Levels of benzo[a]pyrene (BaP) in "mozzarella di bufala campana" cheese smoked according to different procedures

The content of benzo[a]pyrene (BaP), a polycyclic aromatic hydrocarbon, was determined by HPLC-FL in "mozzarella di bufala campana" cheese, a stretched cooked cheese, either experimentally smoked according to traditional procedures, using straw, cardboard, and wood shavings or aromatized with smoke flavoring. The BaP residues, researched also in cheese samples sold at retail, were detected in the rind, in the core, and in the slice (outer and inner parts). In the cheeses experimentally smoked with straw and cardboard the BaP levels, ranging from 0.38 to 2.12 microg kg(-1) and from 0.46 to 2.40 microg kg(-1), respectively, were statistically higher than those of the cheeses smoked with wood shavings and aromatized with liquid smoke (from 0.19 to 0.80 microg kg(-1) and from 0.18 to 0.50 microg kg(-1), respectively). However the cheeses treated with liquid smoke flavor showed a BaP content exceeding the level allowed by the European Union. In the samples sold at retail, smoked with straw, values were lower than those obtained from samples smoked experimentally with the same combustible. This is probably due to different smoking technologies among the several provinces of the Protected Designation of Origin (PDO) area. PDO is a term used to characterize foodstuffs produced and prepared in a given geographical region by the means of a recognized process. A standardization of the traditional smoking procedures and an improvement of liquid smoke purification treatments are recommended for mozzarella cheese.     

Key odorants of Oscypek, a traditional Polish ewe's milk cheese

The unique flavor of Oscypek, a Polish ewe's milk smoked cheese, is described as slightly sour, piquant, salted, and smoked. In this paper with the application of gas chromatography-olfactometry (GC-O) and combination of aroma extract dilution analysis (AEDA) 20 potent odorants of this cheese have been identified within the flavor dilution factor (FD) range of 4-2048. Among them, 2-methoxyphenol, 2-methoxy-4-methylphenol, 4-methylphenol, and butanoic acid showed the highest FD factors. Quantification results based on labeled standard addition followed by calculation of odor activity values (OAV) of 13 compounds with the highest FD factors revealed that 11 compounds were present at concentrations above their odor threshold values and therefore mostly contribute to the overall aroma of smoked ewe's milk cheese. Six of those compounds were represented by phenolic derivatives, with the highest OAV for 2-methoxyphenol (1280). Analysis of key odorants of an unsmoked cheese sample showed that the smoking process had a fundamental influence on Oscypek aroma formation.     

Assessment of polycyclic aromatic hydrocarbon content of smoked fish by means of a fast HPLC/HPLC method

Polycyclic aromatic hydrocarbon (PAH) concentrations in smoked food can reach levels hazardous for the human health, especially when the smoking procedure is carried out under uncontrolled conditions. In this work a simple and rapid method for the determination of PAHs in smoked fish samples is described. PAHs were extracted from the insoluble samples (together with fat substances) by homogenization with acidified chloroform. The fat extract was then submitted to a first LC sample preparation step (performed on a large silica column) to isolate PAHs from triglycerides. After reconcentration, the PAH fraction was finally injected into the reverse-phase analytical column. The proposed method, which presents good characteristics of recoveries and repeatability, was also used to analyze PAH content of some smoked trout samples packed under vacuum.     

前置固相吸附材料对烟熏鲟鱼片的影响及工艺优化

为降低烟熏即食鱼片中的苯并芘(BaP)含量,同时保留其感官特征和风味品质,开发熏烟在线筛滤技术,优化烟熏即食鱼片的加工工艺。本试验通过比较不同固相吸附材料(棉花、硅胶、分子筛、活性氧化铝)对烟熏即食鱼片品质的影响,采用高效液相色谱(HPLC)和气相色谱/质谱联用(GC/MS)对熏鱼的BaP和风味物质进行检测。比较不同固相吸附材料发现,当吸附剂为硅胶时,BaP含量下降至4.88 μg·kg^-1,产品质地、色泽、熏香等感官评分较高,酚类等友好型挥发性物质得到保留。响应面优化后的烟熏鲟鱼片最佳工艺条件为硅胶25 g,烟熏时间30 min,烟熏温度85℃。本研究结果对健康烟熏食品的开发具有重要的参考意义。     

