被膜预处理对冷冻菲律宾蛤仔品质的影响及参数优化

为提高冷冻菲律宾蛤仔品质,分别以魔芋葡甘聚糖、壳聚糖及魔芋葡甘聚糖与壳聚糖(1∶1)溶液对菲律宾蛤仔进行被膜预处理后再进行冷冻试验。分析了不同预处理对冷冻菲律宾蛤仔品质的影响规律。结果表明,被膜预处理可有效改善冷冻菲律宾蛤仔品质,降低冷冻菲律宾蛤仔VBN值,提高产品合格率;在相同浓度条件下,以魔芋葡甘聚糖被膜预处理效果最优,并获得到了冷冻菲律宾蛤仔的优化预处理工艺参数。     

牡蛎壳特性总结:热力特性

探讨了牡蛎的热力特性和热传递以应用于牡蛎去壳。根据对所使用的牡蛎进行的研究,牡蛎壳的导热率在0.9~2.27 W/m℃间变化。牡蛎壳密度在1710~1940 kg/m3之间变化。使用加热或冷冻法似乎可以令闭合的牡蛎壳开启。加热去壳比冷冻去壳更可靠,但热必须通过壳体外部作用于壳体的闭合     

可食性狭鳕鱼皮明胶—壳聚糖复合膜的制备与性质

研究了狭鳕鱼皮明胶可食性膜的性质，采用壳聚糖以不同比例与狭鳕鱼皮明胶共混，以改善狭鳕鱼皮明胶膜的性能。结果表明，狭鳕鱼皮明胶具有很好的成膜性，但其力学性能和热稳定性较低。壳聚糖与鱼皮明胶混合后相容性较好，复合膜的透光率达88%以上。鱼皮明胶中分别加入80%壳聚糖和60%壳聚糖后，膜的抗拉强度和伸长率提高82.5%和330%，热变性温度提高10 ℃。壳聚糖使鱼皮明胶膜水溶性和水蒸气透过系数急剧降低，但吸湿性略有升高。红外光谱、X射线衍射和扫描电镜分析表明，狭鳕鱼皮明胶与壳聚糖并不是简单的混合，而是通过化学结合生成了新的大分子化合物，可以制备稳定的复合膜。     

壳聚糖絮凝法回收鱼糜漂洗水中水溶性蛋白质的工艺研究

采用壳聚糖作为絮凝剂进行鱼糜漂洗水中水溶性蛋白质的回收试验。分别通过体系的pH、回收温度和壳聚糖絮凝剂加入量的单因素试验及这3个因素的正交试验，研究其对蛋白质回收率、透光率和化学耗氧量（COD）去除率的影响，得出壳聚糖絮凝法回收40mL已知蛋白质质量浓度（9．0mg·mL-^1）的鱼糜漂洗水中水溶性蛋白质的最佳工艺条件为体系pH8．0，回收温度35℃，1％壳聚糖添加量为1．5mL。该工艺获得的蛋白质回收率为73．17％，透光率87．50％，COD去除率47．20％。     

海带岩藻聚糖硫酸酯电渗析分离工艺

采用电渗析法对盐沉后的海带酶解液中岩藻聚糖硫酸酯进行分离,探索工业化分离生产岩藻聚糖硫酸酯的方法,以解决目前乙醇沉淀法存在的安全性和高成本等问题。以脱盐率、糖保留率为检测指标,采用响应面法优化了电渗析工艺参数。结果显示,在操作电压80 V、料液流量3.2 L/min、固形物浓度10 mg/ml、p H=5的条件下,电渗析连续循环3次,海带酶液解干基中多糖含量由40.17%提高至47.11%,硫酸根含量由3.36%提高至4.97%。电渗析后海带酶解液干基中的金属离子含量为Ca 0.13 mg/g、Mg 16.04μg/g、Cu 0.29μg/g、Se 11.7μg/g、Cr 8.06μg/g,Pb未检出,较电渗析前均有降低。电渗析对脱除褐藻胶的海带酶解液进行脱盐纯化处理,可有效地分离纯化出岩藻聚糖硫酸酯。     

