Soluble solids accumulation and postharvest performance of ‘Hayward’ kiwifruit

A soluble solids content (SSC) of 6.2% has been used as a minimum harvest index for ‘Hayward’ kiwifruit for about 30 years. This paper describes a study that examines the pattern of soluble solids accumulation in ‘Hayward’ kiwifruit beyond the simple timing at which fruit reach 6.2% and investigates the relationship between soluble solids accumulation and postharvest performance assessed as softening and expression of chilling injury. This has been done using fruit from 10 orchards harvested at a range of SSC from 5 to 10% during one season. Soluble solids accumulation showed a general trend for a change from slow to more rapid accumulation during the season that could be described by a single logistic curve. The point at which the rate of soluble solids accumulation increased was more or less distinct for fruit from different orchards and occurred when fruit were at SSC between 6.3 and 7.4%. It is also possible that there is not a consistent change in soluble solids accumulation rate, with the rate being dependent on the environmental conditions over several days before measurement. There was a major change in softening pattern and low temperature breakdown susceptibility between fruit harvested at 6.4 and at 8.0% SSC. This change coincided with a change to faster soluble solids accumulation at harvest. It is concluded that the pattern, or rate, of soluble solids accumulation is likely to be a more robust indicator of the physiological state of the fruit, and therefore postharvest performance, than a single SSC value.     

The effect of modified atmospheres on the rate of firmness change of ‘Hayward’ kiwifruit

Gas exchange rates and softening of kiwifruit (Actinidia deliciosa (A Chev) Liang et Ferguson cv Hayward) were measured during two seasons under a range of modified atmosphere (MA) conditions (0–21 kPa O₂, 0–5 kPa CO₂) at 0–10 °C to characterise their functional relationship. The kinetics of gas exchange and softening were the same for the two seasons studied.CO₂ partial pressures delayed softening but did not inhibit the rate of gas exchange. Lowering the O₂ levels to near 0 kPa did not inhibit softening completely, suggesting that the rate of softening was driven by energy provided by both oxidative and fermentative processes.An integrated modelling approach was used to link the rate of softening to the rate of gas exchange explaining 88% of the effect of MA on both the rate of gas exchange and fruit softening. Shelf life simulations showed that during storage at 0 °C, lowering O₂ or raising CO₂ gave a substantial benefit towards extending shelf life. At temperatures higher than 3 °C, the additional effect of MA was already limited.     

Changes in volatile production and sensory quality of kiwifruit during fruit maturation in Actinidia deliciosa ‘Hayward’ and A. chinensis ‘Hort16A’

Although volatiles have been previously studied in kiwifruit (Actinidia spp.), there has been no co-ordinated study of volatile release and softening through the full edible period. In this report, the two most important commercial cultivars A. deliciosa ‘Hayward’ and A. chinensis ‘Hort16A’ were evaluated for volatiles released at different ripening stages corresponding to their typical commercial shelf life, and compared to the sensory quality assessed by a trained taste panel. Gas chromatography–mass spectrometry data indicated that large amounts of straight-chain aldehydes and esters were the dominant volatiles in the two cultivars. In particular, butanoates, the main fruity esters in both fruit, significantly increased during ripening and an extremely high level of butanoates was found in the over-ripe fruit. Sensory results indicated that with fruit softening, some of the changes in volatile content could explain changes in fruit flavor detected by a trained panel, and differences in characteristic flavor of the two cultivars. The results have implications for fruit sample handling and volatile assessment.     

Effect of antioxidants in controlling enzymatic browning of minimally processed persimmon ‘Rojo Brillante’

