饲粮蛋白源对早期断奶仔猪生产性能的影响

试验选用64头25日龄杜×(大×长)三元杂交断奶仔猪,随机分为4组:A、B、C为试验组,分别用猪肠膜蛋白粉(DPS)、大豆浓缩蛋白(SPC)、喷雾干燥猪血浆蛋白粉(SDPP)部分取代基础饲粮的鱼粉;D为对照组,饲喂基础饲粮(玉米-豆粕-鱼粉)。试验从仔猪25日龄断奶开始,70日龄结束。结果显示:试验组日增重均显著高于对照组,其中B组比对照组高13.18%(P<0.05);A组、C组分别比对照组高11.53%(P<0.05)、4.43%(P<0.05);B组和A组日增重差异不显著(P>0.05),但均显著高于C组,分别高8.38%(P<0.05)、6.80%(P<0.05)。B组日采食量比对照组高4.82%(P<0.05),A组、C组与对照组相比,日采食量有提高的趋势,但差异不显著(P>0.05)。A组、B组与对照组相比,料肉比有降低的趋势(P>0.05)。由此可见,本试验条件下,大豆浓缩蛋白、猪肠膜蛋白粉、猪血浆蛋白粉对早期(25日龄)断奶仔猪的饲喂效果均优于鱼粉,且大豆浓缩蛋白、猪肠膜蛋白粉对仔猪日增重的改善幅度大于喷雾干燥猪血浆蛋白粉(P<0.05)。     

Effect of select menhaden fish meal in starter diets for pigs

Two trials were conducted to evaluate a select menhaden fish meal (SMFM) as a protein source in starter diets for 390, 3-wk-old weaned pigs. Initial weights averaged 4.8 and 5.5 kg in Trials 1 and 2, and trials were conducted for 5 and 4 wk, respectively. Diets in Trial 1 were formulated by substituting levels of 0, 4, 8, 12, 16 or 20% SMFM for soybean meal plus corn on a protein basis. The 20% fish meal diet contained no soybean meal; all diets contained between 19.8 and 20.2% CP, between 1.34 and 1.40% lysine and 25% dried whey. Replacement of soy protein with fish meal elicited a quadratic improvement (P = .01) in cumulative ADG and average daily feed intake (ADFI) by the end of wk 5. The diet containing 8% SMFM resulted in the maximum observed ADG; however, the maximum ADFI occurred in pigs fed the diet containing 12% SMFM. Breakpoint analysis indicated that 4.5 and 9.3% SMFM maximized ADG and ADFI, respectively. Addition of SMFM did not affect efficiency of feed utilization (F/G). In Trial 2, a 2 X 3 factorial with two levels of dried whey (10 or 20%) and three levels of SMFM (0, 4 or 8%), a SMFM X dried whey interaction (P less than .05) was observed for cumulative ADG and F/G by the of wk 4 with greater benefit from SMFM with 10% than with 20% dried whey.(ABSTRACT TRUNCATED AT 250 WORDS)     

Feeding value of an enzymatically digested protein for early-weaned pigs

Weanling pigs were used in a series of studies to determine the feeding value of an enzymatically digested protein product developed from a blend of swine and poultry abattoir by-products. The initial study used 156 pigs weaned at approximately 22 d of age to compare the product with menhaden fish meal in Phase II diets. The product supported equal growth rate, and there was no preference for diet exhibited based on inclusion level of the enzymatically digested protein product. The second study used 100 pigs weaned at approximately 21 d of age to compare the product with spray-dried animal blood cells in Phase II diets. The product supported a growth rate equal to that with the blood cells, and the combination of products enhanced growth rate (P<.05). The third study used 265 pigs to compare the product with spray-dried porcine plasma in a slope ratio growth assay. Results demonstrated a relative feeding value of 91% for the product over a 4-wk feeding period. The fourth study used 290 pigs to compare the product with spray-dried porcine plasma in Phase II diets; results demonstrated comparable growth performance. The final study used 180 pigs to compare the product with spray-dried porcine plasma in Phase I diets; results demonstrated comparable growth performance. These data indicate that the enzymatically digested abattoir by-product is a high-quality protein source for weanling pigs.     

Effects of pelleting and pellet conditioning temperatures on weanling pig performance

