日本鲐不同脱脂工艺的比较

重点对日本鲐鱼片和鱼糜分别用扩展青霉PF868产生的碱性脂肪酶酶解法与漂洗压榨的理化法脱脂工艺效果进行比较，研究结果表明，对鲐鱼片，理化法（残脂率11．01％，按干基计，下同）优于酶解法（残脂率19．48％），而对鱼糜，酶解法（残脂率3．49％）大大优于理化法（残脂率7．52％），筛选出的脂肪酶的适宜酶解条件为pH8.7-9.2，温度32℃，酶液活度40U.mL^-1, 酶液与底物比为5：1，脱脂时间50min，鲐鱼糜在上述酶解条件下，残脂率可达4％以下，而采用理化法脱脂，残脂率只能达到8％左右，无论酶法还是理化法，均难使鲐鱼片残脂率达到10％以下。     

Growth,survival, and fatty acid composition of Indian white shrimp <Emphasis Type="Italic">Fenneropenaeus indicus</Emphasis> (Milne Edwards) fed diets containing different levels of vitamin E and lipid

The objective of this experiment was to determine the effects of two levels of vitamin E (100 and 300 mg/kg diet) along with two levels of lipid (9 and 14%) and their interaction on growth performance of Indian white shrimp and consequently to evaluate the fatty acid composition and lipid stability of its muscle tissue during frozen storage. Growth of juvenile Indian white shrimp was not significantly affected by dietary vitamin E and lipid levels. Muscle lipid content of shrimp fed diets with 14% lipid was significantly higher than that of with 9% lipid. Obvious effects of the increase in dietary lipid level on muscle fatty acid composition were significant decrease in proportion of 16:0 and increase in proportion of 20:5n-3. The content of vitamin E concentration in shrimp muscle reflected dietary vitamin E concentration and ranged from 6.68 to 14.8 mg/kg muscle corresponding to two (100 and 300 mg/kg) levels of vitamin E in fish diet, respectively. Subsequently, results showed that by increasing the concentration of vitamin E from 100 to 300 mg/kg in diet, the rate of lipid oxidation in the muscle tissue during frozen storage was reduced and, as a result, caused higher HUFA retention in muscle of shrimp fed diet with high lipid level.     

Dietary lipid requirement of whiteleg shrimp Litopenaeus vannamei juveniles cultured in biofloc system

An eight‐week feeding trial was conducted to evaluate the contribution of biofloc on dietary lipid requirement in whiteleg shrimp Litopenaeus vannamei. Five diets with graded levels of dietary lipid (45, 60, 90, 120 and 150 g/kg) were fed to juvenile shrimp. Final weight, weight gain and specific growth rate of shrimp fed diets with 60, 90 and 120 g/kg lipid levels were significantly higher than those of shrimp fed diets with lipid levels 45 and 150 g/kg (p < .05). Feed efficiency and protein efficiency ratio of shrimp fed 60, 90 and 120 g/kg were higher than those fed 150 g/kg diet. Plasma total cholesterol and triglyceride levels were lower in shrimp fed 45 g/kg compared with those fed the 90 g/kg (p < .05). Also, lysozyme activity for 90 g/kg group was higher than the 15 g/kg group. Hepatopancreas lipase and amylase activities of shrimp fed 90 and 120 g/kg diets were significantly higher than those of shrimp fed 45 and 150 g/kg diets. Broken‐line regression analysis for weight gain indicated that the dietary lipid requirement of whiteleg shrimp juveniles reared in a biofloc system was estimated to be higher than 56 g/kg but <60 g/kg.     

