Effect of milk concentration on the irreversible thermal denaturation and disulfide aggregation of beta-lactoglobulin

The kinetics of beta-lactoglobulin (beta-LG) denaturation in reconstituted skim milk samples of various concentrations (9.6-38.4% total solids) over a wide temperature range (75-100 degrees C) was studied. The thermal denaturation of beta-LG had a reaction order of 1.5 at all milk solids concentrations and at all temperatures. The rate of denaturation of beta-LG was markedly dependent on the milk solids concentration and the heating temperature. At 75 degrees C, the thermal denaturation of beta-LG was retarded at higher milk solids concentrations. However, this retardation was less pronounced at higher temperatures so that a similar rate of denaturation was observed at all milk solids concentrations at 100 degrees C. From an examination of the level of disulfide-aggregated beta-LG, it was evident that most, but not all, of the denatured beta-LG was involved in disulfide-aggregated complexes, either with other denatured whey proteins or with the casein micelles. As with beta-LG denaturation, the rate of disulfide aggregation of beta-LG was markedly dependent on the milk solids concentration.     

Denaturation of beta-lactoglobulin in pressure-treated skim milk

The kinetics of beta-lactoglobulin (beta-LG) denaturation in pressure-treated reconstituted skim milk samples over a wide pressurization range (100-600 MPa) and at various temperatures (10-40 degrees C) was studied. Denaturation was extremely dependent on the pressure and duration of treatment. At 100 MPa, no denaturation was observed regardless of the temperature or the holding time. At higher pressures, the level of denaturation increased with an increasing holding time at a constant pressure or with increasing pressure at a constant holding time. At 200 MPa, there was only a small effect of changing the temperature at pressurization. However, at higher pressures, increasing the temperature from 10 to 40 degrees C markedly increased the rate of denaturation. The two major genetic variants of beta-LG (A and B) behaved similarly to pressure treatment, although the B variant appeared to denature slightly faster than the A variant at low pressures (< or =400 MPa). The denaturation could be described as a second-order process for both beta-LG variants. There was a marked change in pressure dependence at about 300 MPa, which resulted in markedly different activation volumes in the two pressure ranges. Evaluation of the kinetic and thermodynamic parameters suggested that there may have been a transition from an aggregation-limited reaction to an unfolding-limited reaction as the pressure was increased.     

Effect of pH on the thermal denaturation of whey proteins in milk

The effect of pH on thermal denaturation of four main whey protein fractions in skim milk was examined by gel permeation FPLC. On heating skim milk at 80 degrees C for 0.5-20.0 min over the pH range 5.2-8.8, the extent of denaturation, based on loss of solubility at pH 4.6, increased with heating time and was usually in the order immunoglobulins > serum albumin/lactoferrin > beta-lactoglobulin > alpha-lactalbumin. Rates of denaturation of the immunoglobulins and the serum albumin/lactoferrin fraction were highest at the lower end of this pH range, whereas those of beta-lactoglobulin and alpha-lactalbumin increased over most of the pH range. The effects of pH, addition of Ca, and reduction of disulfide bonds on the rates of the unfolding and aggregation stages of denaturation are discussed.     

Quantitative assessment of thermal denaturation of bovine alpha-lactalbumin via low-intensity ultrasound, HPLC, and DSC

The degree of irreversible aggregation and the aggregation velocity constant of alpha-lactalbumin (alpha-la) were determined by three methods based on different principles: low-intensity ultrasound as a novel method for this purpose, DSC, and HPLC. The denaturation process of alpha-la causes a decrease in the ultrasonic velocity due to the conformation change of alpha-la molecules. This decrease is a function of the concentration of native alpha-la in the sample. A linear correlation was found between the degree of aggregation of alpha-la determined by these three methods. There is no significant difference between the aggregation velocity constants determined by the three methods. The results show that the ultrasonic method is capable of quantifying the degree of aggregation of a protein, offering an alternative method.     

