Furan levels in coffee as influenced by species, roast degree, and brewing procedures

Brazilian green coffee beans of Coffea arabica and Coffea canephora species were roasted to light, medium, and dark roast degrees and analyzed in relation to furan content by using an in-house validated method based on gas chromatography coupled to mass spectrometry preceded by headspace solid-phase microextraction. Furan was not detected in green coffees, whereas levels between 911 and 5852 μg/kg were found in the roasted samples. Higher concentrations were found in Coffea canephora species and darker ground coffees. Some of the potential furan precursors were observed in significant amounts in green coffee, especially sucrose and linoleic acid, but their concentrations could not be correlated to furan formation. Additionally, coffee brews were prepared from roasted ground coffees by using two different procedures, and furan levels in the beverages varied from <10 to 288 μg/kg. The factor that most influenced the furan content in coffee brew was the brewing procedure.     

Spectrophotometric determination of caffeine in coffee products: collaborative study.

An ultraviolet (UV) spectrophotometric method for determining caffeine in regular and decaffeinated coffee products has been studied collaboratively. Nine laboratories participated in this study which compares the proposed UV method with the official AOAC micro Bailey-Andrew method. Caffeine content was determined on as-is basis on 8 samples of green, roasted, and soluble coffees. The coefficients of variation for the proposed method ranged from 2.02 to 6.98% for the 8 samples studied. The results agreed well with those from the Bailey-Andrew Method. The method was adopted as official first action.     

Incidence,level, and behavior of aflatoxins during coffee bean roasting and decaffeination

Screening for aflatoxins (Afs), isolation and identification of Aspergillus flavus, and the effect of decaffeination and roasting on the level of contamination in coffee beans are studied. The percent frequency of A. flavus ranged between 4 and 80% in green coffee beans (GCB), whereas in ground roasted coffee beans (GRCB), it ranged between 1 and 71%. Aflatoxins were detected in 76.5 and 54.6% of the infected samples with averages of 4.28 and 2.85 microg/kg of GCB and GRCB, respectively. Roasting was demonstrated to lower the concentration of Afs in GCB. The Afs levels were reduced by approximately 42.2-55.9% depending on the type and temperature of roasting. The highest yields of Afs were detected in the decaffeinated green coffee beans (24.29 microg/kg) and roasted coffee beans (16.00 microg/kg). The growth of A. flavus in liquid medium containing 1 or 2% caffeine was reduced by 50%, and the level of aflatoxin in the medium was undetectable.     

Effect of roasting on the formation of chlorogenic acid lactones in coffee

Of all plant constituents, coffee has one of the highest concentrations of chlorogenic acids. When roasting coffee, some of these are transformed into chlorogenic acid lactones (CGL). We have studied the formation of CGL during the roasting of coffee beans in Coffea arabica cv. Bourbon; C. arabicacv. Longberry; and C. canephora cv. Robusta. Individual CGL levels were determined by comparison of HPLC peaks with those of synthetic CGL standards. Seven CGL were identified: 3-caffeoylquinic-1,5-lactone (3-CQL), 4- caffeoylquinic-1,5-lactone (4-CQL), 3-coumaroylquinic-1,5-lactone (3-pCoQL), 4-coumaroylquinic-1,5-lactone (4-pCoQL), 3-feruloylquinic-1,5-lactone (3-FQL), 4-feruloylquinic-1,5-lactone (4-FQL), and 3,4-dicaffeoylquinic-1,5-lactone (3,4-diCQL). 3-CQL was the most abundant lactone in C. arabica and C. canephora, reaching peak values of 230 +/- 9 and 254 +/- 4 mg/100 g (dry weight), respectively, at light medium roast ( approximately 14% weight loss). 4-CQL was the second most abundant lactone (116 +/- 3 and 139 +/- 2 mg/100 g, respectively. The maximum amount of CGL represents approximately 30% of the available precursors. The relative levels of 3-CQL and 4-CQL in roasted coffee were reverse to those of their precursors in green coffee. This suggests that roasting causes isomerization of chlorogenic acids prior to the formation of lactones and that the levels of lactones in roasted coffee do not reflect the levels of precursors in green coffee.     

