Degradation of HMW Glutenins During Wheat Sourdough Fermentations

Bakeries use sourdoughs to improve bread properties such as flavor and shelf life. The degradation of gluten proteins during fermentation may, however, crucially alter the gluten network formation. We observed changes that occurred in the HMW glutenins during wheat sourdough fermentations. As fermentation starters, we used either rye sourdough or pure cultures of lactobacilli and yeast. In addition, we incubated wheat flour (WF) in the presence of antibiotics under different pH conditions. The proteolytic activities of cereal and sourdough‐derived proteinases were studied with edestin and casein. During sourdough fermentations, most of the highly polymerized HMW glutenins degraded. A new area of alcohol‐soluble proteins (≈30.000 MW) appeared as a result of the proteolytic breakdown of gluten proteins. Very similar changes were observable as WF was incubated in the presence of antibiotics at pH 3.7. Cereal and sourdough‐derived proteinases hydrolyzed edestin at pH 3.5 but showed no activity at pH 5.5. An aspartic proteinase inhibitor (pepstatin A) arrested 88–100% of the activities of sourdough enzymes. According to these results, the most active proteinases in wheat sourdoughs were the cereal aspartic proteinases. Acidic conditions present in sourdoughs create an ideal environment for cereal aspartic proteinases to be active against gluten proteins.     

Moderate decrease of pH by sourdough fermentation is sufficient to reduce phytate content of whole wheat flour through endogenous phytase activity

Whole wheat bread is an important source of minerals but also contains considerable amounts of phytic acid, which is known to impair their absorption. An in vitro trial was performed to assess the effect of a moderate drop of the dough pH (around 5.5) by way of sourdough fermentation or by exogenous organic acid addition on phytate hydrolysis. It was shown that a slight acidification of the dough (pH 5.5) with either sourdough or lactic acid addition allowed a significant phytate breakdown (70% of the initial flour content compared to 40% without any leavening agent or acidification). This result highlights the predominance of wheat phytase activity over sourdough microflora phytase activity during moderate sourdough fermentation and shows that a slight drop of the pH (pH value around 5.5) is sufficient to reduce significantly the phytate content of a wholemeal flour. Mg "bioaccessibility"of whole wheat dough was improved by direct solubilization of the cation and by phytate hydrolysis.     

Sucrose metabolism and exopolysaccharide production in wheat and rye sourdoughs by Lactobacillus sanfranciscensis.

The exopolysaccharide (EPS) produced from sucrose by Lactobacillus sanfranciscensis LTH2590 is predominantly composed of fructose. EPS production during sourdough fermentation has the potential to affect rheological properties of the dough as well as the volume, texture, and keepability of bread. Its in situ production by L. sanfranciscensis LTH2590 was demonstrated during sourdough fermentation after the hydrolysis of water soluble polysaccharides. In wheat and rye doughs with sucrose addition the concentration of fructose in the hydrolysate of polysaccharides was significantly higher than that in the hydrolysate of control doughs or doughs without sucrose addition. EPS production by L. sanfranciscensis in wheat doughs was confirmed by the determination of delta (13)C values of water soluble polysaccharides after the addition of naturally labeled sucrose, originating from C(3)- and C(4)-plants. In rye doughs, evidence for EPS production with the isotope technique could be demonstrated only by the determination of delta (13)C values of fructose from water soluble polysaccharides. In addition to EPS formation from sucrose, sucrose hydrolysis by L. sanfranciscensis in wheat and rye sourdoughs resulted in an increase of mannitol and acetate concentrations and in accumulation of glucose. It was furthermore observed that flour arabinoxylans were solublized during the fermentation.     

