亚临界丙烷萃取米糠油及其微量活性组分动力学模型

为了揭示亚临界流体萃取米糠油及其微量活性组分的动力学规律,该文以亚临界丙烷为萃取介质,研究了米糠油、γ-谷维素及α-生育酚等活性组分在不同萃取温度和时间的萃取率,并基于 Baümler 模型对目标物的萃取率进行模型拟合,建立相应的动力学模型并验证。结果表明,亚临界萃取过程中目标物的相对萃取率随时间增长递增,且在初始阶段（洗涤过程）的增长速率快于第二阶段（扩散过程）的增长速率;同时,升高萃取温度可同时提高目标产物的扩散系数和相对萃取率;基于Baümler模型可较好拟合亚临界丙烷萃取米糠油、γ-谷维素和α-生育酚的动力学过程（R2>0.95）,所得动力学模型具有较好的预测准确性。由Arrhenius方程可计算出米糠油、α-生育酚和γ-谷维素的亚临界萃取反应活化能,其中米糠油的活化能最低（5.23 kJ/mol）,α-生育酚次之（7.05 kJ/mol）,γ-谷维素最高（9.11 kJ/mol）,表明γ-谷维素最难萃取且对温度依赖程度最高;根据拟合所得动力学模型,对米糠油提取率进行预测,结果表明,该模型对米糠油萃取率的预测准确率达95.8%,而对γ-谷维素和α-生育酚萃取率的预测准确度稍低,分别达94.7%和94.4%,对三者均具有很好的预测准确性。总之,基于 Baümler 模型可以较好地建立米糠油及其有益伴随物的亚临界萃取动力学模型,从而较为准确的预测米糠油及其微量活性组分的萃取率,对米糠油的亚临界萃取工艺具有一定的理论指导意义。     

Triterpene alcohol and sterol ferulates from rice bran and their anti-inflammatory effects

Six novel feruloyl esters of triterpene alcohols and sterols, viz., two trans-ferulates, cycloeucalenol and 24-methylenecholesterol trans-ferulates, and four cis-ferulates, cycloartenol, 24-methyelenecycloartanol, 24-methylcholesterol, and sitosterol cis-ferulates, besides five known trans-ferulates, cycloartenol (CAR), 24-methylenecycloartanol (24-MCA), 24-methylcholesterol, sitosterol, and stigmastanol trans-ferulates, and one known cis-ferulate, stigmastanol cis-ferulate, were isolated from the methanol extract of edible rice bran. These and eight other synthetic trans- and cis-ferulates of triterpene alcohols and sterols, along with the corresponding free alcohols, were evaluated with respect to their anti-inflammatory activity against 12-O-tetradecanoylphorbol-13-acetate (TPA)-induced inflammation (1 microg per ear) in mice. All of the ferulates showed marked inhibitory activity, and their 50% inhibitory dose (ID(50)) was 0. 1-0.8 mg per ear. On the other hand, whereas two free triterpene alcohols, CAR and 24-MCA, showed strong inhibition (ID(50) 0.2-0.3 mg/ear), eight free sterols examined showed weaker activity (ID(50) 0.7-2.7 mg/ear) than their corresponding ferulates.     

Properties of extracts from defatted rice bran by its subcritical water treatment

Defatted rice bran was extracted with water and subcritical water at 50-250 degrees C for 5 min. The highest extract yield was achieved at 200 degrees C, at which the maximum amounts of protein and carbohydrate were also obtained. The total phenolic and furfural contents, radical scavenging activity, and antioxidative activity for the autoxidation of linoleic acid increased with increasing treatment temperature. The bran extracts exhibited emulsifying activity except for the extract prepared at 250 degrees C, which was concomitant with the disappearance of its high-molecular-mass substances. The extract prepared at 200 degrees C also had the highest emulsion-stabilizing activity.     

Efficiency of rice bran for removal of organochlorine compounds and benzene from industrial wastewater

Rice bran was found to effectively adsorb several organic compounds, such as dichloromethane, chloroform, carbon tetrachloride, trichloroethylene, tetrachloroethylene, and benzene. Equilibrium adsorption isotherms conformed to the Freundlich type (log-log linear). The adsorption of dichloromethane and chloroform by rice bran was observed over the range of pH 1-11. Therefore, rice bran is applicable for treatment of wastewater over a wide pH range. Dichloromethane was successfully removed from water samples with an average removal efficiency of 70% after 60 min when rice bran was added to water samples containing from 0.006 to 100 mg/L dichloromethane. The removal of these organochlorine compounds and benzene by rice bran was attributed to the uptake by intracellular particles called spherosomes. Here, we report the results of a fundamental study of the efficiency of rice bran for removal of organochlorine compounds and benzene using a batch system on the laboratory scale, and describe elucidation of the mechanism of removal of these compounds by rice bran.     

