Low molecular weight compounds responsible for savory taste of Indonesian soy sauce

Indonesian soy sauce is made using only soybeans as the nitrogenous source. Moromi obtained from fermentation of yellow soybeans using Aspergillus sojae as the starter was investigated. The fraction with molecular weights of less than 500 Da obtained by stepwise ultrafiltration was then fractionated by several chromatographic procedures, including gel filtration chromatography and RP-HPLC. Several chemical analyses, CE profiles, and taste profiles were performed to obtain the most intense umami fraction. The main components eliciting or enhancing the umami taste present in the fraction were purified and identified by protein sequencing, ESI-MS, and (1)H NMR at 400 MHz. Besides free l-glutamic acid and aspartic acid, free aromatic amino acids such as l-phenylalanine and l-tyrosine may also play an important role in impressing savory or umami taste of Indonesian soy sauce at their subthreshold concentrations and in the presence of salt and free acidic amino acids. This is reported as a new phenomenon of the so-called bitter amino acids.     

大豆酱油电渗析脱盐工艺参数对其脱盐率及品质的影响

为了降低大豆酱油的含盐量,该文利用电渗析技术对大豆酱油进行脱盐处理,通过单因素试验探讨了电压、流速、pH值对电渗析脱盐效果的影响,确定了较佳电渗析工艺。结果表明在电压为9 V,流速为2.4 cm/s,pH值为4.2,电渗析50 min时脱盐效果较好,氨基酸态氮损失较小,氨基酸态氮损失19.4%,脱盐率达到81.6%。利用氨基酸自动分析仪和气相色谱-质谱联用仪（gas chromatography-mass spectrometry）分析了电渗析前后游离氨基酸及挥发性风味物质的变化规律,结果表明电渗析过程中氨基酸及风味物质均有损失。几种苦味氨基酸如组氨酸、精氨酸、赖氨酸损失较大,分别损失了23.79%、26.39%和28.5%;电渗析过程中,酱油风味物质中醇类、酚类损失较大,尤其是4-乙基愈创木酚损失最多,但因其气味阈值较低,因此对酱油风味影响较小。研究结果为减盐酱油系列产品的生产提供了参考和依据。     

Transcriptome profiling of heat-resistant strain Bacillus licheniformis CGMCC3962 producing Maotai flavor

Although Maotai flavor liquor is exclusive due to its soy sauce flavor, knowledge of its key compound and production mechanism is still scarce until now. To gain insight into the production mechanism of soy sauce flavor, a soy sauce flavor producing strain with high efficiency and heat-resistant capability was obtained, and the metabolic mechanism of the strain was investigated with the technique of microarray profiling. Because high temperature was a key factor for soy sauce flavor production, the global gene expression of this heat-resistant strain fermented at 55 °C was analyzed. Except for the responsive increase of heat shock proteins, which maintained cell survival during heat stress, biosynthesis of cysteine was also up-regulated. In addition, some metabolites were significantly increased when cysteine was added to the fermentation medium, such as 2,3-butanediol, 3-hydroxy-2-butanone, and tetramethylpyrazine, which were important flavor compounds in soy sauce flavor liquor and might be related with soy sauce flavor. The results indicated that cysteine might play an important role in the formation of soy sauce flavor compound, and it might act as an indirect precursor or stimulator of soy sauce flavor formation. This was the first use of the microarray profiling tool to investigate the fermentative strains for Chinese traditional liquor, which would allow a deeper insight into the mechanism of the formation of soy sauce flavor compound.     

Immunoreactivity and amino acid content of fermented soybean products

Food allergy has become a public health problem that continues to challenge both the public and the food industry. The objective of this research was the detection and quantification of the major human allergenic soy proteins and to study the reduction in immunoreactivity and improvement of amino acid content after fermentation of soybean flour. Fermentation was carried out in the solid state of cracked seeds inoculated with Aspergillus oryzae, Rhizopus oryzae, and Bacillus subtilis and in the liquid state of milled soybean flours fermented naturally by microorganisms present only in the seeds or by inoculation with Lactobacillus plantarum. ELISA and Western blot were used to quantify IgE antibody response, and HPLC was used to identify and quantify total amino acids. L. plantarum fermented soy flour showed the highest reduction in IgE immunoreactivity (96-99%) depending upon the sensitivity of the plasma used. Among the solid fermented products, the lowest reduction in immunoreactivity was obtained when mold strains, R. oryzae and A. oryzae, were used (66 and 68%, respectively, for human plasma 97.5 kUA/L). Among the solid fermented products, those inoculated with B. subtilis yielded a 81 and 86% reduction in immunoreactivity against both human plasma 97.5 IgE kUA/L and human pooled plasma samples, respectively. When soybean was subjected to liquid fermentation, most of the total amino acids increased significantly ( p < or = 0.05). In solid fermentation with R. oryzae, only Ala and Thr content improved. Fermentation can decrease soy immunoreactivity, and there is potential of developing nutritious hypoallergenic soy products.     

