Acrylamide in French fries: influence of free amino acids and sugars

The free amino acid profile and sugar (fructose, glucose, and sucrose) composition were determined in potato samples selected to give a large range of variation (a total of 66 samples). From these samples French fries were produced in a laboratory-scale simulation of an industrial process followed by a finish fry at 180 degrees C for 3.5 min using a restaurant fryer. The final product was blast frozen and analyzed for acrylamide. Acrylamide was detected in all samples, but its concentration varied significantly from 50 to 1800 ng/g. For isotope dilution (13C3) acrylamide analysis, samples were extracted with water, cleaned up on HLB Oasis polymeric and Accucat mixed mode anion and cation exchange SPE columns, and analyzed by LC-MS/MS. Statistical analysis of the data indicates that the effect of sugars and asparagine on the concentration of acrylamide in French fries is positive and significant (p < 0.001). It appears that one of the ways acrylamide formation in French fries can be effectively controlled is by the use of raw products with low sugar (and to a lesser degree, asparagine) content.     

Development of stable isotope dilution assays for the simultaneous quantitation of biogenic amines and polyamines in foods by LC-MS/MS

Microbial amino acid metabolism may lead to substantial amounts of biogenic amines in either spontaneously fermented or spoiled foods. For products manufactured with starter cultures, it has been suggested that certain strains may produce higher amounts of such amines than others; however, to support efforts of food manufacturers in mitigating amine formation, reliable methods for amine quantitation are needed. Using 10 isotopically labeled biogenic amines as the internal standards, stable isotope dilution assays were developed for the quantitation of 12 biogenic amines and of the 2 polyamines, spermine and spermidine, in one LC-MS/MS run. Application of the method to several foods revealed high concentrations of, for example, tyramine and putrescine in salami and fermented cabbage, whereas histamine was highest in Parmesan cheese and fermented cabbage. On the other hand, ethanolamine was highest in red wine and Parmesan cheese. The results suggest that different amino acid decarboxylases are active in the respective foods depending on the microorganisms present. The polyamine spermine was highest in salami and tuna.     

Addition of antioxidant of bamboo leaves (AOB) effectively reduces acrylamide formation in potato crisps and French fries

The present study was to demonstrate the efficiency of antioxidant of bamboo leaves (AOB) on the reduction of acrylamide during thermal processing and to summarize the optimal level of AOB applied in potato-based products. Potato crisps and French fries were immersed into different contents of AOB solution, and the frying processing parameters were optimized. The acrylamide content was determined by liquid chromatography-tandem mass spectrometry (LC-MS/MS). The sensory evaluation was performed in double blind manner. Our results showed that nearly 74.1% and 76.1% of acrylamide in potato crisps and French fries was reduced when the AOB addition ratio was 0.1% and 0.01% (w/w), respectively. The maximum inhibitory rate was achieved when the immersion time was designed as 60 s. Sensory evaluation results showed that the crispness and flavor of potato crisps and French fries processed by AOB solution had no significant difference compared to normal potato matrixes (P > 0.05) when the AOB addition ratio was <0.5% (w/w). These results suggested that AOB could significantly reduce acrylamide formation in potato-based foods and keep original crispness and flavor of potato matrixes. This study could be regarded as a pioneer contribution on the reduction of acrylamide in various foods by natural antioxidants.     

Development of two stable isotope dilution assays for the quantitation of acrolein in heat-processed fats

Two stable isotope dilution assays were developed for the quantitation of acrolein in fats and oils using [(13)C(3)]-acrolein as the internal standard. First, a direct GC-MS headspace method, followed by an indirect GC-MS method using derivatization with pentafluorophenyl hydrazine, was established. Analysis of six different types of oils varying in their pattern of fatty acids showed significant differences in the amounts of acrolein formed after heating at various temperatures and for various times. For example, after 24 h at 140 °C, coconut oil contained 6.7 mg/kg, whereas linseed oil was highest with 242.3 mg/kg. A comparison of the results showed that the extent of acrolein formation seemed to be correlated with the amount of linolenic acid in the oils. Although the acrolein concentrations were lowered in all six oils after frying of potato crisps, linseed and rapeseed oil still contained the highest amounts of acrolein after frying. By applying both methods on different thermally treated fats and oils, nearly identical quantitative data were obtained.     

