Negative effects of stress immediately before slaughter on pork quality are aggravated by suboptimal transport and lairage conditions

The objectives of the present experiment were 1) to study the effects of transport conditions and lairage duration on stress level, muscle glycolytic potential, and pork quality; and 2) to investigate whether the negative effects of high stress immediately preslaughter are affected by preceding handling factors (transport and lairage). In a 2 x 2 x 2 factorial design, halothane-free pigs (n = 384) were assigned to either short (50 min) and smooth or long (3 h) and rough transport; long (3 h) or short (<45 min) lairage; and minimal or high preslaughter stress. Pigs were processed in eight groups (48 pigs per group) on various days at a commercial plant. Blood samples were taken at exsanguination to measure plasma cortisol and lactate concentrations. Muscle pH and temperature were measured at 30 and 40 min, respectively, and both were measured at 3 h, postmortem. A LM sample was taken 135 min postmortem to estimate glycogen content and rate of glycolysis. Pork quality attributes were assessed 23 h postmortem. Short transport increased cortisol when followed by short lairage (transport x lairage; P < 0.01). Long transport, but not lairage (P > 0.30), tended to increase (P = 0.06) muscle glycolytic potential. Long transport tended to increase (P = 0.08) electrical conductivity, and decreased a* (P < 0.01) and b* (P < 0.02) values. Decreasing lairage from 3 h to <45 min decreased (P < 0.05) the L* value, but it did not (P > 0.10) affect other pork quality traits. High stress decreased (P < 0.001) muscle glycolytic potential, and increased (P < 0.001) plasma lactate, cortisol, muscle temperature, rate of pH decline, and ultimate pH. Except for decreased (P < 0.001) b* values, pork color was not (P > 0.40) affected by high stress, but water-holding properties (measured by electrical conductivity, filter paper moisture, and drip loss) were impaired (P < 0.001) by high stress. Fiber optic-measured light scattering and Warner-Bratzler shear force were not (P > 0.12) affected by any treatment. Comparisons with the "optimal" handling (short transport, long lairage, and minimal stress) revealed that, with regard to water-holding properties, the negative effects of high stress were aggravated by suboptimal transport and lairage conditions. High stress alone increased electrical conductivity by 56%, whereas high stress in combination with short lairage led to an 88% increase. However, high preslaughter stress contributed most and was the major factor responsible for reductions in pork quality.     

Rapid chilling cannot prevent inferior pork quality caused by high preslaughter stress

The present experiment investigated whether increasing chilling rate could improve meat quality in pigs exposed to either minimal or high stress immediately preslaughter. Pigs (n = 192) were offspring of halothane-free lines. On various days, four groups of 48 pigs were processed at a commercial plant. Within each group, half the pigs were exposed to either minimal or high preslaughter stress. Before entering the cooler at 45 min postmortem, carcasses of both minimal and high preslaughter stress treatments were allocated randomly to either conventional (+4 degrees C for 22 h) or rapid (three-phase chilling tunnel: -15, -10, and -1 degrees C for 15, 38, and 38 min, respectively, followed by storage at 4 degrees C until 22 h postmortem) chilling. Temperature and pH were measured in the blood at exsanguination and in the longissimus lumborum (LL) and semimembranosus (SM) muscle at 0.5, 2.5, 4.5, 6.5, and 22 h postmortem. Meat quality attributes (water-holding capacity and objective color measurements) were assessed on the LL. Preslaughter stress level affected pH and temperature in both blood and muscle, with lower (P < 0.001) pH values and higher (P < 0.001) temperatures for pigs exposed to high vs. minimal stress. Rapid chilling led to a faster (P < 0.001) temperature decline regardless of preslaughter stress level. Rapid chilling did not (P > 0.05) influence the rate of pH decline in the LL muscle, but reduced (P = 0.061) pH decline in the SM. Rapid chilling, as opposed to conventional chilling, decreased (P < 0.05) electrical conductivity in the LL, regardless of preslaughter stress; however, it could not compensate for the detrimental effect (P < 0.05) of stress on drip loss, filter paper moisture absorption, and meat color (L* value). Results from the present study indicated that increasing chilling rate is not a suitable method to resolve pork quality problems caused by inadequate preslaughter handling.     