Effects of Dietary Short-chain Fructooligosaccharides on Intestinal Microflora, Survival, and Growth Performance of Juvenile White Shrimp, Litopenaeus vannamei

Abstract.— Five groups of juvenile white shrimp, Litopenaeus vannamei , in triplicate were separately fed a compound diet with additional short-chain fructooligosaccharides (ScFOS, Profeed^® 95%) 0, 0.4, 0.8, 1.2, or 1.6 g/kg dried diet for 8 wk to investigate the effects of ScFOS on the intestinal microflora, survival, and growth performance of the shrimp. The juvenile shrimp with around 0.17 g of initial body weight were divided into 30 per tank and reared in a standard water recirculation system at 28 C. The shrimp were fed five times a day. At the end of experiment, the shrimp were weighed and their intestinal samples were analyzed for the amounts of Vibrio parahaemolyticus, Aeromonas hydrophila, Lactobacillus sp. , and Streptococcus faecalis using selective agar. The results showed that the shrimps' weight gain and specific growth rate increased with the increment of dietary ScFOS, while their feed conversion ratio decreased. The result was the best when an additional ScFOS 0.4 g/kg dried diet was used.     

Apparent digestibility of animal,plant and microbial ingredients for Pacific white shrimp Litopenaeus vannamei

A digestibility trial was conducted to determine apparent digestibility coefficients of dry matter, protein, energy and amino acids of animal, plant and microbial ingredients for Pacific white shrimp, Litopenaeus vannamei. The tested ingredients included traditional soybean meal (TSBM), PepsoyGen soybean meal (PSBM), NutriVance soybean meal (NSBM), fish meal (FM), poultry meal (PM), squid hydrolysis (SQH), scallop hydrolysis (SCH), flash dried yeast (FDY), two batches of Ulva meal (UMF and UMS) and bacteria biomass (BB). A basal diet was formulated and produced along with the experimental diets which included 300 g/kg of each ingredient and 700 g/kg of the basal diet. Juvenile shrimp (initial mean weight: 12 g, six shrimp/tank, n = 3) were stocked in a recirculation system. Apparent dry matter, protein and energy digestibility coefficients ranged from ?40.11% to 78.51%, 15.17% to 97.03% and 13.33% to 82.56% among different protein sources, respectively. In general, protein and energy digestibilities in soy sources (77.6% to 97.03% and 62.77% to 82.56%, respectively) are higher than the tested animal protein (51.39% to 71.41% and 45.29% to 69.77%, respectively) and single‐cell protein sources (15.17% to 53.47% and 13.33% to 40.39%, respectively). Among the three soybean sources, TSBM showed highest protein and energy digestibility. Apparent individual amino acid digestibility coefficients were also variable among different types of ingredients, and there was a reasonable correspondence to protein digestibility. The most digestible feed ingredients for Pacific white shrimp in this study were conventional soybean meal (SBM) and NutriVance soybean meal (NSBM), which indicated that these ingredients are good protein and amino acid sources for Pacific white shrimp. Resultant digestibility data may provide useful information to commercial shrimp feed industry.     

Stability of Fish Powder Made from Saithe (Pollachius virens) as Measured by Lipid Oxidation and Functional Properties

ABSTRACT

Lipid oxidation and functional properties were monitored in spray dried fish powder made from saithe (Pollachius virens) by-products. The fresh powder exhibited slight antioxidant activity in a model system of linoleic acid emulsion. The freshly made powder had low lipid extract-ability in polar solvents and over 30% free fatty acids (FFA). Further lipid oxidation took place during storage, independent of storage temperatures. Functional properties measured by color changes, water-binding capacity, apparent viscosity and protein solubilty changed more during storage at 30°C than 0°C.     