Steric effects governing disulfide bond interchange during thermal aggregation in solutions of beta-lactoglobulin B and alpha-lactalbumin

Intermolecular disulfide bond formation in pure beta-lactoglobulin (beta-Lg) B and in its 1:1 mixture with alpha-lactalbumin (alpha-La), heated at 85 degrees C for 10 min in solutions of low and high (100 mM NaCl) ionic strength and pH 6.0, was studied by reverse-phase HPLC and MALDI-TOF mass spectrometry. Disulfide bonding between beta-Lg monomers was more extensive than reported in the literature for a temperature of 68.5 degrees C, including formation of trimers connected by two of the three adjacent cysteines, C106/C119/C121. The participation of the different thiol groups in disulfide bonds appeared to depend on their location in the native structure, with surface-located cysteines more involved than internally located ones. This also applied to alpha-La-beta-Lg interactions, where the predominant participants were the surface-located alphaC111, alphaC120, alphaC61, and alphaC6. The least active participant was alphaC28, suggesting that it becomes sterically inaccessible during unfolding of the protein. High ionic strength apparently promoted disulfide bonding. The order of cysteine participation at the high ionic strength was similar to that at low ionic strength, with fewer native-location bonds observed and a lower activity of some groups, such as beta-C106/C119/C121 and alphaC61.     

Determination of the heat treatment undergone by milk by following the denaturation of alpha-lactalbumin with a biosensor

Dairy industries are interested in knowing the heat treatment undergone by milk so as to control the quality of drinking milks or to control their heating systems. Among the different techniques available to characterize the heat treatment of milk, estimation of the denaturation of proteins has been widely used. However, because the concentration of the proteins in raw milk can fluctuate significantly, determining only the concentration of a native protein without knowing its concentration in the raw milk before undergoing heat treatment can lead to significant imprecision. The objective of this study was to develop, on Biacore 3000, a biosensor assay for determining the denaturation index of alpha-lactalbumin by quantifying separately the native and "heat-denatured" forms of alpha-lactalbumin with specific monoclonal antibodies. alpha-Lactalbumin denaturation index is independent of the concentration of alpha-lactalbumin in the original raw milk. The technique developed is discriminating, fast, repeatable, fully automated, and requires no pretreatment of the milk sample.     

Impact of protein surface denaturation on droplet flocculation in hexadecane oil-in-water emulsions stabilized by beta-lactoglobulin

The influence of globular protein denaturation after adsorption to the surface of hydrocarbon droplets on flocculation in oil-in-water emulsions was examined. n-Hexadecane oil-in-water emulsions (pH 7.0) stabilized by beta-lactoglobulin (1-wt % beta-Lg) were prepared by high-pressure valve homogenization. NaCl (0-150 mM) was added to these emulsions immediately after homogenization, and the evolution of the mean particle diameter (d) and particle size distribution (PSD) was measured by laser diffraction during storage at 30 degrees C for 48 h. No change in d or PSD was observed in the absence of added salt, which indicated that these emulsions were stable to flocculation. When 150 mM NaCl was added to emulsions immediately after homogenization, d increased rapidly during the following few hours until it reached a plateau value, while the PSD changed from monomodal to bimodal. Addition of N-ethylmaleimide, a sulfhydryl blocking agent, to the emulsions immediately after homogenization prevented (at 20 mM NaCl) or appreciably retarded (at 150 mM NaCl) droplet flocculation. These data suggests that protein unfolding occurred at the droplet interface, which increased the hydrophobic attraction and disulfide bond formation between droplets. In the absence of added salt, the electrostatic repulsion between droplets was sufficient to prevent flocculation, but in the presence of sufficient salt, the attractive interactions dominated, and flocculation occurred.     

Effect of cationic membrane permselectivity on the efficiency of skim milk electroacidification

Bipolar membrane electroacidification (BMEA) uses the property of bipolar membranes to split water and the demineralization action of cation-exchange membranes (CEM). As milk mineral salt content is very sensitive to ionic strength and pH changes, the aim of this study was to better understand the effect of changes in mineral content during pH decrease and demineralization of skim milk. The objectives were to investigate the effect of different cationic permselective membranes (CSV and CMX membranes) on skim milk cation migration and protein precipitation during BMEA. The permselectivity of both membranes tested does not influence the final efficiency of BMEA. The purity of the bovine milk casein isolates produced was similar to or higher (97-98% versus 93.4-96.7) than those of commercial isolates, due to a reduced ash content (1.2 versus 2.0-3. 8%) resulting from the CEM demineralizing phenomenon. For both membranes, the main ionic species to migrate was the potassium ions.     

