酒糟和醋糟营养成分差异及其瘤胃降解特性分析

本试验旨在评价酒糟、醋糟等非常规饲料资源的饲用价值，为酒糟醋糟资源应用于肉牛养殖提供数据参考。试验选用山西不同地区酒糟、醋糟试样5个，试样编号分别为白酒糟、啤酒糟、醋糟1、醋糟2、醋糟3，发酵原料分别为白酒糟（高粱）、啤酒糟（大麦+大米）、醋糟1（高粱+大麦）、醋糟2（大麦+玉米）、醋糟3（高粱+玉米）。通过实验室常规方法测定样品常规营养成分以及利用体外产气法和尼龙袋法评价其饲用价值，同时建立体外法与尼龙袋法测定干物质降解率的回归方程。结果表明：5个样品的干物质（DM）含量为23.25% ~ 42.96%，粗蛋白质（CP）含量分别为啤酒糟（31.84%）>白酒糟（14.58%）>醋糟3（14.40%）>醋糟1（12.21%）>醋糟2（8.46%）。醋糟1的中性洗涤纤维（NDF）、酸性洗涤纤维（ADF）含量均为最高，其次为醋糟2、醋糟3，白酒糟NDF含量最低。啤酒糟的72 h产气量（GP72）显著高于白酒糟（P < 0.05）。体外产气法和尼龙袋法测定的酒糟72 h干物质降解率（IVDMD72、DMD72）显著高于醋糟（P < 0.05）。5个试样的IVDMD72与DMD成正相关，随着降解时间增加其相关性逐渐增加。综上，酒糟的CP含量较高（14.58% ~ 31.84%），醋糟NDF、ADF含量相对较高（59.59% ~ 64.91%，38.78% ~ 54.78%）。结合GP、IVDMD及DMD结果，酒糟消化性能优于醋糟。以IVDMD建立估算DMD的回归公式为DMD72=-19.215+1.645IVDMD72（R2=0.912，P < 0.05）|以IVDMD建立估算DM有效降解率（ED）的回归公式为ED=-12.448+1.045IVDMD72（R2=0.929，P < 0.01）。 [关键词] 醋糟|酒糟|体外产气法|尼龙袋法     

基于扩散理论的华北春玉米生理成熟后籽粒脱水过程分析

玉米机收籽粒可以显著提高玉米的生产效率,是玉米生产的发展方向。生理成熟后的籽粒含水率是决定机收质量的关键,受品种、密度和气候等多种因素影响。准确估算生理成熟后玉米籽粒含水率,进而分析其主要影响因素,最终确定玉米收获时间和筛选适宜机收的品种,对玉米主产区华北的春玉米籽粒机收发展具有重要意义。因此,于2017年和2018年在河北省泊头、南大港、玉田和山西榆次进行了两年田间春玉米试验,每年设置7个共性品种,每个品种3个密度,对生理成熟后籽粒含水率、品种性状、气象和管理要素进行了监测,并利用基于扩散理论考虑空气温湿度的脱水模型对籽粒含水率进行了模拟,进而计算脱水曲线下的面积(AUDDC),用以筛选脱水优异的玉米品种。结果表明,基于扩散理论的籽粒脱水模型对玉米生理成熟后籽粒含水率的模拟效果较好;年份、地点和品种对生理成熟时籽粒含水率(M_0)和水分扩散速率(k)具有显著影响,密度对脱水参数影响不显著。逐步线性回归分析得到灌浆期参考作物蒸发蒸腾量(ET_0)、最高气温和灌水量对M_0具有显著的正效应,生理成熟后30 d内ET0和灌浆中后期降雨对k具有显著的正效应,全生育期降雨对k具有显著的负效应。品种性状中对M_0影响最大的为苞叶层数(正效应),对k影响最大的为叶片数(负效应)。通过模型计算得到,生理成熟后10d华北地区春玉米籽粒含水率可以下降到28%,籽粒含水率下降到25%的概率为50%。由模型计算得到各品种生理成熟后10 d内的AUDDC,与AUDDC平均值比较发现‘京农科728’‘张1453’‘华农887’‘广德5’和‘金科玉3306’为脱水表现优异的品种。     

Effects of distillers dried grains with solubles and mineral sources on gaseous emissions