内源酶辅助提取虾壳虾青素的研究

文章探讨了内源酶对虾青素提取效果的影响,并以高效液相色谱法（HPLC）测定样品中虾青素的质量浓度,研究了pH、温度和酶解时间这3个因素对虾青素提取效果的影响,采用正交试验进行优化,以虾壳虾青素的萃取率作为评价提取效果的指标。结果表明,当酶解最佳工艺条件为pH 4.0,温度50℃,酶解时间1.5 h时,虾青素的萃取率最高,可达32.16μg.g-1湿虾壳,比直接超声提取提高28%。通过空白试验可知,外加脂肪酶对虾青素提取无促进作用,仅利用内源酶即可达到较好的提取效果,且经济节约。     

Forage-Based Feeding in Commercial Red Claw Ponds in Ecuador

Abstract

Red claw crayfish, Cherax quadricarinatus, are perhaps the first tropical species of crayfish to be cultured commercially. Culture traits and high market value could allow semi-intensive culture. Feeding strategies used in extensive crayfish ponds in temperate climates may not be the most appropriate for semi-intensive culture systems where year-round growth is possible. The following study was conducted to evaluate differences between using a pellet-based system versus a pellet-plus-forage-based system. The study was conducted in 14 0.3-ha ponds on a commercial farm in Ecuador. Juvenile red claw (1-2 g) were stocked into all ponds at a rate of 4/m². All ponds received pelleted shrimp rations at a rate of 3% per day. Seven ponds also received dried hay at a rate of 100 kg/ha/mo during the 3-month study. At harvest, red claw weights were similar (30-34 g), but survivals were significantly higher in ponds receiving pellets and hay (65%) than in ponds receiving pellets only (50%). Yields in pellet-fed ponds averaged 594 kg/ha, while red claw receiving pellets plus forage averaged 889 kg/ha. The addition of dried forage was thought to provide a larger variety of natural food organisms throughout a greater area of the pond bottom and provided additional substrate for dispersal and hiding. Addition of grasses from outside the pond is recommended over production of grasses grown within the pond.     

Evaluation of dried fermented biomass as a feed ingredient in plant‐based practical diets for juvenile Pacific white shrimp Litopenaeus vannamei

Two growth trials were designed to evaluate the utilization of dried fermented biomass (DFB) in commercial type feed formulation for Pacific white shrimp, Litopenaeus vannamei. In trial 1, four experimental diets were formulated to utilize increasing levels (0, 25, 50 and 100 g/kg) of spray‐dried fermented biomass (SDFB) as a replacement of fish meal (FM). Results indicated that SDFB can be utilized up to 50 g/kg as a substitution for FM without causing growth depression in shrimp. However, dietary SDFB supplementation at 100 g/kg significantly reduced the weight gain (WG) of shrimp and increased feed conversion ratio (FCR). This reduction in performance is likely due to palatability or nutrient imbalances of the feed. In trial 2, nine experimental diets were formulated with increasing levels (0, 20, 40, 60 and 120 g/kg) of spray‐dried (S) or granular (G) DFB to replace soy protein concentrate (SPC) or SPC + corn protein concentrate (CPC). This allowed the comparison between spray‐dried and ring‐dried products. Ring drying produced a granular product, reducing dust and increasing product particle size. Shrimp fed with diet containing 20 g/kg GDFB performed the best in terms of final mean weight, WG and FCR. Significantly reduced growth and increased FCR were observed in shrimp fed diets containing 60 and 120 g/kg SDFB. Lipid content of whole body was significantly reduced when GDFB was incorporated at 120 g/kg. No significant differences were detected in survival, protein retention efficiency as well as protein and ash contents of the whole shrimp. Results from analysis of covariance indicated that the processing method (covariant) had a significant effect on final mean weight, WG and FCR. In general, shrimp fed with diet containing granular product performed better as compared to those fed with diets utilizing spray‐dried product. GDFB can be utilized in the diets up to 120 g/kg in practical shrimp feeds as a substitute for SPC and CPC without compromising the growth of shrimp. However, a significant reduction in WG was observed in the diets containing 60 and 120 g/kg SDFB. The results in the current study demonstrate that processing changes to produce a granular product produced an improved feed ingredient for shrimp.     