Preparation and functional properties of rice bran protein isolate

Rice bran protein isolate (RBPI) containing approximately 92.0% protein was prepared from unstabilized and defatted rice bran using phytase and xylanase. The yield of RBPI increased from 34% to 74.6% through the use of the enzymatic treatment. Nitrogen solubilities of RBPI were 53, 8, 62, 78, 82, and 80% at pHs 2.0, 4.0, 6.0, 8.0, 10.0, and 12.0, respectively. Differential scanning calorimetry showed that RBPI had denaturation temperature of 83.4 degrees C with low endotherm (0.96 J/g of protein). RBPI had similar foaming properties in comparison to egg white. But emulsifying properties of RBPI were significantly lower than those of bovine serum albumin. The result of amino acid analysis showed that RBPI had a similar profile of essential amino acid requirements for 2-5-year-old children in comparison to that of casein and soy protein isolate.     

Protein extraction from heat-stabilized defatted rice bran. 1. Physical processing and enzyme treatments

Physical processing with or without enzyme treatments on protein extraction from heat-stabilized defatted rice bran (HDRB) was evaluated. Freeze-thaw, sonication, high-speed blending, and high-pressure methods extracted 12%, 15%, 16%, and 11% protein, respectively. Sonication (0-100%, 750 W), followed by amylase and combined amylase and protease treatments, extracted 25.6-33.9% and 54.0-57.8% protein, respectively. Blending followed by amylase and protease treatment extracted 5.0% more protein than the nonblended enzymatic treatments. High-pressure treatments, 0-800 MPa, with water or amylase-protease combinations, extracted 10.5-11.1% or 61.8-66.6% protein, respectively. These results suggest that physical processing in combination with enzyme treatments can be effective in extracting protein from HDRB.     

Optimization of acid hydrolysis conditions for feruloylated oligosaccharides from rice bran through response surface methodolgy

Response surface methodology (RSM) was employed to optimize the hydrolysis conditions with trifluoroacetic acid (TFA) to obtain the maximum amount of feruloylated oligosaccharides from rice bran. The TFA concentration and hydrolysis time effects on feruloylated oligosaccharides recovery are studied. The optimum hydrolysis conditions for maximizing feruloylated oligosaccharides recovery were 193 mM TFA concentration and 1.36 h of hydrolysis time. Under these conditions the corresponding acyl ferulic group quantity was 78.63 microg in 1 mL of hydrolysate. The model was experimentally verified with a satisfactory coefficient of R (2) (= 0.96). The quantity of acyl ferulic group in the feruloylated oligosaccharides, purified using Amberlite XAD-4, was 916.12 microg/g of rice bran under the optimum hydrolysis conditions. The proposed method accounted for 54.08% of the total acyl ferulic group in rice bran. The results suggest that the proposed conditions were useful in maximizing recovery of feruloylated oligosaccharides from rice bran.     

Prevention of hydrolytic rancidity in rice bran during storage.

The effect of microwave heating, packaging, and storage temperature on the production of free fatty acids (FFA) in rice bran was examined. Freshly milled raw rice bran was adjusted to 21% moisture content and heated in a microwave oven at 850 W for 3 min. Raw and microwave-heated rice bran were packed in zipper-top bags or vacuum-sealed bags and stored at 4-5 or 25 degrees C for 16 weeks. FFA content of bran was measured at 4-week intervals. Total FFA increased rapidly over the 16-week period from the initial value of 2.5% in raw bran stored at 25 degrees C to 54.9% in vacuum bags and 48.1% in zipper-top bags. However, total FFA of raw bran stored at 4-5 degrees C increased at a slower rate from an initial value of 2. 5 to 25.4% in vacuum bags and 19.5% in zipper-top bags. After 16 weeks of storage, total FFA of microwave-heated bran stored at 25 degrees C increased from 2.8 to 6.9 and 5.2%, respectively, for samples stored in vacuum bags and zipper-top bags. Total FFA of microwave-heated samples stored at 4-5 degrees C did not change significantly with storage time. Results showed that hydrolytic rancidity of rice bran can be prevented by microwave heating and that the recommended storage condition for microwaved rice bran is 4-5 degrees C in zipper-top bags.     