Preslaughter handling effects on pork quality and glycolytic potential in two muscles differing in fiber type composition

The objective of the present experiment was to investigate the effects of transportation, lairage, and preslaughter stressor treatment on glycolytic potential and pork quality of the glycolytic longissimus and the oxidative supraspinatus (SSP) or serratus ventralis (SV) muscles. In a 2 x 2 x 2 factorial design, 384 pigs were assigned randomly either to short (50 min) and smooth or long (3 h) and rough transport, long (3 h) or short (< 45 min) lairage, and minimal or high preslaughter stress. Muscle samples were taken from the LM at 135 min and from the SSP at 160 min postmortem for determination of the glycolytic potential and rate of glycolysis. At 23 h postmortem, pork quality was assessed in the LM and the SV. Effects of transport and lairage conditions were similar in both muscle types. Long transport increased (P < 0.01) the glycolytic potential and muscle lactate concentrations compared with short transport. Both long transportation and short lairage decreased (P < 0.01) redness (a* values) and yellowness (b* values) of the LM and SV. In combination with short lairage, long transport decreased (P < 0.05) pork lightness (lower L* values), and electrical conductivity was increased (P < 0.05) after long transport. Several interactions between stress level and muscle type (P < 0.001) were observed. High preslaughter stress decreased (P < 0.001) muscle glycogen in both the LM and SSP, but this decrease was greater in the LM. Lactate concentrations were increased (P < 0.001) only in the LM by high preslaughter stress. Increases in ultimate pH (P < 0.001) and decreases in a* values (P < 0.01) were greatest in the SV, whereas increases in electrical conductivity (P < 0.001) were greatest in the LM. The lack of interactions among transportation, lairage, and muscle type was attributed to the relatively minor differences in stress among treatments. It was concluded that, in glycolytic muscle types such as the LM, the high physical and psychological stress levels associated with stress in the immediate preslaughter period have a greater effect on the water-holding capacity of the meat and may promote PSE development. Conversely, oxidative muscle types tend to have higher ultimate pH values and produce DFD pork in response to intense physical activity and/or high psychological stress levels preslaughter.     

Head-only followed by cardiac arrest electrical stunning is an effective alternative to head-only electrical stunning in pigs

Many small slaughter facilities use head-only electrical stunning to render swine unconscious and insensible to pain before slaughter. Head-only electrical stunning is a reversible procedure that is optimally effective for approximately 15 s after stun completion. In many small North American slaughter plants, the authors have observed hoist speeds that are too slow to achieve a short enough stun-to-bleed interval to maintain insensibility through exsanguination. Unlike many European plants, there is no separate high-speed hoist for pigs and exsanguination on the floor is not condoned. As a result, a 2-stage stunning method was proposed where head-only stunning for 3 s was immediately followed by application of the same stunning wand to the cardiac region of the animal for 3 s while lying in lateral recumbancy. A paired-comparison study was conducted on 89 pigs in a small slaughter facility to compare the head-only method applied for 6 s with the head/heart method. The objective was to evaluate signs of return to sensibility, stun-to-bleed time, blood lactate concentration, muscle pH, drip loss, and fresh meat color to validate the head/heart electrical stunning method for small slaughter plants. Incidence of corneal reflex was not different (P > 0.05) between head/heart (93.8%) and head only (85%) stunning. Nose twitching was more common (P < 0.05) in head only (26.5%) than head/heart (5%) stunning. Head/heart stunning eliminated rhythmic breathing, natural blinking, eye tracking to moving objects, and righting reflex, which were all observed in head-only stunned pigs. Eye tracking to moving objects was observed in 40.8% of head-only stunned pigs. Blood lactate was not different (P > 0.05) between stunning methods (head only: 8.8 ± 0.7 mmol/L, head/heart: 7.8 ± 0.7 mmol/L). Stun-to-bleed time did not differ (P > 0.05; head only: 32 ± 1 s, head/heart: 33 ± 1 s). Mean time to loss of heartbeat with the head-only method was 121 ± 5 s. No heartbeat was observed with the head/heart method. Longissimus thoracis pH, color, and drip loss were not different (P > 0.05) between stunning methods. This study determined that the head/heart electrical stunning method reduces the incidence of signs of return to sensibility without significant effects on meat quality, plant operation speed, or blood lactate concentration. In addition, the head/heart method requires no capital investment for plants that are currently using the head-only method.     

Effects of oral administration of sodium citrate or acetate to pigs on blood parameters, postmortem glycolysis, muscle pH decline, and quality attributes of pork