Gluten hydrolysis and depolymerization during sourdough fermentation

Hydrolysis and depolymerization of gluten proteins during sourdough fermentation were determined. Neutral and acidified doughs in which microbial growth and metabolism were inhibited were used as controls to take into account the proteolytic activity of cereal enzymes. Doughs were characterized with respect to cell counts, pH, and amino nitrogen concentrations as well as the quantity and size distribution of SDS-soluble proteins. Furthermore, sequential extractions of proteins and analysis by HPLC and SDS-PAGE were carried out. Sourdough fermentation resulted in a solubilization and depolymerization of the gluten macropolymer. This depolymerization of gluten proteins was also observed in acid aseptic doughs, but not in neutral aseptic doughs. Hydrolysis of glutenins and occurrence of hydrolysis products upon sourdough fermentation were observed by electrophoretic analysis. Comparison of sourdoughs with acid control doughs demonstrated that glutenin hydrolysis and gluten depolymerization in sourdough were mainly caused by pH-dependent activation of cereal enzymes.     

Endogenous Action of Cysteine Endopeptidase and Three Carboxypeptidases on Triticale Prolamins

Quantitative and qualitative changes occurring in the prolamin fraction in the starchy endosperm of triticale grains were analyzed by SDS‐PAGE on consecutive days of germination. The most intensive hydrolysis of prolamins was observed after the second day of the process. The high molecular weight fractions of prolamins were degraded with the highest rate. Endopeptidase EP8 was capable of hydrolyzing all fractions of prolamins isolated from dry triticale grains, but the high molecular weight fractions were the most rapidly degraded by the enzyme. Carboxypeptidases I, II, and III isolated from triticale grains hydrolyzed prolamins proteolytically modified by endopeptidase EP8, whereas intact prolamins were degraded slightly. Differences in the activity of the studied carboxypeptidases against crude prolamins indicate that carboxypeptidase II may be involved in the initiation of the hydrolysis process and, together with carboxypeptidases I and III, participates in the later stages of degradation of prolamins to amino acids. Experiments with exogenous GA₃ demonstrated that the synthesis of EP8 is induced by this hormone and takes place in the aleurone layer. Mass spectrometry analysis showed the enzyme to be a homologue of barley endopeptidase EP‐A. Both enzymes belong to the cysteine class endopeptidases.     

Prolonged fermentation of whole wheat sourdough reduces phytate level and increases soluble magnesium

This work was designed to compare the effects of different leavens (yeast, sourdough, and a mixture of both) on phytic acid (PA) degradation and to assess the repercussions of PA breakdown on phosphorus and magnesium solubility during bread-making. Sourdough fermentation was more efficient than yeast fermentation in reducing the phytate content in whole wheat bread (-62 and -38%, respectively). Furthermore, lactic acid bacteria present in sourdough enhanced acidification, leading to increased magnesium and phosphorus solubility. To intensify phytate breakdown, bran was incubated with microorganisms (yeast or sourdough) before bread-making. Using this new method, the percentage of phytate breakdown was near 90%, whereas 40% of phytate remained in traditional French bread. In conclusion, a prolonged fermentation with sourdough still leads to improved Mg and P solubility by decreasing phytate content and through acidification.     

Influence of thiol metabolism of lactobacilli on egg white proteins in wheat sourdoughs

In wheat sourdoughs, the degradation of gluten proteins is favored by acidification and reducing conditions. This study aimed to determine the proteolytic degradation of egg white proteins in wheat sourdoughs acidified with lactobacilli differing in their thiol metabolism. Ovotransferrin was the only major egg white protein that degraded during sourdough fermentations. An extensive degradation of ovotransferrin required a heterofermentative lactobacilli starter, Lactobacillus sanfranciscensis, with glutathione reductase activity. Ovotransferrin was more resistant to breakdown when sourdoughs were acidified with homofermentative lactobacilli or a mutant strain of L. sanfranciscensis lacking the glutathione reductase. Its susceptibility to proteolysis in L. sanfranciscensis sourdoughs is thus attributable to thiol accumulation by L. sanfranciscensis, which apparently altered the structure of ovotransferrin through a reduction of disulfide bonds. Proteolytic degradation of ovotransferrin was attributable to wheat aspartic proteinases. In addition to the susceptibility to proteolysis, other functional properties of egg proteins may be influenced by thiol-exchange reactions.     

