Effect of high molecular weight glutenins and rye translocations on soft wheat flour cookie quality

The influence of high molecular weight glutenin subunits (HMW-GS) on wheat breadmaking quality has been extensively studied but the effect of different Glu-1 alleles on cookie quality is still poorly understood. This study was conducted to analyze the effect of HMW-GS composition and wheat-rye translocations on physicochemical flour properties and cookie quality of soft wheat flours. Alleles encoded at Glu-A1, Glu-B1 and Glu-D1 locus had a significant effect over physicochemical flour properties and solvent retention capacity (SRC) profile. The null allele for Glu-A1 locus presented the highest cookie factor observed (CF = 7.10), whereas 1BL/1RS and 1AL/1RS rye translocations had a negative influence on CF. The three cultivars that showed the highest CF (19, 44 and 47) had the following combination: Glu-A1 = null, Glu-B1 = 7 + 8, Glu-D1 = 2 + 12 and no secalins. Two prediction equations were developed to estimate soft wheat CF: one using the HMW-GS composition and the other using physicochemical flour parameters, where SRCsuc, SRC carb, water-soluble pentosans, damaged starch and protein turned out to be better CF predictors. This data suggests that grain protein allelic composition and physicochemical flour properties can be useful tools in breeding programs to select soft wheat of good cookie making quality.     

Influence of allelic prolamin variation and localities on durum wheat quality

Thirty-seven varieties of a Mediterranean durum wheat collection grown in Tunisia and Spain were analysed for their allelic composition in prolamins, as well as their protein concentration, sodium dodecyl sulphate sedimentation (SDSS) test and mixograph parameters. Genotype was a greater source of variation in all measurements than locality. Uncommon high and low molecular glutenin subunits (HMW-GS and LMW-GS) were found (V and 2•• subunits at Glu-A1, 13 + 16 at Glu-B1, 5* subunit and ax allele at Glu-A3). The rare combinations 2 + 4+14 + 18 and 8 + 9+13 + 16+18 subunits at the Glu-B3 locus were found. Glu-A3ax had a positive influence on SDSS and mixograph parameters. Of all the prolamins, those that have the B-LMW-GS composition aaa (for Glu-A3, Glu-B3 and Glu-B2 loci, respectively), when associated with the Glu-A1c and Glu-B1d gave the best semolina quality. By contrast, semolina quality is poor when this same composition is associated with the Glu-A1c and Glu-B1e and even poorer when associated with the Glu-A1c and Glu-B1f. In addition, the cultivars with B-LMW-GS allelic composition aab (for Glu-A3, Glu-B3 and Glu-B2 loci, respectively), when associated with the Glu-A1c and Glu-B1d, gave high quality, whereas when associated with the Glu-A1c and Glu-B1e or with Glu-A1o and Glu-B1f, the quality was very poor.     

Effect of allelic variation at the Glu-3/Gli-1 loci on breadmaking quality parameters in hexaploid wheat (Triticum aestivum L.)

Low molecular weight glutenin subunits (LMW-GS) encoded by the Glu-3 loci are known to contribute to wheat breadmaking quality. However, the specific effect of individual Glu-3 alleles is not well understood due to their complex protein banding patterns in SDS-PAGE and tight linkage with gliadins at the Gli-1 locus. Using DNA markers and a backcross program, we developed a set of nine near isogenic lines (NILs) including different Glu-A3/Gli-A1 or Glu-B3/Gli-B1 alleles in the genetic background of the Argentine variety ProINTA Imperial. The nine NILs and the control were evaluated in three different field trials in Argentina. Significant genotype-by-environment interactions were detected for most quality parameters indicating that the effects of the Glu-3/Gli-1 alleles are modulated by environmental differences. None of the NILs showed differences in total flour protein content, but relative changes in the abundance of particular classes of proteins cannot be ruled out. On average, the Glu-A3f, Glu-B3b, Glu-B3g and Glu-B3i_Man alleles were associated with the highest values in gluten strength-related parameters, while Glu-A3e, Glu-B3a and Glu-B3i_Chu were consistently associated with weak gluten and low quality values. The value of different Glu-3/Gli-1 allele combinations to improve breadmaking quality is discussed.     

