Barley grain constituents, starch composition, and structure affect starch in vitro enzymatic hydrolysis

The relationship between starch physical properties and enzymatic hydrolysis was determined using ten different hulless barley genotypes with variable carbohydrate composition. The ten barley genotypes included one normal starch (CDC McGwire), three increased amylose starches (SH99250, SH99073, and SB94893), and six waxy starches (CDC Alamo, CDC Fibar, CDC Candle, Waxy Betzes, CDC Rattan, and SB94912). Total starch concentration positively influenced thousand grain weight (TGW) (r(2) = 0.70, p < 0.05). Increase in grain protein concentration was not only related to total starch concentration (r(2) = -0.80, p < 0.01) but also affected enzymatic hydrolysis of pure starch (r(2) = -0.67, p < 0.01). However, an increase in amylopectin unit chain length between DP 12-18 (F-II) was detrimental to starch concentration (r(2) = 0.46, p < 0.01). Amylose concentration influenced granule size distribution with increased amylose genotypes showing highly reduced volume percentage of very small C-granules (<5 μm diameter) and significantly increased (r(2) = 0.83, p < 0.01) medium sized B granules (5-15 μm diameter). Amylose affected smaller (F-I) and larger (F-III) amylopectin chains in opposite ways. Increased amylose concentration positively influenced the F-III (DP 19-36) fraction of longer DP amylopectin chains (DP 19-36) which was associated with resistant starch (RS) in meal and pure starch samples. The rate of starch hydrolysis was high in pure starch samples as compared to meal samples. Enzymatic hydrolysis rate both in meal and pure starch samples followed the order waxy > normal > increased amylose. Rapidly digestible starch (RDS) increased with a decrease in amylose concentration. Atomic force microscopy (AFM) analysis revealed a higher polydispersity index of amylose in CDC McGwire and increased amylose genotypes which could contribute to their reduced enzymatic hydrolysis, compared to waxy starch genotypes. Increased β-glucan and dietary fiber concentration also reduced the enzymatic hydrolysis of meal samples. An average linkage cluster analysis dendrogram revealed that variation in amylose concentration significantly (p < 0.01) influenced resistant starch concentration in meal and pure starch samples. RS is also associated with B-type granules (5-15 μm) and the amylopectin F-III (19-36 DP) fraction. In conclusion, the results suggest that barley genotype SH99250 with less decrease in grain weight in comparison to that of other increased amylose genotypes (SH99073 and SH94893) could be a promising genotype to develop cultivars with increased amylose grain starch without compromising grain weight and yield.     

Impact of Elevated Nighttime Air Temperatures During Kernel Development on Starch Properties of Field‐Grown Rice

The structural features of starch were examined to better understand the causes of variability in rice quality resulting from nighttime air temperature (NTAT) incidence during kernel development. Starch samples were isolated from head rice of four cultivars (Bengal, Cypress, LaGrue, and XL723) field‐grown in four Arkansas locations (Keiser, Pine Tree, Rohwer, and Stuttgart) in 2009 and 2010. Average NTATs recorded during the grain‐filling stages of rice reproductive growth in the four locations were 3.0–8.4°C greater in 2010 than 2009. Elevated NTATs altered the deposition of starch in the rice endosperm. Means pooled across cultivars and locations showed that amylose content was 3.1% (percentage points) less for the 2010 sample set. The elevated NTATs in 2010 resulted in a decrease in the percentage of amylopectin short chains (DP ≤ 18) and a corresponding increase in the percentage of long chains (DP ≥ 19) by an average of 1.3% (percentage points). The greater NTATs in 2010 also produced greater starch paste peak, final, and breakdown viscosities, whereas setback and total setback viscosities decreased. Changes in paste viscosity were highly correlated with the changes in the proportion of amylose and amylopectin. Onset gelatinization temperature was greater by 3.5°C, gelatinization enthalpy by 1.3 J/g, and relative crystallinity by 1.5% (percentage points) for the 2010 sample set. Changes in gelatinization parameters and granule relative crystallinity were highly correlated with the changes in amylopectin chain‐length distribution. Year × cultivar × location interaction effects were statistically insignificant, indicating that the four cultivars evaluated all showed some degree of susceptibility to the effects of temperature incidence during kernel development, regardless of the growing location.     