Soy and alfalfa phytoestrogen extracts become potent low-density lipoprotein antioxidants in the presence of acerola cherry extract

Postmenopausal women have an increased risk of coronary heart disease. Oxidation of low-density lipoprotein (LDL) has been implicated in atherogenesis, and the presence of modified LDL (LDL(-)) in plasma appears to represent LDL oxidation in vivo. Because previous studies have demonstrated a strong antiatherogenic effect of estrogen due to its antioxidant activity and similar antioxidant activity was found for specific isoflavones derived from soy extract, the antioxidant activity of a phytoestrogen extract derived from soy and alfalfa was studied. Copper-mediated LDL oxidation was inhibited in the presence of soy and alfalfa extracts, and this effect was further enhanced in the presence of acerola cherry extract, which is rich in ascorbic acid. Male rabbit aortic endothelial cells pretreated with soy extract were resistant to the toxic effects of high levels of LDL and LDL(-), and a lesser, but significant protection, was also afforded by alfalfa extract. Cell-mediated oxidation of LDL, measured by LDL(-) formation, was inhibited in the presence of soy extract but not alfalfa extract. However, in the presence of acerola cherry extract, both soy and alfalfa extracts potently inhibited the formation of LDL(-). These findings show that acerola cherry extract can enhance the antioxidant activity of soy and alfalfa extracts in a variety of LDL oxidation systems. The protective effect of these extracts is attributed to the presence of flavonoids in soy and alfalfa extracts and ascorbic acid in acerola cherry extract, which may act synergistically as antioxidants. It is postulated that this synergistic interaction among phytoestrogens, flavonoids, and ascorbic acid is due to the "peroxidolitic" action of ascorbic acid, which facilitates the copper-dependent decomposition of LDL peroxides to nonradical products; this synergy is complemented by a mechanism in which phytoestrogens stabilize the LDL structure and suppress the propagation of radical chain reactions. The combination of these extracts markedly lowers the concentrations of phytoestrogens required to achieve significant antioxidant activity toward LDL.     

Antioxidant properties of soybean isoflavone extract and tofu in vitro and in vivo

Isoflavones in soybean were extracted in the crude form using 80% food-grade ethanol at 80 degrees C for 6 h and followed by concentration and dehydration. The soy extract contained isoflavones primarily in the forms of glucosides. In vitro antioxidant activities of the soy extract containing 20-500 ppm isoflavones were conducted using a Rancimat method. The results showed that soy isoflavone extract had strong in vitro antioxidant activity. There was a dose-dependent response for the in vitro antioxidant activity at the lower concentrations but not at the higher concentrations. In vivo antioxidant property was determined by measuring the antioxidant enzymes, superoxide dismutase, and catalase in various organs of rats that were fed with diets containing partially oxidized oil and various levels of isoflavones for up to 24 weeks. Neither short-term (8 weeks) feeding nor low isoflavone content (50 ppm) induced changes in superoxide dismutase or catalase activities in rats. Only diets containing high isoflavone contents (150 and 250 ppm) showed obvious elevated enzymatic levels in various organs. In addition, a laboratory-prepared tofu containing approximately 50 ppm isoflavones had better effects than the soy extract with the 250 ppm isoflavone group, which indicated that molecules other than isoflavones may have a synergistic effect on in vivo antioxidant enzyme inductions of tofu.     