Determination of 10 carcinogenic polycyclic aromatic hydrocarbons in mainstream cigarette smoke

Polycyclic aromatic hydrocarbons (PAHs) are one class of chemical compounds that (1) are present at low to trace levels in unburned cigarette filler, and (2) are predominantly generated during combustion. According to a recent report of the International Agency for Research on Cancer, 10 carcinogenic PAHs together with 53 other known carcinogens are present in cigarette smoke. Accurate quantification of these chemicals helps assess public health risk to both smokers and nonsmokers exposed to second-hand smoke. We have developed and validated a specific and sensitive method for measuring these 10 carcinogenic PAHs in the particulate phase of mainstream tobacco smoke. Cigarette smoke particulate, produced using standard machine smoking protocols, was collected on glass fiber Cambridge filter pads. The particulate matter was solvent extracted, purified by solid-phase extraction, and analyzed by liquid chromatography/atmospheric pressure photoionization tandem mass spectrometry using isotopically labeled analogues as internal standards. Our method's limits of detection ranged from 11 to 166 pg and achieved sufficient reproducibility and accuracy to provide useful information on a range of cigarettes having dramatically different machine-smoked tar and nicotine deliveries. The identity of each PAH analyte was established from chromatographic retention time, analyte-specific fragmentation patterns, and relative peak area ratios of the product/precursor ion pairs. This new method provides higher sensitivity, specificity, and throughput than did earlier methods. We found relatively consistent PAH levels among a selection of domestic full-flavor cigarettes. The PAH levels in smoke from highly ventilated light and ultralight cigarettes were low when smoked using ISO (International Organization for Standardization) conditions. However, if highly ventilated cigarettes were smoked under more intense conditions (e.g., larger or more frequent puffs, vents blocked), their PAH levels equaled or exceeded their full-flavor counterparts under ISO conditions.     

Polycyclic aromatic hydrocarbons in liquid smoke flavorings obtained from different types of wood. Effect of storage in polyethylene flasks on their concentrations

Smoke flavorings are widely used as an alternative to the traditional smoking techniques. Smoke generation conditions can determine the level of polycyclic aromatic hydrocarbons (PAHs) in the smoke and, consequently, in these preparations. In this paper, the influence of the wood source on the formation of PAHs is studied. For this purpose, five liquid smoke flavorings, obtained from different types of wood, were used. Sample aliquots, including deuterated internal standards, were subjected to an alkaline treatment, extracted by liquid-liquid partition and cleaned up by means of silica tubes, followed by gas chromatography-mass spectrometry analysis. The results reveal that the flavoring obtained from poplar wood presents the highest number and concentrations of both total and carcinogenic PAHs, even though the levels of these latter are very low. It has also been observed that the storage of smoke flavorings in polyethylene flasks reduces the concentration of some PAHs.     

Effect of ultrasound emulsification on cheese aroma encapsulation by carbohydrates

The encapsulation of liquid cheese aroma (20%) in different carbohydrate matrices by spray-drying was investigated. Carbohydrate stabilized emulsions have been prepared by two emulsifying methods, ultrasonic or Ultra-Turrax treatments, and have been compared in terms of emulsion stability and encapsulation efficiency. The use of ultrasound is particularly effective to obtain a stable emulsion with maltodextrin as support, which is known for poor emulsification properties. In the same way, the spray-dried maltodextrin microcapsules were more effective for retaining cheese aroma when ultrasound (12.7 g/100 g of dry powder) was used for the emulsification step rather than Ultra-Turrax (10.7 g/100 g of dry powder). In terms of encapsulation efficiency, the best system of cheese aroma encapsulation is obtained using ultrasound for the emulsification step and modified starch as support (94.3%). With this support, the positive effect of ultrasound resulted in a lower microcaspsule size and in a higher aroma retention than when Ultra-Turrax was used (83.3%). Studies on the aroma profiles showed changes after encapsulation that depend not only on the nature of the support and the emulsification method but also on the interactions between the aroma compound and the matrix. In terms of flavor quality, the best system of cheese aroma encapsulation is obtained using ultrasound and maltodextrin as support.     

