Effect of Storage on Fat Acidity and Pasting Characteristics of Wheat Flour

Two cultivars of wheat (Triticum aestivum L.), Sunco and Sunsoft, were used to study the influence of storage time and temperature on the formation of starch-lipid complexes in flour pastes. Untreated and fat-reduced whole meal flours were stored separately for up to 12 months at 4, 20, and 30°C. The stored samples were analyzed for fat acidity, pasting properties, and iodine binding values. Fat acidity increased significantly in the untreated flour samples stored at 30 and 20°C compared with 4°C. Starch pasting properties, as measured using a Rapid Visco Analyser (RVA) indicated that the final viscosity of untreated flour samples of both cultivars increased significantly with storage time and elevated temperature, and correlated positively with increased fat acidity. Iodine binding values of the RVA pastes decreased with storage time and elevated temperature, and correlated negatively with fat acidity and final viscosity. The fat-reduced Sunco and Sunsoft flours showed less pronounced changes compared with untreated flours, whereas small changes in the RVA parameters were noted in grains stored over 12 months. The results indicate that free fatty acids are released during storage and that they increase the potential for starch-lipid complex formation when stored whole meal wheat flours are pasted in the RVA. These changes were evident after two to three months of storage at 20 and 30°C.     

Storage of Wheat Grains at Elevated Temperatures Increases Solubilization of Glutenin Subunits

Grains of two wheat (Triticum aestivum L.) cultivars, Sunco and Sunsoft, were stored at 4°C and 30°C for 270 days to examine changes in proteins during storage. When whole meal flour extracted from the grains was analyzed using an unfractionated protein extraction procedure, no significant changes were found in protein content or SDS‐PAGE profile for either cultivar in samples stored at 30°C compared with those stored at 4°C. Fractionation of the flour samples from stored grain into soluble and insoluble proteins revealed increases in soluble protein content for both cultivars stored at 30°C compared with 4°C. The soluble protein content, expressed as a percentage of the total protein, increased by 1.5% (P = 0.032) for Sunco and by 8.0 % (P = 0.158) for Sunsoft during storage at 30°C compared with those samples stored at 4°C. Analysis by SDS‐PAGE and subsequent protein identification revealed that the most evident change that occurred during storage at 30°C was an increase in the content of high molecular weight glutenin subunits (HMW‐GS) in the soluble fraction. The potential effect of changes in solubility of HMW‐GS on functional properties is discussed.     

Effects of Extraction Rates of Wheat Flour on Phyllo (Yufka) Properties at Different Storage Temperatures

Phyllo sheets were produced with flour obtained at different extraction rates (53, 58, or 67%), and stored at 4 and 25°C. Physical, chemical, and sensory properties of fresh and stored phyllo were researched. Fresh phyllo samples from wheat flour at 53% extraction rate were thinner (0.4 mm) and had whiter color (L* = 87.6). Textural properties and overall sensory acceptability of phyllo samples significantly decreased (P ≤ 0.01) with increased extraction rates and storage times. At the end of four days, toughness and extensibility decreased from 0.88 N and 10.9 mm to 0.65 N and 6.7 mm at 4°C and to 0.45 N and 5.6 mm at 25°C. The 53% extraction rate was more suitable for producing phyllo. The shelf life of phyllo samples for preparing borek was determined four days at 4°C and two days at 25°C according to acid contents and sensory properties.     

CM-Cellulase Activity in Sou as affected by Addition of Organic Materials,Temperature, Storage and drying and wetting Cycles

The increase in carboxymethyl-cellulase activity (C.A.) resulting from the addition of different organic materials to calcareous, sandy loam and clay soils was studied. The effect of temperature, storage, as well as drying and wetting cycles on C.A. were also investigated. More C.A. was noticed when the 3 different soils were amended with clover straw than when cotton stalks or farmyard manure were added. Incubating these soils at temperatures from 4 °C up to 70 °C caused a sharp decrease in C. A. which was affected by the time of incubation. This reduction in C.A. varied from 23 to 84 % in the 3 soils used. Considerable losses in C.A. were also noticed when these soils were stored for 28 days either in the refrigerator (40–45 %) or at room temperature (54–71 %). Drying the samples amended with different organic materials caused a tremendous decrease in C.A. ranging from 14 % to 60 %, while rewetting enhanced the regain of C.A. but not to its original level.     

