Analysis of the early stages of lipid oxidation in freeze-stored pork back fat and mechanically recovered poultry meat

An analytical method that can detect low levels of oxidation in food earlier than a sensory panel would be a valuable tool for food manufacturers as well as research institutes. Two model matrixes, pork back fat and mechanically recovered poultry meat (MRPM), were freeze-stored in air at -20 degrees C for 26 weeks. Peroxide value, thiobarbituric acid reactive substances, volatiles analyzed with dynamic headspace gas chromatography-mass spectrometry (GC-MS) and a gas-sensor array technique (electronic nose), chemiluminescence, and front-face fluorescence were evaluated against sensory analysis with regard to detection of early oxidation and correlation with sensory data. Fluorescence and GC-MS could detect oxidative changes in pork back fat earlier than the sensory panel and the electronic nose at the same time. The three methods were highly correlated with sensory attributes (r = 0.8-0.9). GC-MS gave the best results with regard to detection of small oxidative changes in MRPM.     

Inhibition of lipid oxidation in pork bundles processing by superheated steam frying

The effect of superheated steam treatment on the oxidative stability of lipids in packaged Zousoon (pork bundles) was investigated. The aroma quality of Zousoon samples was evaluated by sensory analysis and chromatographic analysis of volatiles. Results of this study indicated that oxidation of lipids occurred in pan-fried Zousoon after prolonged storage. Significant amounts of highly volatile compounds such as formaldehyde, acetaldehyde, acetone, and hexanal in Zousoon were identified by a modified method of cysteamine derivatization followed by gas chromatography-mass spectrometry (GC-MS) analysis. Superheated steam was found to be effective in suppressing lipid oxidation in canned Zousoon as compared with Zousoon fried by the conventional method in a frying pan. The superheated steam-fried samples had relatively low thiobarbituric acid reactive substance (TBARS) and peroxide (POV) values before and after storage, whereas samples prepared by pan frying had relatively high TBARS and POV values before and after storage. Superheated steam-fried Zousoon had superior lipid stability to that prepared by the conventional pan-frying method.     

Efficiency of DNA typing methods for detection of smoked paprika "pimenton de la vera" adulteration used in the elaboration of dry-cured Iberian pork sausages

The purpose of this work was to develop a PCR method for the identification of smoked paprika "Pimento?n de la Vera" adulteration with paprika elaborated from varieties of pepper foreign to the la Vera region, in central western Spain. Three autochthonous varieties of pepper, Jaranda, Jariza, and Bola, and the varieties Papri Queen, Papri King, Sonora, PS9794, and Papri Ace, foreign to the La Vera region, were used in the study. Analyses of the ITS and 5.8S rDNA, RAPD-PCR, SSR, and ISSR were tested. RAPD-PCR, SSR, and ISSR analyses allowed differentiation among the varieties of paprika analyzed. There was no difference in the sequence of ITS1-5.8S rDNA-ITS2. In addition, with the RAPD-PCR primers S13 and S22, two molecular markers were obtained of 641 and 704 bp, respectively, which allowed all of the smoked paprika varieties to be differentiated from paprikas elaborated with the five foreign varieties. These two molecular markers were investigated as a basis for detecting the adulteration of smoked paprika with paprika elaborated from foreign varieties of pepper.     

Effect of plant phenolics on protein and lipid oxidation in cooked pork meat patties

Rapeseed and pine bark are rich sources of phenolic compounds that have in previous studies been shown to exhibit antioxidant and anti-inflammatory properties. In this study, the antioxidant effect of rapeseed and pine bark phenolics in inhibiting the oxidation of lipids and proteins in meat was tested as a possible functional food application. The cooked pork meat with added plant material was oxidized for 9 days at 5 degrees C under light. The suitable level of plant material addition was first screened by following lipid oxidation only. For further investigations plant materials were added at a level preventing lipid oxidation by >80%. The oxidation was followed by measuring the formation of hexanal by headspace gas chromatography and the formation of protein carbonyls by converting them to 2,4-dinitrophenylhydrazones and measured by spectrophotometer. It was shown that rapeseed and pine bark were excellent antioxidants toward protein oxidation (inhibitions between 42 and 64%). These results indicate that rapeseed and pine bark could be potential sources of antioxidants in meat products.     