The addition of Propionibacterium freudenreichii to Raclette cheese induces biochemical changes and enhances flavor development

Two mixtures of Propionibacterium freudenreichii commercial strains were tested as adjunct cultures in pasteurized milk Raclette cheese to investigate the ability of propionibacteria (PAB) to enhance flavor development. Cheese flavor was assessed by a trained sensory panel, and levels of free amino acids, free fatty acids, and volatile compounds were determined. The PAB level showed a 1.4 log increase within the ripening period (12 weeks at 11 degrees C). Eye formation, which was not desired, was not observed in PAB cheeses. PAB fermented lactate to acetate and propionate and produced fatty acids by lipolysis, branched chain volatile compounds derived from isoleucine and leucine catabolism and some esters. One of the experimental cheeses received the highest scores for odor and flavor intensity and was characterized by higher frequencies of detection for some minor notes ("propionic"and "whey" odor, "sweet" taste). PAB can therefore be considered as potential adjunct cultures to enhance or modify cheese flavor development.     

SFE-plus-C(18) lipid cleanup and selective extraction method for GC/MS quantitation of polycyclic aromatic hydrocarbons in smoked meat

In biological matrixes lipid material often poses an interference problem for determinations of nonpolar compounds, e.g., polycyclic aromatic hydrocarbons (PAHs). A newly developed supercritical fluid extraction plus adsorbent method, "SFE-plus-C(18)", offers selective extraction of PAHs in lipid-rich biological matrixes without the need for supplementary cleanup. This method eliminates the use of large volumes of toxic solvent and lengthy lipid removal procedures. This study reports the first application of the SFE-plus-C(18) method to the analysis of a genuine food product, i.e., smoked meat (beef). The procedure employs the addition of C(18) adsorbent beads to the initial sample slurry of pureed smoked meat prior to supercritical CO(2) extraction and GC/MS quantitation. During SF extraction, indigenous lipids are preferentially retained on the beads, and PAHs are selectively extracted with supercritical CO(2). In a comparison of determinations of PAHs by SFE-plus-C(18) vs the conventional SFE method, only 11-17% of the indigenous lipids observed by the conventional SFE method were co-extracted using the SFE-plus-C(18) method. The PAHs in smoked meat could thus be determined efficiently in the presence of a reduced background of co-extracted lipids. Out of 10 targeted PAHs, seven were detected with a range of 10.0-26.0 ng/g in the smoked meat sample. The other three PAHs were not present above the detection limit of the instrument (2.5-4.1 pg). The recoveries of PAHs obtained using the conventional SFE method were 63-94% lower than those achieved by SFE-plus-C(18).     

Identification of allyl esters in garlic cheese

This study describes the identification of six allyl esters in a garlic cheese preparation and in a commercial cream cheese. The extracts were prepared by liquid/liquid extraction and concentrated by the SAFE process. The identification of the allyl esters of acetic, butyric, hexanoic, heptanoic, octanoic, and decanoic acids is based on the correlation of their mass spectrometric data and chromatographic retention time data obtained from the extracts with those of authentic standards. In addition to the gas chromatography (GC)/mass spectrometry analysis, the flavor ingredients were characterized by GC sniffing by a trained flavorist. Some of the esters were isolated by preparative GC.     

