互花米草与土豆混合厌氧发酵产酸和产沼气特性（英）

研究了中温（35℃）批量发酵条件下互花米草与土豆VS配比分别为6∶1、7∶1和9∶1时混合厌氧发酵的产酸发酵和产沼气特性。试验结果表明：1）与互花米草单独发酵时的丙酸型产酸发酵不同,混合发酵的产酸发酵表现为丁酸型发酵;混合发酵时发酵液中总挥发性有机酸（TVFAs）的浓度比互花米草单独发酵时提高了1倍多;混合发酵时发酵液中各单一有机酸浓度依次为乙酸>丙酸>丁酸,而互花米草单独发酵时为丙酸>乙酸>丁酸;2）6∶1、7∶1和9∶1三种配比下的沼气产量分别为460、431和415 mL/g VS,比互花米草单独发酵时的361 mL/gVS分别提高了27.4%、19.3%和15.0%;3）6∶1、7∶1和9∶1三种配比下的沼气中的甲烷含量分别为60.3%、62.4%和62.7%,比互花米草单独发酵条件下57.4%的平均甲烷含量提高了大约3%～5%。总之,混合发酵显著改变了互花米草的产酸发酵特性,这些改变对促进互花米草的厌氧发酵和提高所产沼气的质量均具有积极的意义。     

乙醇预发酵对餐厨垃圾与酒糟混合甲烷发酵的影响

为了解决餐厨垃圾两相干式厌氧发酵产甲烷过程中的挥发酸抑制问题,该试验在酸发酵阶段添加产乙醇菌分别进行12、24和48 h的预发酵,然后在相同条件下进行甲烷发酵,考察不同乙醇预发酵时间对餐厨垃圾与酒糟混合发酵产甲烷的影响,考察其甲烷发酵过程中的pH值、总挥发性有机酸(total volatile fatty acid,TVFA)、乙酸、丙酸、乙醇等参数的变化,并与未经乙醇预发酵的对照组比较,以期为相关领域的理论与实践研究提供参考经验。结果表明:各组乙醇浓度和pH值从高到低的顺序依次为:预发酵48 h组24 h组12 h组对照组,而乙酸和TVFA则呈现相反的顺序;由于乙醇为中性物质,且比丙酸容易转化为乙酸,故可缓解由有机酸累积而导致的酸抑制,使乙醇预发酵12、24、48 h组的累积产甲烷量分别比未经预发酵对照组高9.1%、31.6%、19.9%左右,其中,乙醇预发酵24h时厌氧消化效果较好。研究为厌氧发酵产甲烷过程中的解决酸抑制问题提供参考。     

海带渣与养殖固体废弃物混合发酵产沼气试验

废弃物的高效和资源化利用是现代渔业发展面临的重要课题。该文以海带渣和养殖固废为原料开展了两相发酵产沼气效果试验研究,探讨了中温条件下(35±1℃)料液TS浓度和接种率对混合水解酸化特性以及厌氧发酵产沼气效果的影响。结果表明,海带渣与养殖固废混合水解酸化过程启动很快,第2天乙酸浓度即达到峰值,5 d后丙酸和丁酸浓度增幅较快,水解酸化过程中甲酸产量相对较低。不同TS浓度(6%、8%和10%)和不同接种率(10%、20%和30%)的料液水解3 d,乙酸的酸化度分别为42.6%、50.0%、49.8%和50.7%、44.3%、40.3%;主要有机酸(乙酸+丁酸+甲酸)的酸化度分别达到61.7%、68.7%、62.2%和69.4%、57.5%、58.0%。料液TS浓度为8%~10%、接种率为10%~20%和p H值为6.0~7.0时,海带渣与养殖固废在中温条件下混合水解2~3 d,即可获得后期发酵产沼气所需的酸化料液。此外,发酵产沼气结果表明,每天按与产沼气接种污泥质量比为1:7~1:9的比例添加酸化料液,在p H值为7.0~8.0和35±1℃的条件下厌氧发酵产沼气,产气系统启动很快,而且8~13 d即进入稳定产气阶段,产气率保持在489.4~581.5 m L/g VS,所产沼气中的甲烷体积分数达到82.7%~84.9%,而且料液不会出现酸化现象。海带渣与养殖固废混合水解酸化、批量填料发酵产沼气工艺明显提高了产气效率和系统稳定性。     

