Storage of small bale silage and haylage – influence of storage period on fermentation variables and microbial composition

An experiment investigating changes in fermentation variables and microbial composition during storage of small‐bale silage and haylage was performed. Haylage was defined as silage with a dry‐matter (DM) content exceeding 500 g kg^?1. Grass was wilted to three different DM contents, and baled into silage (350 g DM kg^?1), haylage with a low DM content (550 g kg^?1) and haylage with high DM content (700 g kg^?1) in small rectangular‐shaped bales (0·80 m × 0·48 m × 0·36 m) that were individually wrapped. Bales were stored for short (2 months) or long (14 months) periods before opening and sampling. Silage had higher concentrations of fermentation products and a lower pH than either of the two haylage types. In general, long‐term storage influenced all fermentation variables except concentrations of butyric acid and succinic acid, and yeast counts were higher after 14 months than 2 months of storage. However, silage changed in more fermentation variables during storage than the two haylage types. Although differences between short‐ and long‐term stored silage were found, linear correlations between short‐ and long‐term stored bales were present for all chemical variables. Pearson's correlation coefficients were highest for lactic acid, followed by pH.     

Effects of inoculants and wilting on silage fermentation and nutritive characteristics of red clover–grass mixtures

Various management practices (e.g. wilting, application of silage additives or adding a grass component) can be used to improve silage fermentation of pure red clover (Trifolium pratense L.). Therefore, the aim of this laboratory ensiling study was to investigate the effects of varying proportions of red clover and perennial ryegrass (100/0, 66/33, 33/66, 0/100) on silage quality during two consecutive years. In addition, two wilting levels [target dry matter (DM): 300 vs. 400 g kg^?1] in combination with lactic acid bacteria (LAB) additives were tested. Herbage was ensiled, either untreated or inoculated with homofermentative LAB (low wilted) or homo‐ and heterofermentative LAB (high wilted). In most cases, lactic and acetic acid decreased as the proportions of ryegrass were increased. Data concerning ammonia‐N concentrations showed considerable differences between cuts and years. Silages treated with homofermentative LAB generally had high lactic acid and low final pH, whereas acetic acid and 1,2‐propanediol tended to be higher when homo‐ and heterofermentative LAB were applied. Inoculants had a positive effect on DM losses and ammonia‐N in only a few silages. Wilting decreased DM losses and fermentation acids at most cuts, irrespective of the grass/clover ratio in the herbage mixture. There was a strong year effect on the organic matter digestibility (DOM) of the silages. In conclusion, the optimal strategy for successful silage fermentation of red clover is the ensiling in mixtures with ryegrass. Furthermore, herbage should be wilted to a DM content of about 300–350 g kg^?1. The application of LAB inoculants did not alter the DOM but did improve silage fermentation.     

Alpha‐tocopherol and β‐carotene in legume–grass mixtures as influenced by wilting,ensiling and type of silage additive

Effects of wilting, ensiling and type of additive on α‐tocopherol and β‐carotene contents in legume–grass mixtures were examined. Swards of birdsfoot trefoil + timothy (Bft + Ti), red clover + timothy (Rc + Ti) and red clover + meadow fescue (Rc + Mf) were harvested as a first regrowth in August 2005. Forage was wilted to a dry‐matter (DM) content of 273 g kg^?1 and ensiled without additive or with an inoculant or acid. Wilting decreased α‐tocopherol concentration by 30% in the Bft + Ti mixture (P = 0·015). Untreated Bft + Ti silage had higher α‐tocopherol content than red clover silages (56·9 vs. 34·2 mg kg^?1 DM; P = 0·015). The α‐tocopherol concentration of Bft + Ti forages increased during ensiling from 41·1 mg kg^?1 DM in wilted herbage to 56·9, 65·2 and 56·8 mg kg^?1 DM in untreated, inoculated and acid‐treated silage respectively (P = 0·015). The inoculant increased α‐tocopherol content in the red clover silages (50·1 vs. 34·2 mg kg^?1 DM; P = 0·015) compared with untreated red clover silages. Red clover mixtures had lower β‐carotene content than Bft + Ti (32·3 vs. 46·2 mg kg^?1 DM; P = 0·016), averaged over treatments. In conclusion, wilting had small effects but the use of bacterial inoculant as an additive and a Bft + Ti mixture increased α‐tocopherol concentration in the silage.     

