Changes in the sotolon content of dry white wines during barrel and bottle aging

GC-MS in electron ionization mode (EI) was used as a simple, sensitive method for assaying sotolon [4,5-dimethyl-3-hydroxy-2(5) H-furanone] in various dry white wines. The impact of barrel-aging conditions, that is, whether yeast lees were present or not, on the formation of sotolon in dry white wines was then studied. The sotolon content was highest in dry white wines aged in new barrels without lees, often exceeding the perception threshold (8 microg/L). These results demonstrated that yeast lees were capable of minimizing the formation of sotolon in dry white wines during aging. The sotolon and oxygen contents of several bottle of the same white wine were also compared 7 years after bottling. At the range of dissolved oxygen concentrations generally measured, between 5 and 100 microg/L, the sotolon content remained below its perception threshold in wine. The perception threshold was exceeded only in wines with oxygen concentrations above 500 microg/L. The presence of dissolved oxygen in the wine samples analyzed also resulted in a decrease in their free sulfur dioxide content.     

On the role of squalene in olive oil stability.

The role of squalene in olive oil stability was studied for various concentrations and experimental conditions. No effect was found in induction periods of olive oil at elevated temperatures using the Rancimat apparatus. Samples were then stored at 40 and 62 degrees C in the dark, and the extent of oxidation was followed by periodic measurements of peroxide value and conjugated dienes. A concentration dependent moderate antioxidant activity was evidenced which was stronger in the case of olive oil compared to that found for sunflower oil and lard. In the presence of alpha-tocopherol (100 mg/kg) and caffeic acid (10 mg/kg) the contribution of squalene (7000 mg/kg) was not significant. No radical scavenging activity was observed using DPPH(*) in 2-propanol. The weak antioxidant activity of squalene in olive oil may be explained by competitive oxidation of the different lipids present which leads to a reduction of the oxidation rate. Squalene plays a rather confined role in olive oil stability even at low temperatures.     

Formulation of low-cost fermentative media for lactic acid production with Lactobacillus rhamnosus using vinification lees as nutrients

Lees coming from different steps in white wine and red wine vinification were characterized under physicochemical analyses to determine the content in carbon, nitrogen, ashes, solids in suspension, organic compounds, and minerals. Due to the hydrolytic activity of Lactobacillus strains, lees without autolysis treatments were used directly as the unique nutrient or in combination with corn steep liquor to carry out the glucose to lactic acid fermentation with Lactobacillus rhamnosus CECT-288. Time courses of glucose and lactic acid were modeled according to reported models. Using 20 g/L of lees coming from the white wine technology and re-collected after the second decanting step before distillation, as the only nutrient, the values achieved (P = 105.5 g/L, Q(P) = 2.470 g/L.h) were even higher than those obtained with the costly MRS broth (P = 104.3 g/L, Q(P) = 2.251 g/L.h).     

Pear distillates from pear juice concentrate: effect of lees in the aromatic composition

Pear juice obtained from pear concentrate was fermented at room temperature using Saccharomyces cerevisiae (BDX, ENOFERM, France) as the fermentation microorganism. During the fermentation process, total sugars were measured. High performance liquid chromatography analyses were used to monitor the fermentation process and to characterize the pear wine. The pear wine obtained was distilled with its lees using three different equipments: a glass alembic (a glass pot still coupled to a glass column), a copper alembic, and a glass alembic with the addition of 5 g/L of copper shavings to the pot still. The same distillations were repeated with the wine without its lees (separated by decanting). Several distillation fractions were collected, up to a total of 500 mL of distillate. Gas chromatography was used to identify and quantify the volatile compounds in each fraction, and the methanol and ethanol contents. Based on these results, the heart fraction was defined. ANOVA tests were performed on the heart fractions to determine quantitative differences between some volatile compounds depending on the equipment used and the presence or absence of the wine lees. From this series of ANOVA tests, it can be concluded that the concentrations of the compounds that are considered to have a negative effect on the quality of the distillates (methanol, ethyl acetate, furfural) decrease or do not change when they are distilled in the presence of lees and in the copper alembic. In addition, the concentrations of the positive compounds (ethyl decanoate and ethyl-2-trans-4-cis-decadienoate) increase in the presence of lees for all of the equipment tested. So, it can be assumed that the distillation of pear wine with its lees in copper alembic leads to a better quality product.     

