U.S. market basket study to determine residues of the insecticide chlorpyrifos.

A market basket study was conducted to measure residues of the insecticide chlorpyrifos in samples of apples, applesauce, apple juice, fresh orange juice, tomatoes, peanut butter, whole milk, ground beef, and pork sausage collected during a 12-month period from 200 grocery stores across the United States. Approximately 90% of the samples contained no detectable levels of chlorpyrifos, and all residues detected were below tolerances, the legal limits for the United States. No values greater than the limit of quantitation (LOQ) were found in applesauce (LOQ = 0.008 ppm), apple juice (LOQ = 0.003 ppm), whole milk (LOQ = 0.006 ppm), ground beef (LOQ = 0.005 ppm), or pork sausage (LOQ = 0.007 ppm) samples. Only one fresh orange juice sample contained residues greater than the LOQ at 0.015 ppm. Only about 20% of the apples (maximum = 0.052 ppm), 20% of the tomato samples (maximum = 0.058 ppm), and 50% of the peanut butter samples (maximum = 0.021 ppm) contained quantifiable residues.     

Impact of different stages of juice processing on the anthocyanin, flavonol, and procyanidin contents of cranberries

Juice is the most common form in which cranberries are consumed; however there is limited information on the changes of polyphenolic content of the berries during juice processing. This study investigated the effects of three different pretreatments (grinding plus blanching; only grinding; only blanching) for cranberry juice processing on the concentrations of anthocyanins, flavonols, and procyanidins throughout processing. Flavonols and procyanidins were retained in the juice to a greater extent than anthocyanins, and pressing resulted in the most significant losses in polyphenolics due to removal of the seeds and skins. Flavonol aglycones were formed during processing as a result of heat treatment. Drying of cranberry pomace resulted in increased extraction of flavonols and procyanidin oligomers but lower extraction of polymeric procyanidins. The results indicate that cranberry polyphenolics are relatively stable during processing compared to other berries; however, more work is needed to determine their fate during storage of juices.     

Atomic absorption spectrophotometric method for determination of polydimethylsiloxane residues in pineapple juice: collaborative study

An atomic absorption spectrophotometric method for determination of polydimethylsiloxane (PDMS) residues in pineapple juice was collaboratively studied by 9 laboratories. PDMS residues are extracted from pineapple juice with 4-methyl-2-pentanone and the extracted silicone is measured by atomic absorption spectrophotometry using a nitrous oxide/acetylene flame. Collaborators analyzed 5 samples including 1 blind duplicate. Reproducibility relative standard deviations (RSDR) were 13.1% at 31 ppm, 6.9% at 18 ppm, 14.8% at 7.9 ppm, and 16.1% at 4.9 ppm PDMS. The method has been approved interim official first action by AOAC.     

Transgenic overexpression of expansin influences particle size distribution and improves viscosity of tomato juice and paste

Suppression of the expression of a ripening-related expansin gene, LeExp1, in tomato enhanced fruit firmness and overexpression of LeExp1 resulted in increased fruit softening. Because of the incompletely understood relationship between fresh fruit texture and the consistency of processed products, we examined the effects of LeExp1 overexpression on the processing characteristics of tomato fruit. As determined by Bostwick consistency and by controlled strain rheometry, juices and pastes prepared from transgenic tomatoes with suppressed LeExp1 expression had a higher viscosity than preparations from control fruits. However, the viscosity of juice and paste prepared from fruit overexpressing LeExp1 was significantly greater than products from controls or lines with reduced LeExp1. Bostwick consistency increased by 9% (juice) and 6% (paste) in lines with suppressed LeExp1 expression but increased by 27.5% (juice) and 19.5% (paste) in lines overexpressing LeExp1, relative to controls. Determined by laser diffraction, the particles in juice and paste prepared from transgenic fruits with reduced LeExp1 expression were smaller, and preparations from fruits overexpressing LeExp1 had a size distribution indicating more large particles. Analysis of cell wall polysaccharides size indicated that LeExp1 overexpression enhanced depolymerization of water soluble pectins as well as tightly bound matrix glycans. LeExp1 overexpression may allow increased cell wall hydration, resulting in expanded particle size and increased viscosity of products. Because either LeExp1 suppression or overexpression leads to improved consistency, the interactions that contribute to optimal product rheological properties are complex.     