Acrylamide in foods: occurrence,sources, and modeling

Acrylamide in food products-chiefly in commercially available potato chips, potato fries, cereals, and bread-was determined by liquid chromatography-tandem mass spectrometry (LC-MS/MS). Samples were homogenized with water/dichloromethane, centrifuged, and filtered through a 5 kDa filter. The filtrate was cleaned up on mixed mode, anion and cation exchange (Oasis MAX and MCX) and carbon (Envirocarb) cartridges. Analysis was done by isotope dilution ([D(3)]- or [(13)C(3)]acrylamide) electrospray LC-MS/MS using a 2 x 150 mm (or 2 x 100 mm) Thermo HyperCarb column eluted with 1 mM ammonium formate in 15% (or 10% for the 2 x 100 mm column) methanol. Thirty samples of foods were analyzed. Concentrations of acrylamide varied from 14 ng/g (bread) to 3700 ng/g (potato chips). Acrylamide was formed during model reactions involving heating of mixtures of amino acids and glucose in ratios similar to those found in potatoes. In model reactions between amino acids and glucose, asparagine was found to be the main precursor of acrylamide. Thus, in the reaction between nitrogen-15 (amido)-labeled asparagine and glucose, corresponding (15)N-labeled acrylamide was formed. The yield of the model reaction is approximately 0.1%.     

Development of a stable isotope dilution assay for the quantification of 5-methyl-(E)-2-hepten-4-one: application to hazelnut oils and hazelnuts.

A stable isotope dilution assay was developed for the quantitation of the hazelnut odorant 5-methyl-(E)-2-hepten-4-one by mass chromatography using synthesized [(2)H](2)-5-methyl-(E)-2-hepten-4-one as the internal standard. Application of the method on two batches of commercial hazelnut oils, processed from either roasted or unroasted nuts, revealed 6.4 microg 5-methyl-(E)-2-hepten-4-one per kg of unroasted oil whereas 315.8 microg per kg was determined in the roasted nut oil. The about 50-fold higher amount of 5-methyl-(E)-2-hepten-4-one in roasted hazelnut oil suggested the necessity of a thermal treatment to generate the flavor compound. Pan frying of raw hazelnuts (9 to 15 min) or boiling of the crushed nut material for 1 h in water led to an increase of 5-methyl-(E)-2-hepten-4-one by factors of 600 and 800, respectively, thereby corroborating that the major part of the nut flavorant is formed during heat treatment from a yet unknown precursor in hazelnuts.     

Quantification of free coumarin and its liberation from glucosylated precursors by stable isotope dilution assays based on liquid chromatography-tandem mass spectrometric detection

A stable isotope dilution assay for the quantification of free coumarin and glucosylated coumarin precursors has been developed using [13C2]-coumarin as the internal standard. The doubly labeled coumarin was synthesized by reacting [13C2]-acetic anhydride with salicylic aldehyde and characterized by means of mass spectrometry and nuclear magnetic resonance (NMR) experiments. The specifity of liquid chromatography-tandem mass spectrometry enabled unequivocal determination and sensitive quantitation of the odorant. Because of the very simple extraction procedure, free coumarin could be analyzed within 1h. For quantification of total coumarin, the odorant was liberated from its precursors by an incubation with hydrochloric acid or beta-glucosidase. In analyses of breakfast cereals, the intra-assay coefficient of variation was 9.9% ( n = 5) for total coumarin. When coumarin was added to butter cookies at a level of 10 microg/kg, a recovery of 94.1% was found. Further addition studies revealed a detection limit of 2.9 microg/kg and a quantification limit of 8.6 microg/kg. Application of the stable isotope dilution assay to several plants, foods, and essential oils revealed high contents in cassia products and those foods in which cassia has been used as an ingredient. In contrast to this, Ceylon cinnamon contained much less coumarin. The odorant was also quantified in woodruff, clover seeds, and the essential oils of lavender, citron, and chamomile. Only trace amounts were detected in carrots and the essential oils of peppermint and dill, whereas in bilberries, black raspberries, and Angelica roots, coumarin was below detectable levels. In Ceylon cinnamon and cassia, the odorant occurred mainly in its free form, whereas in fenugreek seeds and woodruff, 68 and 88% of the total coumarin content was liberated from glucosylated precursors, respectively.     