Chemical characterization of the high molecular weight material extracted with hot water from green and roasted arabica coffee

The polysaccharides present in coffee infusions are known to contribute to the organoleptic characteristics of the drink, such as the creamy sensation perceived in the mouth known as "body", the release of aroma substances, and the stability of espresso coffee foam. To increase the knowledge about the origin, composition, and structure of the polysaccharide fraction, the high molecular weight material (HMWM) was extracted with hot water from two green and roasted ground arabica coffees: Costa Rica (wet processed) and Brazil (dry processed). The polysaccharides present in the green coffees HMWM were arabinogalactans (62%), galactomannans (24%), and glucans, and those found in roasted coffees were galactomannans (69%) and arabinogalactans (28%). The polysaccharides of the HMWM of the roasted coffees were less branched than those of the green coffees. The major green coffee proteins had molecular weights of 58 and 38 kDa, and the 58 kDa protein had two subunits, of 38 and 20 kDa, possibly linked by disulfide bonds. The protein fraction obtained from roasted coffees had only a defined band with < or =14 kDa and a diffuse band with >200 kDa. The majority of the galactomannans were precipitated with solutions of 50% ethanol, and the size-exclusion chromatography of the roasted fractions showed coelution of polysaccharides, proteins, phenolics, and brown compounds. The use of strong hydrogen and hydrophobic dissociation conditions allowed us to conclude that the phenolics and brown compounds were linked by covalent bonds to the polymeric material.     

Roasting and aroma formation: effect of initial moisture content and steam treatment

Initial moisture of green coffee may vary as a function of green coffee processing and storage conditions. The impact of initial moisture and steam treatment on roasting behavior and aroma formation was investigated. Steam treated coffees as well as coffees with initial moisture content of 5.10, 10.04, and 14.70 g water per 100 g wb were roasted. Light and dark roasting trials were carried out using a fluidizing-bed roaster with a batch size of 100 g of green beans. Differences in roast coffee attributes, that is, color, density, and organic roast loss, and odorant concentrations were more marked in light roasted than in dark roasted coffees. The results of roasting steam treated coffee suggest that this step affects roasting behavior primarily by extracting some aroma precursor compounds.     

Influence of coffee roasting on the incorporation of phenolic compounds into melanoidins and their relationship with antioxidant activity of the brew

In the present study, the influence of coffee roasting on free and melanoidin-bound phenolic compounds and their relationship with the brews' antioxidant activity (AA), evaluated by TRAP, TEAC, and TRAP, were investigated. Changes in the relative content of free chlorogenic acids (CGA), free lactones, and melanoidin-bound phenolic acids during roasting indicate that phenolic compounds were incorporated into melanoidins mainly at early stages of the process, being thereafter partly oxidized to dihydrocaffeic acid, and degraded. Although less than 1% of CGA in green coffee was incorporated into melanoidins during roasting, the relative content of melanoidin-bound phenolic acids increased significantly during this process, reaching up to 29% of total phenolic compounds in brews from dark roasted coffees. Regardless of the AA assay used and considering all roasting degrees, the overall contribution of CGA to the AA of the whole brews was higher than that of melanoidin-bound phenolic compounds. It was estimated that the latter compounds contributed to 25-47% of the AA, depending on the assay used.     

Chemical characterization of the high-molecular-weight material extracted with hot water from green and roasted robusta coffees as affected by the degree of roast

The hot-water-soluble polymeric material from green and roasted Uganda robusta coffees submitted to different degrees of roasting was isolated and characterized, and the changes in structure and amount of galactomannans and arabinogalactans were determined and discussed in relation to the data already available for arabica coffees, obtained under the same experimental conditions. The content of arabinogalactans extracted from robusta green coffee was higher than that extracted from arabica. For roasted coffees, the amount of galactomannans extracted ranged from 0.66% to 0.92% (w/w). These values were near 50% of those obtained from the arabica coffees using the same extraction procedure. However, the amount of arabinogalactans extracted from robusta coffees (0.56-0.72%) was in the range obtained from arabica. The structures of arabinogalactans and galactomannans extracted from green and roasted coffees were not sufficiently different between robusta and arabica coffees to explain the observed differences in extraction yields for the arabinogalactans from green coffees and for the galactomannans from roasted coffees. The total polysaccharide content and the structures of the galactomannans and arabinogalactans in the two green coffee varieties investigated were also very similar. These differences in the extraction of high-molecular-weight polysaccharides between arabica and robusta roasted coffees may be related to the different susceptibility of the cell walls during the roasting process, known to result in a different porosity between arabica and robusta roasted coffees.     