籽西瓜挖瓤机的研究

目前籽西瓜的生产主要是以收取瓜籽为目的,这不仅造成很大的浪费,而且其废弃物还污染了环境。因此,其综合加工利用是一项急待解决的课题。在籽西瓜综合加工利用中,挖瓤工序是一个薄弱环节,现大多采用手工完成。作者根据共轭切削原理设计出新型挖瓤机,具有高效、工作平稳、机械化程度高等特点,每小时可处理6000kg籽西瓜,为手工挖瓤工效的12倍。     

Identification of sulfur volatiles in canned orange juices lacking orange flavor

The purpose of this study was to understand why some canned orange juices are not perceived as orange juice. Sensory flavor profile data indicated that the primary odor (orthonasal) attributes were tropical fruit/grapefruit, cooked/caramel, musty, and medicine. By comparison fresh-squeezed juice lacked these odor attributes. GC-O analysis found 43 odor-active components in canned juices. Eight of these aroma volatiles were sulfur based. Four of the 12 most intense aroma peaks were sulfur compounds that included methanethiol, 1-p-menth-1-ene-8-thiol, 2-methyl-3-furanthiol, and dimethyl trisulfide. The other most intense odorants included 7-methyl-3-methylene-1,6-octadiene (myrcene), octanal, 2-methoxyphenol (guaiacol), 2-ethyl-4-hydroxy-5-methyl-3(2H)-furanone (homofuraneol), (E)-non-2-enal, (E,E)-deca-2,4-dienal, 4-hydroxy-3-methoxybenzaldehyde (vanillin), and alpha-sinensal. Odorants probably responsible for the undesirable sensory attributes included grapefruit (1-p-menth-1-ene-8-thiol), cooked [2-ethyl-4-hydroxy-5-methyl-3(2H)-furanone, 4-hydroxy-2,5-dimethyl-3(2H)-furanone (Furaneol), and 3-(methylthio)propanal (methional)], musty [7-methyl-3-methylene-1,6-octadiene and (E)-non-2-enal], and medicine (2-methoxyphenol). The canned juices also lacked several aldehydes and esters normally found in fresh orange juice.     

Effect of commercial processing on pesticide residues in selected fruits and vegetables

Commercial food processing operations such as washing, blanching, and cooking remove major portions of the pesticide residues that are currently permitted on the raw agricultural crop. These unit operations are reviewed for selected products, along with degree of residue removal at each step. For example, washing plus peeling removes 99% of carbaryl and malathion residues from tomatoes. Washing removes 83% of benomyl residue from tomatoes and further processing reduces the residue by 98% in tomato puree and catsup. Even in the most concentrated fraction from tomatoes (tomato paste), residues were below the initial level in the raw product.     

叶类蔬菜低农药残留基因型筛选研究

采用气相色谱法（GC-NPD,ECD）测定毒死蜱和氰戊菊酯残留量,研究了菠菜（Spinacia oleracea L.）和不结球白菜（Brassica campestris L. ssp. Chinensis Makino var. communis Tsen et Lee）中毒死蜱、氰戊菊酯的残留动态。结果表明,菠菜中毒死蜱残留量、不结球白菜中毒死蜱和氰戊菊酯残留量存在着明显的基因型差异。同一不结球白菜基因型,毒死蜱和氰戊菊酯的残留量达到《GB 2763—2005食品中农药最大残留限量》中规定的叶类蔬菜农药最大残留限量所需要的时间存在明显差异,且毒死蜱达到最大残留限量所需要的时间比氰戊菊酯长,因此在选择低农药残留基因型时,应首先考虑农药残留时间长、最大农药残留限量低的农药品种。菠菜品种sp0723、卡尔以及不结球白菜品种矮抗青、无锡605和青选3号属于低农药残留的基因型,在生产上推广应用有利于提高叶类蔬菜的食用安全水平。     