贻贝肉在被膜保鲜加工中的镀膜与定型

本文采用不同浓度的褐藻酸钠溶液和氯化钙溶液对贻贝肉被膜保鲜的镀膜与定型进行了研究探讨，分析了说明贻贝肉在镀膜过程中的重量变化情况，定型液浓度与定型时间和被膜液浓度与被膜厚度的关系以及定型液浓度与定型情况。     

酸、碱性对甲壳素脱乙酰基及水解的影响和葡胺糖的制备

本文研究了甲壳素、壳聚糖在不同酸、碱条件下通过测定特性粘度[η]来表征其对降解性能的影响及通过测定游离氨基研究其对脱乙酰基程度的影响,为壳聚糖制备选择工艺条件和应用性能提供重要参数。本文还研究了盐酸存在下彻底水解制备葡胺糖的条件,并对葡胺糖的还原性、旋光性和其衍生物葡胺     

壳聚糖固定化胰蛋白酶制备牡蛎肽的研究

以壳聚糖为载体固定化胰蛋白酶,制备牡蛎肽,然后以肽得率为指标,分别研究了pH值,酶加量,酶解时间和温度等单因子对固定化胰蛋白酶酶解牡蛎蛋白质的影响。实验结果表明,酶解牡蛎蛋白的最佳工艺条件是:底物浓度为200μg/mL,加固定化胰蛋白酶量7mg/3mL,酶解时间3h,pH 8.0,温度40℃。在此条件下水解牡蛎蛋白,肽得率可达到20.39%。     

壳聚糖和益生菌对暗纹东方鲀抗病力和免疫功能的影响

为了解壳聚糖和益生菌刺激和增强免疫应答的可能作用,本试验在基础饲料中添加0.2%、0.5%、1.0%的壳聚糖,0.1%、0.2%、0.4%的益生菌,甘露聚糖与益生菌混合物,壳聚糖与益生菌的混合物,在室内水泥池中喂养暗纹东方鲀(3.15±0.05)g 2个月,根据抗菌活力筛选出免疫增强饲料组(0.2%壳聚糖,0.1%、益生菌,甘露聚糖与益生菌混合物,壳聚糖与益生菌混合物)测定免疫功能。结果表明,甘露聚糖与益生菌混合物仅提高头肾T淋巴细胞转化,壳聚糖与益生菌混合物显著增强头肾T、B淋巴细胞转化和脾脏B淋巴细胞体外培养时分泌的IgM。筛选出的四种免疫增强饲料均能使头肾B淋巴细胞体外培养时分泌的IgM显著增加。无论是脾脏B淋巴细胞还是头肾B淋巴细胞,体外培养时所分泌的IFN-α都不同程度地受抑制。     

介绍六种水产冷冻调理食品加工工艺

调理食品作为一种新兴方便食品,它具有卫生、优质、方便、多样、营养丰富等特点,在国内外市场上很受欢迎。冷冻调理食品业发展较快的有西欧、美国、日本等。日本是亚洲地区冷冻食品销量最大的国家,冷冻调理食品的消费占全部冷冻食品消费的50%以上,且有逐年递增的趋势,发展势态强劲。冷冻调理食品依其调理状态分为三种:1.冷冻前未加热处理过的冷冻调理食品;2.冷冻前已加热处理过的冷冻调理食品;3.不需加热即可食用的冷冻调理食品。一、鱼糜牡蛎饼加工工艺1、原料:采用冷冻鱼糜和新鲜活牡蛎为原料。2、原料处理:冷冻鱼糜采用搅拌解冻法,即将冷…     

Antioxidant Properties of Chitosan Coatings on Frozen Atlantic Salmon Fillet Portions

