首页 | 本学科首页   官方微博 | 高级检索  
相似文献
 共查询到20条相似文献,搜索用时 62 毫秒
1.
改性豆基蛋白胶黏剂的胶合工艺初探   总被引:2,自引:0,他引:2  
以杨木单板为试材研究了改性豆基蛋白胶黏剂的胶合性能,采用单因素实验方法,探讨了改性豆基蛋白胶黏剂压制胶合板的胶合工艺。分析了热压温度、热压时间和涂胶量对三层杨木胶合板胶合性能的影响。结果表明:采用改性后的豆基蛋白胶黏剂,在压力为1.4MPa,温度为165℃左右,热压时间为1.4~1.6 min/mm,涂胶量为220g/m~2,压制的杨木胶合板胶合性能较佳且达到Ⅰ类胶合板的标准。  相似文献   

2.
为获得无甲醛释放的环保胶合板,将热塑性树脂薄膜(低密度聚乙烯(LLDPE)、聚丙烯(PP)、聚氯乙烯(PVC))用作胶黏剂,并利用空气介质阻挡等离子体对热塑性树脂薄膜进行表面改性处理以提高薄膜与杨木单板的界面相容性,从而获得性能良好的环保胶合板。研究了等离子体处理对胶合板胶合性能的影响,并从等离子体处理对热塑性树脂薄膜表面化学组分及其对胶合板界面形貌的影响分析其胶合机理。结果表明:在等离子体处理功率为4.5 kW、处理时间为8 m/min的条件下处理热塑性树脂薄膜,胶合板的胶合强度得到显著提高,LLDPE/杨木胶合板的胶合强度从0.49 MPa增至0.81 MPa,PP/杨木胶合板的胶合强度从0.65 MPa提高到0.84 MPa,均达到Ⅱ类胶合板标准要求。其中用等离子体处理后PVC与杨木制备的胶合板能满足Ⅰ类胶合板的标准要求,胶合强度达到0.79 MPa。XPS分析表明,等离子体改性热塑性树脂薄膜的表面发生了氧化反应,引入了含氧官能团,提高了薄膜表面极性,有利于提高薄膜与杨木单板之间的相互作用,从而使得胶合板的界面胶合更为紧密,说明等离子体处理后树脂与杨木单板的相容性提高,树脂能在单板表面更好地附着。热塑性树脂薄膜与杨木单板制备的胶合板仅有极微量甲醛释放,其主要源于木材自身,远低于国家标准对人造板甲醛释放限量的要求。研究证明等离子体处理能明显改善热塑性树脂薄膜与杨木单板的界面相容性。  相似文献   

3.
采用常压空气介质阻挡放电等离子体对杨木单板表面进行改性处理,利用自制纳米纤维素改性大豆蛋白胶黏剂制备胶合板,研究等离子体处理工艺对杨木单板表面润湿性能和杨木胶合板胶合性能的影响,以期提高胶合板性能、降低施胶量,并从等离子体处理对微观形貌和化学组分两方面的影响分析其机理。试验结果表明:常压等离子体处理后,胶液在单板表面的初始接触角和平衡角相比未处理单板最大分别下降12.4%和46.3%,润湿性能得到明显改善;在达到Ⅱ类胶合板胶合性能的前提下可降低一定的施胶量;改性单板表面粗糙度提高,含氧官能团含量增加,均有利于胶液在单板表面的润湿。综合胶合板性能与经济效益,选择较优处理工艺条件为处理功率4.5 kW、处理速率14 m/min和单面施胶量140 g/m~2。  相似文献   

4.
以杨木单板为基材,低密度聚乙烯(LDPE)薄膜为胶黏剂制备木塑复合胶合板,探讨了单位面积上LDPE的质量、改性剂种类及热压工艺对木塑复合胶合板胶合强度的影响。结果表明:经过表面改性的杨木单板制备的胶合板胶合强度优于未改性单板制备的胶合板胶合强度;以KH-550为杨木单板表面改性剂(用量2%),采用121 g/m~2 LDPE薄膜,在温度160℃、时间8 min、压力2.0~2.2 MPa热压工艺条件下,制备的木塑复合胶合板胶合强度符合GB/T 9846—2015中Ⅱ类胶合板要求;表面改性单板表面接触角的检测结果表明,经硅烷偶联剂KH-550处理的木材表面接触角最小,其渗透性较好。  相似文献   