Quantitation of Amines in Cereal Products: Thermal Processes Are Able to Generate “Biogenic” Amines

On the basis of a derivatization with dansyl chloride prior to LC‐MS/MS measurement, a new quantitation method by means of stable isotope dilution analysis was developed for different amines, such as 2‐ and 3‐methylbutylamine, methylpropylamine, and 2‐phenylethylamine. The method was applied both to different cereal products and to a model system, revealing that the amines stemming from the parent amino acids l ‐isoleucine, l ‐leucine, l ‐valine, and l ‐phenylalanine can also be generated by a “thermogenic” pathway besides the well‐established enzymatic formation. A model system simulating the Strecker reaction by heating single amino acids with an α‐dicarbonyl compound (2‐oxopropanal) showed besides the formation of the well‐known desired aroma‐active Strecker aldehydes also the generation of the corresponding Strecker amines, which are undesired in food due to their negative physiological impacts on human health. Thus, a thermal formation of “biogenic” amines was shown, both in cereal‐based foods and in a model system. A contribution of these amines to the overall food aroma is also possible. With this knowledge at hand, mitigation strategies for the formation of amines undesired for health reasons in parallel with a favored generation of the corresponding aroma‐active aldehydes, depending on the processing parameters, can be suggested to food manufacturers.     

Concentrations of total glutathione and cysteine in wheat flour as affected by sulfur deficiency and correlation to quality parameters

A method for the simultaneous quantitation of total glutathione and total cysteine in wheat flour by a stable isotope dilution assay using high-performance liquid chromatography/tandem mass spectrometry (HPLC-MS/MS) was developed. As internal standards, L-[(13)C3, (15)N]cysteine and L-gamma-glutamyl-L-[(13)C3, (15)N]cysteinyl-glycine were used. The method consisted of the extraction and reduction of flour with tris(2-carboxyethyl) phosphine after the addition of internal standards, protection of free thiol groups with iodoacetic acid, derivatization of free amino groups with dansyl chloride, and HPLC-MS/MS. The limits of detection and quantitation for glutathione were 0.75 nmol/g and 2.23 nmol/g flour, respectively. For cysteine, the limits of detection and quantitation were 0.72 nmol/g and 2.12 nmol/g flour, respectively. The developed method was found to be sensitive enough for quantitation of total glutathione and cysteine levels in wheat flour. This method was then utilized to investigate the effect of sulfur (S) deficiency on the amount of total glutathione and cysteine in flour. In S-deficient wheat, the concentrations of total glutathione and cysteine were proportional to the amount of S supplied during growth. The calculation of correlations revealed that GSH and Cys concentrations influenced the rheological dough properties and the baking performance at least as much as protein parameters. Thus, the low concentration of GSH and Cys in flour from S-deficient wheat had a similar effect on the technological properties as the altered composition of gluten proteins.     

Development of a stable isotope dilution assay for tenuazonic acid

A stable isotope dilution assay (SIDA) for the Alternaria mycotoxin tenuazonic acid was developed. Therefore, [(13)C(6),(15)N]-tenuazonic acid was synthesized from [(13)C(6),(15)N]-isoleucine by Dieckmann intramolecular cyclization after acetoacetylation with diketene. The synthesized [(13)C(6),(15)N]-tenuazonic acid was used as the internal standard for determination of tenuazonic acid in tomato products by liquid chromatography tandem mass spectrometry after derivatization with 2,4-dinitrophenylhydrazine. Method validation revealed a limit of detection of 0.1 μg/kg and a limit of quantitation of 0.3 μg/kg. Recovery was close to 100% in the range of 3-300 μg/kg. Determination of tenuazonic acid in two samples of different tomato ketchups (naturally contaminated) was achieved with a coefficient of variation of 2.3% and 4.7%. Different tomato products (n = 16) were analyzed for their content of tenuazonic acid using the developed SIDA. Values were between 15 and 195 μg/kg (tomato ketchup, n = 9), 363 and 909 μg/kg (tomato paste, n = 2), and 8 and 247 μg/kg (pureed tomatoes and comparable products, n = 5).     

