Foot lesions in finishing pigs and their associations with the type of floor.

The associations between individual foot lesions and different types of floor were investigated in 4038 finishing pigs on 21 units. The overall prevalence of foot lesions was 93.8 per cent and the prevalence ranged from 79.4 per cent to 100 per cent on different units. Analysis showed that pigs kept on bedded floors, with either sparse or deep straw, had a lower prevalence of sole erosions, heel erosions and heel flaps and a higher prevalence of white line lesions, false sand cracks, wall separations and toe erosions than pigs kept on bare solid concrete floors. Partially slatted floors were associated with an increased prevalence of heel erosions, heel flaps, white line lesions, wall separations and false sand cracks, and totally slatted floors were associated with an increased prevalence of sole erosions and heel flaps.     

A cross-sectional study of the prevalence and associated risk factors for capped hock and the associations with bursitis in weaner, grower and finisher pigs from 93 commercial farms in England

The prevalence of capped hock in 5601 post-weaning pigs from 93 pig farms in England was 17.2%. The prevalence increased with age. Once adjusted for age, the lowest prevalence of capped hock was observed in pigs kept on soil floors (usually covered with deep straw bedding). There was no significant increase in the risk of capped hock in pigs kept on solid concrete floors with deep straw bedding. However, pigs kept on solid concrete with some, or the entire pen, sparsely bedded and pigs kept on partially or fully slatted floors had an approximately threefold increased risk of capped hock. This did not vary significantly between these four floor types. This was in contrast to the associated risks for bursitis in the same pigs, where as the floor went from highly resilient (straw and solid floors) to hard and perforated (fully slatted) the risk of bursitis increased in a similar way to a dose response. No other variables that were measured were associated with a change in risk for capped hock, while observation of pigs slipping or slip marks and wet, dirty and worn pens were also associated risks for bursitis. These results indicate that capped hock and bursitis are both affected by exposure to floors, but in different ways. The prevalence of capped hock was associated only with floor hardness, with deep straw protecting the pigs, while bursitis was associated with both changes in bedding depth (hardness), floor material (soil versus concrete) and floor construction (solid versus slatted floors) and in factors associated with locomotion (slipping and slip marks). These results indicate that the aetiology of capped hock and bursitis might differ.     

A cross-sectional study of the prevalence and associated risk factors for bursitis in weaner, grower and finisher pigs from 93 commercial farms in England

A cross-sectional study of 93 farms in England was carried out to estimate the prevalence and associated risk factors for bursitis. A total of 6250 pigs aged 6–22 weeks were examined for presence and severity of bursitis. Details of pen construction, pen quality and farm management were recorded including floor type, presence of bedding, condition of the floor and floor materials. The prevalence of bursitis was 41.2% and increased with each week of age (OR 1.1). Two-level logistic regression models were developed with the outcome as the proportion of pigs affected with bursitis in a pen. Pigs kept on soil floors with straw bedding were used as the reference level. In comparison with these soil floors, bursitis increased on concrete floors where the bedding was deep throughout (OR 4.6), deep in part (OR 3.7), and sparse throughout (OR 9.0), part slatted floors (OR 8.0), and fully slatted floors (OR 18.8). Slip or skid marks in the dunging area (OR 1.5), pigs observed slipping during the examination of the pen (OR 1.3) and wet floors (OR 3.6) were also associated with an increased risk of bursitis. The results indicate that bursitis is a common condition of growing pigs and that the associated risk factors for bursitis were a lack of bedding in the lying area, presence of voids and pen conditions which increased the likelihood of injury.     

Lameness and claw lesions of the Norwegian red dairy cattle housed in free stalls in relation to environment, parity and stage of lactation

Approximately 88% of Norwegian dairy cattle are housed in tie stalls. Free stall housing for all dairy cattle will be implemented within 20 years. This means that the majority of existing stalls will be rebuilt in the near future. Fifty-seven free stall herds of the Norwegian Red breed were randomly selected and 1547 cows and 403 heifers were trimmed by 13 claw trimmers during the late winter and spring of 2002. The claw trimmers had been taught diagnosing and recording of claw lesions. Environment, management- and feeding routines were also recorded. Fifty-three herds had concrete slatted alleys while 4 had solid concrete. Thirty-five herds had concrete as a stall base, while 17 had rubber mats, 2 had wood and 3 had deep litter straw beds. The prevalence of lameness was 1.6% in hind claws. Models for lameness and claw lesions were designed to estimate the influence of different risk factors and to account for the cluster effects within herd and claw trimmer. Detected risk factors for lameness were: parity three and above and narrow cubicles; for heel horn erosions: lactation stage around 5-7 months after calving and solid concrete alleys; for haemorrhages of the white line: lactation stage around 3-5 months after calving and solid concrete alleys; for haemorrhages of the sole: parity one, lactation stage around 5-7 months after calving and short cubicles, for white line fissures: slatted concrete alleys; for asymmetrical claws: parities two and above and for corkscrewed claws: solid concrete alleys. The prevalence of lameness in heifers was low, however 29% had one or more claw lesions. Heifers that were housed in pens or free stalls had more heel-horn erosions, haemorrhages of the sole and white-line fissures than heifers in tie stalls. As new free stalls are being built, it is important to optimise the conditions for claw health.     

