马铃薯淀粉渣生料多菌种固态发酵生产蛋白饲料工艺

该研究以提高马铃薯淀粉渣的营养价值为目的。以马铃薯渣为主要原料,麸皮和蚕豆秸秆粉等为辅料,混合生料用纤维素酶进行降解处理后,再经黑曲霉与康宁木霉制备的糖化菌剂糖化降解,最后选用白地霉、产朊假丝酵母、酿酒酵母3种SCP发酵菌种,采用多菌协生生料固态发酵工艺研制马铃薯渣菌体蛋白饲料。通过对发酵产物中真蛋白、粗淀粉等指标的定量分析和感官特征的比较。结果表明,纤维素酶处理后的原料,经黑曲霉与康宁木霉双菌糖化降解后,在28℃条件下,经3种菌白地霉：产朊假丝酵母：酿酒酵母按8∶1.5∶0.5比例接种,混合发酵55 h     

蒸汽爆破预处理和微生物发酵对玉米秸秆降解率的影响

为了提高玉米秸秆的利用效率,首先对玉米秸秆进行蒸汽爆破预处理（压力2.5 Mpa,维压200 s）,然后再进行米曲霉发酵,研究物理和生物学处理对秸秆成分及相关酶活变化的影响。结果表明,蒸汽爆破使秸秆中纤维素、半纤维素和木质素的降解率分别达到8.47%、50.45% 和36.65% （p＜0.05）。爆破预处理的秸秆再经米曲霉发酵6 d后,秸秆中纤维素和半纤维素的降解率分别为27.89%和64.80% （p＜0.05）,发酵秸秆中的滤纸酶、羧甲基纤维素酶、淀粉酶和蛋白酶活力分别达到335.10、1138.92、1954.20和201.99 U/g。爆破预处理后进行米曲霉发酵,对于提高玉米秸秆的降解率具有非常重要的意义。     

苹果皮渣固态发酵生产菌体蛋白饲料工艺优化及产物品质分析

为提高苹果皮渣中粗蛋白的含量,以黑曲霉为发酵菌种发酵苹果皮渣,通过单因素试验对影响苹果皮渣固态发酵的参数进行优化,在此基础上进一步采用响应面试验筛选最佳发酵工艺参数,并对最佳工艺条件下的发酵产物品质进行分析。结果表明,黑曲霉发酵苹果皮渣的最佳工艺条件为:黑曲霉接种量10%、发酵温度32℃、水料比3.5、发酵时间6 d。此条件下苹果皮渣经发酵后粗蛋白含量从7.05%提高到33.56%,粗脂肪含量从4.75%提高到5.57%,粗纤维含量从21.80%降低到13.53%,氨基酸总含量从45.10 mg·g~(- 1)提高到126.30 mg·g~(- 1),必需氨基酸含量从16.13 mg·g-1提高到50.40mg·g~(- 1)。综上,黑曲霉发酵可以显著提高苹果皮渣的营养价值,这为苹果皮渣资源化利用、缓解蛋白质供需矛盾提供了有效途径。     

不同粮仓中稻谷优势霉菌的鉴定及差异性分析

为了研究稻谷中优势霉菌的种类、数量以及变化趋势,本试验以湖南省3个不同地区稻谷为研究对象,通过初步判断各粮仓优势霉菌,结合分子生物学方法对其ITS 序列进行分析,并对稻谷霉菌进行带菌量测定。结果表明,3个粮仓中,金牛仓稻谷中优势菌株分别为根霉、米曲霉、毛霉、黑曲霉、烟曲霉、黄曲霉、白曲霉、桔青霉;金山仓稻谷中优势菌株分别为根霉、米曲霉、毛霉、黑曲霉、黄曲霉、白曲霉、桔青霉;银光仓稻谷中优势菌株分别为根霉、米曲霉、毛霉、黑曲霉、黄曲霉。3个粮仓中根霉数量分布均表现为上层>下层>中层,米曲霉为中层>上层>下层,毛霉、黑曲霉、黄曲霉的分布为上层>中层>下层,同一霉菌在同一粮仓不同粮层间数量存在显著差异(P<0.05);随着储藏时间的延长,米曲霉、黑曲霉、黄曲霉数量逐渐减少,根霉、毛霉数量增加,同一霉菌在不同储藏时间霉菌数量存在差异显著(P<0.05)。本研究结果为稻谷安全储藏与霉菌防控提供了一定的理论依据。     

