Multiresidue analysis of pesticides in soil by supercritical fluid extraction/gas chromatography with electron-capture detection and confirmation by gas chromatography-mass spectrometry

The applicability of supercritical fluid extraction (SFE) in pesticide multiresidue analysis (organohalogen, organonitrogen, organophosphorus, and pyrethroid) in soil samples was investigated. Fortification experiments were conducted to test the conventional extraction (solid-liquid) and to optimize the extraction procedure in SFE by varying the CO2 modifier, temperature, extraction time, and pressure. The best efficiency was achieved at 400 bar using methanol as modifier at 60 degrees C. For the SFE method, C-18 cartridges were used for the cleanup. The analytical screening was performed by gas chromatography equipped with electron-capture detection (ECD). Recoveries for the majority of pesticides from spiked samples of soil at different residence times were 1, 20, and 40 days at the fortification level of 0.04-0.10 mg/kg ranging from 70 to 97% for both methods. The detection limits found were <0.01 mg/kg for ECD, and the confirmation of pesticide identity was performed by gas chromatography-mass spectrometry in a selected-ion monitoring mode. Multiresidue methods were applied in real soil samples, and the results of the methods developed were compared.     

Extraction of natural vitamin E from wheat germ by supercritical carbon dioxide

An efficient supercritical fluid extraction (SFE) process with carbon dioxide (SFE-CO(2)) was developed for the extraction of natural vitamin E (V(E)) from wheat germ. Both the pretreatment of extracted wheat germ and extraction conditions were optimized to ensure maximal V(E) yield. The extraction was undertaken at the extracting pressure of 4000-5000 psi, the extracting temperature of 40-45 degrees C, and the carbon dioxide flow rate of 2.0 mL/min for 90 min. An optimized pretreatment of wheat germ was usually necessary with a particle size of 30 mesh and a moisture content of 5.1%. A yield comparison of V(E) and its isomers extracted by supercritical CO(2) with those by conventional solvent extraction suggested that this SFE process was a practical process prospectively superior to conventional solvent extraction to prepare V(E) from wheat germ.     

土壤样品中多环芳烃分析方法研究进展

概述了国内外土壤样品中多环芳烃(PAHs)测定方法的研究状况,其中提取方法包括加速溶剂萃取方法、固相微萃取方法、超临界流体萃取方法、亚临界水萃取方法和流化床提取方法等,测定方法有HPLC法、GC法和免疫分析法等。重点介绍了PAHs的提取过程,同时总结了各种方法的优缺点。     

Supercritical fluid extraction of organochlorine pesticides in eggs

The efficacy of supercritical fluid extraction (SFE) for the recovery of 16 common organochlorine pesticides (OCPs) from liquid whole eggs was investigated by employing supercritical carbon dioxide (SC-CO(2)) without the use of a solvent modifier to minimize interfering coextractives. The OCPs tested included aldrin; alpha-, beta-, delta-, and gamma-BHCs; p,p'-DDD, -DDE, and -DDT; dieldrin; endosulfans I, II, and sulfate; endrin; endrin aldehyde; heptachlor; and heptachlor epoxide. The SFE conditions were as follows: 10000 psi (680 bar), 40 degrees C, SC-CO(2) flow rate of 3.0 L/min with an extraction time of 40 min for a total of 120 L of CO(2). The OCPs were trapped off-line in an SPE cartridge containing Florisil and then eluted by an acetone/hexane mixture and analyzed by gas chromatography-electron capture detection (GC-ECD). Recovery studies were carried out on homogenized eggs fortified at the 0.05, 0.10, and 0.20 ppm levels. At the lowest level, 0.05 ppm, recoveries ranged from 81.8 to 108.3%, with CVs < 9.8%. All recoveries were significantly higher than those obtained by an AOAC/FDA solvent extraction method. Eggs containing incurred endosulfan I were also effectively extracted by SFE. This study suggests that the application of SFE for the extraction of OCPs from eggs will result in significant savings in analysis time and lower solvent use and disposal costs compared to conventional solvent extraction procedures.     

Supercritical fluid extraction/enzyme assay: a novel technique to screen for pesticide residues in meat products.