Isolation and determination of alpha-dicarbonyl compounds by RP-HPLC-DAD in green and roasted coffee

Glyoxal, methylglyoxal, and diacetyl formed as Maillard reaction products in heat-treated food were determined in coffee extracts (coffee brews) obtained from green beans and beans with different degrees of roast. The compounds have been reported to be mutagenic in vitro and genotoxic in experimental animals in a number of papers. More recently, alpha-dicarbonyl compounds have been implicated in the glycation process. Our data show that small amounts of glyoxal and methylglyoxal occur naturally in green coffee beans. Their concentrations increase in the early phases of the roasting process and then decline. Conversely, diacetyl is not found in green beans and forms later in the roasting process. Therefore, light and medium roasted coffees had the highest glyoxal and methylglyoxal content, whereas dark roasted coffee contained smaller amounts of glyoxal, methylglyoxal, and diacetyl. For the determination of coffee alpha-dicarbonyl compounds, a reversed-phase high performance liquid chromatography with a diode array detector (RP-HPLC-DAD) method was devised that involved the elimination of interfering compounds, such as chlorogenic acids, by solid phase extraction (SPE) and their derivatization with 1,2-diaminobenzene to give quinoxaline derivatives. Checks of SPE and derivatization conditions to verify recovery and yield, respectively, resulted in rates of 100%. The results of the validation procedure showed that the proposed method is selective, precise, accurate, and sensitive.     

Alkylpyridiniums. 2. Isolation and quantification in roasted and ground coffees

Recent model studies on trigonelline decomposition have identified nonvolatile alkylpyridiniums as major reaction products under certain physicochemical conditions. The quaternary base 1-methylpyridinium was isolated from roasted and ground coffee and purified by ion exchange and thin-layer chromatography. The compound was characterized by nuclear magnetic resonance spectroscopy ((1)H, (13)C) and mass spectrometry techniques. A liquid chromatography-electrospray ionization tandem mass spectrometry method was developed to quantify the alkaloid in coffee by isotope dilution mass spectrometry. The formation of alkylpyridiniums is positively correlated to the roasting degree in arabica coffee, and highest levels of 1-methylpyridinium, reaching up to 0.25% on a per weight basis, were found in dark roasted coffee beans. Analyses of coffee extracts also showed the presence of dimethylpyridinium, at concentrations ranging from 5 to 25 mg/kg. This is the first report on the isolation and quantification of alkylpyridiniums in coffee. These compounds, described here in detail for the first time, may have an impact on the flavor/aroma profile of coffee directly (e.g., bitterness), or indirectly as precursors, and potentially open new avenues in the flavor/aroma modulation of coffee.     

Feasibility study on chemometric discrimination of roasted Arabica coffees by solvent extraction and Fourier transform infrared spectroscopy

In this feasibility study, Fourier transform infrared (FTIR) spectroscopy and chemometric analysis were adopted to discriminate coffees from different geographical origins and of different roasting degrees. Roasted coffee grounds were extracted using two methods: (1) solvent alone (dichloromethane, ethyl acetate, hexane, acetone, ethanol, or acetic acid) and (2) coextraction using a mixture of equal volume of the solvent and water. Experiment results showed that the coextraction method resulted in cleaner extract and provided a greater amount of spectral information, which was important for sample discrimination. Principal component analysis of infrared spectra of ethyl acetate extracts for dark and medium roast coffees showed separated clusters according to their geographical origins and roast degrees. Classification models based on soft independent modeling of class analogy analysis were used to classify different coffee samples. Coffees from four different countries, which were roasted to dark, were 100% correctly classified when ethyl acetate was used as a solvent. The FTIR-chemometric technique developed here may serve as a rapid tool for discriminating geographical origin of roasted coffees. Future studies involving green coffee beans and the use of larger sample size are needed to further validate the robustness of this technique.     

Discrimination between arabica and robusta coffee species on the basis of their amino acid enantiomers

This work reports the results for the composition of robusta and arabica coffee species in terms of their amino acid enantiomers in the green and roasted states. The analyses were conducted for the free amino acids, as well as for the amino acids obtained after acid hydrolysis. The amino acids were extracted/hydrolyzed and isolated by SPE on strong cation exchange columns, derivatized to their N-ethoxycarbonylheptafluorobutyl esters, and analyzed by gas chromatography/FID on a Chirasil l-Val column. Multivariate analyses applied to the results showed that the free amino acids can be used as a tool for discrimination between coffee species, with a special reference to l-glutamic acid, l-tryptophan, and pipecolic acid. There is also some evidence that these compounds can be used for discrimination between green coffees subjected to different postharvest processes. It is also shown that the amino acid levels observed after acid hydrolysis can be used for the same purposes, although displaying less discriminatory power.     

