The effect of different slaughter methods on the post mortem glycolysis of muscle in lambs

Differences in muscular activity and rates of decline in the pH of the M. longissimus dorsi of lambs subjected to different methods of stunning and slaughter were observed. Lambs electrically stunned by a head-to-leg method had significantly lower initial pH values as compared to animals stunned by an electrical head-only method, or by captive bolt, or without any form of stunning prior to slaughter. When electrical stunning by a head-to-leg method was combined with low voltage (24 V) electrical stimulation during slaughter and bleeding, mean pH values declined at the highest rate and fell to approximately 6.0 within two hours of slaughter. This last procedure, therefore, has the potential to greatly reduce times between slaughter and freezing without increasing the risk of cold shortening and the associated toughness of meat.     

The effect of different slaughter methods on the post mortem glycolysis of muscle in lambs

Differences in muscular activity and rates of decline in the pH of the M. longissimus dorsi of lambs subjected to different methods of stunning and slaughter were observed. Lambs electrically stunned by a “head-to-leg” method had significantly lower initial pH values as compared to animals stunned by an electrical “head-only” method, or by captive bolt, or without any form of stunning prior to slaughter. When electrical stunning by a “head-to-leg” method was combined with low voltage (24V) electrical stimulation during slaughter and bleeding, mean pH values declined at the highest rate and fell to approximately 6.0 within two hours of slaughter. This last procedure, therefore, has the potential to greatly reduce times between slaughter and freezing without increasing the risk of cold shortening and the associated toughness of meat.     

Electrical stunning of red deer (Cervus elaphus)

Eighteen of 23 red deer (Cervus elaphus) at a deer slaughtering premises were successfully stunned with an apparatus modified from that normally used to stun sheep. The five unsuccessful electrical stuns were associated with poor head restraint and poor head contact by the electrodes. The median stunning current was 0.9 A, and in the majority of cases the duration of stunning was less than 1 second. The signs of the electrically induced epileptiform seizures in the deer were dissimilar to those seen in sheep, cattle and pigs, in that the initial tonic phase was less marked, and of shorter duration. A similar shorter and less obvious tonic phase was noted in four deer shot with a captive bolt pistol. Two animals which were electrically stunned, and bled within 10 seconds, showed no signs of recovery while bleeding. The electroencephalograms of four deer stunned with currents of 1.3 A for a duration of either 0.5 or 1.0 seconds were recorded under more controlled conditions. All four animals developed electroencephalograms typical of an epileptiform seizure. The animals exhibited behavioural reactions similar to the other 18 animals in the trial at the deer slaughtering premises and were rendered unconscious for between 54 and 122 seconds. The electroencephalogram activity amplitude was greater than that recorded immediately before stunning and took between 6 and 9 seconds to build up to maximum value. It is concluded that, providing the heads of deer are adequately restrained, head-only electrical stunning can be incorporated into a humane method of slaughter for deer.     

Cortical function in cattle during slaughter: conventional captive bolt stunning followed by exsanguination compared with shechita slaughter

Brain function was examined in adult cattle after conventional captive bolt stunning or shechita slaughter, using eight animals in each treatment. The times to loss of evoked responses (visual and somatosensory) and spontaneous activity in the electro-corticogram were used to determine the onset of brain failure. Captive bolt stunning followed by sticking one minute later resulted in immediate and irreversible loss of evoked responses after the stun. Spontaneous cortical activity was lost before sticking in three animals, and in an average of 10 seconds after sticking in the remaining five animals. The duration of brain function after shechita was very variable, and particularly contrasted with captive bolt stunning with respect to the effects on evoked responses. These were lost between 20 and 126 seconds (means of 77 seconds for somatosensory and 55 seconds for visual evoked responses) and spontaneous activity was lost between 19 and 113 seconds (mean 75 seconds) after slaughter.     