Composition,Molecular Structure,Properties, and In Vitro Digestibility of Starches from Newly Released Canadian Pulse Cultivars

Pulse starches were isolated from different cultivars of pea, lentil, and chickpea grown in Canada under identical environmental conditions. The in vitro digestibility and physicochemical properties were investigated and the correlations between the physicochemical properties and starch digestibility were determined. Pulse starch granules were irregularly shaped, ranging from oval to round. The amylose content was 34.9–39.0%. The amount of short A chains (DP 6‐12) of chickpea starch was much higher than the other pulse starches, but the proportions of B1 and B2 chains (DP 13‐24 and DP 25‐36, respectively) were lower. The X‐ray pattern of all starches was of the C type. The relative crystallinity of lentil (26.2–28.3%) was higher than that of pea (24.4–25.5%) and chickpea starches (23.0–24.8%). The swelling factor (SF) in the temperature range 60–90°C followed the order of lentil ≈ chickpea > pea. The extent of amylose leaching (AML) at 60°C followed the order of pea ≈ chickpea > lentil. However, in the temperature range 70–90°C, AML followed the order of lentil > pea > chickpea. The gelatinization temperatures followed the order of lentil > pea > chickpea. The peak viscosity, setback, and final viscosity of pea starch were lower than those of the other starches. Lentil starch exhibited lower rapidly digestible starch (RDS) content, hydrolysis rate, and expected glycemic index (eGI). The resistant starch (RS) content of both lentil cultivars was nearly similar. However, pea and chickpea cultivars exhibited wide variations in their RS content. Digestibility of the pulse starches were significantly correlated (P < 0.05) with swelling factor (60°C), amylose leaching (60°C), gelatinization temperature, gelatinization enthalpy, relative crystallinity, and chain length distribution of amylopectin (A, B1, and B2 chains).     

Properties of Starches from Several Low‐Amylose Rice Cultivars

The starch properties of five low‐amylose rice cultivars, Yawarakomachi, Soft 158, Hanabusa, Aya, and Snow Pearl, were compared with those of two normal amylose rice cultivars, Nipponbare and Hinohikari. There were no large differences in the distributions of the amylopectin chain length determined by high‐performance anion‐exchange chromatography, and the starch gelatinization properties determined by differential scanning calorimetry, between normal and low‐amylose rice cultivars. Results obtained using rapid viscosity analysis indicated that low‐amylose rice starches had lower peak viscosity, breakdown, and setback values than normal amylose rice starches. Starch granules from low‐amylose rice cultivars had a higher susceptibility to glucoamylase than those from normal amylose rice cultivars. The results of this study showed some differences between normal and low‐amylose rice starches in pasting properties and enzymatic digestibility.     

Fine Structures of Amylose and Amylopectin from Large,Medium, and Small Waxy Barley Starch Granules

Amylose and amylopectin were prepared from large, medium, and small granule starches of classified waxy barley flour, and their fine structures were investigated. The amylose content had a wide distribution range (≈1.4–9.4%). Number‐average degrees of polymerization (DP_n) of the amyloses were similar among the samples (≈1,200–1,300). But number of chains per molecule (NC) decreased from the surface to the center (≈6–10 chains). DP_n of the amylopectins varied from 4,657 to 14,604; decreased in the order of large, medium, and small granules in same fractions of the grain; and increased from the surface layer to the center. Longest chains (LC) were not found in any of the amylopectin molecules. The large amylopectin molecule had more long chains and fewer A chains than the small molecule. The amylose content had definite effects on the transition temperature range and crystal formation of the starch granules. There were positive correlations between DP_n of the amylopectin and relative crystallinity (γ = +0.69) and enthalpy value (γ = +0.80), respectively. These findings may help to elucidate biosynthesis mechanism of starch.     