Prevalence of herd specific factors and limb disorders,and their associations in intensive swine production

A longitudinal observational study in 180 pig breeding herds was performed to calculate prevalences of herd specific factors as well as typical limb disorders and to estimate their associations in a 2-step regression analysis. Regarding herd size, genetics, feeding and weight gain herds were distributed almost equal. The population density and the hygiene status were considered proper in most herds. In the farrowing units partially slatted floors of metal or plastic with slats > 9 mm, in the weaning units fully slatted floors of plastic, and in the rearing units fully slatted floors of concrete were most common. Less than 6% of the farms housed their pigs on solid concrete with straw bedding. Herd prevalences of fault floors varied between 18 and 43%. As a herd health problem (morbidity > 25%) claw hematomas and limb abrasions in just 1-week old piglets, overgrown claws and bursa swellings in weaned pigs, and bursa swellings in rearing pigs were wide spread. Leg deformations by osteopathy or arthritis occurred only sporadically. In the risk analysis claw hematomas of piglets were associated with slatted floors, particulary with slats < 10 mm. Abrasions were associated with concrete and rough floor surfaces at all. Overgrown claws and bursa swellings in weaned and in rearing pigs were associated with damaged, slippery or rough floor surfaces. Other associations were not detected. The quality of floor might be more important than the type of housing.     

Factors in the housing environment of finisher pigs associated with the development of gastric ulcers

The prevalence and severity of gastric ulcers were investigated in a sample of 50 slaughter pigs from each of 16 commercial farms in the uk. The mean prevalence of ulcers was 19.1 per cent and the mean (se) severity score on the 16 farms was 2.2 (0.15) on a scale from 0 (normal) to 6 (severe). Multivariate regression analysis showed that the type of lying surface provided for the pigs during the finishing phase was the most important factor associated with the occurrence of gastric ulcers in the farms studied. Finisher pigs housed on slatted floors had a significantly higher mean ulcer severity score (P<0.001) than pigs housed on solid concrete floors, which had a significantly higher score (P<0.01) than pigs housed on straw bedding. Feeding a pelleted finisher ration was also associated with significant increase in ulcer severity (P<0.01) compared with feeding an unpelleted ration, but was of less importance than the type of floor. The detrimental influence of feeding pellets was ameliorated by the provision of straw bedding.     

Prevalence of foot lesions in Danish Holstein cows

In a cross-sectional study of 6240 Danish Holstein cows in 55 herds using loose-housing systems, sole haemorrhages and heel horn erosions occurred frequently in almost all the herds. Digital dermatitis occurred in 47 of the 55 herds (85 per cent). Spearman correlation coefficients revealed relationships between lameness and sole ulcer (0.36), between heel horn erosion and sole haemorrhage (0.39), between heel horn erosion and interdigital dermatitis (0.29) and between sole ulcer and double sole (0.26). The prevalence of heel horn erosion, sole haemorrhage, interdigital dermatitis and digital dermatitis appeared to be most affected by herd-level factors. The associations between individual foot trimmers and all the foot lesions were statistically significant. The risk of interdigital dermatitis increased with decreasing amounts of bedding. Cows housed throughout the year had a marginally higher risk of sole haemorrhage.     