Head-only followed by cardiac arrest electrical stunning is an effective alternative to head-only electrical stunning in pigs

Many small slaughter facilities use head-only electrical stunning to render swine unconscious and insensible to pain before slaughter. Head-only electrical stunning is a reversible procedure that is optimally effective for approximately 15 s after stun completion. In many small North American slaughter plants, the authors have observed hoist speeds that are too slow to achieve a short enough stun-to-bleed interval to maintain insensibility through exsanguination. Unlike many European plants, there is no separate high-speed hoist for pigs and exsanguination on the floor is not condoned. As a result, a 2-stage stunning method was proposed where head-only stunning for 3 s was immediately followed by application of the same stunning wand to the cardiac region of the animal for 3 s while lying in lateral recumbancy. A paired-comparison study was conducted on 89 pigs in a small slaughter facility to compare the head-only method applied for 6 s with the head/heart method. The objective was to evaluate signs of return to sensibility, stun-to-bleed time, blood lactate concentration, muscle pH, drip loss, and fresh meat color to validate the head/heart electrical stunning method for small slaughter plants. Incidence of corneal reflex was not different (P > 0.05) between head/heart (93.8%) and head only (85%) stunning. Nose twitching was more common (P < 0.05) in head only (26.5%) than head/heart (5%) stunning. Head/heart stunning eliminated rhythmic breathing, natural blinking, eye tracking to moving objects, and righting reflex, which were all observed in head-only stunned pigs. Eye tracking to moving objects was observed in 40.8% of head-only stunned pigs. Blood lactate was not different (P > 0.05) between stunning methods (head only: 8.8 ± 0.7 mmol/L, head/heart: 7.8 ± 0.7 mmol/L). Stun-to-bleed time did not differ (P > 0.05; head only: 32 ± 1 s, head/heart: 33 ± 1 s). Mean time to loss of heartbeat with the head-only method was 121 ± 5 s. No heartbeat was observed with the head/heart method. Longissimus thoracis pH, color, and drip loss were not different (P > 0.05) between stunning methods. This study determined that the head/heart electrical stunning method reduces the incidence of signs of return to sensibility without significant effects on meat quality, plant operation speed, or blood lactate concentration. In addition, the head/heart method requires no capital investment for plants that are currently using the head-only method.     

Cattle stunning with a penetrative captive bolt device: A review

The captive bolt device has been used for stunning cattle at abattoirs for more than 100 years and is now one of the stunning devices used most widely. The aim of this review article was to assess the effects that are decisive during cattle slaughter on the quality of stunning with the use of a captive bolt stunning device. The basis of effective stunning is the use of a suitable type of device, with the speed of the bolt and the kinetic energy corresponding to the anatomical parameters of the slaughtered animal. The importance of the regular cleaning and maintenance of stunning devices and monitoring of the effectiveness of stunning goes without saying. The immediate loss of sensibility in the animal must occur after the first shot. The effectiveness of the stunning process can be quantified by regular monitoring of the behavior of animals after stunning with an emphasis on the loss of reflexes (corneal reflex, regular breathing, attempts to regain physiological posture) and checks on the shot location on the skulls of slaughtered animals.     

The use of electrical stunning followed by electro-immobilization for the humane slaughter of cattle

Sir;- In New Zealand, calves are often electrically stunned before slaughter. However, electrical stunning is not usually used for adult cattle, primarily because the large size of the adult animal makes restraint more difficult, resulting in less reproducible stunning, with potential danger to personnel from animal movement. In addition, the slaughter of cattle may be inhumane if the stunning process does not ensure immediate and permanent insensibility (Newhook and Blackmore 1982b). The use and humaneness of electrical stunning of sheep and cattle have been the subject of our recent research, in which we have addressed and resolved many of these problems. We wish to relate our observations in the context of head-only electrical stunning of cattle followed by electro-immobilization to maintain insensibility and ensure carcass stillness.     

Onset of insensibility at slaughter in calves: effects of electroplectic seizure and exsanguination on spontaneous electrocortical activity and indices of cerebral metabolism.

Cerebral venous and femoral arterial blood samples were collected from 21 young calves either during electrical stunning and recovery or electrical stunning and slaughter by carotid severance or slaughter without stunning. The blood samples were analysed for PO2, PCO2, pH, glucose and lactate. The results were compared with simultaneous recordings of spontaneous electrocortical (ECOG) activity. Calves subjected to head-only electrical stunning and slaughter became permanently insensible at the time of the stun. The six calves slaughtered without stunning lost sensibility within 10 seconds. One calf, in which a clot formed in the carotid arteries inhibiting bleeding, maintained some evidence of cortical activity beyond 52 seconds; this was high amplitude low frequency activity and analysis by Fast Fourier Transform showed sensibility was not regained. In the remaining calves the ECOG activity was lost on average within 49 +/- 3.5 (SEM) seconds after slaughter. The cerebral extraction of metabolites increased after carotid severance, indicating inadequacy of cerebral bloodflow after slaughter. No correlations were found between indices of cerebral metabolism and the time of loss of cortical function.     