Lipase-catalyzed modification of rice bran oil to incorporate capric acid

Capric acid (C10:0) was incorporated into rice bran oil with an immobilized lipase from Rhizomucor miehei as the biocatalyst. Effects of incubation time, substrate mole ratio, enzyme load, and water addition on mole percent incorporation of C10:0 were studied. Transesterification was performed in an organic solvent, hexane, and under solvent-free condition. Pancreatic lipase-catalyzed sn-2 positional analysis and tocopherol analysis were performed before and after enzymatic modification. Products were analyzed by gas-liquid chromatography (GLC) for fatty acid composition. After 24 h of incubation in hexane, there was an average of 26.5 +/- 1.8 mol % incorporation of C10:0 into rice bran oil. The solvent-free reaction produced an average of 24.5 +/- 3.7 mol % capric acid. In general, as the enzyme load, substrate mole ratio, and incubation time increased, the mole percent of capric acid incorporation also increased. Time course reaction indicated C10:0 incorporation increased up to 27.0 mol % at 72 h, for the reaction in hexane, and up to 29.6 mol % at 12 h, for the solvent-free reaction. The highest C10:0 incorporations (53.1 and 43.2 mol %) for the mole ratio experiment occurred at a mole ratio of 1:8 for solvent and solvent-free reactions, respectively. The highest C10:0 incorporation (27.9 mol %) for the reaction in hexane occurred at 10% enzyme load, and the highest incorporation (34.4 mol %) for the solvent-free reaction occurred at 20% enzyme load. Incorporation of C10:0 into rice bran oil declined with the addition of increasing amounts of water after reaching 30.3 mol % at 2% water addition in hexane, and in the solvent-free reaction after reaching 35.9 mol %.     

Prevention of oxidative rancidity in rice bran during storage.

The effect of microwave heat on lipoxygenase (LOX) activity in rice bran under various storage conditions was examined. Raw rice bran from the long-grain variety Lemont was adjusted to 21% moisture content and heated in a microwave oven at 850 W for 3 min. Raw and microwave-heated rice bran samples were packed in zipper-top bags or vacuum packs and stored at room temperature (25 degrees C) or in the refrigerator (4-5 degrees C) for 16 weeks. Samples were analyzed for LOX activity at 4-week intervals. LOX activity did not significantly change from its initial value at week 0 for zipper-top and vacuum-packed samples while stored at 4-5 degrees C for 12 weeks, but decreased at week 16. Vacuum packing did not show a significant impact on LOX activity during 16 weeks of storage. Microwave-heated samples stored in the refrigerator did not show significant change in LOX activity for up to 12 weeks but showed a significant (p < 0. 05) decrease at 16 weeks. Results showed that oxidative rancidity of rice bran could be prevented by microwave heating the samples, packing in zipper-top bags, and storing at 4-5 degrees C for up to 16 weeks.     

黑米皮抗氧化活性物质的提取与分离工艺研究

该研究以总抗氧化能力为活性跟踪指标,应用正交试验研究了黑米皮抗氧化活性物质的提取条件。结果表明,黑米皮抗氧化物提取的最佳浸提条件为：以黑米皮为材料,以60%乙醇为溶剂,料液比1∶4、浸提温度60℃、浸提时间4 h。在此条件下,一次浸提率达71.4%,二次浸提率达85%以上。在去除黑米皮抗氧化提取物中的杂质时,选用石油醚或正己烷进行脱脂处理,对其总抗氧化能力的影响最小。通过静态与动态吸附性能比较,从8种大孔吸附树脂中筛选出对黑米皮抗氧化活性物质吸附性能最好的树脂为NKA-II,其最佳解吸剂为70%乙醇溶液。经NKA-II吸附分离后,黑米皮抗氧化提取物的总抗氧化能力提高4.00倍,总花色苷含量提高4.01倍。     

Use of microscopy to assess bran removal patterns in milled rice

During rice milling, the bran and germ are successively removed from the caryopsis (kernel). Because bran and germ contain large quantities of lipid, the amount of lipid remaining on the kernel surface may be used as a method for the assessment of milling quality. Bulk samples of rice pureline varieties and an experimental hybrid were milled for 0, 10, 20, 30, and 40 s. Scanning electron microscopy (SEM) revealed that brown rice kernels had large contours of linear protuberances and depressions running lengthwise along the kernel surface. The protuberances were abraded successively during milling, but varying amounts of material remained in the depressions. Light microscopy combined with the lipid-specific probes Nile Blue A or Sudan Black B demonstrated that the material in the depressions observed with SEM was lipid. Sections of whole, milled rice kernels, prepared using a modified sectioning technique and stained with Nile Blue A, showed that portions of the embryo remain after milling and that lipid is located on or near the surface of the kernel. Differences in quantity and distribution of residual lipid as milling duration increased were documented photographically to indicate the extent to which the bran and embryo components were removed during milling. This paper provides proof of concept that residual lipid is a robust measure of the degree of milling.     