5.
近几年来,由于木材资源短缺,生产胶合板用材除了靠进口木材外.用杨木生产胶合板或杨木芯板、柳植面、背板胶合板的数量愈来愈多。杨木虽然纹理直,结构细.材质轻,单板表面平滑,有一定实用价值,但是杨木和其它胶合板材不同,用普通UF树脂胶及常规的胶合工艺生产胶合板时,胶合质量不稳定,合格率不高,脱胶现象时有发生.用普通PVA改性预压型UF树脂胶生产胶合板时,生产时叠芯、离芯现象较多,影响产品合格率和经济效益。本课题研制的预压型UF树脂胶特别适合于杨木胶合板生产。采用本工艺生产的UF树脂,在会成和使用时都不要加P…  相似文献   

6.
姜惕  李秋雯 《木材工业》1992,6(3):16-20
对三种杨木进行了制造胶合板的工艺试验。试验结果表明,对于UF胶合板,木材性质的变异(例如pH值和缓冲容量等)可在加工过程中产生一系列问题,包括表面起毛、翘曲和合板开胶等。通过初步探讨,三种杨木胶合板的胶合强度可以达到GB 9864—88胶合板国家标准的要求。  相似文献   

7.
杨木胶合板用低毒不脱水脲醛树脂胶   总被引:3,自引:0,他引:3  
为适应短周期工业材-杨木采用低压,快速热压胶合工艺对胶粘剂的特殊要求,通过对树脂合成工艺和杨木单板胶合工艺的一系列试验而研制出低毒,不脱水脲醛树脂胶,试验结果证明使用该胶粘剂压制的新疆杨,1-69杨,I-72杨等杨木胶合板,其胶合强度均符合GB9846-88胶合板国家标准的要求,胶合板游离甲醛释放量视单板树不同分别达到JAS规定的F2级和F3级指标。  相似文献   

8.
本文以速生杨木脲醛树脂强化材为研究对象,研究改性后强化材的饰面特性。测试3种不同极性液体在试件表面的接触角,并计算表面自由能;对不同增重率的杨木进行表面胶合质量检测,研究脲醛树脂浸渍处理杨木对其表面胶合质量的影响;利用傅里叶红外光谱分析杨木浸渍后表面官能团的变化。结果表明:经过浸渍后,杨木润湿性增强。3种液体在强化材表面的接触角均小于未处理材与液体的接触角,随着杨木强化材增重率的增加,表面自由能呈增加的趋势。杨木强化材表面胶合强度随着增重率的增加先增大后减小,在增重率为20%时表面胶合强度最大。红外图谱显示,在波数3 340、2 917、1 738、1 643~1 240 cm-1等处,经过脲醛树脂浸渍后强化材的波峰不同程度的强于未处理材。综上所述,脲醛树脂强化材的饰面性能与增重率相关,随着增重率的增加饰面性能先增加后下降。  相似文献   

9.
将不同微纳纤丝添加量的三聚氰胺树脂涂饰在杨木单板表面,并以添加微纳纤丝的豆胶作为胶黏剂,制造杨木胶合板,检测微纳纤丝添加量对染色杨木单板表面色牢度、胶合板表面耐磨性能、胶合强度的影响。结果表明:微纳纤丝可明显改善单板表面色牢度及表面耐磨性能;在豆胶中加入微纳纤丝,可提高胶合板的胶合强度。  相似文献   