Distillers dried grains with solubles (DDGS), an important ethanol industry co-product, has been used as a high-protein feed in poultry production. Limited studies exist on their effect on air emissions, however. In the current study, 4 diets (2 × 2 factorial design: 0 or 20% DDGS + inorganic or organic mineral sources) were fed to Hy-line W36 hens from 50 to 53 wk of age and the effects of DDGS level and mineral sources on air emissions were monitored continuously for a 23-d period in environmentally controlled chambers. The NH₃, H₂ S, CH₄, nonmethane hydrocarbons, N₂ O, CO₂, and CO₂-equivalent emissions ranged from 0.51 to 0.64 g/day-hen, 0.71 to 0.84 mg/day-hen, 33.9 to 46.0 mg/day-hen, 54.1 to 60.0 mg/day-hen, 66.0 g to 72.2 g/day-hen, and 83.1 to 92.1 g/day-hen, respectively. Feeding DDGS to laying hens resulted in 14% decreased NH₃ emissions but a 19% increase in CH₄ emissions without affecting other gaseous emissions. More than 30% of N, 80% of P, 80% of K, and 50% of Ca was retained in the manure. In conclusion, feeding laying hens a diet containing 20% DDGS may be beneficial for the environment. Substitution for organic trace minerals did not affect hen performance or air emissions.     

细叶百合低温解除休眠过程中鳞茎细胞淀粉粒及花芽分化的变化

以细叶百合为试材,通过低温(5℃)解除鳞茎休眠,研究了休眠解除过程中鳞茎细胞的淀粉粒的变化及细叶百合花芽分化的变化过程。通过石蜡切片和实体显微结构观察,结果表明,低温冷藏期间,顶芽生长锥的高度和宽度逐渐增加,细叶百合花芽分化主要分为4个时期,0~48d为小花原基分化期,60d为外轮花被原基分化期,72d为内轮花被原基分化期,84d为雄蕊和雌蕊原基分化期;鳞片及顶芽细胞内淀粉粒数量随着冷藏时间的延长逐渐减少。冷藏0~24d内,鳞茎细胞没有进行有丝分裂,冷藏36d以后细胞分裂数量逐渐增加,冷藏84d分裂期细胞数量增加到2.6个。     

蒸汽压片技术及其在畜禽生产中的应用

蒸汽压片技术起源于美国,最初应用于反刍动物养殖中。蒸汽压片技术是一种谷物加工方法,谷物经过蒸汽调质、辊式压轧和干燥冷却等过程制成片状谷物,通过加工过程中的各种物理、化学作用,提高谷物中淀粉和其他化学成分的可消化性,增加营养物质与消化道消化液的接触面积,并在一定程度上改变其消化位点,从而增加动物对谷物的消化和吸收率。因此,蒸汽压片技术可以改善谷物的营养价值,提高动物对谷物的利用效率,减少饲料浪费和环境污染。作者综述了蒸汽压片技术的工艺流程、参数和评价指标,以及蒸汽压片处理对谷物营养成分的影响及其在畜禽生产中的应用。     

Trichothecene genotypes of Gibberella zeae from winter wheat fields in the eastern USA

Fusarium head blight (FHB), caused principally by Gibberella zeae (Fusarium graminearum), is a devastating disease of small grains such as wheat and barley worldwide. Grain infected with G. zeae may be contaminated with trichothecene mycotoxins such as deoxynivalenol (DON) and nivalenol (NIV). Strains of G. zeae that produce DON may also produce acetylated derivatives of DON: 3‐acetyl‐DON (3‐ADON) and 15‐acetyl‐DON (15‐ADON). Gradients (clines) of 3‐ADON genotypes in Canada have raised questions about the distribution of G. zeae trichothecene genotypes in wheat fields in the eastern USA. Tri3 and Tri12 genotypes were evaluated in 998 isolates of G. zeae collected from 39 winter wheat fields in New York (NY), Pennsylvania (PA), Maryland (MD), Virginia (VA), Kentucky (KY) and North Carolina (NC). Ninety‐two percent (919/998) of the isolates were 15‐ADON, 7% (69/998) were 3‐ADON, and 1% (10/998) was NIV. A phylogenetic analysis based on portions of three genes (PHO, RED and URA) from 23 isolates revealed two species of Fusarium (F. graminearum sensu stricto and one isolate of F. cerealis (synonym F. crookwellense)). An increasing trend of 3‐ADON genotypes was observed from NC (south) to NY (north). Punctuated episodes of atmospheric transport may favour a higher frequency of 3‐ADON genotypes in the northeastern USA, near Canada, compared with the mid‐Atlantic states. Discoveries of the NIV genotype in NY and NC indicate the need for more intensive sampling in the surrounding regions.     