复合酶法提取稻麸蛋白工艺的优化

运用配料试验设计,采用纤维素酶、复合蛋白酶、植酸酶提取米糠分离蛋白,建立复合酶配合比例与蛋白得率之间的数学模型,确定最佳配比为：纤维素酶65.84%、蛋白酶18.52%、植酸酶15.64%,最佳反应条件为：复合酶温度45℃、底物浓度 20%、酶添加量4%、pH值5.5、水解时间2 h,最终蛋白收率可达86%以上。     

Isolation and identification of novel tocotrienols from rice bran with hypocholesterolemic, antioxidant, and antitumor properties

Two novel tocotrienols were isolated from stabilized and heated rice bran, apart from the known alpha-, beta-, gamma-, and delta-tocopherols and tocotrienols. These new tocotrienols were separated by HPLC, using a normal phase silica column. Their structures were determined by ultraviolet, infrared, nuclear magnetic resonance, circular dichroism, and high-resolution mass spectroscopies and established as desmethyl tocotrienol [3, 4-dihydro-2-methyl-2-(4,8,12-trimethyltrideca-3'(E),7'(E), 11'-trienyl)-2H-1-benzopyran-6-ol] and didesmethy tocotrienol [3, 4-dihydro-2-(4,8,12-trimethyltrideca-3'(E),7'(E), 11'-trienyl)-2H-1-benzopyran-6-ol]. These tocotrienols significantly lowered serum total and LDL cholesterol levels and inhibited HMG-CoA reductase activity in chickens. They had much greater in vitro antioxidant activities and greater suppression of B16 melanoma cell proliferation than alpha-tocopherol and known tocotrienols. Results indicated that the number and position of methyl substituents in tocotrienols affect their hypocholesterolemic, antioxidant, and antitumor properties.     

超声波辅助制备米糠生物柴油及其燃料排放特性

对超声波辅助碱催化米糠油与醇酯交换反应进行了一些列试验研究,并与传统机械搅拌法比较,论证其用于制备生物柴油的可行性.结果显示超声波辅助方法可以缩短酯交换反应的时间15～20 min.超声频率40 kHz条件下反应速度较28 kHz快,但是由于产物水洗分离困难而使得产物得率反而有所下降.超声辅助酯交换法还可以减少催化剂的用量,当催化剂用量为质量分数0.5%时可得到最高的转化率和得率.轻型车排放试验结果显示燃用米糠生物柴油可以显著降低CO和HC排放,而Nox排放有少量增加.     

Efficiency of rice bran for the removal of selected organics from water: kinetic and thermodynamic investigations

The sorption efficiency of indigenous rice (Oryza sativa) bran for the removal of organics, that is, benzene, toluene, ethylbenzene, and cumene (BTEC), from aqueous solutions has been studied. The sorption of BTEC by rice bran is observed over a wide pH range of 1-10, indicating its high applicability to remove these organics from various industrial effluents. Rice bran effectively adsorbs BTEC of 10 microg mL(-1) sorbate concentration from water at temperatures of 283-323 +/- 2 K. The effect of pH, agitation time between solid and liquid phases, sorbent dose, its particle size, and temperature on the sorption of BTEC onto rice bran has been studied. The pore area and average pore diameter of rice bran by BET method are found to be 19 +/- 0.7 m(2) g(-1) and 52.8 +/- 1.3 nm. The rice bran exhibits appreciable sorption of the order of 85 +/- 3.5, 91 +/- 1.8, 94 +/- 1.4, and 96 +/- 1.2% for 10 microg mL(-1) concentration of benzene, toluene, ethylbenzene, and cumene, respectively, in 60 min of agitation time using 0.1 g of rice bran at pH 6 and 303 K. The sorption data follow Freundlich, Langmuir, and Dubinin-Radushkevich (D-R) models. Sorption capacities have been computed for BTEC by Freundlich (32 +/- 3, 61 +/- 14, 123 +/- 28, and 142 +/- 37 m mol g(-1)), Langmuir (6.6 +/- 0.1, 7.5 +/- 0.13, 9.5 +/- 0.22, and 9.4 +/- 0.18 m mol g(-1)), and D-R isotherms (11 +/- 0.5, 16 +/- 1.3, 30 +/- 2.2, and 33 +/- 2.5 m mol g(-1)), respectively. The Lagergren equation is employed for the kinetics of the sorption of BTEC onto rice bran and first-order rate constants (0.03 +/- 0.002, 0.04 +/- 0.003, 0.04 +/- 0.003, and 0.05 +/- 0.004 min(-1)) have been computed for BTEC at their concentration of 100 mug mL(-1) at 303 K. Studies on the variation of sorption with temperatures (283-323 K) at 100 mug mL(-1) sorbate concentration gave thermodynamic constants DeltaH (kJ mol(-1)), DeltaG (kJ mol(-1)), and DeltaS (J mol(-1) K(-1)). The results indicate that the sorption of organics onto rice bran is exothermic and spontaneous in nature under the optimized experimental conditions selected. This sorbent has been used successfully to accumulate and then to determine benzene, toluene, and ethylbenzene in wastewater sample.     