The novel combination of supercritical fluid extraction (SFE) with an enzyme assay system has been used to screen meat products to detect the presence of pesticides. Analytes are collected in water by expanding supercritical carbon dioxide to atmospheric pressure through a restrictor and into an aqueous phase. The solution is then tested for the presence of pesticide residues by enzyme assay. Two experimental approaches have been used. Alachlor-fortified lard and bovine liver were monitored by static SFE coupled with an enzyme immunoassay. SFE of carbofuran-fortified frankfurters was coupled with an enzyme assay based on cholinesterase inhibition. A major benefit of the SFE/enzyme assay technique over conventional screening techniques is that the analyst is not exposed to organic solvents.     

Supercritical fluid extraction and high-performance liquid chromatographic determination of phloroglucinols in St. John's Wort (Hypericum perforatum L.)

A small-scale supercritical fluid extraction (SFE) method was developed for the selective extraction of phloroglucinols from St. John's wort (SJW) leaf/flower mixtures using supercritical carbon dioxide (CO(2)). The extraction efficiency was investigated as influenced by pressure, temperature, time, and modifier. The optimized condition of SFE was carried out at 3.80 x 10(4) kpa (5500 psi) and 50 degrees C. Samples were held in static extraction for 10 min, followed by a dynamic extraction for 90 min at the flow rate of 1 mL/min. A simple and sensitive HPLC method was developed for the analysis of hyperforin and adhyperforin, the major phloroglucinols, in the SFE extract of SJW.     

On-line supercritical fluid extraction/enzymatic hydrolysis of vitamin a esters: a new simplified approach for the determination of vitamins a and e in food

An on-line supercritical fluid extraction (SFE)/enzymatic hydrolysis procedure using immobilized lipase has been developed for the determination of vitamin A in dairy and meat products. Several lipases were tried, of which Novozyme 435 (Candida antarctica type B) showed the highest activity toward retinyl palmitate. There was no observed activity with alpha-tocopheryl acetate. When pressure, temperature, modifiers, flow rate, extraction time, and water content were varied, high vitamin A recovery was obtained in milk powder. Collected extracts were analyzed by reversed-phase high-performance liquid chromatography with ultraviolet and fluorescence detection without additional sample cleanup. The procedure gave reliable values of vitamin A as well as of vitamin E in other food items such as infant formula, minced pork and beef meat, and low- and high-fat liver paste. The described method is faster and more automated than conventional methods based on liquid-liquid extraction, or SFE using off-line saponification, for vitamin A and E determination. Results obtained with the new method did not differ significantly from those obtained with the other two methods mentioned above.     

Effect of variety and maturation of cheese on supercritical fluid extraction efficiency

Supercritical fluid extraction (SFE) has been utilized by the food industry in many applications to extract, fractionate, and recover compounds from various food matrices. However, little research has been conducted using SFE as an alternative process for producing reduced-fat cheese. Lipids in cheeses may be selectively extracted due to the nonpolar properties of supercritical carbon dioxide (SC-CO2), without leaving residual chemicals as is the case in solvent extraction. The objective of this study was to evaluate the influence on the extraction process due to cheese variety and protein breakdown by age. A Latin square design was utilized to test the extractability of lipids from Parmesan and Cheddar cheeses, aged young (9-10 months) or old (24 months). Extraction took place in a 500 mL SFE vessel using 100 g of grated cheese samples. The SFE parameters of the extraction were 350 bar, 35 degrees C, and supercritical carbon dioxide at a flow rate of 20 g/min for 55 min. Compositional analysis measured all treated samples and controls of total lipids, lipid profiling, total protein, protein/peptide analysis, moisture, ash, and pH. Cheese type was a major variable in fat extraction. The extraction in Cheddar showed an average fat reduction of 53.56% for young cheese, whereas that in old Cheddar was 47.90%. However, young Parmesan was reduced an average of 55.07%, but old Parmesan was reduced at 68.11%, measured on a dry basis. SFE extracted triglycerides and cholesterol, but did not remove phospholipids. This investigation introduces the observations of the effect of Cheddar and Parmesan varieties on SFE, offering data on the important parameters to consider in the design of SFE processes to reduce fat in cheese.     

Polycyclic aromatic hydrocarbon profile analysis of high-protein foods, oils, and fats by gas chromatography.