Atlantic salmon contain omega-3 fatty acids, which play important roles in promoting human health but are highly susceptible to oxidation. Chitosan has been shown to have antioxidant properties which could be beneficial in extending the shelf life of Atlantic salmon; however, the effects of chitosan molecular size on oxidation of salmon fillets have not been reported. The primary objective of this study was to evaluate the effects of chitosan coatings on lipid oxidation of Atlantic salmon fillet portions during 5 months frozen storage. The effects of chitosan molecular weight (high molecular weight, low molecular weight, and enzymatically degraded chitosan), concentration (0.5 and 1.0%), and the addition of 1% ascorbic acid to the chitosan coating were evaluated. Chitosan molecular weight significantly affected oxidation as evaluated by propanal levels and changes in L* values of the fillet portions. The chitosan treatment with added ascorbic acid resulted in the lowest propanal levels during 5 months of frozen storage. Manipulation of chitosan molecular weight and incorporation of natural antioxidants into chitosan coatings can provide an effective method of reducing lipid oxidation during extended frozen storage of seafood products.     

Effect of Chitosan Coating Enriched with 6-gingerol on Red Drum Fillets Quality and Shelf Life during Refrigerated Storage

The effect of chitosan coating enriched with 6-gingerol on the quality and shelf life of red drum fillets during refrigerated storage was investigated in this study. Samples were applied with chitosan coating (CH), 6-gingerol (GI), and chitosan coating with 6-gingerol (CH+GI) before storing at 4°C for 20 days. The data in this study showed that treatment with CH+GI could significantly decrease pH value, K-value, thiobarbituric acid value, and total volatile basic nitrogen in red drum fillets during refrigerated storage. The counts of microorganisms, such as Enterobacteriaceae, psychrotrophic, mesophilic bacteria, and lactic acid bacteria, were also significantly lower in the CH+GI group compared with those in the CH and GI groups. Moreover, the combination of chitosan coating and 6-gingerol was more effective in relieving the deterioration of tissue texture and sensory characteristics in the red drum fillets. In addition, the results suggested that chitosan coating and 6-gingerol had a synergistic effect on the quality improvement of red drum fillets. This work demonstrates that chitosan coating enriched with 6-gingerol may be a promising natural preservative for red drum during refrigerated storage.     

Effects of Chitosan Coatings Enriched with Different Antioxidants on Preservation of Grass Carp (Ctenopharyngodon idellus) During Cold Storage

To investigate the effects of chitosan composite coatings for maintaining the quality of grass carp portions, indictors of microbiology (total bacteria count, TBC), chemistry (pH; total volatile basic nitrogen, TVB-N; 2-thiobarbituric acid, TBA; K-value), and sensory characteristics were analyzed periodically. The results showed that chitosan (1.5%, w/v) + acetic acid (1.0%, v/v) + tea polyphenol (TP, 0.5%, w/v) coating significantly (p ≤ 0.05) reduced growth of microorganisms as reflected in TBC, lipid oxidation as displayed in TBA, chemical spoilage as reflected in pH, TVB-N, K-value, and sensory characteristic scores compared to the control samples. The effect of chitosan (1.5%, w/v) + acetic acid (1.0%, v/v) + vitamin C (VC, 0.5%, w/v) coating was better than chitosan (1.5%, w/v) + acetic acid (1.0%, v/v) coating. Chitosan together with acetic acid and TP can be used as a type of preservative coating for grass carp portions under chilled storage.     