Effectiveness of ionizing radiation in reducing furan and acrylamide levels in foods

Furan and acrylamide are two possible carcinogens commonly found in many thermally processed foods. The possibility of using ionizing radiation to reduce the levels of thermally induced furan and acrylamide in water and selected foods was investigated. Aqueous furan solutions, and foods (frankfurters, sausages, infant sweet potatoes) that contained furan were irradiated to various doses of gamma-rays. Water and oil spiked with acrylamide and potato chips (a known acrylamide-containing food) were also irradiated. In addition, possible irradiation-induced formation of acrylamide in glucose and asparagine solutions was analyzed. Results showed that irradiation at 1.0 kGy destroyed almost all furan in water. In frankfurters, sausages, and infant sweet potatoes, the rate of irradiation-induced destruction of furan was much lower than the rate in water, although significant reductions in furan levels were observed in all foods. Irradiation at 2.5-3.5 kGy, doses that can inactivate 5-log of most common pathogens, reduced furan levels in the food samples by 25-40%. Similarly to furan, acrylamide in water was also sensitive to irradiation. After 1.5 kGy of irradiation, most of the acrylamide was degraded. Irradiation, however, had a very limited effect on acrylamide levels in oil and in potato chips, even at a dose of 10 kGy. No detectable acrylamide was formed in the mixture of asparagine and glucose upon irradiation. These results suggest that a low dose of irradiation easily destroys furan and acrylamide in water. In real foods, however, the reduction of furan was less effective than in water, whereas the reduction in acrylamide was minimal.     

Reduction of acrylamide level in french fries by employing a temperature program during frying

In this study, the effect of employing an oil temperature program during frying on the acrylamide content of French fries was investigated. The frying conditions that could lead to lower acrylamide levels in French fries were first simulated by means of an experimentally validated frying model. Then, experiments were conducted to test the simulated conditions in real frying process. Different time/temperature combinations (4 min at 170 degrees C, 2 min at 170 degrees C + 2 min at 150 degrees C, 1 min at 170 degrees C + 3 min at 150 degrees C, 1 min at 190 degrees C + 3 min at 150 degrees C) were employed for frying potato strips (8.5 x 8.5 x 70 mm), and the resultant acrylamide levels were determined with a gas chromatography-mass spectrometry (GC-MS) method. The results indicated that acrylamide levels in French fries can be reduced by half if the final stage of the frying process employs a lower oil temperature. Therefore, the method appears to be an effective way of controlling the acrylamide level in the final product.     

Implementation of acrylamide mitigation strategies on industrial production of French fries: challenges and pitfalls

This study evaluated various additives or process aids on the industrial production of French fries, based on their acrylamide mitigation potential and other quality parameters. The application of acetic and citric acid, calcium lactate and asparaginase was investigated on the production of frozen par-fried French fries at the beginning and end of the 2008 and 2009 potato storage season. Despite the fact that some of these treatments significantly reduced acrylamide content of the final product in preliminary laboratory experiments, their application on the industrial production of French fries did not result in additional acrylamide reductions compared to the standard product. Asparaginase was additionally tested in a production line of chilled French fries (not par-fried). Since for this product a longer enzyme-substrate contact time is allowed, a total asparagine depletion was observed for the enzyme treated fries after four days of cold storage. French fries upon final frying presented acrylamide contents below the limit of detection (12.5 μg kg?1) with no effects on the sensorial properties of the final product.     

Quantitation of N2-[1-(1-carboxy)ethyl]folic acid, a nonenzymatic glycation product of folic acid, in fortified foods and model cookies by a Stable isotope dilution assay