Molecular characterization of storage proteins for selected durum wheat varieties grown in different environments

The variations of the amounts of individual high molecular weight glutenin subunits (HMW-GS), of the ratios HMW-GSy to HMW-GSx and HMW-GS to low molecular weight glutenin subunits (LMW-GS) and of protein content were evaluated for eight durum wheat cultivars in two regions using four fertilizer combinations during two successive years. All measured parameters showed significant variation with genotypes (G), environments (E) and fertilizers (F). The interaction E × G × F was highly significant for glutenin amount variation. Amongst cultivars possessing HMW-GS 20, landraces seem to better value the N-fertilizer use for the accumulation of HMW-GSy than high yielding cultivars. Both HMW-GSy to HMW-GSx and HMW-GS to LMW-GS ratios were found to be positively correlated (p < 0.05) with total protein content.     

Formulating low glycaemic index rice flour to be used as a functional ingredient

Amylose and resistant starch (RS) content in rice flour were manipulated. The experiment was conducted using a full factorial design. Rice flour with average amylose content of 20 and RS content of 0.5 g/100 g dry sample was fortified with pure amylose from potato and high RS modified starch to reach the final amylose content of 30, 40 and 50 and RS content of 2, 4 and 6 g/100 g dry sample. The fortified rice flours were examined for their gelatinisation properties, in-vitro enzymatic starch digestion and gel textural properties. It was found that amylose and RS significantly affect all the fortified rice flour properties (p < 0.05). High amylose and RS improved starch digestion properties, reducing the rate of starch digestion and lowering the glycaemic index (GI) values. Amylose had a more pronounced effect on the fortified rice starch properties than RS. In this study, the fortified rice flour which contained amylose and RS of approximately 74 and 9 g/100 g dry sample respectively was used to produce rice noodles. The noodles exhibited low GI values (GI < 55). However, amylose and RS affected the textures of rice noodles providing low tensile strength and break distance (extensibility).     

High frequency of abnormal high molecular weight glutenin alleles in Chinese wheat landraces of the Yangtze-River region

A total of 485 common landraces of bread wheat were collected from the Yangtze-River region of China. Their high molecular weight glutenin subunit (HMW-GS) composition was analyzed by Matrix-assisted laser desorption/ionization time-of-flight Mass Spectrometry (MALDI-TOF-MS). Among all landraces tested, 453 were homogeneous for HMW-GS, 32 were heterogeneous, and 37 contained abnormal subunits. A total of 22 alleles were detected, including 3 at Glu-A1, 13 at Glu-B1 and 6 at Glu-D1, respectively. Higher variations occurred at the Glu-B1 locus compared with Glu-A1 and Glu-D1. Glu-A1c (74.0%), Glu-B1b (40.4%), Glu-D1a (84.9%) appeared to be the most frequent alleles at Glu-A1, Glu-B1 and Glu-D1, respectively. Two alleles ("null" and 1) at the Glu-A1 locus, three allele compositions (7 + 8, 7OE + 8, 7 + 9) at the Glu-B1 locus, and two (2 + 12 and 5 + 10) at the Glu-D1 locus appeared to be the common types in the 485 landraces. Sixteen new alleles represented by abnormal subunits were identified at the Glu-B1 and the Glu-D1 locus.     

Effects of post-anthesis fertilizer on the protein composition of the gluten polymer in a US bread wheat

Both genetic and environmental factors influence the types and amounts of wheat proteins that link together to form polymers essential for flour quality. To understand how plant growth conditions might influence gluten polymer formation, protein fractions containing small and large polymers were separated from flour from the US wheat Butte 86 grown in the absence or presence of post-anthesis fertilizer. Proteins in the polymer fractions were analyzed by quantitative two-dimensional gel electrophoresis (2-DE). The ratio of high molecular weight glutenin subunits (HMW-GS) to low molecular weight glutenin subunits (LMW-GS) increased in both fractions in response to fertilizer, due in part to small increases in the proportions of individual HMW-GS. There were also changes within the LMW-GS. In particular, omega and alpha chain terminators increased in proportion in both polymer fractions, but changes were more pronounced in the large polymer fractions. Serpins also increased in both polymer fractions. Additionally, the study revealed differences in the proportions of traditional LMW-GS in small and large polymer fractions. LMW-s type proteins were more abundant in the large polymers while LMW-i type proteins were more prevalent in the small polymers, suggesting that these proteins may play different roles in the gluten polymer.     