We conducted two experiments to study the effects of pelleting and pellet conditioning temperature on weanling pig performance. In Exp. 1, 252 weanling pigs (PIC, L326 x C22) averaging 6.0 +/- 1.3 kg and 21 +/- 3 d of age were used to evaluate six corn-soybean meal-based diets containing 15% dried whey and formulated to contain 1.4% lysine. Treatments consisted of a control diet without spray-dried animal protein (SDAP) fed in meal form, a diet with 5% SDAP fed in meal form, and four diets with 5% SDAP that were conditioned at 60, 66, 71, or 77 degrees C for 10 s prior to pelleting. Pellets had a 3.97-mm diameter. The experimental diets were fed from d 0 to 14 after weaning, and all pigs were fed a common diet in meal form from d 14 to 28 after weaning. From d 0 to 7 after weaning, pigs fed diets containing SDAP had greater ADG, gain/feed (P < 0.001), and ADFI (P < 0.05) than pigs fed the control diet. No differences (P > 0.10) were observed between pigs fed the pelleted diets and those fed the SDAP diet in meal form. Conditioning temperature had no effect (P > 0.10) on weanling pig performance from d 0 to 14, and the diet fed from d 0 to 14 had no effect on overall performance (d 0 to 28). In Exp. 2, 252 weanling pigs (6.3 +/- 1.5 kg and 22 +/- 4 d of age) were used to evaluate diets with same composition as in Exp. 1, but treatments consisted of diets with or without SDAP conditioned at 60 degrees C before pelleting, and four diets containing 5% SDAP that were conditioned at 68, 77, 85, and 93 degrees C before pelleting. As in Exp. 1, conditioning lasted 10 s, pellets were 3.97 in mm diameter, and experimental diets were fed for the first 14 d of the 28-d experiment. From d 0 to 7, pigs fed the SDAP diet conditioned at 60 degrees C had greater ADFI (P < 0.05) and tended (P = 0.12) to have greater ADG than pigs fed the diet without SDAP and conditioned at 60 degrees C. From d 0 to 7, ADG (quadratic effect, P < 0.03) and ADFI (linear effect, P < 0.002) decreased as conditioning temperature increased, with the largest decrease observed above 77 degrees C. From d 0 to 14 and 0 to 28, ADG was not affected (P > 0.10) by pellet conditioning temperature or SDAP fed from d 0 to 14. The results of these studies suggest that conditioning diets containing 5% SDAP at temperatures above 77 degrees C decreases weanling pig growth performance.     

Evaluation of methods to reduce bacteria concentrations in spray-dried animal plasma and its effects on nursery pig performance

Four experiments with 1,040 weanling pigs (17 +/- 2 d of age at weaning) were conducted to evaluate the effects of spray-dried animal plasma source, drying technique, and methods of bacterial reduction on nursery pig performance. In Exp. 1, 180 barrows and gilts (initial BW 5.9 +/- 1.8 kg) were used to compare effects of animal plasma, animal plasma source, drying technique (spray-dried or freeze-dried), and plasma irradiation in nursery pig diets. From d 0 to 10, pigs fed diets containing irradiated spray-dried animal plasma had increased ADG and ADFI (P < 0.05) compared with pigs fed diets containing nonirradiated spray-dried animal plasma. Pigs fed irradiated animal plasma Sources 1 and 2 were similar in ADG and ADFI, but pigs fed animal plasma Source 1 had greater ADG (P < 0.05) than pigs fed animal plasma Source 2 and pigs not fed plasma. Pigs fed freeze-dried animal plasma had growth performance similar (P > 0.36) to pigs fed spray-dried animal plasma. Overall (d 0 to 24), pigs fed irradiated spray-dried animal plasma were heavier (P < 0.05) than pigs fed no animal plasma, whereas pigs fed nonirradiated spray-dried plasma were intermediate. In Exp. 2, 325 barrows and gilts (initial BW 5.8 +/- 1.7 kg) were used to compare the effects of irradiation or formaldehyde treatment of animal plasma and formaldehyde treatment of the whole diet. Pigs fed diets containing irradiated animal plasma had greater ADG (P < 0.05) than pigs fed nonirradiated plasma. Pigs fed formaldehyde-treated plasma had greater ADG and ADFI (P < 0.05) than pigs fed diets with either nonirradiated plasma or whole diet treated with formaldehyde. In Exp. 3 (360 barrows and gilts; initial BW 6.3 +/- 2.7 kg) and Exp. 4 (175 barrows and gilts; initial BW 6.1 +/- 1.7 kg), the irradiation of feed (high bacteria) and food-grade (low bacteria) animal plasma in nursery pig diets was examined. Pigs fed irradiated feed-grade plasma Product 2 had increased ADG (P < 0.05) compared with pigs fed nonirradiated plasma Product 2 and pigs fed the control diet without plasma. In Exp. 3 and 4, pigs fed irradiated food-grade plasma had growth performance similar to pigs fed nonirradiated food-grade plasma (P > 0.12). These studies indicate that bacterial reduction of feed-grade, but not food-grade animal plasma, improves nursery pig performance.     