The objective of this study was to determine the effects of oral administration of sodium citrate (CIT) or acetate (ACE) to pigs on blood parameters, postmortem glycolysis, pH decline, and quality attributes of pork. Previous studies have shown that CIT has the potential to inhibit phosphofructokinase (PFK), a key enzyme in postmortem muscle glycolysis. In Exp. 1, CIT, ACE, or water was orally administered (0.75 g/kg of BW) to 24 pigs. After a 30-min rest, pigs were exercised, and blood samples were taken at 45 and 75 min after oral treatment. Citrate and ACE tended (P = 0.08) to increase blood pH and increased (P = 0.02) bicarbonate levels immediately after exercise. After a 30-min rest, blood pH of pigs administered ACE tended (P = 0.09) to remain higher, whereas blood pH of CIT-treated pigs was similar to that of control pigs. Bicarbonate levels in ACE- and CIT-treated pigs were still greater (P < 0.05) than those of control pigs at 75 min after oral treatment. In Exp. 2, 30 pigs were administered CIT, ACE, or water 45 min before stunning (electric plus captive bolt). Antemortem treatments had no effect (P > 0.10) on muscle pH or postmortem concentrations of the glycolytic metabolites of glucose-6 phosphate, fructose-6 phosphate, fructose-1,6 bisphosphate, glyceraldehyde-3 phosphate, dihydroxyacetone phosphate, or lactate. Minor, but inconsistent, differences in quality attributes were found in LM chops, and no differences in quality attributes were found between control and CIT- or ACE-treated pigs for inside and outside semimembranosus muscles (P > 0.10). There was no significant inhibition of the PFK enzyme by orally administered CIT or ACE; however, the PFK glycolytic metabolite data analysis indicated that PFK was a main regulatory enzyme in postmortem muscle.     

Effects of betaine, pen space, and slaughter handling method on growth performance, carcass traits, and pork quality of finishing barrows

An experiment was conducted to determine the effects of betaine, pen space, and preslaughter handling method on growth, carcass traits, and pork quality of finishing barrows. For the growth trial, a 2 x 2 factorial arrangement of treatments was used: betaine (0 or 0.250%) and(or) pen space (m2/pig; adequate, 0.035 BW0.67 kg, or inadequate, 0.025 BW0.67 kg). Each treatment was replicated five times with four barrows per replicate. At trial termination, two barrows from each pen were selected to receive either minimal or normal preslaughter handling. Reducing pen space decreased (P < 0.05) overall ADG and gain:feed and tended (P = 0.12) to decrease overall ADFI. Betaine had no affect (P > 0.10) on overall ADG, ADFI, or gain:feed. Pigs fed betaine had decreased (P < 0.10) carcass length. Other carcass and ham measurements were not affected (P > 0.10) by betaine. Pigs with inadequate pen space had increased (P < 0.10) ultimate pH, subjective color, cooking loss (fresh and frozen chop), and shear force but decreased rectal temperature, loin muscle CIE L*, biceps femoris CIE b*, and drip loss. Pigs subjected to minimal preslaughter handling had decreased (P < 0.10) rectal temperature, plasma cortisol, loin muscle CIE b*, and fresh chop total loss (drip + cooking loss). Pigs fed betaine had increased (P < 0.01) initial pH and decreased (P < 0.10) drip loss (fresh chop). Cooking loss and total loss (frozen chop) were decreased in pigs fed betaine with adequate pen space but increased in pigs fed betaine with inadequate pen space (betaine x pen space, P < 0.01). Pigs fed betaine may have improved pork quality.     

Effects of fasting and transportation on pork quality development and extent of postmortem metabolism

One hundred seventy-seven pigs were used to determine the interaction effects of fasting and length of transport prior to harvest on pork muscle quality. The study design was a 2 x 2 x 3 factorial, which involved two genetic sources, fasting (F) or no fasting (N) of pigs 48-h prior to harvest, and three transport times (0.5, 2.5, or 8.0 h) on a semitrailer to the packing plant. Genetic source was a significant source of variation (P < 0.05) for most composition and muscle quality variables. Fasting reduced hot carcass weight 3.6% (P < 0.05), but length of transport did not affect hot carcass weight (P > 0.05). There were no differences (P > 0.05) in percent lean among fasting and transport treatments. Fasted pigs had higher longissimus dorsi (LD) ultimate pH (pHu), darker lean color, higher marbling score and lower 7-d purge loss, 24-h drip loss, and cooking loss (P < 0.05) than nonfasted pigs. Meat from pigs that were transported 8.0 h had lower glycolytic potential (GP), higher LD and semimembranosus (SM) pHu, darker lean color, and lower L*, 7-d purge loss, 24-h drip loss, cooking loss, and shear force values than meat from pigs transported 0.5 h (P < 0.05). Meat from pigs transported 2.5 h had higher LD and SM pHu and lower L*, 7-d purge loss, 24-h drip loss, and cooking loss than meat from pigs transported 0.5 h (P < 0.05). Meat from pigs transported 8.0 h had higher LD pHu and color scores and lower L* and cooking loss than meat from pigs transported 2.5 h (P < 0.05). The fasting x transport interaction was significant for SM pHu, L*, color score, and drip loss. Fasting improved SM pHu, L*, color score, and drip loss for pigs that were transported 0.5 h (P < 0.05), but when pigs were transported for 2.5 h or 8.0 h, fasting had little or no effect on these muscle quality traits. Fasting lowered GP and increased LD pHu for pigs from the genetic source with the higher initial pork quality (P < 0.05), while fasting had no effect on pork quality for pigs from the genetic source with the lower initial pork quality (P > 0.05). Longer transport times resulted in lower GP and higher LD pHu regardless of genetic source. Fasting and length of transport each had positive effects on pork quality, but length of transport effects was greater in magnitude. When pigs were transported for 0.5 h, fasting for 48 h prior to harvest improved pork quality, but when pigs were transported 2.5 or 8.0 h, fasting had little effect on pork quality.     