Changes in the distribution of nitrogen and plant enzymatic activity during ensilage of lucerne treated with different additives

Effects of formic acid, formaldehyde and two levels of tannic acid on changes in the distribution of nitrogen (N) and plant enzymatic activity during ensilage of lucerne (Medicago sativa) were studied. Lucerne [300 g dry matter (DM) kg^?1 forage] silages were prepared untreated (control) and with formic acid (4 g kg^?1 DM), formaldehyde (1 g kg^?1 DM) and two levels of tannic acid (20 and 50 g kg^?1 DM) as additives. Inhibition of proteolysis by formic acid was more effective than the other additives during the first 7 d of ensiling. Tannic acid was as effective at inhibiting production of non‐protein‐N, ammonia‐N and free amino acid‐N as formic acid and formaldehyde. However, increased concentrations of non‐protein‐N and free amino acid‐N in silage from day 1 to 35 of ensiling were less with the higher level of tannic acid than that in the control and other additive‐treated silages. Carboxypeptidase lost its activity slowly with increasing time of ensiling. At day 2, it still had 0·79 of the original activity in the control silage. After 21 d of ensiling, high levels of carboxypeptidase activity, proportionately 0·41, 0·49, 0·10, 0·35 and 0·30 of the original activity, remained in the control silage, and silages made with formic acid, formaldehyde, and low and high levels of tannic acid respectively. There were higher levels of activity of acid proteinase in formic acid‐treated silage than in the control silage until day 2 of ensilage indicating that the reduction of proteolysis by formic acid was probably due to acidifying the forage below the pH optima of plant protease. Aminopeptidase activity in all silages declined rapidly after ensiling.     

The effect of cell wall degrading enzymes or formic acid on fermentation quality and on digestion of grass silage by cattle

A first cut of timothy, treated with water (untreated), formic acid (FA), cellulase + lactic acid bacteria (CB), cellulase + hemicellulase (CH) or cellulase + hemicellulase + a lignin-modifying enzyme (CHL), was ensiled in pilot-scale silos. Silages, except CB, were fed to four male cattle, each equipped with a rumen and duodenal cannula, in a digestibility trial designed as a 4 × 4 Latin square. The animals were fed a diet of 400 g of concentrate and 600 g of silage at a level of 70 g DM kg^?1 live weight (LW^0·75). All enzyme-treated silages were well-preserved with a more extensive fermentation than in FA silage. The quality of untreated silage was poorer as indicated by higher pH and ammonia-N content. The amount of effluent from enzyme-treated silages ranged from 116 to 127 g kg^?1; for FA and untreated silages values were 101 g kg^?1 and 80 g kg^?1, respectively. Total DM losses from enzyme-treated silages were higher than from FA silage (P < 0·05). No significant differences were noticed between silages in the apparent digestibility of organic matter (OM), neutral-detergent fibre (NDF), acid-detergent fibre (ADF) or nitrogen (N). The apparent digestibility of cellulose was higher with enzyme-treated silages than with FA silage (P < 0·05). The values for microbial N flow at the duodenum were 80·0, 91·9, 80·7 and 70·5g N d^?1, and for the efficiency of rumen microbial N synthesis 38·6, 47·6, 36·9 and 32·5 g N kg^?1 OM apparently digested in the rumen for untreated, FA, CH and CHL silages, respectively. In the rumen the molar proportion of propionate was higher (P < 0·01) and that of butyrate lower (P < 0·01) with enzyme-treated silages when compared with FA silage. The proportion of butyrate was also lower with untreated than with other silages (P < 0·01). The rumen residence time of NDF and ADF was longer (P < 0·05) with enzyme-treated silages than with FA silage.     

Protein supplementation of formic acid- and enzyme-treated silages. 1. Digestibilities, organic matter and fibre digestion

Two silages were made from perennial ryegrass ensiled without wilting in 2-t capacity silos with the application of either formic acid or an enzyme mixture of cellulases and hemicellulases. Effluent losses were monitored over the ensiling period. Subsequent silage analysis showed that the enzyme-treated silage had higher concentrations of residual water soluble carbohydrate, lactic acid and acetic acid, and lower concentrations of cellulose, ADF and NDF. Effluent production was higher with the enzyme silage (formic acid, 211 1 t^?1; enzyme, 2671 t^?1). The silages were either offered as the sole diet or supplemented with rapeseed meal at two levels (60 or 120 g fresh weight kg^?1 silage DM offered) to growing steers equipped with rumen cannulae and T-piece duodenal cannulae. Apparent whole tract digestibilities for DM, OM, N, ADF and NDF were similar for all diets although nitrogen retention (g d^?1) was increased with supplementation of both silages (formic acid, 21·1; formic acid + 60 g, 23·5; formic acid+ 120 g, 28·5; enzyme, 22·6; enzyme + 60 g, 25·8; enzyme+ 120 g, 31·6). Rumen pH, ammonia and total volatile fatty acids patterns were similar. Supplementation increased the amount of organic matter apparently digested in the rumen (ADOMR) with formic acid-treated silage but not with enzyme-treated silage. Liveweight gains were similar for both unsupplemented silages (0·49 kg d^?1). These increased to 0·55 and 0·65 kg d^?1 for formic + 60 and formic + 120 respectively. Liveweight gains for the corresponding enzyme-treated supplemented diets were 0·81 and 0·91 kg d^?1 respectively. Liveweight gains on supplemented enzyme-treated diets were significantly (P < 0·05) greater than those on formic acid-treated diets.     

