be a powerful technique for the identification of beef in processed and unprocessed food, because of its simplicity, specificity and sensitivity. Furthermore, feed components intended for cattle nutrition can be checked. The procedure is also much cheaper than other methods based on RFLPs-PCR, immunodiffusion, and other techniques that need expensive equipment.     

Analysis of organophosphorus pesticides in dried ground ginseng root by capillary gas chromatography-mass spectrometry and -flame photometric detection

A method was developed to determine organophosphorus pesticides (OPs) in dried ground ginseng root. Pesticides were extracted from the sample using acetonitrile/water saturated with salts, followed by solid-phase dispersive cleanup, and analyzed by capillary gas chromatography with electron ionization mass spectrometry in selective ion monitoring mode (GC-MS/SIM) and flame photometric detection (GC-FPD) in phosphorus mode. The detection limits for most of the pesticides were 0.025-0.05 microg/g using GC-FPD but were analyte-dependent for GC-MS/SIM, ranging from 0.005 to 0.50 microg/g. Quantitation was determined from 0.050 to 5.0 microg/g with r 2 > 0.99 for a majority of the pesticides using both detectors. Recovery studies were performed by fortifying the dried ground ginseng root samples to concentrations of 0.025, 0.1, and 1.0 microg/g, resulting in recoveries of >90% for most pesticides by GC-FPD. Lower (<70%) and higher (>120%) recoveries were most likely from complications of pesticide lability or volatility, matrix interference, or inefficient desorption from the solid-phase sorbents. There was difficulty in analyzing the ginseng samples for the OPs using GC-MS at the lower fortification levels for some of the OPs due to lack of confirmation. GC-FPD and GC-MS/SIM complement each other in detecting the OPs in dried ground ginseng root samples. This procedure was shown to be effective and was applied to the analysis of OPs in ginseng root samples. One particular sample, a ground and dried American ginseng (Panax quinquefolius) root sample, was found to contain diazinon quantified at approximately 25 microg/kg by external calibration using matrix-matched standards or standard addition using both detectors. The advantage of using both detectors is that confirmation can be achieved using GC-MS, whereas the use of a megabore column in GC-FPD can be used to quantitate some of the nonpolar OPs without the use of matrix-matched standards or standard addition.     

Development of an immunoassay for the pyrethroid insecticide esfenvalerate.

A competitive enzyme-linked immunosorbent assay was developed for the detection of the pyrethroid insecticide esfenvalerate. Two haptens containing amine or propanoic acid groups on the terminal aromatic ring of the fenvalerate molecule were synthesized and coupled to carrier proteins as immunogens. Five antisera were produced and screened against eight different coating antigens. The assay that had the least interference and was the most sensitive for esfenvalerate was optimized and characterized. The I(50) for esfenvalerate was 30 +/- 6.2 microg/L, and the lower detection limit (LDL) was 3.0 +/- 1.8 microg/L. The assay was very selective. Other pyrethroid analogues and esfenvalerate metabolites tested did not cross-react significantly in this assay. To increase the sensitivity of the overall method, a C(18) sorbent-based solid-phase extraction (SPE) was used for water matrix. With this SPE step, the LDL of the overall method for esfenvalerate was 0.1 microg/L in water samples.     

Histologic detection of cardiac musculature, soy flour, and partially defatted tissue in ground beef: interlaboratory study

A collaborative study was designed and conducted to evaluate the accuracy of a procedure for the histologic detection of cardiac muscle, soy flour, and partially defatted tissue that may occur as adulterants in ground beef. Ground beef samples were prepared containing 0, 3, 5, 10, and 15% of each of the 3 adulterants. Five samples of each composition at each of the 5 dilutions, for a total of 75 unknown samples, were analyzed at each of 5 participating laboratories. The study revealed that this technique is reliable for the detection of these adulterants in ground beef.     