Rheological Changes in Wheat Sourdough During Controlled and Spontaneous Fermentation

The changing rheological characteristics of wheat doughs during fermentation at 30°C for 72 hr were measured using a controlled stress rheometer. Dynamic oscillation tests were performed at frequencies ranging from 0.01 to 10 Hz. Wheat sourdoughs (dough yield 200) were prepared with a mixed starter culture containing typical hetero- and homofermentative sourdough lactic acid bacteria. Results from the controlled fermentation process were compared to results from spontaneous fermentation. Maximum phase angle values, especially at low frequencies, were closely related to total gas production in the doughs. Complex viscosity decreased during fermentation and reached lower final values for doughs without starter culture. Heating characteristics of doughs after various fermentation times were measured at temperatures ranging from 30 to 80°C. The highest values for complex viscosity were found at ≈65°C. When heated, fermented doughs produced weaker gels than fresh doughs. The temperatures at which these maxima occurred increased significantly with fermentation time for spontaneously fermented dough.     

Effects of milling and baking technologies on levels of deoxynivalenol and its masked form deoxynivalenol-3-glucoside

The co-occurrence of the major Fusarium mycotoxin deoxynivalenol (DON) and its conjugate deoxynivalenol-3-glucoside (DON-3-Glc) has been documented in infected wheat. This study reports on the fate of this masked DON within milling and baking technologies for the first time and compares its levels with those of the free parent toxin. The fractionation of DON-3-Glc and DON in milling fractions was similar, tested white flours contained only approximately 60% of their content in unprocessed wheat grains. No substantial changes of both target analytes occurred during the dough preparation process, i.e. kneading, fermentation, and proofing. However, when bakery improvers enzymes mixtures were employed as a dough ingredient, a distinct increase up to 145% of conjugated DON-3-Glc occurred in fermented dough. Some decrease of both DON-3-Glc and DON (10 and 13%, respectively, compared to fermented dough) took place during baking. Thermal degradation products of DON, namely norDON A, B, C, D, and DON-lactone were detected in roasted wheat samples and baked bread samples by means of UPLC-Orbitrap MS. Moreover, thermal degradation products derived from DON-3-Glc were detected and tentatively identified in heat-treated contaminated wheat and bread based on accurate mass measurement performed under the ultrahigh mass resolving power. These products, originating from DON-3-Glc through de-epoxidation and other structural changes in the seskviterpene cycle, were named norDON-3-Glc A, B, C, D, and DON-3-Glc-lactone analogically to DON degradation products. Most of these compounds were located in the crust of experimental breads.     

Modification of IgE binding to beta-lactoglobulin by fermentation and proteolysis of cow's milk

The effect of fermentation by Lactobacilli and of proteolytic hydrolysis of whole milk on the IgE binding ability of beta-lactoglobulin was studied using an ELISA inhibition assay. Sera from nine adult milk allergic patients were tested. The individual sera showed a similar inhibition pattern in the changes during fermentation and proteolysis. The degradation of beta-lactoglobulin was studied with liquid chromatography. In general, fermentation with Lactobacilli gave little effect on IgE binding, even though chromatography data showed a gradual degradation of beta-lactoglobulin. Proteolysis with trypsin, however, gave extensive degradation of beta-lactoglobulin and strongly decreased IgE binding. In addition, we measured the inhibition pattern of beta-lactoglobulin in various selected commercially available fermented milk products. These showed an IgE binding capacity similar to that of nonfermented high pasteurized milk.     