Major flavonoids in grape seeds and skins: antioxidant capacity of catechin, epicatechin, and gallic acid

Grape seeds and skins are good sources of phytochemicals such as gallic acid, catechin, and epicatechin and are suitable raw materials for the production of antioxidative dietary supplements. The differences in levels of the major monomeric flavanols and phenolic acids in seeds and skins from grapes of Vitis vinifera varieties Merlot and Chardonnay and in seeds from grapes of Vitis rotundifolia variety Muscadine were determined, and the antioxidant activities of these components were assessed. The contribution of the major monomeric flavonols and phenolic acid to the total antioxidant capacity of grape seeds and skins was also determined. Gallic acid, monomeric catechin, and epicatechin concentrations were 99, 12, and 96 mg/100 g of dry matter (dm) in Muscadine seeds, 15, 358, and 421 mg/100 g of dm in Chardonnay seeds, and 10, 127, and 115 mg/100 g of dm in Merlot seeds, respectively. Concentrations of these three compounds were lower in winery byproduct grape skins than in seeds. These three major phenolic constituents of grape seeds contributed <26% to the antioxidant capacity measured as ORAC on the basis of the corrected concentrations of gallic acid, catechin, and epicatechin in grape byproducts. Peroxyl radical scavenging activities of phenolics present in grape seeds or skins in decreasing order were resveratrol > catechin > epicatechin = gallocatechin > gallic acid = ellagic acid. The results indicated that dimeric, trimeric, oligomeric, or polymeric procyanidins account for most of the superior antioxidant capacity of grape seeds.     

Detection of poultry and pork in cooked and canned meat foods by enzyme-linked immunosorbent assays

Enzyme-linked immunosorbent assays (ELISA) are described for the detection of poultry and pork in cooked and canned meat foods. These assays are based on species-specific, polyclonal antibodies raised against heat-resistant antigens. The heat-resistant antigens were isolated from raw skeletal muscle tissue of pork and chicken and were found to be immunoreactive even after heating to 120 degrees C for 15 min. The poultry ELISA could detect chicken or turkey at the 126 ppm level, and the pork ELISA could detect pork at the 250 ppm level. Samples of frankfurters, bolognas, pressed meats, canned baby foods, and canned spreads were prepared by simple aqueous extractions.     

The effect of cooking on chlorpyrifos and 3,5,6-trichloro-2-pyridinol levels in chlorpyrifos-fortified produce for use in refining dietary exposure

Various types of produce were fortified with chlorpyrifos and then boiled, baked, canned, or concentrated as appropriate for the type of produce. Both uncooked and cooked samples were analyzed for chlorpyrifos and 3,5,6-trichloro-2-pyridinol, and then, chlorpyrifos cooking factors were calculated by comparing the postcooked concentration to the uncooked concentration. The cooking factors were dependent upon the commodity and cooking procedure: 0.320-1.19 for boiled samples, 0.022-1.18 for baked pulp, and 0.119-0.661 for canned samples. Concentrating chlorpyrifos-fortified orange juice 4-fold resulted in a concentration factor of only 2.6, indicating a loss of chlorpyrifos. Green bean and green pepper plants treated in the greenhouse yielded higher chlorpyrifos concentrations but similar cooking factors to lab-fortified samples. The cooking factors can be used with food consumption databases and modeling tools to refine the dietary exposure according to current product label uses.     