‘Rojo Brillante’ is an important variety of persimmon that after removal of the astringency with high levels of CO₂, maintains firmness and sweetness, making possible its commercialization as a fresh-cut commodity. However, the commercial success of the product is limited mainly by enzymatic browning. This work presents the effect of a wide range of antioxidants on enzymatic browning of ‘Rojo Brillante’ persimmon combining in vitro (extracts and precipitates) and in vivo (cut tissue) studies. Preliminary screening of the antioxidants, determined by absorbance and color measurements of persimmon extracts and pellets, showed that 4-hexylresorcinol (Hexyl), citric acid (CA) and calcium chloride (CaCl₂) were effective at controlling browning at 10 mM; whereas, ascorbic acid (AA) required a higher concentration (25 mM). Peracetic acid, cyclodextrin, cysteine, and hexametaphosphate were not effective at controlling browning, even at a concentration of 50 mM. In in vivo studies, AA (1.12%) and CA (0.21%) were the most effective treatments to control enzymatic browning of fresh-cut material, reaching the limit of marketability in 5–7 days, whereas, Hexyl and CaCl₂ did not reach 1 day of storage. The results showed that optimum concentrations in cut tissue did not always correlate with the in vitro studies, indicating that antioxidants have an effect not only in browning reactions, but also in metabolic activity and cell wall changes during wound-induced reactions. The results provide relevant information for further development of minimally processed ‘Rojo Brillante’ persimmon during storage at 5 °C.     

Postharvest performance of the yellow-fleshed ‘Hort16A’ kiwifruit in relation to fruit maturation

Postharvest performance of fruit is dependent on the maturity or physiological state of the fruit at harvest in conjunction with the postharvest management applied. For yellow-fleshed kiwifruit, the flesh colour is a significant quality attribute, and for ‘Hort16A’, flesh colour has been used for timing harvest. Variability in the postharvest performance of ‘Hort16A’ kiwifruit suggests that flesh colour alone is not as strongly indicative of postharvest performance as soluble solids content (SSC) was found to be for ‘Hayward’ kiwifruit 30 years ago. The postharvest performance of ‘Hort16A’ kiwifruit, assessed as the fruit firmness and chilling injury expression during storage, has been associated with a range of fruit characteristics: flesh colour, SSC, firmness, seed colour, fresh weight, dry matter, starch and soluble carbohydrates measured at harvest throughout maturation. The changing responses of the fruit SSC to temperature, and softening to ethylene, have also been determined. The data illustrate the complex nature of ‘Hort16A’ fruit maturation, even when looking only at simple, easy-to-measure fruit attributes. While a yellow flesh colour is a commercial necessity for ‘Hort16A’ kiwifruit, flesh colour is not a robust indicator of postharvest performance and is not tightly linked to SSC or firmness. Changes in the capacity of fruit to respond to temperature or ethylene are not reflected in on-vine changes. Softening in storage is strongly linked to the softening rate occurring on the vine at the time of harvest. Any association between at-harvest characteristics and chilling susceptibility is less clear, and chilling tolerance appears more associated with the completion of growth and carbohydrate accumulation than with increased soluble solids accumulation rates as in ‘Hayward’. Approaches to extend the understanding of the link between maturation, harvest indices and postharvest performance are discussed.     

Influence of environmental conditions on the quality attributes and shelf life of ‘Goldfinger’ bananas

‘Goldfinger’ bananas (Musa accuminata, FHIA-01) were harvested, held for 14–22 d at five temperatures and a constant relative humidity (RH) or at five RHs and a constant temperature and evaluated for quality attributes. The objectives of this work were to: (1) create quality curves for bananas stored at chilling and non-chilling temperatures; (2) create quality curves for bananas stored at a non-chilling temperatures and different RHs; (3) identify which sensory quality attribute limits the shelf life and marketability of bananas when stored at chilling and non-chilling temperatures or at different RHs; and (4) correlate subjective sensory attributes with quantitative quality measurements. Results from this study showed that temperature had a more significant impact on the quality of banana than RH. Bananas stored at temperatures higher than 10 °C were yellower and softer but had lower starch and higher soluble solids and total sugar content than those stored at lower temperatures. When stored at 2, 5 and 10 °C, bananas developed chilling injury (CI) and abnormal ripening when transferred to 20 °C. The most remarkable impact of RH on banana quality was on weight loss, which was significantly higher in fruit held below 80% RH than in fruit held in 87 or 92% RH. CI was the first sensory quality attribute to reach the limit of acceptability in fruit stored at 2, 5 and 10 °C, whereas color changes and softening limited the shelf life of bananas stored at 15 and 20 °C. Changes in color and/or softening were the two main sensory attributes that limited the shelf life of bananas stored at different RHs. Overall, for maximum quality and shelf life bananas should be stored at or above 15 °C and 92% RH. Finally, sensory attributes can be used to estimate peel color, pulp softening and sweetness, while SSC can be used as a reliable and simple method to estimate the total sugar content of bananas stored at different temperatures or different RHs.     