柑橘幼果提取物对猪肉冷藏过程中抗脂质氧化影响

为了研究不同浓度的柑橘幼果乙醇提取物（CE）在新鲜猪肉中的抗脂质氧化和抑菌作用。在冷藏（4℃）条件下对鲜猪肉进行以下5种处理：对照组（不添加保鲜剂）;AC-0.02（添加0.02%抗坏血酸）;CE-0.05（添加0.05%柑橘幼果醇提物,下同）,CE-0.1和CE-0.2。在12 d的冷藏（4℃）过程中,各样品的pH值均显著降低（p＜0.05）,而硫代巴比妥酸值（TBARS）和游离脂肪酸的含量显著增加（p＜0.05）。CE-0.1和CE-0.2处理组的菌落总数在贮藏过程中均低于对照组。CE的加入使猪肉样品的L*值和a*值都显著下降,在贮藏过程中,CE处理组样品的b*值均高于对照组,且随着CE浓度的增加,b*值增大。5组试验样品中,经CE-0.2处理的样品TBARS值和游离脂肪酸含量最低;对照组的过氧化值在第6天达到最大值,随后逐渐减小,而其它处理组的过氧化值在储藏期间均呈上升趋势。在贮藏1 d后,各处理组中的共轭二烯值均小于对照组。结果表明,柑橘幼果醇提物可作为肉制品的保鲜剂,能有效抑制新鲜猪肉贮藏过程中的脂质氧化和腐败微生物的生长。为开发柑橘幼果天然提取物保鲜剂提供理论参考。     

Detection of poultry and pork in cooked and canned meat foods by enzyme-linked immunosorbent assays

Enzyme-linked immunosorbent assays (ELISA) are described for the detection of poultry and pork in cooked and canned meat foods. These assays are based on species-specific, polyclonal antibodies raised against heat-resistant antigens. The heat-resistant antigens were isolated from raw skeletal muscle tissue of pork and chicken and were found to be immunoreactive even after heating to 120 degrees C for 15 min. The poultry ELISA could detect chicken or turkey at the 126 ppm level, and the pork ELISA could detect pork at the 250 ppm level. Samples of frankfurters, bolognas, pressed meats, canned baby foods, and canned spreads were prepared by simple aqueous extractions.     

Comparative analysis of different hemoglobins: autoxidation,reaction with peroxide,and lipid oxidation

Beef hemoglobin (Hb) had lower levels of deoxyHb and autoxidized much slower as compared to trout Hb at pH 6.3. Chicken Hb autoxidized at a rate intermediate between beef and trout Hb. In the presence of hydrogen peroxide, metHb formed rapidly from trout Hb whereas beef Hb was essentially nonreactive with hydrogen peroxide. The autoxidation rate of perch Hb was more rapid than trout Hb despite the low deoxyHb content of perch Hb. Perch Hb was a better catalyst of lipid oxidation than trout Hb when added to washed cod muscle based on formation of lipid hydroperoxides and thiobarbituric acid reactive substances. These studies indicate that autoxidation rate does not always increase with increasing deoxyHb content. The role of heme crevice volume in heme protein autoxidation is discussed. Among other factors, these studies suggest that rates of lipid oxidation in various muscle foods may depend on the relative ability of hemoglobins from different animal species to promote lipid oxidation.     

Effects of released iron, lipid peroxides, and ascorbate in trout hemoglobin-mediated lipid oxidation of washed cod muscle

Approximately 7% of the iron associated with hemoglobin was released from the heme protein during 2 degrees C storage in washed cod muscle. EDTA (2.2 mM) neither accelerated nor inhibited hemoglobin-mediated lipid oxidation based on the formation of lipid peroxides and TBARS. This suggested that low molecular weight iron was a minor contributor to hemoglobin-mediated lipid oxidation in washed cod muscle. Ascorbate (2.2 mM) was a modest to highly effective inhibitor of hemoglobin-mediated lipid oxidation depending on which washed cod preparation was assessed. Experimental evidence suggested that the ability of residual ascorbate to breakdown accumulating lipid hydroperoxides to reactive lipid radicals can explain the shift of ascorbate from an antioxidant to a pro-oxidant. Increasing the lipid peroxide content in washed cod muscle accelerated hemoglobin-mediated lipid oxidation and decreased the ability of ascorbate to inhibit lipid oxidation. Preformed lipid peroxide content in cod muscle was highly variable from fish to fish.     