产脂肪酶乳酸菌对新疆传统奶酪脂肪酸及风味的影响

为了改善奶酪品质,奶酪生产过程中通常会添加脂肪酶或者产脂肪酶乳酸菌来提升产品品质。该研究以前期筛选的4株高产脂肪酶乳酸菌为发酵剂,分别随机选取3株乳酸菌复配制作酸凝奶酪。试验组：A组T1-5和T1-3属融合魏斯氏菌（Weissella confusa）、H1-6属瑞士乳杆菌（Lactobacillus helveticus）,B组H1-6、T1-5、B2-5属植物乳杆菌（Lactobacillus plantarum）,C组H1-6、T1-3、B2-5,D组T1-3、T1-5、B2-5,对照组（E组）（添加商业发酵剂）,分析发酵剂对传统奶酪pH值、滴定酸度和脂肪氧化情况的影响,并利用气相色谱法（Gas Chromatography,GC）检测奶酪中脂肪酸变化、利用气相色谱-离子迁移谱（Gas Chromatography-Ion Mobility Chromatography,GC-IMS）分析奶酪中风味物质的变化。结果表明：A,B,C,D组4组奶酪的pH值、过氧化值（Peroxide value,POV值）明显低于E组（对照组）（P < 0.05）,A,B组奶酪滴定酸度比对照E组高（P < 0.05）;A,B,C,D组奶酪中饱和脂肪酸（Saturated Fatty Acids,SFA）含量、单不饱和脂肪酸（Monounsaturated Fatty Acids,MUFA）含量和多不饱和脂肪酸（Polyunsaturated Fatty Acids,PUFA）含量均显著高于E组（P < 0.05）;4个试验组样品中亚油酸（C18∶2n6c）含量明显高于对照组（E组）（P < 0.05）。GC-IMS及主成分分析结果显示,A、B组奶酪挥发性风味物质种类多,且相似度较高,其中2-庚酮、丁醛、乙酸丁酯是主要呈味物质;C、E两组奶酪中风味物质比较相似,风味物质主要以乙酸乙酯、乙酸丙酯、己酸乙酯等酯类为主;D组与其他4组有所差异,主要挥发性风味物质为乙酸丁酯、3-辛酮、庚醛等。结合感官评定,A、B两组奶酪整体风味和口感较好,评分较高。筛选得到的产脂肪酶乳酸菌可以作为发酵剂用于提升新疆传统奶酪品质。     

Olfactometric determination of the most potent odor-active compounds in salmon muscle (Salmo salar) smoked by using four smoke generation techniques

The volatile compounds of salmon fillets smoked according to four smoked generation techniques (smoldering, thermostated plates, friction, and liquid smoke) were investigated. The main odor-active compounds were identified by gas chromatography coupled with olfactometry and mass spectrometry. Only the odorant volatile compounds detected by at least six judges (out of eight) were identified as potent odorants. Phenolic compounds and guaiacol derivatives were the most detected compounds in the olfactometric profile whatever the smoking process and could constitute the smoky odorant skeleton of these products. They were recovered in the aromatic extracts of salmon smoked by smoldering and by friction, which were characterized by 18 and 25 odor-active compounds, respectively. Furannic compounds were more detected in products smoked with thermostated plates characterized by 26 odorants compounds. Finally, the 27 odorants of products treated with liquid smoke were significantly different from the three others techniques applying wood pyrolysis because pyridine derivatives and lipid oxidation products were perceived in the aroma profile.     

Physical and sensory properties of dairy products from cows with various milk fatty acid compositions

Dairy products from milk of cows fed diets rich in polyunsaturated fatty acids have a more health-promoting fatty acid composition and are softer but often have oxidized flavors. Dairy products made from cow's milk that has more- or less-unsaturated fatty acid compositions were tested for differences in texture and flavor from those made from bulk-tank milk. The milk was manufactured into butter, vanilla ice cream, yogurt, Provolone cheese, and Cheddar cheese. The products were analyzed for fatty acid composition, physical properties, and flavor. Milk of cows with a more monounsaturated fatty acid composition yielded products with a more monounsaturated fatty acid composition that were softer and had a satisfactory flavor. Thus, selection of cows for milk fatty acid composition can be used to produce dairy products that are probably more healthful and have a softer texture.     