Physicochemical,Structural, and Proteomic Analysis of Starch Granules from Maize Landraces of Northwest Mexico

The variability in grain and starch characteristics and their relationship with the accumulation of starch granule associated proteins were investigated in five maize landraces of Northwest Mexico (Blando de Sonora, Chapalote, Elotero de Sinaloa, Reventador, and Tabloncillo). Significant differences were observed in grain hardness related traits, starch physicochemical properties, and structural properties. Blando de Sonora showed very soft grains, whereas the hardest grains were observed for Chapalote and Reventador. Starch granules isolated from landraces with hard grains contained more amylose and showed polygonal shapes, lower crystallinity and enthalpy of gelatinization, and greater retrogradation and proportion of long amylopectin chains. Proteomic analysis identified the enzymes granule‐bound starch synthase I (GBSSI), starch synthase I and IIa, starch branching enzyme IIb, sucrose synthase 1, and pyruvate phosphate dikinase 2 as granule‐associated proteins. The abundance of GBSSI correlated significantly with amylose content, consistent with the positive correlation observed between amylose and grain hardness. These results showed that the variability in the characteristics evaluated was mainly related to changes in the proportion of amylose in the starch granules, which were associated with differences in the expression of GBSSI. This information may be useful to define strategies for the exploitation and conservation of the landraces.     

Effects of Cultivar and Processing Condition on Physicochemical Properties and Starch Fractions in Parboiled Rice

Starch can be classified into rapidly digestible starch (RDS), slowly digestible starch (SDS), and resistant starch (RS) according to its resistance to amylolytic enzymes. This study investigated the effects of cultivar and feedstock under varying parboiling conditions on the physicochemical properties and starch fractions of parboiled rice. Rice (rough or brown) was soaked, steamed under pressure, dried immediately or stored at room temperature for 24 hr prior to drying, and then treated with or without a repeated steam cycle prior to milling. The storage treatment significantly increased the retrograded amylopectin enthalpy and amylose‐lipid complex melting temperature of parboiled rice. Parboiled rice samples prepared from brown rice feedstock had higher peak melting temperatures but lower enthalpy values of retrograded amylopectin than samples prepared from rough rice after the storage treatment. The pasting viscosity of parboiled rice was most affected by the repeated autoclaving treatment and cultivar. Starch fractions in parboiled rice were significantly affected by cultivar and storage and by the interactions of cultivar and parboiling conditions. The storage treatment significantly increased SDS and generally decreased RDS in parboiled rice. Parboiled rice with different SDS and RS contents can be produced by varying rice cultivar and parboiling conditions.     

Physicochemical Properties and In Vitro Starch Digestibility of Cooked Rice from Commercially Available Cultivars in Canada

The influence of amylose content, cooking, and storage on starch structure, thermal behaviors, pasting properties, and rapidly digestible starch (RDS), slowly digestible starch (SDS), and resistant starch (RS) in different commercial rice cultivars was investigated. Long grain rice with high‐amylose content had a higher gelatinization temperature and a lower gelatinization enthalpy than the other rice cultivars with intermediate amylose content (Arborio and Calrose) and waxy type (glutinous). The intensity ratio of 1047/1022 cm^–1 determined by Fourier Transform Infrared (FT‐IR), which indicated the ordered structure in starch granules, was the highest in glutinous and the lowest in long grain. Results from Rapid ViscoAnalyser (RVA) showed that the rice cultivar with higher amylose content had lower peak viscosity and breakdown, but higher pasting temperature, setback, and final viscosity. The RDS content was 28.1, 38.6, 41.5, and 57.5% in long grain, Arborio, Calrose, and glutinous rice, respectively, which was inversely related to amylose content. However, the SDS and RS contents were positively correlated with amylose content. During storage of cooked rice, long grain showed a continuous increase in pasting viscosity, while glutinous exhibited the sharp cold‐water swelling peak. The retrogradation rate was greater in rice cultivars with high amylose content. The ratio of 1047/1022 cm^–1 was substantially decreased by cooking and then increased during storage of cooked rice due to the crystalline structure, newly formed by retrogradation. Storage of cooked rice decreased RDS content and increased SDS content in all rice cultivars. However, no increase in RS content during storage was observed. The enthalpy for retrogradation and the intensity ratio 1047/1022 cm^–1 during storage were correlated negatively with RDS and positively with SDS (P ≤ 0.01).     