Effects of high-protein/low-carbohydrate swine diets during the final finishing phase on pork muscle quality

The aim of this study was to lower the glycogen stores in pork muscle in order to improve pork muscle quality by feeding an ultra-high-protein/low-carbohydrate (HIPRO) diet. Forty-eight barrows (average live weight = 92 kg) were assigned across five treatments and two replications (four or five pigs per treatment by replication combination). All barrows were fed a control diet (13.1% CP) until their assigned treatment began. A treatment was the number of days the barrows were fed the HIPRO diet prior to slaughter (0, 2, 4, 7, or 14 d). The HIPRO diet (35.9% CP) was 97% extruded soybeans. Daily feed intake and weekly live weights were recorded for all barrows. At-death blood glucose levels were determined. Muscle pH, temperature, and electrical impedance were measured in the longissmus lumborum and semimembranosus muscles at 45 min, 3 h, and 24 h postmortem. Glycolytic potential; Minolta L*a*b* values; visual scores for color, firmness, and marbling; water-holding capacity traits (drip loss, purge loss, and cooking loss); and Warner-Bratzler shear force values were determined in the longissmus thoracis et lumborum. Weight gain per day decreased the longer the pigs were fed the HIPRO diet (P < 0.05). Daily feed intake decreased during the 1st wk on the HIPRO diet but returned to near-control levels during the 2nd wk, which when coupled with the continued decreases in daily gain resulted in substantial decreases in feed efficiency during the 2nd wk on the HIPRO diet (P < 0.05). Blood glucose levels and glycolytic potentials were not lowered by feeding the HIPRO diet (P > 0.05); therefore, no differences in rate of pH decline or ultimate pH among dietary treatments were found (P > 0.05). Likewise, there were no differences among dietary treatments in any of the measured meat quality attributes (P > 0.05). Feeding barrows the HIPRO diet for a time period prior to slaughter decreased feed intake, rate of gain, and feed efficiency and was not effective at lowering glycolytic potential or improving pork muscle quality.     

Effects of dietary magnesium and short-duration transportation on stress response, postmortem muscle metabolism, and meat quality of finishing swine

Crossbred pigs, heterozygous for the halothane gene, were used to determine the effects of long-term dietary supplementation of magnesium mica (MM) and short-duration transportation stress on performance, stress response, postmortem metabolism, and pork quality. Pigs were blocked by weight, penned in groups (six pigs per pen), and pens (three pens per diet) were assigned randomly either to a control corn-soybean meal diet or the control diet supplemented with 2.5% MM (as-fed basis; supplemented at the expense of corn). Diets were fed during the early-finisher (0.95% lysine, as-fed basis; 43.7 to 68 kg) and late-finisher (0.85% lysine, as-fed basis; 68 to 103 kg) periods. At the conclusion of the 71-d feeding trial, 12 pigs from each dietary treatment were selected randomly and subjected either to no stress (NS) or 3 h of transportation stress (TS). Dietary MM had no effect (P > or = 0.40) on ADG or ADFI; however, G:F was improved (P < 0.05) during the early-finisher period when pigs were fed MM-supplemented diets. Plasma glucose concentrations were increased in TS pigs fed the control diet, but transportation did not affect plasma glucose in pigs fed 2.5% MM (diet x transportation stress; P = 0.02). Dietary MM did not affect blood lactate, cortisol, insulin, NEFA, Ca, or Mg concentrations in response to TS (diet x transportation stress; P > or = 0.13); however, circulating lactate, cortisol, and glucose concentrations increased in TS pigs (transportation stress x time; P < 0.01). The LM from TS pigs fed MM had higher initial (0-min) and 45-min pH values than the LM from NS pigs fed the control diet (diet x transportation stress x time; P = 0.07). Lactic acid concentration and glycolytic potential were greater in the LM of TS pigs fed MM than TS pigs fed control diets (diet x transportation stress; P < or = 0.01). Although some trends were identified, neither MM (P > or = 0.15) nor TS (P > or = 0.11) altered the color or water-holding capacity of the LM and semimembranosus. The transportation model elicited the expected changes in endocrine and blood metabolites, but dietary MM did not alter the stress response in pigs. Conversely, although pork quality traits were not improved by dietary MM, delaying postmortem glycolysis and elevating 0- and 45-min muscle pH by feeding finishing diets fortified with MM may benefit the pork industry by decreasing the incidence of PSE pork in pigs subjected to short-duration, routine stressors.     