Yield,nutritive value and silage fermentation of kura clover‐reed canarygrass and lucerne herbages in northern USA

Excellent winter hardiness, persistence and nutritive value of both kura clover (Trifolium ambiguum M. Bieb.) and reed canarygrass (Phalaris arundinacea L.) suggest that intercropping these species could substitute for lucerne (Medicago sativa L.). The dry matter (DM) yield and nutritive value of herbage, and silage characteristics of kura clover‐reed canarygrass (KC‐RCG) herbage, were compared to those of lucerne over two growth cycles near Arlington, WI, USA. First and second growths of lucerne and KC‐RCG herbage were sampled four times at 1‐week intervals and ensiled for 100 d. Yield of DM of the KC‐RCG was 0·23–0·57 greater than that of lucerne on sampling dates in the first growth cycle, with no differences in DM yield in the second growth cycle. The pH of lucerne silage was lower than that of KC‐RCG silage in the first growth, and the opposite occurred in second growth, which was attributed to maturity differences and the proportion of kura clover in the mixture. Lactate concentration was lower in KC‐RCG than lucerne silages in both growth cycles. The lucerne and KC‐RCG silages had similar in vitro DM digestibility except for the final sampling date in the first growth cycle when neutral‐detergent fibre concentration of KC‐RCG herbage exceeded 550 g kg^?1 DM. Crude protein concentration was greater in lucerne silage than in KC‐RCG silage in both growth cycles. Overall, differences in nutritive value and silage fermentation between the two herbages were minimal across growth cycles. These results suggest that a KC‐RCG sward is a viable alternative to lucerne in northern environments of the USA where lucerne production may be limited by winter injury or edaphic factors.     

Effects of the proportions of high or medium digestibility grass silage and concentrates in the diet of beef cattle on liveweight gain, carcass composition and fatty acid composition of muscle

Abstract An experiment was carried out over 2 years to evaluate the effects of increasing the proportion of cereal‐based concentrates in diets containing high‐digestibility and conventional medium‐digestibility grass silages on the dry‐matter (DM) intake, liveweight gain and carcass composition of beef cattle, and to examine the effects of grazed grass and the ratio of grass silage:concentrates in the diet on the fatty acid composition of selected muscle tissues. Late‐maturing steers (n = 231) were offered diets based on high‐digestibility (HD) (0·743 digestible organic matter (DOM) in DM) or medium‐digestibility (MD) (0·643 DOM in DM) grass silages supplemented with barley/soyabean meal‐based concentrates. The concentrates constituted 0·20, 0·40, 0·60 and 0·80 of total DM of the diets, which were offered ad libitum (AL). The two diets, which contained 0·80 concentrates, were also offered at 0·80 of AL intake. A further group of fourteen animals were given the medium‐digestibility silage only for 5 months and then grazed perennial ryegrass pastures for a further 5 months (silage/pasture treatment). For the diets containing HD silage and 0·20, 0·40, 0·60 and 0·80 concentrate, and 0·80 concentrate at 0·8 of AL intake, the DM intakes were 9·4, 10·2, 10·4, 10·2 and 8·1 (s.e. 0·16) kg d^?1, respectively, and daily carcass gains were 0·67, 0·78, 0·77, 0·79 and 0·62 (s.e. 0·029) kg d^?1, respectively; for those containing MD silage and 0·20, 0·40, 0·60 and 0·80 concentrate, and 0·80 concentrate at 0·8 of AL, the DM intakes were 8·2, 9·3, 10·1, 10·1 and 8·0 (s.e. 0·16) kg d^?1, respectively, and daily carcass gains were 0·38, 0·48, 0·64, 0·77 and 0·56 (s.e. 0·029) kg d^?1 respectively. Increasing the proportion of concentrates in silage‐based diets decreased the concentration of omega‐3 (ω‐3) polyunsaturated fatty acids (PUFA) (P < 0·001) and increased the concentration of ω‐6 PUFA (P < 0·001) in muscle. Cattle on the silage/pasture treatment had the highest concentration of ω‐3 PUFA in muscle (51 g kg^?1 lipid), this value being over three times that for animals given diets containing MD silage and 0·80 concentrate in the diet. These results demonstrate the potential of HD silage made from perennial ryegrass relative to high concentrate diets. The consumption of pasture‐finished beef could make a significant contribution towards increasing the intake of ω‐3 PUFA in the human diet.     