Effect of irradiation of individual feed ingredients and the complete diet on nursery pig performance

A total of 1,210 nursery pigs was used in two experiments to evaluate the effects of irradiation of typical nursery diet ingredients, specialty protein products, and the whole diet on nursery pig performance. In Exp. 1, 880 barrows and gilts (15 +/- 2 d of age at weaning) were used in two growth trials (14 d and 12 d for Trials 1 and 2, respectively) to determine the effects of individual ingredient and whole-diet irradiation on nursery pig performance. Overall (d 0 to 14 of Trial 1 and d 0 to 12 of Trial 2), ADG was greater (P < 0.05) for pigs fed irradiated animal plasma compared with pigs fed the control, the diet containing irradiated microingredients, and the diet that was manufactured and irradiated. Also, pigs fed irradiated soybean meal had greater (P < 0.05) ADFI compared with pigs fed the manufactured diet that was irradiated. Pigs fed the diet containing irradiated animal plasma had improved feed efficiency (G:F; P < 0.05) compared with those fed the diet with irradiated microingredients and when all ingredients were irradiated before manufacturing of complete feed. Finally, pigs fed irradiated corn, whey, fishmeal, soybean oil, microingredients, or if all ingredients or the whole diet were irradiated, had similar ADG, ADFI, and G:F (P > 0.12) to control pigs. In Exp. 2, 330 nursery pigs (20 +/- 2 d of age at weaning) were used to determine the effects of irradiation of commercially available specialty protein products in diets for nursery pigs. Overall, ADG was greater (P < 0.05) when pigs were fed diets containing nonirradiated spray-dried animal plasma and egg combination (SDAPE) and dried porcine digest (DPD) compared with pigs fed the control diet containing no specialty protein products. In addition, G:F was improved (P < 0.05) when pigs were fed diets containing nonirradiated SDAPE, DPD, spray-dried beef muscle (SDBM), and spray-dried whole egg (SDWE) compared with pigs fed the control diet. Pigs fed irradiated SDAPE and SDBM had greater (P < 0.05) ADG than pigs fed the nonirradiated forms. Pigs fed irradiated SDBM had improved (P < 0.05) G:F compared with pigs fed the nonirradiated form. In Exp. 1 and 2, an irradiation treatment level of 8.5 kGy was effective in reducing the total bacterial concentration of all ingredients evaluated, as well as the whole diet in Exp.1. Irradiation of certain ingredients, but not the complete diet, increased growth performance of nursery pigs.     

Nutritional evaluation of egg byproducts in diets for early-weaned pigs

A total of 272 Cotswold pigs (17 +/- 1 d) were utilized in three experiments to evaluate the nutritive value of spray-dried egg proteins for early-weaned pigs. In all experiments, pigs were stratified by sex and initial BW and then assigned randomly to experimental diets. In Exp. 1, four corn-soybean meal-based diets containing 7% of either spray-dried porcine plasma (SDPP), spray-dried technical albumen (SDTA), SDTA stored at 70 degrees C for 3 d (SDTA-ht), or spray-dried whole egg (SDWE) were assigned to five pens each with four pigs for a 3-wk study period. Average daily gain, ADFI, and gain:feed ratio (G:F) were determined. At the end of wk 3, five pigs per treatment were killed to determine ileal AA and energy digestibilities, as well as Enterobacteriaceae counts. Compared with the SDPP diet, ADG and G:F were lower (P < 0.05) for SDTA-, SDTA-ht- and SDWE-containing diets. Apparent ileal digestibilities of cystine, histidine, isoleucine, methionine, and threonine in the SDPP diet were lower (P < 0.05) than in diets containing spray-dried egg products. Ileal digestible energy content did not differ (P > 0.05) in all diets (3.1 to 3.2 Mcal/kg). Enterobacteriaceae counts were lower in the SDTA-ht diet than in either the SDTA or SDWE diets (P < 0.05). In Exp. 2, the effect of substituting SDPP with varying levels of SDTA was investigated. Diets were randomly assigned to five pens (except for the 100% SDTA diet, which had four pens), each with four pigs. Average daily gain, ADFI, and G:F decreased linearly as the level of SDTA was increased in the diet (P < 0.05). Replacing SDPP with SDTA at 25 or 50% had no effect on pig performance (P > 0.10). In Exp. 3, phase I diets containing 0, 25, or 50% SDTA in place of SDPP (7% of the diet) were each assigned at random to eight pens each with four pigs for a 14-d period, after which all pigs were switched to a common phase II diet lacking both SDPP and SDTA for another 14 d. Average daily feed intake and ADG did not differ among all diets in phase I and II and overall (d 0 to 28). Pigs fed the diet containing 50% SDTA in phase I had lower (P < 0.05) G:F than those fed the SDPP diet. The results indicate that technical albumen can replace 25 to 50% of SDPP in early-weaned pig diets without compromising performance, and further suggest that heat-treated SDTA may affect intestinal microbial population in pigs.     

Effect of protein source and fumaric acid supplementation on apparent ileal digestibility of nutrients by young pigs