接种物耐酸驯化对菌糠厌氧干发酵产气的影响

为了提高厌氧干发酵体系运行稳定性,使中间产物酸及时转化为甲烷,避免出现酸抑制现象,该研究采用逐步提高乙酸浓度降低pH值的方式对接种物进行驯化,得到了在乙酸浓度10200mg/kg、pH值6.0条件下仍能快速产气的耐酸接种物,并以易水解酸化的菌糠为原料进行了厌氧干发酵试验。结果表明,驯化过程中产甲烷古菌类群的多样性下降,乙酸营养型甲烷八叠球菌丰度大幅提高,乙酸转化率和甲烷浓度逐渐提高;耐酸接种物的脱氢酶活性下降,辅酶F420和纤维素酶活性升高;添加耐酸接种物可以加快菌糠厌氧干发酵启动速度,避免酸抑制现象的发生;接种物含有75%耐酸接种物的试验组甲烷产量提高了56.1%。该研究成果能够为有效解决厌氧干发酵过程酸抑制现象提供一定的理论指导。     

中温和高温环境下乙酸和丙酸厌氧发酵产甲烷动力学特征

采用不同浓度的乙酸和丙酸在中高温下进行厌氧发酵批次试验,采用修正的Gompertz模型和产甲烷的一级动力学模型分析,研究酸浓度和温度对发酵产气动力学的影响。研究表明,当乙酸和丙酸浓度较低时降解较快,高浓度酸抑制产气。乙酸在中温条件下降解较快,质量浓度为5 000 mg/L时中温反应有最大产甲烷速率101 mL/d;质量浓度为10 000 mg/L时高温条件下有最大产甲烷速率77 mL/d,随酸浓度增加,最大产甲烷速率减小,高温反应器对酸的耐受度较高。丙酸在高温条件下更易降解,浓度为4 000 mg/L时,中高温反应均有最大产气速率：78 mL/d（中温）和96 mL/d（高温）。另外,高浓度乙酸和丙酸厌氧降解产气具有滞后性,且随酸浓度的增加滞后期延长,降解过程受到抑制,一级动力学常数减小。温度对厌氧降解的影响大于酸浓度对厌氧降解的影响。     

猪粪秸秆不同物料比对固体产酸发酵效果的影响

在沼液回流的条件下,研究猪粪和秸秆固体产酸发酵过程中,不同原料配比（猪粪与秸秆质量比分别为4︰1、2︰1、1︰1、1︰3和0︰1即纯秸秆）对产酸发酵效果的影响。试验结果表明：增加发酵原料猪粪比例有利于调节发酵体系pH值,但酸化液中氨氮质量浓度较高;沼液回流能有效避免体系过酸现象;上述不同原料质量配比产酸发酵产物以乙酸为主,试验周期内,累积产乙酸质量分别占各反应器挥发性脂肪酸（VFAs）总质量的80.8%、81.8%、77.1%、78.3%和73.8%,酸化液中丙酸质量浓度均低于1.6 g/L,累积产生质量分别占各反应器VFAs总质量的4.8%、2.8%、7.2%、6.5%和8.4%。综合分析表明,猪粪与秸秆比为2︰1时,发酵过程中产酸效果优于其他配比试验。     

固态厌氧消化过程中有机质、有机酸和产气量空间异质性

研究反应器内发酵物料中有机质、有机酸和产气量在反应器中的空间差异对于有效提高混合物料的厌氧产气效率具有关键作用。该文以猪粪和秸秆混合物料为发酵原料,接种活性污泥,采用中温（35℃）筒式两相厌氧发酵工艺,对混合固态物料厌氧消化过程中不同区域料液的有机质、有机酸和产气速率进行监测,并主要分析其纵向的空间异质性变化。结果表明：固态厌氧发酵过程中,TS、VS、乙酸、丙酸、丁酸和戊酸的质量分数随着物料距反应器底面高度的增加而增大,越接近料液顶端,纵向差异越强,反之浓度降低越快,这5种关键物质在料液底部浓度较为均一,异质性明显降低;产气速率和单位VS累计产气量随着物料距反应器底面高度的增大而增加,皆为底层最低而顶层最高;反应过程中存在核心厌氧区,厌氧系统累计产气量和料液高度具有明显的幂增函数（R2=0.9754）关系,该研究为固态厌氧高效发酵提供了数据参考。     