Comparison of the performance of dairy cows offered kale,swedes and perennial ryegrass herbage in situ and perennial ryegrass silage fed indoors in late pregnancy during winter in Ireland

The effects on the performance of dairy cows offered kale, swedes, and perennial ryegrass in situ and perennial ryegrass silage fed indoors to dairy cows pre‐partum during winter in Ireland was examined. Eighty‐eight spring‐calving dairy cows were randomly assigned to one of four offered treatments; (i) 8 kg of dry matter (DM) of kale leaf and stem + 4 kg DM of perennial ryegrass silage (treatment K), (ii) 8 kg DM of the root and leaf of swedes + 4 kg DM of perennial ryegrass silage (treatment S), (iii) 12 kg DM of perennial ryegrass herbage (treatment G) offered in situ and (iv) perennial ryegrass silage offered ad libitum indoors (treatment ID). Cows on treatments K, S and ID had a greater (P < 0·001) increase in body condition score (0·20, 0·14 and 0·50 units respectively) pre‐partum than cows on treatment G which lost 0·22 units. Pre‐partum treatment had no effect on variables of milk production in the following lactation. In the first 100 d of lactation, cows on treatment G pre‐partum had a lower milk fat concentration (35·6 g kg^?1) compared with cows on treatments S and ID (38·3 and 39·3 g kg^?1 respectively). There was no effect of treatment on the intervals between parturition and first insemination (mean 74·6 d) and conception (mean 96·1 d). The results suggest that offering kale and swedes to dairy cows pre‐partum resulted in a similar lactation performance to dairy cows grazing a perennial ryegrass sward or offered perennial ryegrass silage indoors.     

Effects of feeding clover silages on feed intake, milk production and digestion in dairy cows

Silages were made from pure crops of perennial ryegrass, red clover and white clover over 2 years. In all but one case the silage was stored as bales. A silage additive specially adapted for bales (Kofasil Ultra^TM) was used for all silages and they were all of good hygienic quality. The additive contained sodium nitrite, hexamethylene, tetraamine sodium bensoate and sodium propionate. The silages were offered ad libitum, either pure or mixed [grass/clover 0·50/0·50 on a dry‐matter (DM) basis] with a fixed amount (8 kg) of concentrate. Two experiments, one in each year, were performed with high‐yielding multiparous dairy cows in mid‐lactation, and both rumen‐cannulated and intact cows were used. The experiments were carried out using an incomplete changeover design with fifteen cows and five treatments each year. The cows consumed large quantities of these silages (12·7–16·3 kg DM per cow per day). The highest intakes were obtained when the red clover and the 0·50 red clover:0·50 perennial ryegrass silage diets were offered. However, there was a difference between years. In year 1, 0·50 red clover:0·50 perennial ryegrass and 0·50 white clover:0·50 perennial ryegrass silage diets showed the highest intakes while pure perennial ryegrass and white clover silage diets gave lower intakes. In year 2 the highest intake of silage was obtained when the diet containing silage from red clover from a second cut was offered, while the silage from red clover from a first cut gave the lowest intake. The voluntary intakes of silages from white clover and perennial ryegrass were intermediate. No cases of bloat or other digestive disturbances were observed. Milk yield was significantly lower for the perennial ryegrass silage diet compared with all other diets in year 1. In year 2 milk yield was highest for the white clover silage diets and lowest for the red clover silage diets from both cuts. In year 1 there were relatively small differences in milk composition while in year 2 milk fat content was significantly lower with white clover silage diet and milk protein content was significantly higher with the perennial ryegrass diet. The overall conclusion from these experiments was that cows were able to consume large quantities of pure legume silage without serious disturbance to their metabolism. Differences in measurements of rumen metabolism were found between diets and especially between years. Milk production differences appears to be coupled to both differences in rumen physical characteristics, such as passage rate and particle size as well as differences in volatile fatty acid production in the rumen.     