A stable isotope dilution assay (SIDA) for the quantitation of N(2)-[1-(carboxy)ethyl]folic acid (CEF) has been developed by using [(2)H(4)]CEF as the internal standard. After sample cleanup by anion exchange chromatography, the three-dimensional specifity of liquid chromatography-tandem mass spectrometry enabled unequivocal determination of the nonenzymatic glycation product of folic acid (FA). When CEF was added to cornstarch, the detection limit for CEF was found to be 0.4 microg/100 g, and a recovery of 98.5% was determined. In analyses of cookies, the intra-assay coefficient of variation was 8.0% (n = 5). Application of the SIDA to commercial cookies produced from wheat flour fortified with FA revealed CEF contents of up to 7.1 microg/100 g, which accounted for approximately 10-20% of the cookies' FA content. In baby foods, multivitamin juices, and multivitamin sweets, however, CEF was not detectable. Further studies on CEF formation during baking of cookies made from fortified flour and different carbohydrates revealed that fructose was most effective in generating CEF followed by glucose, lactose, and sucrose with 12.5, 3.9, 2.5, and 2.5 microg/100 g of dry mass, respectively. During baking, approximately 50% of FA was retained for both monosaccharides fructose and glucose, and 77% as well as 85% of its initial content was retained for the disaccharides lactose and sucrose, respectively. Of the degraded amount of FA, CEF comprised 28% for fructose as well as 18, 12, and 8% for sucrose, lactose, and glucose, respectively. Therefore, CEF can be considered an important degradation product of FA in baked foods made from fructose. To retain a maximum amount of FA, products should rather be baked with sucrose than with reducing carbohydrates.     

Influence of Nitrogen and Potassium Supply on Contents of Acrylamide Precursors in Potato Tubers and on Acrylamide Accumulation in French Fries

Fried potato products may accumulate substantial amounts of acrylamide due to high precursor contents, namely reducing sugars and asparagine. In a two-factorial experiment increasing N supply, increased the contents of reducing sugars in most cases, and resulted in higher contents of free amino acids. α -amino-N, which was tightly correlated with the contents of free amino acids, can be regarded a suitable rapid test for free asparagine for a given variety. Increasing K addition always raised the citrate contents, but lessened the contents of reducing sugars. Selected treatments were processed into French fries. Highest acrylamide contents were observed in tubers grown with high N and inadequate K supply, which also contained the highest contents of precursors. The experiment clearly demonstrates that nutrient supply has significant impact on the contents of acrylamide precursors and thus for the acrylamide formation during frying.     

Gas chromatographic-mass spectrometric determination of adipate-based polymeric plasticizers in foods

A method for the quantitative determination of adipate-based polymeric plasticizers in foods is described. The procedure involves extraction from the food and transmethylation of the polymeric plasticizer to form dimethyladipate (DMA). The derivative is cleaned up by size-exclusion chromatography and determined by capillary gas chromatography-mass spectrometry with selected ion monitoring. The use of a deuterated internal standard at the extraction stage enables quantitation by stable isotope dilution. A detection limit of 0.1 mg/kg of the polymeric plasticizer in foods and a relative standard deviation of 4% have been achieved routinely. The method has been applied successfully to the analysis of cheese, sandwiches, meat, biscuits, and cake that have been in contact with polymeric plasticized poly(vinyl chloride) films.     

Synthesis of four carbon-13-labeled type a trichothecene mycotoxins and their application as internal standards in stable isotope dilution assays

The first stable isotope dilution assay (SIDA) for the simultaneous quantitation of the most abundant type A trichothecenes in foods and feeds was developed. Synthesis of carbon-13-labeled T2-toxin, HT2-toxin, diacetoxyscirpenol, and monoacetoxyscirpenol was accomplished by [13C2]-acetylation of T2-triol and scirpentriol, respectively. Scirpentriol was prepared from diacetoxyscirpenol by complete alkaline hydrolysis and subsequently was converted to [13C6]-triacetoxyscirpentriol by peracetylation with [13C4]-acetic anhydride. The latter compound was selectively hydrolyzed using ammonium hydroxide to give [13C4]-diacetoxyscirpenol and [13C2]-monoacetoxyscirpenol in reasonable yields. Analogously, [13C6]-T2-triacetate was prepared from T2-triol and subjected to controlled hydrolysis to yield [13C4]-T2-toxin and [13C2]-HT2-toxin. All synthesized products were characterized by NMR and MS experiments. Using the prepared isotopically labeled standards, SIDAs were developed for the quantitation of type A trichothecenes in food and feeds. The mycotoxins were quantified by LC-single and tandem MS after cleanup on multifunctional columns. The method revealed good sensitivity with low detection and quantification limits along with excellent recovery and good precision in interassay studies. Food samples were analyzed using the developed SIDA and showed substantial contamination of oat products with T2-toxin and HT2-toxin. Diacetoxyscirpenol was detected on potatoes, whereas monoacetoxyscirpenol was not present in the analyzed samples.     