Quantitation of volatiles and nonvolatile acids in an extract from coffee beverages: correlation with antioxidant activity

The antioxidant activities of a commercial brewed coffee were investigated by measuring malonaldehyde (MA) formation from oxidized cod liver oil using a gas chromatographic method (MA-GC assay) and a thiobarbituric acid method (TBA assay). The highest antioxidant activity obtained by the MA-GC assay was from regular whole brewed coffee (97.8%) at a level of 20%, and the highest antioxidant activity obtained by the TBA assay was from decaffeinated whole brewed coffee (96.6%) at a level of 5%. Among 31 chemicals identified in a dichloromethane extract, guaiacol, ethylguaiacol, and vinylguaiacol exhibited antioxidant activities, which were comparable to that of alpha-tocopherol. Among nine chlorogenic acids (three caffeoylquinic acids, three feruloylquinic acids, and three dicaffeoylquinic acids) identified, 5-caffeoylquinic acid contained the greatest amount both in regular (883.5 microg/mL) and in decaffeinated (1032.6 microg/mL) coffees; it exhibited 24.5% activity by the MA-GC assay and 45.3% activity by the TBA assay at a level of 10 microg/mL. Caffeic and ferulic acids showed moderate antioxidant activities in both assays.     

Effect of roasting conditions on the polycyclic aromatic hydrocarbon content in ground Arabica coffee and coffee brew

Roasting is a critical process in coffee production as it enables the development of flavor and aroma. At the same time, roasting may lead to the formation of nondesirable compounds, such as polycyclic aromatic hydrocarbons (PAHs). In this study, Arabica green coffee beans from Cuba were roasted under controlled conditions to monitor PAH formation during the roasting process. Roasting was performed in a pilot spouted bed roaster, with the inlet air temperature varying from 180 to 260 degrees C, using both dark (20 min) and light (5 min) roasting conditions. Several PAHs were determined in both roasted coffee samples and green coffee samples. Also, coffee brews, obtained using an electric coffee maker, were analyzed for final estimation of PAH transfer coefficients to the infusion. Formation of phenanthrene, anthracene, and benzo[a]anthracene in coffee beans was observed at temperatures above 220 degrees C, whereas formation of pyrene and chrysene required 260 degrees C. Low levels of benzo[g,h,i]perylene were also noted for dark roasting under 260 degrees C, with simultaneous partial degradation of three-cycle PAHs, suggesting that transformation of low molecular PAHs to high molecular PAHs occurs as the roasting degree is increased. The PAH transfer to the infusion was quite moderate (<35%), with a slightly lower extractability for dark-roasted coffee as compared to light-roasted coffee.     

Evolution of green coffee protein profiles with maturation and relationship to coffee cup quality

Coffee flavor is the product of a complex chain of chemical transformations. The green bean has only a faint odor that is not at all reminiscent of coffee aroma. It contains, however, all of the necessary precursors to generate the unmistakable coffee flavor during roasting. The levels and biochemical status of these precursors may vary in relation to genetic traits, environmental factors, maturation level, postharvest treatment, and storage. To improve our understanding of coffee flavor generation, the sensory and biochemical impact of maturation was assessed. Maturation clearly favored the development of high-quality flavor in the coffee brew. A specific subclass of green coffee beans, however, generated high-quality coffee flavor irrespective of maturation. Biochemical aspects were examined using a dynamic system: immature and mature green coffee suspensions were incubated under air or argon. On the analytical side, a specific pool of flavor precursors was monitored: chlorogenic acids, green coffee proteins, and free amino acids. A link between maturation, the redox behavior of green coffee suspensions, and their sensory scores was identified. Compared to ripe beans, unripe beans were found to be more sensitive to oxidation of chlorogenic acids. Aerobic incubation also triggered the fragmentation or digestion of the 11S seed storage protein and the release of free amino acids.     