MALDI-TOF MS analysis of isoflavones in soy products

Matrix-assisted laser desorption/ionization time-of-flight mass spectrometry (MALDI-TOF MS) is a new technique having a number of advantages for food analysis. This study is the first to demonstrate the use of MALDI-TOF MS to identify isoflavones in soy samples. 2',4',6'-Trihydroxyacetophenone (THAP) and 2,5-dihydroxybenzoic acid (DHB) were both good matrices for isoflavones, but DHB was chosen as the best because it worked well for sample extracts, with good spot-to-spot repeatability. Isoflavones were predominantly ionized in a protonated form with a very small amount of sodium or potassium adduct ions. Fragmentation occurred only through loss of glycosidic residues. Daidzin showed more than twice the response of genistin using MALDI-TOF MS. A simple solid phase extraction of isoflavones from soy samples was developed for MALDI-TOF MS analysis. MALDI-TOF MS can provide an isoflavone profile in 2 min and serves as a powerful tool to identify and study processing changes of isoflavones in soy products.     

Isoflavones in soy-based foods consumed in Brazil: levels,distribution, and estimated intake

The isoflavone content and profile in processed soy-based products consumed in Brazil were determined by high-performance liquid chromatography and photodiode array detection of the intact isoflavones (naturally occurring aglycons, malonyl, acetyl, and beta-glycosides derivatives). Total isoflavone content varied significantly among products, from 2 to 100 mg/100 g (wet basis, expressed as aglycons), with the lowest content being found for soy-based enteral/oral diets and the highest found for textured soy proteins. For soy beverages isoflavone content varied from 12 to 83 mg/L. Soy sauce, miso, and tofu had isoflavone contents of 5.7 mg/L, 20 mg/100 g, and 7 mg/100 g, respectively. The beta-glycosides were the predominant form of the isoflavones in the products analyzed, except for miso, shoyu, and "Diet Shake" in which the aglycons were present in the highest proportions. On the basis of these data, the daily intake of isoflavone from soy products was estimated: the highest values were found for infants fed soy-based formulas, from 1.6 to 6.6 mg/kg of body weight.     

Determination of 4(5)-methylimidazole in soy sauce and other foods by LC-MS/MS after solid-phase extraction

A method for the determination of 4(5)-methylimidazole (4MeI) in naturally brewed soy sauce was developed for the first time using solid-phase extraction (SPE) and liquid chromatography-tandem mass spectrometry (LC-MS/MS). SPE on silica-based reversed-phase cartridges with heptafluorobutyric acid as an ion-pairing reagent was used for the efficient cleanup of 4MeI. A multimode ODS column was employed for the chromatographic separation. To subtract the matrix effect during LC-MS/MS analysis, a standard addition method was used. The levels of 4MeI found in naturally brewed soy sauce were extremely low (ranging from <0.002 to 0.023 μg/g), whereas those in soy sauces containing caramel color were generally high (ranging from 0.43 to 4.8 μg/g). The method proved to be useful for the analysis of 4MeI in other foods such as caramel colors, drinks, and Worcestershire sauce.     

Liquid chromatographic determination of protein acid hydrolysate content in blended soy sauce

Five methods were investigated for the determination of levulinic acid in soy sauce to determine the addition of protein hydrolysate, mainly acid hydrolysate of defatted soybeans. Best results were obtained by using liquid chromatography (LC) with 0.004 M HClO4 as the mobile phase and bromcresol purple as a post-column reagent. An innovative LC method with 0.1% H3PO4 as eluant was developed for determination of levulinic acid at 280 nm in soy sauce. This was the most time-saving method.     

Isoflavone conjugates are underestimated in tissues using enzymatic hydrolysis

Many health effects of soy foods are attributed to isoflavones. Isoflavones upon absorption present as free form, glucuronide, and sulfate conjugates in blood, urine, and bile. Little is known about the molecular forms and the relative concentrations of soy isoflavones in target organs. Acid hydrolysis or enzymatic hydrolysis (glucuronidases and sulfatases) was used to study isoflavone contents in the heart, brain, epididymis, fat, lung, testis, liver, pituitary gland, prostate gland, mammary glands, uterus, and kidney from rats fed diets made with soy protein isolate. The heart had the lowest isoflavone contents (undetectable), and the kidney had the highest (1.8 +/- 0.6 nmol/g total genistein; 3.0 +/- 1.1 nmol/g total daidzein). Acid hydrolysis released 20-60% more aglycon in tissues than enzymatic digestion (p < 0.05), and both hydrolysis methods gave the same level of isoflavones in serum. Approximately 28-44% of the total isoflavone content within the liver was unconjugated aglycon, and the remainder was conjugated mainly as glucuronide. The subcellular distribution of total isoflavones was 55-60% cytosolic and 13-16% in each of the nuclear, mitochondrial, and microsomal fractions. These results demonstrated that (1) soy isoflavones distribute in a wide variety of tissues as aglycon and conjugates and (2) the concentrations of isoflavone aglycons, which are thought to be the bioactive molecules, are in the 0.2-0.25 nmol/g range, far below the concentrations required for most in vitro effects of genistein or daidzein.     