Voluntary intake,digestibility and nitrogen utilization by sheep fed ensiled forage legumes

An experiment was conducted to compare the nutritive value of a range of ensiled forage legumes. Silages were prepared from late second‐cut lotus (Lotus corniculatus), first‐cut sainfoin (Onobrychis viciifolia) and both early and late second‐cut red clover (Trifolium pratense) and lucerne (Medicago sativa). Each experimental silage was offered to six Suffolk‐cross wether lambs, aged 10 months, housed in metabolism crates. Voluntary intakes of dry matter ranged from 71 to 81 g kg^?1 liveweight^0·75 d^?1. Voluntary intakes were similar on the lotus, sainfoin and late‐cut red clover silages, but the voluntary intake on the lotus silage was significantly higher than that on the lucerne silages and early‐cut red clover silage. Digestibility of organic matter in the dry matter was highest for the lotus silage (0·650), and lowest for the sainfoin silage (0·527). Although most of the N in the sainfoin silage appeared to be in an indigestible form, N digestibility was approximately 0·70 for the other legume silages. The highest loss of N in urine, 0·75 of N intake, was recorded for lambs offered the lucerne silage. Differences in N intake, N loss in faeces and N loss in urine led to statistically significant differences in the amount of N retained, with the highest and lowest N balances recorded for the lotus (16 g N d^?1) and sainfoin (?2 g N d^?1) silages respectively. The results confirm that these high protein forages have high intake potential. While low N digestibility appears to limit the nutritional value of sainfoin, further research could formulate feeding strategies that improve the efficiency with which the protein from red clover, lucerne and lotus is utilized.     

Effects of feeding different ensiled forages on the productivity and nutrient-use efficiency of finishing lambs

The effects of offering ensiled red clover (Trifolium pratense), lucerne (Medicago sativa), pea (Pisum sativum), kale (Brassica oleracea) and hybrid ryegrass (Lolium hybridicum) on the productivity and nutrient‐use efficiency of lambs were investigated. Forages were cut, wilted for 24 h and ensiled as round bales. A hundred Suffolk‐cross lambs, aged 8 months, were offered grass silage during a 5‐week standardization period and then group‐housed for 14 d and offered ad libitum access to a treatment silage. For the measurement period, lambs were split into four replicate groups of five lambs per treatment. Dry matter intake and live weight were recorded every 7 d over 56 d. The chemical composition of the silages differed for all the variables measured. Lambs offered pea silage had a very low liveweight gain and this treatment was discontinued after 21 d. Lambs offered the other forages had a higher liveweight gain than lambs offered ryegrass silage (P < 0·001). Food conversion and nitrogen‐use efficiency were higher in lambs offered the red clover, lucerne and kale silages compared with those offered ensiled ryegrass (P < 0·001). These findings demonstrate the potential for using ensiled alternative forages rather than ryegrass to increase the productivity and nutrient use efficiency of livestock systems.     

Apparent digestibility and nitrogen utilization of diets based on maize silage harvested at three stages of maturity and fed to steers

Advancing maize crop maturity is associated with changes in ear‐to‐stover ratio which may have consequences for the digestibility of the ensiled crop. The apparent digestibility and nitrogen retention of three diets (Early, Mid and Late) containing maize silages made from maize of advancing harvest date [dry matter (DM) contents of the maize silages were 273, 314 and 367 g kg^?1 for the silages in the Early, Mid and Late diets respectively], together with a protein supplement offered in sufficient quantities to make the diets isonitrogenous, were measured in six Holstein–Friesian steers in an incomplete Latin square design with four periods. Dry‐matter intake of maize silage tended to be least for the Early diet and greatest for the Medium diet (P = 0·182). Apparent digestibility of DM and organic matter did not differ between diets. Apparent digestibility of energy was lowest in the Late diet (P = 0·057) and the metabolizable energy concentrations of the three silages were calculated as 11·0, 11·1 and 10·6 MJ kg^?1 DM for the Early, Medium and Late diets respectively (P = 0·068). No differences were detected between diets in starch digestibility but the number of undamaged grains present in the faeces of animals fed the Late diet was significantly higher than with the Early and Mid diets (P = 0·006). The apparent digestibility of neutral‐detergent fibre of the diets reduced significantly as silage DM content increased (P = 0·012) with a similar trend for the apparent digestibility of acid‐detergent fibre (P = 0·078). Apparent digestibility of nitrogen (N) was similar for the Early and Mid diets, both being greater than the Late diet (P = 0·035). Nitrogen retention did not differ between diets. It was concluded that delaying harvest until the DM content is above 300 g kg^?1 can negatively affect the nutritive value of maize silage in the UK.     