A method is described for the determination of polycyclic aromatic hydrocarbons (PAHs) with 3-7 rings in (I) meat, poultry, fish, and yeast; and (II) oils and fats. The extraction of PAHs from group I is incomplete, and, therefore, group I samples must be dissolved homogeneously by saponification in 2N methanolic potassium hydroxide. The PAHs are concentrated by liquid-liquid extraction (methanol-water-cyclohexane, N,N - dimethylformamide - water-cyclohexane) and by column chromatography on Sephadex LH 20. The PAHs are separated by high-performance gas-liquid chromatography (GLC) with columns containing 5% OV-101 on Gas-Chrom Q and estimated by integration of the flame ionization detector signals in relation to an internal standard (3,6-dimethylphenanthrene and/or benzo(b)chrysene). The sensitivity is significantly higher than that obtained with ultraviolet spectroscopic methods. The reproducibility and margin of error were tested with meat samples fortified with 11 PAHs and with samples of sunflower oil. The method was further applied to meat, smoked fish, yeast, and unrefined sunflower oil. All samples investigated contained more than 100 PAHs (characterized by mass spectrometry) of which only the main components were determined: phenanthrene, anthracene, fluorene, fluoranthene, pyrene, benzo(a)anthracene, chrysene, benzo(b)fluoranthene + benzo (j)fluoranthene + benzo(k) fluoranthene, benzo(e)pyrene, benzo(a)pyrene, perylene, dibenz(a,j)anthracene, dibenz(a,h)anthracene + indeno(1,2,3,-cd)pyrene, benzo(ghi)perylene, anthanthrene, and coronene. In contrast to other methods, the GLC profile analysis allows the recording of known and unknown PAH peaks simultaneously and also allows a compilation of all PAHs.     

Method of determination of nitrosamines in sausages by CO2 supercritical fluid extraction (SFE) and micellar electrokinetic chromatography (MEKC)

In this paper, the use of supercritical fluid extraction (SFE) and micellar electrokinetic capillary chromatography (MEKC) is proposed for the complete analysis of volatile nitrosamines in sausages. The extraction fluid used was CO2 and variables such as density, temperature of thimbles, extraction time, modifier, fluid flow, and kind of traps were investigated. Several experiments were carried out to obtain the most favorable conditions for analysis of volatile nitrosamines in sausages. The recoveries ranged from 21 to 82% for the five nitrosamines studied. The optimal condition of extraction was 0.2 g of sample fortified with 10 mg/kg, using dynamic extraction during 20 min and with adsorbent Florisil in the trap. The solvent selected for the elution of the analytes was methanol.     

Supercritical carbon dioxide extraction of spirulina platensis component and removing the stench.

The chemical component of spirulina was determined by supercritical CO(2) extraction. The protein and essential amino acid contents of spirulina powder were not significantly decreased through supercritical CO(2) extraction, but the contents of total amino acid and lipids were reduced. The spirulina powder had a stench smell before, but not after, supercritical CO(2) extractions. The highest yield rate of lipids was obtained at an extraction pressure of 35 MPa and an extraction time of 4 h. The lipids could be used as additives of health foods containing gamma-linolenic acid.     

Accelerated solvent extraction and gas chromatography/mass spectrometry for determination of polycyclic aromatic hydrocarbons in smoked food samples.

Accelerated solvent extraction (ASE) is a new sample extraction method offering a number of advantages such as low pe -extraction cost, reduced solvent and time consumption, and simplified extraction protocols. In this study, the ASE method was applied to the extraction of polycyclic aromatic hydrocarbons (PAHs) from biological samples. For recovery studies, fish tissues and ground pork were used as sample matrices. Sample aliquots fortified with 16 PAHs were extracted by ASE, and the extracts were treated with sulfuric acid and Florisil, followed by gas chromatography-mass spectrometry analysis. The PAH recoveries by the ASE method were found to be comparable with or better than those by Soxhlet extraction. The extraction and quantitation method was then applied to the determination of PAHs in several smoked meat samples obtained from a local market. Up to 12 PAHs were found to be present at concentrations ranging from 3 to 52 ng/g wet sample.     