Fatty Acid Profiles and Lipid Oxidation Status of Sun Dried,Deep Fried,and Smoked Sardine (Rastrineobola argentea) from Lake Victoria,Tanzania

Freshwater fishes contain long chain omega-3 and omega-6 polyunsaturated fatty acids (PUFAs) of highest nutritional value. PUFAs in fish are susceptible to oxidative damage during processing and subsequent storage. Sardines (Rastrineobola argentea) are an important fish species of Lake Victoria, constituting 72.3% of the total landings by weight on the Tanzanian side of the lake. Fatty acid profiles and lipid oxidation status of sun-dried, deep-fried, and smoked sardines were investigated. Lipid oxidation was assessed by peroxide value, thiobarbituric acid reactive substances (TBARS), and free fatty acids. Fatty acids were analyzed by gas chromatography with flame ionization detector. The three omega-3 PUFAs: docosahexaenoic acid (C22:6n-3), docosapentaenoic acid (C22:5n-3), and eicosapentaenoic acid (C20: 5n-3) contributed 57–60, 63, and 38% of PUFAs in sun-dried, smoked, and deep-fried sardines, respectively. Lipid oxidation reactions were more pronounced in sardines dried on sand and rocks, with TBARS values 97.87 and 84.18 µmolMDA/kg, respectively. The polyene index was significantly lower (p < 0.05) in deep-fried sardines, indicating lower retention of PUFAs in the product. Lake Victoria sardines are a rich source of omega-3 PUFAs. PUFAs in sun-dried sardines are prone to oxidative damage. Smoking resulted in relatively higher retention of omega-3 fatty acids in products.     

脂肪酶对南方鲇生长性能、消化酶活性及血液生化指标的影响

在基础饲料中分别添加0、0.1、0.3 g/kg的脂肪酶,饲喂平均体重(57.6±0.02)g的南方鲇(Silurus meridionalis Chen)60 d,测定南方鲇的生长性能、饲料表观消化率、消化酶活性及血液生化指标。结果显示:添加0.1 g/kg和0.3 g/kg的脂肪酶,增重率比对照组分别提高了4.0%和5.8%,但差异不显著(P>0.05),饲料系数分别下降了5.0%和6.6%,差异显著(P<0.05),肥满度和粗脂肪消化率显著提高(P<0.05),对内脏指数、肝脏指数、肠脂指数、胰蛋白酶活力、肠蛋白酶活力、肠脂肪酶活力及血液生化指标均没有显著影响(P>0.05)。添加0.3 g/kg的脂肪酶显著提高胰脂肪酶活力(P<0.05),添加0.1 g/kg的脂肪酶对胰脂肪酶活力没有显著影响(P>0.05)。结果表明,在脂肪水平为10%的饲料中添加0.3 g/kg的脂肪酶可以提高胰脂肪酶活力,提高脂肪消化率,改善饲料利用率。     

Utilization of fermented soybean meal for fishmeal substitution in diets of Pacific white shrimp (Litopenaeus vannamei)

Two feeding experiments were carried out to evaluate the utilization of fermented soybean meal (FSBM) in diets for Pacific white shrimp (Litopenaeus vannamei). The digestibility experiment was assessed with four diets: a reference diet and three ingredient test diets containing FSBM, local and Chilean fishmeal. The growth experiment was conducted including four isonitrogenous and isocaloric diets formulated to contain the graded levels of dietary fishmeal (0 g/kg, 150 g/kg, 300 g/kg and 450 g/kg) substituted by FSBM. The results indicated that ADCs of crude protein in FSBM were high (888.4 g/kg) and equal in local fishmeal but little lower than Chilean fishmeal while without any significant differences observed in ADCs of crude lipid among the different test ingredients. After 75 days of growth trial, survival rates and feed conversion ratio were not significantly different among the experimental treatments. However, shrimp fed the diets with increasing inclusions of FSBM had a tendency to reduce weight gain and specific growth rate. Based on the correlation between weight gain and substituted fishmeal level analysed by broken‐line regression, the optimum level of fishmeal replaced by FSBM in diet was 253.6 g/kg without adverse effects on growth and feed utilization of Pacific white shrimp.     