Proteolysis in Hispánico cheese manufactured using a mesophilic starter,a thermophilic starter,and bacteriocin-producing Lactococcus lactis subsp. lactis INIA 415 adjunct culture

Lactococcus lactis subsp. lactis INIA 415, a strain harboring the structural genes of bacteriocins nisin Z and lacticin 481, was used as adjunct culture in the manufacture of Hispánico cheese with a mesophilic starter and a thermophilic starter of high aminopeptidase activity. Addition of the bacteriocin producer promoted early lysis of mesophilic and thermophilic starter bacteria. Extracellular aminopeptidase activity in 7-day-old cheese made using mesophilic and thermophilic starters plus bacteriocin producer was 3.0-fold the level reached in cheese made without the bacteriocin producer. Proteolysis in cheese made with mesophilic and thermophilic starters plus bacteriocin-producing adjunct culture after 25 days of ripening was 1.5-fold the level reached in cheese made without the bacteriocin producer, and the level of total free amino acids was 2.9-fold the level found in cheese made without the bacteriocin producer. Cheese made with mesophilic and thermophilic starters plus bacteriocin producer received the highest scores for flavor quality and flavor intensity and reached in 25 days the flavor intensity score of a 75-day-old cheese made without the bacteriocin producer.     

Removal of cholesterol from Cheddar cheese by beta-cyclodextrin

This study was carried out to determine the cholesterol removal rate and resulting changes in flavor, fatty acid and bitter amino acid production in reduced-cholesterol Cheddar cheese, made by cream separation followed by 10% beta-cyclodextrin (beta-CD) treatment. The cholesterol removal from the cheese was 92.1%. The production of short-chain free fatty acids (FFAs) increased the ripening time in control and cream-treated cheeses. The quantity of short-chain FFAs released between treatments during ripening was different, while not much difference was found in the production of neutral volatile compounds in the samples. Reduced-cholesterol cheese produced much higher levels of bitter amino acids than the control. In sensory analysis, the texture score of control Cheddar cheese increased significantly with ripening time; however, that of the cream treatment group decreased dramatically with ripening time. On the basis of our results, we conclude that the cheese made from beta-CD-treated cream had a higher rate of cholesterol removal and ripened rapidly.     

Characteristic aroma components of British Farmhouse Cheddar cheese

Aroma components responsible for aroma typical of British Farmhouse Cheddar cheese were studied by aroma extract dilution analysis. Cheese extracts were prepared by direct solvent extraction, high-vacuum transfer, and class fractionation. Most aroma-active components of acidic and neutral/basic fractions have been previously associated with Cheddar cheese flavor. p-Cresol was mainly responsible for a "cowy-barny" note, whereas an intense "soil-like" note was due to 2-isopropyl-3-methoxypyrazine. At much lower odor intensity, 2-isobutyl-3-methoxypyrazine contributed a "bell pepper-like" note. Additionally, within the same wedge of cheese, the concentrations of p-cresol and 2-isopropyl-3-methoxypyrazine were lower at the narrow end (center) than at the rind side. Direct addition of p-cresol (> or =100 ppb) or 2-isopropyl-3-methoxypyrazine (> or =3 ppb) in a mild domestic Cheddar cheese resulted in increases in intensities of cowy/phenolic and earthy/bell pepper aroma notes.     