Rapid determination of fumonisin B1 in food samples by enzyme-linked immunosorbent assay and colloidal gold immunoassay

A rapid enzyme-linked immunosorbent assay (ELISA) test (microwell plate) and a membrane-based colloidal gold immunoassay in flow-through and lateral-flow formats for the rapid detection of fumonisin B1 (FB1) were developed. The rapid microwell assay can be completed within 20 min with the detection limit of 0.5 +/- 0.2 microg/L. Membrane-based colloidal gold immunoassays had a visual detection limit of 1.0 microg/L for FB1 with the detection time of <10 min. Matrix interference was eliminated by 15-fold dilutions of methanol extracts with buffer. These immunoassays can be used as quantitative or qualitative tools for the rapid detection of FB1 residues in 10-20 min on-site.     

Simultaneous detection of eight food allergens using optical thin-film biosensor chips

Food allergies are important food safety issues nowadays. To maintain the safety of people who experience allergic reactions, labeling is required in many countries and efficient and reliable detection methods are necessary. This paper reports a novel method for the rapid identification of food allergens through the use of a silicon-based optical thin-film biosensor chip with which color change results can be perceived by the naked eye without any extra equipment. The whole system can detect eight food allergens including soybean, wheat, peanut, cashew, shrimp, fish, beef, and chicken simultaneously. Sensitive and specific detection of the absolute detection limit of this method was 0.5 pg of cashew DNA, and the practical detection limit of 0.001%. The biosensor chip detection time was about 30 min after PCR amplification. The assay is proposed as a sensitive, specific, high-throughput, and ready-to-use analytical tool to detect the presence or confirm the absence of eight food allergens.     

Immunochemical analysis of 2,4,6-tribromophenol for assessment of wood contamination

2,4,6-Tribromophenol (2,4,6-TBP) has been used as a wood preservative and flame retardant and is a synthetic intermediate of the most important brominated flame retardants (BFR) produced. The use of TBP-contaminated wood materials in the food industry poses a risk of significant economical losses due to food contamination. In this work an efficient and reliable immunochemical method for analysis of TBP in wood samples has been established consisting of alkaline wood extraction followed by analysis on a microplate ELISA (enzyme-linked immunosorbent assay). TBP is efficiently extracted from wood samples in 10 min and directly measured after 10-fold buffer dilution to avoid matrix interferences. The analytical procedure has a limit of detection of 45 ng g (-1) of TBP in wood (1.5 microg L (-1) in extracts). The method has been applied to the analysis of contaminated real wood samples, showing that the levels of contamination can reach high TBP concentrations (up to 2000 microg L (-1)). An excellent correlation was observed between TBP levels in wood extracts determined by ELISA and gas chromatography-mass spectrometry (GC-MS) analysis ( R (2) = 0.990, N = 19). The precision found is below 22% CV. The immunoanalytical method developed is fast, reliable, and cost-effective, shows good high-throughput screening capabilities, and can be an excellent tool for assessment of wood contamination at lumber mills or related industries. The TBP ELISA has the potential to be used for environmental, food, and biological monitoring of brominated phenolic compounds considered nowadays as emerging pollutants.     

Production of polyclonal antibodies against ochratoxin A and its detection in chilies by ELISA

Polyclonal antibodies were produced for Ochratoxin A (OA) by injecting OA-bovine serum albumin (BSA) conjugate subcutaneously at multiple sites into a New Zealand White inbred rabbit. Antiserum could be used at a dilution exceeding 1:100 000 in an indirect competitive enzyme-linked immunosorbent assay (ELISA), and detected OA concentrations up to 0.1 ng/mL. The 50% inhibition binding (I(50)) of OA was 5 ng/mL. Antibodies did not react with ochratoxin B, coumarin, 4-hydroxycoumarin, L-phenylalanine, and aflatoxin B1. OA contamination in chilies (Capsicum annum L.) collected from commercial markets and cold storage units was determined. The mean recoveries from OA-free chilies spiked with 1 to100 microg of OA per kg of chili sample were 90-110% with a standard deviation of <10%. Of 100 chili samples tested, 26 were found to contain over 10 microg/kg of OA. In 12 samples the OA concentration varied from 10 to 30 microg/kg, in 10 samples from 30 to 50 microg/kg, in 3 samples from 50 to100 microg/kg, and in one sample it was 120 microg/kg. This is the first record in India of OA in chilies, a major component of cooked foods in this country, and it is noteworthy that OA contamination exceeded the permissible limit for human consumption of less than 20 microg/kg in over 26% of the market samples tested.     