Influence of Chitosan Nanocomposite and Rosemary (Rosmarinus officinalis L.) Extract Coating on Quality of Huso huso Fillet Inoculated with Listeria monocytogenes During Refrigerated Storage

This study aimed to evaluate the antilisterial and antioxidative effects of chitosan nanocomposites and rosemary extract coating on the fillet of Huso huso inoculated with Listeria monocytogenes during refrigerated storage (4°C). Fish fillets were subjected as control (without coating), 0.5% rosemary extract (RE), 1% chitosan (CS), and combination of chitosan and rosemary extract as chitosan nanocomposite (CS/RE). Then, samples were inoculated with L. monocytogenes. Subsequently, the chemical parameters (total volatile basic nitrogen (TVB-N), peroxide value (PV), pH, and thiobarbituric acid (TBA)) and antilisterial effects of coatings were monitored during 16 days of storage at 4°C. According to the results, CS/RE demonstrated a significant (p < 0.05) ability to inhibit the growth of L. monocytogenes from 4.14 log cfu/g to 2.23 log cfu/g at the end of the storage period, followed by CT and RET treatments, respectively, compared to the control. Even though samples coated with CS/RE had the lowest pH and TVB-N values (p < 0.05), this coating was not able to pause the protein denaturation after 8 days of storage (p > 0.05) compared to the other treatments. On the other hand, CS/RE coating retarded lipid oxidation by decreasing PV and TBA production in the samples compared to the control up to the end of refrigerated storage (p < 0.05).     

鱼肉酶解物及壳聚糖对鲤鱼涂膜保鲜效果的研究

以感官评分、挥发性盐基氮、菌落总数、K值为指标,研究比较了鱼肉酶解物和壳聚糖为原料的涂膜液对鲤(Cyprinus carpio)(4℃)冷藏过程中品质变化的影响。结果显示:贮藏期间,对照组的感官评分显著低于各涂膜组(P<0.05)。贮藏前8 d,涂膜组能够显著抑制K值的升高(P<0.05)。鱼肉酶解物和壳聚糖涂膜组均能够显著抑制细菌的生长,而贮藏2～6 d内鱼肉酶解物涂膜鲤鱼的菌落总数显著低于壳聚糖涂膜组(P<0.05)。贮藏后期,鱼肉酶解物组能延缓TVB-N值的升高,壳聚糖涂膜组能够显著抑制TVB-N值的升高(P<0.05)。鱼肉酶解物可作为一种新的可食性涂膜材料,用于延长鲤鱼的贮藏期。     

Commercial assessment of growth and mortality of fifth-generation Sydney rock oysters Saccostrea glomerata (Gould, 1850) selectively bred for faster growth

The Sydney rock oyster Saccostrea glomerata (Gould, 1850) industry acquired hatchery-produced spat selected for faster growth for the first time in January 2004. Selectively bred and non-selected (Control) spat produced concurrently were used to compare performance when grown under commercial conditions. Spat were distributed to farmers in seven estuaries in New South Wales. Individual farmers cultivated these oysters using their own techniques and growth and mortality were recorded quarterly. At each site, the two oyster types were cultivated using the same culture method, location and density. Growth was compared when oysters were 27 months of age. At this time, selectively bred oysters were significantly larger and heavier than Control oysters. The same result was obtained when oysters were compared at the point in time when selectively bred oysters had reached 50 g at each site. No significant difference was found for cumulative mortality between the selectively bred oysters and Control oysters across all sites. However, the seven sites had significantly different levels of cumulative mortality. Overall, the performance of selectively bred oysters was superior to the Control oysters and selectively bred oysters reached the 50 g bench mark within 29.3 months when averaged across all sites.     

The efficiency and condition of oysters and macroalgae used as biological filters of shrimp pond effluent

