表面涂层木工刀具的研究进展

介绍几种表面涂层木工刀具的加工方法和使用状况,分析表面涂层刀具的切削特点和磨损形态,概述了国内外研究进展.研究成果表明,涂层处理可以延长刀具使用寿命,减少刃磨和换刀时间,提高生产效率和表面加工质量.     

土壤干旱与柿叶片膜脂及脂质过氧化的关系

在不同灌水条件下,对盆栽柿幼树叶片组织相对含水量,细胞透性,超氧化物歧化酶(SOD)和过氧化氢酶(CAT)活性,膜脂脂肪酸组分和脂质过氧化作用产物——丙二醛(MDA)含量进行测定,结果表明:当水势Ψ_S下降时,细胞透性(PERM)增大,SOD和CAT活性下降,脂质过氧化作用增强,膜脂中不饱和脂肪酸含量下降,饱和脂肪酸含量升高。试验证明:土壤水势(?)_S=-3.80±0.47bar,各指标变化最明显。本试验条件下,幼柿叶片SOD活性,CAT活性,MDA含量,PERM,不饱和脂肪酸指数(IUFA)与组织相对含水量(RWC)和土壤水势(Ψ_s)间具显著相关关系。     

木聚糖酶在膜反应器内的酶解特性

分别研究了粗木聚糖酶和纯化的木聚糖酶在超滤膜反应器(UMR)和常规反应器(CSBR)中的酶解特性。粗木聚糖酶或纯木聚糖酶在UMR中酶解木聚糖时,反应进行了525 m in时所得产品中低聚木糖各组分的质量分数(木二糖~木五糖)均在20%左右,木糖质量分数约为9.5%。在UMR中粗木聚糖酶降解木聚糖时的低聚木糖得率、低聚木糖占总糖的比例和低聚木糖生产能力比纯木聚糖酶在CSBR中分别高19.1%、14.8%和13.5%;而木糖的得率却低55.2%。粗木聚糖酶在UMR中酶解木聚糖时,所得低聚木糖产品中木二糖~木五糖组分含量基本相等;纯木聚糖酶在CSBR中酶解木聚糖时,所得低聚木糖产品中木二糖含量较高。同纯木聚糖酶在CSBR中酶解特性相比,粗木聚糖酶在UMR中酶解木聚糖可以制得高质量低聚木糖。     

木聚糖酶解反应与膜分离技术研究

过程耦合是应用技术领域研究的热点之一 ,膜及膜分离技术的开发促进了过程耦合技术的发展。如膜超滤、膜萃取、膜蒸馏、渗透蒸发。在超滤膜反应器中木聚糖酶解制备低聚木糖的条件 :酶体积用量1 0 % ,木聚糖质量浓度 3 0 .0 g/L ,稀释率 1h-1,pH值 5 .0 ,反应温度 48℃ ,酶解时间 1 3 5min。在该条件下 ,低聚木糖得率、木糖得率、低聚木糖生产能力及低聚木糖与总糖之比分别为 2 8.5 % ,4.1 % ,3 .80g/ (L·h)和0 .87,并比较了分批加料、浓缩酶、常规反应器中酶解反应效果 ,浓缩木聚糖酶酶解结果表明 :木糖得率很低(0 .2 % ) ,低聚木糖得率为 3 5 .9%。     

木质素电氧化的影响因素研究

木质素是天然高分子聚合物，具有一定的化学反应惰性。本文率先研究草类木质素在膜助电解时的电化学氧化作用。其结果表明：膜助电解对黑液中的有机物具有一定的氧化作用，能使木质素中的芳环被氧化而打开；同时木质素的氧化作用与施加的电压、阳极的电极材料等因素有关。通过对木质素氧化产物结构的进一步研究，可为木质素的电化学改性提供了新的方法。     

Changes of plasma membrane H<Superscript>+</Superscript>-ATPase activities of <Emphasis Type="Italic">Glycine max</Emphasis> seeds by PEG treatment