10.
为提高木材与地质聚合物的界面胶合强度,使用KH550、KH560和KH570三种硅烷偶联剂对杨木单板进行涂刷处理,以实验室自制的偏高岭土基地质聚合物为木材胶黏剂,热压制备胶合板,研究硅烷偶联剂处理对杨木单板表面微观形貌和润湿性能、胶接界面化学基团和微观结构、胶合板干态和湿态胶合强度的影响。结果表明:KH550、KH560、KH570偶联剂处理后,木材表面形成的硅烷薄膜层,有利于碱激发剂在木材表面的进一步扩散,平衡接触角分别降低了25.8%、31.8%、14.8%;硅烷偶联剂处理有利于促进地质聚合物在木材内部的渗透,其中偶联剂KH550处理组的地质聚合物在木材中渗透更为均匀;经浓度为10%的KH550处理后,胶合板胶合强度达到最大值,其湿态胶合强度与干态胶合强度分别比未处理材提高了41.5%和47.5%。  相似文献   

11.

In Scandinavia, moose (Alces alces L.) sometimes cause severe browsing damage to economically-important pine. Moose-vehicle accidents have spurred construction of fences along roads, and these may interfere with moose migration between summer and winter ranges, or the road alone may be a barrier. If this happens and moose build up along roads, landowners may suffer economically. Therefore, this study investigated whether roads, fences or other factors influence the use of young pine stands by moose. Eighty stands along roads in northern Sweden were evaluated in which individually-browsed branches were counted on 9972 pines. Moose browsing was not significantly related to birch (Betula pendula Roth, B. pubescens Ehrh.) density, nor did it differ between pines (Pinus contorta Douglas or P. sylvestris L.). However, increased pine density, site productivity and proximity to a highway were associated with increased browsing. Further large-scale studies are needed to understand moose habitat selection and the effects of roads.  相似文献   

12.

The root systems of 2-yr-old Picea glauca, Picea mariana and Pinus banksiana seedlings were submitted to various frost temperatures during an artificial frost to induce different levels of root damage. Frost-damaged and control seedlings were placed in a greenhouse under high and low soil moisture regimes. Seedling growth and physiology were evaluated periodically. Seedling survival was reduced when root damage reached levels of 60-80%. Root systems of all three species showed partial to total recovery by the end of the experiment. In general, root freezing damage caused reductions in seedling growth, with these reductions becoming less significant over time. Root damage had little to no effect on black spruce and jack pine seedling physiology, while white spruce CO 2 uptake decreased with increasing root damage. Shoot nitrogen content of all three species decreased slightly with increasing root damage.  相似文献   

13.
Heterobasidion parviporum and Heterobasidion annosum are widely distributed root‐rot fungi that infect conifers throughout Europe. Infection of conifer stumps by spores of these pathogens can be controlled by treating fresh stumps with a competing non‐pathogenic fungus, Phlebiopsis gigantea. In this study, growth of three Latvian strains of P. gigantea and the biological control agent ‘Rotstop’ strain was evaluated in stem pieces of Norway spruce, Scots pine, lodgepole pine, Douglas‐fir, Weymouth pine, Siberian larch and Sitka spruce. The growth rates of one H. parviporum and one H. annosum isolate were also measured in the same stem pieces. The growth rate of P. gigantea varied greatly in wood of different conifer species. It was higher in the three pine species, lower in Norway spruce and lowest in Sitka spruce and Siberian larch, and in Douglas‐fir, this fungus did not grow. The largest area of wood occupied by P. gigantea was in lodgepole pine. Growth of Latvian isolates of P. gigantea in the wood of Pinus and Picea species was comparable to that of the Rotstop isolate. Consequently, stump treatment with local P. gigantea isolates should be recommended. However, our results suggest that Douglas‐fir stump treatment against Heterobasidion by P. gigantea may be ineffective and other stump treatment methods should be considered.  相似文献   

14.