A meta‐analysis comparing standard polyethylene and oxygen barrier film in terms of losses during storage and aerobic stability of silage

A meta‐analysis was undertaken of 51 comparisons of standard polyethylene film with oxygen barrier (OB) film in covering systems for bunker silos, unwalled clamp silos and bales. Mean losses of DM or OM during storage from the top 10 to 60 cm of bunker and clamp silos were 195 g kg^?1 for standard film and 114 g kg^?1 for OB film systems (41 sets of data, P < 0·001), while mean total losses of DM from baled silage were 76·8 g kg^?1 for standard film and 45·6 g kg^?1 for OB film systems (10 sets of data, P < 0·001). Top surface silage judged subjectively to be inedible was 107 and 29·6 g kg^?1 for standard film and OB film systems respectively (5 sets of data, P = 0·02). Aerobic stability was 75 h for silage stored under standard film system and 135 h for silage stored under OB film system (11 sets of data, P = 0·001). It is concluded that the OB film system reduces losses from the outer layers of silos and from bales and increases the aerobic stability of silage in the outer layers of silos.     

Effects of treating low dry-matter grass with a bacterial inoculant on the intake and performance of beef cattle and studies on its mode of action

A randomized block design experiment involving thirty beef cattle (mean initial live weight 462 kg) was carried out to evaluate a bacterial inoculant based on a single strain of Lactobacillus plantarum as a silage additive and to provide further information in relation to its mode of action. Three herbages were harvested on 10 August 1989 using three double-chop forage harvesters from the first regrowth of a perennial ryegrass sward which had received 170 kg N, 25 kg P₂O₅, and 42 kg K₂O ha^?1. They received either no additive (silage C), formic acid at 2·91 (t grass)^?1(silage F) or the inoculant at 3·21 (t grass)^?1 (silage I). Mean dry-matter (DM), water-soluble carbohydrate and crude protein concentrations in the untreated herbages were 158g kg^?1, 88 g (kg DM)^? and 183g (kg DM)^?1 respectively. For silages C, F and I respectively, pH values were 4·01, 3·57 and 3·62; ammonia N concentrations 117, 55 and 77 g (kg total N)^?1; and butyrate concentrations 2·18, 0·50 and l·24g (kg DM)^?1. The silages were offered ad libitum and supplemented with 2·5 kg concentrates per head daily for 77 days. For treatments C, F and I, silage DM intakes were 6·59, 7·25 and 6·80 (s.e. 0·074)kg d^?1; metabolizable energy (ME) intakes 86,99 and 94 (s.e. 0·8) MJ d^?1; liveweight gains 0·90, 0·97 and 1·02(s.e.0·066) kg d^?1; carcass gains 541,656 and 680 (s.e. 34·0) g d^?1. Inoculant treatment increased DM (P < 0·01), organic matter (P < 0·01), crude fibre (P < 0·05), neutral detergent fibre (NDF) (P < 0·05) and energy (P < 0·05) digestibilities, the digestible organic matter concentration (P < 0·01) and the ME concentration (P < 0·05) of the total diets. Additive treatment altered rumen fermentation patterns but had little effect on the rumen degradability of silage DM, modified acid detergent (MAD) fibre, NDF or hemicellulose. It is concluded that treatment with the inoculant improved silage fermentation and increased digestibility, had little effect on silage DM intake but significantly increased carcass gain to a level similar to that sustained by a well-preserved formic acid-treated silage     

Nutritive value of barley/kale bi-crop silage for lactating dairy cows

Six mid‐lactation multiparous Holstein–Friesian dairy cows were used to examine the potential of a fermented whole‐crop barley (Hordeum vulgare)/kale (Brassica oleracea) bi‐crop as a feed compared with a first‐cut perennial ryegrass silage. The barley/kale bi‐crop was grown as a strip intercrop, and was harvested and ensiled as an intimate mixture [0·80 barley and 0·20 kale on a dry‐matter (DM) basis]. Animals were offered ad libitum access to one of three experimental diets in a duplicated Latin Square design experiment: (i) Bi‐crop (the barley/kale bi‐crop); (ii) Grass (the grass silage); and (iii) Mix (a 1:1 fresh mixture of Bi‐crop and Grass). All animals also received a standard dairy concentrate at a rate of 4 kg d^?1 in equal portions at each of two milkings. The Bi‐crop and Grass silages contained 346 and 293 g DM kg^?1, 108 and 168 g crude protein kg^?1 DM, 268 and 36 g starch kg^?1 DM, and had pH values of 3·87 and 3·80 respectively. Animals offered the two bi‐crop silage‐containing diets consumed more forage DM than those offered grass silage (14·6, 14·9 and 12·6 kg DM d^?1 for Bi‐crop, Mix and Grass respectively; s.e.d. 0·45, P < 0·01) and yielded more milk (24·0, 23·9, 22·6 kg d^?1 for Bi‐crop, Mix and Grass respectively; s.e.d. 0·26, P < 0·01). However, differences in the partitioning of dietary nitrogen towards milk protein and away from excretion in urine suggest a more efficient (rumen) utilization of feed protein by animals offered diets containing the bi‐crop silage. It is concluded that, despite having a low crude protein concentration, barley/kale bi‐crop silage offers excellent potential as a feed for lactating dairy cows.     