Astaxanthin degradation and lipid oxidation of Pacific white shrimp oil: kinetics study and stability as affected by storage conditions

The kinetics of astaxanthin degradation and lipid oxidation in shrimp oil from hepatopancreas of Pacific white shrimp (Litopenaeus vannamei) as affected by storage temperature were studied. When shrimp oil was incubated at different temperatures (4, 30, 45 and 60 °C) for 16 h, the rate constants (k) of astaxanthin degradation and lipid oxidation in shrimp oil increased with increasing temperatures (p < 0.05). Thus, astaxanthin degradation and lipid oxidation in shrimp oil were augmented at high temperature. When shrimp oils with different storage conditions (illumination, oxygen availability and temperature) were stored for up to 40 days, astaxanthin contents in all samples decreased throughout storage (p < 0.05). All factors were able to enhance astaxanthin degradation during 40 days of storage. With increasing storage time, the progressive formation of primary and secondary oxidation products were found in all samples as evidenced by the increases in both peroxide values (PV) and thiobarbituric acid reactive substances (TBARS) (p < 0.05). Light, air and temperatures therefore had the marked effect on astaxanthin degradation and lipid oxidation in shrimp oils during the extended storage.     

Optimization of Ozonated Water Treatment of Wild-Caught and Mechanically Peeled Shrimp Meat

ABSTRACT

Ozone is a USFDA and USDA approved food contact sanitizing agent and has been used in the seafood industry in both gaseous and dissolved forms to destroy bacteria. The wild harvest shrimp industry is the most economically important fishery in the U.S. Gulf of Mexico region, and in Louisiana the majority of the harvest is mechanically peeled and frozen. Dissolved ozone was measured in processing water at product application to study the optimization of ozonated water treatment for reducing microbial contamination of peeled shrimp meat. Shrimp samples were either sprayed or soaked in water with 1, 2, and 3 ppm dissolved ozone. Treatment times of 20, 40, and 60 seconds were investigated for all applications and concentrations. Similar volumes of water were applied for all treatments, and soaking showed greater bacterial reduction than spray treatments for all time and concentration combinations studied. Soaking in 3 ppm dissolved ozone for 40 s and 60 s showed the greatest reduction of total aerobic bacteria, and 60 s at 3 ppm resulted in the greatest reduction of Pseudomonas bacteria. Ozonated water treatment did not produce oxidation in the shrimp samples. The optimal treatment of soaking shrimp in 3 ppm dissolved ozone for 60 s will be used for further investigations of refrigerated shelf life extension and Listeria monocytogenes destruction in peeled shrimp meat.     

Optimal dietary lipid requirement of postlarval white shrimp,Litopenaeus vannamei in relation to growth performance,stress tolerance and immune response

A 25‐day experiment was conducted to evaluate the optimal lipid level for postlarval Litopenaeus vannamei. Shrimp (1.7 mg) were fed five isonitrogenous diets containing grade levels of lipid (96.6, 114.3, 128.5, 136.5 and 154.5 g/kg diet, respectively). Each diet was assigned to four tanks (500 shrimp), and shrimp were fed six times a day. Weight gain was increased with the increasing dietary lipid levels, and the highest weight gain was observed in shrimp fed diet with 154.5 g/kg lipid (p < 0.05). On the contrary, the survival was lowest in shrimp fed the L15.45 and highest in shrimp fed the L11.43. Triglyceride in hepatopancreas was increased, and cholesterol was decreased with the increasing dietary lipid. Pyruvate kinase and AMPK mRNA expression were highest in shrimp fed the L12.85. Malondialdehyde in whole body was positively correlated with the dietary lipid levels. The mRNA expression of SOD and Caspase 3 was highest in shrimp fed the L12.85. After hypoxia stress, shrimp fed the L12.85 showed highest survival. The mRNA expression of superoxide dismutase and Akirin was highest in shrimp fed the L11.43 and L15.45, respectively. Based on the survival after 25‐day feeding trail and after the hypoxia stress, the optimal dietary lipid for postlarval L. vannamei should be 118–124 g/kg.     