Measures preventing BSE-contamination during the slaughter of cattle

SRM-regulations and the prohibition of pithing have removed major risks of spreading BSE-infection. Traditional slaughter technology, especially captive bolt stunning, head handling and carcass splitting nevertheless still provide non-negligible risks for contamination with the BSE-agent if present in cattle, and should therefore be replaced by safer techniques. However, alternative methods like electrical stunning or removal of the spinal cord prior to splitting the carcass cannot yet be considered a reliable and practical option. Surface contamination could be prevented altogether by abandoning the practice of carcass splitting and by removing the vertebral column while still connected to the head, although this would result in disadvantages for post mortem inspection.     

Return-to-sensibility problems after penetrating captive bolt stunning of cattle in commercial beef slaughter plants

OBJECTIVE: To evaluate efficacy of penetrating captive bolt stunning of cattle in commercial beef slaughter plants and identify potential causes of a return to sensibility among stunned cattle. DESIGN: Observational study. SAMPLE POPULATION: 21 federally inspected commercial beef slaughter plants. PROCEDURE: In each plant, stunning of at least 100 cattle (19 large plants) or a minimum of 1 hour of production (2 small plants) was observed, and cattle were evaluated for signs of returning to sensibility on the bleed rail. Cattle with a limp, flaccid head, a lack of spontaneous blinking, and an absence of a righting reflex were considered insensible. RESULTS: In 17 of the 21 (81%) plants, all cattle were rendered insensible before they were hoisted onto the bleed rail. The remaining 4 plants had cattle that had signs of returning to sensibility; these cattle were restunned prior to skinning or leg removal. Of 1,826 fed steers and heifers, 3 (0.16%) had signs of returning to sensibility, whereas 8 of 692 (1.2%) bulls and cows did. Return-to-sensibility problems were attributed to storage of stunner cartridges in damp locations, poor maintenance of firing pins, inexperience of the stunner operator (ie, shooting cattle too high on the forehead), misfiring of the stunner because of a dirty trigger, and stunning of cattle with thick, heavy skulls. CONCLUSIONS AND CLINICAL RELEVANCE: Results suggest that efficiency of captive bolt stunning of cattle in commercial slaughter plants can be safely and objectively assessed. Care should be taken to maintain stunners correctly, particularly when stunning bulls and cows with heavy skulls.     

Neuropathological changes produced by non-penetrating percussive captive bolt stunning of cattle

A blunt, non-missile head injury inflicted by a non-penetrating captive bolt pistol in cattle at slaughter resulted in immediate loss of consciousness, a depressed fracture of the frontal bone and widespread subarachnoid haemorrhage, particularly beneath the impact site, in the temporal and frontal lobes, and around the brainstem. There was also invariably petechial haemorrhage in the basal ganglia and thalamus. The large concussive force applied to the cranium by the stunner was probably responsible for rendering the animal insensible and the vascular damage produced by this force and the sudden ventrocaudal acceleration of the brain after impact. These findings supported the use of this mode of stunning, followed by exsanguination, as an acceptable form of slaughter of cattle in abattoirs.     

Neuropathological changes produced by non-penetrating percussive captive bolt stunning of cattle

A blunt, non-missile head injury inflicted by a non-penetrating captive bolt pistol in cattle at slaughter resulted in immediate loss of consciousness, a depressed fracture of the frontal bone and widespread subarachnoid haemorrhage, particularly beneath the impact site, in the temporal and frontal lobes, and around the brainstem. There was also invariably petechial haemorrhage in the basal ganglia and thalamus. The large concussive force applied to the cranium by the stunner was probably responsible for rendering the animal insensible and the vascular damage produced by this force and the sudden ventrocaudal acceleration of the brain after impact. These findings supported the use of this mode of stunning, followed by exsanguination, as an acceptable form of slaughter of cattle in abattoirs.     

