Effect of pH on the thermal stability of potent roasty odorants, 3-mercapto-3-methylbutyl esters, in coffee drink

The effect of pH on the thermal stability of potent roasty odorants, 3-mercapto-3-methylbutyl esters, in coffee drinks was investigated. The concentration of 3-mercapto-3-methylbutyl formate in the coffee drink was drastically decreased during the heat processing. However, the residual ratio of this compound in the coffee drink adjusted to pH 5.0 was higher than that of pH 6.5. On the other hand, the residual ratios of 3-mercapto-3-methylbutyl acetate showed high values in the coffee drinks adjusted to both pHs. In the pH range of 3-7, the residual ratios of 3-mercapto-3-methylbutyl formate in aqueous model solutions varied depending on the pH value. It had a thermal stability maximum at pH 4.0, while 3-mercapto-3-methylbutyl acetate showed stability during heat processing over all the pH values tested. In addition, the residual ratios of the formate and acetate esters, which were composed of various alcohol derivatives, showed the same tendency as that of the 3-mercapto-3-methylbutyl esters. These results suggested that the low thermal stability and pH dependence of 3-mercapto-3-methylbutyl formate are based on the structure of the formate ester.     

Influence of manufacturing conditions and crop season on the formation of 4-mercapto-4-methyl-2-pentanone in Japanese green tea (sen-cha)

4-Mercapto-4-methyl-2-pentanone is one of the most strongly contributing odorants in the volatile fraction of a Japanese green tea (sen-cha) infusion, and on the basis of the results of an aroma extract dilution analysis, the contribution of this compound to the flavor of the sen-cha infusion varied according to the degree of heating of the tea leaves during the roasting process. The concentration of this odorant in the sen-cha infusion, as with other roasty odorants, increased with the increasing roasting temperature. However, the slope of the increase curve differed with the odor compound, and even if roasting was done at a low temperature, at which the other roasty odorants hardly increased, 4-mercapto-4-methyl-2-pentanone still increased and reached a maximum at 112 degrees C. On the other hand, the amount of 4-mercapto-4-methyl-2-pentanone in sen-cha was a maximum in the first crop, then decreasing in the order of the second and third crops. These results suggested that the amount of 4-mercapto-4-methyl-2-pentanone was closely involved with the quality of sen-cha and that the concentration was dependent on the roasting conditions for the green tea leaves, which might be accompanied by an enzymatic reaction.     

Chemical interactions between odor-active thiols and melanoidins involved in the aroma staling of coffee beverages.

Comparative aroma dilution analyses of the headspaces of aqueous solutions containing either the total volatiles isolated from a fresh coffee brew, or these volatiles remixed with the melanoidins isolated from coffee brew, revealed a drastic decrease in the concentrations of the odorous thiols 2-furfurylthiol, 3-methyl-2-butenthiol, 3-mercapto-3-methylbutyl formate, 2-methyl-3-furanthiol, and methanethiol when melanoidins were present. Among these thiols, 2-furfurylthiol was affected the most: e.g., its concentration decreased by a factor of 16 upon addition of melanoidins. This was accompanied by a decrease in the overall roasty-sulfury aroma. Quantitations performed by means of stable isotope dilution assays confirmed the rapid loss of all thiols with increasing time while keeping the coffee brew warm in a thermos flask. Using [2H2]-2-furfurylthiol as an example, [2H]-NMR and LC/MS spectroscopy gave strong evidence that thiols are covalently bound to the coffee melanoidins via Maillard-derived pyrazinium compounds formed as oxidation products of 1,4-bis-(5-amino-5-carboxy-1-pentyl)pyrazinium radical cations (CROSSPY). Using synthetic 1,4-diethyl diquaternary pyrazinium ions and 2-furfurylthiol, it was shown that 2-(2-furyl)methylthio-1,4-dihydro-pyrazines, bis[2-(2-furyl)methylthio]-1,4-dihydro-pyrazines, and 2-(2-furyl)methylthio-hydroxy-1,4-dihydro-pyrazines were formed as the primary reaction products. Similar results were obtained for models in which either 1,4-diethyl diquaternary pyrazinium ions were substituted by Nalpha-acetyl-L-lysine/glycolaldehyde, or the 2-furfurylthiol by 2-methyl-3-furanthiol and 3-mercapto-3-methylbutyl formate. On the basis of these results it can be concluded that the CROSSPY-derived pyrazinium intermediates are involved in the rapid covalent binding of odorous thiols to melanoidins, and, consequently, are responsible for the decrease in the sulfury-roasty odor quality observed shortly after preparation of the coffee brew.     