Effect of heat treatment on denaturation of bovine alpha-lactalbumin: determination of kinetic and thermodynamic parameters

The effect of heat treatment on the denaturation of alpha-lactalbumin was studied, under different conditions, over a temperature range of 78-94 degrees C. The concentration of the residual immunoreactive protein after different treatments was determined by kinetic analysis, obtaining D and Z values. Thermodynamic parameters were also calculated. Denaturation of alpha-lactalbumin, measured by the loss of immunoreactivity, could be described as an order of reaction of n = 1.5. Results obtained indicated that alpha-lactalbumin was more heat-sensitive when treated in milk than in phosphate buffer. The protein was also denatured more rapidly in the apo form than in the calcium-saturated form. Besides, the thermal stability of apo-alpha-lactalbumin decreased with the binding of oleic acid.     

Role of the soluble and micelle-bound heat-induced protein aggregates on network formation in acid skim milk gels

Gel formation was monitored by low amplitude rheometry during acidification at 40 degrees C with 1.5% glucono-delta-lactone in combined milk systems containing soluble and/or micelle-bound heat-induced (95 degrees C/10 min) aggregates of denatured whey proteins and kappa-casein and in heated dairy mixes with varying micellar casein/whey protein ratio (CN/WP). Both soluble and micelle-bound aggregates increased gelation pH and gel strength. Micelle-bound aggregates seemed to modify the micelle surface so that micelles were destabilized at a pH of 5.1 (instead of 4.7), while soluble aggregates precipitated at their calculated pI of approximately 5.3, and initiated an early gelation by interacting with the micelles. Decreasing the CN/WP ratio produced larger aggregates with higher whey protein: kappa-casein ratio, which gave more elastic gels. The specific effects of the micellar and soluble aggregates on gel strength are discussed with respect to their relative proportions in the heated milk.     

巴氏杀菌和超巴氏杀菌对牛乳清蛋白结构及热稳定性的影响

为了研究巴氏杀菌与超巴氏杀菌处理对牛乳清蛋白结构的影响,采用热力学和光谱学等方法测定乳清蛋白结构及稳定性。红外光谱分析结果显示巴氏杀菌处理对乳清蛋白二级结构影响不显著,而经超巴氏杀菌处理后的乳清蛋白中α-螺旋结构含量显著减少,无规则卷曲结构含量显著增多,结构转变的更为无序,其稳定性更好;荧光光谱分析结构表明经121℃、5 s超巴氏杀菌处理的乳清蛋白样品发生红移,说明超巴氏杀菌改变了乳清蛋白二级和三级结构;差示扫描量热法分析结果显示121℃、5 s热处理的乳清蛋白样品热变性温度为99.9℃,高于巴氏杀菌处理的乳清蛋白样品,表明超巴氏杀菌处理后的乳清蛋白样品的稳定性显著提高,期望为制备高品质乳提供理论基础。     

Real-time monitoring of thermal flavor generation in skim milk powder using atmospheric pressure chemical ionization mass spectrometry

The feasibility of monitoring volatile flavor compounds formed by thermal treatment of skimmed milk powder in real time by atmospheric pressure chemical ionization mass spectrometry (APCIMS) was established. Skim milk powder samples were heated isothermally (70 to 120 degrees C) at different moisture contents (2.2 and 12.7 g water/100 g dry solids). Headspace was sampled and analyzed continuously in full scan mode (30-180 amu) by APCIMS. The identity of the volatile compounds monitored by APCIMS was confirmed by coupled GC-EI-APCIMS. The concentration measured by the APCIMS was the net effect of three processes, namely formation of the compound, partition from the skim milk powder into the gas phase, and dilution due to the headspace sampling method used. Preliminary experiments established that the technique could follow the effects of heating temperature and moisture content on the formation of selected compounds from skim milk powder.     