Use of Tetragenococcus halophilus as a starter culture for flavor improvement in fish sauce fermentation

The potential of Tetragenococcus halophilus as a starter culture for flavor improvement in fish sauce fermentation was elucidated. Four strains of T. halophilus isolated from fish sauce mashes were inoculated to anchovy mixed with 25% NaCl with an approximate cell count of 10(6) CFU/mL. The α-amino content of 6-month-old fish sauce samples inoculated with T. halophilus was 780-784 mM. The addition of T. halophilus MRC10-1-3 and T. halophilus MCD10-5-10 resulted in a reduction of histamine (P < 0.05). Fish sauce inoculated with T. halophilus showed high contents of total amino acids with predominantly high glutamic acid. Major volatile compounds in fish sauce were 2-methylpropanal, 2-methylbutanal, 3-methylbutanal, and benzaldehyde. T. halophilus-inoculated fish sauce samples demonstrated the ability to reduce dimethyl disulfide, a compound contributing to a fecal note. The use of T. halophilus for fish sauce fermentation improves amino acid profiles and volatile compounds as well as reduces biogenic amine content of a fish sauce product.     

LC/UV/ESI-MS analysis of isoflavones in Edamame and Tofu soybeans

High-performance liquid chromatography coupled with ultraviolet and electrospray ionization mass spectrometry (HPLC/UV/ESI-MSD) was applied to the study of isoflavones in both Edamame and Tofu soy varieties, from which the immature fresh soybeans or the mature soybean seeds are consumed, respectively. Positive atmospheric pressure interface (API) MS and MS/MS were used to provide molecular mass information and led to the identification of a total 16 isoflavones, including three aglycones, three glycosides, two glycoside acetates, and eight glycoside malonates. The major isoflavones in soybean seeds were daidzein and genistein glycoside and their malonate conjugates. Trace levels of daidzein and genistein acetyl glycosides were found only in the mature dry soybean seeds. To facilitate quantitative analysis, acid hydrolysis during extraction of soy samples was selected to convert the various phytoestrogen conjugates into their respective isoflavone aglycones, allowing accurate quantitation of total phytoestrogens as aglycones. On the basis of HPLC combined with UV and MS detection, all three targeted soy isoflavone aglycones, daidzein, genistein and glycitein in hydrolyzed extracts were successfully quantified within 25 min with formononetin used as the internal standard. The standard curves of UV detection were fitted in the range of 14.16-29000 ng/mL for daidzein, 15.38-31500 ng/mL for genistein, and 11.72-24000 ng/mL for glycitein. For MS detection, the standard curves were established in the range of 3.54-1812.5 ng/mL for daidzein, 3.85-1968.75 ng/mL for genistein, and 2.93-1500 ng/mL for glycitein. Good linearities (r(2) > 0.999 for UV and r(2) > 0.99 for MS) for standard curves were achieved for each isoflavone. The accuracy and precision (RSD) were within 10% for UV detection and 15% for MS detection (n = 10). Using this method, the phytoestrogen levels of total isoflavone aglycones from 30 soybean seed varieties were then evaluated for confirmation of the technique. Total isoflavones ranged across the varieties from 0.02 to 0.12% in the Edamame varieties, which are harvested while the seeds are still immature, and from 0.16 to 0.25% in Tofu varieties, harvested when the seeds are physiologically mature. While the literature has focused on the isoflavone content of soy products and processing soy, this report provides a reliable analytical technique for screening of authenticated fresh immature Edamame soybeans and Tofu soybeans.     

Ultraviolet spectrophotometric determination of benzoic acid in soy sauce.