肌糖原含量与猪生产性能、胴体品质及肉质性状间的关系

试验比较2个不同基因型猪肌糖原含量、生长性能、胴体品质和肉质的差异,并分析肌糖原含量与生长性能、胴体品质及肉质之间的相关关系。将7头纯种汉普夏阉公猪体重为(19.48±1.1)kg和6头长撒公猪体重为(20.5±1.5)kg在相同条件下进行单圈饲养,到体重达100kg左右时屠宰,并测定肌糖原、胴体品质和肉质。结果表明:汉普夏猪比长撒猪有较高的日增重(P>0.05),较高的肌糖原含量(P<0.05);长撒猪有较高的背膘厚(P<0.01),较低的屠宰率(P<0.05)、眼肌面积和瘦肉率(P<0.01);汉普夏猪有较低的pH2(P<0.05)、剪切力(P<0.05)和b值(P<0.01),但滴水损失和失水率(P<0.05)高于长撒猪。相关分析结果表明:肌糖原含量与眼肌面积和瘦肉率呈正相关,与剪切力、滴水损失、平均日增重、b值、pH1和pH2呈负相关,而与平均日增重、屠宰率和胴体长相关性不大。这表明肌糖原含量是影响猪胴体品质和肉质的一个重要因素。     

Comparison of histochemical characteristics in various pork groups categorized by postmortem metabolic rate and pork quality

The purpose of the present study was to investigate the variations in histochemical characteristics of muscle samples segregated according to metabolic rates (MR) and pork quality attributes. A total of 231 crossbred Duroc x (Yorkshire x Landrace) pigs was evaluated. Samples of the LM were taken to evaluate histochemical characteristics, postmortem MR, and meat quality. Samples were classified into fast, normal, and slow MR groups based on muscle pH at 45 min and R-value. Drip loss and lightness (L*) were used to assign samples to 1 of 4 quality classes. Pale, soft, and exudative pork belonging in the fast group had the greatest (P < 0.05) percentage of type IIb fibers, and RSE (reddish-pink, soft, and exudative) pork belonging in the fast group had a similar tendency. Additionally, RFN (reddish-pink, firm, and nonexudative) pork belonging in the normal group showed a lower (P < 0.05) percentage of type IIb fibers than PSE or RSE, regardless of MR, and DFD pork had the lowest (P < 0.05) percentage of type IIb fibers. In general, the fast-glycolyzing PSE pork with the lowest pH at both 45 min and 24 h had greater percentages of type IIb fibers than the fast-glycolyzing RFN pork. There were more fiber-type composition differences between quality classes in pork undergoing a fast rate of metabolism compared with pork undergoing a normal rate of metabolism. It can be concluded that muscle histochemical characteristics are associated with early postmortem MR, the extent of glycolysis, and, thereby, pork quality; however, these effects are limited to the pigs exhibiting a fast glycolytic rate.     

Effects of chromium propionate on growth, carcass traits, and pork quality of growing-finishing pigs

An experiment was conducted to determine the effect of dietary Cr propionate (CrProp) on growth, carcass traits, and pork quality of crossbred finishing gilts. Dietary treatments were 0 or 200 ppb Cr (as CrProp; as-fed basis), and each treatment was replicated four times with five gilts per replicate pen. Gilts were fed diets containing 0.82% lysine from 73 to 80 kg BW and 0.64% lysine from 80 to 115 kg BW. At the end of the trial, carcass and pork quality data were collected from four gilts per replicate. Average daily gain, ADFI, and G:F were not affected (P = 0.76 to 0.96) by CrProp. Before delivery at the abattoir, shrink loss was determined after an 18-h fast (fasting shrink) and after hauling (shipping shrink) pigs for 2.66 h (209.2 km). Fasting, shipping, and overall shrink were not affected (P = 0.14 to 0.39) by CrProp. Carcass length was increased (P = 0.03) in pigs fed CrProp. Loin muscle area, 10th-rib backfat thickness, average backfat thickness, dressing percent, muscle score, fat-free lean, and percent lean were not affected (P = 0.18 to 0.95) by CrProp. Twenty-four-hour loin pH was increased (P = 0.10) in pigs fed CrProp, but 45-min loin and ham pH and 24-h ham pH were not affected (P = 0.39 to 0.83) by CrProp. Subjective (color, marbling, firmness, and wetness) and objective (Commission Internationale de l'Eclairage L*, a*, b*) assessments of the loin muscle (at the 10th-rib interface) were not affected (P = 0.62 to 0.99) by CrProp. Forty-eight-hour drip (P = 0.10) and 21-d purge loss (P = 0.01) were decreased in pigs fed CrProp, but cook and total loss (drip + cook loss) and shear force were not affected (P = 0.35 to 0.53) by CrProp. Plasma cortisol, glucose, and lactate concentrations were not affected (P = 0.28 to 0.97) by CrProp after transportation or during exsanguination. These data indicate that CrProp may improve some aspects of pork quality (loin pH, drip and purge loss) but not growth performance or carcass traits.     