Extractable amounts of trans-resveratrol in seed and berry skin in Vitis evaluated at the germplasm level

Extractable amounts of resveratrol in berry skins and seeds were studied in 120 grape (Vitis) germplasm cultivars during two consecutive years to determine the distribution of resveratrol among the main grape genotypes. Interspecific rootstock cultivars had much higher extractable amounts of resveratrol in skin and seed than all other grape genotypes studied in both years. Extremely high extractable amounts of resveratrol in berry skins [>100 microg g(-1) of skin fresh weight (FW)] and seeds (>20 microg g(-1) of seed FW) were observed on two rootstock cultivars obtained from hybrids of V. monticula x V. riparia. Extractable amounts of resveratrol in berries of rootstock cultivars that are the descendants of V. riparia were also very high. The cultivated European type (V. vinifera) cultivars and their hybrids with V. labrusca had relatively low levels of extractable resveratrol in berry skin and seed, and the extractable amounts of resveratrol in berry skin and seeds were, with a few exceptions, <2 microg g(-1) of skin or seed FW. Extractable amounts of resveratrol in berry skin and seeds were closely related with fruit traits or purpose of uses and climate. Significantly higher extractable amounts of resveratrol in berry skin were found in seeded cultivars than in seedless ones, in both berry skin and seeds in winemaking grapes than in table grapes, and in red grapes than in green ones. Moreover, rainfall during fruit development resulted in higher extractable amounts of resveratrol in berry skin, whereas resveratrol synthesis and accumulation in grape seeds were not related to climate change.     

我国大樱桃深加工开发利用研究

大樱桃是深受人们喜爱的水果,但货架期较短,对其进行深加工显得尤为重要。我国大樱桃深加工产品主要有罐头、果脯、果酱、果汁、果酒、果醋等,这些产品中食品添加剂使用较为普遍。为了延长大樱桃产业链、提高产品附加值、促进大樱桃产业提质增效,整理归纳了近年来大樱桃深加工相关技术的研究文献,从果肉、果核和树叶3个方面综述了深加工开发利用研究进展,果肉的深加工主要是制作罐头、果酱、果冻、果汁及复合饮料、果脯、果酒、果醋和色素等,果核的深加工主要是提取大樱桃仁油、黄酮、多糖、蛋白及抗氧化多肽,树叶的深加工主要是提取黄酮和多糖;并针对樱桃深加工中存在的问题提出了今后的主要研究方向。     

Phenolic content and antioxidant capacity of muscadine grapes

Fruits of 10 cultivars of muscadine grapes (five bronze skin and five purple skin) grown in southern Georgia were separated into skin, seed, and pulp. Each fruit part and the leaves from the corresponding varieties were extracted for HPLC analysis of major phenolics. Total phenolics were determined colorimetrically using Folin-Ciocalteu reagent. Total anthocyanins were determined according to a pH-differential method, using a UV-visible spectrophotometer. Antioxidant capacity was determined by the Trolox equivalent antioxidant capacity (TEAC) assay. Gallic acid, (+)-catechin, and epicatechin were the major phenolics in seeds, with average values of 6.9, 558.4, and 1299.4 mg/100 g of fresh weight (FW), respectively. In the skins, ellagic acid, myricetin, quercetin, kaempferol, and trans-resveratrol were the major phenolics, with respective average values of 16.5, 8.4, 1.8, 0.6, and 0.1 mg/100 g of FW. Contrary to previous results, ellagic acid and not resveratrol was the major phenolic in muscadine grapes. The HPLC solvent system used coupled with fluorescence detection allowed separation of ellagic acid from resveratrol and detection of resveratrol. Reported here for the first time are the phenolic content and antioxidant capacity of muscadine leaves. Major phenolics in muscadine leaves were myricetin, ellagic acid, kaempferol, quercetin, and gallic acid, with average concentrations of 157.6, 66.7, 8.9, 9.8, and 8.6, respectively. Average total phenolics were 2178.8, 374.6, 23.8, and 351.6 mg/g gallic acid equivalent in seed, skin, pulp, and leaves, respectively. Total anthocyanin contents were 2.1 and 132.1 mg/100 g of FW in the skins of bronze and purple grapes, respectively, and 4.3 and 4.6 mg/100 g of FW in seeds and pulps, in that order. Antioxidant capacity values were, on average, 2.4, 12.8, 281.3, and 236.1 microM TEAC/g of FW for pulps, skins, seeds, and leaves, respectively.     