Breeding of new rice cultivar ‘Tohoku 194’ with ‘Sasanishiki’-type good eating quality of cooked rice

Cooked rice of ‘Sasanishiki’ is soft and not as sticky as those of Japanese leading cultivars ‘Koshihikari’ and ‘Hitomebore’. As a method for efficient selection of a breeding line having a good eating quality like that of ‘Sasanishiki’, the use of physical properties of cooked rice and cooking quality was examined. There were differences of physical properties of the surface layer, starch-iodine blue value per solid substance weight in cooking water and volume expansion of cooked rice between ‘Sasanishiki’ and ‘Hitomebore’, these properties being considered to be usable for the selection of breeding lines. Using these traits as selection targets, one line, named ‘Tohoku 194’, which has eating quality highly similar to that of ‘Sasanishiki’ and cold tolerance derived from ‘Hitomebore’, was selected from progeny of a cross between ‘Sasanishiki’ and ‘Hitomebore’. An application for registration as a new variety has been submitted for ‘Tohoku 194’ under the Japanese Plant Variety Protection Act, and is expected to become a recommended cultivar in Miyagi Prefecture. ‘Tohoku 194’ may fulfill various demands of consumers and companies in the food industry.     

Effect of gamma irradiation treatment at phytosanitary dose levels on the quality of ‘Lane Late’ navel oranges

The objectives of this study were to determine the dose tolerance of ‘Lane Late’ navel oranges (Citrus sinensis L. Osbeck) to irradiation for phytosanitary purposes, identify the sensory attributes that may be affected by the treatment, and determine which changes, if any, influence consumer liking. ‘Lane Late’ navel oranges on Carrizo citrange (C. sinensis Poncirus trifoliate) rootstock were irradiated at target dose levels of 200, 400 and 600 Gy (actual absorbed doses were in the range of 100–300, 300–500, and 500–700 Gy, respectively) then stored for 1 d at 5 °C, 3 weeks at 5 °C (to simulate sea shipment to Asia) or 4 weeks (3 weeks at 5 °C and 1 week at 20 °C to simulate distribution to retail following sea shipment). Trained sensory panelists found increased pitting and visual damage in oranges treated at doses of 400 and 600 Gy. Consumer liking scores for appearance were significantly lower for oranges treated at 400 Gy, however, their overall liking scores for those same oranges were not significantly different than control. Color, total phenolic content, vitamin C and ORAC (oxygen radical absorbance capacity) values were not affected by irradiation. Dose effects were seen in terms of visual damage, increased weight loss and increased concentration of certain volatiles and as well as decreased SSC (soluble solids concentration) at doses 400 and 600 Gy. The primary effect of irradiation on fruit quality was external damage and pitting at doses of 400 and 600 Gy. Further research should consider pack configuration and/or combination treatments to possibly mitigate negative irradiation effects on appearance of the fruit.     

Effect of initial hermetic sealing on quality of ‘Kyoho’ grapes during storage

Experiments of initial hermetic sealing using high barrier film were carried out on ‘Kyoho’ grapes (Vitis vinifera L. × V. Labrusca L. cv. Kyoho) in the 2008 and 2009 fruit seasons, to investigate their potential to enhance quality and extend storage life of the fruit. In the 2008 season, grapes were packaged in high barrier film bags for 1, 2, 3, 4 and 5 weeks, and a modified atmosphere (MA) of low oxygen and high carbon dioxide was formed after sealing. After packaging, fruit were removed from bags and stored in air for up to 90 d at 0 °C. In the 2009 season, grapes were packaged in perforated bags, or in high barrier film bags for 2 weeks and subsequently perforated bags to avoid further anoxia and excessive CO₂ accumulation. After treatment, fruit were stored for up to 90 d at 0 °C, followed by shelf-life at 20 °C for 7 d. Non-packaging air storage was used as a control in both seasons. Fruit quality attributes including soluble solids, titratable acidity, stem browning, berry drop and decay incidence were measured. The results indicated that short-term initial MAP (≤2 weeks) had potential for improving appearance of bunches and maintaining the quality of berries during long-term storage, and significantly reduced quality deterioration. Stems were greener and berry drop and decay incidence were more effectively controlled when fruit were sealed in high barrier film bags for 2 weeks and the bags were subsequently perforated.     