Influence of floor surface and access to pasture on claw health in dairy cows kept in cubicle housing systems

In this study, the effects on the claw health of dairy cows of three different floor types and access to pasture were investigated on 35 farms. The farms were fitted with a given floor type in the indoor walking area of a cubicle housing system: a solid rubber, mastic asphalt or slatted concrete floor. Because we chose farms on which the given floor type was in good condition, the data presented show what can be achieved on these types of floors under ideal circumstances. Cows on half of the farms per floor type had access to pasture during the grazing period. Each farm was visited three times at approx. 6-month intervals at the end of the winter indoor-housing period and at the end of the summer period, i.e. after the period with access to pasture on half of the farms. During each visit, the claw health of the same 10 cows per farm was assessed on the occasion of routine claw trimming. The proportion of cows with haemorrhages increased from mastic asphalt to rubber and slatted concrete floors. A lower proportion of cows kept on mastic asphalt was affected by white-line fissures and needed intermittent claw-trimming, an indicator for lameness. Cows housed in cubicle systems with slatted concrete floors were at the lowest risk of having heel-horn erosions. Access to pasture was associated with a lower incidence of slight white-line fissures and dermatitis digitalis. A higher proportion of cows with sole haemorrhages and sole ulcers were found on all floor types at the end of the summer period than at the end of the winter indoor-housing period. Floor type did not influence the presence of sole ulcers and deep white-line fissures. In conclusion, the effect of floor type on claw health was slight, and none of the investigated floor types was clearly superior to the others. Access to pasture was not effective in reducing the presence of most types of claw lesions associated with the floor type used in the indoor walking area.     

Incidence of lameness and abrasions in piglets in identical farrowing pens with four different types of floor

Background

Lameness in piglets is a major animal welfare issue. Floor abrasiveness is a common cause of superficial injury in piglets in farrowing pens. The abrasion achieved may act as a gate for infections, which in turn may induce development of infectious arthritis. In this study, the influence of improvements of the floor quality and of increased ratios of straw in identical farrowing pens was measured.

Methods

The study was carried out at a herd with four identical farrowing units with solid concrete floor bedded with 1 kg chopped straw per sow and 1 hg per piglet and day. Nothing was changed in the management of the four identical farrowing units, but four experimental groups were created: Group I – control, Group II – the amount of bedding was doubled. The surface of the floor was repaired in two units, Group III – Piglet Floor^®, Flowcrete Sweden AB, Perstorp, Sweden and Group IV – Thorocrete SL^®, Växa Halland, Sweden. Three farrowing batches were studies in each unit. In total, 93 litters (1,073 piglets) were examined for foot and skin lesions until the age of 3 weeks. The occurrence of lameness was registered until weaning at an average age of 4.5 weeks. Twenty seven lame piglets were culled instead of medicinally treated and subjected to necropsy including histopathological and microbiological examinations. Isolates of streptococci, staphylococci and E. coli were tested with respect to antimicrobial resistance.

Results

Piglet born on the repaired floors had the lowest prevalences of abrasions at carpus. Also the doubled straw ration decreased the abrasions. Skin lesions at carpus decreased significantly in magnitude in all four systems from day 10. At day 3, the sole bruising scores of the control unit were greater than the other three units (p < 0.001). At day 10 and 17, sole bruising was less common in the units with repaired floors than in the control group and the group with doubled straw ration. In total 41 piglets were diagnosed as lame, corresponding to 3.8% of all live-born piglets (n = 1,073). Around 85% of these diagnoses took place during the first 3 weeks of life and the risk incidence of lameness decreased from 1.5% during the first week of life to 0.5% during the fourth week. The incidence of lameness was highest in the control unit and lowest in the units with repaired floors. Twenty lame piglets were confirmed to have bacterial growth in the joint. The causative agents were Streptococcus dysgalactiae subsp. equisimilis (60%), Staphylococcus hyicus subsp. hyicus (35%) and Escherichia coli (5%). These isolates were sensitive to all antibiotics included in the antimicrobial panels.

Conclusion

The results suggest that proper maintenance of the floor can prevent the degree of roughness and abrasiveness of the floors, which in turn can contribute significantly to prevention of abrasions, sole bruising and lameness in piglets. Maintaining the surface of concrete floors with two different commercially available solutions both decreased the incidence of abrasions and sole bruisings and thereby also of arthritis significantly. Also doubling the amount of chopped straw turned out to prevent development of skin lesions and sole bruisings to some extent, and subsequently also the incidence of arthritis.     