Synthesis of angiotensin I-converting enzyme (ACE)-inhibitory peptides and gamma-aminobutyric acid (GABA) during sourdough fermentation by selected lactic acid bacteria

This article aimed at investigating the synthesis of angiotensin I-converting enzyme (ACE)-inhibitory peptides and gamma-aminobutyric acid (GABA) during sourdough fermentation of white wheat, wholemeal wheat, and rye flours. Sourdough lactic acid bacteria, selected previously for proteinase and peptidase activities toward wheat proteins or for the capacity of synthesizing GABA, were used. The highest ACE-inhibitory activity was found by fermenting flour under semiliquid conditions (dough yield 330) and, especially, by using wholemeal wheat flour. Fourteen peptides, not previously reported as ACE-inhibitory, were identified from the water/salt-soluble extract of wholemeal wheat sourdough (IC 50 0.19-0.54 mg/mL). The major part of the identified peptides contained the well-known antihypertensive epitope VAP. The synthesis of GABA increased when the dough yield was decreased to 160. The highest synthesis of GABA (258.71 mg/kg) was found in wholemeal wheat sourdough.     

Oat Bran Fermentation by Rye Sourdough

Hydration of oat bran including fermentation by rye sourdough was studied. Three types of oat bran suspensions were prepared (a control, one with whole meal rye flour added, and one with rye starter added). The suspensions were incubated for 1, 2, 3 and 4 hr. β‐Glucan content and solubilities of protein and β‐glucan were analyzed. Viscosity of the supernatants of oat bran suspensions was determined. Neither the rye sourdough nor the rye flour alone had a significant effect on the total β‐glucan content of oat bran suspensions. However, the addition of rye, either as whole meal rye flour or as sourdough starter, markedly increased the solubility of β‐glucan and proteins and simultaneously decreased the viscosity of the water‐soluble fraction of oat bran suspension. This suggests that a hydrolysis of β‐glucan had occurred that could change the rheological properties of oat bran in baking and the physiological potential of oat bran in nutrition.     

Influence of baking conditions and precursor supplementation on the amounts of the antioxidant pronyl-L-lysine in bakery products

The influence of baking conditions and dough supplements on the amounts of the antioxidant and Phase II-Enzyme modulating, protein-bound 2,4-dihydroxy-2,5-dimethyl-1-(5-acetamino-5-methoxycarbonyl-pentyl)-3-oxo-2H-pyrrol (pronyl-L-lysine) in bakery products was investigated in quantitative studies. These studies revealed high amounts of the antioxidant in bread crust, only low amounts in the crumb, and the absence of this compound in untreated flour. The amounts of pronyl-L-lysine were found to be strongly influenced by the intensity of the thermal treatment. For example, increasing the baking time from 70 to 210 min or increasing the baking temperature from 220 to 260 degrees C led to a 5- or 3-fold increase in the concentrations of this antioxidant in the crust, respectively. In addition, modifications in the recipe showed to have a major impact on pronyl-L-lysine formation. For example, substituting 5% of the flour with the lysine-rich protein casein or with 10% of glucose increased the amounts of the antioxidant by more than 200%. Quantitative analyses of commercial bread samples collected from German bakeries revealed the highest amount of 43 mg/kg for a full grain bread, followed by a rye/wheat bread, both of which have been sourdough fermented. A mixed-grain bread as well as pale wheat bread, both prepared without sourdough fermentation, contained significantly lower amounts of pronyl-L-lysine, and German pretzels, which are treated with a dilute sodium hydroxide solution prior to baking, contained only trace amounts of pronyl-L-lysine (e.g., less than 5 mg/kg were detectable in pretzels). Systematic studies revealed that the decrease of the pH value induced by microbial acid formation during sourdough fermentation is the clue for producing high amounts of pronyl-L-lysine in baking products. These data clearly demonstrate for the first time that the amounts of the antioxidant and chemopreventive compound pronyl-L-lysine in bakery products is strongly dependent on the manufacturing conditions as well as the recipe.     

Effects of Fermentation and Baking of Whole Wheat and Whole Rye Sourdough Breads on Cereal Alkylresorcinols

Alkylresorcinol (AR) content was determined in multiple-stage whole wheat and whole rye flour sours, as well as in whole wheat and whole rye flour doughs and breads. AR content decreased considerably during fermentation and baking. AR content was reduced by 20 and 46%, respectively, at the end of sourdough starter fermentation of whole wheat and whole rye flour sours. AR content, which was 512 and 210 μg/g in whole rye and whole wheat flour doughs, respectively, was 30 and 0 μg/g, respectively, after baking of breads. Synthetic AR added at different levels to doughs was also greatly reduced during fermentation and baking.     