Effects of Rough Rice Storage Conditions on the Amylograph and Cooking Properties of Medium-Grain Rice cv. Bengal

Rough rice (cv. Bengal) was stored at four moisture contents (8.8, 10.7, 12.9, and 13.6% MC) and three temperatures (3, 20, and 37°C) for up to six months. The amylograph overall paste viscosity of the milled rice increased during storage. This increase was most apparent in all samples stored at 37°C. For rice stored at 20 and 37°C at all MC levels, a 30–50% increase in peak viscosity (PV) was observed during the first three months of storage. PV subsequently leveled off for rice stored at 12.9 and 13.6% MC but declined for samples stored at 8.8 and 10.7% MC. The final viscosities also increased during storage. The water-absorption ratio of the samples during cooking in excess water increased by an average of 15% over six months of storage. The amylograph and cooking properties were significantly affected (P < 0.05) by rough rice storage duration, temperature, MC, and their respective interactions.     

Effects of Rough Rice Storage Conditions on Gelatinization and Retrogradation Properties of Rice Flours

Changes in gelatinization and retrogradation properties of two rice cultivars, Bengal and Kaybonnet, during rough rice storage were studied using differential scanning calorimetry (DSC). The storage variables included two storage moisture contents (12 and 14%), three storage temperatures (4, 21, and 38°C), and four storage durations (0, 3, 9, and 16 weeks). Rough rice cultivar, storage temperature, moisture content, and duration affected (P < 0.05) the enthalpies and temperatures of gelatinization and retrogradation of rice flour. Bengal had a higher gelatinization enthalpy (P < 0.005) but lower gelatinization temperatures (P < 0.0001) than the long-grain Kaybonnet. Rice stored at 38°C exhibited higher gelatinization enthalpy and temperatures (P < 0.05) than those stored at 4 or 21°C. Storage duration affected the gelatinization and retrogradation properties through a higher order, rather than a linear, relationship.     

Prevention of oxidative rancidity in rice bran during storage.

The effect of microwave heat on lipoxygenase (LOX) activity in rice bran under various storage conditions was examined. Raw rice bran from the long-grain variety Lemont was adjusted to 21% moisture content and heated in a microwave oven at 850 W for 3 min. Raw and microwave-heated rice bran samples were packed in zipper-top bags or vacuum packs and stored at room temperature (25 degrees C) or in the refrigerator (4-5 degrees C) for 16 weeks. Samples were analyzed for LOX activity at 4-week intervals. LOX activity did not significantly change from its initial value at week 0 for zipper-top and vacuum-packed samples while stored at 4-5 degrees C for 12 weeks, but decreased at week 16. Vacuum packing did not show a significant impact on LOX activity during 16 weeks of storage. Microwave-heated samples stored in the refrigerator did not show significant change in LOX activity for up to 12 weeks but showed a significant (p < 0. 05) decrease at 16 weeks. Results showed that oxidative rancidity of rice bran could be prevented by microwave heating the samples, packing in zipper-top bags, and storing at 4-5 degrees C for up to 16 weeks.     

Effect of Extruding Wheat Flour at Lower Temperatures on Physical Attributes of Extrudates and on Thiamin Loss When Using Carbon Dioxide Gas as a Puffing Agent