Effects of selected extrusion parameters on physicochemical properties and in vitro starch digestibility and β-glucan extractability of whole grain oats

Whole grain oat flour was extruded under different moisture contents (15%, 18%, 21%), barrel temperatures (100 °C, 130 °C), and screw speeds (160 rpm, 300 rpm, 450 rpm), and selected physicochemical properties, in vitro starch digestibility, and β-glucan extractability of the extrudates were analyzed. An increase in screw speed resulted in an increase in radial expansion index, water absorption index, and water solubility index. Screw speed significantly affected slowly and rapidly digestible starch. Moderate screw speed (300 rpm) led to higher slowly digestible starch with an accompanying decrease in rapidly digestible starch. Low moisture conditions (15%) resulted in the highest resistant starch and water-extractable β-glucan. Under the conditions used in this study, extrusion did not result in changes in water-extractable β-glucan molecular weight. Thus, extrusion might be beneficial in improving functionality and consumer acceptability by affecting physicochemical properties, in vitro starch digestibility, and β-glucan extractability of oat extrudates.     

Effect of wheat germ flour addition on wheat flour,dough and Chinese steamed bread properties

Wheat germ flour (WGF) has been developed as a functional food ingredient with high nutritional value. In this study, WGF was applied in steamed bread-making in order to improve the quality of Chinese steamed bread (CSB). Partial substitution of wheat flour with WGF at levels of 3%, 6%, 9% and 12% (w/w) was carried out to investigate physicochemical properties of blends and their steaming performance. Falling number (FN) values of composite flours ranged from 199 to 223 s. Viscosity analysis results showed that wheat flour mixed with WGF had higher pasting temperature and lower viscosities. Dough rheological properties were also investigated using farinograph and extensograph. The addition of WGF diluted the gluten protein in dough and formed weak and inextensible dough, which can be studied by scanning electron microscope (SEM) analysis. CSB made with WGF had significantly lower volume, specific volume and higher spread ratio. The sensory acceptability and physicochemical quality of CSB were improved with the application of a low level of WGF (3% and 6%). However, results showed that a high level of WGF over 9% is not recommended because of unsatisfactory taste. As a whole, addition of appropriate level of WGF in wheat flour could improve the quality of CSB.     

The molecular structure features-immune stimulatory activity of arabinoxylans derived from the pentosan faction of wheat flour

Recently, the immune stimulation properties of cereal arabinoxylans (AX) have been reported. The aims of this study were to identify the molecular features and potential immune stimulation activities of AX and enzymatic modified arabinoxylan (AXE) from the pentosan fraction of wheat flour.The results of molecular characterization of AX and AXE show that AXE contains a larger portion (85.7%) of low Mw arabinoxylans (≤25 kDa) and has a higher degree of branch substitution (0.81 ± 0.01) compared to AX (49.5% and 0.62 ± 0.02). In in vitro testing, the ability of AX and AXE to stimulate immune cells, as measured by NO₂⁻ production by U937 cells and IL-8 secretion by Caco-2 cells were found to be dose–dependent in the range tested (100–5000 μg/mL p ≤ 0.05). AXE showed a greater activity at each concentration (100–5000 μg/mML) than AX (p ≤ 0.05).In conclusion, the greater immune stimulating activity of AXE may be associated with its low Mw (≤25 kDa) and a higher degree of branch substitution (0.81 ± 0.01).     

Puroindoline genes introduced into durum wheat reduce milling energy and change milling behavior similar to soft common wheats

Grain physical characteristics and milling behavior of a durum wheat line in which both wild-type puroindoline genes were translocated and stabilized after backcrossing (Svevo-Pin) were compared with the parent line (Svevo). The only observed differences between grain characteristics were the mechanical resistance and starchy endosperm porosity revealed through vitreosity measurement. A significant increase of flour and a decrease of semolina yield and break milling energy were observed from Svevo-Pin in comparison with the non-recombinant parent line in accordance to the lower grain mechanical resistance and higher porosity measurements. Moreover, the particle size distribution shown for Svevo-Pin flour appeared consistent with a lower adhesion between starch granules and the protein matrix attributed to the presence of wild-type puroindolines. Coarse bran yield was conversely increased. This appeared to be due to a lower starchy endosperm recovery as a higher proportion of grain starch was found in this bran fraction. Flour from the durum parent line was inversely enriched in phytic acid, a cellular marker of the aleurone layer. Starch damage was also lower in Svevo-Pin flours in comparison with Svevo. All of the observed differences between translocation and parent lines were confirmed independent of the culture growth conditions (n = 12).     