Proteins and other interfering substances are precipitated from soy sauce, using sodium tungstate under acidic conditions. After centrifugation, the supernate is successively extracted with ethyl ether to isolate the benzoic acid in the organic solvent. The ethyl ether extract is washed with dilute HCl. Benzoic acid is then quantitatively determined by ultraviolet spectrophotometry. Recovery of sodium benzoate added to soy sauce ranged from 94 to 104%.     

Regulative actions of dietary soy isoflavone on biological antioxidative system and lipid metabolism in rats

Male Sprague-Dawley rats, 4 weeks of age, were fed purified diets either with or without 0.2% soy isoflavones rich powder for 5 weeks to elucidate their direct functions such as antioxidative action and regulation of lipid metabolism. Dietary soy isoflavones decreased serum lipid peroxide level in rats. Levels of liver and serum alpha-tocopherol were higher in the rats fed isoflavone than in those fed isoflavones-free diet. Thus, dietary soy isoflavones exhibited mild antioxidative function in this animal experiment. Isoflavone metabolites from diet may act as scavengers of reactive oxygen species. Dietary soy isoflavones lowered hepatic 3-hydroxy-3-methylglutaryl CoA reductase activity, although liver cholesterol level was not modulated. However, the levels of serum cholesterol and triglyceride decreased by consumption of soy isoflavones. Therefore, dietary soy isoflavones may exhibit hypocholesterolemic and hypolipidemic functions. Moreover, dietary soy isoflavones lowered hepatic Delta6 desaturase activity. Reflecting this observation, Delta6 desaturation indices ((18:2(n = 6) + 18:3(n = 6))/20:4(n = 6)) of tissue lipids tended to be lower in rats fed isoflavones than in those fed isoflavones-free diet. This action may contribute to the prevention of inflammatory response by imbalance of eicosanoids. These observations suggest that the positive intake of soy isoflavones may reduce the risk of some cardiovasucular diseases through their radical scavenging function and hypocholesterolemic action.     

Characteristics of salt-fermented sauces from shrimp processing byproducts

A salt-fermented sauce from shrimp processing byproducts (heads, shells, and tails) was prepared and characterized. Three types of sauces were prepared; sauce C, with 30 g of salt/100 g of byproduct (high salt); sauce E, with 30 g of salt and 0.2 g of sodium erythorbate (high salt); and sauce L, with 20 g of salt, 0.2 g of sodium erythorbate, 6 g of sorbitol, 0.5 mL of lactic acid, and 5 mL of ethanol (low salt). Sauces C and E showed higher exopeptidase activities than sauce L, whereas sauce L showed the highest endopeptidase activity. After 3 months of fermentation, the amino N content of sauce increased from 150-200 to 500-600 mg/100 g and the nonprotein nitrogen content increased from 300 to 950-1050 mg/100 g. Volatile basic nitrogen content increased significantly from 18 to 60 mg/100 g. The total carotenoids retained in sauces C, E, and L were 26.3, 76.2, and 73%, respectively, thus indicating that the addition of sodium erythorbate to sauces E and L retarded oxidation. Water activities of sauces C, E, and L were 0.753, 0.751, and 0.773, respectively. According to the omission test, the taste of sauces was influenced by the content of free amino acids, mainly glutamic acid and aspartic acid. All three sauces examined showed a 35% higher total amino acid content than commercial salt-fermented shrimp sauces. Therefore, shrimp processing byproducts may lend themselves to the preparation of high-quality salt-fermented sauces.     

Novel process of fermenting black soybean [Glycine max (L.) Merrill] yogurt with dramatically reduced flatulence-causing oligosaccharides but enriched soy phytoalexins

Black soybeans [Glycine max (L.) Merrill] were germinated under fungal stress with food grade R. oligosporus for 3 days and were homogenized and fermented with lactic acid bacteria (LAB) to produce soy yogurt. Fungal stress led to the generation of oxylipins [oxooctadecadienoic acids (KODES) isomers and their respective glyceryl esters] and glyceollins--a type of phytoalexins unique to soybeans. In soy yogurt, the concentrations of total KODES and total glyceollins were 0.678 mg/g (dry matter) and 0.953 mg/g, respectively. The concentrations of other isoflavones (mainly genistein and daidzein and their derivatives) in soy yogurt remained largely unchanged after the processes compared with the control soy yogurt. Germination of black soybean under fungal stress for 3 days was sufficient to reduce stachyose and raffinose (which cause flatulence) by 92 and 80%, respectively. With a pH value of 4.42, a lactic acid content of 0.262%, and a maximum viable cell count of 2.1 x 10 (8) CFU/mL in the final soy yogurt, soy milk from germinated soybeans under fungal stress was concluded to be a suitable medium for yogurt-making. The resulting soy yogurt had significantly altered micronutrient profiles with significantly reduced oligosaccharides and enriched glyceollins.     