Enhanced squalene production by wild-type Saccharomyces cerevisiae strains using safe chemical means

Interest is increasing in establishing renewable sources for squalene, a functional lipid, as the conventional ones are limited. In the present study, squalene production was achieved in a wild-type laboratory Saccharomyces cerevisiae strain by two safe chemical means using terbinafine (0.05-0.55 mM) and methyl jasmonate (MJ) (0-1.00 mM). Bioprocess kinetics optimized by response surface methodology and monitored by high-performance liquid chromatography revealed a clear dependence of growth and squalene content (SQC) and yield (SQY) on the above regulators. Maximum SQC (10.02±0.53 mg/g dry biomass) and SQY (20.70±1.00 mg/L) were achieved using 0.442 mM terbinafine plus 0.044 mM MJ after 28 h and 0.300 mM terbinafine after 30 h, respectively. A 10-fold increase in SQY was achieved in comparison to that in the absence of regulator. The ruggedness of optimum conditions for SQY was verified for five industrial strains. The cellular lipid fraction (～12% of dry biomass) was rich in squalene (12-13%). Results are encouraging toward bioprocess scale up.     

Fate of ochratoxin A during vinification of Semillon and Shiraz grapes

Semillon and Shiraz grapes containing ochratoxin A (OA) were obtained by inoculation of bunches on the vine with Aspergillus carbonarius. Citric acid content was greater in the inoculated grapes than in healthy grapes. Samples were collected throughout vinification of these grapes and the OA content was quantified using a stable isotope dilution liquid chromatographic-tandem mass spectrometric method. The mass of processed and waste streams during vinification was also noted. Reduction in the amount of OA in juice and wine occurred at every solid-liquid separation stage. The OA concentration (microg/kg) in white and red wine after racking was 4% and 9%, respectively, of that in crushed grapes. This corresponds to 1% and 6% of the total OA content that was initially present in the inoculated grapes. The OA content was divided between solid and liquid phases at each stage of vinification. OA did not appear to be transformed either chemically or biologically by yeast during fermentation, rather was discarded with the marc, juice lees, and gross lees.     

Interactions between yeast lees and wine polyphenols during simulation of wine aging. II. Analysis of desorbed polyphenol compounds from yeast lees

In the first part of this work, the analysis of the polyphenolic compounds remaining in the wine after different contact times with yeast lees during simulation of red wine aging was undertaken. To achieve a more precise view of the wine polyphenols adsorbed on lees during red wine aging and to establish a clear balance between adsorbed and remnant polyphenol compounds, the specific analysis of the chemical composition of the adsorbed polyphenolic compounds (condensed tannins and anthocyanins) after their partial desorbtion from yeast lees by denaturation treatments was realized in the second part of the study. The total recovery of polyphenol compounds from yeast lees was not complete, since a rather important part of the initial wine colored polyphenols, especially those with a dominant blue color component, remained strongly adsorbed on yeast lees, as monitored by color tristimulus and reflectance spectra measurements. All anthocyanins were recovered at a rather high percentage (about 62%), and it was demonstrated that they were not adsorbed in relation with their sole polarity. Very few monomeric phenolic compounds were extracted from yeast lees. With the use of drastic denaturing treatments, the total recovery of condensed tannins reached 83%. Such tannins extracted from yeast lees exhibited very high polymeric size and a rather high percentage of galloylated residues by comparison with initial wine tannins, indicating that nonpolar tannins were preferentially desorbed from yeast lees by the extraction treatments.     

Production in large quantities of highly purified hydroxytyrosol from liquid-solid waste of two-phase olive oil processing or "Alperujo"

The effect of hydrothermal treatment of two-phase olive waste (alperujo) on the solubilization of hydroxytyrosol was studied. Different conditions of saturated steam were assayed. A high amount of hydroxytyrosol was solubilized and increased with increasing steaming temperature and time, reaching 1.4-1.7 g/100 g of dry alperujo. The effect of acidic (H(2)SO(4)) and basic (NaOH) catalysts was also evaluated. Acid-catalyzed treatment was more effective at milder conditions, whereas the alkali-catalyzed conditions were not very suitable. In the present study, the extracted hydroxytyrosol was purified by means of a new, simple, and inexpensive chromatographic system, under international patent application (PCT/ES02/00058). From 1000 kg of alperujo, with 70% humidity, can be obtained approximately 4.5-5 kg of hydroxytyrosol. After a purification process, at least 3 kg of hydroxytyrosol, at 90-95% purity, would be obtained. The purified compound was identified by HPLC/UV and (1)H and (13)C NMR analyses, and its antioxidant activity was tested on refined olive oil without antioxidants by Rancimat method. The oxidative stability of refined olive oil was increased by a factor of 1.71 in the presence of 100 ppm of hydroxytyrosol.     