Current shrimp pond management practices generally result in elevated concentrations of nutrients, suspended solids, bacteria and phytoplankton compared with the influent water. Concerns about adverse environmental impacts caused by discharging pond effluent directly into adjacent waterways have prompted the search for cost‐effective methods of effluent treatment. One potential method of effluent treatment is the use of ponds or raceways stocked with plants or animals that act as natural biofilters by removing waste nutrients. In addition to improving effluent water quality prior to discharge, the use of natural biofilters provides a method for capturing otherwise wasted nutrients. This study examined the potential of the native oyster, Saccostrea commercialis (Iredale and Roughley) and macroalgae, Gracilaria edulis (Gmelin) Silva to improve effluent water quality from a commercial Penaeus japonicus (Bate) shrimp farm. A system of raceways was constructed to permit recirculation of the effluent through the oysters to maximize the filtration of bacteria, phytoplankton and total suspended solids. A series of experiments was conducted to test the ability of oysters and macroalgae to improve effluent water quality in a flow‐through system compared with a recirculating system. In the flow‐through system, oysters reduced the concentration of bacteria to 35% of the initial concentration, chlorophyll a to 39%, total particulates (2.28–35.2 µm) to 29%, total nitrogen to 66% and total phosphorus to 56%. Under the recirculating flow regime, the ability of the oysters to improve water quality was significantly enhanced. After four circuits, total bacterial numbers were reduced to 12%, chlorophyll a to 4%, and total suspended solids to 16%. Efforts to increase biofiltration by adding additional layers of oyster trays and macroalgae‐filled mesh bags resulted in fouling of the lower layers causing the death of oysters and senescence of macroalgae. Supplementary laboratory experiments were designed to examine the effects of high effluent concentrations of suspended particulates on the growth and condition of oysters and macroalgae. The results demonstrated that high concentrations of particulates inhibited growth and reduced the condition of oysters and macroalgae. Allowing the effluent to settle before biofiltration improved growth and reduced signs of stress in the oysters and macroalgae. A settling time of 6 h reduced particulates to a level that prevented fouling of the oysters and macroalgae.     

The Effects of Sodium Alginate on Quality of Rainbow Trout (Oncorhynchus mykiss) Fillets Stored at 4 ± 2°C

Edible coating is a novel food packaging technology for controlling the growth of spoilage bacteria and chemical changes in ready-to-eat food products. Fresh fish are highly perishable foodstuffs and are very susceptible to spoilage. A sodium alginate coating was used to maintain the quality of rainbow trout fillets in chilled storage over a period of 20 days. Fillet samples were coated with an aqueous solution of 3% sodium alginate and then stored at chilled temperature (4 ± 2°C). The control and coated samples were analyzed periodically (every 5 days) for microbial (aerobic plate count and psychrotrophic count), chemical (total volatile basic nitrogen, thiobarbituric acid, peroxide value), and sensory characteristics. The results indicated that the sodium alginate coating helped protect the quality characteristics of treated fresh fish fillets and prolonged the shelf life during chilled storage of rainbow trout fillets.     

Effects of E/Z Isomers and Coating Materials of Astaxanthin Products on the Pigmentation and Antioxidation of Rainbow Trout,Oncorhynchus mykiss

The objective of this study was to compare the effects of four astaxanthin preparations with different ratio of E/Z (trans/cis) isomers and different coating materials on the pigmentation and antioxidation properties of rainbow trout. Five diets were designed as basal diet (without astaxanthin supplementation) and four astaxanthin diets (100 mg/kg diet) supplemented with four astaxanthin products, BASF (79% all‐E, gelatin coated), Wisdom‐B (85% all‐E, gelatin coated), Wisdom‐C (94% all‐E, carrageenan coated), and Wisdom‐D (94% all‐E, gelatin coated). After 4 wk feeding, the flesh astaxanthin content, redness, and yellowness of astaxanthin‐supplemented groups were higher than those of control group at the second and fourth week (P < 0.05). Among these astaxanthin‐supplemented groups, the Wisdom‐B group had the highest flesh redness and astaxanthin content. The astaxanthin‐supplemented groups also had the lower flesh frozen loss and malondialdehyde level than control group at the fourth week (P < 0.05). The results indicated that dietary 100 mg/kg astaxanthin could improve the flesh redness and antioxidation abilities of rainbow trout. The ration of E/Z isomers and properties of coating materials of astaxanthin preparations influenced the pigmentation and antioxidation properties, and Wisdom‐B had a better pigmentation effect on the flesh than other astaxanthin preparations.