Mean age, mean and top heights and yield were studied in 20 mixed stands of birch ( Betula pubescens Ehrh. and B. pendula Roth) and Picea abies (L.) Karst. and nine mixed stands of birch and Pinus sylvestris L. in south-eastern Norway. Each mixed stand and the adjacent pure coniferous stand (control) were growing under the same site conditions and had not been commercially thinned. There were no significant differences in mean age at breast height or in top heights between birch and conifers in the mixed stands, while mean height was significantly higher for birch than for spruce. A growth index was calculated based on total volume and age at breast height. For the spruce sites the growth in young mixed stands (birch < 17 m) was superior to that of pure spruce, while the difference was insignificant in older stands. The growth index correlated positively with the ratio between generatively and vegetatively regenerated birch trees, and negatively with the age of the oldest species in the mixture and with site quality. For the pine sites there was no significant difference in the growth index between mixed birch-pine and pure pine stands. A mixture effect of birch on the volume yield of spruce or pine could not be demonstrated.  相似文献   

15.

An outbreak of the needle-shortening pine gall midge, Thecodiplosis brachyntera , occurred on Scots pine, Pinus sylvestris (L.) and lodgepole pine, P. contorta (Dougl.) in central Sweden during 1995-1998. The larval feeding of T. brachyntera kills current-year needles and heavy infestation causes severe defoliation. A pattern of fluctuating defoliation among years and sites was found on both pine species. Defoliation was evenly distributed in the crown of P. sylvestris during years of high as well as low infestation; apical whorls had as much defoliation as basal whorls. In P. contorta , however, there was a tendency for defoliation to be concentrated on branches in the most apical whorls. Growth ring increments on P. sylvestris with high levels of defoliation (71%) did not differ from trees with moderate levels (26%) of defoliation. Shoot lengths were significantly shorter, however, on heavily infested trees the year after defoliation.  相似文献   

16.

The effects of soil scarification (mounding), slash removal and clear-cut age on the natural regeneration in clear-cuts was evaluated using data from four sites in southern Sweden. The treatments were carried out during a good seed and establishment year for birch ( Betula pubescens Ehrh. and B. pendula Roth). Scarification had the strongest positive effect on the density of naturally regenerated seedlings, especially in birch, but also in pine ( Pinus sylvestris L.) and spruce [ Picea abies (L.) Karst]. Slash removal had a positive effect on birch density. No statistically significant effect of clear-cut age was found. In addition, no statistically significant interactions between clear-cut age and scarification or slash removal were found. The ingrowth of field vegetation was the fastest in areas that were not scarified, less rapid in areas scarified on old clear-cuts, and the slowest after scarification in fresh clear-cuts. In conclusion, it may be possible to control the density of birch during a good establishment year for birch. If birch is desired, the best combination of treatments is to remove the slash and scarify; otherwise, these treatments should be avoided.  相似文献   

17.
Contour hedgerows of multipurpose tree species in the sloping tea lands of Sri Lanka are expected to reduce soil erosion and also add significant amounts of plant nutrients to the soil via periodic prunings. The objective of this experiment was to characterize the biomass decomposition pattern and quantify the amount of nutrients added through prunings of six tree species (Calliandra calothyrsus, Senna spectabilis, Euphatorium innulifolium, Flemingia congesta, Gliricidia sepium and Tithonia diversifolia) currently being used in hedgerows associated with tea. Withered leaf and stem prunings (50 g) were enclosed in 2-mm litter bags, placed at 5-cm depth and retrieved after one, three, six, nine and 12 weeks. Loss of initial dry weight, N, P and K was measured. Single exponential decay function adequately described both dry weight and nutrient loss. Tree species differed significantly in their rate of breakdown with decomposition constants (k) varying from 0.0299 to 0.2006 week−1 for leaves and from 0.0225 to 0.0633 week−1 for stems. Gliricidia showed the highest k for leaves with the rest in the following descending order: Senna > TithoniaEuphatorium > Calliandra > Flemingia. A similar pattern was observed for loss of all nutrients with Calliandra and Flemingia always having lower k values than the rest. Although N immobilization was not observed, immobilization of P and K was observed during the first week of incubation in some species, particularly in stem prunings. Annual biomass of prunings differed significantly between tree species in the following descending order: Calliandra > Senna > Flemingia > Tithonia > Gliricidia > Euphatorium. Calliandra added the greatest amount of nutrients annually to the soil with Euphatorium adding the least. Calliandra prunings provided the annual total K requirement and 49% of the N requirement of mature tea. However, none of the species provided more than 5% of the P requirement. It is concluded that among the tree species tested, Calliandra and Flemingia are the most suitable for contour hedgerows in tea plantations of this agroclimatic region because of their higher soil nutrient enrichment capacity and slower decomposition rates which would minimize leaching losses. This revised version was published online in June 2006 with corrections to the Cover Date.  相似文献   

18.