啤酒麦糟纤维素酶水解的研究

以经过适当预处理后的啤酒麦糟作原料，采用里氏木霉产生的纤维素酶进行水解．其纤维素的水解反应可描述为：①前６小时内迅速水解；②６～２４小时内较慢水解；③２４小时后缓慢水解．在水解过程中，存在纤维二糖的积累．且以前６小时积累较多，纤维二糖的最高浓度可达７．５２ｇ／Ｌ．水解前期采取分批添料方法，可提高水解得率和底物浓度．并大大提高水解液中还原糖的浓度．     

Whole wheat bread: Effect of bran fractions on dough and end-product quality

Consumption of whole-wheat based products is encouraged due to their important nutritional elements that benefit human health. However, the use of whole-wheat flour is limited because of the poor processing and end-product quality. Bran was postulated as the major problem in whole wheat breadmaking. In this study, four major bran components including lipids, extractable phenolics (EP), hydrolysable phenolics (HP), and fiber were evaluated for their specific functionality in flour, dough and bread baking. The experiment was done by reconstitution approach using the 2⁴ factorial experimental layout. Fiber was identified as a main component to have highly significant (P < 0.05) and negative influence on most breadmaking characteristics. Although HP had positive effect on farinograph stability, it was identified as another main factor that negatively impacted the oven spring and bread loaf volume. Bran oil and EP seemed to be detrimental to most breadmaking characteristics. Overall, statistical analysis indicates that influence of the four bran components are highly complex. The bran components demonstrate multi-way interactions in regards to their influence on dough and bread-making characteristics. Particularly, Fiber appeared to have a high degree of interaction with other bran components and notably influenced the functionality of those components in whole wheat bread-making.     

青稞秸秆替代苇状羊茅对全混合日粮青贮早期发酵品质及有氧稳定性的影响

本试验旨在研究不同比例青稞秸秆替代苇状羊茅对全混合日粮青贮早期发酵品质及有氧稳定性的影响。试验设对照组(TH0)和3个青稞秸秆不同比例替代组TH_5、TH_(10)和TH_(15)。青贮14d开窖取样,分析其发酵品质、化学成分及微生物数量,将剩余的发酵TMR暴露于空气,用多通道温度记录仪记录温度变化;并分别在有氧暴露的第2,5和8天取样评定其有氧稳定性。结果表明,与对照组(TH0)相比,TH_5的pH、乳酸、乙酸、总挥发性脂肪酸和乙醇含量无显著(P0.05)差异;TH_(10)和对照相比pH差异不显著(P0.05),但乳酸、乙酸、总挥发性脂肪酸和乙醇含量显著(P0.05)低于对照组;TH_(15) pH显著(P0.05)高于对照组,乳酸、乙酸、总挥发性脂肪酸和乙醇含量显著(P0.05)低于对照组;各组氨态氮/总氮和乳酸/乙酸无显著(P0.05)差异,均以乳酸发酵为主,发酵品质良好。有氧暴露第2天后各组pH和氨态氮/总氮持续上升;乳酸、乙酸和水溶性碳水化合物含量持续下降;酵母菌和好氧细菌数量显著(P0.05)升高。除TH_(15)外,其他各组温度在第35h开始上升,TH_(15)温度上升延迟,并且温度上升峰值最小。和其他组相比,TH_(15)有氧稳定性最好。综合考虑发酵品质、有氧稳定性及对青稞秸秆资源的最大化利用,建议采用TH_(15)设计配方最为适宜。     

配合饲料中添加玉米DDGS对刺参(Apostichopus japonicus)生长、体组成及免疫指标的影响

在基础饲料中分别添加0、10％、20％、30％、40％的玉米干酒精糟及其可溶物(Dried distiller's grains with solubles,DDGS),配制成5种等氮等能的实验饲料(DDGS0、DDGS10、DDGS20、DDGS30 和DDGS40),饲喂初始体重为(9.69±0.28)g的刺参56 d,研究玉米DDGS作为替代蛋白源对其生长、体成分及免疫指标的影响.结果显示,随着玉米DDGS添加水平的升高,刺参增重率和特定生长率略有下降,但各组间差异不显著(P＞0.05).各实验组刺参体壁指数、肠道指数、肠长比以及体壁水分、粗蛋白、粗脂肪和粗灰分含量均不受玉米DDGS添加的影响(P＞0.05).体腔液中溶菌酶的活性呈先上升后稳定的趋势,其中,DDGS20和DDGS40组显著高于DDGS0和DDGS 10组(P＜0.05),DDGS30组与其他各组无显著差异(P＞0.05).酸性磷酸酶的活性呈先上升后下降的趋势,在DDGS20组达到最大值,其中,DDGS20组显著高于其他各组(P＜0.05),DDGS40组显著高于DDGS0组(P＜0.05),其他各组间无显著差异(P＞0.05).酚氧化酶的活性随着DDGS添加量的增加呈上升趋势,各添加组均显著高于DDGS0组(P＜0.05),DDGS40组显著高于DDGS 10组(P＜0.05),其他各组间无显著差异(P＞0.05).饲料中添加玉米DDGS对体腔液中碱性磷酸酶和超氧化物歧化酶的活性无显著影响(P＞0.05).本研究表明,饲料中添加0-40％的玉米DDGS均不影响刺参的生长和体壁成分,且添加20％-40％的玉米DDGS能提高刺参体腔液中免疫酶的活性.