汽爆玉米秸秆酶解时表观酶活及物料理化性质的变化

为推动汽爆玉米秸秆生产丁醇的工业化进程,从工程实际出发,针对汽爆玉米秸秆酶解过程进行研究,考察酶解液糖浓度、纤维素酶表观酶活以及搅拌器搅拌功率的变化,并利用显微镜、电镜、X-ray、以及粒度分布仪对酶解反应过程中物料物理化学性质的改变进行表征。结果表明：随着酶解反应的进行,酶解液糖浓度从初始的0持续增加到56.25 g/L,搅拌功率持续降低,由反应初期的32.3 W降低至反应后期的5.2 W,且都是在1 h内变化最快;纤维素酶表观酶活则表现为先降低后增加,然后再降低的趋势;在酶解过程中固体颗粒粒度呈现降低的趋势,比表面积逐渐增加,结晶度和微晶尺寸也有所降低,颗粒内部空腔增多。该研究为秸秆丁醇工业化提供参考。     

豆腐渣混合苹果渣固态发酵改善纤维适口性

为了改善豆腐渣发酵后膳食纤维的适口性,适量混合部分苹果渣,利用其糖分提高酿酒酵母的发酵效率,并对其固态发酵工艺条件进行优化。采用单因素和正交试验方法优化的较佳发酵条件为pH值为8、发酵温度22℃、豆腐渣与苹果渣质量比2∶1、酿酒酵母接种量8%、发酵时间48 h。在优化发酵条件下,豆腐渣和苹果渣混合物中粗纤维的质量分数由发酵前的107.8 mg/g下降到发酵后的64.2 mg/g,降解率为40.45%。混合苹果渣的固态发酵极大地改善了膳食纤维的适口性,可以作为健康食品原料广泛使用。     

黑曲霉固体发酵生产纤维素酶培养基构成优化研究

研究结果表明应用双温度培养法进行黑曲霉固体发酵生产纤维素酶时 ,在自然补给氧气、培养基 pH值约6 .5并保持环境湿度约 6 0 %条件下 ,葡萄糖对滤纸酶活力有促进作用 ;葡萄糖、麸皮、(NH4 ) 2 SO4 、水分适宜作为固体培养基基本成分 ;表面活性剂吐温 80对纤维素酶活力促进效果并不明显     

黑曲霉固态发酵苹果渣产木聚糖酶的工艺优化研究

为了获得有较高酶活值的低成本木聚糖酶产品,试验以苹果渣和棉粕为基料研究了黑曲霉(Aspergillus niger SL-05)固态发酵产木聚糖酶的最佳条件.初步试验结果表明:以棉粕和苹果渣(1:1)作为基础氮源和碳源得到的发酵曲的酶活值最高.通过Plackett-Burman试验筛选出了对产酶影响显著的3个因素:尿素、KH2PO4、含水率.进一步试验采用二次回归正交旋转试验设计研究了自变量(尿素、KH2PO4、含水率)对黑曲霉SL-05产酶的影响,通过响应面分析获得了产酶的最佳条件.模型的方差检验显示总回归达到了显著水平(P＜0.05),失拟性检验不显著,说明模型适合并且预测尿素、KH2PO4、含水率对产酶的影响非常有效.在最佳条件(基料棉粕和苹果渣比例为1:1,第2氮源尿素2.6%,无机盐KH2PO4 0.09%,速效碳源葡萄糖2%,含水率62.9%,30℃培养60 h)下,分别获得T5662、30000 U/g的木聚糖酶和纤维素酶的高酶活发酵干曲.以廉价的工农业废料作为基本培养基获得了有较高酶活的产品,经济优势明显.     

甜高粱茎汁及茎渣同步糖化发酵工艺优化

为了提高甜高粱秸秆乙醇生产中茎汁和茎渣的利用,以甜高粱茎汁及其渣为发酵原料,对茎汁茎渣混合原料同步糖化乙醇发酵的工艺条件进行优化研究。采用Plackett-Burman(PB)筛选设计试验筛选出影响甜高粱茎秆渣汁同步糖化乙醇发酵的显著因素。采用响应面法建立了同步糖化发酵乙醇生产的乙醇产量数学模型。根据该模型进行了工艺参数的优化,以乙醇产量为指标,试验所得甜高粱茎秆渣汁同步糖化化乙醇发酵的优化工艺条件为:发酵温度36.58℃,混合纤维素酶添加量=23.5(FBU/m L)/35.25(CBU/m L),甜高粱渣汁质量体积比为8.2%,理论预测乙醇产量为89.2%,在此条件下进行验证试验,乙醇产量为88.98%,平均质量浓度,验证了数学模型的有效性,为提高甜高粱茎汁及茎渣混合原料同步糖化发酵产乙醇和提高发酵效率提供参考。     