Wheat flour with 0.3% (w/w) thiamin was extruded on a twin‐screw laboratory‐scale extruder (19‐mm barrel) at lower temperatures and expanded using carbon dioxide (CO₂) gas at 150 psi. Extrusion conditions were die temperature of 80°C and screw speed range of 300–400 rpm. Control samples were extruded at a die temperature of 150°C and screw speed range of 200–300 rpm. Dough moisture content was 22% in control samples and 22 and 25% in CO₂ samples. Expansion ratio, bulk density, WAI, and %WSI were compared between control and treatment. CO₂ injection did not significantly increase expansion ratio. Bulk densities in the CO₂ extruded samples decreased when feed moisture decreased from 25 to 22%. The products using CO₂ had lower WAI values than products puffed without CO₂ at higher temperatures. The mean residence time was longer in CO₂ screw configurations than in conventional screw configurations. Thiamin losses were 10–16% in the control samples. With CO₂, thiamin losses were 3–11% at 22% feed moisture, compared with losses of 24–34% at 25% moisture. Unlike typical high‐temperature extrusion, thiamin loss in the low‐temperature samples decreased with increasing screw speed. Results indicate that thiamin loss at lower extrusion temperatures with CO₂ injection is highly dependent on moisture content.     

Effects of Bran Prehydration on Functional Characteristics and Bread‐Baking Quality of Bran and Flour Blends

The effect of bran prehydration on the composition and bread‐baking quality was determined using bran and flour of two wheat varieties. Bran was hydrated in sodium acetate buffer (50mM, pH 5.3) to 50% moisture at 25 or 55°C for 1.5 or 12 h. The soluble sugar content in bran increased with prehydration. Decreases in phytate and soluble fiber were observed in prehydrated bran, but insoluble fiber was not affected by prehydration. Likewise, free phenolic content decreased, and there was little change in the content of bound phenolics in prehydrated bran. The compositional changes were greater in the bran prehydrated at 55 than at 25°C, and for 12 than for 1.5 h. Addition of prehydrated bran delayed dough development of bran and flour blends and slightly increased water absorption of dough. A higher loaf volume of fresh bread and lower crumb firmness of bread stored for 10 days were observed in bread containing bran prehydrated at 25°C than in bread containing nonhydrated bran or bran prehydrated at 55°C. The prehydration of bran at 25°C before being incorporated into refined flour for dough mixing improved bread quality by altering bran compositional properties, allowing enough water to be absorbed by fibrous materials in the bran and preventing water competition among dough constituents.     

Effect of Holding Temperature on the Structures of Mung Bean Starch Gels and Noodles

The effect of storage temperatures (‐10, +1, and +10°C) on the structural organization of mung bean starch gels and noodles was studied by acid hydrolysis, X‐ray diffractometry, and gel‐permeation chromatography. The gels showed higher susceptibility to acid compared with the noodles as shown by the rate constants of the first stage of hydrolysis (k = 5.37–12.17 × 10^‐2/day and k = 4.19–4.61 × 10^‐2/day for gels and noodles, respectively). Acid hydrolysis showed no difference in the amount of resistant residues of both gels (42–46%) and noodles (44–45%), except for gels (38%) stored at ‐10°C. The acid‐resistant residues of both the gels and noodles had a B‐type X‐ray diffraction pattern (major reflections at 2θ = 19, 24, and 25°). The acid‐resistant residues of the unstored sample and those stored at ‐10°C for both gels and noodles contained chains with DP 46–54 and after debranching yielded two peaks with DP 29–39 and DP 15–19. The acid‐resistant residues of gels and noodles stored at +1 and +10°C contained chains with DP 35–37 and after debranching showed two chain populations with DP 31–33 and DP 14–19. These results indicate the greater participation of amylopectin in the retrogradation process occurring during storage at +1 and +10°C.     

Impact of Wheat Fiber on Frozen Dough Shelf Life and Bread Quality

Freezing and prolonged frozen storage of dough results in constant deterioration in the overall quality of the final product. In this study the effect of wheat bran and wheat aleurone as sources of arabinoxylan (AX) on the quality of bread baked from yeasted frozen dough was investigated. Wheat fiber sources were milled to pass through a 0.5 mm screen, prehydrated for 15 min, and incorporated into refined wheat flour at 15% replacement level. Dough products were prepared from refined flour (control A), whole wheat flour (control B), aleurone composite flour (composite flour A), and bran composite flour (composite flour B) and stored at –18°C for 28 weeks. Dough samples were evaluated for breadmaking quality at zero time, 14 weeks, and 28 weeks of storage. Quality parameters evaluated were loaf weight, loaf specific volume, and crumb firmness. Composite flour bread samples showed the most resistance to freeze damage (less reduction in the overall product quality), indicating a possible role of some fiber components (e.g., AX) in minimizing water redistribution in the dough system and therefore lessening adverse modifications to the gluten structure. The data suggest that the shelf life of frozen dough and quality of obtained bread can be improved with the addition of an AX source.     