Supercritical fluid extraction of the pesticides carbosulfan and imidacloprid from process dust waste

Large amounts of contaminated process dust remain from the procedure of pesticide treatments applied to seed pellets. A pilot study in analytical-scale supercritical fluid extraction (SFE) was performed to determine the possibility of using supercritical carbon dioxide for the extraction of the nonpolar insecticide carbosulfan and the more polar insecticide imidacloprid present in contaminated dust waste, at concentrations of up to 20% (w/w). The effects of various experimental conditions, such as temperature, flow rate, and addition of modifier, on the recovery of the analytes were evaluated by extracting the pesticides both from spiked support material and from real dust samples. It was found that carbosulfan could easily be extracted from the dust waste within 30 min at 138 bar and 40 degrees C with a recovery of 98.9% (RSD = 2.3%, n = 10), compared to values obtained with a validated liquid extraction method. A sufficient removal of the more polar substance imidacloprid required the addition of a modifier, and the results showed a strong dependence of the extraction efficiency on the choice of modifier. Extractions at 276 bar and 80 degrees C with a solvent consisting of supercritical carbon dioxide modified with methanol (5%) gave a recovery of 97.0% (RSD = 3.6%, n = 10) using a 40 min extraction time. The results indicate that it seems to be possible to use process-scale SFE for the decontamination of pesticides from dust waste. The conditions outlined also permit analytical determinations of the two insecticides based on a combination of SFE and liquid chromatography.     

Volatiles obtained from whole and ground grain samples by supercritical carbon dioxide and direct helium purge methods: observations on 2,3-butanediols and halogenated anisoles.

Volatile compounds were obtained from whole and ground grain samples by two methods. In the supercritical fluid extraction (SFE) method, volatiles were extracted from the grain with supercritical carbon dioxide, trapped at -78 degrees C, and then transferred via a purge-and-trap instrument to a gas chromatograph with mass and infrared detectors (GC-MS/IR) for separation and identification. In the direct-helium-purge method (DHP), volatiles were purged directly from the grain into the purge-and-trap instrument for subsequent transfer to the GC-MS/IR system. With SFE, extraction of volatiles was favored by ground grain, low pressures (相似文献   

Comparison of Three Extraction Systems for Determining Surface Lipid Content of Thickness‐Fractionated Milled Rice

The surface lipid content (SLC) of rice is often used to objectively measure the degree to which bran has been removed from rice kernels, commonly known as degree of milling (DOM). This study was conducted to evaluate new, rapid extraction technology for potential timesaving measurements of SLC of milled rice. The SLC of two long‐grain rice cultivars, Cypress and Drew, were determined using three extraction systems: Soxtec, accelerated solvent extraction (ASE), and supercritical fluid extraction (SFE). Before milling, rough rice was separated into three thickness fractions (<1.84, 1.84–1.98, and >1.98 mm) and samples from each thickness fraction were milled for durations of 10, 20, and 30 sec. Head rice collected from each milling duration was extracted using each of the three methods. Results showed that regardless of the extraction method, thinner kernels had lower SLC measurements than thicker fractions. In most cases, both the ASE and Soxtec produced SLC greater than that of the SFE. The ASE also showed SLC measurements at least as great as those from Soxtec extraction, suggesting that the ASE is as thorough in extracting lipids as commonly used methods.     

Comparison of the chemical composition of extracts from Scutellaria lateriflora using accelerated solvent extraction and supercritical fluid extraction versus standard hot water or 70% ethanol extraction

The aqueous extract of American skullcap (Scutellaria lateriflora L. (S. lateriflora), Lamiaceae) has been traditionally used by North American Indians as a nerve tonic and for its sedative and diuretic properties. Recent reports stated that flavonoids and possibly amino acids are responsible for the anxiolytic activity. As a part of our search for environmentally friendly solvents to extract the active components from medicinal plants, we used S. lateriflora in a comparison of accelerated solvent extraction (ASE) using water, and supercritical fluid extraction (SFE) using CO2 and 10% EtOH as modifier, at different temperatures. Flavonoids and amino acids were quantified by HPLC-UV and HPLC-MS, respectively. The flavonoid content was compared with conventional extraction methods (hot water extraction and 70% ethanol). The use of ASE at 85 degrees C with water as solvent gave the best results for flavonoid glycosides and amino acids, whereas SFE gave higher yields of flavonoid aglycones. However, the results obtained for total flavonoids were not significatively superior to hot water extraction or 70% aqueous EtOH extract.     