Effect of pH on the association of denatured whey proteins with casein micelles in heated reconstituted skim milk

Skim milk was adjusted to pH values between 6.5 and 6.7 and heated (80, 90, and 100 degrees C) for up to 60 min. Changes in casein micelle size, level of whey protein denaturation, and level of whey protein association with the micelles were monitored for each milk sample. Changes in casein micelle size were markedly affected by the pH at heating. At low pH (6.5-6.55), the casein micelle size increased markedly during the early stages of heating, and the size plateaued on prolonged heating. The maximum increase in size was approximately 30-35 nm. In contrast, at high pH (6.7), much smaller changes in size were observed on heating and the maximum increase in size was only approximately 10 nm. An intermediate behavior was observed at pH values between these two extremes. The rate of denaturation of the major whey proteins, alpha-lactalbumin and beta-lactoglobulin, was essentially unaffected by the pH at heating for the small pH changes involved in this study, and the changes in casein micelle size were poorly related to the level of whey protein denaturation. In contrast, the level of denatured whey proteins associating with the micelles was markedly dependent on the pH at heating, with high levels of association at pH 6.5-6.55 and low levels of association at pH 6.7. Changes in casein micelle size were related to the levels of denatured whey proteins that were associated with the casein micelles, although there was a small deviation from linearity at low levels of association (<15%). Further studies on reconstituted and fresh milk samples at smaller pH steps confirmed that the association of whey proteins with the casein micelles was markedly affected by the pH at heating. These results indicate that the changes in casein micelle size induced by the heat treatment of skim milk were a consequence of the whey proteins associating with the casein micelles and that the level of association was markedly influenced by small pH changes of the milk. It was not possible to determine whether the association itself influenced the casein micelle size or whether parallel reactions involving micellar aggregation caused the increase in micelle size as whey protein association progressed.     

Screening method for vitamins A and D in fortified skim milk, chocolate milk, and vitamin D liquid concentrates

Vitamin A was determined in fortified chocolate milk and skim milk; vitamin D was determined in fortified chocolate milk, skim milk, and vitamin D concentrates, using reverse phase high pressure liquid chromatography (HPLC). The sample is saponified, extracted with hexane, and chromatographed in an HPLC system on a 10 micron Vydac TP reverse phase C18 column, using acetonitrile-methanol (9+1) as the mobile phase. For 6 replicates, the recoveries of vitamins A and D, using this procedure, were 99 and 98%, respectively.     

Influence of sucrose on the thermal denaturation, gelation, and emulsion stabilization of whey proteins

The influence of sucrose (0-40 wt %) on the thermal denaturation and functionality of whey protein isolate (WPI) solutions has been studied. The effect of sucrose on the heat denaturation of 0.2 wt % WPI solutions (pH 7.0) was measured using differential scanning calorimetry. Sucrose increased the temperature at which protein denaturation occurred, for example, by 6-8 degrees C for 40 wt % sucrose. The dynamic shear rheology of 10 wt % WPI solutions (pH 7.0, 100 mM NaCl) was monitored as they were heated from 30 to 90 degrees C and then cooled to 30 degrees C. Sucrose increased the gelation temperature and the final rigidity of the cooled gels. The degree of flocculation in 10 wt % oil-in-water emulsions stabilized by 1 wt % WPI (pH 7.0, 100 mM NaCl) was measured using a light scattering technique after they were heated at fixed temperatures from 30 to 90 degrees C for 15 min and then cooled to 30 degrees C. Sucrose increased the temperature at which maximum flocculation was observed and increased the extent of droplet flocculation. These results are interpreted in terms of the influence of sucrose on the thermal unfolding and aggregation of protein molecules.     

Electrophoretic pattern, thermal denaturation, and in vitro digestibility of oxidized myosin

Physicochemical changes and in vitro digestibility of chicken breast myosin oxidized with a nonenzymic free-radical-generating system (FeCl(3)/H(2)O(2)/ascorbate) were studied by SDS-PAGE, differential scanning calorimetry, and o-phthaldialdehyde assay. Oxidation caused fragmentation and polymerization of myosin. Myosin polymers were cross-linked mainly through disulfide bonds. Hydroxyl radicals destabilized myosin, lowering its denaturation temperature by up to 4 degrees C. Oxidized myosin also produced a new thermal transition in the 60-80 degrees C temperature range, which could be attributed to the formation of disulfide-stabilized polymers. The proteolytic susceptibility of myosin to pepsin, trypsin, and chymotrypsin was increased by oxidation. Under nonreducing conditions, however, oxidized myosin showed decreased digestibility. The results may help explain variations in the functionality and nutritional quality of muscle foods in meat processing in which oxidation is involved.     