Effects of Temperature,Sonication Time,and Power Settings on Size Distribution and Extractability of Total Wheat Flour Proteins as Determined by Size‐Exclusion High‐Performance Liquid Chromatography

The size‐exclusion (SE) HPLC profile of total protein extract obtained by sonication of flour samples at ambient temperature showed marked instability on reinjection. Instability was related to the presence of flour proteases that were inactivated by thermal treatment of flour samples at 60°C. Extraction of flour protein by sonication was a function of ultrasonic energy (sonication time × power product) delivered to flour sample. As protein solubility increased, the proportions of the earliest eluted SE‐HPLC fractions (F1 and F2) increased. Oversonication of proteins evidenced by a decrease in F1 amount at the benefit of F2 occurred below the sonication energy level needed for total protein extraction. Ultrasonic energy level was adjusted to allow total protein extraction while limiting oversonication. The sonication procedure was applied on 27 flour samples of contrasting dough strength to extract total proteins. Absolute amount of protein extractable by sonication, determined from SE‐HPLC area, was strongly correlated with flour protein content. Very significant and equivalent relationships were found between alveographic W index and absolute amount of either unextractable protein extract or F1 of SE‐HPLC profile from total protein extract.     

Viability of Oryza sativa L. seeds stored under genebank conditions for up to 30 years

Germination ability, equilibrium relative humidity (eRH), and moisture content of ‘control’ seed samples representing 183 rice accessions stored in the active (2–4 °C) and base (?10 °C until 1993, then ?20 °C) collections of the T. T. Chang Genetic Resources Center were determined after storage for 20.5–30.5 years. Germination of seeds that had been stored in the base collection was generally high (>70 %), whereas germination was more variable for seeds stored in the active collection. Samples with lower viability after storage in the active collection were likely to have lower viability after storage in the base collection. There were significant differences in the moisture content-eRH relationship of the seeds depending on whether the seeds had been stored in the active or base collection. Based on re-test data for regular seed samples regenerated in 1979–1980 and stored in the active collection for up to 31 years, estimates of the time for ability to germinate to fall to 50 % (p ₅₀) ranged from 54 to 997 years. For the same seed samples stored in the base collection for approximately 31 years, ability to germinate has been maintained and germination increased due to improved procedures. The ability to germinate of base collection samples was also generally higher than that of ‘safety duplicate’ samples of the same seed lots that had been sent to the National Center for Genetic Resources Preservation, USA in 1981 and stored at ?18 °C. This may have been due to uptake of moisture either during processing for dispatch or as a consequence of poor packaging material. The results are discussed in relation to long-term seed storage and genebank management.     

Effect on Dough Functional Properties of Partial Fractionation,Redistribution, and In Situ Deposition of Wheat Flour Gluten Proteins Exposed to Water,Ethanol, and Aqueous Ethanol