Growth performance, carcass composition, quality, and enhancement treatment of fresh pork identified through deoxyribonucleic acid marker-assisted selection for the Rendement Napole gene

Progeny (n = 70) from unrelated, DNA tested, Rendement Napole carrier (RN-/rn+) Hampshire sires, and DNA tested, Rendement Napole normal (rn+/rn+) Yorkshire dams were genotyped for the segregating RN- allele via DNA marker-assisted methodology. Six slaughter groups ensued, with littermates all being represented within the same slaughter group. Boneless pork loins were removed from right carcass sides after a 48-h chill at 2 degrees C. The anterior portions of the loins were not enhanced, whereas the posterior sections were enhanced with a solution containing 0.5% sodium chloride and 0.5% sodium tripolyphosphate to 110% of their initial weight. Carcasses of carrier pigs had less (P < 0.05) 10th rib fat depth and a greater (P < 0.01) percentage carcass lean than carcasses of normal pigs. Postmortem LM pH of carrier pigs was lower (P < 0.002) at 3, 6, 12, and 24 h, and tended to be lower (P = 0.062) at 48 h compared with that of normal animals. Samples of LM from carrier pigs had greater (P < 0.01) glycolytic potential values, drip loss percentages, and a* values, and lower pH values at fabrication than LM from normal pigs. No genotype differences (P > 0.05) were found for LM lactate, L*, or b* values. Nonenhanced semimembranosus samples from carrier pigs exhibited greater (P < 0.05) purge loss percentages and L* values, and lower (P < 0.01) pH values than samples from normal pigs. Enhanced LM samples exhibited greater (P < 0.05) drip and purge loss percentages, greater pH, and lower L* values at fabrication, regardless of Napole status. These findings suggest that the Napole gene has a positive influence on carcass leanness but detrimental effects for lean quality, which were often further compounded when meat was subjected to enhancement treatment.     

Effect of lairage time,behaviour and gender on stress and meat quality parameters in pigs

The objective of this study was to determine the effects of lairage time (short vs. long), behavior (aggressive vs. non‐aggressive) and gender (gilts, barrows and boars) on stress and meat quality parameters in pigs (n = 100). In the group with short lairage, aggressive behavior of gilts and boars was observed. At exsanguination, blood samples were collected and levels of blood lactate and plasma cortisol were determined. Post mortem pH value, temperature, drip loss, sensory and instrumental color and meat quality class were determined on the muscle Longissimus dorsi. Higher blood lactate concentration (P < 0.05) and skin blemish score (P <0.001), lower temperature (P < 0.05) and drip loss (P < 0.01), as well as darker, less red and yellow meat color (P < 0.001) were found after long lairage compared to short lairage. Gilts had higher plasma cortisol concentrations than barrows (P < 0.05), while barrows had lower skin blemish scores (P < 0.05) than gilts and boars after long lairage. The highest incidence of PSE (pale, soft and exudative) meat was observed in barrows (100.00%) and boars (91.67%) after short lairage, while the lowest incidence of PSE meat was found in barrows (28.89%) after long lairage. Aggressiveness affected meat temperature, as aggressive pigs had higher meat temperature (P < 0.05) than non‐aggressive pigs.     