Flavor enhancement of reduced fat cheddar cheese using an integrated culturing system

Mild cheese flavor in reduced fat Cheddar cheese was enhanced by using an integrated starter culture system. Three cultures, Lactococcus lactis subsp. cremoris SK11, L. lactis subsp. lactis biovar. diacetylactis JVI, and Lactobacillus casei 7A, were carefully selected to obtain a nonbitter, mildly acid, buttery flavored cheese. Cheeses were produced from all possible combinations of these cultures with the constraint that L. lactis subsp. cremoris SK11 was used as the primary acid-producing culture. Cheeses made with SK11 were compared to cheeses produced using an L. lactis subsp. cremoris commercial starter culture. Cheeses were ripened for 150 days and periodically sampled for chemical, microbiological, and sensory analysis. Cheeses produced with L. lactis subsp. cremorisSK11 had substantially lower bitterness intensity than the cheeses produced with commercial starter culture. L. lactis subsp. lactis biovar. diacetylactis JVI significantly increased diacetylacetoin and acetate concentrations. Sensory results indicate that these cheeses had increased buttery (diacetyl) flavor.     

Accelerated solvent extraction and gas chromatography/mass spectrometry for determination of polycyclic aromatic hydrocarbons in smoked food samples.

Accelerated solvent extraction (ASE) is a new sample extraction method offering a number of advantages such as low pe -extraction cost, reduced solvent and time consumption, and simplified extraction protocols. In this study, the ASE method was applied to the extraction of polycyclic aromatic hydrocarbons (PAHs) from biological samples. For recovery studies, fish tissues and ground pork were used as sample matrices. Sample aliquots fortified with 16 PAHs were extracted by ASE, and the extracts were treated with sulfuric acid and Florisil, followed by gas chromatography-mass spectrometry analysis. The PAH recoveries by the ASE method were found to be comparable with or better than those by Soxhlet extraction. The extraction and quantitation method was then applied to the determination of PAHs in several smoked meat samples obtained from a local market. Up to 12 PAHs were found to be present at concentrations ranging from 3 to 52 ng/g wet sample.     

Time course and specificity of lipolysis in Swiss cheese

Controlling lipolysis in cheese is necessary to ensure the formation of desirable flavor. To get a better understanding of the mechanism of lipolysis in Swiss cheese, cheeses were manufactured with and without (control) the addition of Propionibacterium freudenreichii. Products of lipolysis were quantified throughout ripening. Half of the free fatty acids (FFA) released in milk (3.66 mg/g fat), in particular the short-chain FFA, were lost in the whey during curd drainage, whereas diglycerides and monoglycerides were retained within the curd. P. freudenreichii was responsible for the release of most FFA during ripening (10.84 and 0.39 mg/g fat in propionibacteria-containing and control cheeses, respectively). Indices of lipolysis displayed low specificity. All types of FFA were released, but butyric and palmitic acids more significantly, which could be due to a low sn-1,3 regioselectivity. All glycerides were hydrolyzed in the following order: monoglycerides>diglycerides>triglycerides. The results of this study show the quantitative and qualitative contributions of the different lipolytic agents to Swiss cheese lipolysis.     

Determination of parent and substituted polycyclic aromatic hydrocarbons in high-fat salmon using a modified QuEChERS extraction, dispersive SPE and GC-MS

A fast and easy modified QuEChERS (quick, easy, cheap, rugged and safe) extraction method has been developed and validated for determination of 33 parent and substituted polycyclic aromatic hydrocarbons (PAHs) in high-fat smoked salmon that greatly enhances analyte recovery compared to traditional QuEChERS procedures. Sample processing includes extraction of PAHs into a solution of ethyl acetate, acetone and isooctane followed by cleanup with dispersive SPE and analysis by GC-MS in SIM mode. Method performance was assessed in spike recovery experiments (500 μg/g wet weight) in three commercially available smoked salmon with 3-11% fat. Recoveries of some 2-, 3- and 5-ring PAHs were improved 50-200% over traditional methods, while average recovery across all PAHs was improved 67%. Method precision was good with replicate extractions typically yielding relative standard deviations <10%, and detection limits were in the low ng/g range. With this method, a single analyst could extract and clean up ≥60 samples for PAH analysis in an 8 h work day.