Investigation of Digestibility In Vitro and Physicochemical Properties of A‐ and B‐Type Starch from Soft and Hard Wheat Flour

In this study, the functional properties of A‐ and B‐type wheat starch granules from two commercial wheat flours were investigated for digestibility in vitro, chemical composition (e.g., amylose, protein, and ash content), gelatinization, retrogradation, and pasting properties. The branch chain length and chain length distribution of these A‐ and B‐type wheat starch granules were also determined using high‐performance anion exchange chromatography (HPAEC). Wheat starches with different granular sizes not only had different degrees of enzymatic hydrolysis and thermal and pasting properties, but also different molecular characteristics. Different amylose content, protein content, and branch chain length of amylopectin in A‐ and B‐type wheat starch granules could also be the major factors besides granular size for different digestibility and other functional properties of starch. The data indicate that different wheat cultivars with different proportion of A‐ and B‐type granular starch could result in different digestibility in wheat products.     

Soft Wheat Starch Pasting Behavior in Relation to A‐ and B‐type Granule Content and Composition

Flours of two soft wheat cultivars were fractionated into native, prime, tailing, A‐, and B‐type starch fractions. Starch fractions of each cultivar were characterized with respect to A/B‐type granule ratio, amylose content, phosphorus level (lysophospholipid), and pasting properties to investigate factors related to wheat starch pasting behavior. While both cultivars exhibited similar starch characteristics, a range of A‐type (5.7– 97.9%, db) and B‐type granule (2.1–94.3%, db) contents were observed across the five starch fractions. Though starch fractions displayed only subtle mean differences (<1%) in total amylose, they exhibited a range of mean phosphorus (446–540 μg/g), apparent amylose (18.7–23%), and lipid‐complexed amylose (2.8–7.5%) values, which were significantly correlated with their respective A‐ and B‐type granule contents. A‐type (compared with B‐type) granules exhibited lower levels of phosphorus, lipid‐complexed amylose, and apparent amylose, though variability for the latter was primarily attributed to starch lipid content. While starch phosphorus and lipid‐complexed amylose contents exhibited negative correlation with fraction pasting attributes, they did not adequately account for starch fraction pasting behavior, which was best explained by the A/B‐type granule ratio. Fraction A‐type granule content was positively correlated with starch pasting attributes, which might suggest that granule size itself could contribute to wheat starch pasting behavior.     

Structure and functional properties of sorghum starches differing in amylose content

Starches were isolated from grains of waxy, heterowaxy, and normal sorghum. To study the relationship between starch structure and functionality and guide applications of these starches, amylose content, amylopectin chain-length distributions, gelatinization and retrogradation, pasting properties, dynamic rheological properties, and in vitro enzyme digestion of raw starches were analyzed. Heterowaxy sorghum starch had intermediate amylose content, pasting properties, and dynamic rheological properties. Stress relaxation was a useful indicator of cooked starch cohesiveness. Cooked heterowaxy sorghum starch (10% solids) had a viscoelastic-solid type of character, whereas cooked waxy sorghum starch behaved like a viscoelastic liquid. Amylopectin of normal sorghum starch had a slightly higher proportion of chains with degree of polymerization (DP) of 6-15 (45.5%) compared with amylopectin of heterowaxy starch (44.1%), which had a gelatinization peak temperature 2 degrees C higher than normal sorghum starch. Heterowaxy sorghum starch contained significantly lower rapidly digestible starch (RDS) and higher resistant starch (RS) than waxy sorghum starch.     