The effect of additives on the ensilage of forage of differing perennial ryegrass and white clover content

Pure perennial ryegrass or perennial ryegrass/white clover mixtures (70:30 and 40:60 on a fresh-matter basis) were ensiled in laboratory silos either untreated or alter treatment with freshly cultured Lactobacillus (Lb.) plantarun or freshly cultured Lb. plantarum plus Lactococcus (Lc.) lactis. freeze-dried Lb. plantarum or freeze-dried Lb. Plantarum plus sodium formate, sodium formate or formic acid. The effect of these additives on silage fermentation characteristics and quality of the resultant silages was examined. There were significant interactions between treatments and herbages for all silage quality parameters measured, except for acetic acid concentration. The influence of additives on the final pH of all silages was small but statistically significant. Lactic acid concentration was not directly related to herbage mixture, overall mean values ranging from 118 to 120 ± 1.5 g kg^?1 dry matter (DM), but wider variation was seen between treatments for individual herbage mixtures. Acetic acid concentrations were significantly (P<0·001) affected by herbage mixture ensiled, increasing linearly as clover content increased from zero to 60%. Untreated control and formic acid-treated silages contained significantly (p<0·001) higher acetic acid concentrations than those treated with other additives. Silage ammonia N concentrations were significantly (p<0 001) influenced by herbage mixture. Lowest ammonia N concentrations (< 50 g kg^?1 DM) were observed in silages that had been treated with formic acid, freshly cultured Lb. plantarum or Lb. plantarum plus Lc. lactis. The fraction 1 leaf protein (FILP) contents of silages were significantly (P <0·001) affected by both treatment and herbage mixture, with consistently and significantly higher values found in freshly cultured inoculant-treated silages. A poor correlation (r²= 0·12) existed between ammonia N and FILP in all silages. The inclusion of up to 60% white clover in the ensiled herbage did not adversely affect final silage quality. However, additive treatment markedly influenced the residual FILP content of silages, those treated with freshly cultured inoculants having the highest values.     

Influence of maceration at cutting on lactic acid bacteria populations, silage fermentation and voluntary intake and digestibility of precision-chopped lucerne silage

Laboratory experiments with lucerne (Medicago sativa) have shown that maceration at cutting improves silage fermentation. Samples taken during wilting and after various ensiling periods were analysed for lactic acid bacteria (LAB) numbers and indices of silage fermentation. In Experiment 1, in which maceration was tested in unwilted and wilted lucerne, there was an additive effect of maceration and wilting on LAB numbers at ensiling, thus LAB numbers were approximately 108 colony-forming units (cfu) g^?1 fresh crop for wilted, macerated forage compared with 103 cfu g^?1 fresh crop for unwilted, unmacerated forage at ensiling. Initially, maceration reduced pH (P < 0·001) and increased lactic acid (unwilted comparison only; P < 0·001) and insoluble N (wilted comparison only; P < 0·001) concentrations. After 70 d ensiling, beneficial effects of maceration were associated only with the wilted silage. In Experiment 2, macerated lucerne was compared with unmacerated material, which was either ensiled after a wilting period of similar length or after wilting had proceeded to the same DM concentration as in the macerated forage. During wilting, LAB numbers were significantly higher in macerated than unmacerated forage (P < 0·05). This was also the case during the first 16 h of ensiling (P < 0·01). A decline in pH was observed earlier in macerated silage. Two days after ensiling, lactic acid concentration was higher in macerated silage (P < 0·05), but insoluble N concentration was not different. In a third experiment, unconditioned forage was compared with forages ensiled after regular conditioning or maceration. Although drying rate over 30 h was not influenced by degree of conditioning, LAB numbers during wilting increased with the degree of conditioning. In silages made from these treatments after 6 h wilting, there were no major effects on fermentation characteristics. In a fourth experiment, digestibility and voluntary intake of precision-chopped silage were measured in sheep and found not to be increased by maceration. It was concluded that maceration per se resulted in marginal improvements in fermentation; however, when maceration also increased DM concentration, fermentation was markedly improved. In these precision-chopped silages, maceration had no effect on intake or digestibility.     