Interactions between volatile and nonvolatile coffee components. 1. Screening of nonvolatile components

This study is the first of two publications that investigate the phenomena of coffee nonvolatiles interacting with coffee volatile compounds. The purpose was to identify which coffee nonvolatile(s) are responsible for the interactions observed between nonvolatile coffee brew constituents and thiols, sulfides, pyrroles, and diketones. The overall interaction of these compounds with coffee brews prepared with green coffee beans roasted at three different roasting levels (light, medium, and dark), purified nonvolatiles, and medium roasted coffee brew fractions (1% solids after 1 or 24 h) was measured using a headspace solid-phase microextraction technique. The dark roasted coffee brew was slightly more reactive toward the selected compounds than the light roasted coffee brew. Selected pure coffee constituents, such as caffeine, trigonelline, arabinogalactans, chlorogenic acid, and caffeic acid, showed few interactions with the coffee volatiles. Upon fractionation of medium roasted coffee brew by solid-phase extraction, dialysis, size exclusion chromatography, or anion exchange chromatography, characterization of each fraction, evaluation of the interactions with the aromas, and correlation between the chemical composition of the fractions and the magnitude of the interactions, the following general conclusions were drawn. (1) Low molecular weight and positively charged melanoidins present significant interactions. (2) Strong correlations were shown between the melanoidin and protein/peptide content, on one hand, and the extent of interactions, on the other hand (R = 0.83-0.98, depending on the volatile compound). (3) Chlorogenic acids and carbohydrates play a secondary role, because only weak correlations with the interactions were found in complex matrixes.     

Investigation of the change in the flavor of a coffee drink during heat processing

Heat processing is responsible for the change in the flavor of a coffee drink. In this study, the application of gas chromatography-olfactometry of headspace samples (GCO-H) using the vapor fraction before and after heat processing of the coffee samples resulted in the detection of 12 odor-active peaks for which the flavor dilution (FD) factors changed. Eight potent odorants were identified from these peaks by gas chromatography-mass spectrometry (GC-MS). Among these components, methanethiol (putrid), acetic acid (sour), 3-methylbutanoic acid (sour), 2-furfuryl methyl disulfide (meaty), and 4-hydroxy-2,5-dimethyl-3(2H)-furanone (caramel-like) increased after heating of the coffee sample, whereas 2-furfurylthiol (roasty), methional (potato-like), and 3-mercapto-3-methylbutyl formate (roasty) decreased compared with the coffee sample before heat treatment. In addition, extensive studies have been carried out on the pH effects on the change in the concentration of 2-furfurylthiol during heat processing and in the pH range of 5-7; it was found that the concentration of this compound in the model solutions had significantly changed.     

Model studies on the influence of coffee melanoidins on flavor volatiles of coffee beverages

Addition of the total melanoidin fraction isolated by water extraction from medium-roasted coffee powder to a model solution containing a set of 25 aroma compounds mimicking the aroma of a coffee brew reduced, in particular, the intensity of the roasty, sulfury aroma quality. Model studies performed by static headspace analysis revealed that especially three well-known coffee odorants, that is, 2-furfurylthiol (FFT), 3-methyl-2-butene-1-thiol, and 3-mercapto-3-methylbutyl formate, were significantly reduced in the headspace above an aqueous model solution when melanoidins were added. In particular, the low molecular weight melanoidins (1500-3000 Da) led to the most significant decrease in FFT. In contrast, for example, aldehydes remained unaffected by melanoidin addition.     

