Real-time TaqMan polymerase chain reaction detection and quantification of cow DNA in pure water buffalo mozzarella cheese: method validation and its application on commercial samples

Mozzarella cheese obtained from buffalo (Bubalus bubalis) milk is a typical Italian product certificated by means of the European Protected Designation of Origin (PDO). Mozzarella cheese can also be obtained from bovine milk or bovine/buffalo milk mixtures, but in this case, it cannot be sold as PDO product, and its label must report the actual ingredients. However, bovine milk in PDO products was frequently detected in the past, suggesting fraudulent addition or accidental contamination. Several methods based on end-point polymerase chain reaction (PCR) have been profitably applied in a large number of tests to detect the presence of undeclared ingredients, also in dairy products. In the present study we report a real-time PCR method able to quantify bovine milk addition to pure buffalo cheese products. We validated a normalized procedure based on two targets: bovine mitochondrial cytochrome b (cyt b) to detect and quantify the bovine DNA and nuclear growth hormone (GH) gene used as a universal reference marker. With the use of this real-time PCR assay, 64 commercial mozzarella di bufala cheese samples purchased at local supermarkets, dairy shops, or directly from cheese manufacturers were analyzed. The results obtained demonstrate that most of the commercial samples were contaminated with bovine milk. Therefore, this assay could be conveniently employed to carry out routine and accurate controls aimed not only to discourage any fraudulent behavior but also to reduce risks for consumer health.     

Typicality and geographical origin markers of protected origin cheese from The Netherlands revealed by PTR-MS

Volatile fingerprints of 30 cumin cheese samples of artisanal farmers' cheese of Leiden with EU Protected Designation of Origin (PDO) and 29 cumin cheese samples of varying commercial Dutch brands without PDO protection were used to develop authentication models. The headspace concentrations of the volatiles, as measured with high sensitivity proton-transfer mass spectrometry, were subsequently subjected to partial least-squares discriminant analysis (PLS-DA). Farmers' cheese of Leiden showed a distinct volatile profile with 27 and 9 out of the 60 predominant ions showing respectively significantly higher and lower concentrations in the headspace of the cheese in comparison to the other cumin cheeses. The PLS-DA prediction models developed classified in cross-validation 96% of the samples of PDO protected, artisanal farmers' cheese of Leiden correctly, against 100% of commercial cumin cheese samples. The characteristic volatile compounds were tentatively identified by PTR-time-of-flight-MS. A consumer test indicated differences in appreciation, overall flavor intensity, creaminess, and firmness between the two cheese groups. The consumers' appreciation of the cumin cheese tested was not influenced by the presence of a name label or PDO trademark.     

Use of recombinant cyprosin in the manufacture of ewe's milk cheese

A recombinant cyprosin from the cardoon (Cynara cardunculus L.) was assayed and compared with calf rennet in batches of ewes' milk cheese by determining different chemical, biochemical, and microbiological parameters over 4 months of ripening. There were no differences between the two types of coagulants in most chemical parameters, a(w), and pH. Proteolysis was more marked and rapid in cheese containing recombinant cyprosin as coagulant, the soluble nitrogen content of which was significantly higher (p < 0.01) than that of the cheese obtained with animal rennet; at the end of ripening the nonprotein nitrogen of cheese produced with recombinant cyprosin was slightly higher (p > 0.05) as compared with that in cheeses obtained with animal rennet. Microbial counts in the milk used for making cheese were high in most of the groups analyzed. Despite slight differences in counts, the main microbial groups analyzed were similar in cheese produced with both types of coagulants throughout ripening.     

Identification of the production chain of Asiago d'Allevo cheese by nuclear magnetic resonance spectroscopy and principal component analysis

In the present work, a rapid and simple NMR method to discriminate Asiago d'Allevo cheese samples from different production chains is described. A fast and reproducible extraction of the organic fraction was employed. By applying chemometric analysis to NMR data, it is possible to differentiate PDO Asiago cheese produced in alpine farms from that produced in lowland and mountain industrialized factories. PCA of both (1)H and (13)C NMR spectra showed a good separation of alpine farm products from the other ones, whereas the lowland and mountain industrialized cheeses are undistinguishable. The samples were differentiated on the basis of a higher content of unsaturated fatty acids, principally oleic, linoleic, linolenic, and conjugated linoleic acids for the alpine farm cheeses and a higher content of saturated fatty acids for the industrialized products. Conjugated linoleic acid and 1-pentene are also discriminating components.     