Influence and Interactions of Processing Conditions and Starter Culture on Formation of Acids,Volatile Compounds,and Amino Acids in Wheat Sourdoughs

The aim of this work was to study the influence of process parameters and the starter culture on the characteristics of wheat sourdough by using response surface methodology. Influence of fermentation temperature (16–32°C), ash content of flour (0.6–1.8%), and fermentation time (6–20 hr) were considered as independent factors and their effects were studied in sourdough fermented with Lactobacillus plantarum, L. brevis, Saccharomyces cerevisiae, or with a combination of yeast and lactic acid bacteria. Formation of acidity, free amino acids, and volatile compounds were considered the main responses. A possibility to enhance formation of potential flavor compounds and precursors without excessive acidity formation in wheat sourdoughs was established. The total amount of amino acids increased by 25–50%, depending on the strain and fermentation conditions. The total amount of volatile compounds increased seven‐ to 100‐fold, depending on the strain and fermentation conditions. Sourdough started with S. cerevisiae was an effective way to optimize the amount of volatile compounds without excessive acidity formation in appropriate processing conditions. Ash content of flour and fermentation time were the most significant factors to modify metabolic activity of wheat sourdoughs. Frequent interactions between the studied factors were observed on the formation of acidity, amino acids, and volatile compounds with most of the strains studied. Possibility to improve current industrial fermentation processes and control flavor attributes of breads by using optimized sourdough was established.     

Gluten-free sorghum bread improved by sourdough fermentation: biochemical, rheological, and microstructural background

This study was conducted to improve the quality and theoretical understanding of gluten-free sorghum bread. The addition of 2% hydroxypropyl methylcellulose improved bread based on 105% water, 70% sorghum flour, and 30% potato starch. Nevertheless, a flat top and tendency toward a hole in the crumb remained. Sourdough fermentation of the total sorghum flour eliminated these problems. Size-exclusion high-performance liquid chromatography demonstrated that during sourdough fermentation, proteins from the dough liquid were degraded to peptides smaller than kafirin monomers (<19 kDa). Laser scanning confocal microscopy showed aggregated protein in bread crumb without sourdough fermentation, whereas with sourdough fermentation, only small isolated patches of protein bodies embedded in matrix protein remained. In oscillatory temperature sweeps, sourdough fermentation caused a significantly higher resistance to deformation (|G*|) after gelatinization of the above batter relative to batters without sourdough. Results suggest that a strong starch gel, without interference of aggregated protein, is desirable for this type of bread.     

Developments in the Science of Zein,Kafirin, and Gluten Protein Bioplastic Materials

Despite much research, there are very few commercial prolamin bioplastics. The major reason, apart from their high cost, is that they have inferior functional properties compared with synthetic polymer plastics. The inferior functional properties are because the prolamins are complex, each consisting of several classes and subclasses, and the functional properties of their bioplastics are greatly affected by water. Prolamin bioplastics are produced by controlled protein aggregation from a solvent or by thermoplastic processing. Recent research indicates that aggregation occurs by polypeptide self‐assembly into nanostructures. Protein secondary structure in terms of α‐helical and β‐sheet structure seems to play a key but incompletely understood role in assembly. Also, there is inadequate knowledge as to how these nanostructures further assemble and organize into the various forms of prolamin bioplastics such as films, fibers, microparticles, and scaffolds. Many methods have been investigated to improve prolamin bioplastic functionality, including better solvation of the prolamins, plasticization, physical and chemical cross‐linking, derivatization, and blending with synthetic and natural polymers, and some success has been achieved. The most promising area of commercialization is the biomedical field, in which the relative hydrophilicity, compatibility, and biodegradability of, particularly, zein and kafirin are advantageous. With regard to biomedical applications, “supramolecular design” of prolamin bioplastics through control over inter‐ and intramolecular weak interactions and disulfide/sulfhydryl interchange appears to have considerable potential.     