Changes in pectins and product consistency during the concentration of tomato juice to paste

Concentrating tomato juice to paste during the tomato season allows for preservation and long-term storage, but subsequent dilution for formulation of value-added products is known to result in a loss of consistency. To understand the reasons for this, samples of unconcentrated juice, processing intermediates, and concentrated paste were collected from an industrial processing plant during normal commercial production. All samples were diluted with water to 5 degrees Brix and then analyzed for consistency and pectin content. Whole juice consistency, measured with a Bostwick consistometer, decreased through the course of juice concentration, with the largest change occurring early in the process, as the juice was concentrated from 5 to 10 degrees Brix. This decrease in consistency occurred during the production of paste from both hot- and cold-break juices. The change in Bostwick value was correlated with a decrease in the precipitate weight ratio. The loss of consistency during commercial processing was not the direct result of water removal because a sample of this same 5 degrees Brix juice could be concentrated 2-fold in a vacuum oven and then diluted back to 5 degrees Brix with no change in consistency or precipitate ratio. Total pectin content did not change as the juice was concentrated to paste, but the proportion of the total pectin that was water soluble increased. The greatest increases in pectin solubility occurred during the hot break and late in the process where the evaporator temperature was the highest.     

Varietal differences among the phenolic profiles and antioxidant activities of seven table grape cultivars grown in the south of Italy based on chemometrics

Seven table grape cultivars grown in Apulia region were considered: Italia, Baresana, Pizzutello, Red Globe, Michele Palieri, Crimson Seedless, and Thompson Seedless. Seeds, skins and pulps were extracted and analyzed for their phenolic profiles and antioxidant activities. The hierarchy in the phenolic contents was seeds, skins, and pulps. These results indicate that the intake of the whole berries (seeds included) must be strongly recommended. The highest phenolic contents were detected on Italia and Michele Palieri cv., respectively within the white and the red/black table grapes. Seeds gave a high contribution to the berry antioxidant activity, as they had higher phenolic content than skins and contained high quantities of proanthocyanidines, but the strongest antioxidant activity was shown by the pulp juices due to their content in hydroxycinnamyl acids. The principal component analysis applied to the phenolic composition and antioxidant activity of skins, pulps, and seeds allowed a good separation of Italia and Michele Palieri cultivars. According to the cluster analysis, cultivars were grouped into two clusters, one including Michele Palieri and the other one including Italia, Baresana, Pizzutello, and Thompson Seedless.     

Changes in antioxidant and metabolite profiles during production of tomato paste

Tomato products and especially concentrated tomato paste are important sources of antioxidants in the Mediterranean diet. Tomato fruit contain well-known antioxidants such as vitamin C, carotenoids, flavonoids, and hydroxycinnamic acids. The industrial processing of this fruit into tomato paste involves several treatments that potentially affect the final profile of antioxidants and other metabolites in the commercial product. Here we have used both biochemical and metabolomic techniques to assess the effect of each separate step in the industrial production chain starting from fresh fruit to the final tomato paste. Material was collected from five independent tomato paste production events spread over two successive years. Samples comprised the intact ripe fruits and semifinished products after fruit-breaking, separation of the pulp from skin and seeds, evaporation, and finally after canning and pasteurization. The effect of each processing step was determined by different types of analysis. First, the total antioxidant capacity and total phenolic content were determined by commonly used spectrophotometric methods. Second, individual antioxidants in the extracts were identified and compared using an HPLC with online antioxidant detection. Third, in each sample the levels of the major individual antioxidants present, i.e., vitamin C, phenolic compounds (such as rutin and chlorogenic acid), tocopherols, and carotenoids, were quantified. Fourth, an untargeted metabolomic approach using LC-QTOF-MS was used to identify those production steps that have the largest impact on the overall metabolic profile in the final paste as compared to the original fruits. This multifaceted approach has revealed that each processing step induces specific alterations in the metabolic profile, as determined by the different analysis procedures, and that in particular the fruit-breaking step and the removal of seed and skin significantly affect the levels of antioxidants and many other metabolites present in commercial tomato paste.     