Evolution of green coffee protein profiles with maturation and relationship to coffee cup quality

Coffee flavor is the product of a complex chain of chemical transformations. The green bean has only a faint odor that is not at all reminiscent of coffee aroma. It contains, however, all of the necessary precursors to generate the unmistakable coffee flavor during roasting. The levels and biochemical status of these precursors may vary in relation to genetic traits, environmental factors, maturation level, postharvest treatment, and storage. To improve our understanding of coffee flavor generation, the sensory and biochemical impact of maturation was assessed. Maturation clearly favored the development of high-quality flavor in the coffee brew. A specific subclass of green coffee beans, however, generated high-quality coffee flavor irrespective of maturation. Biochemical aspects were examined using a dynamic system: immature and mature green coffee suspensions were incubated under air or argon. On the analytical side, a specific pool of flavor precursors was monitored: chlorogenic acids, green coffee proteins, and free amino acids. A link between maturation, the redox behavior of green coffee suspensions, and their sensory scores was identified. Compared to ripe beans, unripe beans were found to be more sensitive to oxidation of chlorogenic acids. Aerobic incubation also triggered the fragmentation or digestion of the 11S seed storage protein and the release of free amino acids.     

Screening of raw coffee for thiol binding site precursors using "in bean" model roasting experiments

The purpose of the following study was to investigate the influence of coffee roasting on the thiol-binding activity of coffee beverages, and to investigate the potential of various green bean compounds as precursors of thiol-binding sites by using promising "in bean" model roast experiments. Headspace gas chromatographic analysis on coffee brews incubated in the presence of the roasty-sulfury smelling 2-furfurylthiol for 20 min at 30 degrees C in septum-closed vessels revealed that the amounts of "free" thiol decreased drastically with increasing the roasting degree of the beans used for preparation of the brews. A half-maximal binding capacity (BC(50)) of 183 mg of 2-furfurylthiol per liter of standard coffee beverage was determined for a roasted coffee (CTN value of 67), thus demonstrating that enormous amounts of the odor-active thiol are "bound" by the coffee. Furthermore, biomimetic "in bean" precursor experiments have been performed in order to elucidate the precursor for the thiol-binding sites in the raw coffee bean. These experiments opened the possibility of studying coffee model reactions under quasi-natural roasting conditions and undoubtedly identified chlorogenic acids as well as thermal degradation products caffeic acid and quinic acid as important precursors for low-molecular-weight thiol-binding sites. In particular, when roasted in the presence of transition metal ions, chlorogenic acids and even more caffeic acid showed thiol-binding activity which was comparable to the activity measured for the authentic coffee brew.     

Alkylpyridiniums. 2. Isolation and quantification in roasted and ground coffees

Recent model studies on trigonelline decomposition have identified nonvolatile alkylpyridiniums as major reaction products under certain physicochemical conditions. The quaternary base 1-methylpyridinium was isolated from roasted and ground coffee and purified by ion exchange and thin-layer chromatography. The compound was characterized by nuclear magnetic resonance spectroscopy ((1)H, (13)C) and mass spectrometry techniques. A liquid chromatography-electrospray ionization tandem mass spectrometry method was developed to quantify the alkaloid in coffee by isotope dilution mass spectrometry. The formation of alkylpyridiniums is positively correlated to the roasting degree in arabica coffee, and highest levels of 1-methylpyridinium, reaching up to 0.25% on a per weight basis, were found in dark roasted coffee beans. Analyses of coffee extracts also showed the presence of dimethylpyridinium, at concentrations ranging from 5 to 25 mg/kg. This is the first report on the isolation and quantification of alkylpyridiniums in coffee. These compounds, described here in detail for the first time, may have an impact on the flavor/aroma profile of coffee directly (e.g., bitterness), or indirectly as precursors, and potentially open new avenues in the flavor/aroma modulation of coffee.     