稻草与猪粪混合厌氧消化特性研究

在中温条件下（35℃）,研究了稻草中添加猪粪对厌氧消化过程的影响,分析了消化过程中日产气量、累积产气量、甲烷含量、pH、挥发性脂肪酸以及硝态氮和氨态氮的变化。结果表明,将猪粪与稻草混合厌氧消化产沼气可以顺利进行,混合物的Vs产气量为330．14L·kg^-1 VS,沼气中甲烷含量为62．88％,添加猪粪对稻草产气量和有机酸的影响不明显,但对发酵过程中可能出现的酸积累有一定的缓冲作用。添加猪粪可以大幅提高发酵液中NO3-N含量,较稻草的处理提高34．53％,对提高消化液的肥料价值有重要意义。因此,将稻草与猪粪混合厌氧消化产沼气是完全可行的。     

预发酵方式对餐厨垃圾酸化抑菌及甲烷发酵的影响

餐厨垃圾水分和有机物含量高,在收集储运过程中易酸腐变臭,影响其资源化利用。该文在新鲜餐厨垃圾中分别接种酵母菌和乙酸菌进行乙醇和乙酸预发酵,预发酵后的餐厨垃圾与酒糟混合进行甲烷发酵,并与不接任何菌种的对照组比较,考察2种预发酵方式对餐厨垃圾酸化抑菌及其与酒糟混合甲烷发酵的影响。研究结果表明,乙酸和乙醇预发酵对餐厨垃圾均具有良好的酸化抑菌效果,其大肠杆菌和金黄葡萄球菌数均比对照组降低了2个数量级以上;累积甲烷产量由高到低的顺序是:乙醇预发酵对照乙酸预发酵组,前者累积产甲烷量比对照组和乙酸预发酵组分别提高21.3%和49.8%;乙醇预发酵组乙醇浓度最高,而乙酸和丙酸浓度均最低;相反,乙酸预发酵组挥发性脂肪酸浓度积累导致产甲烷菌活性较低,其产气效率最低。因此,乙醇预发酵是一种既能实现餐厨垃圾酸化抑菌,又能维持发酵系统的稳定性,提高其后续产甲烷效率的有效预发酵方式。     

复合菌系MC1预处理对玉米秸秆厌氧发酵产甲烷效率的提高

采用高效纤维素分解菌复合系MC1对玉米秸秆进行预处理,以提高玉米秸秆厌氧甲烷发酵的效率和产气量。复合菌系预处理的结果表明,预处理发酵液的pH值呈先下降后升高的趋势,与以往的复合菌系发酵产物pH值特性相似。在14 d的预处理过程中,秸秆质量减少了59.0%,其中纤维素减少了53.1%,半纤维素减少了76.4%。发酵液中的可溶性糖含量最大值出现在第2 d,为1.44 g/L。化学需氧量（COD）和挥发性产物最大值均出现在第4 d,监测到的5种挥发性产物的量分别为乙醇2.38 g/L、乙酸0.57 g/L、丙酸0.11 g/L、丁酸0.62 g/L和甘油0.22 g/L,因此,处理4 d后最适合甲烷发酵。厌氧发酵的结果表明,与未处理的玉米秸秆的厌氧发酵相比,预处理后的秸秆总产气量和总甲烷量分别了提高了33.0%和58.1%。结果表明,MC1对玉米秸秆预处理后,可明显提高甲烷产量,具有较高的利用潜力。     

Characterization of Organic Acids Recovered from Rhizosphere of Corn Grown on Biosolids‐Treated Medium