Fate of quinoxyfen residues in grapes, wine, and their processing products

Quinoxyfen is a new fungicide that belongs to the family of the quinolines, recently introduced to control powdery mildew (Uncinula necator). In this paper the fate of quinoxyfen residues from vine to wine and in their processing products was studied. After the last of four applications at the recommended rate, 0.38 mg/kg of residue was found on the grapes, which is under the legal limit fixed in Italy (0.5 mg/kg). The degradation rate was according to a pseudo-first-order kinetics (r = 0.964) and the half-life was 7.24 days. Vinification was carried out with and without maceration. During the vinifications without maceration <50% of the residues passed from the grapes to the musts. Separation of the lees (8%) from the must by centrifugation caused no detectable residues in centrifuged must. At the end of fermentation with and without maceration no quinoxyfen residues were determinable in the wine. No effect on the alcoholic or malolactic fermentation was observed even in the presence of higher quinoxyfen concentrations than those found in the grapes at harvest time. During fermentation, the yeasts partially degraded the pesticides and completly adsorbed them. Bacteria, on the other hand, do not have any degradative effect on the pesticides. The raisins obtained by sun-drying did not contain any residues, whereas those obtained by oven-drying show the same amount of residues as in the fresh grapes. During the sun-drying process the fruit weight decreased by a factor of 4; the decrease in the oven-drying was equivalent. Samples of dregs and liquid lees, fortified with high levels of quinoxyfen. were double-distilled. The first dregs distillate, with an alcohol content of 32.1%, did not show any residues, whereas the first lees distillate, with an alcohol content of 34.5%, showed 7% of the initial residues. After the second lees distillation, the obtained product showed an alcoholic content of 81.2% and no residues of quinoxyfen (<0.01 mg/kg).     

Influence of wine turbidity on the accumulation of volatile compounds from the oak barrel

In this work the influence of the turbidity of a red wine aged in oak barrels on the accumulation of volatile compounds has been studied. From the results obtained, it may be concluded that the wine turbidity had an effect on the concentration of many of the oak volatile compounds, especially furanic and phenolic compounds. In all cases the concentrations of furanic aldehydes and vanillin were significantly higher (p < 0.01) in the filtered wine than in the unfiltered wine. However, in the unfiltered wine the concentrations of gamma-butyrolactone and eugenol were higher. This difference in the concentrations would be due to the different compositions of the wines and the binding of compounds to some components of the lees. Likewise, it has been observed that the composition of the lees is fundamental in the binding of volatile compounds to the lees as the fermentative lees behave differently from the lees from the wine aging in barrels.     

Impact of oxygen consumption by yeast lees on the autolysis phenomenon during simulation of wine aging on lees

Potential oxygen consumption by lees, more precisely by nonviable yeasts, during wine aging was recently described. Additionally, yeast autolysis is described as the main mechanism of degradation of lees during wine aging. Thus, to understand the effect of oxygen consumption by yeast lees during wine aging, an accelerated wine aging methodology was tested. Wine aging in the presence of yeast lees was studied both in the presence and in the absence of oxygen. Different markers of yeast autolysis were followed to find a relationship between oxygen consumption by yeast lees and changes in the final wine composition after aging. No differences for compounds tested were found in the wine and in the lees except among sterol compounds in lees: in the presence of oxygen, the concentration of ergosterol in lees was significantly lower than that in the absence of oxygen. It was hypothesized that ergosterol could be oxidized under the influence of oxygen, but none of the known products of ergosterol oxidation were recovered in the corresponding yeast lees. In addition, the decrease of ergosterol content in yeast lees cannot account for the total amount of oxygen consumed by yeast lees during such wine aging.     

Interactions between yeast lees and wine polyphenols during simulation of wine aging: I. Analysis of remnant polyphenolic compounds in the resulting wines

Wine aging on yeast lees is a traditional enological practice used during the manufacture of wines. This technique has increased in popularity in recent years for the aging of red wines. Although wine polyphenols interact with yeast lees to a limited extent, such interactions have a large effect on the reactivity toward oxygen of wine polyphenolic compounds and yeast lees. Various domains of the yeast cell wall are protected by wine polyphenols from the action of extracellular hydrolytic enzymatic activities. Polysaccharides released during autolysis are thought to exert a significant effect on the sensory qualities of wine. We studied the chemical composition of polyphenolic compounds remaining in solution or adsorbed on yeast lees after various contact times during the simulation of wine aging. The analysis of the remnant polyphenols in the wine indicated that wine polyphenols adsorption on yeast lees follows biphasic kinetics. An initial and rapid fixation is followed by a slow, constant, and saturating fixation that reaches its maximum after about 1 week. Only very few monomeric phenolic compounds remained adsorbed on yeast lees, and no preferential adsorption of low or high polymeric size tannins occurred. The remnant condensed tannins in the wine contained fewer epigallocatechin units than the initial tannins, indicating that polar condensed tannins were preferentially adsorbed on yeast lees. Conversely, the efficiency of anthocyanin adsorption on yeast lees was unrelated to its polarity.     