On the role of (-)-2-methylisoborneol for the aroma of Robusta coffee

The role of 2-methylisoborneol (MIB) in coffee aroma is controversially discussed in the literature. MIB is known as an off-flavor compound in drinking water and food, but it has also been suggested as a key flavor component of Robusta coffee, discriminating Robusta from Arabica coffee. To check this hypothesis the role of MIB in coffee brews was studied. Two reference samples containing pure Arabica and Robusta coffee brews were compared with five samples of Arabica coffee brews containing increasing amounts of MIB. The sensory panel consisting of 12 assessors perceived a distinct difference in the Arabica coffee odor and flavor in the presence of 10-25 ng/kg MIB, which is close to its threshold value in water. The sensory impression was described as musty, mold-like, and earthy. The intensity increased with increasing concentration of MIB. The panelists agreed that there was no similarity with the Robusta reference sample. The Arabica coffee brew spiked with MIB was no longer palatable due to the odor and flavor defect formed.     

Effect of roasting conditions on the polycyclic aromatic hydrocarbon content in ground Arabica coffee and coffee brew

Roasting is a critical process in coffee production as it enables the development of flavor and aroma. At the same time, roasting may lead to the formation of nondesirable compounds, such as polycyclic aromatic hydrocarbons (PAHs). In this study, Arabica green coffee beans from Cuba were roasted under controlled conditions to monitor PAH formation during the roasting process. Roasting was performed in a pilot spouted bed roaster, with the inlet air temperature varying from 180 to 260 degrees C, using both dark (20 min) and light (5 min) roasting conditions. Several PAHs were determined in both roasted coffee samples and green coffee samples. Also, coffee brews, obtained using an electric coffee maker, were analyzed for final estimation of PAH transfer coefficients to the infusion. Formation of phenanthrene, anthracene, and benzo[a]anthracene in coffee beans was observed at temperatures above 220 degrees C, whereas formation of pyrene and chrysene required 260 degrees C. Low levels of benzo[g,h,i]perylene were also noted for dark roasting under 260 degrees C, with simultaneous partial degradation of three-cycle PAHs, suggesting that transformation of low molecular PAHs to high molecular PAHs occurs as the roasting degree is increased. The PAH transfer to the infusion was quite moderate (<35%), with a slightly lower extractability for dark-roasted coffee as compared to light-roasted coffee.     

3-Mercapto-2-methylpentan-1-ol, a new powerful aroma compound

3-Mercapto-2-methylpentan-1-ol was first detected in a complex thermally processed flavor and finally isolated from raw onions. The chemical structure of this new compound was identified by MS and (1)H NMR measurement and synthesis of the proposed structure. Sensory evaluation at different concentrations indicated that the flavor quality is strongly dependent on concentration. At low concentration (0.5 ppb) a pleasant meat broth, sweaty, onion, and leek-like odor can be perceived. On the basis of some isolation experiments and volatiles occurring in raw onions, a formation pathway is proposed. As one intermediate 3-mercapto-2-methylpentanal, another new strong flavor compound, was suggested. The presence of this compound in raw onions was confirmed by synthesis and comparison of MS and chromatographic data.     

Headspace GC and sensory analysis characterization of the influence of different milk additives on the flavor release of coffee beverages

Previous investigations of coffee flavor have been confined to the analysis of the aroma substances. These investigations showed that about 30 volatile compounds were substantially responsible for the coffee flavor. The aim of this study was to investigate the influence of different milk additives and one coffee whitener on the release of flavor impact compounds from coffee beverages. For the investigation of these effects an external static headspace technique was developed. With this technique the most potent odorants of the coffee beverage were determined. Analyses were performed by gas chromatography/olfactometry, flame ionization detection, and mass spectrometric detection. In addition, sensory studies of the odor profiles were performed. Milk and vegetable products as additives for coffee beverages affected the release of aroma substances in the brew through their lipid, protein, and carbohydrate components. All beverages with an additive showed reduced, but typical, odor profiles for each additive.     