Abstract

Organic acid production by plants and microorganisms was quantified in sand media amended with biosolids in the presence and absence of corn (Zea mays L.) in a sand‐culture hydroponic medium. Total quantities of organic acids were greatest in treatments containing both plants and biosolids, with lesser amounts in treatments with plants alone, biosolids‐treated media alone, and a nutrient solution–irrigated blank medium. Biosolids enhanced organic acid production in the rhizosphere and influenced the composition of organic acid mixtures. Only lactic, acetic, butyric, and oxalic acids were detected in media without plants. When the medium was planted, additional organic acids were recovered including tartaric, maleic, succinic, valeric, glutaric, pyruvic, and propionic. Lactic, acetic, and butyric acids were predominant in solutions recovered from the planted media and collectively accounted for 0.65 to 0.75 of the COO^? mole fraction. Oxalic, maleic, and tartaric acids were the second most abundant and varied from 0.05 to 0.1 of the mole fraction, followed by succinic, valeric, glutaric, propionic, and pyruvic acids, comprising ≤0.05 of the mole fraction. Plant growth stage had no effect on relative proportions of organic acids but did influence the total quantities of organic acids recovered. Biosolids sources did not have a significant effect on either the quantity or composition of organic acids in any media. The predominance of organic acids that are microbial fermentation products suggests that the carbon contained in root exudates and biosolid amendments was transformed into a mixture of various fermentation products that accumulated in the rhizosphere solution and sand medium as a result of microbial growth and activity.     

Effect of Sludge Dissolved Organic Matter on Oxidation of Ferrous Iron and Sulfur by Acidithiobacillus Ferrooxidans and Acidithiobacillus Thiooxidans

Although two species of chemolithoautotrophic bacteria, Acidithiobacillus ferrooxidans and Acidithiobacillus thiooxidans, are widely considered to be the main microorganisms that control the process of bioleaching of heavy metals from sewage sludge, little is known about the effect of dissolved organic matter (DOM) present in sewage sludge on bacterial oxidation of energy substrate. Batch cultures studies showed that sludge DOM significantly inhibited ferrous iron and sulfur oxidation by Acidithiobacillus ferrooxidans LX5 and Acidithiobacillus thiooxidans TS6, respectively. The toxicity of sludge DOM appeared when the concentration was higher than 150 mg DOC L^?1. Among the organic compounds tested, the monocarboxylic organic acids including formic acid, acetic acid, propionic acid, and butyric acid exhibited a marked toxicity to Acidithiobacillus species. Of these organic acids, formic acid was the most toxic one as indicating that iron and sulfur oxidation almost were entirely inhibited at a concentration of 1.67 mM. In addition, it was found that A. ferrooxidans LX5 was more sensitive to glucose, starch, and citric acid than A. thiooxidans TS6, while the former seemed to be more acetic, propionic, and butyric acid resistant than the latter. In the selected 150 mg DOC L^?1 of DOM derived from Sludge-H, the concentrations of formic acid and acetic acid were 8.94 mM and 2.09 mM, respectively, being a contributing factor causing 95% inhibition of iron oxidation and 70% inhibition of sulfur oxidation. To exploit specific heterotrophic microorganisms to eliminate these toxic organic compounds should be further studied.     

植物乳杆菌抑制黄曲霉活性代谢物的初步研究

植物乳杆菌（Lactobacillus plantarum）能够抑制黄曲霉生长,但起主要抑菌作用的物质尚未明确。该研究采用非靶向代谢组学技术比较分析了8株抑菌活性较好（S组）和8株抑菌活性较差（W组）的L. plantarum发酵上清液。结果显示,两组L. plantarum发酵上清液的代谢组存在显著差异（P<0.05）。通过数据库比对鉴定得到咪唑乙酸、酪氨酸等30个显著差异代谢物（P<0.05）,其中有机酸、脂肪酸等酸性物质较多为22个。通过与已报道的乳酸菌产生的抗真菌物质相比较,找到十八烷酸、吲哚乙酸等结构一致或结构类似物,表明上清液中酸性物质起主要的抑菌作用,且其抑菌活性依赖于低 pH 值的酸性环境。在L. plantarum产生的主要有机酸中,乳酸、乙酸、丙酸的抑菌活性良好,其抑制黄曲霉活性从大到小依次为丙酸、乙酸、乳酸。当乙酸浓度为2.64g/L、丙酸浓度为1.76 g/L时,可完全抑制浓度为106个/mL的黄曲霉孢子生长。综合表明,植物乳杆菌代谢物中有机酸和脂肪酸为主要抑菌物质,且抑菌活性随酸性物质浓度增大而增强。     