Resistant Starch Content Is Related to Granule Size in Barley

Physical properties of resistant starch (RS) were examined in a range of barley genotypes to determine the contribution of starch and seed physical characteristics to the RS component. Thirty‐three barley genotypes were studied, which varied significantly in their RS, amylose, and starch contents and grain yield. From 33 genotypes, 13 exhibiting high RS were selected for detailed physicochemical analysis of starch. In high‐RS varieties, granule size and number were unimodal, compared with normal starches from a reference genotype, which showed a bimodal distribution. Principal component analysis (PCA) showed that a higher content of granules <15 µm was positively correlated with RS and amylose content, whereas the proportion of granules 15–45 µm was negatively correlated with the RS and amylose contents. Physical fractionation of starches by centrifugation into different population sizes demonstrated that size alone is not an accurate indicator of the population of A‐type and B‐type granules within a given genotype. PCA also showed that large 15–45 µm granules were positively correlated with seed thickness and that thousand grain weight was positively correlated with seed width. High‐RS and high‐amylose genotypes showed variation in overall yield and starch content, with some genotypes showing yield comparable to the reference genotype. Analysis of amylopectin chain length distribution showed that high amylose or RS content was not associated with a higher proportion of amylopectin long chains when compared with either waxy or reference (normal) barley genotypes. This study highlights useful markers for screening barley genotypes with favorable starch characteristics.     

Fine structures and physicochemical properties of starches from chalky and translucent rice kernels

This work compared the molecular structures and physicochemical properties of starches obtained from chalky and translucent kernels of six rice cultivars. Starch samples were prepared according to a modified alkali steeping method. Crystallinity, pasting characteristics, and thermal properties were studied by X-ray diffraction, rapid viscosity analysis, and differential scanning calorimetry, respectively. Starch molecular size fractions (amylopectin, amylose, and intermediate material) were estimated by high-performance size exclusion chromatography, and the chain length profiles of isoamylase-debranched amylopectin were evaluated by high-performance anion-exchange chromatography with pulsed amperometric detection. Starches from chalky kernels contained less amylose (more amylopectin) and more short branch-chain amylopectin (less long branch-chain amylopectin) compared with the translucent kernel starches. Differences in starch structural features significantly correlated with observed variation in grain translucency, starch X-ray diffraction patterns, thermal properties, and pasting characteristics. Starch synthesis in chalky kernels may slightly favor glucan chain branching over chain elongation.     

Effect of Partial Gelatinization and Lipid Addition on α‐Amylolysis of Barley Starch Granules

The effect of partial gelatinization with and without lipid addition on the granular structure and on α‐amylolysis of large barley starch granules was studied. The extent of hydrolysis was monitored by measuring the amount of soluble carbohydrates and the amount of total and free amylose and lipids in the insoluble residue. Similarly to the α‐amylolysis of native large barley starch granules, lipid‐complexed amylose (LAM) appeared to be more resistant than free amylose and amylopectin. Partial gelatinization changed the hydrolysis pattern of large barley starch granules; the pinholes typical of α‐amylase‐treated large barley starch granules could not be seen. Lipid addition during partial gelatinization decreased the formation of soluble carbohydrates during α‐amylolysis. Also free amylose remained in the granule residues and mostly amylopectin hydrolyzed into soluble carbohydrates. These findings indicate that lysophospholipid (LPL) complexation with amylose occurred either during pretreatment or after hydrolysis, and free amylose was now part of otherwise complexed molecules instead of being separate molecules. Partial gelatinization caused the granules to swell somewhat less during heating 2% starch‐water suspensions up to 90°C, and lipid addition prevented the swelling completely. α‐Amylolysis changed the microstructure of heated suspensions. No typical twisting of the granules was seen, although the extent of swelling appeared to be similar to the reference starch. The granules with added LPL were partly fragmented after hydrolysis.     