Levels of benzo[a]pyrene (BaP) in "mozzarella di bufala campana" cheese smoked according to different procedures

The content of benzo[a]pyrene (BaP), a polycyclic aromatic hydrocarbon, was determined by HPLC-FL in "mozzarella di bufala campana" cheese, a stretched cooked cheese, either experimentally smoked according to traditional procedures, using straw, cardboard, and wood shavings or aromatized with smoke flavoring. The BaP residues, researched also in cheese samples sold at retail, were detected in the rind, in the core, and in the slice (outer and inner parts). In the cheeses experimentally smoked with straw and cardboard the BaP levels, ranging from 0.38 to 2.12 microg kg(-1) and from 0.46 to 2.40 microg kg(-1), respectively, were statistically higher than those of the cheeses smoked with wood shavings and aromatized with liquid smoke (from 0.19 to 0.80 microg kg(-1) and from 0.18 to 0.50 microg kg(-1), respectively). However the cheeses treated with liquid smoke flavor showed a BaP content exceeding the level allowed by the European Union. In the samples sold at retail, smoked with straw, values were lower than those obtained from samples smoked experimentally with the same combustible. This is probably due to different smoking technologies among the several provinces of the Protected Designation of Origin (PDO) area. PDO is a term used to characterize foodstuffs produced and prepared in a given geographical region by the means of a recognized process. A standardization of the traditional smoking procedures and an improvement of liquid smoke purification treatments are recommended for mozzarella cheese.     

Milk excretion of ivermectin and moxidectin in dairy sheep: assessment of drug residues during cheese elaboration and ripening period

Ivermectin (IVM) and moxidectin (MXD) are broad-spectrum endectocide antiparasitic drugs extensively used in food-producing animals. The patterns of IVM and MXD excretion in milk were comparatively characterized following their subcutaneous administration (200 microg.kg(-1) of body weight) to lactating dairy sheep. The relationship between milk excretion and plasma disposition kinetics of both compounds was characterized. A pool of milk collected from all of the animals in each experimental group was used for cheese elaboration. IVM and MXD residual concentrations were assessed during the cheese-making process and ripening period. IVM and MXD concentrations were measured in plasma, milk, and milk product (whey, curd, and cheese) samples using an HPLC-based methodology with fluorescence detection. IVM and MXD were extensively distributed from the bloodstream to the mammary gland, and large quantities, particularly of MXD, were excreted in milk. Residual concentrations of both compounds were recovered in milk up to 30 (IVM) and 35 (MXD) days post-treatment. The total fraction of the administered dose excreted in milk for MXD was significantly higher than that of IVM. During cheese production, the highest residual concentrations of both molecules were measured in the curd. Thirty-four percent of the total drug residue measured in the pooled milk collected from treated sheep was lost during the cheese-making process. The lowest residual concentrations were measured in the whey. IVM and MXD concentrations in the elaborated cheese tended to increase during the ripening period, reaching the highest residual level at 40 days of cheese maturation. The long persistence of milk residual concentrations of MXD and IVM in lactating dairy sheep and the high concentrations found in cheese and other milk-related products should be seriously considered before recommendation of the extralabel use of these antiparasitic drugs in dairy animals.     