Changes in headspace volatile concentrations of coffee brews caused by the roasting process and the brewing procedure

Headspace-solid-phase microextraction technique (HS-SPME) coupled with gas chromatography-mass spectrometry (GC-MS) and gas chromatography-olfactometry (GC-O) were used to characterize the aroma compounds of coffee brews from commercial conventional and torrefacto roasted coffee prepared by filter coffeemaker and espresso machine. A total of 47 volatile compounds were identified and quantified. Principal component analysis (PCA) was applied to differentiate coffee brew samples by volatile compounds. Conventional and torrefacto roasted coffee brews were separated successfully by principal component 1 (68.5% of variance), and filter and espresso ones were separated by principal component 2 (19.5% of variance). By GC olfactometry, a total of 34 aroma compounds have been perceived at least in half of the coffee extracts and among them 28 were identified, among which octanal was identified for the first time as a contributor to coffee brew aroma.     

烹饪方式对安岳坛子肉风味的影响

为了解四川安岳坛子肉的特征风味及烹饪方式对其特征风味的影响,采用电子鼻、电子舌及气质联用仪研究不同烹饪方式(蒸制和烤制)对坛子肉风味物质组成及其含量的影响。结果表明,烤制坛子肉与生制坛子肉、蒸制坛子肉与生制坛子肉、烤制坛子肉与蒸制坛子肉的判别因子分析聚类差异极显著(P <0.01)。2种烹饪方式得到的熟制坛子肉的风味化合物主要包括醇类、醛类、酯类、酮类、醚类、含硫化合物和杂环化合物七大类。烤制形成的风味物质种类高达101种,常温蒸制61种,此外,异戊醇、乙醛、丁酸丁酯、乙酸乙酯、正己酸乙酯、吡啶、呋喃和丙酮构成蒸制坛子肉的特征风味,己醛、丁酸丁酯、正己酸乙酯和4-羟基-4-甲基-2-戊酮构成烤制坛子肉的特征风味。本研究结果为坛子肉即食食品的精深加工提供了理论依据。     

Chlorogenic acids and lactones in regular and water-decaffeinated arabica coffees

The market for decaffeinated coffees has been increasingly expanding over the years. Caffeine extraction may result in losses of other compounds such as chlorogenic acids (CGA) and, consequently, their 1,5-gamma-quinolactones (CGL) in roasted coffee. These phenolic compounds are important for flavor formation as well as the health effects of coffee; therefore, losses due to decaffeination need to be investigated. The present study evaluates the impact of decaffeination processing on CGA and CGL levels of green and roasted arabica coffees. Decaffeination produced a 16% average increase in the levels of total CGA in green coffee (dry matter), along with a 237% increase in CGL direct precursors. Different degrees of roasting showed average increments of 5.5-18% in CGL levels of decaffeinated coffee, compared to regular, a change more consistent with observed levels of total CGA than with those of CGL direct precursors in green samples. On the other hand, CGA levels in roasted coffee were 3-9% lower in decaffeinated coffee compared to regular coffee. Although differences in CGA and CGL contents of regular and decaffeinated roasted coffees appear to be relatively small, they may be enough to affect flavor characteristics as well as the biopharmacological properties of the final beverage, suggesting the need for further study.     

In vitro antioxidant and ex vivo protective activities of green and roasted coffee

The antioxidant properties of green and roasted coffee, in relation to species (Coffea arabica and Coffea robusta) and degree of roasting (light, medium, dark), were investigated. These properties were evaluated by determining the reducing substances (RS) of coffee and its antioxidant activity (AA) in vitro (model system beta-carotene-linoleic acid) and ex vivo as protective activity (PA) against rat liver cell microsome lipid peroxidation measured as TBA-reacting substances. RS of C. robustasamples were found to be significantly higher when compared to those of C. arabica samples (p < 0.001). AA for green coffee samples were slightly higher than for the corresponding roasted samples while PA was significantly lower in green coffee compared to that of all roasted samples (p < 0.001). Extraction with three different organic solvents (ethyl acetate, ethyl ether, and dichloromethane) showed that the most protective compounds are extracted from acidified dark roasted coffee solutions with ethyl acetate. The analysis of acidic extract by gel filtration chromatography (GFC) gave five fractions. Higher molecular mass fractions were found to possess antioxidant activity while the lower molecular mass fractions showed protective activity. The small amounts of these acidic, low molecular mass protective fractions isolated indicate that they contain very strong protective agents.     