产纤维素酶真菌混合发酵研究进展

总结了常见的分解纤维素真菌种类,并介绍了纤维素酶生产的方法。传统的利用单一菌种发酵纤维素材料的方法存在降解率低,发酵时间长等缺陷。而利用微生态原理,使用多个菌种进行混合发酵的方法被证明可以有效降解纤维素。重点介绍了固态混合发酵和液体混合发酵的工艺,并对产纤维素酶真菌混合发酵的前景作了预测。     

Immunoreactivity and amino acid content of fermented soybean products

Food allergy has become a public health problem that continues to challenge both the public and the food industry. The objective of this research was the detection and quantification of the major human allergenic soy proteins and to study the reduction in immunoreactivity and improvement of amino acid content after fermentation of soybean flour. Fermentation was carried out in the solid state of cracked seeds inoculated with Aspergillus oryzae, Rhizopus oryzae, and Bacillus subtilis and in the liquid state of milled soybean flours fermented naturally by microorganisms present only in the seeds or by inoculation with Lactobacillus plantarum. ELISA and Western blot were used to quantify IgE antibody response, and HPLC was used to identify and quantify total amino acids. L. plantarum fermented soy flour showed the highest reduction in IgE immunoreactivity (96-99%) depending upon the sensitivity of the plasma used. Among the solid fermented products, the lowest reduction in immunoreactivity was obtained when mold strains, R. oryzae and A. oryzae, were used (66 and 68%, respectively, for human plasma 97.5 kUA/L). Among the solid fermented products, those inoculated with B. subtilis yielded a 81 and 86% reduction in immunoreactivity against both human plasma 97.5 IgE kUA/L and human pooled plasma samples, respectively. When soybean was subjected to liquid fermentation, most of the total amino acids increased significantly ( p < or = 0.05). In solid fermentation with R. oryzae, only Ala and Thr content improved. Fermentation can decrease soy immunoreactivity, and there is potential of developing nutritious hypoallergenic soy products.     

Enzymatic formation of ether linkage producing shoyuflavones from genistein and (+/-)-trans-epoxysuccinic acid

The production mechanism of shoyuflavones, conjugated ethers of isoflavones with tartaric acid and isolated from fermented soy sauce, was studied. In the high molecular weight fraction of the culture extract of Aspergillus oryzae, genistein was transformed into shoyuflavone B in the presence of (+/-)-trans-epoxysuccinic acid but not in the low molecular one. Asp. sojae and Asp. tamarii showed high activity similar to Asp. oryzae but none of Asp. niger, Rhizopus oligosporus, and Mucor praini did. The contents of epoxysuccinic acids in the starting materials of soy sauce and the cultures of various Asp. fungi were determined as dimethyl 2-chloro-3-hydroxysuccinate derivatives by GC-MS. Although epoxysuccinic acids were contained in Asp. oryzae, Asp. sojae, and Asp. tamarii cultures, they were not found in soybeans and wheat. A possible producing mechanism for shoyuflavones by enzymatically conjugating isoflavones to (+/-)-trans-epoxysuccinic acid with ether linkage was suggested.     

采用EEM-FRI方法研究黑曲霉对牛粪堆肥腐熟及纤维素降解影响

为了优化堆肥工艺,提高堆肥产品质量,研究黑曲霉对牛粪堆肥腐熟度和纤维素降解的影响.该研究以牛粪为原料,小麦秸秆为辅料,以不添加黑曲霉为对照,分别添加1％、2％和3％的黑曲霉进行好氧堆肥,研究了黑曲霉不同添加量对腐熟度指标、养分含量、腐殖质组成以及纤维素组分的影响,并采用激发发射荧光光谱结合荧光区域积分(Excitati...     

Induction of the soybean phytoalexins coumestrol and glyceollin by Aspergillus

Several isoflavonoid phytoalexins produced by soybeans are known to be estrogenic, with potential beneficial health effects in humans. Increased production of phytoalexins by the soybean plant will facilitate research efforts in this area. In this study, phytoalexin induction and accumulation in soybean cotyledon tissue was observed using four species of Aspergillus: A. sojae, A. oryzae, A. niger, and A. flavus. All four Aspergillus species tested elicited phytoalexin accumulation in living soybean cotyledons. Results from a time course study indicated that maximum concentrations of the phytoalexin glyceollin, 955 microg/g fresh weight (fw), occurred at day 3 in soybean cotyledon tissue inoculated with A. sojae. Other Aspergillus species caused an accumulation of glyceollin at significantly lower levels. A maximum concentration of coumestrol of 27.2 microg/g fw was obtained from soybean cotyledons inoculated with A. niger. Soybean phytoalexins induced by food-grade A. sojae and A. oryzae allowed the collection of higher concentrations of phytoalexins for further examination in several in vitro and in vivo biological studies conducted to determine potential estrogenic activities.     