Liquid laccase production by Phomopsis liquidambari B3 accelerated phenolic acids degradation in long-term cropping soil of peanut

The accumulation of phenolic acids in soil is one of the main problems associated with continuous cropping of peanut. Although laccases secreted by fungi can efficiently transform phenolic acids, there are few reports on the use of these enzymes to bioremediate continuous cropping soil. Food waste and wheat straw are waste products; however, they could be used productively as resources for laccase production by the endophytic fungus Phomopsis liquidambari B3. We cultured Phomopsis liquidambari B3 in medium containing food waste as the main nitrogen source and wheat straw as the main carbon source. In order to study the effects of fermentation liquid on phenolic acid degradation, rhizosphere soil microbial communities and peanut seedling growth, the fermentation product, which had high laccase activity, was added to continuously cropped soil of peanut. The concentration of 4-hydroxybenzoic acid, vanillic acid, and coumaric acid in soil had decreased by 57.4, 52.5, and 49.4%, respectively, compared with no-treatment control during 28 days. Analysis of denaturing gradient gel electrophoresis profiles showed that the bacterial and fungal community structures in rhizosphere soil were affected by changes in the phenolic acids concentration. The biomass of peanut plants and the number of root nodules were increased 68.3% and 5.9-fold, respectively. These results showed that the laccase product reduced the accumulation of phenolic acids in soil, the decrease in phenolic acids concentration and the increase in certain dominant microorganisms promoted peanut seedling growth and nodulation. This technology provides a new strategy for bioremediation of continuous cropping soil, while simultaneously reducing waste and protecting the environment.     

Effect of Baking Method and Fermentation on Folate Content of Rye and Wheat Breads

The effect of baking method on folates of rye and wheat breads, as well as the effect of sourdough fermentation of rye, were examined. Sourdough fermentations were performed both with and without added yeast, and samples were taken throughout the baking process. Samples were analyzed microbiologically for their total folate content after trienzyme extraction. Individual folate vitamers were determined by HPLC after affinity chromatographic purification. The lowest folate contents for both rye and wheat breads were found from breads baked without added yeast. Total folate content increased considerably during sourdough fermentation due to increased amounts of 10‐HCO‐H₂folate, 5‐CH₃‐H₄folate, and 5‐HCO‐H₄folate. Baker's yeast contributed markedly to the final folate content of bread by synthesizing folates during fermentation. Proofing did not influence total folate content but changes in vitamer distribution were observed. Folate losses in baking were ≈25%. The variety of sourdoughs and baking processes obviously lead to great variation in folate content of rye breads. The possibilities to enhance natural folate content of rye bread by improving folate retention in technological processes and by screening and combining suitable yeasts and lactic acid bacteria should be further investigated.     

Biotechnological production of vitamin B2-enriched bread and pasta

Lactic acid bacteria (LAB) were obtained from durum wheat flour samples and screened for roseoflavin-resistant variants to isolate natural riboflavin-overproducing strains. Two riboflavin-overproducing strains of Lactobacillus plantarum isolated as described above were used for the preparation of bread (by means of sourdough fermentation) and pasta (using a prefermentation step) to enhance their vitamin B2 content. Pasta was produced from a monovarietal semolina obtained from the durum wheat cultivar PR22D89 and, for experimental purposes, from a commercial remilled semolina. Several samples were collected during the pasta-making process (dough, extruded, dried, and cooked pasta) and tested for their riboflavin content by a high-performance liquid chromatography method. The applied approaches resulted in a considerable increase of vitamin B2 content (about 2- and 3-fold increases in pasta and bread, respectively), thus representing a convenient and efficient food-grade biotechnological application for the production of vitamin B2-enriched bread and pasta. This methodology may be extended to a wide range of cereal-based foods, feed, and beverages. Additionally, this work exemplifies the production of a functional food by a novel biotechnological exploitation of LAB in pasta-making.