The prevalence and risk factors associated with forelimb skin abrasions and sole bruising in preweaning piglets

The presence of skin abrasions and sole bruising in 264 preweaning piglets (1–30 days old) from 13 breeding units in south west England was investigated in 1995. The mean prevalence of forelimb skin abrasions among the pigs on the study farms was 36% (range 0–59%) and sole bruising was 50% (range 0–95%). Skin abrasions were located on three aspects on the front limbs: the carpus, the metacarpus and the digit. Lesions occurred early in a piglet's life; the modal ages for sole bruising was 4 days and for skin abrasions were 5 and 10 days. The presence of skin abrasions on the front limbs was significantly associated with the presence of sole bruising on the front feet. Logistic regression indicated that part-concrete, part-round-mesh (OR 56.4) and part-concrete, part-metal-rods floors (OR 15.9) and exposed aggregate (OR 4.6) were associated with an increased odds of sole bruising while the presence of sparse straw (OR 0.12) or deep straw (OR 0.12) in the pen was associated with lower odds of sole bruising. The same floor type (part-concrete, part-round-mesh) was associated with increased odds of forelimb skin abrasions (OR 2.2). A worn floor surface where the solid adjoined the perforated area (OR 4.6) and the presence of sparse shavings (OR 1.7) were also associated with an increased risk of skin abrasions.     

Fattening bull raising--alternative housing on slatted floors

Rubber topped slatted floor gives more lying comfort to intensive fed fattening bulls, reduces risks of integument lesions as well as increases their locomotion comfort. On the other side there are more fissured alterations and defects in the sole and heel horn due to lack of sufficient wear away which often made the bearing surface to be overgrown. Overgrown claws are also seen on solid slatted floors, but these horn parts were normally grated down in short time that frequently goes along with abrasions of the claw peak and the wall horn as well. The current experiences of our study show favour to the use of a floor that combines hard and soft qualities. Weak claw performance and health has a link to a bad state of cleanness of the pens and the animals as well and must be assessed with regard to permanent wetness on the grounds. Animals out of greater pens are less dirty because the solid floor becomes sooner dry than in cases with higher crowding degrees of animals. More space per animal and higher comfort gives chance for higher daily weight gain. The recordings and evaluations of this project are still in progress.     

Supplemental biotin for swine. I. Influence on feedlot performance, plasma biotin and toe lesions in developing gilts

Three trials, utilizing a total of 240 crossbred gilts, were conducted to study the influence of 0 (NB) or 220 (SB) microgram supplemental biotin/kg of diet on feedlot performance, plasma biotin and development of toe lesions in developing gilts. Corn-soybean meal diets were fed from weaning to 92 kg body weight. Gilts were housed on expanded-metal floors to 50 kg body weight and on partially slatted concrete floors until completion of the trials. Feedlot performance, hair and structural soundness scores were not different (P greater than .10) between NB and SB gilts. Plasma biotin (PB) levels were elevated (P less than .01) when supplemental biotin was included in the diet. Gilts consuming SB diets had fewer (P less than .01) toe lesions/gilt and lower (P less than .01) toe lesion severity scores/gilt compared with gilts fed NB diets. Heel-horn erosion and heel cracks were the most frequent toe lesions observed. Fewer gilts (P less than .01) developed side-wall toe cracks when fed SB diets. Supplemental biotin reduced the frequency of individual toes containing heel-horn erosion (P less than .10), heel cracks (P less than .05) and side-wall toe cracks (P less than .05) with the severity of these lesions not affected (P greater than .10) by supplemental biotin. These results suggest that biotin levels in corn-soybean meal diets are adequate for feedlot performance, and that supplemental biotin can improve hoof integrity, but will not prevent toe lesions.     

Incidence of foot and skin lesions in nursing piglets and their association with behavioural activities.

A total of 356 piglets from one farm were examined for foot and skin lesions every day for the first 10 days after birth, and then on alternate days until they were weaned. Over a period of 24 days 100 per cent of the piglets examined developed sole bruising, and 49.1 per cent developed sole erosions. Sole bruising lasted for an average of 13 days and sole erosions for seven days. At the beginning of the study, a higher proportion of piglets had mild sole bruising; from three to nine days of age piglets had moderate sole bruising but from days 10 to 20 mild bruising was again observed more frequently. Skin lesions were observed on the carpal aspect of the front limbs; 60.9 per cent of the piglets developed skin abrasions, 70.7 per cent developed healed wounds and 90 per cent developed hairless patches. The skin abrasions lasted on average for six days, the healed wounds for five days and the hairless patches for eight days. Piglets which developed sole bruising and/or sole erosions on the first day of life were significantly heavier than those which did not. Continuous observations of the piglets' behaviour during the first six days of life showed that sole bruising increased as the total time spent in the creep area or lying near the sow on the solid floor increased. During the first three days of life skin abrasions increased as the total time spent lying in the creep area increased. There was a positive correlation between the total time piglets spent suckling and the incidence of carpal skin abrasions between four and six days of age. Piglets with sole bruising, sole erosions or carpal skin abrasions spent less time during the day in 'other' activities such as walking, playing or fighting.     