Two experiments were conducted to determine the apparent ileal digestibility of DM and N by young pigs fed diets supplemented with different protein sources or organic acids. Pigs were surgically fitted with silicone cannulas at 2 wk of age. Following surgery, pigs were allowed to recuperate with their dams while suckling normally. After weaning at 24 d, pigs were assigned to treatment diets at 28 d of age. A 3-d adjustment and 4-d collection sequence was followed for the duration of the 4-wk experiment. Four treatment diets were fed in each experiment in a weekly rotation until each diet had been fed to each pig. Diet samples and digesta collected through the ileal cannulas were analyzed for chromic oxide (used as an indigestible marker), DM, and N. Pigs in Exp. 1 were fed isolysinic (1.0%) corn-based diets supplemented with casein, soybean meal, soy protein concentrate, or isolated soy protein. Casein addition resulted in improved DM (P less than .001) and N (P less than .05) digestibility but reduced gain (P less than .05) compared with the average of the soy protein sources. Nitrogen from diets formulated with soybean meal was digested more completely (P less than .05) than N from diets based on soy protein concentrate and isolated soy protein. Experiment 2 was an evaluation of the effect of dried skim milk (25%) and fumaric acid (2%) addition on apparent ileal digestibility of N and DM in corn-soybean meal diets. Addition of dried skim milk improved DM (P less than .01) and N (P less than .05) digestibility and daily gain (P less than .001). Fumaric acid supplementation did not affect nutrient digestibility or gain (P greater than .10).     

Comparison of spray-dried blood meal and blood cells in diets for nursery pigs

We used a total of 680 pigs to compare spray-dried blood meal and blood cells in nursery diets. In Exp. 1, 350 barrows (17 +/- 2 d of age at weaning) were used to compare three levels of spray-dried blood meal or blood cells (2.5, 5.0, and 7.5%) in the diet fed from d 5 to 19 postweaning (6.6 to 9.9 kg). Inclusion of either blood product improved ADG (P < 0.005) and G:F (P < 0.001) compared to pigs fed the control diet without added blood products. However, pigs fed spray-dried blood meal had greater ADG (P < 0.001), ADFI (P < 0.04), and G:F (P < 0.001) from d 0 to 7 compared to those fed blood cells. The greatest differences observed between the two blood products occurred at the 5 and 7.5% inclusion levels. No differences (P > 0.05) in growth performance were detected between the two blood products from d 7 to 14. In Exp. 2, 380 barrows (initial BW of 10.7 kg and 41 +/- 2 d of age) were used to determine lysine bioavailability of spray-dried blood meal and blood cells via the slope ratio procedure. With G:F ratio as the response criterion, blood meal and blood cells had similar lysine bioavailability relative to crystalline lysine. These experiments indicate that both blood products had similar lysine bioavailability, and that pigs fed spray-dried blood meal had greater performance during the initial 7 d (d 5 to 12 after weaning). However, as the pigs became heavier, there were no differences observed in performance of pigs fed either blood meal or blood cells.     

Comparison of spray‐dried egg and albumen powder with conventional animal protein sources as feed ingredients in diets fed to weaned pigs

We evaluated the apparent (AID) and standardized ileal digestibility (SID) of amino acids (AA) in spray‐dried egg (SPE) and albumen powder (AP) compared with spray‐dried porcine plasma (SDPP), dried porcine solubles (DPS) and fish meal (FM). Additionally, the effects of these egg byproducts as a replacement for conventional animal proteins on the performance and nutrient digestibility of piglets were studied. In Exp. 1, six barrows fitted with ileal T‐cannulas were allotted to a 6 × 6 Latin Square design and fed six diets. The AID and SID of AA were generally higher in AP and FM (P < 0.01) than in the other protein sources. In Exp. 2, 150 piglets weaned at 21 days, were fed diets containing the five protein sources for 3 weeks. Weight gain of piglets fed SDPP was the highest among the treatments. Dry matter and protein digestibility for pigs offered SDPP were higher (P < 0.01) than those offered FM and DPS. AP decreased (P < 0.05) Escherichia coli counts in the cecum. DPS decreased (P < 0.05) serum diamine oxidase compared with SPE. In conclusion, AP and SPE are competitive with traditional animal protein sources and can be successfully fed to piglets without compromising performance.     

The effects of poultry meal source and ash level on nursery pig performance

Weanling pigs (total of 560) were used in two experiments to determine the effects of poultry meal in nursery diets on pig performance. In Exp. 1,210 barrows and gilts (initially 7.4 kg and 21 +/- 2 d of age) were fed one of five diets, which included a control diet with no specialty protein products or (as-fed basis) the control with 2.5 or 5.0% fish meal, or 2.9 or 5.9% poultry meal (11.8% ash). Poultry meal replaced fish meal on an equal lysine basis. Overall (d 0 to 28), pigs fed diets containing fish meal had greater (P < 0.01) ADG than pigs fed poultry meal. Increasing fish meal tended to have increased (quadratic, P < 0.07) ADG, with the greatest improvement observed in pigs fed the diet containing 2.5% fish meal. Pigs fed diets containing fish meal had improved (P < 0.01) G:F compared with pigs fed diets containing poultry meal. In Exp. 2, a total of 350 barrows and gilts (initially 8.9 kg and 22 +/- 2 d of age) were fed one of seven experimental diets, which included a control diet with no specialty protein products, or the control with 2.5 or 5.0% fish meal, 2.9 or 5.8% low-ash (10.9%) poultry meal, and 3.1 or 6.2% high-ash (13.5%) poultry meal. Poultry meal replaced fish meal on an equal lysine basis. Overall (d 0 to 15), there were no differences in ADG and ADFI (P = 0.14); however, pigs fed diets containing fish meal or poultry meal had improved (linear, P < 0.01) G:F compared with pigs fed the control diet. Pigs fed diets containing low-ash poultry meal had greater (P < 0.01) G:F compared with pigs fed diets containing high-ash poultry meal. Based on these data, quality control specifications, such as ash content, need to be considered when using poultry meal as an animal protein replacement in diets for nursery pigs.     