Molecular Structure and Organization of Starch Granules from Developing Wheat Endosperm

Wheat starches isolated from seeds harvested between 7 and 49 days after anthesis (DAA) were fractionated into large (>8 μm) and small (<8 μm) granules and studied for starch structure and architecture. Starch granules at 7 DAA possessed unimodal size distribution, whereas it was bimodal at later maturity stages. The apparent amylose fraction of starch granules at early maturity (7 and 14 DAA) consisted of intermediate‐type materials, whereas starch at later maturity stages (28 and 49 DAA) contained branched amylose. Wide‐angle X‐ray scattering (WAXS) revealed a well‐developed polymorphic structure already at 7 DAA. Although the presence of a small proportion of B‐type crystallites mixed with A‐type crystallites was observed in the X‐ray diffractogram of starches at early maturation (7 and 14 DAA), it was masked by the A‐type crystallites at later maturity stages. However, the large granules had a higher proportion of B‐type crystallites and lower relative crystallinity (RC) than their small‐granule counterpart. The iodine absorption properties of the starch granules demonstrated different levels of mobility of the starch polymers at different stages of maturity and the mobility of more glucan polymers in the large granule population compared with the small granules at the same maturity stage. Iodine did not change the characteristic A‐type crystalline pattern of starch, but it increased RC. Changes in peak width at half height based on WAXS data further suggested the possible interaction of iodine with amylopectin intercluster chain segments and branch chains in formation of inclusion complexes.     

Mechanism and enzymatic contribution to in vitro test method of digestion for maize starches differing in amylose content

To determine the rapidly digestible starch (RDS), slowly digestible starch (SDS), and resistant starch (RS) contents in a starch sample, the addition of amyloglucosidase is often used to convert hydrolyzates from α-amylase digestion to glucose. The objectives of this study were to investigate the exact role of amyloglucosidase in determining the digestibility of starch and to understand the mechanism of enzymatic actions on starch granules. Four maize starches differing in amylose content were examined: waxy maize (0.5% amylose), normal maize (≈27% amylose), and two high-amylose starches (≈57 and ≈71% amylose). Notably, without amyloglucosidase addition, the RS content increased from 4.3 to 74.3% for waxy maize starch, 29.7 to 76.5% for normal maize starch, 65.8 to 88.0% for starch with 57% amylose, and 68.2 to 90.4% for the starch with 71% amylose. In the method without α-amylase addition, less RS was produced than without added amyloglucosidase, except in maize at 71% amylose content. Scanning electron microscopy (SEM) revealed the digestive patterns of pinholes with α-amylase and burrowing with amyloglucosidase as well as the degree of digestion between samples. To understand the roles of amyloglucosidase and α-amylase in the in vitro test, multiple analytical techniques including gel permeation chromatography, SEM, synchrotron wide-angle X-ray diffraction, and small-angle X-ray scattering were used to determine the molecular and crystalline structure before and after digestion. Amyloglucosidase has a significant impact on the SDS and RS contents of granular maize starches.     

水稻心白突变体xb1的淀粉理化特性分析

淀粉是稻米胚乳的主要成分,解析其理化特性对改良水稻品质具有十分重要的意义。为了探究心白稻米淀粉的理化特性,本研究以经EMS诱导粳稻品种辽星1号获得的心白突变体xb1为材料,利用扫描电镜、激光粒度分析仪、RVA快速黏度分析仪、差示扫描量热仪等方法,对形态结构、淀粉颗粒结构和粒径分布、糊化特性及热力学特性等进行了分析。结果表明,与野生型相比,突变体xb1籽粒的粒宽、粒厚和千粒重均显著降低;淀粉结构和淀粉粒粒径分布均发生改变,淀粉粒粒径值大于13左右的淀粉粒数量明显低于野生型;突变体种子中蛋白质含量极显著高于野生型,总淀粉含量极显著低于野生型,而直链淀粉含量没有明显改变;在支链淀粉分支结构上,聚合度(DP)在6~9之间的短链及25~35之间的中长链比例有所增加,而DP值在10~24之间的中短链及36~50之间的长链比例有所减少;突变体xb1淀粉的糊化起始温度(To)、峰值温度(Tp)、终止温度(Tc)和糊化距离(Tr)均未发生明显改变,只有热焓值(△H)极显著提高。同时,突变体xb1的RVA谱特征值中,热浆黏度(HPV)、峰值黏度(PKV)、冷胶黏度(CPV)和消减值(SBV)极显著提高,崩解值(BDV)和回复值(CSV)极显著降低。本研究结果为探索垩白形成的生理机制以及进一步的基因克隆奠定了基础。     