BSE--consequences for slaughtering,cutting and employer's protection

The conventional slaughtering of cattle includes some critical process stages where a carry over of BSE-risk material (brain, spinal cord) on the meat can occur. These processes are captive bolt stunning, cut off the head and first of all sawing the spine lengthways. Alternative stunning methods like electrical stunning or concussion stunning are under investigation, nevertheless they are in the moment no useful alternatives for most of the slaughter houses. The most promising methods available at present for minimising the risk appear to be in manual cattle slaughtering boning the entire carcass, either still warm or refrigerated and in industrial beef cattle slaughtering extraction of the spinal cord by vacuum from the whole carcass followed by conventional sawing or completely sawing out the spine including spinal ganglia. Working processes, including the cutting or exposure of risk material, are a risk for the employer's too. Special protective measures must be taken.     

Survey of the effectiveness of stunning procedures used in Spanish pig abattoirs

Two pig abattoirs (A and B) equipped with an automated head-only and head-to-chest electrical stunning system, and two (C and D) equipped with a manual carbon dioxide stunning system, were evaluated to compare the effectiveness of stunning in a total of 10,454 pigs slaughtered under commercial conditions. In the abattoirs with the electrical stunning system, the percentage of animals that responded to a nose prick was significantly lower (P<0.05) in abattoir B, where a higher current intensity was used (P<0.05), than in abattoir A. No righting reflex was observed in the electrically stunned pigs. In the abattoirs with the carbon dioxide stunning system, the percentage of animals that responded to a nose prick and showed a righting reflex was significantly lower (P<0.05) in abattoir C, where the duration of the carbon dioxide cycle was longer and the interval between discharge from the system to sticking was shorter (P<0.05), than in D. Comparing the electrical and carbon dioxide stunning systems, the pigs stunned with carbon dioxide were significantly more responsive to a nose prick (P<0.05) and 25 per cent of them showed a righting reflex. Under the conditions of the study the fully automated head-only stunning with additional chest electrodes appeared to be more effective and less susceptible to incorrect handling than the manual carbon dioxide stunning system.     

Insensibility during slaughter of pigs in comparison to other domestic stock

The onset of insensibility during slaughter was studied in five, 31-day-old pigs. The state of sensibility was determined from the study of electroencephalograms (EEC) which were of a bipolar transhemispheric derivation. In 3 pigs slaughtered by bilateral severance of both common carotid arteries and jugular veins, it was judged that insensibility occurred within 25 s and there was no resurgence of cerebrocortical activity following subsequent respiratory gasps. The EEGs became isoelectric within 115 s. These results are compared with previous findings by the authors that adult sheep and lambs slaughtered by similar techniques became insensible within 7 s whereas, in calves, the onset of insensibility was delayed for up to 85 s and there were resurgences of cerebrocortical activity, following a respiratory gasp, for more than 300 s. These differences in the apparent onset of insensibility in the 3 species of animal are discussed in relation to the anatomical features and possible dynamics of the blood supply to the brain during slaughter. It is concluded that for humane reasons, head-to-back electrical stunning of pigs is preferable to a head-only method.     

Review of the production of ostrich meat

Ostrich meat was originally considered to be a by-product of the leather industry. Ostrich farming focused on the production of good quality hides and was mainly based on experience. Since a few years there has been a move from hide production to meat production; however, little is known about ostrich meat production which has consequences for legislation. There is insufficient knowledge about the factors influencing muscle growth. The strong growth of ostrich meat production in the EU member states should be discussed because the climatic conditions are not optimal and the price of the meat may remain high compared to meat of broilers, pigs, and cattle. Information programmes have to be set up for all members in the production chain. The present method for stunning of ostriches has to be changed in most slaughterhouses. In this study the effects of electrical and mechanical stunning on unconsciousness, duration of unconsciousness, behaviour, and meat quality parameters were examined. At least 500 mA is needed to stun ostriches effectively, and they can be killed using a short-stick interval or a long stunning duration. A modified captive needle pistol, using air pressure, is an alternative to electrical head-only stunning.     

Assessment of the effectiveness of head only and back-of-the-head electrical stunning of chickens

1. The study assesses the effectiveness of reversible head-only and back-of-the-head electrical stunning of chickens using 130–950 mA per bird at 50 Hz AC.