粪便、餐厨及芦苇混合厌氧消化过程中餐厨含量的影响研究

采用完全混合湿式厌氧发酵方法,对餐厨、粪便及芦苇3种物料混合厌氧消化过程中餐厨含量的影响进行了研究。结果表明,餐厨加入量对这3种物料混合厌氧发酵影响显著。适当增加餐厨比例,有利于产气率的提高,但随着餐厨比例的增加,混合厌氧消化过程中乙酸、丙酸和丁酸含量增加明显,较容易出现＂酸化＂现象而影响产气效果。粪便、芦苇与餐厨湿重比为7∶2.5∶3时,产气效果最佳,最高容积产气率为1118mL·L^-1·d^-1,平均甲烷含量为64.6%,COD去除率达到68.56%。随着餐厨比例的增加,NH3-N含量逐渐增加,但未对厌氧消化产生抑制作用。     

Effects of aliphatic acids on seed germination and seedling growth in soil

Abstract

It is commonly assumed that the adverse effect of plant residues on crop yields is largely, or partly, due to phytotoxic compounds leached from these residues or produced by their decomposition, and it has been suggested that the phytotoxic compounds responsible for reduced crop yields are aliphatic acids such as acetic acid, butyric acid, and propionic acid. To test the validity of this hypothesis, we studied the effects of different amounts of acetic acid, butyric acid, and propionic acid on seed germination and seedling growth of corn (Zea mays L.), barley (Hordeum vulgare L.), and wheat (Triticum aestivum L.) in soils. The data obtained showed that the aliphatic acids tested had adverse effects on seed germination and seedling growth only when the amounts applied were much greater than the amounts reported to occur in soils treated with plant residues. We conclude that the adverse effect of plant residues on crop yields is not due to aliphatic acids derived from these residues.     

淹水土壤有机酸积累与秸秆碳氮比及氮供应的关系

有机酸积累和毒害是稻田秸杆还田中受到广泛关注的问题。本文以水稻与小麦秸杆为材料，采用淹水培养研究了甲酸、乙酸、丙酸及丁酸在士壤中的积累及其与秸秆碳氮比、氮肥添加量的关系。结果表明，在不施用氮肥的情况下。随秸秆用量的增加，秸秆处理的有机酸积累均显著增多。与稻秸处理相比，麦秸处理的有机酸（尤其足丙酸）积累量显著较高，土壤溶液中NH4^＋浓度显著较低。加入尿素明显减少有机酸积累，促进CH4排放，但对CO2的排放无显著影响；氮素的影响在麦秸处理中表现的尤为明显。上述结果说明麦秸的高碳氮比增加了无机氮的生物固定，抑制有机酸向CH4转化，从而导致麦秸处理有机酸积累量高于稻秸处理。施用氮肥是减少麦秸还田后有机酸积累的有效措施之一，但此措施将可能促进CH4的排放。     

添加钢渣恢复厌氧消化酸化系统提高沼气产量

针对厌氧消化酸化后传统恢复产气方法成本高,产气率低的问题,该文通过对比研究钢渣和碱对酸化后发酵体系的恢复作用,结果表明酸化体系添加钢渣后累积产气率为285.33 m L/g,较传统法(加碱)提高了25.8%,两组数据差异显著。同时对恢复产气后的p H值,总挥发性脂肪酸(total volatile fatty acid),碱度(alkalinity),挥发性脂肪酸(volatile fatty acids)进行了监测分析,发现两组的上述数据差异并不显著,TVFA/TA和丙酸/乙酸的比值更加有效指示两体系恢复后的稳定性,且添加钢渣体系较加碱体系提前8 d恢复正常。最后分析了恢复产气后消化液中重金属,两体系的重金属含量完全满足NY/T 2065-2011沼肥施用技术规范中的相关要求,此举提供了一种优于传统恢复酸化液渣产气的方式,为解决实际工程易酸化、恢复产气成本高的问题提出了新的解决方法。     

Organic acids in root exudates and soil solution of Norway spruce and silver birch