Low dose gamma irradiation does not affect the quality,proximate or nutritional profile of ‘Brigitta’ blueberry and ‘Maravilla’ raspberry fruit

Blueberry (Northern Highbush, cv ‘Brigitta’) and raspberry (cv ‘Maravilla’) fruit were subject to low dose gamma irradiation (0, 150, 400 and 1000 Gy) and stored at 0 °C for three or ten days (blueberry) and two or seven days (raspberry) to determine the effects of irradiation on fruit quality and nutritional and proximate contents. In general, none of the irradiation doses (≤1000 Gy) significantly affected blueberry or raspberry fruit quality (overall fruit quality, colour, firmness, weight loss, TSS, TA levels or TSS/TA ratio), or the nutritional or proximate content (ash, carbohydrate, dietary fibre, energy, moisture, protein, sodium, potassium, total sugars, fructose, ascorbic acid, monomeric anthocyanin, citric and malic acids). The length of time in storage affected some fruit quality and nutritional and proximate content parameters (such as overall fruit quality, firmness, weight loss, TA levels, dietary fibre, potassium, ascorbic acid, citric and malic acids), with longer storage periods resulting in lower quality fruit, irrespective of irradiation treatment. No interaction was detected between the effects of irradiation treatment and storage time, indicating that the storage effect was consistent for all irradiation doses on both blueberry and raspberry fruit quality.     

Characterization of ethylene biosynthesis and its regulation during fruit ripening in kiwifruit,Actinidia chinensis ‘Sanuki Gold’

Ethylene biosynthesis in kiwifruit, Actinidia chinensis ‘Sanuki Gold’ was characterized using propylene, an ethylene analog, and 1-methylcyclopropene (1-MCP), an inhibitor of ethylene perception. In fruit harvested between a young stage (66 days after pollination) (DAP) and an early commercial harvesting stage (143 DAP), 2 days of exposure to propylene were sufficient to initiate ethylene biosynthesis while in fruit harvested at commercial harvesting stage (154 DAP), 4 days of propylene treatment were required. This observation suggests that response of ethylene biosynthesis to propylene treatment in kiwifruit declined with fruit maturity. Propylene treatment resulted in up-regulated expression of AC-ACO1, AC-ACO2, AC-SAM1 and AC-SAM2, prior to the induction of AC-ACS1 and ethylene production, confirming that AC-ACS1 is the rate limiting step in ethylene biosynthesis in kiwifruit. Treatment of fruit with more than 5 μL L^?1 of 1-MCP after the induction of ethylene production subsequently suppressed ethylene production and expression of ethylene biosynthesis genes. Treatment of fruit with 1-MCP at harvest followed with propylene treatment delayed the induction of ethylene production and AC-ACS1 expression for 5 days. These observations suggest that in ripening kiwifruit, ethylene biosynthesis is regulated by positive feedback mechanism and that 1-MCP treatment at harvest effectively delays ethylene production by 5 days.     

Applications of salt solutions before and after harvest affect the quality and incidence of postharvest gray mold of ‘Italia’ table grapes