The application of the cold‐ethanol laboratory fractionation method to the bulk separation of wheat starch and gluten is accompanied by incidental dissolution, removal, or redeposition of a small part of the functional gliadin protein. The new distribution resulting from process incidental redeposition of soluble components or by purposeful add‐back of soluble and leached components can lead to differences in functionality and more difficult recovery of native properties. To assess this issue, we exposed several wheat flour types to ethanol and water (50–90% v/v) solutions, water, and absolute ethanol at 22°C and –12°C. The exposure was mass conserving (leached components returned to substrate by evaporation of the solvent without separation of phases) or mass depleting (leached components not returned to substrate). The result of the mass‐conserving contact would be flour with altered protein distributions and intermolecular interactions. The result of the mass‐depleting contact would also include altered protein content. Furthermore, the mass‐conserving contact would model an industrial outcome for a cold‐ethanol process in which leached components would be added back from an alcohol solution. The leaching result was monitored by mixography of the flour, nitrogen analysis, and capillary zone electrophoresis of extracts. Although dough rheology was generally like that of the source flour, there were notable differences. The primary change for mass‐conserving contact was an increase in the time to peak resistance and a decrease in the rate of loss of dough resistance following peak resistance. These changes were in direct proportion to the amount of protein mobilized by the solvent. Leaching at 22°C, prevented dough formation for most aqueous ethanol concentrations and greatly reduced gliadin protein content. Minimal changes were noted for solvent contact at –12°C regardless of the ethanol concentration. The data suggested that 1) the conditions applied in cold‐ethanol enrichment of protein from wheat will generally preserve vital wheat gluten functionality, 2) functionality losses can be recovered by returning the solubilized fractions, and 3) the flour to which the gluten is added may require more mixing.     

Nonenzymatic Browning During Storage of Infant Cereals

The browning indicators furosine and color were determined in infant cereals and infant cereals containing powdered milk to evaluate the utility of these parameters for monitoring storage. Studies were made on seven infant cereal samples including both gluten and gluten‐free products. Samples were stored under laboratory conditions at 28°C for four or 16 weeks; or under modified water activity conditions at 25°C or 55°C for one, two, three, or four weeks; or under industrial conditions in air or nitrogen atmospheres at 32°C or 55°C for one, three, six, or 12 months. Furosine levels increased during the storage of infant cereals containing powdered milk under all time, temperature, and water activity (a_w) conditions assayed, except drastic conditions (55°C, a_w = 0.65). Color values increased in infant cereals with gluten (7‐cereal and 8‐cereal samples), regardless of milk content, when they were stored under drastic conditions (55°C or 25°C with normal or modified water activity). However, the gluten‐free infant cereals (rice‐corn and rice‐corn‐soy samples) that have a characteristic yellow color showed no increase in color during storage. The extent of the Maillard reaction was greatest in the infant cereals that included milk in their formulation.     

Effect of Sucrose on Glass Transition,Gelatinization, and Retrogradation of Wheat Starch

Differential scanning calorimetry (DSC) was used to study the effect of sucrose on wheat starch glass transition, gelatinization, and retrogradation. As the ratio of sucrose to starch increased from 0.25:1 to 1:1, the glass transition temperature (T_g, T_g′) and ice melting enthalpy (ΔH_ice) of wheat starch‐sucrose mixtures (with total moistures of 40–60%) were decreased to a range of −7 to −20°C and increased to a range of 29.4 to 413.4 J/g of starch, respectively, in comparison with wheat starch with no sucrose. The T_g′ of the wheat starch‐sucrose mixtures was sensitive to the amount of added sucrose, and detection was possible only under conditions of excess total moisture of >40%. The peak temperature (T_m) and enthalpy value (ΔH_G) for gelatinization of starch‐sucrose systems within the total moisture range of 40–60% were increased with increasing sucrose and were greater at lower total moisture levels. The T_g′ of the starch‐sucrose system increased during storage. In particular, the significant shift in T_g′ ranged between 15 and 18°C for a 1:1 starch‐sucrose system (total moisture 50%) after one week of storage at various temperatures (4, 32, and 40°C). At 40% total moisture, samples with sucrose stored at 4, 32, and 40°C for four weeks had higher retrogradation enthalpy (ΔH) values than a sample with no sucrose. At 50 and 60% total moisture, there were small increases in ΔH values at storage temperature of 4°C, whereas recrystallization of samples with sucrose stored at 32 and 40°C decreased. The peak temperature (T_p), peak width (δT), and enthalpy (ΔH) for the retrogradation endotherm of wheat starch‐sucrose systems (1:0.25, 1:0.5, and 1:1) at the same total moisture and storage temperature showed notable differences with the ratio of added sucrose. In addition, T_p increased at the higher storage temperature, while δT increased at the lower storage temperature. This suggests that the recrystallization of the wheat starch‐sucrose system at various storage temperatures can be interpreted in terms of δT and T_p.     