Here we report on low molecular weight organic acids in root exudates and soil solutions of Norway spruce and silver birch grown in rhizoboxes, sterile microcosms and the field. Monocarboxylic acids dominated in all three experimental systems. Formic, shikimic and oxalic acids were found in both spruce and birch microcosms. Fumaric acid was exclusive for spruce, while lactic, malonic, butyric and phthalic acids were only found in the birch microcosms. In spruce rhizoboxes oxalic, lactic, formic, butyric and pthalic acids were found. In addition, citric, adipic, propionic, succinic and acetic acids were observed in the rhizosphere of birch. Behind root windows in the field, only oxalic and lactic acids were found in the rhizosphere of spruce fine roots, whereas also formic and phthalic were observed close to birch fine roots, all at low concentrations. The rhizosphere of mycorrhizal short roots of birch contained butyric acid along with the acids observed for birch fine roots. Our results emphasise that characteristics of both the trees e.g. species, developmental stage, root density, mycorrhizal status, and the experimental system, i.e. growth conditions are important for the composition and the amount of organic acids. We conclude that the rhizosphere of birch contains more organic acids at higher concentrations than spruce.     

蛋白质和过瘤胃脂肪对晋南牛瘤胃发酵和尿嘌呤衍生物的影响

为探究蛋白质和富含不饱和脂肪酸的过瘤胃脂肪对瘤胃发酵和尿嘌呤衍生物的影响,选用4头装有永久性瘤胃瘘管的晋南阉牛,按照蛋白质需要量的85%、100%和115%设计3个水平,并在此基础上添加0、2.5%、5.0%和7.5%的亚麻油制作的钙皂作为过瘤胃脂肪,采用3×4两因素设计,共形成12组饲粮组合,测定瘤胃pH、氨态氮浓度(NH_3-N)浓度、挥发性脂肪酸(VFA)含量以及尿嘌呤衍生物(PD)的排出量。结果表明,蛋白质和过瘤胃脂肪水平对瘤胃pH均无显著影响。蛋白质水平对NH_3-N浓度影响显著,9组NH_3-N显著高于1、2、3、4和8组,10组显著高于3和8组;对丙酸和乙酸、丁酸、乙酸/丙酸及总酸分别具有极显著和显著影响,5组的乙酸浓度较1、2、3和4组显著提高,9、10和11组瘤胃液中的丙酸浓度较1和2组显著提高,12组较2组显著提高,10组的丁酸浓度显著高于7和8组,1和2组的乙酸/丙酸比值显著高于9、10和11组;对精补料养分有效降解率影响极显著,对秸秆有机物(OM)和酸性洗涤纤维(ADF)分别具有极显著和显著影响,10组精补料粗蛋白质(CP)瘤胃有效降解率显著高于2、3、4、5、6、7和8组,1、9、11和12组显著高于4、5、6、7和8组;对玉米秸秆中ADF瘤胃有效降解率6、7和8组显著高于除5和12组之外的其余各组,5和12组显著高于除9和11组之外的其余各组;对尿囊素和尿嘌呤衍生物有显著影响,12组的尿囊素和尿嘌呤衍生物显著高于1和4组,11组尿酸显著高于其余组。综上,饲粮蛋白质水平对瘤胃发酵和尿嘌呤衍生物具有显著影响,饲粮蛋白质水平为饲养标准需要量前提下,过瘤胃脂肪适宜添加量为饲粮的5%。本研究结果为肉牛养殖中日粮过瘤胃脂肪添加量及蛋白质水平提供了一定的依据。     

Organic Acid Effects on Nutrient Uptake by Rice

The purpose of this work was to evaluate the responses of 20 rice cultivars to the phytotoxic effects of acetic, propionic, and butyric acids produced in soils under anaerobic conditions. The study was conducted in a hydroponic system, with four levels (0, 3, 6, and 9 mM) of the three organic acids in the ratio of 6:3:1 in a factorial of complete randomized block design with three replications. The evaluated variables were phosphorus (P) and potassium (K) contents. The analysis of variance revealed a significant interaction, and the established regressions showed differences among the genotypes as evaluated for both variables. Four genotypes were classified as tolerant in relation to P content and three genotypes as tolerant in relation to K. The best performance was verified with japonica genotypes and the irrigation-based growing system.