The efficacy of some potassium and calcium based salts, namely potassium sulphate (PS), potassium sorbate (PSo), potassium carbonate (PC), potassium bicarbonate (PB), calcium sulphate (CS), calcium chelate (CCh), calcium chloride (CC) and calcium silicate (CSi) against gray mold of ‘Italia’ table grapes, was evaluated. In in vitro experiments, PSo, PC, PB, and CCh completely inhibited mycelial growth of Botrytis cinerea at 0.25%. Under artificial inoculation, salts at 1% (immersed or sprayed) showed a variable effect against the pathogen. For natural infection, salt solutions (1%, w/v) were applied according to three strategies: (a) spray (one week) before harvest, (b) immersion after harvest, and (c) combined treatments spray and immersion. The decay incidence of gray mold was evaluated after 30 days at 2 ± 1 °C and 90–95% RH, followed by 7 days of shelf-life at 22 ± 2 °C. All tested salts significantly reduced the decay incidence of gray mold as compared to a water control for the three strategies. The percentages of reduction ranged between 77–100, 91–98, and 61–100% for the preharvest treatment, in combined application, and in the postharvest treatment, respectively. PB and PSo were the most effective salts, completely inhibiting development of gray mold when applied before harvest and as a postharvest treatment. The influence of salts on physical and chemical properties of berry quality including total soluble solids, titratable acidity, pH, color index, weight losses and microbiological profiles was also investigated. New strategies are needed with the critical goal of controlling gray mold of grapes with no fungicide residues. Salts applied just before harvest may be an effective way to minimize gray mold during storage.     

Hydrogen ion concentration affects quality retention and modifies the effect of calcium additives on fresh-cut ‘Rocha’ pear

‘Rocha’ pear (Pyrus communis L.) was used as a model system to assess the effect of pH of dipping solutions on quality retention of fresh-cut fruit and its interaction with calcium additives. Pear slices were dipped for 60 s in a buffer solution at pH 3.0, 5.0 or 7.0 and stored at 4.5 °C for 13 days. In other experiments, pear slices were dipped for 60 s in buffer solutions containing 250 mM of calcium ascorbate, lactate, chloride, and propionate, at pH 3.0 or 7.0, and stored at 4.5 °C for 6 days. Browning and softening were more intense in slices dipped in a solution at pH 3.0 than at pH 5.0 or 7.0, but microbial growth was lower in slices treated at pH 3.0. The effect of calcium additives depended on the anion and significant interactions between the effects of calcium salt and pH were observed. Calcium ascorbate was very effective in preserving color and reducing microbial growth irrespective of pH, but enhanced pectin solubilization and tissue softening at pH 3.0. Slices treated with 250 mM calcium propionate or calcium lactate were softer and had higher electrolyte efflux when treated at pH 3.0 than at pH 7.0. Calcium lactate enhanced browning and reduced microbial growth at pH 3.0 but did not affect color or microbial counts at pH 7.0. All calcium treatments enhanced electrolyte leakage. pH of the dipping solution can affect, per se, the quality of fresh-cut fruit. The choice of calcium additives to prevent undesirable changes on visual and sensory quality of cut produce should involve pH ranges that provide the expected benefits.     

The potential for commonly measured at-harvest fruit characteristics to predict chilling susceptibility of ‘Hort16A’ kiwifruit

The propensity for physiological disorders to arise during low temperature storage of kiwifruit is a significant commercial risk. The potential to use fruit characteristics (flesh colour, soluble solids content (SSC), dry matter and firmness) estimated non-destructively at harvest as markers for the susceptibility of ‘Hort16A’ kiwifruit to chilling injury (CI) has been investigated for individual fruit. While the fruit that developed CI during storage were some of the least advanced fruit on each orchard, the flesh colour, SSC, firmness and dry matter of the susceptible fruit differed considerably among orchards, such that there was not a clear minimum or maximum threshold for which fruit did or did not develop CI across all orchards. There was a large ‘orchard factor’ in the susceptibility of fruit to CI that was as important, if not more important, than the flesh colour, SSC, firmness and dry matter values. The ‘orchard factor’ may derive from a combination of environmental conditions and/or orchard management practices, in conjunction with fruit growth and development. Hence it is concluded that a generally applicable at-harvest prediction of ‘Hort16A’ fruit susceptibility to CI is not possible from an at-harvest non-destructive estimation of flesh colour, SSC, firmness and dry matter.     