Growth performance, gastrointestinal microbial activity, and nutrient digestibility in early-weaned pigs fed diets containing flaxseed and carbohydrase enzyme

The effects of ground flaxseed (FS) and a multicarbohydrase enzyme (C) supplement on piglet performance, gastrointestinal microbial activity, and nutrient digestibility were investigated in a 28-d trial. The enzyme supplement provided 500 units of pectinase, 50 units of cellulase, 400 units of mannanase, 1,200 units of xylanase, 450 units of glucanase, and 45 units of galactanase per kilogram of diet. Ninety-six pigs were weaned at 17 d of age (BW, 6.1 +/- 0.4 kg, mean +/- SD) and assigned to treatments based on a 2 x 2 factorial arrangement in a completely randomized design, with 6 pens per diet (4 pigs per pen). The diets contained wheat, barley, peas, soybean meal, and canola meal with 0 or 12% FS, and were fed without or with C. Flaxseed was included by changing the levels of the other ingredients to balance the diets for DE and nutrients. Diets had similar nutrient contents and met the NRC (1998) nutrient specifications, with the exception of DE, CP, and AA, which were 95, 94, and 97% of the NRC requirements, respectively. Diets were fed in a 2-phase feeding program (2 wk/phase). Feed intake and BW were measured weekly, and 1 pig per pen with a BW nearest the pen average was bled weekly to evaluate plasma urea nitrogen. On d 28, fresh fecal samples were collected from each pen and 1 pig per pen with a BW nearest the pen average was killed to evaluate intestinal microbial activity and nutrient digestibility. A dietary effect on piglet performance was observed only in wk 3, when the FS diets decreased (P = 0.005) ADG and G:F, tended to decrease (P = 0.070) ADFI, and increased (P = 0.027) plasma urea nitrogen. An interaction between FS and C was observed for ileal digesta viscosity (P = 0.045), such that C increased viscosity in the FS diet but had no effect in the non-FS diet. Flaxseed and C interacted to affect ileal ammonia content (P = 0.049), such that in the absence of FS, pigs fed the diet with C had lower ammonia than those on the diet without C. Flaxseed and C affected other ileal parameters independently. Pigs fed the FS diets had decreased (P = 0.003 to 0.033) anaerobic spore counts, organic acid, DM, CP, and nonstarch polysaccharide (NSP) digestibility compared with pigs fed the non-FS diets, whereas pigs fed the C-supplemented diets had greater (P = 0.009 to 0.061) lactobacilli counts, lactate, DM, and NSP digestibility than pigs fed the unsupplemented diets. In conclusion, FS reduced ileal microbial activity, nutrient digestibilities, and piglet performance in wk 3. The multicarbohydrase supplement increased ileal DM and NSP digestibilities as well as lactobacilli counts and lactate.     

Use of pet food-grade poultry by-product meal as an alternate protein source in weanling pig diets

Three experiments were conducted to evaluate pet food-grade poultry by-product meal (PBM) as a replacement protein source for fish meal (FM), blood meal (BM), and spray-dried plasma protein (SDPP) in weanling pig diets. In the first study, 200 crossbred pigs (initial BW = 6.5 kg) were weaned (21 d) and randomly allotted to one of four dietary treatments, which included a control and three test diets where PBM was substituted for FM, blood products, or both. Experimental diets were fed during Phase I (d 0 to 5 postweaning) and Phase II (d 5 to 19), and a common Phase III diet was fed from d 19 to 26. Overall (d 0 to 26), there was no difference in performance of pigs fed PBM in place of the other ingredients. However, during Phase I, BW (P < 0.05), ADG (P < 0.02), and intake (P < 0.001) in pigs fed diets containing SDPP were greater than those fed diets with PBM. In Exp. 2, the performance of pigs (n = 100, initial BW = 6.5 kg) fed diets containing 20% PBM (as-fed basis, replacing SDPP, BM, FM, and a portion of the soybean meal) in all phases of the nursery diet was compared with a group fed conventional diets without PBM. There were no differences in overall performance (d 0 to 26); however, ADG (P < 0.10) and feed intake were higher (P < 0.01) for pigs fed the conventional diet than for pigs fed the 20% PBM diet during Phase I (d 0 to 5). Experiment 3 was a slope-ratio assay to determine the ability of PBM to replace SDPP. A total of 320 pigs (initial BW = 7.32 kg) was weaned (21 d) and allotted to five treatment groups in three trials in a blocked design with product (SDPP or PBM) as the first factor, and lysine level (1.08, 1.28, 1.49%; as-fed basis) as the second factor. Growth rate increased with increasing lysine (P < 0.05), regardless of the source. These results indicate that PBM can be used in nursery diets in place of blood meal and fish meal without affecting performance. Furthermore, although feeding PBM in Phase I diets was not equivalent to SDPP during the first week, there was no overall difference in performance at the end of the nursery phase.     