Natural occurrence of ochratoxin A and antioxidant activities of green and roasted coffees and corresponding byproducts

Ochratoxin A is an important mycotoxin that can enter the human food chain in cereals, wine, coffee, spices, beer, cocoa, dried fruits, and pork meats. Coffee is one of the most common beverages and, consequently, it has a potential risk factor for human health related to ochratoxin A exposure. In this study, coffee and corresponding byproducts from seven different geographic regions were investigated for ochratoxin A natural occurrence by HPLC-FLD, nutritional characterization, and antioxidant activities by spectrophotometric assay. The research focused on composition changes in coffee during the processing step "from field to cup". Costa Rica and Indian green coffees were the most contaminated samples, with 13 and 11 microg/kg, respectively, while the Ethiopian coffee was the least contaminated, with 3.8 microg/kg of ochratoxin A. The reduction of ochratoxin A contamination during the roasting step was comparable for any samples that were considered under the recommended level of 4 microg/kg. Total dietary fibers ranged from 58.7% for Vietnam and 48.6% for Ivory Coast in green coffees and ranged from 58.6% for Costa Rica to 61.2% for India in roasted coffee. Coffee silverskin byproduct obtained from Ivory Coast was the highest, with 69.2 and 64.2% of insoluble dietary fibers, respectively.     

Assessing the antioxidant activity of melanoidins from coffee brews by different antioxidant methods

Antioxidant activity of instant coffees produced from the same green coffee beans roasted at three different degrees was analyzed. Coffee melanoidins were obtained by ultrafiltration (10 kDa cutoff) and subsequent diafiltration. Pure melanoidins were isolated from melanoidins after overnight incubation in 2 M NaCl and then ultrafiltered. Filtrates, corresponding to the low molecular weight (LMW) fraction noncovalently linked to the melanoidin skeleton, were also preserved. Antioxidant activity of coffee brews (CB), melanoidins (M), pure melanoidins (PM), and bounded melanoidin compounds (BMC) were tested using the 2,2-diphenyl-1-picrylhydrazyl (DPPH), 2,2'-azobis-(3-ethylbenzothiazoline-6-sulfonic acid) (ABTS), and ferric reducing power (FRAP) methods. The correlation between the different methods was studied. The higher contribution of melanoidins to the total antioxidant activity of coffees was shown to be caused by the LMW compounds linked noncovalently to the melanoidin skeleton, as data from BMC confirmed. CB, M, and BMC fractions exert the highest antioxidant activity in aqueous media, whereas PM was not dependent on the reaction media. The highest correlation was found between DPPH and FRAP methods.     

Correlation of selected constituents with the total antioxidant capacity of coffee beverages: influence of the brewing procedure

Relationships between volatile and nonvolatile compounds and the antioxidant capacity of coffee brews prepared from commercial conventional and torrefacto roasted coffees, employing commonly used doses and prepared by four brewing procedures (filter, plunger, mocha, and espresso machine) were assessed. Significant correlations between volatile Maillard reaction products and antioxidant capacity (measured by both 2,2-diphenyl-1-picrylhydrazyl radical and redox potential methods) were not observed. Highly positive correlations between browned compounds and caffeine with both antioxidant capacity parameters were reported. Principal component analysis allowed coffee brews separation according to coffee roasting processes (PC1) and brewing procedures (PC2), showing that in all cases coffee brews from torrefacto roasted coffee were more antioxidant that those extracted from conventional ones; also, coffee brews extracted by an espresso machine were more antioxidant than those extracted by mocha, plunger, and filter machines.     

Coffee dietary fiber contents and structural characteristics as influenced by coffee type and technological and brewing procedures

Coffee brews contain considerable amounts of soluble dietary fiber, mainly low substituted galactomannans and type II arabinogalactans. Factors possibly influencing the content and structures of dietary fiber in coffee brews, such as type of coffee, roasting and grinding degree, and brewing procedure, were studied. In addition, several commercial samples such as instant espresso, instant coffee, instant cappuccino, decaffeinated coffees, and coffee pads were analyzed. The dietary fiber contents of the coffee brews ranged from 0.14 to 0.65 g/100 mL (enzymatic-gravimetric methodology), proving an influence of the factors investigated. For example, the drip brew of an arabica coffee contained significantly more soluble dietary fiber than the drip brew of a comparable robusta coffee, and depending on the brewing procedure, the soluble dietary fiber content of beverages obtained from the same coffee sample ranged from 0.26 to 0.38 g/100 mL. Dietary fiber contents of coffee brews were enhanced only up to a certain degree of roast. Drip brews of decaffeinated arabica coffees (commercial samples) contained significantly less dietary fiber than any non-decaffeinated drip brew investigated in this study. The observed differences in the dietary fiber contents were accompanied by changes in the structural characteristics of fiber polysaccharides, such as galactomannan/arabinogalactan ratio, galactose substitution degree of mannans, or galactose/arabinose ratio of arabinogalactans as analyzed by methylation analysis.