Assessment of the aroma impact of major odor-active thiols in pan-roasted white sesame seeds by calculation of odor activity values

Eleven odor-active thiols, namely, 2-methyl-1-propene-1-thiol, (Z)-3-methyl-1-butene-1-thiol, (E)-3-methyl-1-butene-1-thiol, (Z)-2-methyl-1-butene-1-thiol, (E)-2-methyl-1-butene-1-thiol, 2-methyl-3-furanthiol, 3-mercapto-2-pentanone, 2-mercapto-3-pentanone, 4-mercapto-3-hexanone, 3-mercapto-3-methylbutyl formate, and 2-methyl-3-thiophenethiol, recently identified in an extract prepared from white sesame seeds, were quantitated in sesame using stable isotope dilution analyses. For that purpose, the following deuterium-labeled compounds were synthesized and used as internal standards in the quantitation assays: [2H6]-2-methyl-1-propene-1-thiol, [2H3]-(E)- and [2H3]-(Z)-2-methyl-1-butene-1-thiol, [2H3]-2-methyl-3-furanthiol, [2H2]-3-mercapto-2-pentanone, [2H3]-4-mercapto-3-hexanone, [2H6]-3-mercapto-3-methylbutyl formate, and [2H3]-2-methyl-3-thiophenethiol. On the basis of the results obtained, odor activity values (OAVs) were calculated as ratio of the concentration and odor threshold of the individual compounds in cooking oil. According to their high OAVs, particularly the 3-methyl-1-butene-1-thiols (OAV: 2400) and the 2-methyl-1-butene-1-thiols (OAV: 960) were identified as the most odor-active compounds in pan-roasted white sesame seeds. These compounds were therefore suggested to be mainly responsible for the characteristic but rather unstable sulfury aroma of freshly pan-roasted white sesame seeds.     

Roasting and aroma formation: effect of initial moisture content and steam treatment

Initial moisture of green coffee may vary as a function of green coffee processing and storage conditions. The impact of initial moisture and steam treatment on roasting behavior and aroma formation was investigated. Steam treated coffees as well as coffees with initial moisture content of 5.10, 10.04, and 14.70 g water per 100 g wb were roasted. Light and dark roasting trials were carried out using a fluidizing-bed roaster with a batch size of 100 g of green beans. Differences in roast coffee attributes, that is, color, density, and organic roast loss, and odorant concentrations were more marked in light roasted than in dark roasted coffees. The results of roasting steam treated coffee suggest that this step affects roasting behavior primarily by extracting some aroma precursor compounds.     

Isolation, identification, and quantification of roasted coffee antibacterial compounds

Coffee brew is a widely consumed beverage with multiple biological activities due both to naturally occurring components and to the hundreds of chemicals that are formed during the roasting process. Roasted coffee extract possesses antibacterial activity against a wide range of microorganisms, including Staphylococcus aureus and Streptococcus mutans, whereas green coffee extract exhibits no such activity. The naturally occurring coffee compounds, such as chlorogenic acids and caffeine, cannot therefore be responsible for the significant antibacterial activity exerted by coffee beverages against both bacteria. The very low minimum inhibitory concentration (MIC) found for standard glyoxal, methylglyoxal, and diacetyl compounds formed during the roasting process points to these alpha-dicarbonyl compounds as the main agents responsible for the antibacterial activity of brewed coffee against Sa. aureus and St. mutans. However, their low concentrations determined in the beverage account for only 50% of its antibacterial activity. The addition of caffeine, which has weak intrinsic antibacterial activity, to a mixture of alpha-dicarbonyl compounds at the concentrations found in coffee demonstrated that caffeine synergistically enhances the antibacterial activity of alpha-dicarbonyl compounds and that glyoxal, methylglyoxal, and diacetyl in the presence of caffeine account for the whole antibacterial activity of roasted coffee.