Effect of biotin supplementation on hoof health and ceramide composition in dairy cattle

The effect of biotin supplementation on various foot lesions and hoof ceramide composition of toe (wall) and sole portions of hooves was studied in crossbred dairy cattle. Biotin supplementation was done for five months in 14 cattle at a farm and the other 14 animals kept as control. A significant decline was observed in heel erosions and sole avulsions along with total disappearance of white line fissures and double soles in the biotin supplemented cattle resulting in decrease in the overall disease score. Thin layer chromatographs of the hoof lipids revealed 11 types of ceramides in sole lipids and 6 types of ceramides in toe (wall) lipids. The ceramides were typed and identified according to their Rf values. A qualitative increase in the density of thin layer chromatographs of sole lipids was observed in biotin supplemented cattle whereas a non-significant difference in density of thin layer chromatographs of toe lipids was observed after supplementation of biotin.     

A pilot study on the improvement of the lying area of finishing pigs by a soft lying mat

In this pilot study, we tested whether a soft mat (foam covered with a heat-sealed thermoplastic) reduces alterations and injuries at the skin and the leg joints.The soft mat in the lying area of partly slatted pens was compared to a lying area consisting of either bare or slightly littered (100 g straw per pig and day) concrete flooring. In this study we focused on skin lesions on the legs of finishing pigs as indicators of impaired welfare. Pigs were kept in 19 groups of 8-10 individuals and were examined for skin lesions around the carpal and tarsal joints either at a weight of <35 kg, or at close to 100 kg. The likelihood of hairless patches and wounds at the tarsal joints was significantly lower in pens with the soft lying mat than in pens with a bare concrete floor. Pens with a littered concrete floor did not differ compared to pens with a bare concrete floor. The soft lying mat thus improved floor quality in the lying area in terms of preventing skin lesions compared to bare and slightly littered concrete flooring. Such soft lying mats have thus the potential to improve lying comfort and welfare of finishing pigs.     

Slatted versus Solid Floors in the Dung Area of Farrowing Pens: Effects on Hygiene and Pig Performance,Birth to Weaning

The effect of slatted versus solid floors in the dung area of farrowing pens on the health and production of pigs from birth to weaning was studied. In half of the farrowing pens, evenly distributed within a unit, the plastic slats were glued together to form a solid surface and only urine drainage was allowed. A total of 201 litters were studied. Pen hygiene in the slatted floor pens in general was significantly better in all trials, and there was a demonstrably higher amount of bacteria in the solid floor pens. Total mortality from birth to weaning was significantly higher for the solid floor treatment group, primarily due to more traumatic injuries and more infection losses. No significant treatment effects on morbidity and daily weight gain were observed. In conclusion, even in a closed herd with batch farrowing, good general hygiene level and good herd immunity, a small change such as solid flooring in the dung area can negatively affect pig health and production before weaning.     

Non-infectious factors associated with macroscopic and microscopic lung lesions in slaughter pigs from farrow-to-finish herds

A cross-sectional epidemiological study was conducted in 150 randomly selected farrow-to-finish herds to investigate which non-infectious factors might act as risk indicators for the prevalence and severity of macroscopic and microscopic lung lesions in slaughter pigs. Data were collected during herd visits through inspections of the pigs and through interviews with the farmers. Macroscopic lung lesions of pneumonia and pleuritis were recorded at slaughter from 25 pigs per herd, and microscopic lung lesions of lymphohistiocytic infiltration were recorded from 10 pigs per herd. The median herd level prevalences were 24 per cent for pneumonia, 16 per cent for pleuritis and 60 per cent for lymphohistiocytic infiltration. Pneumonia lesions were negatively associated with pleuritis lesions and positively associated with lymphohistiocytic infiltration. Pleuritis lesions were negatively associated with lymphohistiocytic infiltration. The prevalence and the severity of pneumonia lesions were increased by a high frequency of purchasing gilts and by a slaughter date in January to February. The presence of a growing unit also increased the severity of pneumonia. The prevalence and the severity of pleuritis lesions were higher when there were more pig herds in the municipality, and when there were poor biosecurity measures, and their prevalence was increased by a slaughter date in January to February, and their severity by a slaughter date in March to April. An increase in the airspace stocking density in the finishing unit also increased the prevalence of pleuritis. The prevalence and the severity of lymphohistiocytic infiltration in the lung tissue were higher in herds purchasing gilts. Pigs raised in pens with slatted floors were also at higher risk of more severe lesions of lymphohistiocytic infiltration.     