Thermally generated 3-aminopropionamide as a transient intermediate in the formation of acrylamide

On the basis of the recent findings that "biogenic amines" can also be formed during thermal food processing from their parent amino acids in a Strecker-type reaction, the formation of 3-aminopropionamide, the biogenic amine of asparagine, was investigated in model systems as well as in thermally processed Gouda cheese. The results of model studies revealed that, besides acrylamide, 3-aminopropionamide was also formed in amounts of 0.1-0.4 mol % when asparagine was reacted in the presence of either glucose or 2-oxopropionic acid. Results of a second series of model experiments in which [(13)C(4)(15)N(2)]-asparagine ([(13)C(4)(15)N(2)]-Asn) and unlabeled 3-aminopropionamide were reacted together in the presence of glucose revealed a >12-fold higher efficacy of 3-aminopropionamide in acrylamide generation as compared to asparagine. Both [(13)C(3)(15)N(2)]-3-aminopropionamide and [(13)C(3)(15)N(1)]-acrylamide were formed during [(13)C(4)(15)N(2)]-Asn degradation in a ratio of about 1:4, supporting the idea that 3-aminopropionamide is a transient intermediate in acrylamide formation. In this study, 3-aminopropionamide was identified and quantified for the first time in foods, namely, in Gouda cheese. Although the fresh cheese contained low amounts of 3-aminopropionamide, its concentrations were much increased to approximately 1300 mug/kg after thermal processing. In isotope labeling studies, performed by administering to the cheese [(13)C(4)(15)N(2)]-Asn in a ratio of 1:2 as compared to the "natural" concentrations of asparagine, similar ratios of unlabeled/labeled 3-aminopropionamide and unlabeled/labeled acrylamide were determined. Thus, 3-aminopropionamide could be verified as a transient intermediate of acrylamide formation during food processing.     

A new LC/MS-method for the quantitation of acrylamide based on a stable isotope dilution assay and derivatization with 2-mercaptobenzoic acid. Comparison with two GC/MS methods

Acrylamide (AA) was found to form a stable thioether in reasonable yields (45-50%) when reacted with 2-mercaptobenzoic acid at 20 degrees C for 3 h. On the basis of this finding and using [(13)C(3)]-acrylamide as the internal standard, a sensitive and selective new stable isotope dilution analysis for AA quantitation in food samples was developed based on single stage LC/MS. Comparison of the quantitative results obtained by applying the new method to potato chips, crispbread or butter cookies with data obtained by two stable isotope dilution analysis, using direct measurement of AA by GC/MS, but differing in the workup procedure, revealed detection limits in the same order of magnitude (6.6 microg/kg). Quantitative data obtained by application of the three methods on the same samples of potato chips or cookies, respectively, were also in very good agreement. Quantitation of AA in crispbreads treated with an amylase/protease mixture did not show increased AA levels, thereby indicating that inclusion of AA in starch/protein gels is not very probable during breadmaking.     

Quality evaluation of olive oil by statistical analysis of multicomponent stable isotope dilution assay data of aroma active compounds

An instrumental method for the evaluation of olive oil quality was developed. Twenty-one relevant aroma active compounds were quantified in 95 olive oil samples of different quality by headspace solid phase microextraction (HS-SPME) and dynamic headspace coupled to GC-MS. On the basis of these stable isotope dilution assay results, statistical evaluation by partial least-squares discriminant analysis (PLS-DA) was performed. Important variables were the odor activity values of ethyl isobutanoate, ethyl 2-methylbutanoate, 3-methylbutanol, butyric acid, E,E-2,4-decadienal, hexanoic acid, guaiacol, 2-phenylethanol, and the sum of the odor activity values of Z-3-hexenal, E-2-hexenal, Z-3-hexenyl acetate, and Z-3-hexenol. Classification performed with these variables predicted 88% of the olive oils' quality correctly. Additionally, the aroma compounds, which are characteristic for some off-flavors, were dissolved in refined plant oil. Sensory evaluation of these models demonstrated that the off-flavors rancid, fusty, and vinegary could be successfully simulated by a limited number of odorants.