Short-term N availability in response to dissolved-organic-carbon from poultry manure, alone or in combination with cellulose

 Short-term changes in N availability in a sandy soil in response to the dissolved organic carbon (DOC) from a poultry manure (application rate equivalent to approximately 250 kg N ha^–1) were evaluated in a 44-day aerobic incubation experiment. The treatments included poultry manure alone and two treatments in which an extra source of C, of low water solubility, was added with the poultry manure in the form of a low (1.05 g kg^–1) and a high (4.22 g kg^–1) amount of cellulose. All treatments were fertilised with the equivalent of 60 kg N ha^–1 of (¹⁵NH₄)₂SO₄ in solution. A control treatment consisted of sieved field-moist soil plus 60 kg N ha^–1 of (¹⁵NH₄)₂SO₄ in solution. Measurements were made of N₂O and CO₂ emissions, inorganic N, DOC, biomass N, biomass C and labelled N contained in the inorganic N and biomass N pools. The dynamics of N turnover in this study were driven mainly by processes of mineralisation–immobilisation with little significant loss of N by volatilisation or denitrification. The DOC supplied with the poultry manure played a more important role in N₂O emissions than differences in C/N ratio. Changes in DOC and cumulative CO₂-C production during the first 11 days were also highly correlated (R ²=0.88–0.66, P<0.01). An initial net immobilisation of N, with significant increases in biomass C and biomass N (P<0.05) for all treatments over the control at day 11, indicated a high availability of C from the DOC fraction. The presence of additional C from the applied cellulose did not enable a massive N immobilisation. Total inorganic N and unlabelled inorganic N concentrations were highest in soils treated with poultry manure alone (P<0.05), indicating that an active gross mineralisation of the added poultry manure and a possible positive priming effect were taking place during the incubation. Received: 29 May 1998     

Effects of sterol structure, temperature, and lipid medium on phytosterol oxidation

Factors contributing to the oxidative stability of phytosterols were studied. Unsaturated stigmasterol and saturated sitostanol were used as model compounds and were heated at different temperatures in different lipid matrices for various periods of time. Accumulations of the major secondary oxidation products were used as a marker of the stability of heated compounds, and the products were analyzed by gas chromatography-mass spectrometry. The results showed that both temperature and heating time, as well as sterol structure and lipid matrix composition, affected phytosterol oxidation. In particular, the interactions between different lipid matrices and temperatures had drastic effects on the total contents of the phytosterol oxides formed and also on the reaction pathways of oxidation. During heating at high temperatures for prolonged periods, >20% of stigmasterol was oxidized. At moderate temperatures the oxidation of stigmasterol was rather slow. Sitostanol oxide contents were low under all heating conditions studied.     

Heterogeneous aspects of lipid oxidation in dried microencapsulated oils

This work was aimed at studying lipid oxidation in dried microencapsulated oils (DMOs) during long-term storage. Samples were prepared by freeze-drying of emulsions containing sodium caseinate and lactose as encapsulating components. Evaluation of lipid oxidation was approached by quantitative analysis of nonvolatile lipid oxidation products and tocopherol. Lipid oxidation products were analyzed by separation of polar compounds by adsorption chromatography followed by HPSEC with refraction index detection for quantitation of oxidized triglyceride monomers, dimers, and oligomers. The analytical method applied enabled the detection of different oxidative patterns between the free and encapsulated oil fractions. The free oil fraction of DMOs showed a typical oxidative pattern for oils in continuous phase, which consisted of a clear induction period, in which hydroperoxides (oxidized triglyceride monomers) accumulated, before oxidation accelerated. The end of the induction period was marked by the total loss of tocopherol and the initiation of polymerization. On the contrary, the encapsulated oil showed a pattern characteristic of a mixture of oils with different oxidation status. Thus, high contents of advanced oxidation compounds (polymerization compounds) were detected when the antioxidant (tocopherol) was still present in high amounts. It is concluded that the encapsulated oil was comprised of oil globules with very different oxidation status. The results obtained in this study gave evidence of heterogeneous aspects of lipid oxidation in a dispersed-lipid food system.     