The effects of treating low dry-matter, low digestibility grass with a bacterial inoculant on the intake and performance of beef cattle, and studies on its mode of action

This experiment evaluated a bacterial inoculant based on a single strain of Lactobacillus plantarum as a silage additive. Three silages were harvested on 8 September 1989 from the second regrowth of a perennial ryegrass sward, which had received 167 kg N, 28 kg P₂O₅ and 45 kg K₂O ha^?1. Mean dry matter (DM) and water soluble carbohydrate concentrations of the herbages at ensiling were 148 g kg^?1 and 78 g.(kg DM)^?1 respectively. Herbages were treated with either no additive (C), formic acid (3·0 1 t^?1) (F) or the inoculant (3·0 1 t^?1) (I) and were ensiled in three 80-t capacity silos. For silages C, F and I respectively, pH values were 4·70, 3·77 and 4·47, ammonia-N concentrations were 192, 111 and 182 g (kg total N)^?1 and butyrate concentrations were 6·8, 1·8 and 7·1 g (kg DM)^?1. The silages were offered ad libitum and supplemented with 2·0 kg concentrates per head daily to thirty-six heifers (mean initial live weight 442 kg). For silages C, F and I, silage DM intakes were 12·7, 14·4 and 14·1 (s.e. 0·42) g (kg live weight)^?1, metabolizable energy intakes were 155, 166 and 172 (s.e. 5·1) kJ (kg live weight)^?1, and estimated carcass gains were 456, 519 and 518 (s.e. 28·1) g d^?1 respectively. A further 18 similar cattle were used in studies on the digestibility of the silages, and rumen degradation of each was estimated with three mature cattle. Inoculant treatment significantly increased crude fibre (P <0·01), neutral detergent fibre (P <0·01), modified acid detergent fibre (P <0·01), hemicellulose (P <0·05) and N digestibilities (P <0·05) and tended to increase N retention from the total diet. It is concluded that although treatment of herbage that was difficult to ensile with the inoculant did not improve silage fermentation, it significantly increased digestibility, especially of the fibre fractions, and silage DM intake and tended to increase animal performance to levels similar to those achieved with a well preserved formic acid-treated silage. Increases in silage DM and metabolizable energy intakes are likely to have been attributable to the effects of the inoculant on digestibility, especially of the fibre fractions.     

Effect of forage matting on rate of grass drying, rate of silage fermentation, silage intake and digestibility of silage by sheep

The effects of forage matting on rate of grass drying and silage fermentation, digestibility, and intake were examined using perennial ryegrass swards. Treatments compared were: forage mats, where grass was processed through a laboratory scale macerator prior to matting and wilting to 228 g dry matter (DM) kg^?1 (FM treatment); unconditioned grass which was direct ensiled at 163 g DM kg^?1 (DE treatment); unconditioned grass which was wilted for the same period as FM to 213 g DM kg^?1 (UC treatment); unconditioned grass which was wilted to 234 g DM kg^?1 (UC₂₅, treatment). All forages were dried on black plastic sheeting. For each treatment a total of approximately 80 kg grass DM was ensiled in seven 290 I plastic bins for 136 d prior to feeding to wether sheep. A further total of 14 kg grass DM from each treatment was ensiled in twenty-one plastic pipes (152 mm diameter, 762 mm long) to give a total of 84 pipes. Rate of silage fermentation was determined by destructively sampling pipes following 1, 2, 4, 6, 13, 20 and 50 d of ensilage. Over the mean wilting period of 6·9 h, grass from the FM treatment dried significantly faster (P < 0·001) and required less solar energy per unit of moisture loss than unconditioned grass. The rate of grass drying was highly correlated with solar radiation. The FM treatment did not influence the rate or extent of silage fermentation. The intakes and digestibilities of FM, UC and UC₂₅ were not significantly (P < 0·05) different from each other but were higher than for the DE treatment (P < 0·05 for digestibility and NS for intake). In Northern Ireland it is unlikely that there will be sufficient solar radiation to allow forage mats to be made, wilted to a level to prevent effluent production and harvested within one working day. Further work is required to optimize mat-making technology for more rapid drying and to determine the effect of adverse weather on nutrient losses from mats.