Effectiveness of microsatellite DNA markers in checking the identity of protected designation of origin extra virgin olive oil

Collina di Brindisi is an Italian extra virgin olive oil that obtained the mark of protected designation of origin (PDO) according to EC Regulation 2081/92. The varietal requirements of the official production protocol of this oil foresee that this oil is prepared from cultivar Ogliarola (minimum 70%) and other Olea europaea L. cultivars that are diffused in the production area, accounting for a maximum of 30%. The aim of this work was to verify the effectiveness of microsatellite analysis in verifying the identity of Collina di Brindisi PDO olive oil. A preliminary assessment of product's quality by means of chemical analyses was also carried out. Microsatellite analysis clarified that the generic name Ogliarola, indicated in the technical sheet of this PDO oil, actually corresponded to the Ogliarola salentina cultivar. Furthermore, the obtained results showed that the examination of a limited number of DNA microsatellites enables the identification of the Ogliarola salentina cultivar in this PDO oil.     

Mathematical method for the prediction of retention times of fatty acid methyl esters in temperature-programmed capillary gas chromatography

An accurate method for identification of fatty acids in complex mixtures analyzed by temperature-programmed capillary gas chromatography is described. The method is based on a mathematical approach using regression curves obtained by plotting the relative retention times of fatty acid methyl esters (FAMEs) analyzed in isothermal and gradient temperature conditions. The method was applied to a complex biological sample (human milk), and it was possible to identify 64 fatty acids, including branched-chain and other fatty acids for which reference standards were not readily available. The identities of the majority of the peaks were confirmed by mass spectrometry. The relative residuals and the relative differences between estimated and measured relative retention times of individual FAMEs varied from 0.03 to 3.15% and from 0.0 to 2.9%, respectively. The method is useful for identification of fatty acids in routine analysis.     

Factors affecting the retention of rennet in cheese curd

The coagulant retained in cheese curd is a major contributor to proteolysis during ripening. The objective of this study was to quantify the effects of several milk-related factors and parameters during cheese manufacture on the retention of coagulant in cheese curd. The amount of coagulant retained in curd was determined by its activity on a synthetic heptapeptide (Pro-Thr-Glu-Phe-[NO2-Phe]-Arg-Leu) using reversed-phase HPLC. The retention of chymosin in cheese curd increased significantly when the pH of milk was reduced at rennet addition below pH 6.1, the pH at whey drainage below pH 5.7, or the average casein micelle size in milk and when the ionic strength of milk was increased. The casein content of milk and the quantity of chymosin added to milk had no significant effect on the retention of chymosin in curd; the quantity of coagulant bound per gram of casein remained unchanged.     

Implementation of acrylamide mitigation strategies on industrial production of French fries: challenges and pitfalls

This study evaluated various additives or process aids on the industrial production of French fries, based on their acrylamide mitigation potential and other quality parameters. The application of acetic and citric acid, calcium lactate and asparaginase was investigated on the production of frozen par-fried French fries at the beginning and end of the 2008 and 2009 potato storage season. Despite the fact that some of these treatments significantly reduced acrylamide content of the final product in preliminary laboratory experiments, their application on the industrial production of French fries did not result in additional acrylamide reductions compared to the standard product. Asparaginase was additionally tested in a production line of chilled French fries (not par-fried). Since for this product a longer enzyme-substrate contact time is allowed, a total asparagine depletion was observed for the enzyme treated fries after four days of cold storage. French fries upon final frying presented acrylamide contents below the limit of detection (12.5 μg kg?1) with no effects on the sensorial properties of the final product.     

Comparison of the amounts of volatile compounds in French protected designation of origin virgin olive oils

Headspace solid-phase microextraction (HS-SPME) -gas chromatography using flame ionization detection and multivariate analysis were applied to the study of the specificity of protected designation of origin (PDO) virgin olive oils produced in a southern French region (Alpes-Maritimes) based on their volatile compounds. A total of 35 PDO olive oils from Nice, 6 commercial oils, and 12 other French PDO olive oils were analyzed. Recorded data were subjected to principal component analysis (PCA) and soft independent modeling of class analogy (SIMCA). The method developed here was able to perfectly distinguish different qualities of olive oils. Representative samples from each class obtained by chemometric treatment were analyzed by HS-SPME and GC-MS. PCA and SIMCA of chromatographic data were related to sensory analysis and led to a better understanding of the chemical features and observed sensory effects of olive oils.     