Factors Affecting Viscosity of Slurries of Oat Groat Flours

Oat grain is routinely kilned and steamed before milling to develop flavor and to inactivate lipid-degrading enzymes. Heat treatments can significantly affect viscous properties, which have functional and nutritional importance. Oat flour slurries (23%, w/w, solids dry basis) made from steamed (for 20 min) or autoclaved (at 121°C, 15 psi, for 10 min) grain developed high viscosities, whereas flour slurries made from raw or kilned (105°C for 90 min) oats did not. Flour slurries made from raw groats, surface-sterilized by 1% hypochlorite, were more viscous than untreated raw groat flour slurries, suggesting that β-glucan hydrolases on the surface of the groat caused the viscosity losses observed in raw or kilned groats. However, because viscosities developed by surface-sterilized groats were not as great as in steamed oat-flour slurries and because some roasting treatments also inactivated enzymes without enhancing viscosity, it appears steaming might also affect the β-glucan polymer, resulting in its greater hydration in solution. Smaller particle size and higher incubation temperature also resulted in increased flour slurry viscosity, presumably because of increased hydration of the β-glucan. Rmoval of lipids from steamed oat flour significantly increased the oat flour slurry viscosity, apparently by increasing the β-glucan concentration in the flour.     

Influence of Bran Particle Size on Bread‐Baking Quality of Whole Grain Wheat Flour and Starch Retrogradation

The influence of bran particle size on bread‐baking quality of whole grain wheat flour (WWF) and starch retrogradation was studied. Higher water absorption of dough prepared from WWF with added gluten to attain 18% protein was observed for WWFs of fine bran than those of coarse bran, whereas no significant difference in dough mixing time was detected for WWFs of varying bran particle size. The effects of bran particle size on loaf volume of WWF bread and crumb firmness during storage were more evident in hard white wheat than in hard red wheat. A greater degree of starch retrogradation in bread crumb stored for seven days at 4°C was observed in WWFs of fine bran than those of coarse bran. The gels prepared from starch–fine bran blends were harder than those prepared from starch–unground bran blends when stored for one and seven days at 4°C. Furthermore, a greater degree of starch retrogradation was observed in gelatinized starch containing fine bran than that containing unground bran after storage for seven days at 4°C. It is probable that finely ground bran takes away more water from gelatinized starch than coarsely ground bran, increasing the extent of starch retrogradation in bread and gels during storage.     

Sorption of dissolved organic carbon in soils: effects of soil sample storage,soil-to-solution ratio,and temperature

Experiments on the sorption of dissolved organic carbon (DOC) in soils were mainly conducted in batch approaches. Because varying setups were used in these studies, comparison of the results requires knowledge on the effects that different experimental conditions may have on the sorption of DOC. This investigation evaluated the DOC sorption of soils using differently pretreated soil samples (field-fresh (two sampling dates), air-dried, stored at 3°C and −18°C), at different soil-to-solution ratios (1:40, 1:20, 1:10 and 1:5 w/v) and different temperatures (5°C, 15°C, 25°C and 35°C). The sorption of DOC was analyzed using the initial mass (IM) approach, which regressed the initial amount of sorbate (normalized to soil mass) against the sorbed amount (normalized to soil mass). The DOC release — when a solution without DOC was added — strongly increased with temperature and soil-to-solution ratio. Among the different types of sample storage and preparation, air-drying resulted in the largest DOC release. The smallest release was from the field-fresh samples. Freezing and storage at 3°C resulted in intermediate DOC release with freezing having the greater effect. The release from air-dried samples exceeded that of field-fresh samples by a factor of four at maximum. In contrast, none of the experimental setups influenced the slope of the IM isotherms. Thus, it seems possible to compare directly the binding affinity of DOC to different soils as determined at varying experimental conditions.