Quantification of vitamin E and gamma-oryzanol components in rice germ and bran

Rice bran is a rich natural source of vitamin E and gamma-oryzanol, which have been extensively studied and reported to possess important health-promoting properties. However, commercial rice bran is a mixture of rice bran and germ, and profiles of vitamin E and gamma-oryzanol components in these two different materials are less well-studied. In the current study, vitamin E and gamma-oryzanol components in rice bran and germ were analyzed by liquid chromatography/mass spectrometry/mass spectrometry. The components were identified by electrospray ionization mass spectrometry (ESI-MS) with both positive- and negative-ion modes. Both deprotonated molecular ion [M - H](-) and protonated molecular ion [M + H](+) found as the base peaks in spectra of vitamin E components made ESI-MS a valuable analytic method in detecting vitamin E compounds, especially when they were at very low levels in samples. Ultraviolet absorption was used for quantification of vitamin E and gamma-oryzanol components. While the level of vitamin E in rice germ was 5 times greater than in rice bran, the level of gamma-oryzanol in rice germ was 5 times lower than in rice bran. Also, the major vitamin E component was alpha-tocopherol in rice germ and gamma-tocotrienol in rice bran. These data suggest that rice bran and germ have significantly different profiles of vitamin E and gamma-oryzanol components. The method enables rapid and direct on-line identification and quantification of the vitamin E and gamma-oryzanol components in rice bran and germ.     

Purification and identification of components of gamma-oryzanol in rice bran Oil.

High-purity gamma-oryzanol was obtained from crude rice bran oil using a normal-phase preparative scale HPLC. A reverse-phase HPLC method was used for separating the individual components of gamma-oryzanol present in rice bran oil. Ten fractions were isolated and collected using the reverse-phase HPLC method, and their structures were identified. Identification was accomplished using GC/MS with an electron impact mass spectrum after components were transformed into trimethylsilyl ether derivatives. The 10 components of gamma-oryzanol were identified as Delta(7)-stigmastenyl ferulate, stigmasteryl ferulate, cycloartenyl ferulate, 24-methylenecycloartanyl ferulate, Delta(7)-campestenyl ferulate, campesteryl ferulate, Delta(7)-sitostenyl ferulate, sitosteryl ferulate, compestanyl ferulate, and sitostanyl ferulate. Three of these, cycloartenyl ferulate, 24-methylenecycloartanyl ferulate, and campesteryl ferulate, were major components of gamma-oryzanol.     

Water extract of defatted rice bran suppresses visceral fat accumulation in rats

Rice bran has been reported to inhibit pancreatic lipase activity in vitro. This action shows that administration of rice bran may result in a decrease in plasma triglyceride levels and suppress accumulation of fat in vivo. We administered water extract of defatted rice bran (WED-rice bran) to rats to determine its effects. Single administration of WED-rice bran at a dose of 1 g/kg body weight caused a decrease in plasma triglyceride levels in fat emulsion induced hypertriglyceridemic rats. Four week administration of WED-rice bran suppressed accumulation of visceral fat and body weight gain without influencing food consumption, liver function, and renal function. These results indicate that a reduction of plasma triglycerides and suppression of visceral fat accumulation may be induced by pancreatic lipase inhibition caused by administration of WED-rice bran.