Processing and storage effects on the ellagitannin composition of processed blackberry products

Changes in blackberry ellagitannin composition in response to juicing (clarified and nonclarified), pureeing, canning (in water or syrup), and freezing as well as changes in processed products during 6 months of storage were investigated. Canning, pureeing, and freezing had little effect on ellagitannins, but processing berries into nonclarified and clarified juices resulted in total ellagitannin losses of 70 and 82%, respectively, due to removal of ellagitannin-rich seeds in the presscake. Minimal changes in total ellagitannin content were observed during storage of thermally processed products, but compositional changes indicative of ellagitannin depolymerization were apparent. The ellagitannin content and composition of frozen berries remained stable over 6 months of storage. Ellagitannins are well retained in canned, pureed, and frozen blackberries, but methods are needed to prevent losses during juice processing and/or exploit the ellagitannin-rich coproducts.     

Liquid chromatographic-electrochemical determination of ethylenethiourea in foods by revised official method

AOAC official method 29.119-29.125 was revised to determine ethylenethiourea (ETU) directly by a liquid chromatographic-electrochemical (LC-EC) determinative technique and to improve ETU recovery. ETU is extracted from food products with a methanol-aqueous sodium acetate solution. A portion of the concentrated filtrate is added to a column of diatomaceous earth, and ETU is eluted with 2% methanol in methylene chloride to separate it from food coextractives, which are retained on the column. The eluate is collected in a siliconized flask and evaporated, the residue is dissolved in water, and 20 microL of solution is injected onto an LC graphitized carbon column. ETU is eluted from the LC column with a mobile phase of acetonitrile-aqueous 0.1M phosphoric acid-water (5 + 25 + 70), and the eluted ETU is detected by using an amperometric electrochemical detector equipped with a gold/mercury working electrode. Recovery data were obtained by fortifying 13 food products with ETU: baked potatoes; canned applesauce, mushrooms, creamed spinach, green beans, spinach, and tomatoes; cooked fresh cabbage and frozen collards; fresh celery and lettuce; grape jelly; and powdered sugar cake donuts. Raw celery was found to cause low ETU recoveries. Average percent recoveries of ETU from the other 12 food products were 92 with a standard deviation of 12 for the low (0.05 and 0.1 ppm) fortification levels and 90 with a standard deviation of 6 for the higher (0.5 and 1 ppm) fortification levels. The limits of quantitation were 0.01 and 0.02 ppm for food products with low and high sugar content, respectively.     

Polyphenol screening of pomace from red and white grape varieties (Vitis vinifera L.) by HPLC-DAD-MS/MS

Phenolic compounds of 14 pomace samples originating from red and white winemaking were characterized by HPLC-MS. Up to 13 anthocyanins, 11 hydroxybenzoic and hydroxycinnamic acids, and 13 catechins and flavonols as well as 2 stilbenes were identified and quantified in the skins and seeds by HPLC-DAD. Large variabilities comprising all individual phenolic compounds were observed, depending on cultivar and vintage. Grape skins proved to be rich sources of anthocyanins, hydroxycinnamic acids, flavanols, and flavonol glycosides, whereas flavanols were mainly present in the seeds. However, besides the lack of anthocyanins in white grape pomace, no principal differences between red and white grape varieties were observed. This is the first study presenting comprehensive data on the contents of individual phenolic compounds comprising all polyphenolic subclasses of grapes including a comparison of several red and white pomaces from nine cultivars. The results obtained in the present study confirm that both skins and seeds of most grape cultivars constitute a promising source of polyphenolics.