Investigating the potential of a humidification system to control moisture loss and quality of ‘Crimson Seedless’ table grapes during cold storage

The potential of humidifying cold storage rooms to control moisture loss and quality of table grapes in different package designs was studied. Fruit were stored in cold rooms (−0.33 ± 0.32 °C or −0.12 ± 0.32 °C) with humidifier (95.0% RH) or no humidification (90.3% RH) respectively. Room humidification resulted in a 7.5% and 9.0% increase in RH inside the clamshell and open-top punnets multi-scale packages respectively in comparison to non-humidified storage, while there was no significant change in RH inside the 4.5 kg carry bag multi-packaging. The grapes were assessed for weight loss and SO₂ injury at intervals during a 35 d period. After 21 d of cold storage under humidification, weight loss of grapes was significantly higher (P < 0.05) in packages with open-top punnets than clamshell punnets and carry-bags. After 35 days in non-humidified cold storage, grape weight losses were 1.45 ± 0.32%, 1.62 ± 0.21% and 2.01 ± 0.57% for the 4.5 kg carry-bag, 5 kg clamshell punnet and 5 kg open-top multi-packages, respectively. When fruit were stored inside the same types of multi-packages under humidification, the corresponding weight losses were 0.97 ± 0.34%, 1.08 ± 0.27% and 2.00 ± 0.57%. Cold storage humidification reduced the rate of stem dehydration and browning; however, it increased the incidence of SO₂ injury in table grape bunches and caused wetting of the packages.     

Extending the shelf life of fresh-cut eggplant with a soy protein–cysteine based edible coating and modified atmosphere packaging

The effect of a soy protein-based edible coating with antioxidant activity, and conventional and superatmospheric modified atmosphere (MA) packaging, on the quality of fresh-cut ‘Telma’ eggplants, was evaluated during storage. In a first experiment, eggplant pieces were dipped in either a coating composed of soy protein isolate (SPI) and 0.5% cysteine (Cys), or water as an uncoated control. Samples were packed in trays under atmospheric conditions to reach a passive MA (MA-P) or two gas mixtures (MA-A: 15 kPa CO₂ + 5 kPa O₂; MA-B: 80 kPa O₂) and were stored at 5 °C. Atmospheric conditions were used as the control conditions (Control). The coated samples packed under MA-B and Control conditions resulted in the highest whiteness index (WI) values during storage, whereas MA-A did not improve the shelf-life of minimally processed eggplants and had the lowest WI values. The MA-B and atmospheric control conditions helped to maintain firmness, whereas the coating helped to maintain the weight loss under MA-A and MA-B. The maximum commercial shelf-life was reached on day 6 for the coated samples packed under atmospheric conditions. In a second experiment, the commercial shelf-life of fresh-cut eggplants was extended to 8 and 9 storage days by increasing the Cys content in the edible coating from 0.5 to 1% under MA-B and Control storage conditions, respectively.     

Effects of cold storage and shelf-life on sensory quality and consumer acceptance of ‘Abate Fetel’ pears

Fruit products certified by quality labels should guarantee high levels of consumer acceptance, despite the unavoidable variability arising from growing conditions and postharvest responses. The quality of ‘Abate Fetel’ pear (Pyrus communis L.) fruit was studied, after short or long cold storage, by analysis of physicochemical, texture and flavour traits, to investigate factors affecting consumer acceptance. Fruit from three orchards differing in location and design, monitored during 10 d of ripening at 20 °C, softened progressively to reach and exceed firmness adequate for consumption. Change in colour, in particular hue angle, paralleled softening. Sensory traits were investigated by evaluating fruit of three different firmness levels within the range of acceptable eating quality. Firmness differences were clearly perceived both by expert judges and by consumers, but did not influence the degree of liking. ‘Abate Fetel’ pear can maintain acceptable eating quality at 20 °C for 4–8 d after 13 weeks storage at ?1 °C, or 2–6 d after 23 weeks storage at ?1 °C. Changing texture parameters were perceived at eating, without compromising overall quality. Production system affected intrinsic quality parameters such as total soluble solids concentration, but did not influence consumer acceptance. In consumer tests conducted after 13 weeks of cold storage, high scores were recorded, with a 86% acceptance frequency and more than 40% of scores reflecting “like very much” or “like extremely”. After 23 weeks of cold storage a decrease in degree of liking was observed. The overall value of ‘Abate Fetel IGP Emilia-Romagna’ quality label was confirmed by consumer evaluations. However, the decrease in consumer acceptance after 23 weeks of cold storage indicates that caution should be used in using long storage durations.