Supercritical fluid extraction of lycopene from tomato processing byproducts

Tomato seeds and skins acquired from the byproduct of a local tomato processing facility were studied for supercritical fluid extraction (SFE) of phytochemicals. The extracts were analyzed for lycopene, beta-carotene, alpha-carotene, alpha-tocopherol, gamma-tocopherol, and delta-tocopherol content using high-performance liquid chromatography-electrochemical detection and compared to a chemically extracted control. SFEs were carried out using CO(2) at seven temperatures (32-86 degrees C) and six pressures (13.78-48.26 MPa). The effect of CO(2) flow rate and volume also was investigated. The results indicated that the percentage of lycopene extracted increased with elevated temperature and pressure until a maximum recovery of 38.8% was reached at 86 degrees C and 34.47 MPa, after which the amount of lycopene extracted decreased. Conditions for the optimum extraction of lycopene from 3 g of raw material were determined to be 86 degrees C, 34.47 MPa, and 500 mL of CO(2) at a flow rate of 2.5 mL/min. These conditions resulted in the extraction of 61.0% of the lycopene (7.19 microg lycopene/g).     

Direct connection of supercritical fluid extraction and supercritical fluid chromatography as a rapid quantitative method for capsaicinoids in placentas of Capsicum.

The fruits of Capsicum annuum L. are used worldwide as chili peppers and in folk medicines. The pungent components of C. annuum, which are irritants, are called capsaicinoids (CAPS), and the most abundant components are capsaicin, dihydrocapsaicin, and nordihydrocapsaicin. To analyze CAPS in the placentas of Capsicum fruits rapidly and safely, we used a directly connected system of supercritical fluid extraction and supercritical fluid chromatography (SFE/SFC). As a column for SFE/SFC, only a silica-type column was found to be suitable. The CAPS contents in placentas of C. annuum cv. Jalapeno (hot type) and C. annuum cv. Shishitoh (less-hot type) determined by the SFE/SFC method agreed well with those in the range of 0-13.81 mg g(-1) fr. wt determined by the usual extraction-HPLC method. The SFE/SFC method has the advantages of no need for pretreatment and no (or minimal) need for organic solvents. We conclude that this method is useful as a rapid (20 min) and safe screening test for the pungency of various Capsicum fruits.     

Determination of the fluoroquinolone enrofloxacin in edible chicken muscle by supercritical fluid extraction and liquid chromatography with fluorescence detection

A supercritical fluid extraction (SFE) method for the extraction of enrofloxacin from a chicken breast muscle was examined. A liquid chromatograph, equipped with a fluorescence detector, was used for the detection of enrofloxacin. Optimal extraction parameters, such as extraction time, supercritical fluid volume, modifier concentration, pressure, and temperature, were determined by examining SFE recoveries from control muscle samples spiked with enrofloxacin at different levels. In all of the experiments, high recovery values were observed, ranging from 101 to 104%. The extraction of enrofloxacin from real muscle samples was examined in chickens that were treated orally with enrofloxacin. Extraction was carried out by the SFE method after each oral treatment and under optimal extraction conditions at set intervals over time. The SFE, combined with liquid chromatographic analysis, showed that the concentration of enrofloxacin in the chicken muscles decreased continuously with time, giving a negligible concentration 72 h after the treatment. These results suggest that SFE is a useful approach for the extraction of enrofloxacin from chicken breast muscles.     

Evaluation of supercritical fluid extraction/aminopropyl solid-phase "in-line" cleanup for analysis of pesticide residues in rice

Supercritical fluid extraction (SFE) and the use of aminopropyl solid-phase material for "in-line" cleanup was evaluated for residue analysis of 22 GC-amenable pesticides in wild- and white-rice samples with a fat content of 1.9 and 0.4%, respectively. After optimizing the extraction conditions on glass beads as inert material and evaluating the fat amount extracted from rice by SFE, the use of Florisil, Celite, Extrelut, Hydromatrix, and an aminopropyl material as fat-retention materials for SFE "in-line" cleanup was assessed, aminopropyl being the most suitable material for this cleanup of fat. Pesticide mean recoveries obtained from rice samples, at fortification levels around 0.5 mg/kg, by means of the SFE/in-line cleanup method finally proposed (15-mL CO2 volume, 50 degrees C temperature, 200 atm pressure, 200 muL of methanol static modifier, and a 1-cm layer of aminopropyl at the bottom of the extraction vessel), ranged between 74 and 98%, except for captafol and dimethoate for which mean recoveries lower than 21% were determined.