不同蛋白能量比饲料对草鱼幼鱼消化酶活性的影响

以鱼粉和豆粕为蛋白源,鱼油和豆油等比例混合油为脂肪源,共配制4个蛋白水平(20%、25%、30%、35%),每一蛋白水平设4个脂肪水平(4.5%、8%、11.5%、15%),共16组饲料。每组设3个重复,在水温23~29℃下,连续投喂初始体重为(16.84±0.28)g的草鱼(Ctenopharyngodon idellus)10周,研究不同蛋白能量比饲料对草鱼幼鱼消化酶活性的影响。结果显示:肠道蛋白酶的活性随着饲料蛋白含量的升高而显著升高(P<0.05),饲料蛋白水平在20%~30%时,饲料中的脂肪水平对蛋白酶活性影响不显著(P>0.05),蛋白水平在35%时,高脂肪抑制了蛋白酶活性,肝胰脏的蛋白酶变化规律类似于肠道;肠道和肝胰脏淀粉酶活性在饲料蛋白含量相同的情况下,随着脂肪含量的升高呈现显著的下降趋势(P<0.05),但饲料中蛋白(30%,35%)和脂肪(8%,11.5%,15%)含量较高时,淀粉酶活性较稳定;肠道和肝胰脏的脂肪酶活性在饲料蛋白含量相同的情况下,随着脂肪含量的升高,呈显著上升的趋势(P<0.05),但在蛋白含量(30%,35%)和脂肪含量(8%、11.5%,15%)的6个试验组之间差异不显著(P>0.05);在脂肪含量分别为4.5%、8%和11.5%时,饲料的蛋白含量对肠道的脂肪酶活性无显著性影响(P>0.05),当脂肪含量为15%时,随着蛋白含量的升高,肠道的脂肪酶活性显著降低(P<0.05)。结果表明,草鱼饲料中蛋白含量为30%和脂肪为8%(即蛋白能量比21.7 mg/kJ)的试验组草鱼获得较高的消化酶活性。     

生物絮团对罗氏沼虾体组成和消化酶活性的影响

通过向养殖水体中泼洒糖蜜构建生物絮团养殖模式,分析生物絮团营养组成,并探讨生物絮团对罗氏沼虾体组成和消化酶活性的影响。试验分对照组和试验组(生物絮团组),其中试验组在养殖过程中泼洒糖蜜。试验在室内水泥池内(2 m×2 m×0.6 m)进行,每个处理有3个重复,每个重复225尾虾(0.26 g±0.02 g),试验周期为90 d。养殖过程中不换水,糖蜜的泼洒量根据饲料投喂量进行计算(C/N为20)。结果显示:添加糖蜜能够显著促进生物絮团的形成,到第90天时,试验组的絮团体积达21.22 mL/L;而对照组为6.03 mL/L;试验组絮团粗蛋白含量为29.47%,粗脂肪含量为4.32%,二者均显著高于对照组,而粗灰分含量为11.36%,显著低于对照组;泼洒糖蜜对罗氏沼虾体组成的影响不显著,对照组和试验组肌肉粗蛋白含量分别为21.09%和21.20%,粗脂肪含量分别为2.91%和3.06%;另外,向水体中泼洒糖蜜对罗氏沼虾消化酶活性影响显著。试验组罗氏沼虾肠脂肪酶活性、胃脂肪酶活性和胰脂肪酶活性均显著高于对照组;试验组罗氏沼虾糜蛋白酶活性、胰蛋白酶活性也均显著高于对照组。但泼洒糖蜜对肠淀粉酶、胃蛋白酶、胃淀粉酶、胰淀粉酶和纤维素酶活性没有显著影响。试验表明,生物絮团营养组成丰富,能够有效提高消化酶活性。     