Boron doped diamond biosensor for detection of Escherichia coli

o-Nitrophenol, released from o-nitrophenyl-beta-D-galactopyranose as catalyzed by beta-galactosidase, a tetramer of Escherichia coli, has been exploited for the detection of E. coli contamination in foodstuffs. This reaction was detected using a boron doped diamond electrode poised at +0.93 V, without any surface modification. The enzyme was effectively induced by isopropyl-beta-D-thiogalacto-pyranoside with the maximum enzyme activity observed with sodium dodecyl sulfate at 50 degrees C. A biphasic calibration plot was observed: 4 x 10(4) to 2 x 10(5) cells/mL and 2 x 10(5) to 6 x 10(6) cells/mL for the first and second region, respectively. The detection limit was 4 x 10(4) cells/mL with a total analysis time of <1.5 h. Electrode fouling was easily overcome by approximately 40 rapid CV scans, and the method was applicable for detecting E. coli in artificially spiked samples of beef, pork, chicken, milk, and tap water.     

Rapid fluorogenic enumeration of Escherichia coli in selected, naturally contaminated high moisture foods

An assay for the enzyme glucuronidase was used to determine the presence of Escherichia coli in selected, naturally contaminated high moisture foods. Raw pork sausage, ground turkey, and ground beef were inoculated into tubes containing the substrate 4-methylumbelliferyl beta-D-glucuronide (MUG) in lauryl tryptose (LT) medium. After incubation at 35 degrees C for 24 h, the inoculated LT-MUG tubes were examined under longwave ultraviolet light for the presence of a fluorogenic glucuronidase end product. A fluorescing tube indicated the presumptive presence of E. coli. The 10 day most probable number method of the AOAC and the LT-MUG procedure gave comparable recoveries of E. coli.     

Use of electrochemical biosensor and gas chromatography for determination of dichlorvos in wheat

Two methods for the determination of dichlorvos in durum wheat by electrochemical assay and gas chromatography, respectively, have been developed. Dichlorvos, an organophosphorus anticholinesterase pesticide, was extracted from wheat with hexane, and the filtered extract was directly analyzed by gas chromatography with nitrogen-phosphorus flame detection (NPD). Recoveries of dichlorvos from milled wheat spiked at 0.25-1.5 microg/g ranged from 96.5 to 100.9%, and the limit of detection was 0.02 microg/g. The electrochemical assay was based on the detection of choline, the acetylcholinesterase product, via a choline oxidase biosensor. An aliquot of the filtered hexane extract was partitioned with phosphate buffer solution, and the organic layer was evaporated prior to electrochemical analysis. A limit of detection of 0.05 microg/g of dichlorvos was obtained with mean recoveries of 97-103% at spiking levels of 0.25-1.5 microg/g. A good correlation (r = 0.9919) was found between the results obtained with the electrochemical and those obtained with the gas chromatographic methods. The electrochemical method was peer-validated in two laboratories that analyzed 10 blind samples (5 duplicates), including a blank and 4 spiked samples with dichlorvos at levels of 0.25, 0.60, 1.00, and 1.50 microg/g. Within-laboratory repeatability (RSDr) and between-laboratory reproducibility (RSDR) ranged from 5.5 to 7.8% and from 9.9 to 17.6%, respectively.