Verification of silage type using near-infrared spectroscopy combined with multivariate analysis

The ability to authenticate the feed given to animals has become a major challenge in animal production, where the diet fed to the animal is one of the most important production factors affecting the composition of milk and meat from cattle, sheep, and goats. Hence, there is currently an increased consumer demand for information on herbivore production factors and particularly the animal diet. The aim of this study was to evaluate the reliability and accuracy of near-infrared (NIR) reflectance spectroscopy as a tool to verify and authenticate the type of silage used as fed for ruminants. Grain silage (GrS, n = 94), grass and legume silage (GLegS, n = 121), and sunflower silage (SunS, n = 50) samples were collected from commercial farms and analyzed in the visible and NIR regions (400-2500 nm) in a monochromator instrument in reflectance. Principal component analysis (PCA), partial least-squares discriminant analysis (PLS1-DA), and linear discriminant analysis (LDA) models were used as methods to verify the different silage types. The classification models based on the NIR data correctly classified more than 90% of the silage samples according to their type. The results from this study showed that NIR spectra combined with multivariate analysis could be used as a tool to objectively authenticate silage samples used as a feed for ruminants.     

The viscoelastic properties of processed cheeses depend on their thermal history and fat polymorphism

Both the composition and the thermal kinetics that are applied to processed cheeses can affect their texture. This study investigated the effect of the storage conditions and thermal history on the viscoelastic properties of processed cheese and the physical properties of the fat phase. The microstructure of processed cheese has been characterized. Using a combination of physical techniques such as rheometry, differential scanning calorimetry, and X-ray diffraction, the partial crystallization of fat and the polymorphism of triacylglycerols (TG; main constituents of milk fat) were related to changes in the elastic modulus and tan δ as a function of temperature. In the small emulsion droplets (<1 μm) dispersed in processed cheeses, the solid fat phase was studied at a molecular level and showed differences as a function of the thermal history. Storage of processed cheese at 4 °C and its equilibration at 25 °C lead to partial crystallization of the fat phase, with the formation of a β' 2 L (40.9 ?) structure; on cooling at 2 °C min(-1), the formation of an α 3 L (65.8 ?) structure was characterized. The cooling of processed cheese from 60 to -10 °C leads to the formation of a single type of crystal: α 3 L (72 ?). Structural reorganizations of the solid fat phase characterized on heating allowed the interpretation of the elastic modulus evolution of processed cheese. This study evidenced polymorphism of TG in a complex food product such as processed cheese and allowed a better understanding of the viscoelastic properties as a function of the thermal history.     

Plasmin system and microbial proteases in milk: characteristics,roles, and relationship

Proteolysis of milk proteins can be attributed to both native proteases and the proteases produced by psychrotrophic bacteria during storage of fresh raw milk. These proteases cause beneficial or detrimental changes, depending on the specific milk product. Plasmin, the major native protease in milk, is important for cheese ripening. Milk storage and cheese-making conditions can affect the level of plasmin in the casein and whey fractions of milk. A microbial protease from a psychrotrophic microorganism can indirectly increase plasmin levels in the casein curd. This relationship between the plasmin system and microbial proteases in milk provides a means to control levels of plasmin to benefit the quality of dairy products. This paper is a short review of both the plasmin system and microbial proteases, focusing on their characteristics and relationship and how the quality of dairy products is affected by their proteolysis of milk proteins.     

Chemical and Microbiological Soil Characteristics under Conventional and Organic Coffee Production Systems

The objective of this study was to evaluate the effect of Conilon coffee (Coffea canephora) cultivated under conventional and organic management systems on the chemical and microbiological characteristics of the soil, as compared to an Atlantic forest. Chemical soil properties, microbial biomass carbon (MBC), microbial biomass nitrogen (MBN), microbial activity (MA), and metabolic quotient (qCO2) were determined at depths of 0–10 cm and 10–20 cm in two seasons (summer and winter). Although microbiological attributes varied according to the season and soil depth, MBC provided 54.15% of relative contribution to distinguish the treatments, followed by MBN and MA. Results indicate that the cultivation of coffee under organic management is more sustainable than under conventional system. Carbon from microbial biomass was the most important soil microbiological attribute in the clustering of the different management methods. Atlantic forest soil followed by organic coffee cultivation soil showed the best soil-quality indices.     