黑曲霉对潮褐土镉、锌污染的原位固定修复潜力研究

采用温室盆栽试验,研究了在黑曲霉(30582)作用下油菜对潮褐土Cd、Zn复合污染胁迫的耐性及富集特征。结果表明:接入黑曲霉菌液对油菜地上部干重总体上无明显影响,且降低了油菜对土壤Cd、Zn的吸收量。加入黑曲霉菌液后,油菜地上部和地下部Cd含量较对照最高分别降低了31.60%,37.82%;地上部和地下部Zn含量较对照处理最高分别降低了35.12%,35.74%;土壤有效态Cd、Zn含量显著减少,较对照最高分别降低了30.51%,39.64%。综上,黑曲霉有效地降低了污染土壤中Cd、Zn的生物有效性,对土壤中低浓度重金属污染的原位固定表现出较佳的效果,具备应用于修复Cd、Zn污染土壤的潜力。     

Corncob-induced endo-1,4-beta-d-xylanase of Aspergillus oryzae MTCC 5154: production and characterization of xylobiose from glucuronoxylan

Eight different fungi were cultivated in a peptone-yeast extract medium containing 1% oat spelt xylan (OSX) to evaluate endo-1,4-beta-xylanase secretion for xylooligosaccharide (XOS) production. Aspergillus oryzae MTCC 5154, Aspergillus flavus , Aspergillus niger , and Aspergillus ochraceus showed significant titers of endoxylanases, which were further used for the production of XOS from birch wood xylan (BWX). A. oryzae produced 89.5 +/- 1.13% XOS in the hydrolysate at 24 h of reaction. The effect of OSX, BWX, and raw corncob on the induction of endoxylanase in A. oryzae was studied, and the xylanase activity was maximum at 96 h of cultivation in 3% corncob containing medium. XOS produced at 36 h of reaction was 5.87 +/- 0.53 mg/mL (12 +/- 2% xylose, 48 +/- 2.43% xylobiose, and 40 +/- 3.6% higher oligomers) from 1% BWX . HPLC/refractive index detection and ESI/MS analysis of fractions obtained by GPC corresponded to neutral and 4- O-methyl-alpha- d-glucuronic acid substituted acidic oligosaccharides. The major fraction, beta- d-xylopyranosyl-(1-->4)- d-xylanopyranose was characterized using (13)C NMR.     

Characteristics and use of okara, the soybean residue from soy milk production--a review

Large quantities of okara produced annually pose a significant disposal problem. It contains mostly crude fiber composed of cellulose, hemicellulose, and lignin, about 25% protein, 10-15% oil, but little starch or simple carbohydrates. It is a suitable dietary additive in biscuits and snacks because it reduces calorie intake and increases dietary fiber. The high-quality protein fraction has good water holding and emulsifying qualities and contains a peptide with anti-hypertension effects. The pectic polysaccharides fraction is suitable for thickening acid milk products. Okara fermented with Actinomucor elegans (meitauza), Aspergillus oryzae (koji), Neurospora intermedia (ontjom), and Rhizopus oligosporus (tempe), on consumption, reduces cholesterol level and contains substances that counteract dietary free radicals. Unique and useful products produced by Bacillus subtilis and Penicillium simplicissimum on okara include surfactin and iturin A (fungicidal), okaramines A, B, D-F (D is insecticidal), an oleanane triterpene, and two dihydroquinolinones (one toxic for Artemia salina). Okara has been used as silkworm food and in the production of ceramics.     

黑曲霉木聚糖酶基因（xynB）的克隆及真核分泌表达

通过RT-PCR方法,以黑曲霉(Aspergillus niger)GIM3.452总RNA为模板,克隆出木聚糖酶B(xy-lanase B,xynB)基因的成熟肽编码序列(567 bp),编码188个氨基酸.将其与猪腮腺分泌蛋白(parotid secretoryprotein,PSP)基因的信号肽序列通过重叠延伸PCR(SOE-PCR)得到拼接片段PSxynB,并将其克隆到真核表达载体pcDNA6/HisTMA中,得到重组质粒pcDNA-PSxynB,重组质粒经过酶切、测序鉴定,证实含有目的片段,且构建正确.在脂质体介导下将重组质粒pcDNA-PSxynB转染猪肾细胞(PK15),通过RT-PCR证实其在PK15细胞中表达,并在细胞培养液中测到了木聚糖酶活最高达36.4 IU/mL.