Characterisation of starch during germination and seedling development of a rice mutant with a high content of resistant starch

To acquire a better understanding of whether RS influences the dynamics of in vivo starch digestion and seed vigour, the high-RS rice mutant RS4 (RS ca. 10%) and the wild type R7954 were used to investigate total amylase activity, seedling vigour, starch content and starch granule structure during germination. RS4 exhibited similar seed vigour to R7954. Amylose and amylopectin in R7954 showed synchronous degradation throughout the whole process, while amylopectin was hydrolysed significantly faster than amylose in RS4 during the earlier germination stages. The starch residues of RS4 after germination (GD) lost endotherm peaks and showed a special X-ray diffraction pattern with only two peaks at around 16.90° and 21.62°, probably due to remnants of amylopectin and its tight crosslinking with the cell wall. The remaining starch after 10 GD, primarily amylopectin may make a critical contribution to total resistant starch content. These results indicated that RS had no negative impact on seed vigour in rice lines, although RS cannot be hydrolysed by α-amylase from human and animal in vitro. By appropriately increasing the special amylopectin fraction, a new breeding programme of high RS crops and improvement in the eating quality of high RS rice varieties might be achieved.     

Thermal degradation kinetics of bioactive compounds from black rice flour (Oryza sativa L.) extracts

The effect of thermal processing on the degradation of the phytochemicals in black rice flour by means of fluorescence spectroscopy and degradation kinetics was investigated. In order to investigate the influence of food matrices, a comparative analysis between integral rice flour and different fractions was performed. The preliminary compositional results suggested a higher content in phytochemicals in fraction four of the seven fractions of black rice flour, which was sifting through a sieve with a diameter of 180 μm. The compositional complexity was highlighted by fluorescence spectroscopy. The heat-treatment caused structural changes that led to red- or blue-shifts in maximum emission. The first-order kinetic model was used to describe the mechanism of degradation. The activation energies were 10.07 ± 1.04 kJ/mol for total polyphenolic, 7.26 ± 0.58 kJ/mol for total monomeric anthocyanins and 6.71 ± 1.12 kJ/mol for antioxidant activity in case of integral flour extract. For fraction four extract obtained by, the E_a values were: 3.51 ± 0.53 kJ/mol, 11.49 ± 1.47 kJ/mol, 15.80 ± 1.50 kJ/mol and 19.91 ± 3.27 kJ/mol, respectively. The calculated values of the activation energy revealed higher temperature dependence of total polyphenols in integral flour and of antioxidant activity in fraction four, respectively.     

In vitro starch digestibility and predicted glycaemic indexes of buckwheat,oat, quinoa,sorghum, teff and commercial gluten-free bread

The in vitro starch digestibility of five gluten-free breads (from buckwheat, oat, quinoa, sorghum or teff flour) was analysed using a multi-enzyme dialysis system. Hydrolysis indexes (HI) and predicted glycaemic indexes (pGI) were calculated from the area under the curve (AUC; g RSR/100g TAC*min) of reducing sugars released (RSR), and related to that of white wheat bread. Total available carbohydrates (TAC; mg/4 g bread “as eaten”) were highest in sorghum (1634 mg) and oat bread (1384 mg). The AUC was highest for quinoa (3260 g RSR), followed by buckwheat (2377 g RSR) and teff bread (2026 g RSR). Quinoa bread showed highest predicted GI (95). GIs of buckwheat (GI 80), teff (74), sorghum (72) and oat (71) breads were significantly lower. Significantly higher gelatinization temperatures in teff (71 °C) and sorghum flour (69 °C) as determined by differential scanning calorimetry (DSC) correlated with lower pGIs (74 and 72). Larger granule diameters in oat (3–10 μm) and sorghum (6–18 μm) in comparison to quinoa (1.3 μm) and buckwheat flour (3–7 μm) as assessed with scanning electron microscopy resulted in lower specific surface area of starch granules. The data is in agreement with predictions that smaller starch granules result in a higher GI.     