Muscle characteristics and meat quality traits are affected by divergent selection on residual feed intake in pigs

Residual feed intake (RFI) is defined as the difference between the observed feed intake and that expected based on requirements for maintenance and production. A divergent selection was conducted during 4 generations in Large White male pigs to produce low and high RFI lines. The present study aims at determining the influence of this selection on biochemical and histological traits of skeletal muscle, and relating these changes to correlated effects on growth, carcass composition, and meat quality traits. At 8 d preslaughter, biopsies from the LM were taken in the fed state on 14 females from each RFI line fed ad libitum. Animals were slaughtered at 107.8 ± 8.0 kg of BW without any previous fasting. Samples of LM, semimembranosus (SM), biceps femoris (BFM), and rhomboideus muscles were taken at both 30 min and 24 h postmortem. Myofiber typing was only assessed in LM. Low RFI pigs ("efficient") had leaner carcasses with greater muscle content (P < 0.001), less backfat thickness (P < 0.001), and less intramuscular fat content in all 4 muscles (P < 0.01 to P = 0.04). Their greater muscle content was associated with hypertrophy of all fast-twitch fibers. Glycogen content in all glycolytic muscles (i.e., LM, SM and BFM), was greater in low than high RFI pigs. The greater accumulation of glycogen in LM of low RFI pigs was specifically located in the fast-twitch glycolytic IIBW fibers, which correspond to fibers containing IIb, IIb + IIx, or IIx myosin heavy chains. The difference in muscle glycogen content between RFI line pigs was more significant in the living animals (P = 0.0003) than at 30 min postmortem (P = 0.08). This was associated with a decreased ultimate pH (P = 0.001), and greater lightness of color (P = 0.002) and drip loss (P = 0.04) in LM of low than high RFI line pigs, suggesting that selection for reduced RFI may impair some meat quality traits, such as water-holding capacity. Pigs from the low RFI line exhibited a greater (P = 0.02) percentage of IIBW fibers in LM and tended (P < 0.10) to have less lipid β-oxidative capacity in LM, SM, and BFM. In contrast, no difference (P > 0.10) between lines was found for citrate synthase and lactate dehydrogenase activities, mitochondrial activity, and expression of genes coding for uncoupling proteins 2 and 3. Differences between RFI pigs in plasma leptin, cortisol, and thyroid hormone concentrations are presented and discussed. In conclusion, selection for low RFI influenced muscle properties in a way favoring muscle mass, but likely impairing meat quality.     

Chilling rate effects on pork loin tenderness in commercial processing plants

The present experiment was conducted to provide a large-scale objective comparison of pork LM tenderness and other meat quality traits among packing plants that differ in stunning method and carcass chilling rate. For each of 2 replicates, pigs were sourced from a single barn of a commercial finishing operation that fed pigs from a single terminal crossbred line. On each day, 3 trucks were loaded, with each of those trucks delivering the pigs to a different plant. Plant A used CO(2) stunning and conventional spray chilling; Plant B used CO(2) stunning and blast chilling; and Plant C used electrical stunning and blast chilling. The boneless, vacuum-packaged loin was obtained from the left side of each carcass (n = 597; 100 · plant(-1) · replicate(-1)). As designed, HCW, LM depth, and LM intramuscular fat percentage did not differ among plants (P > 0.05). By 1.67 h postmortem (1 h after the carcasses exited the harvest floor), the average deep LM temperature was >10°C warmer for Plant A than Plants B and C (32.1°C, 21.6°C, and 19.3°C, for Plants A, B, and C, respectively) and deep LM temperature continued to be >10°C warmer for Plant A until 4.17 h or 6.33 h postmortem than for Plants C and B, respectively. Both plants that used blast chilling produced loins with greater LM slice shear force at 15 d postmortem than did the plant that used conventional spray chilling (P < 0.0001). The frequency of loins with excessively high (>25 kg) LM slice shear force values was greater for Plant B than Plant A (14.7% vs. 1%; P < 0.01). Among all the traits studied, including visual and instrumental evaluations of LM color, ultimate pH, marbling score, and lean color stability, the only other difference between Plants A and B was that purge loss during 13 d (from d 1 to 14) of vacuum-packaged storage was greater for Plant B (P < 0.05). That is, with this sample of pigs and CO(2) stunning, no loin quality advantages were detected for blast chilling. Regardless of chilling method, CO(2) stunning resulted in darker LM lean color and greater LM water-holding capacity than did electrical stunning (P < 0.05). This research shows that differences in chilling systems among pork packing plants can have a strong influence on loin chop tenderness.     