Compost Production from Olive Tree Pruning Wastes Enriched with Phosphate Rock

Olive production is increasing very fast in the last 20 years in Al-Jouf region, northern region of the Kingdom of Saudi Arabia. There are now more than 5 million olive trees in the productive stage. A huge amount of waste is produced annually from this sector, including pruning waste of olive trees and solid waste from olive oil mills of three-phase system. The waste of olive used to produce compost could be of safe disposal technique. Disposal of such waste is expensive and it causes some environmental hazards. Rock phosphate (RP), which is available in the same region, can be used to improve the nutrient value of the produced compost. In this experiment olive pruning waste was composted alone and in a mixture with different RP in two different ratios, namely 5% and 10%, on the dry weight basis of olive waste. Compost processing took place on plies for 8 months. Temperature and moisture were monitored daily while periodical samples were taken from all piles for testing pH, EC, C/N, and germination index. Composts in all treatments reached the theomorphic phase, which killed weed seeds and pathogens. The produced compost from all treatments fulfilled the requirements of maturity according to the California Compost Quality Council after 8 months of composting. In addition, the RP enhanced composting efficiency and improved the quality of the produced compost. Compost parameters met the standard requirements for the compost that was suitable for agriculture purposes with average values of pH ranging from (7.02–7.65) and EC (2.20–3.94 dS m^?1). Nutrient concentrations in the produced compost were N (1.28–1.79%), P (0.23–2.15%), and K (2.59–4.22%).     

利用葡萄酒糟生产有机复混肥研究

研究了以葡萄酿酒后副产物皮渣和籽渣为原料,采用化学腐熟促进处理、微生物好氧发酵和添加复配N、P、K等方法生产有机复混肥,该产品有机质含量≥300g/kg,N、P、K总含量≥250g/kg,并含有10多种中微量元素,田间试验结果表明与等养分和等价格化肥相比,施用该有机复混肥可增产10％以上,对多种经济作物品质有明显改善作用,且改土培肥效果明显。     

Determination of spherosomes from lees materials

To evaluate the effectiveness in adsorbing organochlorine compounds such as chloroform, dichloromethane, or benzene by lees materials, the determination of spherosomes from different lees materials was established by using a hemacytometer under an optical microscope. Rice bran, wheat bran, rapeseed, linseed, okara, and sakekasu were used for this investigation, and activated carbon was also used as a standard adsorbent material. The number of spherosomes varied from 1.82 x 10(10) particles/g for sakekasu to 4.95 x 10(10) particles/g for wheat bran. There was a high correlation between the removal efficiency in adsorbing organochlorine compounds such as chloroform, dichloromethane, or benzene by lees materials and the number of spherosomes from different lees materials.     

Stability of virgin olive oil. 1. Autoxidation studies

Virgin olive oil samples with similar oxidative stabilities and fatty acid compositions were stored for 24 months. Changes in the lipid substrate were followed by peroxide value and K(232) measurements. HPLC was used to evaluate changes in the alpha-tocopherol, pigment, and squalene contents. Total polar phenol content was measured colorimetrically. The loss of alpha-tocopherol and carotenoids was comparable with that of polar phenol content, suggesting an active participation in autoxidation. The limited role of squalene in autoxidation was further confirmed using an olive oil model and in the presence of alpha-tocopherol. Pheophytin a degradation was high, although spectrometric estimation of chlorophyll content did not indicate so. Evaluation of pheophytin a activity at three different levels of addition on the oil model indicated a concentration-dependent antioxidant role more pronounced at elevated temperatures, which could be partially due to the activity of certain degradation products.     