Antiplatelet activity of soy sauce as functional seasoning.

In seeking the functionality of foodstuffs applicable to medicine, soy sauce was found to show antiplatelet activity. Therefore, the active components in soy sauce were purified, structurally identified, and studied for their inhibitory effects on the aggregation of human platelets. Aqueous 2-fold diluents of soy sauce inhibited platelet aggregation induced by collagen and epinephrine depending on the dilution factor. Since a basic extract with diethyl ether completely inhibited collagen-induced aggregation, it was subjected to serial extractions and multistep HPLC fractionations for purifying antiplatelet components. The finally obtained isolates were identified as 1-methyl-1,2,3,4-tetrahydro-beta-carboline and 1-methyl-beta-carboline on the basis of EI-MS, (1)H NMR, diode array, and fluorescence spectra. Their spectral data and chromatographic behaviors were the same as those of synthetic ones. 1-Methyl-1,2,3, 4-tetrahydro-beta-carboline showed mean concentrations (n = 5-6) of 4.6, 4.2, 28.6, 11.6, and 65.8 microgram/mL to produce 50% inhibition of the maximal aggregation response induced by epinephrine, platelet-activating factor, collagen, adenosine 5'-diphosphate, and thrombin, respectively. Its inhibitory effect was much greater than that of 1-methyl-beta-carboline on platelet aggregation by all the tested inducers. The quantitative HPLC analysis revealed that the significant amounts of both antiplatelet compounds were uniformly contained in commercially available soy sauce. From these results, soy sauce may be referred to as functional seasoning containing alkaloidal components with the potent preventive effect on thrombus formation.     

Antioxidant activity of isoflavones and their major metabolites using different in vitro assays

Isoflavone phytoestrogens found mainly in soybeans and clover are widely studied phytochemicals. Genistein and daidzein, the major isoflavones found in soy, have received the most attention. However, they undergo extensive metabolism in the intestine and the liver, which might affect their biological properties, e.g. their antioxidant capacities. Furthermore, the biological activities of other naturally occurring isoflavones, for instance, glycitein from soy or biochanin A from red clover, have not yet been studied in detail. The aim of this study was to investigate the antioxidant activities of six naturally occurring isoflavones and their corresponding oxidative and bacterial metabolites. The oxygen radical absorbance capacity assay as well as the in vitro oxidation of low density lipoproteins with the conjugated diene and the thiobarbituric acid reacting substances formation as end points were used. The oxidative metabolites of genistein and daidzein as well as equol exhibited the highest antioxidant activities in all three assays. With few exceptions, they were more effective than the positive controls quercetin and ascorbic acid. Formononetin, the 4'-O-methyl ether of daidzein, showed the lowest antioxidant property. Because the antioxidant efficacy of isoflavones as effective antioxidants is evident at concentrations well within the range found in the plasma of subjects consuming soy products, this biological activity could be of physiological relevance.     

Changes of astringent sensation of soy milk during tofu curd formation

The effect of isoflavone on soy milk and tofu astringency was investigated, and no consistency was found between an undesirable astringent taste and isoflavone contents. Isoflavone-enriched extract (approximately 39% isoflavones) showed no astringency. Soybean foods having high amounts of isoflavones showed less astringency. About 80% of isoflavones exist freely in both soy milk and tofu, but 55% of phytates (which play an important role in the formation of the tofu curd network) exist freely in the soy milk, and 6-13%, on the basis of coagulation, existed freely in the tofu curds. A 1% potassium phytate solution at pH 7 showed the very same astringency as soy milk; however, calcium phytate at the same concentration and pH showed no undesirable sensation. Thus, it is assumed that the astringent characteristics caused by phytic ions in soy milk are lost upon conversion of phytic ions to their insoluble salt forms during soy milk coagulation.