Temperature effect on lactose crystallization, maillard reactions, and lipid oxidation in whole milk powder

Whole milk powder with an initial water content of 4.4% (w/w) and a water activity of 0.23 stored in hermetically sealed vials for up to 147 days below (37 and 45 degrees C) and above (55 degrees C) the glass transition temperature (T(g) determined to have the value 48 degrees C) showed a strong temperature dependence for quality deterioration corresponding to energies of activation close to 200 kJ/mol for most deteriorative processes. The glass transition was found not to cause any deviation from Arrhenius temperature dependence. Lactose crystallization, which occurred as a gradual process as monitored by isothermal calorimetry, is concluded to liberate bound water (a(w) increase to 0.46) with a modest time delay (approximately 2 days at 55 degrees C) and with concomitant surface browning as evidenced by an increasing Hunter b-value. Browning and formation of bound hydroxymethyl-furfural determined by HPLC seem to be coupled, while formation of another Maillard reaction product, furosine, occurred gradually and was initiated prior to crystallization. Initiation of lipid oxidation, as detected by lipid-derived radicals (high g-value ESR spectra), and progression of lipid oxidation, as detected by headspace GC, seem not to be affected by lactose crystallization and browning, and no indication of browning products acting as antioxidants could be determined.     

Electron spin resonance spin trapping for analysis of lipid oxidation in oils: inhibiting effect of the spin trap alpha-phenyl-N-tert-butylnitrone on lipid oxidation

The electron spin resonance (ESR) spin trapping technique was investigated as an analytical approach to follow lipid oxidation of rapeseed oil, sunflower oil, and fish oil during storage at 40 degrees C. Unlike previous investigations, alpha-phenyl-N-tert-butylnitrone (PBN), used as spin trap, was added to the fresh oils and formation of radicals was monitored during storage. Results were compared with the development in peroxide value (PV) and the thiobarbituric acid index (TBA). Increasing radical development was detected during the initial stages of oxidation, during which no significant changes in PV and TBA were observed. Evidence of spin adduct depletion was found during prolonged storage, suggesting that although spin trapping of radicals may be used to follow early events in lipid oxidation, it is not a suitable parameter for long periods of time. Addition of the spin trap after sequential samplings is recommended for getting an insight of oxidative changes during storage. Further, the influence of the spin trap (PBN) on lipid oxidation was studied in detail by application of PV and TBA and by following the depletion of naturally occurring tocopherol. PBN was found to possess a profound inhibiting effect on lipid oxidation. Such an effect was found to be dependent on the nature of the oil, and it was observed that the lower the oxidative stability, the larger the effect of PBN on lipid oxidation. This effect was interpreted in terms of the capability of PBN to react with peroxyl radicals, which in turn depends on the initial tocopherol content of the oils.     

Role of lipid oxidation, chelating agents, and antioxidants in metallic flavor development in the oral cavity

This study investigated the production of metallic flavor, which is a combination of taste and retronasal odor. Chemical reactions in the oral cavity and saliva of healthy subjects were investigated after ingesting iron and copper solutions above and near threshold levels. Significant increase in lipid oxidation (p < 0.001) occurred after metal ingestion, detected as TBARS values. Ferrous ion caused the greatest flavor sensation and lipid oxidation, followed by cupric and cuprous ions. Ferric ion did not cause metallic sensation. Occurrence of oxidation was supported by damage to salivary proteins, detected as protein-carbonyls, and by a significant increase of odorous lipid oxidation related aldehydes. Sensory evaluation demonstrated that antioxidants (vitamins E and C) minimally reduced metallic flavor but that chelating agents (EDTA and lactoferrin) removed the metallic flavor. The role of lipid oxidation is essential for the production of a metallic flavor from ingestion of ferrous, cupric, and cuprous ions.     

Lipid oxidation in a chicken muscle model system: oxidative response of lipid classes to iron ascorbate or methemoglobin catalysis

Catalysis by iron ascorbate and activated methemoglobin generated different oxidative responses in chicken muscle model systems. In iron ascorbate systems, large increases in hydroperoxides and thiobarbituric acid-reactive substances (TBARS) occurred during the initial stage of incubation. Thereafter, iron ascorbate catalysis led to a slow increase in the oxidation of triacylglcyerol (TG) and sarcoplasmic reticulum (SR) membrane lipids. By the end of incubation, 24, 36, and 32% of the initial content of n-3 fatty acids in free fatty acids, TG, and SR single-lipid model systems catalyzed by iron ascorbate had been lost. Reduced losses of n-3 fatty acids were observed in the SR and TG fractions (0 and 24%, respectively) when iron ascorbate model systems contained all three lipid fractions (mix). Hydroperoxides and TBARS in model systems catalyzed by activated methemoglobin were characterized by a lag phase during most of the incubation. Consistent with their role as antioxidants, losses of alpha-tocopherol (42-49%), gamma-tocopherol (36-42%), and protein sulfhydryls (41-52%) were observed in model systems catalyzed by activated methemoglobin. SR and mix model systems were 30-50% slower to oxidize than TG model systems when activated methemoglobin served as the catalytic agent.     