The evaluation of soybean meals from 3 major soybean-producing countries on productive performance and feeding value of pig diets

This study was conducted to evaluate 1) the effects of soybean meal (SBM) from 3 major SBM-producing countries (United States, Brazil, and India) on the growth performance, nutrient digestibility, and meat quality of growing-finishing pigs and 2) the feeding value of the evaluated SBM as a feedstuff for growing-finishing pigs. Soybean meal representative of each country was purchased on the open market. A total of 144 barrows with the average BW of 23.77 (SD = 1.52 kg) were allotted to 3 dietary treatments with 12 replicate pens per treatment and 4 pigs per pen. The US SBM used in this trial had greater CP and total AA contents, greater KOH protein solubility, and less crude fiber than SBM from either Brazil or India. Diets were formulated to be isolysinic and isocaloric. Pigs fed diets containing US SBM were heavier (P < 0.05) than pigs fed diets containing Brazilian or Indian SBM at 12 and 18 wk. Pigs fed diets containing US SBM had greater (P < 0.05) ADG and G:F throughout the overall period when compared with pigs fed SBM produced in Brazil or India. The DM and N digestibility were greater for US SBM (P < 0.05) than Brazilian and India SBM at 6, 12, and 18 wk. Pigs were slaughtered at the end of 18 wk, and no differences were observed on meat quality (backfat thickness, LM area, pH, meat color, water holding capacity, and drip loss) among the treatments, except lean percentages were less and backfat thickness was greater in pigs fed Brazilian and Indian SBM than US SBM. The cost per kilogram of BW gain of the experimental diet containing US SBM was less than that of diets containing Brazilian or Indian SBM, but it would depend on the relative prices of each SBM. Based on the results of the current experiment, the productivity and feeding value of US SBM seems to be greater than the SBM produced in Brazil and India.     

Dried skim milk as a replacement for soybean meal in growing-finishing diets: effects on growth performance, apparent total-tract nitrogen digestibility, urinary and fecal nitrogen excretion, and carcass traits in pigs

Two trials were conducted to determine the replacement nutritive value of dried skim milk for growing-finishing pigs. In a three-phase feeding trial, 180 growing composite barrows (40.8 +/- 2.9 kg BW) were allotted to three dietary treatments. Each phase lasted 28 d. Treatment 1 comprised a basal corn-soybean meal diet supplemented with crystalline AA to contain true ileal digestible concentrations (as-fed basis) of 0.83, 0.66, and 0.52% Lys; 0.53, 0.45, and 0.40% Thr; and 0.51, 0.45, and 0.42% sulfur amino acids (SAA; Met + Cys) in Phases 1, 2, and 3, respectively. Treatments 2 and 3 were the basal diets with 5 and 10% (as-fed basis) dried skim milk added. The three diets at each phase were formulated to have the same quantities of DE, true ileal digestible Lys, Thr, Trp, SAA, Ca, and available P. Pigs were housed 10 per pen (six pens/treatment), allowed ad libitum access to feed, and slaughtered at 121.6 +/- 9.3 kg BW. No differences were detected between pigs fed the basal diet and the dried skim milk diets or between pigs fed the 5 and 10% dried skim milk diets, respectively, in 84-d ADG (P = 0.84 or P = 0.71), ADFI (P = 0.54 or P = 0.91), and G:F (P = 0.80 or P = 0.97), in hot carcass weight (P = 0.66 or P = 0.74), 45-min postmortem LM pH (P = 0.90 or P = 0.53), 10th-rib backfat thickness (P = 0.24 or P = 0.77), LM area (P = 0.13 or P = 0.63), weights of belly (P = 0.43 or P = 0.70), trimmed wholesale cuts (P = 0.18 to 0.85 or P = 0.06 to 0.53), and ham components (P = 0.25 to 0.98 or P = 0.32 to 0.63). In the N balance trial, four littermate pairs of finishing gilts (82.9 +/- 2.0 kg BW) were assigned within pair to the basal or the 10% dried skim milk (as-fed basis) finishing diet. Daily feed allowance was 2.6x maintenance DE requirement and was given in two equal meals. Total fecal collection from eight meals and a 96-h urine collection began on d 14 when gilts weighed 92.1 +/- 2.2 kg BW. No differences were found between dietary treatments in gilt's daily N intake (P = 0.33) and the daily output of urinary urea (P = 0.88), urinary N (P = 0.97), fecal N (P = 0.69), and total manure (P = 0.62), as well as apparent total-tract N digestibility (P = 0.84) and N retention (P = 0.84). It is concluded that growing-finishing pigs fed diets containing 10% dried skim milk would have growth performance, carcass traits, and N digestibility and use similar to those fed typical corn-soybean meal diets.     