The effects of seed weight and seed type on seedling growth of Pinus sylvestris (L.) were studied by seeding individually weighed orchard and stand seed in different mixtures under harsh (direct seeding in field) and optimal (seeding in nursery) conditions. In the nursery experiment an increase in the seed weight from 3 to 7 mg increased the seedling height by 10-27% and total weight by 27-113%, and decreased the height/diameter ratio by 5-6% after 2 yrs. With elimination of seed weight effects, orchard seedlings were 2% taller than stand seedlings in year 2. Without elimination of seed weight effects, orchard seedlings were 7-13% taller. In the field experiment an increase in the seed weight from 3 to 7 mg increased seedling height by 18-65%, stem volume by 81-274% and the number of top-buds by 23-34% in year 5. After elimination of seed weight effects, orchard seedlings were 7-13% taller than stand seedlings and without elimination of seed weight effects 20-21% taller after 5 yrs. Even after elimination of both seed weight and genetic effects orchard seedlings were 3-9% larger than stand seedlings in the field experiment. In conclusion, the influence of seed weight and seed type on growth traits and slenderness is highly significant and the influence seems to be greater in harsh conditions.  相似文献   

19.
Baobab leaves form an important part of the local diet in Sahel countries and elsewhere in Africa. Existing leaf nutritional data and agroforestry performance information are based solely on Adansonia digitata L., the baobab of continental Africa. The introduction potential of Adansonia species from the center of diversity in Madagascar and from Australia remains untapped. To assess this potential, the mineral contents and B1 and B2 vitamin levels of dried baobab leaves were determined for five-year old trees of A. digitata, A. gibbosa (A. Cunn.) Guymer ex D. Baum, A. rubrostipa Jum. & H. Perrier (syn. A. fony Baill.), A. perrieri Capuron and A. za Baill. grown in an introduction trial in Mali. Nutritional data were evaluated against survival and vigor to identify promising germplasm. Leaf vitamin and crude protein contents were highest in the Madagascar species, especially A. rubrostipa (B1 88 mg 100 g−1, B2 187 mg 100 g−1, protein 20.7% dry weight). However, the local species far outperformed the introductions in survival, tree height, basal diameter and resistance to termites. We suggest grafting as a way of harnessing the vigor of well-adapted local baobab varieties to the superior nutritional profiles of A. rubrostipa and others. Cross-species grafting tests in Adansonia were successful, thus creating new agroforestry possibilities with different scion/rootstock combinations.  相似文献   

20.
Abstract

Wood in general and wooden studs in particular are often distorted owing to uneven shrinkage during the drying process in the sawmill. Twist is often the most detrimental of all types of distortion, and it is caused by spiral grain in combination with variations in moisture content. For sawmills, the objective is to produce dried, straight boards, and one method of dealing with boards with excessive spiral grain is to sort them out and then dry them in a pretwisted position to obtain straight boards after drying. A model using the finite element (FE) method for the simulation of drying twist distortions was first calibrated against laboratory experiments in which boards were dried with and without restraints and pretwists. After the calibration, the FE results were compared with industrial test results for boards that were dried without restraints or with restraints with zero pretwist, i.e. straight restraints. The FE model used an elastic–ideally plastic material model to obtain permanent deformations. The calibration was to set the yield stresses so that there was a good match between FE results and results from the laboratory experiments. The comparison between the industrial test results and the FE results showed that the FE model is capable of realistic simulations of drying boards with and without restraints and presumably also pretwists.  相似文献   

设为首页 | 免责声明 | 关于勤云 | 加入收藏

Copyright©北京勤云科技发展有限公司  京ICP备09084417号