Effect of processing and storage on the stability of flaxseed lignan added to dairy products

This study investigated the effects of processing and storage on the stability of purified, flaxseed-derived secoisolariciresinol diglucoside (SDG) added to milk prior to the manufacture of different dairy products. We analyzed the effect of high-temperature pasteurization, fermentation, and milk renneting as well as storage on the stability of SDG added to milk, yogurt, and cheese. Also, the stability of SDG in whey-based drinks was studied. Added SDG was found to withstand the studied processes well. In edam cheese manufacture, most of the added SDG was retained in the whey fraction and 6% was found in the cheese curd. SDG was also relatively stable in edam cheese during ripening of 6 weeks at 9 degrees C and in yogurt during storage of 21 days at 4 degrees C. Up to 25% of added SDG was lost in whey-based drinks during storage of 6 months at 8 degrees C. We conclude that SDG can be successfully supplemented in dairy-based products.     

A bayesian model for the analysis of lactation curves of dairy goats

This article aims to determine the effect of certain covariates, such as season of kidding, parity, and time of kidding on the characteristics of the lactation curve of Saanen dairy goats. Characteristics investigated are peak milk yield, time of peak milk yield, total milk production, persistency, and the relationship between fat and protein in milk composition, as well as between lactation curves of the same animal in successive years. The analysis is carried out using a hierarchical Bayesian approach, together with Wood’s model, to model lactation. Posterior distributions of quantities of interest are obtained by means of the Markov chain Monte Carlo (MCMC) methods. These clearly illustrate the significant effect of especially parity, but also season and time of kidding on the characteristics of the lactation curve. Total and peak milk yield increase with increasing parity up to about the third or fourth parity, while peak yield is later for first than for later parities. The analysis also enables estimation of lactation characteristics of untested animals, prediction of future characteristics and identification of exceptional animals.     

Detection of pH 4.6 insoluble beta-lactoglobulin in heat-treated milk and Mozzarella cheese

Different protein aggregates including beta-lactoglobulin (beta lg) were detected in the pH 4.6 insoluble fraction recovered from actual heat-treated milk samples by gel electrophoresis and immunoblotting. A competitive enzyme-linked immunosorbent assay (ELISA) using anti-beta lg polyclonal antibodies was developed to analyze the beta lg partition in the protein fractions obtained upon acidification of both milk and Mozzarella cheese at pH 4.6. According to ELISA determinations, nearly 90% of the pH 4.6 soluble beta lg included in raw milk was found in the pH 4.6 insoluble fraction of ultrahigh temperature (UHT)-treated milk. As concerns Mozzarella cheese analysis, ELISA results indicated that about 36% of the total beta lg milk content was transferred from pasteurized milk to Mozzarella cheese, whereas less than 0.5% was transferred from raw milk. The pH 4.6 insoluble beta lg proved to be a suitable indicator of the intensity of the heat treatment applied to milk. The ELISA-based detection of this parameter was suggested for quality control of both drinking milk and raw milk cheese.     

Characterization of effects of a long-term wastewater irrigation on soil quality by microbiological and biochemical parameters

Investigations were conducted to evaluate the effects of long-term (up to 100 years) wastewater irrigation on the selected microbiological and biochemical characteristics of a Cambisol and a Haplic Luvisol. The developments of soil oligotrophic and copiotrophic bacteria (including actinomycetes), the total microbial biomass (ATP content), and acitivity of enzymes catalyzing major substrate transformations in soil (β-glucosidase, β-acetyl-glucosaminidase, proteinase, phosphatase) indicated significantly differences between wastewater treated and non-irrigated soil sites. The increases of the individual indices under the effect of wastewater irrigation show that remarkable differences in the microbiological and biochemical parameters of soil quality remained detectable also 20 years after the soil treatment was terminated.