Use of carbohydrases in corn-soybean meal-based nursery diets

Three experiments were conducted to test the hypothesis that supplementing nursery pig diets with a mixture of carbohydrases (CS) will improve pig performance and nutrient digestibility. The CS used in these experiments contained 7 units/g of alpha-1,6-galactosidase, 22 units/g of beta-1,4-mannanase, beta-1,4 mannosidase, and trace amounts of other enzymes. In Exp. 1, 108 pigs weaned at d 21 of age were fed one of three diets containing 0 (control), 0.1, or 0.2% CS for 5 wk, based on a three-phase feeding program (1, 2, and 2 wk). Over the entire 35-d period, ADG was not affected (P > 0.05) by treatment, but supplementing 0.1% CS increased (P < 0.05) gain:feed by 9%. Experiment 2 used 10 gilts fitted with simple T-cannula in the terminal ileum at 3 wk of age. After cannulation, pigs were fed the same control Phase I and II diets, but the Phase III diet contained either 0 or 0.1% CS. Ileal samples were collected for the 3 d following the 5-d adjustment period during Phase III. Apparent ileal digestibility of GE, lysine, threonine, and tryptophan was greater (P < 0.05) in the CS diet. In Exp. 3, 90 pigs weaned at 21 d of age were fed the same control Phase I and II diets, but the Phase III diet contained either 0 or 0.1% CS. Phase III diets were fed for 3 wk. Average daily gain of the CS group was greater (P < 0.05) than the control group during wk 3. Gain:feed ratio was greater (P < 0.05) for the carbohydrase group during the entire Phase III period. Four pigs per treatment were killed at the end of Exp. 3 to measure villus height and to determine the concentration of raffinose and stachyose in different parts of the gastrointestinal tract. Average villus height was greater (P < 0.05) in pigs fed the CS diet. Carbohydrase supplementation decreased (P < 0.05) the concentration of stachyose in freeze-dried digesta from the proximal and distal small intestine. Raffinose concentration, on the other hand, was decreased (P < 0.05) by CS supplementation only in the distal small intestine. These lower concentrations suggest that CS improved the digestibility of carbohydrate in soybean meal. In conclusion, the addition of CS to Phase I and Phase II nursery diets containing low levels of soybean meal did not improve pig performance, but its addition to corn-soybean meal-based Phase III nursery diets improved gain:feed ratio and energy and AA digestibility.     

Effect of receiving diets containing alfalfa and certain feed additives on performance of feeder pigs transported long distances

Three experiments were conducted to determine the effect of receiving diets containing alfalfa meal and certain feed additives on performance of comingled feeder pigs transported 900 to 1,100 km. In Exp. 1, the inclusion of 9.4% dehydrated alfalfa meal in receiving diets for 2 wk resulted in no difference (P greater than .1) in gain or feed conversion from purchase to market compared with pigs fed a basal corn-soybean meal (CS) diet or a diet containing 20% ground whole oats (O). In Exp. 2, pigs fed receiving diets containing 10% dehydrated alfalfa meal had no improvement (P greater than .1) in gain (.60 vs .61 kg/d) or conversion (3.25 vs 3.17) compared with CS-fed pigs. In Exp. 3, pigs fed a receiving diet for 2 wk containing 10% mid-bloom alfalfa ate more (P less than .002) feed daily for 2 wk (.82 vs .76 kg) and overall (P less than .04; 1.92 vs 1.85 kg) and had an improved (P less than .03) daily gain from purchase to market (.61 vs .59 kg) compared with CS-fed pigs. In Exp. 2, pigs fed diets containing 44 mg/kg tylosin (T) gained similar to pigs fed no additive (O) and slower (P less than .01) than pigs fed 110 mg/kg chlortetracycline (CTC; .59, .60 and .63 kg/d), with no significant differences in feed to gain conversion (3.12, 3.23 and 3.18).(ABSTRACT TRUNCATED AT 250 WORDS)     

Phosphorus bioavailability, growth performance, and nutrient balance in pigs fed high available phosphorus corn and phytase

Three experiments were conducted to evaluate P bioavailability, growth performance, and nutrient balance in pigs fed high available P (HAP) corn with or without phytase. The bioavailability of P in normal and HAP corn relative to monosodiumphosphate (MSP) for pigs was assessed in Exp. 1. In a randomized complete block design, 96 pigs (average initial BW 9.75 kg) were fed eight diets for 28 d. The reference and test diets were formulated by adding P as MSP, HAP, or normal corn at 0, 0.75, or 1.5 g/kg to a corn-starch-soybean meal basal diet (2.5 g/kg P) at the expense of cornstarch. Plasma inorganic P concentration responded linearly (P < 0.05) to supplemental P intake. Estimates of P bioavailability from HAP andnormal corn when plasma P was regressed on supplemental P intake were 46 and 33%, respectively. In Exp. 2 and 3, pigs were fed corn-soybean meal-based diets containing HAP corn or normal corn and 0 or 600 units of phytase per kilogram in a 2 x 2 factorial arrangement (two corn sources and two levels of phytase). In Exp. 2, 48 crossbred pigs (barrow:gilt, 1:1) averaging 9.25 kg were used to evaluate growth performance. There were no detectable interactions between corn source and phytase for any of the performance criteria measured. Pigs receiving normal corn had the lowest (P < 0.05) BW and rate of gain. Feed efficiency was lower (P < 0.05) in pigs fed normal compared with those fed the HAP corn phytase-supplemented diet. In Exp. 3, 24 crossbred barrows averaging 14.0 kg were used to evaluate nutrient digestibility. There were no detectable interactions between corn and phytase for any of the N and Ca balance criteria. Nitrogen and Ca retention were improved in pigs receiving HAP corn with phytase (P < 0.05). Retention and digestibility of P was lowest (P < 0.01) for pigs on normal corn diet without phytase. The percentage of P digested and retained was improved and fecal P excretion lowered (P < 0.05) by feeding HAP corn.The results of this study indicate that the bioavailability and balance of P in HAP corn is superior to that of normal corn. The addition of 600 phytase units (Natuphos 600, BASF) to HAP corn-based diets further improved P digestibility and reduced P excretion in pigs.     