2. Three trials were conducted to compare both stunning systems: (a) behavioural assessment of return of consciousness, (b) insensibility to thermal pain, and (c) assessment of return of brain activity with visually evoked potentials (VEPs).

3. Assessment of behaviour suggested that the period of unconsciousness following head-only electrical stunning was shorter in hens compared to broilers.

4. Stunning across the back-of-the-head delayed the time to return of brainstem function compared to stunning with standard head-only electrodes. Additionally, back-of-the-head stunning produced a more prolonged period of electroanalgesia compared to head-only.

5. Based on examination of return of brain function with VEPs in hens, back-of-the-head stunning produced a shorter-lasting stun than standard head-only. However, even for standard head-only, the stun was notably shorter than previously reported. In some birds, brain function had returned within 9 s after the end of stunning.

6. The results suggest that some birds may recover consciousness prior to or during the neck cut. Based on these findings, back-of-the-head stunning and standard head-only stunning of hens should not be recommended without further development.

     

Insensibility during slaughter of pigs in comparison to other domestic stock

The onset of insensibility during slaughter was studied in five, 31-day-old pigs. The state of sensibility was determined from the study of electroencephalograms (EEC) which were of a bipolar transhemispheric derivation. In 3 pigs slaughtered by bilateral severance of both common carotid arteries and jugular veins, it was judged that insensibility occurred within 25s and there was no resurgence of cerebrocortical activity following subsequent respiratory gasps. The EEGs became isoelectric within 115s. These results are compared with previous findings by the authors that adult sheep and lambs slaughtered by similar techniques became insensible within 7s whereas, in calves, the onset of insensibility was delayed for up to 85s and there were resurgences of cerebrocortical activity, following a respiratory gasp, for more than 300s.

These differences in the apparent onset of insensibility in the 3 species of animal are discussed in relation to the anatomical features and possible dynamics of the blood supply to the brain during slaughter.

It is concluded that for humane reasons, “head-to-back” electrical stunning of pigs is preferable to a “head-only” method.     

Electrical stunning of cattle

Cattle are normally stunned electrically by three sequential cycles, first a three-second head-only cycle, to stun the animal, secondly a 15-second cardiac cycle, to induce ventricular fibrillation (cardiac arrest), and thirdly a four-second discharge cycle, to reduce convulsions after death. An effective and immediate stun was produced when > or =1.15 amps sinusoidal AC at 50 Hz was applied between the nose and neck electrodes for less than one second. However, when applied for three seconds, head-only currents of >0.46 amp sinusoidal AC at 50 Hz were sufficient to induce epileptiform activity in the brain, identified as high amplitude low frequency activity in the electroencephalogram. The induction of effective head-only electrical stunning resulted in an average interval of 50 seconds before the return of rhythmic breathing movements, and positive corneal and palpebral reflexes. The cardiac arrest cycle successfully induced ventricular fibrillation when >1.51 amps sinusoidal AC at 50 Hz was applied for five seconds between the nose and brisket electrodes.     

Observations during captive bolt stunning of rabbits]

78 rabbits of mixed breed and about 3 kg live weight were stunned before slaughter with a commercial spring operated captive bolt apparatus designed for rabbits and water fowl. The following reaction patterns were observed: 1.) Immediate onset of tonic spasm, followed by weak to heavy clonic spasms and/or subsequent relaxation; irreversible loss of corneal reflex and cessation of respiration: effective and irreversible stun tantamount to killing 2.) Same reaction as before except that respiration restarted after 1/2 to 2 min: effective but only temporary stun 3.) Similar reaction as before, but respiration maintained: insufficient stun 4.) Immediate onset of weak tonic spasm; respiration and corneal reflex maintained: insufficient stun. According to this classification 56 rabbits (72%) were killed outright and 18 (23%) temporarily stunned while in 4 (5%) the stun was ineffective. The captive bolt apparatus proved thus to be principally suited for the stunning resp. killing of slaughter rabbits. The best stunning results were obtained with shots into the parietal bone near the sagittal line but not hitting the bone sutures. To achieve this the apparatus has to be placed slightly paramedian on the front as close to the ears as possible. Insufficient stunning results could be blamed on deviating shooting positions. To avoid misses a good fixation of the animal including its head is necessary. Correct application provided the use of penetrating concussion stunners should be preferred to applying a blow to the neck for stunning rabbits.