Effects of particle size on the quality attributes of reconstituted whole-wheat flour and tortillas made from it

The objective of this study was to examine the effects of whole-wheat flour (WWF) particle size on the quality attributes of WWF tortillas. WWF samples of different particle size distributions from commercial U.S. hard white (median diameters: 175.7, 128.6, 120.0, 108.5 and 102.4 μm), hard red winter (median diameters: 173.7, 133.6, 124.3, 110.8 and 104.2 μm) and hard red spring (median diameters: 173.7, 132.1, 124.7, 112.9, 106.3 μm) wheat classes were obtained by fine grinding of bran and shorts and re-combining with the rest of fractions. For all three wheat classes, as WWF median particle size decreased, the L* (lightness) value decreased but the adjusted damaged starch, polyphenol oxidase activity, and a* and b* values increased. Mixolab data showed that development time decreased as WWF particle size was reduced, while stability time and starch retrogradation increased. As for WWF tortilla quality, the breaking force and extensibility increased with decreasing particle size from ∼175 to 129–134 μm, but diameter and thickness were not significantly affected. The results indicated that reducing the median particle sizes of WWFs from ∼175 μm to ∼130 μm would significantly improve the WWF tortilla quality.     

Predicted truly absorbed protein supply to dairy cattle from hulless barley (Hordeum vulgare L.) with altered carbohydrate traits with multi-year samples

Hulless barley breeding lines varying in amylose (1–20% DM) and β-glucan content (5–10% DM) have been developed at the Crop Development Centre, Canada. The objectives of this large-scale study were to 1) determine and confirm the effect of these new hulless barley lines (zero-amylose waxy, CDC Fibar; 5%-amylose waxy, CDC Rattan; normal-amylose, CDC McGwire and high-amylose, HB08302) with altered carbohydrate traits on 1) metabolic characteristics of protein; 2) intestinal digestion of various nutrients and 3) modeling nutrient supply from these barley varieties by using NRC Dairy 2001 model and DVE/OEB system. CDC Copeland was included as a hulled barley control. Among the hulless barley lines, CDC Fibar contained the highest and CDC McGwire contained the lowest total digestible protein (TDP: 147 vs. 116 g/kg DM). HB08302 was greater (P < 0.05) in intestinal digestible protein (IDP: 40.6% RUP) but relatively lower (P < 0.05) in total digestible protein (TDP: 120 g/kg DM). Compared with hulless barley, hulled barley showed relatively lower (P < 0.05) intestinal digestible protein (38 vs. 53 g/kg DM) and total digestible protein (102 vs. 129 g/kg DM). In modeling nutrient supply from the DVE/OEB system, the results showed hulled barley was lower (P < 0.01) in true protein supplied to the small intestine (TPSI: 127 vs. 142 g/kg DM), lower in truly absorbed rumen bypassed feed protein in small intestine (ABCP^DVE: 43 vs. 58 g/kg DM), lower in truly absorbed protein in the small intestine (DVE: 95 vs. 111 g/kg DM), and lower in degraded protein balance (OEB^DVE: −39 vs. −23 g/kg DM) than the hulless barley lines but greater (P < 0.01) in undigested inorganic matter (9 g/kg DM). From NRC Dairy 2001 model, CDC Fibar was greater (P < 0.05) in degraded protein balance (OEB^NRC: −30 g/kg DM) and metabolizable protein (MP: 118 g/kg DM) than the other hulless barley lines, while hulled barley was relatively lower (P < 0.01) in total metabolizable protein (MP: 83 vs. 105 g/kg DM). Our correlation results suggested that TDP was negatively correlated to amylose (r = −0.85, P < 0.001) but positively correlated to β-glucan level (r = 0.74, P < 0.001) in hulless barley cultivars. The DVE and OEB^DVE as well as MP were negatively correlated (P < 0.05) to amylose level but positively correlated to β-glucan level (P < 0.05). In conclusion, altered carbohydrate traits in the hulless barley varieties have the potential to increase intestinal nutrient availability to ruminants and significantly improved the truly absorbed protein supply to dairy cattle compared to hulled barley. Hulless barley with lower amylose and higher β-glucan level could provide greater (P < 0.05) truly digested protein in the small intestine, better synchronized available energy and N and increase metabolizable protein supply to ruminants.     