Effects of blood meal pH and irradiation on nursery pig performance

A total of 720 nursery pigs in three experiments were used to evaluate the effects of blood meal with different pH (a result of predrying storage time) and irradiation of spray-dried blood meal in nursery pig diets. In Exp. 1, 240 barrows and gilts (17 +/- 2 d of age at weaning) were used to determine the effects of blood meal pH (7.4 to 5.9) in diets fed from d 10 to 31 postweaning (7.0 to 16.3 kg of BW). Different lots of dried blood meal were sampled to provide a range in pH. Overall (d 0 to 21), pigs fed diets containing blood meal had greater ADG (P < 0.05) and ADFI (P < 0.05) than pigs fed diets without blood meal. Ammonia concentrations in blood meal rose as pH decreased. However, blood meal pH did not influence (P > 0.16) ADG, ADFI, or gain:feed (G:F). In Exp. 2, 180 barrows (17 +/- 2 d of age at weaning) were used to determine the effects of post drying pH (7.6 to 5.9) and irradiation (gamma ray, 9.5 kGy) of blood meal on growth performance of nursery pigs from d 5 to 19 postweaning (6.8 to 10.1 kg of BW). One lot of whole blood was isolated with 25% of the total lot dried on d 0, 3, 8, and 12 after collection to create a range in pH. Overall, pigs fed blood meal had improved G:F (P < 0.01) compared to pigs fed the control diet. Similar to Exp. 1, the ammonia concentration of blood meal increased with decreasing pH. Blood meal pH did not influence ADG, ADFI, or G:F (P > 0.21), but pigs fed irradiated blood meal (pH 5.9) had greater ADG and G:F (P < 0.05) than pigs fed nonirradiated blood meal (pH 5.9). In Exp. 3, 300 barrows (17 +/- 6 d of age at weaning) were used to determine the effects of blood meal irradiation source (gamma ray vs. electron beam) and dosage (2.5 to 20.0 kGy) on growth performance of nursery pigs from d 4 to 18 postweaning (8.7 to 13.2 kg of BW). Overall, the mean of all pigs fed blood meal did not differ in ADG, ADFI, or G:F (P > 0.26) compared to pigs fed the control diet without blood meal. Pigs fed irradiated blood meal had a tendency (P < 0.10) for increased G:F compared with pigs fed nonirradiated blood meal. No differences in growth performance were detected between pigs fed blood meal irradiated by either gamma ray or electron beam sources (P > 0.26) or dosage levels (P > 0.11). These studies suggest that pH alone as an indicator of blood meal quality is not effective and irradiation of blood meal improved growth performance in nursery pigs.     

Effect of protein and(or) carbohydrate fractions of dried whey on performance and nutrient digestibility of early weaned pigs

One hundred eighty 3-wk-old pigs (initial weight 4.8 kg) were utilized in a 35-d growth trial to determine the effects of the carbohydrate and(or) protein fraction of dried whey on pig performance. In addition, 30, 3-wk-old pigs (initial weight 4.9 kg) were used in two digestion trials to study the effects of the whey fraction on nutrient digestibility. Dietary treatments included a corn-soybean meal diet (control), control + 20% dried whey, control + 14.4% lactose, control + 2.1% lactalbumin, control + 14.4% lactose + 2.1% lactalbumin, and control + 8.4% whey protein concentrate. Pelleted diets containing equal lysine concentrations were fed. Lactose and lactalbumin were added at the same levels as provided by a 20% dried whey diet. Pigs fed diets containing milk products exhibited superior (P less than .05) ADG and efficiency of feed utilization and greater (P less than .05) apparent digestibilities for DM, energy and N compared with pigs fed the control diet. Including either lactose or lactalbumin in the diet for the early weaned pig resulted in similar gain, feed efficiency and nutrient digestibility. These results indicate that both the carbohydrate (lactose) and protein (lactalbumin) fractions of dried whey are important in explaining the beneficial response to dried whey elicited in the weanling pig.