Methods for Characterization of Residual Starch in Distiller's Dried Grains with Solubles (DDGS)

The objective of this study was to establish methods for determining the content and components of residual starch in distiller's dried grains with solubles (DDGS), a coproduct from dry‐grind corn ethanol production. Four DDGS prepared in our laboratory and one DDGS obtained from a commercial ethanol manufacturer were used for the study. Quantitative analysis of total residual sugar (TRS) in DDGS was performed by determining d ‐glucose produced by enzymatic hydrolysis of oligosaccharides and residual starch remaining in hexane‐defatted DDGS after being dispersed in 90% DMSO. The TRS consisted of free glucose, oligosaccharides, and residual starch. The commercial manufacturer's DDGS contained more TRS (15.8%, w/w db) than the laboratory‐processed DDGS (2.4–2.9%, w/w db). The content of residual starch remaining in the commercial DDGS (5.5% w/w db) was also larger than the laboratory‐processed DDGS (1.9–2.5% w/w db). Analyses of molecular weight distribution showed that the residual starch in DDGS consisted of short‐chain amylose and amylopectin, respectively, as the major and minor components. The short‐chain amylose molecules constituted 86.5–94.1% of the residual starch. The major population of the short‐chain amyloses had an average degree of polymerization (DP) of 85, closely resembling the length of enzyme‐resistant fragments of amylose‐lipid complexes.     

Effects of Growing Environment on Properties of Starch from Five Australian Wheat Varieties

The effects of growing conditions on properties of starch from wheat grain were examined. Growing conditions affected starch and amylose content, granule size distribution, protein associated with starch granules, and starch swelling power in grains from five commercial Australian milling wheat varieties grown at multiple locations in two years in crop production systems. Soil nitrogen and meteorological conditions were major contributors to variability in grain yield and grain protein and starch contents. The volume proportion of B‐granules was positively affected by warmer temperatures before flowering but negatively correlated with high temperatures during grain filling. Genotype was the main source of variability in the proportion of B‐granules and granule dimensions, starch‐granule proteins, and starch swelling power, although there were also significant contributions to variability from the growing conditions. Seasonal effects and interactions between genotype and season and location were significant sources of variability in amylose content, proportion of short chains of amylopectin, and flour swelling power. The positive relationships between starch content and the number of clear days and atmospheric temperatures before flowering indicate that conditions that enhance accumulation of assimilates before anthesis influence the deposition of reserves in developing grain.     

Determining the Role of Starch in Flour Tortilla Staling Using α‐Amylase

Effects of α‐amylase modification on dough and tortilla properties were determined to establish the role of starch in tortilla staling and elucidate the antistaling mechanism of this enzyme. Control and amylase‐treated tortillas were prepared using a standard bake test procedure, stored at 22°C, and evaluated over four weeks. Amylase improved shelf‐stability of tortillas. The enzyme also produced a significant amount of dextrins and sugars, decreased loss of amylose solubility, and weakened starch granules. Amylopectin crystallinity increased with time, but was similar for the control and treated tortillas. Staling of tortillas appears to mainly involve the starch in the amorphous phase. As such, amylase activity does not significantly interfere with amylopectin crystallization. It is proposed that amylase partially hydrolyzed the dispersed starch (i.e., mostly amylose), starch bridging the crystalline region, and protruding amylopectin branches. Starch hydrolysis decreases the rigid structure and plasticized polymers during storage. The flexibility of tortillas results from the combined functionalities of the amylose gel and amylopectin solidifying the starch granules during storage. Protein functionality may also be involved in tortilla staling, but this needs further research.