The Effect of Claw Lesions and Claw Infections on Lameness in Loose Housing of Pregnant Sows

During a 12-month period lameness, claw lesions and claw infections were studied in 15 herds with loose housing of pregnant sows on partly slatted concrete floors. Of these herds, 12 herds had concrete slats and 3 herds had plastic slats. The mean prevalence proportion of lame sows in the herds was 13.1%. The risk of lameness increased with increasing claw lesion score and with the presence of claw infections. In the herds with concrete slats, the relative risk of lame sows was 2.4 times higher than in the herds with plastic slats. In the herds with poor floor hygiene, the relative risk of lameness was 2.8 times higher than in the herds with dry and clean floors. The mean prevalence proportion of sows with claw infections at the 3 separate examinations in the 15 herds was 3.8%. Claw infections were more prevalent in herds with dirty floors and in herds with little space per animal (<2m²). In the herds with concrete slats, the relative risk of claw infections was 2 times higher than in the herds with plastic slats.     

The effects of plastic slatted floor or straw bedding on performance, liver weight and liver copper concentrations in intensively reared lambs

One hundred and eight Texel sired lambs were weaned at 37 days old and allocated three days later to one of two treatments, using two pens per treatment, in order to evaluate lamb hepatic copper (Cu) values. In Treatment 1 (T1) the lambs were confined to pens having recycled plastic slatted flooring, while in Treatment 2 (T2) the lambs were confined to pens having straw bedded floors, with fresh straw added on alternate days. The lambs had ad libitum access to a coarse lamb concentrate. The crude protein (g/kg DM), crude fibre (g/kg DM), total zinc (mg/kg) and background levels of copper (Cu) (mg/kg) and molybdenum (Mo) (mg/kg) of the diet were 17.2, 10.9, 152, 9.7 and 0.92, respectively. The lambs were slaughtered when they reached about 39 kg live weight. Following slaughter, the liver was removed and weighed and the caudal lobe frozen for subsequent Cu analysis. The livers of lambs on the plastic floor treatment had higher liver weights (843 vs. 804 g, S.E.M. 11.0; P < 0.05) and higher hepatic copper (396 vs. 315 mg/kg DM, S.E.M. 18.2; P < 0.05) than those from lambs that were bedded with straw. The Cu accumulation per kg of liver DM per week was estimated to be 8.4 and 13.7 mg for lambs on the straw bedding and plastic slated treatments, respectively. It is concluded that when lambs are housed on plastic slatted flooring, relative to straw bedding, there is a higher accumulation of hepatic copper levels likely to result in a greater risk of Cu toxicity when lambs are reared on all concentrate diets.     

Supplemental biotin for swine. III. Influence of supplementation to corn- and wheat-based diets on the incidence and severity of toe lesions, hair and skin characteristics and structural soundness of sows housed in confinement during four parities

The influence of supplementing 0 (NB) or 440 (SB) micrograms biotin/kg to corn- or wheat-based diets on toe lesions, hair characteristics and structural soundness in 116 crossbred female swine was studied from selection (100 kg) until completion of four parities. Gilts that had been previously fed corn-soybean meal diets with 0 or 220 micrograms supplemental biotin/kg diet during growth and development, remained on either the biotin unsupplemented or supplemented diet. Females were housed in buildings containing partially slatted and solid concrete floors. Toe, hair and soundness evaluations were made at a mean age of 240, 521, 732, 916 and 1,090 d. Type of grain fed did not influence (P greater than .10) any response criteria evaluated. Six types of toe lesions were observed across all dietary treatments and varied in severity from minor to very severe. The percentage of females with heel cracks, heel-horn junction cracks and side-wall horn cracks was reduced (P less than .01) when females were fed SB diets. Females fed SB diets had fewer (P less than .001) total lesions, heel cracks, heel-horn junction cracks, side-wall horn cracks and white-line horn cracks (P less than .03) compared with females consuming NB diets. In general, biotin supplementation was more effective in reducing the number and percentage of toe lesions in multiparous sows compared with gilts and primiparous sows. Biotin supplementation increased (P less than .001) the number of hairs/cm2 skin and improved (P less than .001) hair scores. Histological evaluation and soundness scores were not affected (P greater than .10) by level of biotin fed.(ABSTRACT TRUNCATED AT 250 WORDS)