Alkylresorcinol composition allows the differentiation of Triticum spp. having different degrees of ploidy

Total alkylresorcinol (AR) content and homologue composition were assessed in whole grain flours of 15 varieties each of bread wheat, durum, spelt, emmer, and einkorn grown in four different environments. Bread wheat (761 ± 92 μg/g DM) and spelt (743 ± 57 μg/g) belonging to the hexaploid species showed higher AR concentrations than the tetraploid durum (654 ± 48 μg/g, p < 0.05), while the concentrations found in the diploid einkorn (737 ± 91 μg/g) and the tetraploid emmer (697 ± 94 μg/g) did not significantly differ from the other species. The AR content showed a remarkable heritability and, thus, seemed to be mainly determined by genetic factors. If ARs were assumed to be deposited within a specific AR-rich layer of the kernel, AR levels of all varieties would easily surpass their minimal inhibitory concentrations against fungal pathogens within this barrier layer. Although the AR carrying a C21:0 side chain was the main homologue in all species, the levels of all AR homologues and their relative composition significantly differed between hexaploid (bread wheat and spelt), tetraploid (durum and emmer) and diploid (einkorn) species. Consequently, a clear-cut differentiation of Triticum species and derived whole grain flours according to their degrees of ploidy was established based on concentrations of saturated C₁₇-, C₁₉-, C₂₁-, C₂₃-, and C₂₅-substituted ARs.     

The role of sensitivity to abscisic acid and gibberellin in pre-maturity α-amylase formation in wheat grains

To study the role of abscisic acid (ABA) and gibberellin (GA) sensitivity in regulating pre-maturity α-amylase (PMA) in wheat grains, plants were grown in a glasshouse under cold-shock and ambient conditions. α-amylase activity in response to applied ABA and GA was measured in detached-grains with the embryo removed (in vitro) and in intact-grains attached to the plant (in situ). The in vitro experiment was conducted using Spark (low PMA-susceptible genotype) and Rialto (highly PMA-susceptible genotype), with the aim of defining the time point for GA-sensitivity. The results showed an increase in GA-sensitivity at about 640 degree days after anthesis (DAA) in Rialto. There was no evidence for a change in ABA-sensitivity in either variety. The in situ experiments were conducted using genotypes from a Spark × Rialto doubled haploid population segregating for the Rht-D1a (tall) or Rht-D1b allele and for the presence or absence of 1BS/1RS. For Rht-D1a (tall) or Rht-D1b genotypes with or without 1BS/1RS, the cold-shock significantly increased GA-sensitivity, whereas there was no significant change in ABA-sensitivity. These results show PMA is related to an increase in GA-sensitivity that occurs in the aleurone at around 640 degree DAA, and can be enhanced by environmental factors (e.g. cold-shock).     

Quinoa (Chenopodium quinoa Willd.) protein hydrolysates with in vitro dipeptidyl peptidase IV (DPP-IV) inhibitory and antioxidant properties

The potential of quinoa to act as a source of dipeptidyl peptidase IV (DPP-IV) inhibitory and antioxidant peptides was studied. A quinoa protein isolate (QPI) with a purity of 40.73 ± 0.90% was prepared. The QPI was hydrolysed at 50 °C for 3 h with two enzyme preparations: papain (P) and a microbial papain-like enzyme (PL) to yield quinoa protein hydrolysates (QPHs). The hydrolysates were evaluated for their DPP-IV inhibitory and oxygen radical absorbance capacity (ORAC) activities. Protein hydrolysis was observed in the QPI control, possibly due to the activity of quinoa endogenous proteinases. The QPI control had significantly higher DPP-IV half maximal inhibitory concentrations (IC₅₀) and lower ORAC values than QPH-P and QPH-PL (P < 0.05). Both QPH-P and QPH-PL had similar DPP-IV IC₅₀ and ORAC values. QPH-P had a DPP-IV IC₅₀ value of 0.88 ± 0.05 mg mL⁻¹ and an ORAC activity of 501.60 ± 77.34 μmol Trolox equivalent (T.E.) g⁻¹. To our understanding, this is the first study demonstrating the in vitro DPP-IV inhibitory properties of quinoa protein hydrolysates. QPHs may have potential as functional ingredients with serum glucose lowering properties.