Effect of steam treatment of alperujo on the composition, enzymatic saccharification, and in vitro digestibility of alperujo

The solid waste from two-phase olive oil extraction or "alperujo" was submitted to steam treatment at high pressure or temperature, 200 degrees C for 5 min, in the presence and absence of mild acid catalyst. This treatment made easier the separation of the solid and liquid fractions. Besides the recovery of certain valuable components from the liquid fraction (the antioxidant hydroxytyrosol, low molecular weight oligosaccharides, glucose, mannitol, etc.), the major components of the solid residue could be also exploited. In this study, changes in composition of alperujo due to steam treatment were determined. The process reduced appreciably the hemicellulose concentrations (75-88%), removed a substantial portion of Klason lignin and protein (50%), and led to an extensive solubilization of alperujo (55-67%). Cellulose was very resistant to autohydrolysis and acid-catalyzed hydrolysis, so the solid residue was enriched in fat (13-18 g/100 g of dry steam-treated alperujo) and cellulose (15-25 g/100 g of dry and defatted steam-treated alperujo). The steam-treated material can be efficiently saccharified with commercial cellulase. The best hydrolysis yields were attained, up to 80%, when the treated material was post-treated with NaOH. The possibility of using this steam-treated alperujo in animal feeding was evaluated by an in vitro digestibility test, using the pepsin-cellulase method. The treatment affected positively the nutritional characteristics of alperujo with an increase in its in vitro (dry and organic matter) digestibility (8-10% higher than untreated material). In vitro digestibility and cellulose accessibility to enzymatic hydrolysis were improved by the alkali post-treatment.     

葡萄酒生产废弃物与剩余污泥厌氧共消化研究进展

厌氧消化技术被广泛应用于多种行业废弃物的处置。然而,葡萄酒生产废弃物浓度高、pH值低以及季节性变化的特性容易造成负荷冲击,导致反应器微生物流失、运行不稳定。同时,剩余污泥组分复杂、水解率低导致产气效率低。厌氧共消化具有均衡营养素、减缓抑制效应、丰富菌群多样性和提高甲烷产量等优势,也逐渐成为一种重要的葡萄酒生产废弃物与剩余污泥的处置方式。尽管已有二者在不同运行策略下共消化性能的研究,但仍未有报道阐明其共消化的影响因素以及基于葡萄酒生产废弃物特性建立直接种间电子传递的研究进展。因此,该文介绍了葡萄酒生产废水与剩余污泥、葡萄酒生产固体废弃物与剩余污泥的共消化进展,并分别归纳了2种体系中影响消化效能的主要因子;随后总结了共消化体系中基于乙醇建立的直接种间电子传递的研究进展;最后,围绕以上内容展望了共消化技术在葡萄酒生产废弃物与剩余污泥协同处理的前景。     

Fenhexamid adsorption behavior on soil amended with wine lees

The adsorption of fenhexamid (FEN) [N-(2,3-dichloro-4-hydroxyphenyl)-1-methylcyclohexanecarboxamide] on vineyard soil amended with wine lees (WL) produced by vinery was studied. The adsorption extent depends on WL fraction. The addition of the centrifuged solid lees (SWL) increases the FEN adsorption on soil. Most likely, the organic insoluble fraction formed mainly by dead fermentation yeasts is responsible for the observed increase. The adsorption measured on some deactivated yeasts of wine fermentation shows that Saccharomyces cerevisiae are the most active in FEN retention. On the other hand, the soil amendment with whole WL decreases considerably the fungicide adsorption. This opposite effect may be the result of FEN hydrophobic bonds with the dissolved organic matter of lees that keeps fungicide in solution. This hypothesis is substantiated by the increased FEN solubility in the supernatant of centrifuged wine lees (LWL). The results of soil column mobility confirm that the elution with LWL increases the mobility of FEN in soil.     

Fate of iprovalicarb, indoxacarb, and boscalid residues in grapes and wine by GC-ITMS analysis

The behavior in field and the transfer from grapes to wine during winemaking of iprovalicarb, indoxacarb, and boscalid was studied. The residue levels found in grapes were far below the MRLs set for grapes in EU, accounting at harvest time 0.81, 0.43, and 4.23 mg/kg for iprovalicarb, indoxacarb, and boscalid, respectively. The residue levels in the samples treated with boscalid may have residual problems (due to an accumulation effect) if repeated field treatments will be performed. Winemaking experiments showed a complete transfer of all pesticide from grapes to the must, while in wine the residues were low or negligible due to the adsorbing effect of lees and pomace. The clarification experiments showed a good removal of pesticide residues from the wine media, for all pesticides. The GC-ITMS method showed good performance with adequate recoveries ranging from 75 to 115%, and good method limits of quantitation (LOQs) and of determination (LODs) far below MRLs.