Collaborative study of a method for the extraction of light filth from whole, cracked, or flaked and ground spices.

An improved method has been developed for the extraction of light filth from whole, cracked, or flaked spices (basil, bay leaves, clery leaves, chervil, chives, dill weed, mint flakes, parsley, rosemary, sage, tarragon, thyme, and vegetable flakes) and from ground spices (cloves, cumin, marjoram, mustard seed, oregano, sage, and thyme). The method involves a chloroform or isopropanol defatting, followed by a direct flotation from 40% isopropanol with Tween 80-EDTA (1+1) and mineral oil-heptane (85+15). Collaborative results show that the proposed method is more rapid to perform and yields better filth recoveries than the official first action methods for ground spices, 44.116, and whole, cracked, or flaked spices, 44.129. The method has been adopted as official first action.     

Ability of lipid hydroperoxides to partition into surfactant micelles and alter lipid oxidation rates in emulsions

Lipid hydroperoxides are important factors in lipid oxidation due to their ability to decompose into free radicals. In oil-in-water emulsions, the physical location of lipid hydroperoxides could impact their ability to interact with prooxidants such as iron. Interfacial tension measurements show that linoleic acid, methyl linoleate, and trilinolein hydroperoxides are more surface-active than their non-peroxidized counterparts. In oil-in-water emulsion containing surfactant (Brij 76) micelles in the continuous phase, linoleic acid, methyl linoleate, and trilinolein hydroperoxides were solubilized out of the lipid droplets into the aqueous phase. Brij 76 solubilization of the different hydroperoxides was in the order of linoleic acid > trilinolein > or = methyl linoleate. Brij 76 micelles inhibited lipid oxidation of corn oil-in-water emulsions with greater inhibition of oxidation occurring in emulsions containing linoleic acid hydroperoxides. Surfactant solubilization of lipid hydroperoxides could be responsible for the ability of surfactant micelles to inhibit lipid oxidation in oil-in-water emulsions.     

Evaluation of lipid ultraviolet absorption as a parameter to measure lipid oxidation in dark chicken meat

The application of lipid UV absorption (235, 269, and 280 nm) to follow up lipid oxidation in dark chicken meat has been evaluated using raw and cooked samples with different alpha-tocopherol contents (modulated by dietary supplementation). To this purpose, when absorption was measured at 235 nm, second-derivative spectrophotometry did not show any significant advantage over nonderivative spectrophotometry. For absorption at 269 and 280 nm, nonderivative spectrophotometry more sensitively monitored lipid oxidation than second- and third-derivative spectrophotometry. In addition, only direct measurements at 235 and 269 nm and second-derivative measurements at 235 nm showed a limited usefulness to follow up lipid oxidation in our samples. However, these UV absorption parameters were much less effective than lipid hydroperoxide values measured through a ferrous oxidation-xylenol orange method and 2-thiobarbituric acid values determined by a third-derivative spectrophotometric method with acid aqueous extraction.     

Effects of alpha-tocopherol, beta-carotene, and soy isoflavones on lipid oxidation of structured lipid-based emulsions

Structured lipids (SLs) are triacylglycerols that have been modified to change the fatty acid composition and/or positional distribution in the glycerol backbone by chemically and/or enzymatically catalyzed reactions and/or genetic engineering. Ten percent oil-in-water emulsions were formulated with a canola oil/caprylic acid SL and stabilized with 0.5% whey protein isolate (WPI) or sucrose fatty acid ester (SFE). The effects of alpha-tocopherol, beta-carotene, genistein, and daidzein (added at 0.02 wt % of oil) on lipid oxidation were evaluated over a 15-day period in emulsion samples. Significantly (p < 0.05) less total oxidation (calculated from peroxide value and anisidine value measurements) occurred in the WPI emulsions compared to their SFE counterparts. In this study, alpha-tocopherol, beta-carotene, and both soy isoflavones exhibited prooxidant activities in SFE emulsions. Because of their ability to exhibit prooxidant activity under certain conditions, manufacturers must experiment with these compounds before adding them to SL-based products as functional ingredients.