Effects of trailer design on animal welfare parameters and carcass and meat quality of three Pietrain crosses being transported over a long distance

This study aimed at evaluating the effects of trailer design on stress responses and meat quality traits of 3 different pig crosses: 50% Pietrain breeding with halothane (HAL)(Nn) (50Nn); 50% Pietrain breeding with HAL(NN) (50NN); and 25% Pietrain breeding with HAL(NN) genotype (25NN). Over a 6-wk period, pigs (120 pigs/crossbreed) were transported for 7 h in either a pot-belly (PB) or flat-deck (FD) trailer (10 pigs/crossbreed(-1.)trailer(-1.)wk(-1)). Temperature (T) and relative humidity (RH) were monitored in each trailer. Behaviors during loading and unloading, time to load and unload, and latency to rest in lairage were recorded, whereas a sub-population of pigs (4 pigs/crossbreed(-1.)trailer(-1.)wk(-1)) was equipped with gastro-intestinal tract (GIT) temperature monitors. Blood samples were collected at exsanguination for measurement of cortisol, creatine kinase (CK), lactate, haptoglobin, and Pig-MAP concentrations. Meat quality data were collected at 24 h postmortem from the LM and semimembranosus (SM) and adductor (AD) muscles of all 360 pigs. Greater T were recorded in the PB trailer during transportation (P = 0.006) and unloading (P < 0.001). Delta GIT temperature was greater (P = 0.01) in pigs unloaded from the PB. At loading, pigs tended to move backwards more (P = 0.06) when loaded on the FD than the PB trailer. At unloading, an interaction was found between trailer type and crossbreed type, with a greater (P < 0.01) frequency of overlaps in 50NN and 25NN pigs and slips/falls in 50Nn and 50NN pigs from the FD than the PB trailer. Cortisol concentrations at slaughter were greater (P = 0.02) in pigs transported in the PB than FD trailer. Greater lactate concentrations were found in 50Nn and 50NN pigs (P = 0.003) and greater CK concentrations (P < 0.001) in 50Nn pigs. As expected, 50Nn pigs produced leaner (P < 0.001) carcasses, with greater (P = 0.01) dressing percentages, as well as lower (P < 0.001) ultimate pH values and greater (P < 0.001) drip loss percentages in the LM and greater (P = 0.002) drip losses and a paler color (greater L* values, P = 0.02) in the SM than 50NN pigs. When used for long distance transportation under controlled conditions, the PB trailer produced no detrimental effects on animal welfare or pork quality. Pigs with 50% Pietrain crossbreeding appear to be more responsive to transport stress, having the potential to produce acceptable carcass and pork quality, provided pigs are free of the HAL gene.     

Glycolytic potential of red, soft, exudative pork longissimus muscle

Red, soft, exudative (RSE) pork is red as "normal" pork and exudative as PSE pork. The origin of RSE quality is unknown. In the present study, we determined whether the occurrence of RSE pork is related to the presence of the RN (Rendement Napole) gene. A glycolytic potential [= 2 x (glucose + glycogen + glucose-6-phosphate) + lactate] of > 180 micromol lactate/g of meat was used as indicator for presence of the RN gene. At 1 d postmortem, pork loin samples were collected at a commercial slaughter plant, and meat quality characteristics and glycolytic potential were determined. Glycolytic potential of RSE pork (n = 42) was higher (P < .01) than that of RFN (red, firm, nonexudative) pork (n = 25): 137 vs 110 micromol lactate/g of muscle. The glycolytic potential of PSE pork (n = 28) was 161 micromol lactate/g of muscle, which was higher (P < .01) than the glycolytic potential of RFN or RSE pork. Using a glycolytic potential of 180 micromol lactate/g of muscle as suggestive for the presence of the RN gene, four (10%) of the RSE samples were from RN carriers. By the same criterion, the PSE group contained nine (32%) RN gene carriers. These results suggest that the occurrence of RSE quality is not related to the presence of the RN gene.     

Comparison of the effects of different transport conditions and lairage times in a Mediterranean climate in South Africa on the meat quality of commercially crossbred Large white x Landrace pigs

Information on the effect of road transportation conditions and lairage times on the meat quality of pork under South African conditions is very sparse. In this investigation, the effects of 2 road conditions (rough road with frequent stops - A; smooth road, few stops - B) and 2 lairage holding periods (2 h and 24 h) on the physical meat quality attributes of commercially produced pigs during summer (ambient temperatures > 30 degrees C) in the Western Cape (South Africa) were investigated. Pig meat from pigs transported on a road that caused more stress (A), had lower pH 45 (measured 45 min post mortem) values after 2 h lairage than pigs transported over a smoother road. Pigs B had a lower muscle pH 24 (measured 24 h post mortem) than group A, indicating that they had more glycogen reserves available for post mortem glycolysis. Road conditions A were more stressful resulting in a higher incidence of PSE pork, as shown by the percentage drip loss and the L* values. When the lairage period was increased to 24 h prior to slaughter, pigs transported under road conditions A had time to replenish their energy reserves and the pH 45, drip loss and L* values were within an acceptable range. However, pigs transported under road conditions B had lower pH 45 and higher pH 24 values, indicating that the lairage period was too long and that energy reserves were depleted in order to adapt to the stressful conditions. Results from this investigation indicate that improvement of the transport/road conditions will result in better pork quality.