Study of Photo and Thermoluminescence Properties to Identify Irradiated Dried-Fishery Products

ABSTRACT

Radiation-specific luminescence properties in irradiated dried-fishery products (pollack, little pollack, clams, and shrimp) were investigated at different dose levels (0–10 kGy). Photostimulated luminescence (PSL) analysis of whole samples was effective for dried clams and shrimp, while low PSL sensitivity was observed in dried pollack and little pollack. Thermoluminescence (TL) analysis was conducted after isolation of silicate minerals, in which the two methods of mineral isolation—density separation and acid hydrolysis—were compared. Irradiated samples were easily distinguishable through the strong TL glow curves, with maximum peaks in temperature range of 150–250°C. TL ratios (TL₁/TL₂) were < 0.1 for nonirradiated samples, while > 0.1 for irradiated. There was a clear effect of applied irradiation dose, with a negligible effect of the method used for mineral separation. The mineral composition showed that feldspar and quartz minerals were mainly responsible for the well-characterized luminescence behavior upon irradiation.     

Pharmacokinetics and bioavailability of oxytetracycline in vannamei shrimp (Penaeus vannamei) and the effect of processing on the residues in muscle and shell

The present study examined the pharmacokinetics and bioavailability of oxytetracycline (OTC) in vannamei shrimp (Penaeus vannamei) after intra-sinus (10 mg/kg) and oral (10 and 50 mg/kg) administration and also investigated the net changes of OTC residues in the shrimp after the thermal, acid and alkaline processing methods. The hemolymph concentrations of OTC after intra-sinus dosing were best described by a two-compartment open model. The oral bioavailability was found to be 48.2 and 43.6% at doses of 10 and 50 mg OTC/kg, respectively. The peak hemolymph concentrations after 10 and 50 mg OTC/kg doses were 3.37 and 17.4 μg/ml; the times to peak hemolymph concentrations were 7 and 10 h. The elimination half-lives were found to be 15.0 and 11.5 h for the low and high dose, respectively. The residual OTC was rapidly eliminated from muscle with the elimination half-life value of 19.4 and 15.4 h, respectively, for the groups treated with doses of 10 and 50 mg/kg. The residual OTC levels in the muscle fell below the MRL (0.2 μg/g) at 72 and 96-h post-dosing at dose levels of 10 or 50 mg/kg, respectively. Residual OTC levels in muscle and shell were approximately 20–50% lower in the thermal treatment such as boiling, baking and frying. By the acid treatment, OTC residues were reduced to >80%, while those were reduced to around 30% by alkaline treatment.     

The effectiveness of a commercial microbial product in poorly prepared tiger shrimp, Penaeus monodon (Fabricius), ponds

The efficacy of a commercial microbial product was tested in commercial tiger shrimp, Penaeus monodon (Fabricius), ponds for one culture period in Kuala Selangor, Malaysia. Four ponds with replicates for treatment and control were used. The pond bottom was dried but the organic sludge was not removed as normally practised in pond preparation. The ponds were stocked with 15 post‐larvae at the rate of 31.m^?2. Physical, chemical and biological parameters of the pond were analysed every 2 weeks during the culture period. Water quality parameters remained within the optimum range for shrimp culture except for ammonia‐nitrogen being significantly higher in control ponds and silica in treated ponds. Benthic organisms were not found in any of the ponds. The average counts of different bacteria were not significantly higher in treated ponds than control. Because of poor health, the shrimp were harvested earlier (72 days) than the usual 120 days. An average of 875.60 ± 67.00 kg shrimp ha^?1 was obtained in treated ponds with a feed conversion ratio (FCR) of 1.57 ± 0.10 and survival rate of 42.35 ± 5.37% compared with 719.50 ± 130.94 kg shrimp ha^?1, 2.99 ± 0.70 and 21.25 ± 3.26%, respectively, in control ponds. Neither the microbial product nor the frequent water exchange was effective in overcoming the problems caused by the poor pond bottom.