Two types of radicals in whole milk powder. Effect of lactose crystallization, lipid oxidation, and browning reactions

Whole milk powder was stored in closed vials at 60 degrees C to induce crystallization of lactose within a short time scale. After an induction period of 3-4 days simultaneous crystallization of lactose, increase of water activity, formation of browning products, and increase of radical content took place. Radicals detected before lactose crystallization were characterized by a narrow ESR spectrum (g = 2.006) and could be depleted by removal of oxygen and therefore were assigned to oxidation processes. Late-stage radicals present after crystallization of lactose gave much wider spectra (g = 2.0048) and were independent of oxygen availability and assigned to late-stage Maillard reaction products. The study indicates that the processes of lactose crystallization, browning, and formation of radical species (g = 2.0048) are strongly coupled, while lipid oxidation is less dependent on the other processes.     

Temperature effect on lactose crystallization, maillard reactions, and lipid oxidation in whole milk powder

Whole milk powder with an initial water content of 4.4% (w/w) and a water activity of 0.23 stored in hermetically sealed vials for up to 147 days below (37 and 45 degrees C) and above (55 degrees C) the glass transition temperature (T(g) determined to have the value 48 degrees C) showed a strong temperature dependence for quality deterioration corresponding to energies of activation close to 200 kJ/mol for most deteriorative processes. The glass transition was found not to cause any deviation from Arrhenius temperature dependence. Lactose crystallization, which occurred as a gradual process as monitored by isothermal calorimetry, is concluded to liberate bound water (a(w) increase to 0.46) with a modest time delay (approximately 2 days at 55 degrees C) and with concomitant surface browning as evidenced by an increasing Hunter b-value. Browning and formation of bound hydroxymethyl-furfural determined by HPLC seem to be coupled, while formation of another Maillard reaction product, furosine, occurred gradually and was initiated prior to crystallization. Initiation of lipid oxidation, as detected by lipid-derived radicals (high g-value ESR spectra), and progression of lipid oxidation, as detected by headspace GC, seem not to be affected by lactose crystallization and browning, and no indication of browning products acting as antioxidants could be determined.     

Effect of proteolytic squid protein hydrolysate on the state of water and dehydration-induced denaturation of lizard fish myofibrillar protein

With the goal of preparing low-cost functional food, squid protein hydrolysate (SPH) was extracted from four squid species by protease treatment. Peptides are the major components (approximately 84-88%) of the SPH. The stabilization effects of 5% SPH (dried weight/wet weight) on the state of water and the denaturation of frozen lizard fish Saurida wanieso myofibrillar protein (Mf) were evaluated on the basis of desorption isotherm curves with respect to Ca2+-ATPase inactivation and the presence of unfrozen water, which was determined using differential scanning calorimetry during dehydration, and the effects were compared with those of sodium glutamate. The Mf with SPH was found to contain higher levels of monolayer and multilayer sorption water, resulting in decreased water activity and Ca2+-ATPase inactivation. The amount of unfrozen water in Mf with SPH increased significantly, suggesting that the peptides of SPH stabilized water molecules on the hydration sphere of Mf, which maintained the structural stability of Mf, and therefore suppressed dehydration-induced denaturation. The effect by SPH was less than that by sodium glutamate.     

Detection of pH 4.6 insoluble beta-lactoglobulin in heat-treated milk and Mozzarella cheese

Different protein aggregates including beta-lactoglobulin (beta lg) were detected in the pH 4.6 insoluble fraction recovered from actual heat-treated milk samples by gel electrophoresis and immunoblotting. A competitive enzyme-linked immunosorbent assay (ELISA) using anti-beta lg polyclonal antibodies was developed to analyze the beta lg partition in the protein fractions obtained upon acidification of both milk and Mozzarella cheese at pH 4.6. According to ELISA determinations, nearly 90% of the pH 4.6 soluble beta lg included in raw milk was found in the pH 4.6 insoluble fraction of ultrahigh temperature (UHT)-treated milk. As concerns Mozzarella cheese analysis, ELISA results indicated that about 36% of the total beta lg milk content was transferred from pasteurized milk to Mozzarella cheese, whereas less than 0.5% was transferred from raw milk. The pH 4.6 insoluble beta lg proved to be a suitable indicator of the intensity of the heat treatment applied to milk. The ELISA-based detection of this parameter was suggested for quality control of both drinking milk and raw milk cheese.