The soybean （Glycine max） Heihe No. 23 is sensitive to imbibitional chilling injury. Polyethylene glycol （PEG） treatment can improve chilling tolerance of soybean seeds to a certain extent. The changes of hydrolytic ATPase in plasma membranes and H^＋-pumping responses in soybean seeds were investigated during PEG treatments. Effects of exogenous calcium and exogenous ABA on the hydrolytic ATPase were also examined in order to understand the mechanism of chilling resistance. Highly purified plasma membranes were isolated by 6.0% aqueous two-phase partitioning from soybean seeds, as judged by the sensitivity of hydrolytic ATPase to sodium vanadate. PEG treatment resulted in a slight increase of the hydrolytic ATPase activity in 12 h. Then the activity decreased gradually, but still higher than the control. The H^＋-pumping activity increased steadily during PEG treatment. Exogenous calcium had both activating and inhibiting effects on the hydrolytic ATPase, but the activity was inhibited in soybean seeds treated with exogenous ABA. Results suggested that PEG treatment, not the exogenous calcium and ABA, up-regulated H^＋-ATPase activities in soybean seeds.     

低浓度SO2对油桐叶片细胞膜脂肪酸含量的影响

膜系统是细胞内光合和呼吸等生理活动的重要场所之一,SO2对光合系统的破坏首先会引起细胞膜系统的变化.气相色谱测定表明,体积分数为0.3×10-6的SO2对油桐叶片处理10d以上,会使不饱和脂肪酸含量UFA、不饱和脂肪酸指数IUFA、C18:3、C18:3/IUFA上升,使饱和脂肪酸含量、C16:1trans、C16:1trans/IUFA下降;但随着SO2熏气时间的延长,会使不饱和脂肪酸含量UFA、不饱和脂肪指数IUFA、C18:3、C18:3/IUFA下降,饱和脂肪酸含量上升,熏气111d后,处理的UFA、IUFA、C18:3、C18:3/IUFA分别是对照的94.74%、92.52%、87.87%、94.97%;处理的饱和脂肪酸、C16:1trans、C16:1/IUFA分别是对照的1.16、1.15、1.24倍.熏气112d后,会使极性脂和中性脂中的不饱和脂肪酸C18∶3含量,不饱和脂肪酸含量UFA和不饱和脂肪酸指数IUFA及C18:3/IUFA值下降.因此,长期低体积分数SO2处理会使细胞膜的脂肪酸组成发生变化,使不饱和脂肪酸含量下降,饱和脂肪酸含量上升,从而使细胞膜的功能发生变化.     

木材渗透性可控制原理研究

本文研究了木材渗透性可控制机制,探寻了渗透性可控制原理。结果表明,影响渗透性高低的最主要因素为纹孔膜微孔半径和数量,微孔大而多者,渗透性高;微孔愈小,微孔里气-液界面上毛细管张力愈高,对液体流动的影响愈大,浸注愈难,欲使浸注液深注入木材,必须施一与此微孔半径相应足以克服此张力的压力。若欲改善低渗透树种木材的难浸注性,似应从纹孔入手,用化学的、物理的和生物的等方法增大和增多有效纹孔膜微孔半径和数量,以减小毛细管张力,降低使用压力,增大流量率,提高渗透性。     

Protectivity conferred by immunization with intranasal recombinant outer membrane protein H from Pasteurella multocida serovar A:1 in chickens

Recombinant outer membrane protein H (rOmpH) is a potential fowl cholera vaccine candidate. The present study was aimed at developing rOmpH formulations for intranasal administration. The rOmpH was purified and formulated with either Escherichia coli enterotoxin B (LTB) or CpG oligodeoxynucleotides (ODN) as an adjuvant. Antibody responses in chickens intranasally immunized with rOmpH in combination with 2 different adjuvants were significantly increased (P<0.05) post immunization. Chicken survival rates showed that rOmpH formulated with ODN and LTB elicited 90% and 70% protection, respectively. Our findings indicated that rOmpH formulated with ODN elicited protection better than that formulated with LTB. Therefore, the vaccines formulations in the present study can be considered new intranasal vaccine formulations for fowl cholera in chickens.